2009 Chrysler Aspen Owner Manual Supplement Hybrid
2009 Chrysler Aspen Manual
2009 Chrysler Aspen manual content summary:
- 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 1
2009 OWNER'S MANUAL Aspen/Durango Hybrid Supplement - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 2
With respect to any Vehicles Sold in Canada, the name Chrysler LLC shall be deemed to be deleted and the name Chrysler Canada Inc. used in substitution therefor. DRIVING AND ALCOHOL Drunken driving is one of the most frequent causes of accidents. Your driving ability can be seriously impaired with - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 3
THE FEATURES OF YOUR VEHICLE ...19 UNDERSTANDING YOUR INSTRUMENT PANEL ...21 STARTING AND OPERATING ...55 WHAT TO DO IN EMERGENCIES ...67 MAINTAINING YOUR VEHICLE ...87 MAINTENANCE SCHEDULES ...113 INDEX ...127 1 2 3 4 5 6 7 8 9 - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 4
- 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 5
INTRODUCTION CONTENTS Ⅵ Introduction ...4 1 - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 6
This booklet is a supplement to the Owner's Manual. This manual was prepared with the assistance of service and engineering specialists and is intended to aid the operators of Hybrid vehicles in understanding the operation and required maintenance procedures for such vehicles. This supplement - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 7
Vehicle Operating Characteristics ...10 ▫ Driving To Achieve Maximum Fuel Economy ...11 Ⅵ Important Hybrid System Information ...12 ▫ Hybrid System Components ...12 ▫ High Voltage Battery ...14 ▫ Disposal Of High Voltage Battery ...15 ▫ High Voltage Battery Service Disconnect ...15 ▫ Charge Assist - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 8
position for extended periods of time. This will discharge the 12-Volt battery and may degrade the battery life and/or prevent the vehicle from starting. For information on using the vehicles accessories (radio, video system or power outlets) refer to "Electrical Power Outlets" in Section 3 of this - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 9
prevent rolling. Refer to "Regenerative Braking System" under "Hybrid Vehicle Unique Operating Characteristics" in this Section for further information. Driving When the "READY" light is illuminated the gas engine can shut off automatically to save on fuel, and start automatically to provide power - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 10
battery • Engine temperature, transmission temperature or coolant temperature • Hybrid System malfunction (Hybrid service lamp on) • Tow/Haul activated • Hood is ajar • Shift lever position 2 or 1 NOTE: The gas engine can also automatically shut off with the shift lever in PARK, REVERSE, DRIVE - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 11
automatic/conveyor style car wash facility, it is important that the driver follow the attendant's or posted instructions and that your shift lever is shifted to NEUTRAL when instructed. • A Hybrid vehicle that is in REVERSE or DRIVE with the "READY" light illuminated and gas engine stopped, is NOT - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 12
The Hybrid power gauge indicates the amount of regenerative braking. If the system detects slippery conditions while braking, mainly friction is used to slow the vehicle. The RBS can result in extended life of the hydraulic service brakes; however, all inspection, scheduled maintenance, and service - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 13
as the high voltage battery is cooled by the cabin air. Driving To Achieve Maximum Fuel Economy Your fuel economy should improve throughout your Hybrid vehicle's break-in period. As with any vehicle, fuel economy can be significantly impacted by your driving style and accessory usage. For best - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 14
. • Perform all scheduled maintenance. IMPORTANT HYBRID SYSTEM INFORMATION Before operating your new Hybrid vehicle, be sure to read the following information. Hybrid System Components 1 - High Voltage Battery (located under the second row seat) 2 - High Voltage Battery Service Disconnect 3 - 12 - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 15
Warning Labels attached to the high voltage (Hybrid System) components. • Do not remove or replace any of the Hybrid System (high voltage) components. All replacement or repairs of Hybrid System components should be performed at an authorized dealer. 2 WARNING! Your vehicle has both a high voltage - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 16
Your Hybrid vehicle is equipped with a maintenance free Nickel Metal-Hydride (NiMH) battery rated at approximately 300-Volts. The high voltage battery is located under the second row seat. The high voltage battery has an internal electric fan and an interior air inlet to keep the battery cool. Air - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 17
To keep the high voltage battery in good operating condition, drive the vehicle at least once every several months for a minimum of 30 minutes or 10 miles (16 km) or until the high voltage battery has been completely recharged. Refer to "Hybrid Gauge" and "Hybrid Energy Center" in Section 4 of this - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 18
service disconnect. The high voltage service disconnect is used when your vehicle requires service by a trained technician at an authorized dealer. the high voltage battery using the 12-Volt battery system. If the high voltage battery's state of charge is too low and the engine will not crank, - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 19
HIGH VOLTAGE WIRING (ORANGE COLORED) inside or outside of parts of the vehicle, never touch it because it may be Electrolyte (strong alkali) from the high voltage battery using a fire extinguisher that is used exclusively for electrical fires. Or use large amounts of water to prevent flammable gas - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 20
- 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 21
UNDERSTANDING THE FEATURES OF YOUR VEHICLE CONTENTS Ⅵ Electrical Power Outlets ...20 3 - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 22
THE FEATURES OF YOUR VEHICLE ELECTRICAL POWER OUTLETS Using the vehicles accessories (radio, video system or power outlets) can discharge the 12-Volt battery, degrade the battery life and/or prevent the vehicle from starting. It is recommended to limit the use of the ACC mode to approximately 15 - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 23
Center ...36 ▫ Hybrid System Operating Conditions ...36 Ⅵ Climate Controls ...42 ▫ Automatic Temperature Control (ATC) ...42 ▫ Automatic Control ...43 ▫ Level Of Automatic Control ...44 ▫ Manual Control (ATC) ...44 ▫ Rear Zone Climate Control ...48 ▫ Rear Rotary Temperature Control ...49 ▫ Front - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 24
22 UNDERSTANDING YOUR INSTRUMENT PANEL HYBRID INSTRUMENT CLUSTER - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 25
gauge indicates engine coolant temperature. Any reading within the normal range indicates that the cooling system is operating satisfactory. The temperature gauge will likely indicate a high temperature when driving in hot weather, up mountain grades, in heavy traffic or when towing a trailer. If - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 26
when the ignition is turned ON. If the light turns on while driving, stop the vehicle, shift into NEUTRAL, press the TOW/HAUL button and increase the engine speed for two to three minutes. If the temperature reading does not return to normal, see your authorized dealer for service immediately. - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 27
turns on while driving, it indicates a problem with the 12-Volt electrical system. See your authorized dealer for service immediately. 10. HEV Service Light This light indicates that the Hybrid System requires service. See your authorized dealer. 4 WARNING! A hot engine cooling system is dangerous - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 28
the engine oil pressure has become too low. For a bulb check, this light will illuminate momentarily when the ignition is turned ON. If the light comes on while driving, stop the vehicle and shut off the engine as soon as possible. See your authorized dealer for service immediately. 14. Hybrid Gauge - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 29
Electronic Vehicle Information Center (EVIC) equipped vehicles, when the appropriate conditions exist, messages such as "door ajar" (indicates that a door(s) may be ajar), "gASCAP" (which indicates that your gas cap is possibly loose or damaged), ЉCHANgE OIL" (indicates that the engine oil should be - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 30
after a single chime has sounded to indicate the next scheduled oil change interval. The engine oil change indicator system is duty cycle based, which means the engine oil change interval may fluctuate dependent upon your personal driving style. Unless reset, this message will continue to display - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 31
the service so that the correct mileage can be engine running. The ESP/TCS indicator light starts to flash as soon as the tires lose traction and the ESP system your speed and driving to the prevailing towing. If this light comes on, stop the vehicle, press the TOW/HAUL button, and run the engine - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 32
with the Electronic Throttle Control (ETC) system. If a problem is detected, the light will come on while the engine is running. If the light remains on with the engine running your vehicle will usually be drivable, however, see your authorized dealer for service as soon as possible. If the light - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 33
several miles/ kilometers at speeds greater than 30 mph (48 km/h), see an authorized dealer as soon as possible. 25. Malfunction Indicator Light (MIL) The Malfunction Indicator Light (MIL) is part of an Onboard Diagnostic system (OBD II) which monitors the emissions and engine/hybrid control system - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 34
your vehicle will usually be drivable and not need towing, see your authorized dealer for service as soon as possible. CAUTION! • Prolonged driving with the MIL on could cause damage to the engine control system. It also could affect fuel economy and driveability. • If the MIL is flashing, severe - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 35
fuel efficiency and tire tread life, and may affect the vehicle's handling and stopping ability. Please note that the TPMS is not a substitute for proper tire maintenance malfunction indicator is illuminated, the system may not be able to or alternate tires or wheels on the vehicle that prevent - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 36
a few seconds when the ignition is turned to the ON position as a bulb check. If the light turns on and remains on while driving, it suggests that there is a potential problem with the Regenerative Brake System (RBS) and the need for system service. See your authorized dealer as soon as possible. - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 37
position is the optimal Hybrid location. Hybrid Gauge 1 - CHARGING - Indicates that the high voltage battery is being charged during braking or certain driving conditions. 2 - ECONOMY - Indicates the HEV vehicle is being propelled forward in electric mode, Hybrid mode or Fuel Saver mode (MDS) which - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 38
36 UNDERSTANDING YOUR INSTRUMENT PANEL HYBRID ENERGY CENTER Hybrid System Operating Conditions The Hybrid System performs various functions depending on the operating condition, such as starting the gas engine, when charging is required, etc. The following Hybrid System information screens will be - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 39
37 This screen will display when the vehicle has been started and the Hybrid System is active. This display will appear when the vehicle is slowing down with the gasoline engine running and the high voltage battery is being charged. The engine will be illuminated on the radio screen. 4 Charging - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 40
38 UNDERSTANDING YOUR INSTRUMENT PANEL This display appears when the Hybrid system is off. The engine will not be illuminated on the radio screen. This display appears when the engine is at or near wide open throttle. The engine will be illuminated on the radio screen. Engine Power Battery Power - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 41
. The engine will not be running or illuminated on the radio screen. This display appears when the vehicle is driving in Hybrid mode (both the electric motors and gasoline engine running). The engine will be illuminated on the radio screen. 4 Engine And Battery Power Charging Battery - Engine Off - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 42
during braking or coasting down and the engine is not running. The engine will not be illuminated on the radio screen. This display appears when the high voltage battery is being charged during braking or coasting down and the engine is running. The engine will be illuminated on the radio screen - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 43
appears when the vehicle is operating in Hybrid mode and the Multi-Displacement System (MDS) is active. Half of the engine will appear illuminated on the radio screen. Refer to "Multi-Displacement System (MDS)" in Section 5 of the Owner's Manual for further information on MDS. 4 Fuel Saver Mode - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 44
42 UNDERSTANDING YOUR INSTRUMENT PANEL CLIMATE CONTROLS Automatic Temperature Control (ATC) The control can be turned on by pressing the power knob. When the control is turned on, it will be in the last mode prior to being turned off. Pressing the power knob a second time will turn off the control. - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 45
are not blocking the infrared sensor. It is also important that objects are not used that may scratch or damage it in any way. The Hybrid vehicle also uses a humidity sensor to determine cabin comfort, improve system efficiency, and reduce window fogging. This sensor is located behind the rearview - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 46
possible. • In cold weather, the fan will not turn on in Auto mode until the engine coolant has warmed up sufficiently. This is indicated by the "WARM UP DELAY" message on With Electronic Vehicle Information Center (EVIC) - If Equipped" in Section 3 of the Owner's Manual. • The system can be put - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 47
Use this knob to regulate the amount of air delivered through the system conditioning system. system is enabled. The compressor may operate at any temperature above 32°F (0°C). Recirculate Button The Hybrid vehicle automatically uses Use this mode to block out any outside odors, smoke, dust - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 48
Manual control of recirculation is possible only in Panel, Floor, and Bi-Level modes. It will not operate in Mix, or Defrost modes. The recirculation symbol will flash three times indicating recirculation is not available in these modes. NOTE: If the interior comfort during sunny but cool conditions. - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 49
rear control located in the rear of the center floor console as described under the ЉRear Zone Climate Control.Љ NOTE: The front display will show "CONTROL IN REAR." REAR OFF This turns the rear system off. The control will return to the front system display after approximately five seconds if no - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 50
22°C] recommended for average person) and will be displayed digitally on the front control when in rear mode. Rear Window Defrosting and Rear Window Washer/Wiper Refer to "Rear Window Features" in Section 4 of the Owner's Manual. Rear Zone Climate Control Headliner air comes from the outlets in the - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 51
YOUR INSTRUMENT PANEL 49 The rear compartment control uses two rotary knobs: one for the temperature control and the other for the fan speed control. The mode for the rear air conditioning and heating system is always controlled by the front control unit. Fan and temperature can be controlled - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 52
grilles located in the rear storage area are not obstructed by stowed articles. Front Unit to Rear Unit Chart If the Front recirculation decisions for a fast cooldown. Drive with the windows down for the first few minutes to purge hot cabin air. To use manual mode follow the steps listed below for - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 53
the air conditioning, and drive with the windows open for the first few minutes the vehicle is high. This often occurs in mild or cool temperatures when it's rainy or humid. In most cases interior fogging. As the temperature gets colder it may be necessary to direct air onto the windshield by using - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 54
52 UNDERSTANDING YOUR INSTRUMENT PANEL Winter Operation When operating the system during the Winter months, make sure the air intake, located directly in front of the windshield, is free of ice, slush, snow, or other obstructions. This will also prevent snow ingestion into the ducts. - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 55
UNDERSTANDING YOUR INSTRUMENT PANEL 53 Operating Tips Chart 4 Operating Tips - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 56
- 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 57
/Transmission Interlock System ...58 ▫ 2-Mode Hybrid Transmission Ranges ...58 Ⅵ Four-Wheel Drive Operation ...62 ▫ MP 3010 "Active On Demand" Transfer Case ...62 Ⅵ Power Steering ...63 Ⅵ Electronic Brake Control System ...64 ▫ Hill Start Assist (HSA) ...64 Ⅵ Recreational Towing (Behind Motorhome - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 58
turn off the engine and remove the key from the ignition switch if you want to rest or sleep in your car. Accidents can be caused by inadvertently moving the shift lever. Accidents can also be caused by pressing the accelerator pedal. This may cause excessive heat in the exhaust system, resulting in - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 59
procedure contact your authorized dealer. WARNING! (Continued) • Do not attempt to push or tow your vehicle to get it started. Vehicles equipped with an automatic transmission cannot be started this way. Unburned fuel could enter the catalytic converter and once the engine has started, ignite and - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 60
system is active only while the ignition switch is in the ON position. Always press the brake pedal first, before moving the shift lever out of PARK. 2-Mode Hybrid Transmission Ranges PARK Supplements the parking brake by locking the transmission. The engine can be started in this range. Never use - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 61
. You could lose control of the vehicle and hit someone or something. Only shift into gear when the engine is idling normally and when your right foot is firmly on the brake pedal. REVERSE Use this range only after the vehicle has come to a complete stop. NEUTRAL Shift to NEUTRAL when vehicle - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 62
2-Mode Hybrid Transmission will select one of four fixed gear ratios to maximize fuel economy. However, the best fuel economy savings will be when the following is conditions are met: • the shift lever is in DRIVE. • the engine coolant has reached normal operating temperature. • the TOW/HAUL switch - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 63
in the high voltage battery. NOTE: • If the vehicle is started in extremely cold temperatures, the 2-Mode Hybrid Transmission will automatically transmission cools down. After cool down, the transmission will resume normal operation. When To Use TOW/HAUL Mode When driving in hilly areas, towing a - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 64
fuel economy. NOTE: Electric only mode and engine stop-start are disabled then TOW/HAUL is activated. The TOW/HAUL light will illuminate in the instrument cluster to indicate when the switch has been activated. Pressing the switch a second time restores normal operation. FOUR-WHEEL DRIVE OPERATION - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 65
stop assist in order to prevent damage to the system. Normal operation will resume once the system is allowed to cool. If for some reason the power assist is end of the steering wheel travel are considered normal and does not indicate that there is a problem with the power steering system. 5 - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 66
Assist (HSA). All seven systems work together to enhance vehicle stability and control in various driving conditions, and are commonly system will release brake pressure and the vehicle will roll down the hill. The CAUTION! Prolonged operation of the steering system at the end of the steering wheel - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 67
65 system will and all forward gears when the activation requirements have been met. The system will not activate if the vehicle is placed in NEUTRAL or PARK. 8%), with a loaded vehicle, or while pulling a trailer, when the system will not activate and slight rolling may occur. This could cause a - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 68
order to avoid rolling down the hill while resuming acceleration, manually activate the trailer brake prior to releasing the brake pedal. remember to use the parking brake while parking on a hill, and that the driver is responsible for braking the vehicle. RECREATIONAL TOWING (BEHIND MOTORHOME - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 69
Jacking Instructions ...68 ▫ Jack Location ...68 ▫ Removing The Spare Tire ...69 ▫ Tire Changing Procedure ...70 Ⅵ Jump-Starting Procedures ...77 ▫ Charge Assist Procedure - High Voltage Battery ...77 ▫ Jump-Starting - 12-Volt Battery ...84 Ⅵ Towing A Disabled Vehicle ...86 ▫ Four-Wheel Drive ...86 - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 70
a vehicle that is on a jack. Never start or run the engine while the vehicle is on a jack. If you need to get under a raised vehicle, take it to a service center where it can be raised on a lift. • The jack is designed to use as a tool for changing tires only. The jack should not be - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 71
WHAT TO DO IN EMERGENCIES 69 Removing The Spare Tire The spare tire on your vehicle is located underneath the vehicle in the rear. 1. Remove the rubber plug from the floor in the cargo area. 6 Spare Tire Winch Spare Tire Location Remove the spare tire before attempting to jack the vehicle. 2. - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 72
. Never get any part of your body under a vehicle that is on a jack. Never start or run the engine while the vehicle is on a jack. If you need to get under a raised vehicle, take it to a service center where it can be raised on a lift. Do not raise this vehicle using a bumper jack. The scissor - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 73
front and rear of the wheel diagonally opposite the jacking position. For example, if the right front wheel is being changed, block the left rear wheel. or changing the wheel. 2. Set the parking brake. 3. Place the shift lever in PARK (automatic transmission). On 4-wheel drive vehicles, shift the - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 74
Instructions WARNING! (Continued) WARNING! • Do not get under the vehicle when it is on a jack. • Only use wheel diagonally opposite the wheel to be raised. • Set the parking brake firmly and set an automatic transmission in PARK; a manual transmission in REVERSE. • Never start or run the engine - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 75
on the ground. 3. When changing a front wheel, place the jack under the frame rail behind the wheel. Locate the jack as far forward as possible on the straight part of the frame (prior to inboard transition). Operate the jack using the jack drive tube and the wheel wrench; the tube extension may be - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 76
close to the tire as possible with the drive tubes extending to the rear. Connect the jack tube extension and wheel wrench. Right Rear Jacking Location Before raising the wheel off the ground, make sure that the jack will not damage surrounding truck parts and adjust the jack position as required - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 77
dealer or at a service station. WARNING! A loose tire or jack thrown forward in a collision or hard stop could injure someone in the vehicle. Always stow the jack, tools and the extra tire and wheel in the places provided. 7. Remove wheel blocks. Do not install chrome or aluminum wheel center caps - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 78
the valve stem facing the ground. To Stow The Flat Or Spare Turn the wheel so that the valve stem is downward. Slide the wheel retainer through the center of the wheel and position it properly across the wheel opening. For convenience in checking the spare tire inflation, stow with the valve stem - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 79
to "Charge Assist Procedure - High Voltage Battery" in this Section. Charge Assist Procedure - High Voltage Battery The "Charge Assist" procedure allows you to charge the high voltage battery using the 12-Volt battery system. The Navigation radio will guide you through the "Charge Assist" procedure - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 80
may take up to 60 minutes for the system to become adequately charged to start the engine. • There are remote battery posts located under the hood that are used to assist in the "Charge Assist" procedure. • A second running vehicle may be used in this "Charge Assist" procedure provided the generator - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 81
operating on both vehicles, it could take up to 60 minutes to charge the high voltage battery. To minimize the charging time ensure that a minimum amount of accessories are being used. Always wear eye protection and remove all metal jewelry such as watch bands or bracelets which might make - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 82
charger and allow the high voltage battery to charge. NOTE: Depending on the type of battery charger you are using and the vehicle load, the charging current may vary. Do not allow the charging current to exceed 70 Amps. Follow the manufacturer's instructions for necessary precautions and operation - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 83
at a rate higher then 70 Amps could damage the 12-Volt battery. 7. If the 12-Volt battery charger has been properly connected and the system determines that the conditions are correct for charging, the Navigation radio will display a message "CHARGING in Progress". 6 Charging In Progress CAUTION - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 84
be turned to the ON/RUN position to use an accessory. • Do not use the accessory mode for a long period of time, since the charging system will not maintain either the 12-Volt or high voltage battery in this mode. Allow the system to charge until the Navigation radio displays the "Attempt to start - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 85
belt and fan blades. 10. Remove the 12-Volt battery charger positive clamp. NOTE: Allow the vehicle to idle for a minimum of 10 minutes before attempting to drive. Charging Aborted If the "Charge Assist" procedure is interrupted, the Navigation radio will display "Charge Aborted". WARNING! Any - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 86
towed to the nearest authorized dealer for service. Jump-Starting - 12-Volt Battery WARNING! • Battery fluid is a corrosive acid solution; do not allow battery battery generates hydrogen gas which is flammable and explosive. Keep flame or spark away from the vent holes. Do not use a booster battery - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 87
vehicles. 3. Turn OFF heater, radio and all unnecessary electrical loads. 4. Connect one end of a jumper cable to the positive terminal of the booster battery. Connect the other end of the same cable to the remote positive post. 6 Remote Positive Post WARNING! Do not permit vehicles to touch each - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 88
injury or property damage due to battery explosion. • Damage to charging system of booster vehicle or of immobilized vehicle. TOWING A DISABLED VEHICLE Four-Wheel Drive The manufacturer requires towing your Hybrid with all four wheels OFF the ground using a flatbed. WARNING! • Do not connect the - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 89
Ⅵ Engine Compartment - 5.7L HEMI V-8 ...88 Ⅵ Maintenance Procedures ...89 ▫ Traction Power Inverter Module Cooling System ...89 ▫ 2-Mode Hybrid Transmission ...95 ▫ Transfer Case (All Wheel Drive) ...96 ▫ Axles ...96 ▫ Appearance Care And Protection From Corrosion ...97 Ⅵ Fuses ...98 ▫ Interior - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 90
YOUR VEHICLE ENGINE COMPARTMENT - 5.7L HEMI V-8 1 2 3 4 5 6 7 - Traction Power Inverter Module (TPIM) Coolant Bottle - Air Cleaner Filter - Engine Oil fill - Engine Oil Dipstick - Brake Fluid Reservoir - Fuses (Power Distribution Center 2) - Fuses (Power Distribution Center) 8 - Washer Fluid - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 91
or replace any of the Hybrid System components. All replacement or repairs of Hybrid System components should be performed by a factory-trained technician at an authorized dealer. The pages that follow contain the required maintenance services determined by the engineers who designed your vehicle - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 92
applicable). Check the coolant bottle tubing for brittle rubber, cracking, tears, cuts and tightness of the connection at the bottle and radiator. Inspect the entire system for leaks. NOTE: DO NOT REMOVE THE COOLANT PRESSURE CAP WHEN THE COOLING SYSTEM IS HOT. Cooling System Warning Label - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 93
cap while the system is hot or under pressure. • Do not use a pressure cap other than the one specified for your vehicle. Personal injury or engine damage may result. Maintain coolant (antifreeze) concentration at a minimum of 50% MOPAR Antifreeze/Coolant 5 Year/100,000 Mile Formula HOAT (Hybrid - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 94
cooling system cleaner. Follow with a thorough rinsing to remove all deposits and chemicals. Properly dispose of old coolant (antifreeze) solution. Selection Of Coolant Refer to "Fluids, Lubricants, and Genuine Parts" in this section for the correct fluid type. CAUTION! (Continued) • Do not use - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 95
water when mixing the water/TPIM coolant (antifreeze) solution. The use of lower quality water will reduce the amount of corrosion protection in the engine cooling system. Please note that it is the owner's responsibility to maintain the proper level of protection against freezing according - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 96
YOUR VEHICLE Disposal of Used TPIM Coolant Used ethylene glycol based TPIM children, do not store ethylene glycol based TPIM coolant (antifreeze) in open containers or allow it to remain in puddles on the ground. If when the engine cools, the cooling system should be pressure tested for leaks. - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 97
2-Mode Hybrid Transmission Fluid Level Check NOTE: Your vehicle has a capped transmission fill tube. It is sealed and should not be tampered with. Your authorized dealer has the proper tools to ensure that the fluid level is set properly. Fluid And Filter Change Refer to "Maintenance Schedules" in - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 98
affect seals. Transfer Case (All Wheel Drive) Inspect the transfer case for fluid leaks. If a fluid leak is evident the transfer case fluid level may be low. Have the transfer case serviced immediately. Axles Drain And Refill Refer to "Maintenance Schedules" in Section 7 of this supplement - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 99
. NOTE: Your Hybrid vehicle can be run through typical commercial car wash facilities. There are some simple precautions that you should keep in mind. • When entering an automatic/conveyor style car wash facility, it is important that the driver follow the attendant's or posted instructions and that - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 100
Power Distribution Center (PDC) in the engine compartment. The I.O.D. cavities include a snap-in retainer that allows the CAUTION! Car wash equipment damage, vehicle damage or a potential accident event could result if the car wash facility instructions for PARK, NEUTRAL, DRIVE and REVERSE - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 101
MAINTAINING YOUR VEHICLE 99 fuse to be disconnected without removing it from the fuse block. Pressing the I.O.D. fuse back into the cavity reconnects it. Interior Fuses The fuse block contains blade-type mini-fuses, relays, and circuit breakers for high-current circuits. It is located in the left - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 102
Natural 10 Amp Red Radio Battery Feed Humidity Sensor/IR_AZC Driver Sensor/Inside Rear View Mirror/Driver Heated Seat/Passenger Heated Seat F8 F3 F4 F5 F6 HEV Assy Trans/DTCM/ ESP/ PCM/TPIM/Trans 10 Amp Pump Controller/HVAC Red AUX Pump/Power Steering Pump/Fuel Pump Relay Sw_Pwr_Mirror/ 10 Amp - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 103
VTA/ Blue HEV Diagnostic Port 20 Battery Blue Feed 25 Amp Amplifier Battery Feed Natural 10 Amp Red Power Distribution Center Your vehicle is equipped with an electrical power distribution center located in the left side of the engine compartment. 7 Power Distribution Center This center - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 104
to the following chart. These fuses and relays can be obtained from your authorized dealer. Cavity 1 2 3 4 5 6 Cartridge Fuse/ Relay Spare Fuse 30 Amp Pink 40 Amp Green 50 Amp Red 40 Amp Green 30 Amp Pink MiniFuse N/A Front Wipers Electric Brake Feed Mini Fuses Section C Feed Power Seats Run Remote - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 105
60 Amp Yellow MiniFuse Description JB Feed (Interior) Cavity 23 24 25 26 27 28 15 Amp Blue Spare 20 Amp Yellow Spare Description Trailer Tow N/A Stop Lamp Switch N/A Run/Start Relay Feed N/A Pump Fuel Pump Relay Feed HGM (Hybrid Gateway Module) Power Inverter RBS (Regenerative Brake System) - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 106
VEHICLE Cavity 32 33 34 35 36 37 38 Cartridge Fuse/ Relay MicroRelay MicroRelay Spare MicroRelay MicroRelay SpareMicroRelay SpareMicroRelay MiniFuse Description Fuel Pump-2 Stop Lamp Switch N/A Fuel Pump Cavity 39 40 41 42 43 Cartridge Fuse/ Relay MiniFuse 10 Amp Red 20 Amp Yellow 10 Amp Red - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 107
power distribution center located in the left side of the engine compartment. inside cover, otherwise the cavity number of each fuse is stamped on the inside cover that corresponds to the following chart. These fuses and relays can be obtained from your authorized dealer. Cavity 1 2 Cartridge - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 108
An integrated power module is located in the left side of the engine compartment. stamped on the inside cover, otherwise the cavity number of Rear Wiper Rly Relay Lt Trailer-Tow Stop/ Turn Rly Relay Rt Trailer-Tow Stop/ Turn Rly Relay Park Lamps Rly 10 Amp Lt Park Lamps Red Integrated - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 109
10 Amp Red Relay 20 Amp Yellow 20 Amp Yellow Spare 20 Amp Yellow 20 Amp Yellow Description Trailer-Tow Park Lamps Rt Park Lamps Radiator Fan Hi Rly Front Control Module (FCM) Batt #4 Front Control Module (FCM) Batt #2 Spare Ft Fog Lamps Horn Cavity 17 18 19 20 21 22 23 24 - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 110
108 MAINTAINING YOUR VEHICLE Cavity 25 26 27 28 Cartridge Fuse/ Mini-Fuse Description Relay Relay Ft Fog Lamps Rly Relay Adjustable Pedal Rly 30 Amp Ignition Off Draw Green (IOD) #1 30 Amp Ignition Off Draw Green (IOD) #2 Cavity 29 30 Cartridge Fuse/ Mini-Fuse Relay Description Spare Spare - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 111
CAPACITIES Fuel (Approximate) Engine Oil with Filter SAE 5W-20, API Certified Cooling System (Includes 2.1 Qts./2 L for Coolant Bottle) 5.7L with Rear Heat (MOPAR Antifreeze/Coolant 5 Year/100,000 Mile Formula) TPIM Coolant System NOTE: All fluid capacities are approximate. U.S. 27 Gallons 7 Quarts - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 112
FLUIDS, LUBRICANTS AND GENUINE PARTS Engine Component TPIM Coolant Engine Oil Filter Spark Plugs Fuel Selection Fluid, Lubricant, or Genuine Part MOPAR Antifreeze/Coolant 5 Year/100,000 Mile Formula HOAT (Hybrid Organic Additive Technology) MOPAR Engine Oil Filter (P/N 04884899AB) or equivalent - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 113
Component 2-Mode Hybrid Transmission Transfer Case Front Axle Rear Axle Brake Master Cylinder Fluid, Lubricant, or Genuine Part Dexron VI 3 and SAE J1703 should be used or equivalent. If DOT 3 brake fluid is not available, then DOT 4 is acceptable. Use only recommended brake fluids. Pentosin CHF - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 114
- 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 115
MAINTENANCE SCHEDULES CONTENTS Ⅵ Maintenance Schedule ...114 ▫ Required Maintenance Intervals ...115 8 - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 116
other than your authorized dealer the message can be reset by referring to the steps described in "Oil Change Required - If Equipped" under "System Status (EVIC Displays)" of the Electronic Vehicle Information Center (EVIC) - If Equipped" in Section 4 of the Owner's Manual or under "Odometer/Trip - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 117
MAINTENANCE SCHEDULES 115 At Each Stop for Fuel • Check the engine oil level about five minutes after a fully warmed engine is shut off. Checking the oil level while the vehicle is on level ground will improve the accuracy of the oil level reading. Add oil only when the level is at or below the ADD - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 118
116 MAINTENANCE SCHEDULES 6,000 Miles (10,000 km) or 6 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter. ❏ Rotate tires. 12,000 Miles (20,000 km) or 12 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter. ❏ Rotate tires. ❏ If using - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 119
exhaust system. ❏ Inspect the front suspension, tie rod ends and boot seals; replace if necessary. Odometer Reading Repair Order # Signature Authorized Chrysler Dealer Date Dealer Code 30,000 Miles (50,000 km) or 30 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 120
the front and rear axle fluid; change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing. Odometer Reading Repair Order # Signature Authorized Chrysler Dealer Date Dealer Code 42,000 Miles (70,000 km) or 42 Months Maintenance Service Schedule ❏ Change the engine oil - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 121
MAINTENANCE SCHEDULES 119 54,000 Miles (90,000 km) or 54 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter. ❏ Rotate tires. ❏ Inspect the front and rear axle fluid; change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing. 60,000 - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 122
120 MAINTENANCE SCHEDULES 66,000 Miles (110,000 km) or 66 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter. ❏ Rotate tires. 72,000 Miles (120,000 km) or 72 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter. ❏ Rotate tires. ❏ If using - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 123
MAINTENANCE SCHEDULES 121 78,000 Miles (130,000 km) or 78 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter. ❏ Rotate tires. 84,000 Miles (140,000 km) or 84 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter. ❏ Rotate tires. ❏ If using - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 124
system. ❏ Inspect the front suspension, tie rod ends and boot seals; replace if necessary. Odometer Reading Repair Order # Signature Authorized Chrysler Dealer Date Dealer Code 102,000 Miles (170,000 km) or 102 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 125
120,000 Miles (200,000 km) or 120 Months Maintenance Service Schedule Change the engine oil and engine oil filter. Rotate tires. Replace the engine air cleaner filter. Inspect the brake linings; replace if necessary. Inspect the CV joints. Inspect exhaust system. Inspect the front suspension, tie - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 126
124 MAINTENANCE SCHEDULES 126,000 Miles (210,000 km) or 126 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter. ❏ Rotate tires. ❏ Inspect the front and rear axle fluid; change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing. 132,000 - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 127
towing. ❏ Inspect the CV joints. ❏ Inspect exhaust system. ❏ Inspect the front suspension, tie rod ends and boot seals; replace if necessary. 150,000 Miles (250,000 km) or 150 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter. ❏ Rotate tires. ❏ Replace the engine - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 128
126 MAINTENANCE SCHEDULES - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 129
INDEX 9 - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 130
95 Fluid and Filter Changes ...95 Fluid Level Check ...95 Fluid Type ...111 Gear Ranges ...58 Special Additives ...95 Axle Fluid ...111 Axle Lubrication (Axle Fluid) ...96 Battery ...88 Charging ...77 Emergency Starting ...77 Gas Caution ...78,84 Hybrid (300V) ...14 Brake Control System, Electronic - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 131
Towing ...Disposal Hybrid 300V Battery ...Driving to Achieve Maximum Fuel Economy ...46,47 ...24 ...95 ...86 ...15 ...11 Emergency, In Case of Jacking ...70 Engine Compartment ...88 Coolant (Antifreeze) ...110 Fuel Requirements ...109 Jump Starting ...77 Oil ...109,110 Oil Filler Cap ...88 Oil - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 132
Case ...96 Fluids, Lubricants and Genuine Parts ...110 Four Wheel Drive ...62 Operation ...62 Front Axle (Differential) ...97 Fuel Gauge ...23 Octane Rating ...110 Requirements ...109 Tank Capacity ...109 Fuses ...98,99,101,105,106 Gas Gauge (Fuel Gauge) ...23 Gauges Coolant Temperature ...23 - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 133
Description) ...23 Locks Keys ...6 Lug Nuts ...75 Maintenance Procedures ...89 Maintenance Schedule ...114 Malfunction Indicator Light (Check Engine) ...31 Manual Transmission Lubricant Selection ...111 Oil Change Oil Change Oil, Engine Capacity Indicator ...28 Indicator, Reset ...28 ...110 ...109 - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 134
Axle (Differential) ...Recreational Towing ...Regenerative Brake System ...Resetting Oil Change Indicator ...96 66 10 28 Schedule, Maintenance ...114 Seat Belts Reminder ...24 Security Alarm (Theft Alarm) ...25 Selection of Coolant (Antifreeze) ...110 Service and Maintenance ...89 Shifting Transfer - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 135
...70 Wheel Nut Torque ...75 Towing ...86 Disabled Vehicle ...86 Recreational ...66 Traction Control ...29 Transaxle ...58 Automatic ...58 Operation ...58 Transfer Case ...96 Fluid ...111 Four-Wheel-Drive Operation ...62 Transmission ...95 Automatic ...95 Filter ...95 Fluid ...111 Maintenance ...95 - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 136
VEHICLE ENGINE COMPARTMENT - 5.7L HEMI V-8 MAINTENANCE PROCEDURES Traction Power Inverter Module Cooling System2-Mode Hybrid TransmissionTransfer Case (All Wheel Drive)AxlesAppearance Care and Protection From CorrosionFUSES Interior FusesPower Distribution CenterPower Distribution Center 2Integrated - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 137
design considerations are incorporated into this vehicle's electronic system to provide immunity to radio frequency signals. Mobile battery connection. This connection should not be fused. Antennas for two-way radios should be mounted on the roof or the rear area of the vehicle. Care should be used - 2009 Chrysler Aspen | Owner Manual Supplement Hybrid - Page 138
Chrysler LLC 81-326-0937 Second Edition Printed in U.S.A.
Aspen/Durango
O W N E R ’ S M A N U A L
H y b r i d S u p p l e m e n t
2 0 0 9