2005 Chrysler PT Cruiser Owner Manual Convertible
2005 Chrysler PT Cruiser Manual
2005 Chrysler PT Cruiser manual content summary:
- 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 1
SECTION 1 2 3 4 5 6 7 8 9 10 TABLE OF CONTENTS PAGE INTRODUCTION ...3 THINGS TO KNOW BEFORE STARTING YOUR VEHICLE ...9 UNDERSTANDING THE FEATURES OF YOUR VEHICLE ...59 UNDERSTANDING YOUR INSTRUMENT PANEL ...119 STARTING AND OPERATING ...179 WHAT TO DO IN EMERGENCIES ...231 MAINTAINING YOUR - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 2
- 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 3
INTRODUCTION CONTENTS Ⅵ Introduction ...4 Ⅵ How To Use This Manual ...4 Ⅵ Warnings And Cautions ...6 Ⅵ Vehicle Identification Number ...6 Ⅵ Vehicle Modifications / Alterations ...7 1 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 4
these publications carefully. Following the instructions and recommendations in this manual will help assure safe and service, remember that your dealer knows your vehicle best, has the factory-trained technicians and genuine Mopar parts, and is interested in your satisfaction. WARNING! Engine - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 5
INTRODUCTION 5 1 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 6
injury. It also contains CAUTIONS against procedures which could result in damage to your vehicle. If you do not read this entire manual you may miss important information. Observe all Warnings and Cautions. VEHICLE IDENTIFICATION NUMBER Vehicle Identification Number (VIN) is found on the driver - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 7
INTRODUCTION 7 VEHICLE MODIFICATIONS / ALTERATIONS 1 WARNING! Any modifications or alterations to this vehicle could seriously affect its roadworthiness and safety and may lead to an accident resulting in serious injury or death. - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 8
- 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 9
14 Ⅵ Sentry Key ...14 ▫ Replacement Keys ...16 ▫ Sentry Key Programming ...16 ▫ General Information ...17 Ⅵ Steering Wheel Lock - If Equipped ...17 ▫ If You Wish To Manually Lock The Steering Wheel ...17 ▫ To Release The Steering Wheel Lock ...17 ▫ Automatic Transaxle Ignition Interlock System . .18 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 10
Panic Alarm ...22 ▫ To Program Transmitters ...23 ▫ General Information ...23 ▫ Transmitter Battery Service ...24 Ⅵ Security Alarm System ...25 ▫ To Set The Alarm ...25 ▫ To Disarm The System ...26 ▫ Security System Manual Override ...26 Ⅵ Deck Lid ...26 ▫ Power Deck Lid Release ...27 Ⅵ Emergency - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 11
THINGS TO KNOW BEFORE STARTING YOUR VEHICLE 11 Ⅵ Engine Break-In Recommendations ...56 Ⅵ Safety Tips ...57 ▫ Exhaust Gas ...57 ▫ Safety Checks You Should Make Inside The Vehicle ...57 ▫ Periodic Safety Checks You Should Make Outside The Vehicle ...58 2 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 12
YOUR KEYS The dealer that sold you your new vehicle has the key code numbers for your vehicle locks. These numbers can be used to order keys may be inserted into the locks with either side up. Ignition Key Removal Automatic Transaxle Place the shift lever in PARK and make sure that the shift knob - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 13
cylinder to warn you that this safety feature is inoperable. The engine can be started and stopped but the key cannot be removed until you obtain service. Manual Transaxle Depress and hold the release button located between the ignition switch and the instrument panel. Turn the ignition switch - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 14
be warned not to touch the parking brake, brake pedal or the gear selector lever. Don the key forward. See Section 7 of this manual for door lock lubrication. Key-In-Ignition , sounds a signal to remind you to remove the key. NOTE: With the driver's the engine. The system will shut the engine off - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 15
automatic regardless of whether or not the vehicle is locked or unlocked. During normal operation, the Theft Alarm/ Immobilizer Light will come on for three (3) seconds immediately after the ignition switch is turned on for a bulb check. Afterwards, if the bulb remains on, this indicates a problem - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 16
for dealer replacement of keys. Sentry Key Immobilizer System serviced, bring all vehicle lock cylinder key code. 2. Insert the remove the first key. 3. Insert the second valid key and turn the ignition switch ON within 15 seconds. After ten seconds a chime will sound and the Theft Alarm Light - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 17
a single chime will sound. The Theft Alarm Light will stop flashing, turn on for part 15 and with RSS-210 of Industry Canada. Operation is subject to the following conditions Manually Lock The Steering Wheel: With the engine running, turn the steering wheel upside down, turn off the engine and remove - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 18
the wheel to the left to engage the lock, turn the wheel slightly to the left to disengage it. Automatic Transaxle Ignition Interlock System This system prevents the key from being removed unless the shift lever is in PARK and the shift knob push-button is out. It also prevents shifting out - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 19
STARTING YOUR VEHICLE 19 WARNING! When leaving the vehicle always remove the key from the ignition lock, and lock your vehicle. CAUTION! An unlocked vehicle is an invitation to thieves. Always remove the key from the ignition and lock all of the doors when leaving the vehicle unattended. Power - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 20
off and unlock all the doors with one turn of the key by following these instructions. NOTE: Steps 2 and 3 must be completed within 10 seconds. 1. Close back on by repeating the above mentioned procedure. Automatic Door Locks The doors will lock automatically if: 1. all doors are closed, 2. vehicle - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 21
button on the key fob once to unlock the driver's door, or twice within five seconds to unlock all doors, the park lights will also flash twice. The interior lights also come on and remain on for about 30 seconds when you unlock the doors. NOTE: You may turn off this feature - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 22
22 THINGS TO KNOW BEFORE STARTING YOUR VEHICLE To Lock The Doors: Press and release the LOCK button to lock all doors. The park lights will flash and the horn will chirp to acknowledge the signal. Horn Chirp Feature The horn chirp that signals that the doors have been locked - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 23
device complies with FCC rules part 15 and with RSS-210 of Industry Canada. Operation is subject to the following conditions: • This device may to operate from a normal distance, check for these two conditions. 1. Weak batteries in transmitter. The expected life of batteries is from one to two years - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 24
Transmitter Battery Service The recommended replacement battery is 2016 or its equivalent. NOTE: Do not touch the battery terminals removal. 2. Remove and replace the batteries. Avoid touching the new batteries with your fingers. Skin oils may cause battery deterioration. If you touch a battery - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 25
on for 3 minutes the alarm will shut off immediately. To set the alarm: 1. Remove the keys from the ignition switch and get out of the vehicle. 2. Lock the manner, the system will automatically disarm. After 16 seconds the indicator light will flash slowly. This shows that the system is fully armed. - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 26
front door using either a key or the Keyless Entry Transmitter, the alarm has been activated. Check the vehicle for tampering. Security System Manual Override The system will not arm if you lock the doors using the manual door lock plunger. DECK LID NOTE: The key that is used to start the vehicle is - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 27
entry or by using the power deck lid release switch, located in the glove box. Gas props support the deck lid in the open position. However, because disabled when the vehicle speed exceeds 5 mph (8 km/h), or when the vehicle theft alarm is in the armed or alarming state. 2 WARNING! • Driving with - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 28
pulling on the glow-inthe-dark lever attached to the deck lid latching mechanism. See following picture. POWER WINDOWS The power window switches are located on the instrument panel above the A/C controls. The top left switch controls the left front window and the top right switch controls the right - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 29
Press the window switch past the detent, release, and the window will go down automatically. Press the switch a second time in either direction to stop the window. To open the window part way, press the window switch part way and release it when you want the window to stop. 2 Power Window Switches - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 30
30 THINGS TO KNOW BEFORE STARTING YOUR VEHICLE Wind Buffeting Wind buffeting can be described as the perception of pressure on the ears or a helicopter type sound in the ears. Your vehicle may exhibit wind buffeting with the windows down. This is a normal occurrence and can be minimized. If - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 31
belt webbing is twisted, and comes in contact with the wearers body, the twisted belt should be corrected using the Lap/Shoulder Belt Untwisting stops or collisions. This feature allows the shoulder part of the belt to move freely with you under normal conditions. But in a collision, the belt will - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 32
are the strongest parts of your body and can take the forces of a collision the best. • Wearing your belt in the wrong place could make your injuries in a collision much worse. You might suffer internal injuries, or you could even slide out of part of the belt. Follow these instructions to wear your - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 33
THINGS TO KNOW BEFORE STARTING YOUR VEHICLE 33 Lap/Shoulder Belt Operating Instructions 1. Enter the vehicle and close the door. Sit back and adjust the seat. 2. The seat belt latch plate is above the back of the front - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 34
too far forward, increasing the possibility of injury. Wear your seat belt snugly. • A belt that is worn under your arm is very dangerous. Your body could strike the inside surfaces of the vehicle in a collision, increasing head and neck injury. A belt worn under the arm can cause internal injuries - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 35
BEFORE STARTING YOUR VEHICLE 35 4. Position the lap belt across your thighs, below your abdomen. To remove slack in the lap belt portion, pull up on the shoulder belt. To loosen the lap belt not resting on your neck. The retractor will withdraw any slack in the belt. 2 Removing Slack From Belt - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 36
can be removed from the guide to allow for easier access to the rear seats. WARNING! A frayed or torn belt could rip apart in a collision and leave you with no protection. Inspect the belt system periodically, checking for cuts, frays, or loose parts. Damaged parts must be replaced immediately. Do - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 37
THINGS TO KNOW BEFORE STARTING YOUR VEHICLE 37 Lap/Shoulder Belt Untwisting Procedure Use the following procedure to untwist a twisted lap/ shoulder belt. 1. Position the latch plate as close as possible to the anchor point. 2 Seat Belt Webbing Guide Positioning Latch Plate - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 38
38 THINGS TO KNOW BEFORE STARTING YOUR VEHICLE 2. At about 6 to 12 inches (15 to 30 cm) above the latch plate, grasp and twist the belt webbing 180° to create a fold that begins immediately above the latch plate. 3. Slide the latch plate upward over the folded webbing. The folded webbing must - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 39
equipped with pretensioning devices that are designed to remove slack from the seat belt in the event the airbags and pretensioners, both must be replaced. Seat Belts And Pregnant Women We recommend the baby safe. Pregnant women should wear the lap part of the belt across the thighs and as snug - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 40
steering wheel. The passenger's front airbag is mounted in the instrument panel, above the glove compartment. The words SRS AIRBAG are embossed on the airbag covers. Front Airbag Components NOTE: The front airbags are certified to the Federal regulations that allow less forceful deployment. - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 41
located inside the driver and front passenger seats, and their covers are also labeled SRS AIRBAG. WARNING! • Do not put anything on or around the airbag covers or attempt to manually is equipped with side airbags, do not use accessory seat covers or place objects between you and the side airbags - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 42
, move the seat as far back as possible, and use the proper child restraint. Refer to the section on Child Restraint. You should read the instructions provided with your child restraint to make sure that you are using it properly. - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 43
THINGS TO KNOW BEFORE STARTING YOUR VEHICLE 43 2. All occupants should wear their lap and shoulder belts properly. 3. The driver and front passenger seats should be moved back as far as practical to allow the front airbags room to inflate. 4. If your vehicle has side airbags, do not lean against - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 44
System, on vehicles equipped, consists of the following: • AIRBAG Readiness Light (shared with the front airbag system) • Side Airbag in the driver airbags. The airbag control module also monitors the readiness of the electronic parts of the system whenever the ignition switch is in the START or ON - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 45
off. If the front or side airbag control modules detect a malfunction in any part of the system, the airbag light will turn on either momentarily or continuously. WARNING! Ignoring the AIRBAG light in your instrument panel could mean you won't have the airbags to protect you in a collision. If - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 46
to inflate. The airbag control module will not detect roll over, front or rear collisions. The Airbag Control Module monitors the readiness of the electronic parts of the system whenever the ignition switch is in the START or ON positions. These include all of the items listed under "The Side Airbag - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 47
throat irritation, move to fresh air. If the irritation continues, see your doctor. If these particles settle on your clothing, follow the garment manufacturer's instructions for cleaning. • It is . Have the airbags and seat belt pretensioners replaced by an authorized dealer as soon as possible. - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 48
bumper, vehicle body structure, or frame. • You need proper knee impact protection in a collision. Do not mount or locate any aftermarket equipment on or behind the knee bolsters. • It is dangerous to try to repair any part authorized dealer service the system immediately. • The AIRBAG light does not - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 49
is the law, and you can be prosecuted for ignoring it. Children 12 years and under should ride properly buckled up in a rear seat, if available. According to crash statistics, children are safer when properly restrained in the rear seats, rather than in the front. WARNING! In a collision, an - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 50
almost large enough for an adult safety belt. Always check the child seat owner's manual to ensure you have the correct seat for your Two types of child restraints can be used rearward-facing: infant carriers and ЉconvertibleЉ child seats. Both types of child restraints are held in the vehicle by - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 51
THINGS TO KNOW BEFORE STARTING YOUR VEHICLE 51 • The belt-positioning booster seat is for children weighing more than 40 lbs (18 kg), but who are still too small to fit the vehicle's seat belts properly. If the child cannot sit with knees bent over the vehicle's cushion while the child's back is - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 52
Check the label on the restraint for weight and height limits. • Carefully follow the instructions on the belt until it is all removed from the retractor. Allow the belt to automatic locking mode. Pull on the excess webbing to tighten the lap portion about the child restraint. Follow the instructions - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 53
not in use, secure it in the vehicle with the seat belt or remove it from the vehicle. Don't leave it loose in the vehicle. In part of the seat and body structure, and are readily visible. In addition, there are two tether strap anchorages located behind the rear seat head form, in the convertible - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 54
straps, and you are urged to take advantage of all of the available attachments provided with your child restraint in any vehicle. Installing the head form and attached to the tether anchor, located behind the rear seat head form, in the convertible top storage area. Then tighten all three straps - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 55
as possible. 2 Tether Strap Mounting Not all child restraint systems will be installed as we have described here. Again, carefully follow the instructions that come with the child restraint system. NOTE: If your child restraint seat is not LATCH compatible, install the restraint using the vehicle - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 56
VEHICLE • Check belt braking or in a collision. Pets should be restrained in the rear seat in pet harnesses or pet carriers that are secured by seat belts. ENGINE conditions under which vehicle operations will occur. The recommended viscosity and quality grades are shown in Section 7 of this manual - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 57
You Should Make Inside The Vehicle Seat Belts Inspect the belt system periodically, checking for cuts, frays and loose parts. Damaged parts must be replaced immediately. Do not disassemble or modify the system. WARNING! Exhaust gases can injure or kill. They contain carbon monoxide (CO) which - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 58
indicator lights on the instrument panel. Fluid Leaks Check area under vehicle after overnight parking for fuel, engine coolant, oil or other fluid leaks. Also, if gasoline fumes are detected or fuel, power steering fluid or brake fluid leaks are suspected, the cause should be located and corrected - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 59
...62 ▫ To Lower The Top ...62 ▫ To Raise The Top ...66 ▫ Convertible Top Boot Cover Installation-If Equipped ...68 ▫ Convertible Top Boot Cover Removal And Storage ...72 ▫ Convertible Top Manual Override ...73 Ⅵ Mirrors ...75 ▫ Inside Compass/Temperature Mirror ...75 ▫ Outside Mirror-Driver - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 60
To Open And Close The Hood ...93 Ⅵ Lights ...94 ▫ Interior Lights ...94 ▫ Multi-Function Control Lever ...95 ▫ Headlights, Parking Lights, Instrument Panel Lights ...96 ▫ Daytime Running Lights (Canada Only) ...96 ▫ Lights-On Reminder ...96 ▫ Fog Lights ...97 ▫ Turn Signals ...97 ▫ Highbeam/Lowbeam - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 61
The Universal Transceiver ...107 ▫ "Rolling Code" Programming ...109 ▫ Canadian Programming/Gate Programming . . 110 ▫ Operation ...111 ▫ Reprogramming A Single Button ...111 ▫ Security ...111 Ⅵ Electrical Power Outlets ...112 ▫ Electrical Outlet Use With Engine Off ...114 Ⅵ Console Features ...115 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 62
storage area, prior to leaving the top lowered for an extended period of time. This will help prevent possible mildew build-up. WARNING! The convertible top does not provide the structural protection that a reinforced metal roof does, and the fabric top cannot be expected to prevent the ejection of - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 63
! To fully insure that no damage occurs, be sure that the vehicle is at a complete stop with the gear selector in the Park position (automatic transaxle) or in the Neutral position (manual transaxle) before lowering or raising the top. CAUTION! To avoid damage to either the top or the rear window - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 64
position. NOTE: The Power Top Switch has two detent positions for lowering the convertible top. Pressing and holding the Power Top Switch lightly in the first detent position will lower the windows slightly and the convertible top to the full down position. Pressing and holding the switch in the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 65
UNDERSTANDING THE FEATURES OF YOUR VEHICLE 65 5. Install the Convertible Top Boot Cover, if equipped. Refer to Convertible Top Boot Cover Installation-If Equipped, in this section. CAUTION! Damage to the convertible top boot cover could result if the latch handle is not completely closed when the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 66
prevents convertible top operation at speeds over 10 mph (16 km/h). 1. Remove the convertible top boot cover, if equipped. Refer to Convertible Top Boot Cover Removal and in the Park position (automatic transaxle) or in the Neutral position (manual transaxle) before lowering or raising the top. - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 67
, ski racks, etc., should not be attached to the convertible top mechanism as they will damage the top. Do not place objects on the convertible top, in the top well or on the sport bar. Damage to the convertible top may occur. 3 Engaging Convertible Top Latches 5. Raise the latch handle into the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 68
UNDERSTANDING THE FEATURES OF YOUR VEHICLE Convertible Top Boot Cover Installation-If Equipped 1. With the top down and the convertible top latch handle in the stowed position, lay the unfolded boot cover across the convertible top. Boot Laying Across Convertible Top Convertible Top Latch Handle - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 69
UNDERSTANDING THE FEATURES OF YOUR VEHICLE 69 2. Install the rear edge of the boot, first tucking the rear edge of the boot under the rear and both sides of the rails. 3 Tucking Boot Under Rail - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 70
70 UNDERSTANDING THE FEATURES OF YOUR VEHICLE 3. Pull the right and left boot arms forward and engage both boot arm snaps. Make sure both snaps are fully engaged. 4. Engage the boot center section retainer using the tabs provided. Engaging Boot Center Section Engaging Boot Arm Snaps - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 71
UNDERSTANDING THE FEATURES OF YOUR VEHICLE 71 5. Tuck the rear flap of the boot in behind the Upper Moulding. 3 Tucking In Rear Flap - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 72
VEHICLE Convertible Top Boot Cover Removal and Storage 1. Unsnap the snaps and remove the top cover boot. 2. Lay the boot cover flat with the center section retainer facing the rear of the car. 3. First fold the left side of the boot cover to the middle of the boot cover. Folding Boot Cover Left - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 73
of the boot cover and store it in the trunk or a dry secure area. CAUTION! Do not lay heavy objects on top of the boot or lay the boot on top of sharp/pointy objects. Damage could occur to the boot. CONVERTIBLE TOP MANUAL OVERRIDE If your vehicle is experiencing electrical failure (low battery, etc - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 74
until the screw stops. This will relieve the hydraulic pressure and allow the convertible top to be raised manually. 5. Pull down and rotate the handle counterclockwise to engage the latches. Engaging Convertible Top Latches Bleeder Screw 6. Raise the handle into the stowed position. 7. Close the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 75
UNDERSTANDING THE FEATURES OF YOUR VEHICLE 75 MIRRORS Inside Compass/Temperature Mirror This manual day-night inside rearview mirror has an integrated compass and outside temperature display, along with dual map/courtesy lamps with switches for independent operation. These - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 76
the "Left" button to toggle the left reading lamp "ON/OFF". Repeat the key press to cycle the light. NOTE: The light can be activated with the ignition off. NOTE: The light(s) will automatically shut off after seven minutes with ignition off. Temperature Press and hold the "Right" button for 5-10 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 77
UNDERSTANDING THE FEATURES OF YOUR VEHICLE 77 Compass Variance • Find your current location and determine the correct Zone number from the map. • Press and hold the "Left" button for 5-10 seconds (until "Zone" appears in the display), then - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 78
no longer appears in the display. • Drive the vehicle under normal operating conditions. Outside Mirror-Driver's Side Adjust the outside mirror to center on the adjacent mirror so you can just see the side of your vehicle in the part of the mirror closest to the vehicle. WARNING! Vehicles and other - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 79
UNDERSTANDING THE FEATURES OF YOUR VEHICLE 79 Electric Remote-Control Mirrors Use the mirror select switch, located to the left of the steering column on the instrument panel, to adjust the view obtained in the outside mirrors. Press the L or R button for - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 80
vanity mirror is on the sun visor. To use the mirror, rotate the sun visor down and swing the mirror cover upward. The lights turn on automatically. Closing the mirror cover turns off the lights. SEATS Front Seat Adjustment The adjusting bar is at the front of the seats, near the floor. Pull the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 81
UNDERSTANDING THE FEATURES OF YOUR VEHICLE 81 Using body pressure, move forward and rearward on the seat to be sure the seat adjusters have latched. WARNING! • Adjusting a seat while the vehicle is moving is - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 82
82 UNDERSTANDING THE FEATURES OF YOUR VEHICLE Reclining Bucket Seats The recliner control is on the outboard side of the seat. To recline, lean forward slightly before lifting the lever, then lean back to the desired position and release the lever. Lean forward and lift the lever to return the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 83
UNDERSTANDING THE FEATURES OF YOUR VEHICLE 83 NOTE: The driver's front seat has a full recliner memory, which will allow the seat back to return to its original position. Passenger Seat Back Tilt (Easy Entry System) How to operate the passenger front seat: 1. Rotate front seat handle rearward - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 84
84 UNDERSTANDING THE FEATURES OF YOUR VEHICLE 4. To return seat to a sitting position, rotate seat back upright until it locks. 5. Push seat rearward until the track locks. NOTE: The passenger front seat has a full recliner memory, which will allow the seat back to returned to its original position - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 85
UNDERSTANDING THE FEATURES OF YOUR VEHICLE 85 Adjustable Head Restraints Head restraints can reduce the risk of whiplash injury in the event of impact from the rear. Pull up or push down on the head restraints so that the upper edge is as high as practical. To raise the head restraint, pull up on - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 86
THE FEATURES OF YOUR VEHICLE Heated Seats - If Equipped This feature heats the front driver's and passenger's seats. The control for the heater is located on the outboard side of each seat. After turning on the ignition, you may choose from HIGH, or LOW heat settings. An indicator on the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 87
OF YOUR VEHICLE 87 Folding Rear Seat To provide additional storage area, each rear seatback can be folded forward. The seat back release knobs are located in the trunk area. Pull the left side seatback release knob to fold down the left side seatback. Pull the right side seatback release knob - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 88
88 UNDERSTANDING THE FEATURES OF YOUR VEHICLE WARNING! • It is extremely dangerous to ride in a cargo area, inside or outside of a vehicle. In a collision, people riding in these areas are more likely to be seriously injured or killed. • Do not allow people to ride in any area of your vehicle that - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 89
UNDERSTANDING THE FEATURES OF YOUR VEHICLE 89 To tumble the seat forward use the following procedure: 1. The seat back release knobs are located in the trunk area. Pull the left side seatback release knob to fold down the left side seatback. Pull the right side seatback release knob - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 90
90 UNDERSTANDING THE FEATURES OF YOUR VEHICLE 2. From inside the vehicle, fold the rear seat back down flat. 3. Pull the release handle located at the bottom of the folded seat back and tumble the seat forward. Folding Rear Seat Back Tumbling Rear Seat - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 91
UNDERSTANDING THE FEATURES OF YOUR VEHICLE 91 4. Attach the cinching tether strap, located at the side of the seat cushion, onto the hook bar on the center trim panel and tighten by pulling the cinching strap until the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 92
92 UNDERSTANDING THE FEATURES OF YOUR VEHICLE NOTE: Prior to rotating the seat cushions reward, be sure that the rear seat belt buckles are secured with the straps, so that the buckles are accessible. NOTE: Prior to lifting either seatback to the upright position, be sure that the seat belt is - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 93
right, and raise the hood. Use the hood prop rod clipped to the driver's side of the engine compartment to secure the hood in the open position. Place the hood prop at the location stamped into the inner hood surface. To prevent possible damage, do not slam the hood to close it - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 94
a collision. Be sure all hood latches are fully latched before driving. LIGHTS Interior Lights The interior lights come on when a door or the deck lid is opened. With the ignition key in the OFF position, the interior lights will automatically turn off in about 8 minutes if a door is left open or - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 95
The lever is located on the left side of the steering column. 3 Parade Mode (Daytime Brightness Feature) Rotate the dimmer control to the first detent (white semi-circle). This feature brightens the odometer and radio display when the parking lights or headlights are on during daylight conditions. - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 96
whenever the ignition switch is on, the headlights are off, and the parking brake is off. The headlight switch must be used for normal night time driving. Lights-on Reminder If the headlights or parking lights are on after the ignition is turned OFF, a chime will sound to alert the driver when - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 97
the lever partially up or down without moving beyond the detent. If either light remains on and does not flash, or there is a very fast flash rate, check for a defective outside light bulb. If an indicator fails to light when the lever is moved, it would suggest that the fuse or indicator bulb - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 98
THE FEATURES OF YOUR VEHICLE WINDSHIELD WIPERS AND WASHERS The wipers and washers are operated by a switch on the control lever. The lever is located on the right side of the steering column. Move the control lever up to select the desired wiper speed. Windshield Washers To use the washer - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 99
allow the wipers to return to the park position before turning off the engine. If the wiper switch is left on and the wipers freeze to the speed operation. Intermittent Wiper System Use the intermittent wiper when weather conditions make a single wiping cycle, with a variable pause between cycles, - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 100
VEHICLE Adding Washer Fluid The fluid reservoir is located in the rear of the engine compartment on the passenger side and should be checked for fluid level at regular intervals. Fill the reservoir with windshield washer solvent (not radiator antifreeze) and operate the system for a few seconds to - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 101
UNDERSTANDING THE FEATURES OF YOUR VEHICLE 101 TILT STEERING COLUMN To tilt the column, push down on the lever below the multi-function control lever and move the steering wheel up or down, as desired. Pull the lever back up to lock the column firmly in place. WARNING! Tilting the steering column - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 102
the Traction Control System is in use. The TRAC OFF switch is located on the instrument panel below the radio. To turn the system OFF, press the TRAC OFF switch until the TRAC OFF indicator in the instrument cluster lights up. Traction Control Switch To turn the system back ON, press the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 103
Control System indicator "TRAC OFF" will illuminate momentarily as a bulb check, each time the ignition switch is turned ON. This will occur even at speeds greater than 25 mph (40 km/h). The speed control lever is located on the right side of the steering wheel. 3 Speed Control Switches To - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 104
speed control will only operate in third and fourth gear. To Deactivate: A soft tap on the brake pedal, pulling the speed control lever towards you "CANCEL", or normal brake or clutch pressure while slowing the vehicle will deactivate speed control without erasing the set speed memory. Pressing the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 105
decrease. Each time the button is tapped, speed decreases. Manual Transaxle: Depressing the clutch pedal will disengage the speed control. A slight increase in engine RPM before the speed control disengages is normal. Vehicles equipped with manual transaxles may need to be shifted into a lower gear - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 106
Vehicles equipped with four speed automatic transaxles may experience a downshift Theft Alarm is in the Disarmed mode. The HomeLink Universal Transceiver replaces up to three remote controls (hand held transmitters) that operate devices such as garage door openers, motorized gates, or home lighting - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 107
For best results, install a new battery in the hand held transmitter before programming. If your garage door opener (located in the garage) is equipped with an antenna, make sure that the antenna is hanging straight down. 1. Turn off the engine. 3 WARNING! Vehicle exhaust contains carbon - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 108
pets or damage to objects. 2. Erase the factory test codes by pressing the two outside buttons. Release the buttons when the light in the Universal Transceiver begins to flash (about 20 seconds). door openers may require you to replace step 4 with the procedures listed under Canadian Programming. - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 109
if your device is protected by a "Rolling Code" system: • Check the owner's manual for the device for mention of "Rolling Codes". • Press and hold the programmed button on the Universal Transceiver. If the Universal Transceiver indicator light flashes rapidly and then stays on after 2 seconds, the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 110
location and color of the button may vary by garage door opener manufacturer. If you have difficulty in locating the training button, check your garage door opener manual, has not previously been done. Refer to the Programming instructions. You may use either your Universal Transceiver or your - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 111
of the previously trained frequencies, hold down both outside buttons until the indicator light begins to flash. This device complies with part 15 of FCC rules and with RS-210 of Industry Canada. Operation is subject to the following conditions: 1. This device may not cause harmful interference. 3 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 112
symbol or battery symbol, indicating power source. All outlets are protected by a single 20 Amp fuse. The outlet that is located in the front of the center floor console is a conventional cigar lighter outlet. Power Outlet It will accept a cigar lighter unit, which is part of - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 113
. This outlet is powered directly by the battery, regardless of the ignition switch position. All accessories connected to this outlet should be removed or turned off when the vehicle is not in use, to protect the battery against discharge. The third outlet is located in the right rear cargo area - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 114
, if plugged in long enough, the vehicle's battery will discharge sufficiently to degrade battery life and/or prevent engine starting. • Accessories that draw higher power (i.e. coolers, vacuum cleaners, lights, etc.), will degrade the battery even more quickly. Only use these intermittently and - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 115
UNDERSTANDING THE FEATURES OF YOUR VEHICLE 115 CONSOLE FEATURES The console has two front cup holders, a coin holder, 12 volt power outlet, and front and rear storage trays. There are additional cup holders; one is molded in the center of the console to hold large cups and the other is at the rear - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 116
, if plugged in long enough, the vehicle's battery will discharge sufficiently to degrade battery life and/or prevent engine starting. • Accessories that draw higher power such as coolers, vacuum cleaners, lights, etc., will discharge the battery even more quickly. Only use these intermittently and - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 117
UNDERSTANDING THE FEATURES OF YOUR VEHICLE 117 Storage Pockets There are also Storage pockets located on each door trim panel. 3 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 118
- 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 119
Instrument Cluster ...124 Ⅵ Instrument Cluster-Turbo, With AutoStick ...125 Ⅵ Instrument Cluster-Turbo, Without AutoStick . . 126 Reception ...135 Ⅵ Sales Code RAZ-AM/ FM Stereo Radio With Cassette Tape Player, CD Player And CD Changer Controls ...136 ▫ Operating Instructions - Radio ...136 ▫ Power - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 120
Selection ...139 ▫ Scan Button ...139 ▫ To Set The Radio Push-Button Memory ...140 ▫ To Change From Clock To Radio Mode ...140 ▫ Operating Instructions - Tape Player ...140 ▫ Seek Button ...140 ▫ Fast Forward (FF) ...141 ▫ Rewind (RW) ...141 ▫ Tape Eject ...141 ▫ Scan Button ...141 ▫ Changing Tape - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 121
Button ...145 ▫ Scan Button ...145 ▫ CD Changer Control Capability - If Equipped ...145 Ⅵ Sales Code RBB-AM/FM Stereo Radio With Cassette Tape Player And CD Changer Capability ...146 ▫ Operating Instructions ...147 ▫ Power Button ...147 ▫ Electronic Volume Control ...147 ▫ Seek ...147 ▫ Tune ...148 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 122
Player Operation ...162 Ⅵ Sales Code RB1-AM/FM Stereo Radio With DVD/GPS Navigation System ...166 Ⅵ Cassette Tape And Player Maintenance ...167 Ⅵ CD/DVD Disc Maintenance ...168 Ⅵ Radio Operation And Cellular Phones ...168 Ⅵ Climate Controls ...169 ▫ Air Conditioning ...169 ▫ Operating Tips ...174 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 123
UNDERSTANDING YOUR INSTRUMENT PANEL 123 INSTRUMENT PANEL FEATURES 4 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 124
124 UNDERSTANDING YOUR INSTRUMENT PANEL INSTRUMENT CLUSTER - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 125
UNDERSTANDING YOUR INSTRUMENT PANEL 125 INSTRUMENT CLUSTER-TURBO, WITH AUTOSTICK 4 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 126
126 UNDERSTANDING YOUR INSTRUMENT PANEL INSTRUMENT CLUSTER-TURBO, WITHOUT AUTOSTICK - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 127
on briefly as a bulb check. If the light stays on or comes on while driving, it means that there is a problem with the charging system. Obtain SERVICE IMMEDIATELY. 3. Deck Lid Ajar This light comes on if the deck lid is not completely closed. 4. Oil Pressure Light Shows low engine oil pressure. The - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 128
) mark, turn the engine off immediately and call for service. There are steps that you can take to slow down an impending overheat condition. If your air conditioning is on, turn it off. The air conditioning system adds heat to the engine cooling system and turning off the A/C removes this heat. You - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 129
. Before reaching the red area, ease up on the accelerator to prevent engine damage. 12. Anti-Lock Warning Light (ABS) - If Equipped This light monitors the Anti-Lock Brake System (ABS) described elsewhere in this manual. This light will come on when the ignition key is turned to the ON position - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 130
to the ON position. The light should illuminate for three seconds, or until the engine is started, whichever comes first. The light should then go out unless the parking brake is applied or a brake fault is detected. If the light does not illuminate, have the light inspected and serviced as soon as - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 131
brake application. If the parking brake is off and the light remains on, have the brake system inspected as soon as possible. 15. Trac Indicator - If Equipped The TRAC Light will come on momentarily as a bulb check or replacement, be sure to keep a record of the reading before and after the service - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 132
have the system checked. The light will also come on if: • The Traction Control switch has been used to turn the system off, • There is an anti-lock system failure, • There is a Traction Control system failure, • The system has been automatically deactivated to prevent damage to the brake system due - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 133
until the brakes have cooled. The system will automatically reactivate and turn off the TRAC OFF Light. 22. Malfunction Indicator Light This light is part of an onboard diagnostic system called OBD that monitors emissions, engine, and automatic transmission control systems. The light will illuminate - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 134
moved to the AutoStick position and shows the current gear selection. 26. Fuel Door Reminder This symbol is a reminder that the Fuel Filler Door is located on the front passenger's (right) side of the vehicle. 27. Odometer/Trip Odometer Reset Knob Press the knob to switch between the odometer and - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 135
provide excellent reception under most operating conditions. Like any system, however, the wave amplitude, and thus remain a part of the AM reception. They interfere very transmission is based on frequency variations, interference that consists of amplitude variations can be filtered out, leaving - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 136
ignition switch has been turned off. Opening a vehicle front door will cancel this feature. SALES CODE RAZ-AM/ FM STEREO RADIO WITH CASSETTE TAPE PLAYER, CD PLAYER AND CD CHANGER CONTROLS Operating Instructions - Radio NOTE: Power to operate the radio is controlled by the ignition switch. It must - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 137
to give FM receivers user-friendly features, such as Program Service name (PS) and Program Type (PTY). Program Service name is typically used by the broadcaster to display the station types: Program Type Adult Hits Classical Classic Rock College Radio Display Adlt Hit Classicl Cls Rock College 4 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 138
PANEL Program Type Country Information Jazz Foreign Language News Nostalgia Oldies Personality Public Rhythm and Blues Religious Music Religious Talk Rock Soft Soft Rock Soft Rhythm and Blues Radio Display Country Inform Jazz Language News Nostalga Oldies Persnlty Public R&B Rel Musc Rel Talk - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 139
AM or FM, pausing for 5 seconds at each listenable station before continuing to the next. Pressing the AM/FM button continues the search in the alternate frequency band. To stop the search, press SCAN a second time. 4 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 140
the pushbutton twice. To Change From Clock To Radio Mode Press the Time button to change the display between radio frequency and time. Operating Instructions - Tape Player Insert the cassette with the exposed tape side toward the right and the mechanical action of the player will gently pull the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 141
to cancel the feature. Changing Tape Direction If you wish to change the direction of tape travel (side being played), press the PTY button. The lighted arrow in the display window will show the new direction. Metal Tape Selection If a standard metal tape is inserted into the player, the player will - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 142
Dolby Noise reduction System: Press the Dolby button (button 2) after you insert the tape. The NR light in the display will go off when the Dolby System is off. The Dolby System is automatically reactivated each time a tape is inserted. * "Dolby" noise reduction manufactured under license from Dolby - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 143
you insert a disc with the ignition ON and the radio OFF, the CD will automatically be pulled into the CD Player and the display will show the time of day unload and move to the entrance for easy removal. The unit will switch to the radio mode. If you do not remove the disc within 15 seconds, it will - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 144
144 UNDERSTANDING YOUR INSTRUMENT PANEL FF/TUNE/RW Press FF (Fast Forward) and the CD player will begin to fast forward until FF is released. The RW ( Reverse) button works in a similar manner. Program Button 4 (Random Play) Press this button while the CD is playing to activate Random Play. This - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 145
is compatible with a remote mounted CD changer available through Mopar Accessories. The following instructions are for the radio controls that operate this fast forward. Press and hold the RW button for fast reverse. The audio output can be heard when fast forward and fast reverse are activated. - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 146
. Skipping will not damage the disc or the player, and play will resume automatically. As a safeguard and to protect your CD player, one of the following upside down • Damaged disc • Water condensation on optics SALES CODE RBB-AM/FM STEREO RADIO WITH CASSETTE TAPE PLAYER AND CD - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 147
UNDERSTANDING YOUR INSTRUMENT PANEL 147 Operating Instructions NOTE: Power to operate the radio is supplied Turning the volume control to the right increases the volume and to the left decreases it. When the audio system is turned on, the sound will be set at the same volume level as last played. - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 148
148 UNDERSTANDING YOUR INSTRUMENT PANEL Tune Press the TUNE control up or down to increase or decrease the frequency. If the button is pushed and held, the radio will continue to tune until the button is released. The frequency will be displayed and continuously updated while the button is pushed. - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 149
UNDERSTANDING YOUR INSTRUMENT PANEL 149 Bass and Treble Tone Control The tone controls consist of 2 separate bands. The bass band is on the left, and the treble band is on the right. Each band is adjusted by a slider control with a detent at the mid-position. Moving the control up or down increases - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 150
5 seconds of the current selection. The SEEK symbol appears on the display when Music Search is in operation. Music Search shuts off automatically when a selection has been located. Selective Music Search Press the SEEK button up or down to move the track number to skip forward or backward 1 to - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 151
remote mounted CD changer available through Mopar Accessories. The following instructions are for the and hold the RW button for fast reverse. The audio output can be heard when fast forward and fast reverse player, and play will resume automatically. As a safeguard and to protect your CD player, - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 152
the display if the laser is unable to read the Disc data for the following reasons: • Excessive vibration • Disc inserted upside down • Damaged disc • Water condensation on optics Radio Display Messages Your radio has been designed to display certain messages when - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 153
UNDERSTANDING YOUR INSTRUMENT PANEL 153 SALES CODE RBK-AM/ FM STEREO RADIO WITH CD PLAYER AND CD CHANGER CONTROLS Radio Operation Power/Volume Control Press the ON/VOL control to turn the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 154
154 UNDERSTANDING YOUR INSTRUMENT PANEL the radio will continue to tune until you release the button. The frequency will be displayed and continuously updated while the button is pressed. Balance The Balance control adjusts the left-to-right speaker balance. Press the BAL button in and it will pop - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 155
change the display between radio frequency and time. General Information This radio complies with Part 15 of FCC rules and with RSS-210 of Industry Canada. Operation is subject to the following conditions: 1. This device may not cause harmful interference, 2. This device must accept any interference - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 156
selection. EJT - Eject Press the EJT button and the disc will unload and move to the entrance for easy removal. The unit will switch to the radio mode. If you do not remove the disc within 15 seconds, it will be reloaded. The unit will continue in radio mode. The disc can - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 157
Equipped This radio is compatible with a remote mounted CD changer available through Mopar Accessories. The following instructions are for the radio controls that operate this CD changer. Mode button for fast reverse. The audio output can be heard when fast forward and fast reverse are activated. 4 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 158
momentarily. Skipping will not damage the disc or the player, and play will resume automatically. As a safeguard and to protect your CD player, one of the following warning down • Damaged disc • Water condensation on optics Radio Display Messages Your radio has been designed to display certain - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 159
UNDERSTANDING YOUR INSTRUMENT PANEL 159 SALES CODE RBQ-AM/FM STEREO RADIO WITH 6 - DISC CD CHANGER 4 RBQ Radio - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 160
160 UNDERSTANDING YOUR INSTRUMENT PANEL Radio Operation Power/Volume Control Press the PWR/VOL control to turn the radio on. Turn the volume control clockwise to increase the volume. NOTE: Power to operate the radio is controlled by the ignition switch. It must be in the ON or ACC position to - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 161
UNDERSTANDING YOUR INSTRUMENT PANEL 161 Balance - BAL The Balance control adjusts the left-to-right speaker balance. Press the BAL button in and it will pop out. Adjust the balance and push the button back in. Fade The Fade control provides for balance between the front and rear speakers. Press the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 162
162 UNDERSTANDING YOUR INSTRUMENT PANEL General Information This radio complies with Part 15 of FCC rules and with RSS-210 of Industry Canada. Operation is subject to the following conditions: 1. This device may not cause harmful interference, 2. This device must accept any interference received, - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 163
it is being ejected. If you have ejected a disc and have not removed it within 15 seconds, it will be reloaded. If the CD is not removed, the radio will continue to play the non-removed CD. If the CD is removed and there are other CD's in the radio, the radio will play - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 164
be selected. Many radio stations do not currently broadcast PTY information. Toggle the PTY button to select the following format types: Program Type Adult Hits Classical Classic Rock College Country Emergency Emergency Test Radio Display Adlt Hit Classicl Cls Rock College Country ALERT! Test - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 165
PANEL 165 Program Type Information Jazz Foreign Language News Nostalgia Oldies Personality Public Rhythm and Blues Religious Music Religious Talk Rock Soft Soft Rock Soft Rhythm and Blues Sports Radio Display Inform Jazz Language News Nostalga Oldies Persnlty Public R&B Rel Musc Rel Talk - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 166
program type in the radio display. Time Press the TIME button to change the display from elapsed CD playing time to time of day. SALES CODE RB1-AM/FM STEREO RADIO WITH DVD/GPS NAVIGATION SYSTEM RB1 Radio The navigation system provides maps, turn identification, selection menus and - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 167
Manual" for detailed operating instructions. NOTE: If your vehicle is not equipped with the CD Changer option, you will not be able to use the Navigation system and the CD Player simultaneously. Always remove lodged in the tape transport. The other adverse condition is low or "muddy" sound from one - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 168
be possible to remove all deposits with a simple WET cleaning cassette. CD/DVD DISC MAINTENANCE To keep the CD/DVD discs in good condition, take the performance from your radio. This condition may be lessened or eliminated by relocating the cellular phone antenna. This condition is not harmful to the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 169
of the OFF position are for Air Conditioning. Choosing one of these speeds turns on the air conditioning compressor. The fan speed increases as you move the control to the left from the OFF position. NOTE: The air conditioning compressor will not engage until the engine has been running for about 10 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 170
is a difference in temperature between the upper and lower outlets for added comfort. The warmer air goes to the floor outlets. This feature gives improved comfort during sunny but cool conditions. Floor Air is directed through the floor outlets and side window demist outlets with a small amount - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 171
windshield and side window demist outlets. Use this mode with maximum fan and temperature settings for best windshield and side window defrosting. NOTE: The air conditioning compressor operates in both Mix and Defrost or a blend of these modes even if the fan switch is not in the A/C position. This - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 172
stuffy and window fogging may occur. Extended use of this mode is not recommended. NOTE: If your air conditioning performance seems lower than expected, check the front of the A/C condenser: located in front of the radiator, for an accumulation of dirt or insects. Clean with a gentle water spray - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 173
choose the recirculate mode, the mode control knob will automatically move to the left of the Mix position. NOTE: If you choose Defrost mode and the Circulation control is in the recirculate Mode, the system will automatically switch to the Outside Air mode and the knob will move to that position - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 174
174 UNDERSTANDING YOUR INSTRUMENT PANEL Operating Tips - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 175
. Summer Operation Air conditioned vehicles must be protected with a highquality antifreeze coolant to provide proper corrosion protection and to raise the boiling point of the coolant for protection against overheating. A 50% concentration is recommended. Outside Air Intake When operating the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 176
is located at the center of the instrument panel, below the radio. Press this button to turn on the rear window defroster, and the optional electric remote control heated mirrors. An amber light shows that the defroster is on. Rear Defroster Switch NOTE: The defroster turns off automatically after - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 177
UNDERSTANDING YOUR INSTRUMENT PANEL 177 CAUTION! To avoid damaging the electrical conductors, do not use scrapers, sharp instruments, or abrasive window cleaners on the interior surface of the rear window. Labels can be peeled off after soaking with warm water. 4 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 178
- 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 179
...182 ▫ Automatic Transaxle ...182 ▫ Manual Transaxle ...182 ▫ Normal Starting ...182 ▫ Extremely Cold Weather (Below Ϫ20°F Or Ϫ29°C) ...183 ▫ If Engine Fails To Start ...183 ▫ After Starting ...184 ▫ Turbocharger "Cool Down" ...184 Ⅵ Automatic Transaxle - If Equipped ...185 ▫ Brake/Transmission - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 180
Manual Transaxle Operation ...191 ▫ 2.4 Liter Turbo- If Equipped ...193 ▫ Recommended Shift Speeds ...194 ▫ Downshifting ...194 Ⅵ Parking Brake ...195 Ⅵ Brake System ...197 ▫ Anti-Lock Brake 216 ▫ Tread Wear Indicators ...216 ▫ Replacement Tires ...217 ▫ Alignment And Balance ...218 Ⅵ Tire Chains - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 181
STARTING AND OPERATING 181 Ⅵ Tire Rotation Recommendations ...220 Ⅵ Fuel Requirements ...221 ▫ 2.4L Standard Engine And 2.4L Standard Turbo Engine ...221 ▫ 2.4L High Output Turbo Engine ...221 ▫ Reformulated Gasoline ...222 ▫ Gasoline/Oxygenate Blends ...222 ▫ MMT In Gasoline ...223 ▫ Materials - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 182
or PARK position before you can start the engine. Apply the brakes before shifting to any driving gear. NOTE: You must press the brake pedal before shifting out of Park. Manual Transaxle Before starting the engine fully apply the parking brake, press the clutch pedal to the floor and place the gear - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 183
to get it started. Vehicles equipped with an automatic transaxle cannot be started this way. Unburned fuel could enter the catalytic converter and once the engine has started, ignite and damage the converter and vehicle. If the vehicle has a discharged battery, booster cables may be used to obtain - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 184
body air inlet opening in an attempt to start the vehicle. This could result in flash fire causing serious personal injury. After Starting The idle speed will automatically decrease as the engine chart should be used as a guide in determinning the amount of engine idle time required to sufficiently - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 185
Tow 5 AUTOMATIC TRANSAXLE - IF EQUIPPED • Shift into or out of REVERSE only after the vehicle has come to a complete stop and the engine is at engine is above idle speed. • Before shifting into any gear, make sure your foot is firmly on the brake pedal. NOTE: You MUST press and hold the brake - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 186
. Only shift into gear when the engine is idling normally and when your right foot is firmly on the brake pedal. Brake/Transmission Interlock System This system prevents you The engine can be started and stopped but the key cannot be removed until you obtain service. Four Speed Automatic Transaxle - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 187
possible convenience. Your dealer has diagnostic equipment to determine if the problem could recur. If the transaxle cannot be reset, dealer service is required. Gear Ranges For Four Speed Automatic Transaxle DO NOT race the engine when shifting from PARK or NEUTRAL positions into another gear range - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 188
all vehicles, you should never exit a vehicle while the engine is running. Before exiting a vehicle, you should always shift the vehicle into P (Park), remove the key from the ignition, and apply the parking brake. Once the key is removed from the ignition, the transmission shift lever is locked in - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 189
and extend transaxle life by reducing excessive shifting and heat build up. Use the "3" range when descending steep grades to prevent brake system distress. "1" Low This range should be used for maximum engine braking when descending steep grades. In this range, up shifts will occur only to prevent - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 190
manual gear shifting capability to provide you with more control. Autostick allows you to maximize engine braking will be shown in the transmission gear display, located in the instrument cluster. You can shift in will operate automatically; shifting between the four available gears. When - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 191
until the powertrain cools off. • If the system detects a problem it will disable the Autostick mode and the transmission will return to the automatic mode until the problem is corrected. MANUAL TRANSAXLE OPERATION NOTE: The parking brake should be engaged and the gear selector placed in REVERSE - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 192
will find it easier to use only the lower gears. For steady highway driving with light accelerations, 5th gear is recommended. Never drive with your foot resting on the clutch pedal, or try to hold the vehicle on a hill with the clutch pedal partially engaged. This will cause abnormal wear on the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 193
Turbo- If Equipped The neutral position of the shift lever is located between THIRD and FOURTH gear. This is the position the shifter lever will return to automatically to confirm that reverse has been selected and the backup lights will illuminate. NOTE: Listen for the audible chime to confirm - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 194
optimal fuel economy, it should be upshifted as listed in table 1. TABLE 1-MANUAL TRANSAXLE NORMAL ACCELERATION AND CRUISE SHIFT SPEEDS IN mph (km/h) ENGINE MODE 1 to 2 2 to 3 3 to 4 4 to 5 SIZE Accel 15 (24) 25 (40) 40 (65) 45 (72) 2.4L Turbo Cruise 15 (24) 25 (40) 42 (68) 45 (72) 2.4L Accel 15 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 195
up a steep grade, downshift early so that the engine will not be overburdened. PARKING BRAKE When the parking brake is applied with the ignition on, the Brake Light in the instrument cluster will come on. NOTE: This light only shows that the parking brake is on. It does not show the degree of - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 196
is pulled up slightly past its applied position. When parking on a hill, it is important to set the parking brake before placing the gear selector in Park, otherwise the load on the automatic transaxle locking mechanism may make it difficult to move the selector out of Park. As an added precaution - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 197
as standard equipment. In the event power assist is lost for any reason (for example, repeated brake applications with the engine off), the brakes will still function. However, the effort required to brake the vehicle will be much greater than that required with the power system operating. WARNING - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 198
master cylinder drops, the brake warning indicator will light. Anti-Lock Brake System (ABS) - If Equipped The ABS gives increased vehicle stability and brake performance under most braking conditions. The system automatically "pumps" the brakes during severe braking conditions to prevent wheel lock - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 199
STARTING AND OPERATING 199 WARNING! • Anti-lock system (ABS) cannot prevent the natural laws of physics from acting on the vehicle, nor can it increase braking or steering efficiency beyond that afforded by the condition of the vehicle brakes and tires or the traction afforded. • The ABS cannot - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 200
spin. The system reduces wheel slip and maintains traction at the driving (front) wheels by engaing the brake on the wheel that is losing traction. When this occurs the TRAC indicator light located above the instrument cluster odometer will flash. The system operates at speeds below 40 mph (64 km - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 201
deactivate and turn on the TRAC OFF Light located in the instrument cluster. This is to prevent overheating of the brake system and is a normal condition. The system will remain disabled for about 4 minutes until the brakes have cooled. The system will automatically reactivate and turn off the TRAC - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 202
the sidewall beginning with the section width. The letter ЉPЉ is absent from this tire size designation. Example: 215/65R15 96H • LT(Light Truck)-Metric tire sizing is based on U.S. design standards. The size designation for LT-Metric tires is the same as for P-Metric tires except for the letters - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 203
LT = Light Truck tire based on U.S. design standards T = Temporary Spare tire 31 = Overall Diameter in Inches (in) 215 = Section Width in Milimeters (mm) 65 = Aspect Ratio in Percent (%) -Ratio of section height to section width of tire. 10.5 = Section Width in Inches (in) R = Construction Code - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 204
OPERATING EXAMPLE: Service Description: 95 = Load Index -A numerical code associated with the maximum load a tire can carry. H = Speed Symbol -A symbol indicating the range of speeds at which a tire can carry a load corresponding to its load index under certain operating conditions. -The maximum - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 205
only be on one side. Tires with white sidewalls will have the full TIN including date code located on the white sidewall side of the tire. Look for the TIN on the outboard side of black sidewall tires as mounted on the vehicle. If the TIN is not found on the outboard side - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 206
206 STARTING AND OPERATING Tire Loading and Tire Pressure Tire Placard Location NOTE: The proper cold tire inflation pressure for passenger cars is listed on either the "B" pillar, the Certification Label or in the Tire Inflation Pressures brochure in the glove compartment. Tire Placard Location - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 207
Loading Information placard and the Vehicle Loading section of this manual. 5 Tire and Loading Information This placard tells you important the total weight your vehicle can carry NOTE: Under a maximum loaded vehicle condition, gross axle weight ratings (GAWR's) for the front and rear axles must - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 208
OPERATING To determine the maximum loading conditions of your vehicle, locate the statement "The combined weight of from your trailer will be transferred to your vehicle. Consult this manual to determine how this reduces the available cargo and luggage load capacity of your vehicle. NOTE: The - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 209
STARTING AND OPERATING 209 5 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 210
to cushion shock. Objects on the road and chuck holes can cause damage that results in tire failure. • Unequal tire pressures can cause steering problems. You could lose control of your vehicle. • Over inflated or under inflated tires can affect vehicle handling and can fail suddenly, resulting in - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 211
tire replacement. brochure in the glove compartment. Some vehicles may have Supplemental Tire Pressure Information for vehicle loads that are less than the maximum loaded vehicle condition. These pressure conditions will be found in the "Supplemental Tire Pressure Information" section of this manual - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 212
psi (7 kPa) per 12° F (7° C) of air temperature change. Keep this in mind when checking tire pressure inside a garage especially in the winter. kPa) for every 12° F (7° C) for this outside temperature condition. CAUTION! After inspecting or adjusting the tire pressure always reinstall the valve - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 213
low. Tire Pressures for High Speed Operation The manufacturer advocates driving at safe speeds within posted speed limits. Where speed limits or conditions are such that the vehicle can be driven at high speeds, maintaining correct tire inflation pressure is very important. Increased tire pressure - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 214
The compact spare is for temporary emergency use with radial tires. It is engineered to be used on your style vehicle only. Since this tire has limited tread life, the original tire should be repaired (or replaced) and reinstalled at the first opportunity. WARNING! Temporary use spare tires are for - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 215
cover ground clearance, do not take your vehicle through an automatic car wash with the compact spare installed. Damage to by a limited use spare tire warning label located on the limited use spare tire and wheel replace (or repair) the original tire and reinstall on vehicle at the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 216
placard or limited use spare tire and wheel assembly. Replace (or repair) the original tire at the first in mud, sand, snow, or ice conditions, do not spin your vehicle's wheels above 35 mph ( Freeing A Stuck Vehicle in Section 6 of this manual. WARNING! Fast spinning tires can be dangerous. Forces - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 217
the Tire and Loading Information placard for the size designation of your tire. The service description and load identification will be found on the original equipment tire. Failure to use equivalent replacement tires may adversely affect the safety, handling, and ride of your vehicle. We recommend - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 218
resulting in changes to steering, handling, and braking of your vehicle. This can cause unpredictable handling sudden tire failure and loss of vehicle control. CAUTION! Replacing original tires with tires of a different size may result correct this condition. See your dealer for proper diagnosis. - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 219
STARTING AND OPERATING 219 Improper alignment will not cause vehicle vibration. Vibration may be a result of tire and wheel out-ofbalance. Proper balancing will reduce vibration and avoid tire cupping and spotty wear. TIRE CHAINS Due to limited clearance, tire chains are not recommended. SNOW - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 220
vehicles operate at different loads and perform different steering, driving and braking functions. For these reasons, they wear at unequal rates, and type of driving found in the "Maintenance Schedules" Section of this manual. More frequent rotation is permissible if desired. The reasons for any - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 221
poorer performance. 2.4L High Output Turbo Engine Your engine is designed to meet all Light spark knock at low engine speeds is not harmful to your engine. However, continued heavy spark knock at high speeds can cause damage and immediate service is required. Poor quality gasoline can cause problems - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 222
air quality. The manufacturer supports the use of reformulated gasolines. Properly blended reformulated gasolines will provide excellent performance and durability of engine result in starting and driveability problems and may damage critical fuel system components. Problems that result from using - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 223
in the United States is required to contain effective detergent additives. Use of additional detergents or other additives is not needed under normal conditions and would result in additional cost. Therefore you should not have to add anything to the fuel. Fuel System Cautions CAUTION! Follow these - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 224
fuel or ignition malfunctions, can cause the catalytic converter to overheat. If you notice a pungent burning odor or some light smoke, your engine may be out of tune or malfunctioning and may require immediate service. Contact your dealer for service assistance. • The use of fuel additives which - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 225
inspected every time the vehicle is raised. Have any abnormal conditions repaired promptly. Until repaired, drive with all side windows fully be sure the replacement cap is for use with this vehicle. NOTE: When removing the fuel filler cap, lay the cap tether in the hook, located on the fuel filler - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 226
lit in or near the vehicle when the gas cap is removed or the tank filled. • Never add fuel when the engine is running. This is in violation of most state and federal fire regulations and will cause the malfunction indicator light to turn on. NOTE: Tighten the gas cap about 1/4 turn until - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 227
. Before towing a trailer carefully review this information to tow your load as efficiently and safely as possible. Perform maintenance services as prescribed in the maintenance schedules manual. When your vehicle is used for trailer towing, never exceed the gross axle weight rating (GAWR) by the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 228
capability for your vehicle is 1,000 lbs (454 kg). • If using a manual transaxle vehicle for trailer towing, all starts must be in FIRST gear to avoid excessive clutch slippage. • The trailer tongue load must be considered as part of the combined weight of occupants and cargo, and should never - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 229
for motoring safety. • The automatic transaxle fluid and filter should be changed if you REGULARLY tow a trailer for more than 45 minutes of continuous operation. See Schedule "B" in section 8 of this manual for transaxle fluid change intervals. NOTE: Check the automatic transaxle fluid level before - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 230
- 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 231
Hazard Warning Flasher ...232 Ⅵ If Your Engine Overheats ...233 Ⅵ Jacking And Tire Changing ...235 ▫ Jack Location ...235 ▫ Spare Tire Stowage ...236 ▫ Preparations For Jacking ...237 ▫ Jacking Instructions ...238 Ⅵ Jump-Starting Procedures Due To A Low Battery ...240 Ⅵ Driving On Slippery Surfaces - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 232
. If it is necessary to leave the vehicle to go for service, the flasher system will continue to operate with the ignition key removed and the vehicle locked. NOTE: With extended use, the flasher may wear down your battery. Hazard Flasher Switch The flasher switch is on top of the steering - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 233
off immediately and call for service. NOTE: There are steps that you can take to slow down an impending overheat condition. If your air conditioner is on, turn it off. The air conditioning system adds heat to the engine cooling system and turning off the A/C removes this heat. You can also turn - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 234
vehicle. Idle the vehicle with the air conditioner turned off until the pointer drops back into the normal range. After appropriate action has been taken, if the pointer remains on the "H", turn the engine off immediately, and call for service. WARNING! A hot engine cooling system is dangerous. You - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 235
fall on you. You could be crushed. Never get any part of your body under a vehicle that is on a jack. Never start or run the engine while the vehicle is on a jack. If you need to get under a raised vehicle, take it to a service center where it can be raised on a lift. • The jack - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 236
is stowed under the rear of the vehicle by means of a hook/basket mechanism. To remove or stow the compact spare, use the jack handle to rotate the "spare tire drive" nut. The nut is located under the rear scuff plate at the right rear of the cargo area, just inside the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 237
. Use of an air wrench or other power tools is not recommended and can damage the winch. Preparations For Jacking Park the vehicle on a firm level surface, avoid ice or slippery areas, set the parking brake and place the gear selector in PARK (automatic transaxle) or REVERSE (manual transaxle). Turn - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 238
238 WHAT TO DO IN EMERGENCIES Jacking Instructions 1. Remove the scissors jack and lug wrench from the stowage bag. NOTE: If equipped with a center cap that covers the wheel nuts, pry off the cap using the small end of the lug wrench. To reinstall the cap, make sure it is properly lined - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 239
the wheel. Lightly tighten the nuts Remove the wheel nuts and pull the wheel and wheel covers where applicable off the hub. Install the spare wheel and wheel nuts with the cone shaped end of the 6 7. Finish tightening the nuts. Push down on the wrench while tightening the wheel nuts. Alternate - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 240
you have tightened the nuts correctly, have them checked with a torque wrench by your dealer or at a service station. 8. Remove the wheel blocks and lower the jack until it is free. Stow the lug wrench, replaced tire, and jack. Secure all parts using the means provided. WARNING! A loose tire thrown - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 241
to get it started. Vehicles equipped with an automatic transaxle cannot be started this way. Unburned fuel could enter the catalytic converter and once the engine has started, ignite and damage the converter and vehicle. If the vehicle has a discharged battery, booster cables may be used to obtain - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 242
start terminal, located near the hood release latch, of the vehicle with the discharged battery. Make sure you have a good contact. Negative Jump Start 6. Turn the ignition switch to the ON position for 3 seconds before moving the ignition switch to the START position. 7. Start the engine in the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 243
WHAT TO DO IN EMERGENCIES 243 8. When removing the jumper cables, reverse the sequence exactly. Be careful of the moving belts and fan. DRIVING ON SLIPPERY SURFACES Acceleration Rapid acceleration on snow covered, wet, or other slippery surfaces may cause the front wheels to pull erratically to the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 244
244 WHAT TO DO IN EMERGENCIES 2. Slow down if road has standing water or puddles. 3. Replace tires when tread wear indicators first become visible. 4. Keep tires properly inflated. 5. Maintain enough distance between your vehicle and the vehicle in front of you - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 245
DISABLED VEHICLE With Ignition Key Four Speed Automatic Transaxle Your vehicle may be towed under the following conditions: The steering column must be unlocked and front wheels off the ground to avoid damage to the transaxle. Manual Transaxle Your vehicle may be towed if the gearshift lever is in - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 246
must be in the OFF position, not in the LOCK or ACCESSORY positions. Do not attempt to use sling type equipment when towing. manual transaxle, it may be towed at any legal highway speed, for any distance, if the transaxle is in neutral. If the ignition key is not available, vehicles with automatic - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 247
WHAT TO DO IN EMERGENCIES 247 CONVERTIBLE TOP MANUAL OVERRIDE If your vehicle is experiencing electrical failure (low battery, etc.) and it is necessary to raise the convertible top, perform the following steps: 1. Locate the convertible top motor bleeder screw, which is found in the trunk under - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 248
248 WHAT TO DO IN EMERGENCIES 5. Pull down and rotate the handle counterclockwise to engage the latches. 6. Raise the handle into the stowed position. 7. Close the convertible top motor bleeder screw by turning the screw clockwise until it stops. Engaging Convertible Top - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 249
And Maintenance Programs ...255 Ⅵ Replacement Parts ...256 Ⅵ Dealer Service ...256 Ⅵ Maintenance Procedures ...257 ▫ Engine Oil ...257 ▫ Drive Belts - Check Condition And Tension . . 261 ▫ Spark Plugs ...262 ▫ Ignition Wiring System ...262 ▫ Catalytic Converter ...262 ▫ Engine Timing Belt ...264 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 250
Ball Joints ...268 ▫ Body Lubrication ...269 ▫ Windshield Wiper Blades ...269 ▫ Windshield Washer Reservoir ...270 ▫ Exhaust System ...271 ▫ Cooling System ...272 ▫ Hoses And Vacuum/Vapor Harnesses ...277 ▫ Fuel System Connections ...277 ▫ Brake System ...278 ▫ Automatic Transaxle ...280 ▫ Manual - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 251
/Side Marker Lights . . 300 ▫ Front Fog Lights - If Equipped ...300 ▫ Tail/Stop, And Rear Turn Signal Lights ...300 ▫ Back Up Light Bulb ...301 ▫ Center High Mounted Stop Light ...301 Ⅵ Fluids And Capacities ...302 Ⅵ Recommended Fluids, Lubricants And Genuine Parts ...303 ▫ Engine ...303 ▫ Chassis - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 252
252 MAINTAINING YOUR VEHICLE 2.4L TURBO ENGINE COMPARTMENT - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 253
MAINTAINING YOUR VEHICLE 253 2.4L ENGINE COMPARTMENT 7 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 254
This system monitors the performance of the emissions, engine, and automatic transmission control systems. When these systems are operating serviced before any emissions tests can be performed. • If the "Malfunction Indicator Light" is flashing while the engine is running, severe catalytic converter - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 255
and is not on when the engine is running, and that the OBD (On Board Diagnostic) system is ready for testing. Normally, the OBD system will be ready. The OBD system may not be ready if your vehicle was recently serviced, if you recently had a dead battery, or a battery replacement. If the OBD system - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 256
of non-Mopar parts for maintenance and repairs will not be covered by the manufacturer's warranty. DEALER SERVICE Your dealer has the qualified service personnel, special tools and equipment to perform all service operations in an expert manner. Service Manuals are available which include detailed - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 257
Level To assure proper engine lubrication, the engine oil must be maintained at the correct level. Check the oil level at regular intervals, such as every fuel stop. WARNING! You can be badly injured working on or around a motor vehicle. Do only that service work for which you have the knowledge - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 258
the following list to decide if any apply to you. • Day and night temperatures are below 32°F (0°C). • Stop and Go driving. Engine Oil Dipstick Checking the oil while the vehicle is on level ground, will improve the accuracy of the oil level readings. Maintain the oil level between the MIN - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 259
. If none of these apply to you, and your vehicle is equipped with a Turbo Charged Engine change your engine oil at every interval shown on schedule "A"-TURBO in the maintenance schedule section of this manual. NOTE: Under no circumstances should oil change intervals exceed 6000 miles (10 000 km - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 260
oil improves low temperature starting and vehicle fuel economy. Refer to your engine oil filler cap for the recommended engine oil viscosity for your vehicle. For information on engine oil filler cap location, see the Engine Compartment illustration in this section. Lubricants which do not have both - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 261
oil filter. Use a filter of this type for replacement. The quality of replacement filters varies considerably. Only high quality filters should be used to assure most efficient service. Mopar Engine Oil Filters are high quality oil filters and are recommended. Drive Belts - Check Condition and - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 262
Engine data Label located under the hood for the proper type of spark plug for use in your vehicle. Ignition Wiring System The ignition cables should be kept clean and properly connected. Terminals should be fully seated. Cracked, damaged, or faulty cables should be replaced. Catalytic Converter - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 263
263 CAUTION! Damage to the catalytic converter can result if your vehicle is not kept in proper operating condition. In the event of engine malfunction, particularly involving engine misfire or other apparent loss of performance, have your vehicle serviced promptly. Continued operation of your - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 264
of dirt accumulate in the fuel tank, frequent filter replacement may be necessary. The fuel filters are located inside the fuel tank. See your dealer for service. Air Cleaner Element (Filter) Under normal driving conditions, replace the filter at the intervals shown on Schedule "A". If, however - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 265
Turbo engine, a small amount of oil accumulation in the air cleaner box is normal. The amount will depend on driving style. The air cleaner box should be cleaned out and a new make-upair filter element should be installed during the normal air filter maintenance procedure. Maintenance-Free Battery - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 266
than 12 volts. Don't allow cable clamps to touch each other. Battery posts, terminals and related accessories contain lead and lead compounds. Wash hands after handling. CAUTION! It is essential when replacing the cables on the battery that the positive cable is attached to the positive post and - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 267
of each warm season. This service should include cleaning of the condenser fins and a performance test. Drive belt tension should also be checked at this time. WARNING! • Use only refrigerants and compressor lubricants approved by the manufacturer for your air conditioning system. Some unapproved - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 268
Parts for correct fluid types. Front Suspension Ball Joints There are two front suspension lower ball joints that are permanently lubricated. Inspect these ball joints whenever under vehicle service is done. Damaged seals and their corresponding potentially damaged ball joints must be replaced - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 269
wiper blades to remove frost or ice from the windshield. make sure that they are not frozen to the glass before turning them on to avoid damaging the blade. Keep the blade rubber out of contact with petroleum products such as engine oil, gasoline, etc. Windshield Wiper Blade Replacement 1. Lift the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 270
onto the wiper arm tip until it locks in place. Windshield Washer Reservoir The washer fluid reservoir is located in the rear of the engine compartment on the passenger side and should be checked for fluid level at regular intervals. Fill the reservoir with windshield washer solvent (not radiator - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 271
and adjacent body areas for broken, damaged, deteriorated, or mispositioned parts. Open seams or loose connections could permit exhaust fumes to seep into the passenger compartment. In addition, inspect the exhaust system each time the vehicle is raised for an oil change or lubrication. Replace as - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 272
until the radiator has had time to cool. Never try to open a cooling system pressure cap when the radiator is hot. Coolant Checks Check engine coolant (antifreeze) protection every 12 months (before the onset of freezing weather, where applicable). If coolant is dirty or rusty in appearance, the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 273
not running), check the cooling system pressure cap for proper vacuum sealing by draining a small amount of coolant from the radiator drain cock. If the cap is sealing properly, the engine coolant (antifreeze) will begin to drain from the coolant recovery bottle. DO NOT REMOVE THE COOLANT PRESSURE - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 274
be covered under the new vehicle warranty, and decreased corrosion protection. If a non-HOAT coolant is introduced into the cooling system in an emergency, it should be replaced with the specified coolant as soon as possible. Do not use plain water alone or alcohol base engine coolant (antifreeze - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 275
system. To prevent scalding or injury, do not remove the pressure cap while the system is hot or under pressure. Engine Coolant Disposal Used ethylene glycol based engine coolant is a regulated substance requiring proper disposal. Check with your local authorities to determine the disposal rules - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 276
for proper corrosion protection of your engine which contains aluminum components. • Make sure that the radiator and coolant recovery bottle hoses are not kinked or obstructed. • Keep the front of the radiator clean. If your vehicle has air conditioning, keep the front of the condenser clean, also. - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 277
couplings to make sure the are secure and no leaks are present. Components should be replaced immediately if there is any evidence of degradation that could cause failure. Fuel System Connections Electronic clamps, or their equivalent in material and specification, in any fuel system servicing. 7 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 278
indication of leakage. Actual dripping of hot fluid when systems are under pressure (during vehicle operation) should be noted before a hose is replaced based on leakage. WARNING! Riding the brakes can lead to brake failure and possibly an accident. Driving with your foot resting or riding on the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 279
VEHICLE 279 NOTE: Inspection of brake hoses should be done whenever the brake system is serviced and at every engine oil change. fluid reservoir. Fluid level can be expected to fall as the brake pads wear. Brake fluid level should be checked when pads are replaced. However, low fluid level may - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 280
Fluids, Lubricants and Genuine Parts for correct fluid type. Use only brake fluid that has been in a tightly closed container to avoid contamination from foreign matter. Do not allow petroleum based fluid to contaminate the brake fluid as seal damage will result! Automatic Transaxle All front wheel - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 281
fluid will result in more frequent fluid and filter changes. Refer to Recommended Fluids, Lubricants and Genuine Parts for correct fluid type. Fluid Level Check The fluid level in the automatic transaxle should be checked whenever the vehicle is serviced. Operation with an improper fluid level will - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 282
fluid is between 85° to 125°F (29° to 52°C). 6. Wipe the dipstick clean and reinsert until seated. Remove dipstick and note reading. If the fluid is hot, reading should be in the cross hatched area marked "HOT sufficient transmission fluid to bring to the proper level. Transaxle Dipstick Location - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 283
from entering the transaxle after checking or replenishing fluid, make certain that the dipstick cap is seated properly. Fluid And Filter Changes Automatic transmission fluid and filter should be changed as follows: Maintenance schedule "A"-Turbo Charged Engines - No change necessary. Maintenance - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 284
284 MAINTAINING YOUR VEHICLE Manual Transaxle Lubricant Selection Use only manufacturers recommended transmission fluid, refer to Recommended Fluids, Lubricants and Genuine Parts for correct fluid type. Fluid Level Check Check the fluid level by removing the fill plug. The fluid level should be - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 285
gravel impact. • Insects, tree sap and tar. • Salt in the air near sea coast localities. • Atmospheric fallout/industrial pollutants. Washing • Wash vehicle, wash it as soon as possible. • Use Mopar auto polish to remove road film and stains and to polish your vehicle. Take care never to scratch - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 286
of the owner. • Use Mopar touch up paint on scratches or chips as soon as possible. Your dealer has touch up paint to match the color of your vehicle. • If your vehicle is damaged due to an accident or similar cause which destroys the paint and protective coating have your vehicle - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 287
prevent corrosion. Wash them with the same soap solution as the body of your vehicle. Rinse wheels thoroughly. When cleaning extremely dirty wheels wheel trim. DO NOT USE: • Any abrasive cleaner • Any abrasive cleaning pad (such as steel wool) or abrasive brush • Any cleaner that contains an acid - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 288
the wheel surface. NOTE: Replacement costs for components damaged and should be removed promptly with a damp cloth. Stubborn soils can be removed easily with a based cleaners to clean your leather upholstery. Application of a leather conditioner is not required to maintain the original condition - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 289
the possibility of scratching the lenses and reducing light output, avoid wiping with a dry cloth. To remove road dirt, wash with a mild soap sharp instruments which may scratch the elements. Instrument Panel Cover The instrument panel cover has a low glare surface which minimizes reflections in the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 290
remove the belts from the vehicle to wash them. Replace the belts if they appear frayed or worn or if the buckles do not work properly. CONVERTIBLE TOP CARE Immediate removal highly recommended. Automatic car washing equipment can damage the top material. If you must use an automatic car wash, soft - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 291
Cleaning Procedure For additional cleaning assistance in removing stubborn stains, apply Mopar Convertible Cloth Top Cleaner # 4883061 to the all directions, covering an area of about two square feet at a time. Avoid heavy scrubbing. Rinse the entire vehicle with water to remove all soap and - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 292
Fuses (Power Distribution Center) A Power Distribution Center is located in the engine compartment; next to the air cleaner filter. A label identifying the components and circuits is located on the underside of the cover. CAUTION! Avoid getting Scotchguard on the surrounding weather strips - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 293
MAINTAINING YOUR VEHICLE 293 7 Power Distribution Center - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 294
Amp/Blue Anti-Lock Brake (ABS) Solenoid 40 Amp/ Electric Back Light (EBL) Green 40 Amp/ Power Top Green 40 Amp/ Green 10 Amp/Red 15 Amp/Lt. Blue 20 Amp/ Yellow 15 Amp/Lt. Blue 20 Amp/ Yellow IP Fuse Block Air Conditioning (A/C) Stop Lights Fuel Pump/Auto Shut Down (ASD) Horn Electronic Automatic - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 295
Fog Lamps (Export Only) Interior Fuses The fuse access panel is on the left side of the instrument panel next to the steering column. To remove the panel, pull it out, as shown. A label identifying the components and circuits is located on the inside of the cover. Interior Fuse Panel 7 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 296
/Red 10 Amp/Red 20 Amp/ Yellow 20 Amp/ Yellow 10 Amp/Red 15 Amp/Lt. Blue 10 Amp/Red 10 Amp/Red 10 Amp/Red Cluster/RKE/SKIM Engine Module/ABSTRAC PDC Relays/LDP Interior Lighting Overhead Console/Radio Wipers/Comb. FLS Auto Stick/Ignition Heated Seats Heated Mirrors Rt Headlamp Lt - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 297
problem in the circuit that must be corrected. VEHICLE STORAGE If you will not be using your vehicle for more than 21 days you may want to take steps to preserve your battery from the battery. REPLACEMENT BULBS LIGHT BULBS - Inside Bulb No. ABS Indicator ...LED Airbag Indicator ...LED Brake System - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 298
74 Voltage Indicator ...LED NOTE: * Vacuum Fluorescent Display All the inside bulbs are brass or glass wedge base. Aluminum base bulbs are not approved and should not be used for replacement. LIGHTS BULBS - Outside Bulb No. Low Beam Headlight ...9006XS High Beam Headlight ...9005XS Front Park/Turn - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 299
MAINTAINING YOUR VEHICLE 299 BULB REPLACEMENT Headlight Bulb Replacement CAUTION! Do not touch the new headlight bulb with your fingers. Oil contamination will severely shorten bulb life. 1. Remove the headlight access cover splash shield, located in the front wheel well opening. 2. Disconnect the - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 300
Front Park/Turn Signal/Side Marker Lights 1. Remove the headlight access cover splash shield, located in the front wheel well opening. 2. Rotate the socket to the left one quarter turn to replace and replace the bulb. Front Fog Lights - If Equipped 1. Remove the fasteners attaching the lower splash - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 301
the screws attaching the back up light to the rear fascia and remove the housing. 2. Remove the socket from the housing. 3. Pull the bulb out of the socket and replace. Center High Mounted Stop Light 1. Open the deck lid and remove the deck lid CHMSL cover. 2. Remove CHMSL lens from the housing by - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 302
AND CAPACITIES Fuel (Approximate) Engine Oil-With Filter 2.4 Liter Engines (Use API Certified SAE 5W-30 Engine Oil. Refer to your engine oil filler cap for correct SAE grade meeting DaimlerChrysler Material Standard MS-6395.) Cooling System * 2.4 Liter Engines (Mopar Antifreeze/Coolant 5 Year/100 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 303
MAINTAINING YOUR VEHICLE 303 RECOMMENDED FLUIDS, LUBRICANTS AND GENUINE PARTS Engine Component Engine Coolant Engine Oil Engine Oil Filter Spark Plugs Fuel Selection Fluids, Lubricants and Genuine Parts Mopar Antifreeze/Coolant 5 Year/100,000 Mile Formula HOAT (Hybrid Organic Additive Technology) - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 304
Automatic Transmission Fluid. Manual Transmission Fluid. Brake Master Cylinder Fluids, Lubricants and Genuine Parts. Mopar ATF+4 Automatic Transmission Fluid. Mopar ATF+4 Automatic Transmission Fluid. Mopar DOT 3, SAE J1703 should be used. If DOT 3, SAE J1703 brake fluid is not available - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 305
MAINTENANCE SCHEDULES CONTENTS Ⅵ Emission Control System Maintenance ...306 Ⅵ Maintenance Schedule ...306 ▫ Schedule "B"-All Engines ...309 ▫ Schedule "A"-Non Turbo ...319 M A I N T E N A N C E S ▫ Schedule "A"-Turbo ...323 C H E D U L E S 8 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 306
emission control system. These, and all other maintenance services included in this manual, should be done to provide best vehicle performance and reliability. More frequent mainS tenance may be needed for vehicles in severe operating C conditions such as dusty areas and very short trip H driving - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 307
3,000 miles (5 000 km) or 3 months, whichever comes first, and follow schedule "B-All Engines" of the ЉMaintenance SchedulesЉ section of this manual. NOTE: IF ANY of these apply to you then flush and replace the engine coolant every 102,000 miles (164,000 km) or 60 months, whichever comes first, and - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 308
Oil Change • Change the engine oil filter. • Inspect the exhaust system. • Inspect the brake hoses. • Inspect the CV joints and front suspension components. • Check the automatic transaxle fluid level. • Check the manual transaxle fluid level and fill plug condition. • Check the coolant level, hoses - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 309
your vehicle under one or more of the following conditions. Change the automatic transmission fluid and filter every 60,000 miles (96 000 km) if the vehicle is usually operated under one or more of the conditions marked with an छ. Change the manual transaxle fluid every 48,000 miles (77 000 km - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 310
IF ANY of these apply to you then flush and replace the engine coolant every 102,000 miles (164,000 km) or 60 months, whichever comes first, and follow schedule "B-All Engines" of the ЉMaintenance SchedulesЉ section of this manual. schedule "A"-NON TURBO in the maintenance schedule section of this - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 311
311 M Miles (Kilometers) Change engine oil and engine oil filter, if not replaced at 3 months. Rotate tires. Inspect the brake linings. Inspect the engine air cleaner filter, replace as necessary.* Inspect the Make-up air filter, replace as necessary. 3,000 (5 000) X 6,000 (10 000) X X 9,000 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 312
E Inspect the brake linings. S C H E D U L E S 21,000 (34 000) X 24,000 (38 000) X X X 27,000 (43 000) X 30,000 (48 000) X X X X X X X X 33,000 (53 000) X 36,000 (58 000) X X X 8 Replace the engine air cleaner filter. Replace the spark plugs. Inspect the tie rod ends and boot seals. Inspect - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 313
ENGINES 313 M Miles ( Kilometers) Change engine oil and engine oil filter, if not replaced at 3 months. Rotate tires. Inspect the brake linings. Change the brake fluid. If vehicle is used for trailer towing. Inspect the engine air cleaner filter, replace as necessary.* Change the manual transaxle - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 314
the tie rod ends and boot seals. Inspect the PCV valve and replace if necessary. Not required if previously changed. * ‡ Replace the Make-up air filter. Adjust the generator drive belt tension. Change the automatic transaxle fluid and filter.छ Flush and replace engine coolant at 60 months, if - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 315
months. Rotate tires. X X X Inspect the brake linings. X Inspect the engine air cleaner filter and replace X as necessary.* Replace the engine air cleaner filter. X Replace the spark plugs. X Inspect the tie rod ends and boot seals. X Inspect the PCV valve and replace if necessary. X Not required if - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 316
the brake linings. S C H E D U L E S 93,000 (150 000) X 96,000 (154 000) X X X X 99,000 (159 000) X 102,000 (164 000) X X 105,000 (168 000) X 8 Change the brake fluid. If vehicle is used for trailer towing. Inspect the engine air cleaner filter and replace as necessary.* Change the manual - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 317
) Change engine oil and engine oil filter, if not replaced at 3 months. Rotate tires. Inspect the brake linings. Replace the engine air cleaner filter. * Inspect the tie rod ends and boot seals. Replace the Make-up air filter. Adjust the generator drive belt tension. Change automatic transaxle fluid - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 318
M A I N T E N A N C E S C H E D U L E S 318 SCHEDULE "B"-ALL ENGINES * This maintenance is recommended by the manufacturer to the owner but is not required to maintain the emissions warranty. ‡ This maintenance is not required if previously replaced. - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 319
"A"-NON TURBO 319 M SCHEDULE "A"-NON TURBO Miles (Kilometers ) [Months] Change engine oil and engine oil filter. Rotate tires. Inspect the brake linings. Replace the engine air cleaner filter. Replace the spark plugs. Inspect the tie rod ends and boot seals. Replace the Make-up air filter. Adjust - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 320
000) [60] X X X X X X X X X 66,000 (106 000) [66] X X 8 Replace the engine air cleaner filter. Replace the spark plugs and ignition cables. Inspect the tie rod ends and boot seals. Inspect the PCV valve and replace, if necessary.* Flush and replace the engine coolant at 60 months, if not done at - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 321
engine oil and engine oil filter. Rotate tires. Inspect the brake linings. Replace the engine air cleaner filter. Replace the spark plugs. Inspect the tie rod ends and boot seals. Inspect the PCV valve and replace if necessary. Not required if previously changed. * ‡ Replace the Make-up air filter - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 322
NON TURBO A I N Miles T (Kilometers) E N [Months] A Change engine oil and engine oil filter. N C Rotate tires. E Inspect the PCV valve and replace if necessary. * ‡ S C H E D U L E S 108,000 (173 000) [108] X X 114,000 (182 000) [114] X X Replace the air cleaner filter. Replace the engine timing - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 323
SCHEDULE "A"-TURBO 323 M SCHEDULE "A"-TURBO Miles (Kilometers) [Months] Change engine oil and engine oil filter. Rotate tires. Inspect the brake linings. Replace the engine air cleaner filter. Replace the spark plugs. Inspect the tie rod ends and boot seals. Replace the Make-up air filter. Adjust - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 324
engine oil and engine oil filter. N C Rotate tires. E Inspect the brake linings. S C H E D U L E S 35,000 (56 000) [42] X X 40,000 (64 000) [48] X X X 45,000 (72 000) [54] X X 50,000 (80 000) [60] X X X 55,000 (88 000) [66] X X Flush and replace engine coolant at 60 months, if not replaced - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 325
Miles (Kilometers) [Months] Change engine oil and engine oil filter. Rotate tires. Inspect the brake linings. Replace the engine air cleaner filter. Replace the spark plugs and ignition cables. Inspect the tie rod ends and boot seals. Inspect the PCV valve and replace if necessary. Not required if - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 326
(160 000) [120] X X X 105,000 (168 000) [126] X X 8 Replace the engine air cleaner filter. Replace the spark plugs. Adjust the generator drive belt tension. Inspect the tie rod ends and boot seals. Inspect the PCV valve and replace if necessary. Not required if previously changed. * ‡ Flush and - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 327
TURBO 327 M Miles (Kilometers) [Month] Change engine oil and engine oil filter. Rotate tires. Inspect the PCV Valve and replace if necessary. * Replace the engine air cleaner filter. Replace on or around a motor vehicle. Do only that service work for which you have the knowledge and the right - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 328
- 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 329
ASSISTANCE CONTENTS Ⅵ Suggestions For Obtaining Service For Your Vehicle ...330 ▫ Prepare For The Appointment ...330 ▫ Prepare A List ...330 ▫ Be Reasonable With Requests ...330 Ⅵ If You Need Assistance ...331 Ⅵ Warranty Information ...333 Ⅵ Mopar Parts ...335 Ⅵ Reporting Safety Defects ...335 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 330
your warranty folder. All work to be performed may not be covered by the warranty, discuss additional charges with the service manager. Keep a maintenance log of your vehicle's service history. This can often provide a clue to the current problem. Prepare A List Make a written list of your vehicle - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 331
manufacturer and its dealers are vitally interested in your satisfaction. We want you to be happy with our products and services. Warranty service must be done by an authorized Chrysler, Dodge, or Jeep dealer. We strongly recommend that you take your vehicle to you selling dealer. They know you and - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 332
to a TDD or a conventional teletypewriter (TTY) in the United States can communicate with the manufacturer by dialing 1-800-380-CHRY. Service Contract You may have purchased a service contract for your vehicle to help protect you from the high cost of unexpected repairs after your manufacturer's new - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 333
contract that is not the manufacturer's Service Contract. It is not responsible for any service contract other than the manufacturer's Service Contract. If you purchased a service contract that is not a manufacturer's Service Contract, and you require service after your manufacturer's new vehicle - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 334
334 IF YOU NEED CONSUMER ASSISTANCE U.S. ONLY - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 335
PARTS Mopar fluids, lubricants, parts, and accessories are available remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, and the manufacturer. To defect, you should contact the Customer Service Department immediately. Canadian customers who wish - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 336
find and correct problems the first time, using step-by-step troubleshooting and driveability procedures, proven diagnostic tests and a complete list of all tools and equipment. • Owner's Manuals. These manuals have been prepared with the assistance of service and engineering specialists to acquaint - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 337
at: www.techauthority.daimlerchrysler.com or www.daimlerchrysler.ca/manuals DEPARTMENT OF TRANSPORTATION UNIFORM TIRE QUALITY GRADES The following treadwear grade is a comparative rating based on the wear rate of the tire when tested under controlled conditions on a specified government test course. - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 338
338 IF YOU NEED CONSUMER ASSISTANCE WARNING! The traction grade is based on braking (straightahead) traction tests and does not include cornering (turning) performance. Temperature Grades The temperature grades are A (highest), B, and C, representing the tire's resistance to the generation - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 339
INDEX 10 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 340
...7 Antifreeze (Engine Coolant) ...273,302,303 Capacities ...302 Anti-Lock Brake System (ABS) ...198 Anti-Lock Warning Light ...129 Anti-Theft Security Alarm ...25 Appearance Care ...284 Auto Down Power Windows ...29 Automatic Door Locks ...20 Automatic Transaxle ...12,182,185,280 Fluid and Filter - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 341
Back-Up Lights ...301 Ball Joints ...268 Battery ...265 Keyless Transmitter Replacement ...24 Belts, Drive ...261 Belts, Engine ...264 Body Mechanism Lubrication ...269 Boot, Convertible Top ...68,72 B-Pillar Location ...206 Brake Fluid ...304 Brake, Parking ...195 Brake System ...197,278 Anti-Lock - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 342
115 Contract, Service ...332 Convertible ...62 Convertible Boot ...68,72 Convertible Top ...62 Convertible Top Maintenance ...290 Convertible Top Manual Override ...73,247 Cool Down, Turbo ...184 Coolant ...302,303 Coolant Pressure Cap ...275 Cooling System ...272 Adding Coolant (Antifreeze) ...274 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 343
Light ...Cup Holder ...Customer Assistance ... ... ... ... ... ... ... ... ... 275 273 284 264 132 115 331 Door Ajar ...131 Door Locks ...18 Door Locks, Automatic In Case of Jacking ...235 Jump Starting ...240 Towing ...245 Dealer Service ...256 Deck Lid ...26 Deck Lid, Emergency Release ...28 Deck - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 344
Air Cleaner ...264 Engine Fuel ...264 Engine Oil ...261,303 Flashers ...232 Hazard Warning ...232 Flat Tire Stowage ...240 Flooded Engine Starting ...183 Fluid, Brake ...304 Fluid Capacities ...302 Fluid Leaks ...58 Fluid Level Checks Automatic Transaxle ...281 Fluids ...303 Fog Light Service - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 345
INDEX 345 Fuel ...221,303 Adding ...225 Additives ...223 Capacity ...302 Clean Air ...222 Filler Cap ...134,225 Filler Door ...134 Filter ...264 Gasoline ...221 Gauge ...127 Hoses ...277 Light ...133 Octane Rating ...221 Requirements ...221 System Hoses ...277 Tank Capacity ...302 Fueling ...225 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 346
Interior Appearance Care ...288 Interior Fuses ...295 Interior Lights ...94 Intermittent Wipers ...99 Introduction ...4 Jack Location ...235 Jack Operation ...235,238 Jump Starting ...240 Key, Programming . . Key Release Button . Key, Replacement . . Key, Sentry ...Key-In Reminder ...Keyless Entry - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 347
...221 Light Bulbs ...297,299 Lights ...58,94 Airbag ...44,48,58,132 Anti-Lock ...129 Back-Up ...301 Brake Warning ...130 Center Mounted Stop ...301 Daytime Running ...96 Deck Lid Ajar ...127 Dimmer Switch, Headlight ...95 Engine Temperature Warning ...128 Fog ...97,133,300 Front Replacement ...299 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 348
Schedule ЉAЉ-Non Turbo Schedule ЉAЉ-Turbo ...Schedule ЉBЉ ...Schedule ЉBЉ-All Engines Maintenance Schedules ...Malfunction Indicator Light ...265 ...257 ...257 ...319 ...323 ...309 ...309 ...306 ...133,255 Manual Override, Convertible Top ...73,247 Manual, Service ...336 Manual Transaxle ...182 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 349
System ...254,255 Opener, Garage Door ...106 Operator Manuals (Owner's Manuals) ...4 Outside Air Intake ...175 Overdrive ...189 Overheating, Engine ...233 Owner's Manual ...4,336 Paint Care ...284 Panic Alarm ...22 Parking Brake ...195 Passing Light ...97 Pets ...56 Placard, Tire and Loading - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 350
Keyless Entry ...21 Replacement Bulbs ...297 Replacement Keys ...16 Replacement Parts ...256 Replacement Tires ...217 Reporting Safety Defects ...335 Restraints, Child ...49,54 Restraints, Infant ...50 Rotation, Tires ...220 Safety Checks Inside Vehicle ...57 Safety Checks Outside Vehicle ...58 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 351
82,83 Security Alarm (Theft Alarm) ...25 Sentry Key ...14,26 Sentry Key Programming ...16 Service and Maintenance ...306 Service Assistance ...330,331 Service Contract ...332 Service Manuals ...336 Setting the Clock ...134 Severe Service ...309 Shift Speeds, Manual Transaxle ...194 Shoulder Belts - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 352
352 INDEX Starting ...182 Automatic Transmission ...182 Engine Fails to Start ...183 Manual Transmission ...182 Starting Procedures ...182 Steering Power ...199,268 Tilt Column ...101 Wheel Lock ...17 Storage ...116,297 Storage Bin ...116 Stuck, Freeing ...244 Supplemental - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 353
Trailer and Tongue Weight ...228 Warnings ...227 Transaxle ...185 Automatic ...12,182,185,280 Autostick ...190 Manual ...13,182,191 Operation ...185 Overdrive ...189 Selection of Lubricant ...280 Transmitter Battery Service ...24 Transmitter, Garage Door Opener ...106 Transmitter Programming ...23 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 354
Vehicle Modifications/Alterations ...7 Vehicle Storage ...297 Vehicle Theft Alarm ...25 Warning, Door Ajar ...131 Warning Lights (Instrument Cluster Description) . 127 Warnings and ...28 Windshield Washers ...98 Windshield Wipers ...98,269 Wiper Blade Replacement ...269 Wipers, Intermittent ...99 - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 355
NOTES - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 356
NOTES - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 357
NOTES - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 358
NOTES - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 359
NOTES - 2005 Chrysler PT Cruiser | Owner Manual Convertible - Page 360
NOTES
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
-
101
-
102
-
103
-
104
-
105
-
106
-
107
-
108
-
109
-
110
-
111
-
112
-
113
-
114
-
115
-
116
-
117
-
118
-
119
-
120
-
121
-
122
-
123
-
124
-
125
-
126
-
127
-
128
-
129
-
130
-
131
-
132
-
133
-
134
-
135
-
136
-
137
-
138
-
139
-
140
-
141
-
142
-
143
-
144
-
145
-
146
-
147
-
148
-
149
-
150
-
151
-
152
-
153
-
154
-
155
-
156
-
157
-
158
-
159
-
160
-
161
-
162
-
163
-
164
-
165
-
166
-
167
-
168
-
169
-
170
-
171
-
172
-
173
-
174
-
175
-
176
-
177
-
178
-
179
-
180
-
181
-
182
-
183
-
184
-
185
-
186
-
187
-
188
-
189
-
190
-
191
-
192
-
193
-
194
-
195
-
196
-
197
-
198
-
199
-
200
-
201
-
202
-
203
-
204
-
205
-
206
-
207
-
208
-
209
-
210
-
211
-
212
-
213
-
214
-
215
-
216
-
217
-
218
-
219
-
220
-
221
-
222
-
223
-
224
-
225
-
226
-
227
-
228
-
229
-
230
-
231
-
232
-
233
-
234
-
235
-
236
-
237
-
238
-
239
-
240
-
241
-
242
-
243
-
244
-
245
-
246
-
247
-
248
-
249
-
250
-
251
-
252
-
253
-
254
-
255
-
256
-
257
-
258
-
259
-
260
-
261
-
262
-
263
-
264
-
265
-
266
-
267
-
268
-
269
-
270
-
271
-
272
-
273
-
274
-
275
-
276
-
277
-
278
-
279
-
280
-
281
-
282
-
283
-
284
-
285
-
286
-
287
-
288
-
289
-
290
-
291
-
292
-
293
-
294
-
295
-
296
-
297
-
298
-
299
-
300
-
301
-
302
-
303
-
304
-
305
-
306
-
307
-
308
-
309
-
310
-
311
-
312
-
313
-
314
-
315
-
316
-
317
-
318
-
319
-
320
-
321
-
322
-
323
-
324
-
325
-
326
-
327
-
328
-
329
-
330
-
331
-
332
-
333
-
334
-
335
-
336
-
337
-
338
-
339
-
340
-
341
-
342
-
343
-
344
-
345
-
346
-
347
-
348
-
349
-
350
-
351
-
352
-
353
-
354
-
355
-
356
-
357
-
358
-
359
-
360
 |
 |
TABLE OF CONTENTS
SECTION
PAGE
1
INTRODUCTION
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
3
2
THINGS TO KNOW BEFORE STARTING YOUR VEHICLE
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
9
3
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
59
4
UNDERSTANDING YOUR INSTRUMENT PANEL
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
119
5
STARTING AND OPERATING
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
179
6
WHAT TO DO IN EMERGENCIES
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
231
7
MAINTAINING YOUR VEHICLE
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
249
8
MAINTENANCE SCHEDULES
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
305
9
IF YOU NEED CONSUMER ASSISTANCE
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
329
10
INDEX
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
339
1
2
3
4
5
6
7
8
9
10