2004 Ford Freestar Owner's Manual
2004 Ford Freestar Manual
2004 Ford Freestar manual content summary:
- 2004 Ford Freestar | Owner's Manual - Page 1
4 10 10 15 Entertainment Systems AM/FM AM/FM AM/FM AM/FM stereo stereo with CD stereo with in-dash six CD stereo cassette with CD 18 18 20 23 26 Climate Controls Manual heating and air conditioning Rear window defroster 33 33 42 Lights Headlamps Turn signal control Bulb replacement 43 43 47 49 - 2004 Ford Freestar | Owner's Manual - Page 2
Table of Contents Seating and Safety Restraints Seating Safety restraints Air bags Child restraints 108 108 131 145 157 Driving Starting Brakes Transmission operation Vehicle loading Trailer towing Recreational towing 171 171 175 179 184 188 - 2004 Ford Freestar | Owner's Manual - Page 3
279 Accessories Index 287 289 All rights reserved. Reproduction by any means, electronic or mechanical including photocopying, recording or by any information storage and retrieval system or translation in whole or part is not permitted without written authorization from Ford Motor Company. Ford - 2004 Ford Freestar | Owner's Manual - Page 4
Motor Company and its products visit the following website: • In the United States: www.ford.com • In Canada: www.ford.ca • In Australia: www.ford.com.au • In Mexico: www.ford.com.mx Additional owner information is given in separate publications. This Owner's Guide describes every option and model - 2004 Ford Freestar | Owner's Manual - Page 5
km) of new vehicle operation. Vary your speed to allow parts to adjust themselves to other parts. Drive your new vehicle at least 500 miles (800 km ring seating. See Engine oil in the Maintenance and Specifications chapter for more information on oil usage. 5 2004 Freestar (win) Owners Guide (post - 2004 Ford Freestar | Owner's Manual - Page 6
about the performance or status of various systems and modules in the vehicle, such as engine, throttle, steering or brake systems. In order to properly diagnose and service your vehicle, Ford Motor Company, Ford of Canada, and service and repair facilities may access vehicle diagnostic information - 2004 Ford Freestar | Owner's Manual - Page 7
access the information independently of Ford Motor Company and Ford of Canada. Special instructions For your added safety, your vehicle is fitted with sophisticated electronic controls. Please read the section Supplemental restraint system (SRS) in the Seating and Safety Restraints chapter. Failure - 2004 Ford Freestar | Owner's Manual - Page 8
See Owner's Guide Fasten Safety Belt Air Bag-Front Air Bag-Side Child Seat Installation Warning Child Seat Tether Anchor Anti-Lock Brake System Child Seat Child Seat Lower Anchor Brake System Brake Fluid Non-Petroleum Based AdvanceTrac Traction Control Master Lighting Switch Hazard Warning - 2004 Ford Freestar | Owner's Manual - Page 9
Smoking, Flames, or Sparks Explosive Gas Battery Acid Fan Warning Maintain Correct Fluid Level Engine Air Filter Jack MAX MIN Power Steering Fluid Emission System Passenger Compartment Air Filter Check fuel cap Low tire warning 9 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English - 2004 Ford Freestar | Owner's Manual - Page 10
heavy acceleration and deceleration) and have your vehicle serviced immediately. Under engine misfire conditions, excessive exhaust temperatures could damage the catalytic converter, the fuel system, interior floor coverings or other vehicle components, possibly causing a fire. 10 2004 Freestar - 2004 Ford Freestar | Owner's Manual - Page 11
. Air bag readiness: If this light fails to illuminate when ignition is turned to ON, continues to flash or remains on, have the system serviced immediately. A chime will also sound when a malfunction in the supplemental restraint system has been detected. 11 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 12
belt. Check transaxle: Illuminates when a transaxle problem has been detected and shifting may be restricted. If the light remains on, have the system serviced immediately. Charging system: Illuminates when the battery or hot. 12 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 13
: Illuminates when the fuel level in the fuel tank is at or near empty (refer to Fuel gauge in this chapter). Speed control: Illuminates when the speed control is engaged. Turns off when the speed control system is disengaged. 13 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 14
or the hazard lights are turned on. If the indicators stay on or flash faster, check for a burned out bulb. Bulb warning: Illuminates when one of the exterior front turn lamps or rear brake/turn/tail lamps bulb has burned out. • Without Message Center 14 2004 Freestar (win) Owners Guide (post-2002 - 2004 Ford Freestar | Owner's Manual - Page 15
in the ignition) and the driver's door is opened. Turn signal warning chime: Sounds when the turn signal lever has been activated to signal a turn and not turned off after the vehicle is driven more than 0.8 km (1/2 mile). GAUGES 15 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus - 2004 Ford Freestar | Owner's Manual - Page 16
seconds. The temperature display in the overhead console (if equipped) will also be changed. • With Message Center Refer to Message Center in the Drivers Controls chapter on how to switch the display from Metric to English. 16 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 17
is in motion or on a grade. The arrow near the fuel pump icon indicates which side of the vehicle the fuel filler door is located. Refer to Filling the tank in the Maintenance and Specifications chapter for more information. 17 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 18
setting. Use . SEEK / / / / SEEK, SEEK, Balance: Press to adjust the audio between the left and right speakers. / / SEEK, SEEK . Use Fade: Press to adjust the audio between the front and rear speakers. / / SEEK, SEEK . Use 18 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 19
Entertainment Systems 3. Seek: manually decrease / increase the hours. Press CLK Press again to set the minutes. When this audio is used in cargo vans where no rear speakers are installed in the vehicle, fading to the rear speakers will result in no audio output. 19 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 20
FM STEREO/ SINGLE CD SOUND SYSTEM (IF EQUIPPED) / Tuner: Press to 1. manually go up or down the radio adjust the audio between the left and right speakers. / / SEEK . Use Fade: Press to adjust the audio between the front and rear speakers. / / SEEK . Use 20 2004 Freestar (win) Owners Guide (post- - 2004 Ford Freestar | Owner's Manual - Page 21
the system will store the last one in the remaining presets. 4. Aux: Press to toggle between FES/DVD and AUX modes. If no auxiliary sources are available, NO AUX AUDIO 10. Fast forward: Press to manually advance in a CD track. 21 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 22
Entertainment Systems 11. Rewind: Press to manually reverse in back on. 17. CD: Press to enter CD mode. If a CD is already loaded into the system, CD play will begin where it ended last. 18. CD eject: Press to eject a CD. 19. CD slot: Insert a CD label side up. 22 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 23
IN-DASH SIX CD SOUND SYSTEM (IF EQUIPPED) / Tuner: Press to 1. manually go up or down the radio adjust the audio between the left and right speakers. Use / / SEEK . Fade: Press to adjust the audio between the front and rear speakers. / / SEEK . Use 23 2004 Freestar (win) Owners Guide (post-2002 - 2004 Ford Freestar | Owner's Manual - Page 24
the system will store the last one in the remaining presets. 4. Aux: Press to toggle between FES/DVD and AUX modes. If no auxiliary sources are available, NO AUX AUDIO 10. Fast forward: Press to manually advance in a CD track. 24 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 25
Entertainment Systems 11. Rewind: Press to manually reverse in a CD track. 12. Memory presets: To set a station: Select frequency band AM/FM; tune Press and hold for 2 seconds to auto eject all CDs present in the radio mechanism. 25 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 26
a CD label side up. AM/FM STEREO CASSETTE/SINGLE CD SOUND SYSTEM (IF EQUIPPED) / Tuner: Press to 1. manually go up or down the radio frequency. Also use in menu mode to Press to adjust the treble setting. Use 26 / / SEEK . 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 27
sources are available, NO AUX AUDIO will be displayed. To return to radio mode, press AM/FM. 6. Tape eject: Press to eject a tape. 7. Text: In CD mode, displays track title, artist name, and disc title (if available). 27 / / SEEK to adjust the 2004 Freestar (win) Owners Guide (post-2002-fmt) USA - 2004 Ford Freestar | Owner's Manual - Page 28
turned off, the volume will come back on at a "nominal" listening level when the ignition switch is turned back on. 18. CD: Press to enter CD mode. If a CD is already loaded into the system, CD play will begin where it ended last. 28 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus - 2004 Ford Freestar | Owner's Manual - Page 29
the rear seat passengers to hear audio through the headphones. Press again to deactivate. 4. MEM: Press consecutively to scroll through the preset stations, change tape side (if equipped), or to change discs on multiple disc radios (if equipped). 29 2004 Freestar (win) Owners Guide (post-2002 - 2004 Ford Freestar | Owner's Manual - Page 30
shall be plugged into the headphone icon jacks on the rear audio control face. Infrared headphones are included in vehicles equipped with the Family Entertainment System and shall only be used to listed to the media COMPRESS 30 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 31
System. Wireless headphones will not play audio from any other sources (AM, FM, tape, or Radio CD). The front and rear seat mountains, tall buildings, power lines, electric fences, traffic lights and thunderstorms can interfere with 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 32
Systems CD/CD PLAYER CARE Do: • Handle correctly when used in Ford CD players. Irregular shaped AUDIO SYSTEM WARRANTY AND SERVICE Refer to the Warranty Guide for audio system warranty information. If service is necessary, see your dealer or qualified technician. 32 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 33
A/C: Press to activate/deactivate air conditioning. Use with recirculated air to improve cooling performance and efficiency. Engages and . automatically in MAX A/C, 6. Fan speed adjustment: Controls the volume of air circulated in the vehicle. 33 2004 Freestar (win) Owners Guide (post-2002-fmt) USA - 2004 Ford Freestar | Owner's Manual - Page 34
control to full heat. 4. Set the fan speed to the highest setting. 5. Direct the outer instrument panel vents towards the side windows. Do not place objects on top of the instrument panel as these objects may become projectiles in a collision or sudden stop. . 34 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 35
AND AIR CONDITIONING SYSTEM WITH REAR PASSENGER COMPARTMENT CLIMATE CONTROL (IF EQUIPPED) 1. Air flow selections: Controls the direction of the airflow in the vehicle. See the following for a brief description on each control. MAX A/C: Distributes recirculated air through the instrument panel vents - 2004 Ford Freestar | Owner's Manual - Page 36
the highest speed initially, then adjust to maintain passenger comfort. and modes: In the • Move the temperature control selector to the coldest setting. . Use with A/C to provide • Select A/C and recirculated air colder airflow. 36 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 37
panel as these objects may become projectiles in a collision or sudden stop. DUAL ZONE AUTOMATIC TEMPERATURE CONTROL WITH REAR PASSENGER COMPARTMENT CLIMATE CONTROL (IF EQUIPPED) Defrost: Distributes outside air ) is illuminated. 37 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 38
vents and the floor 10. vents. 11. : Distributes air through the instrument panel vents. 12. Manual override controls: Allows you to change the system operation. To return to full automatic control, press AUTO. Front fan speed control: Press to manually increase or 13. F decrease the fan speed. To - 2004 Ford Freestar | Owner's Manual - Page 39
REAR: Press to enable the control located in the rear seat. Press again to turn the auxiliary system off. DUAL ZONE AUTOMATIC TEMPERATURE CONTROL WITH HEATED SEATS AND REAR PASSENGER COMPARTMENT CLIMATE CONTROL (IF EQUIPPED) Defrost: Distributes outside air through the windshield defroster 1. vents - 2004 Ford Freestar | Owner's Manual - Page 40
vents. 10. : Distributes air through the instrument panel vents. 11. Manual override controls: Allows you to change the system operation. To return to full automatic control, press AUTO. Driver heated seat control: Press once to activate the high 12. heat setting (2 indicator lights). Press again to - 2004 Ford Freestar | Owner's Manual - Page 41
to reach the desired temperature. 19. REAR: Press to enable the control located in the rear seat. Press again to turn the auxiliary system off. OPERATING TIPS • To reduce fog build up on the windshield during humid weather, place the air flow selector in the position. • To reduce humidity build up - 2004 Ford Freestar | Owner's Manual - Page 42
dust and pollen particles. The filter is located just in front of the windshield under the cowl vent screen on the passenger side of the vehicle. For more information, or to replace the filter, see your Ford, Lincoln or Mercury Dealer. 42 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English - 2004 Ford Freestar | Owner's Manual - Page 43
condition. • the headlamps and park lamps must be turned off when the ignition is in off or accessory position, or the front wipers are off for more than 30 seconds while the ambient light level is at daytime brightness. Autolamp control (if equipped) The autolamp system provides light sensitive - 2004 Ford Freestar | Owner's Manual - Page 44
• the headlamp control is in the lighting during these conditions. Failure to activate your headlamps under these conditions may result in a collision. High beams Push the lever toward the instrument panel to activate. Pull the lever towards you to deactivate. 44 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 45
via manual activation using the dome lamp switch or the headlamp switch, whichever is provided. The system will not turn off the parking lamps if the headlamp control is in the PARK position. For interior lights, refer to Illuminated entry in the Locks and security chapter. PANEL DIMMER CONTROL Use - 2004 Ford Freestar | Owner's Manual - Page 46
reference line on the vertical wall or screen at this height (a piece of masking tape works well). The center of the lamp is marked by a 0.5 mm circle on the headlamp lens. 3. Turn on the low beam headlamps to illuminate the wall or screen and open the hood. 46 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 47
in the middle position). • the instrument panel dimmer switch is moved to the passenger side position (right position). • any of the remote entry controls are pressed and the ignition is OFF (an the operation switch is in the middle position). 47 2004 Freestar (win) Owners Guide (post-2002-fmt) USA - 2004 Ford Freestar | Owner's Manual - Page 48
dome and map lamps are located overhead, above the second row passenger seats. The dome lamp will stay on if the panel dimmer control is moved to the passenger side position. When the control is in the middle position, the lamp will only come on when a door is opened. If the control is moved to the - 2004 Ford Freestar | Owner's Manual - Page 49
Lights Dome lamps (if equipped) The front dome lamp is located overhead between the driver and passenger seats. The dome lamp will stay on if the panel dimmer control is moved to the passenger side position. When the control is in the middle position, the lamp will only come on when a door is opened - 2004 Ford Freestar | Owner's Manual - Page 50
Map lamp (overhead console) 906 Stepwell lamp T-562 Front seat footwell 194 Front door mounted courtesy lamp 168 All replacement bulbs are clear in color except where noted. To replace all instrument panel lights - see your dealer. Replacing headlamp bulbs To remove the headlamp bulb: 1. Make sure - 2004 Ford Freestar | Owner's Manual - Page 51
expose the bulb socket. 3. To remove the side marker bulb, turn the bulb socket counterclockwise, and pull the bulb straight out of the socket. 51 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 52
and remove from lamp assembly. 4. Pull bulb straight out of socket and push in new bulb. Install the new bulb(s) in reverse order. Replacing high-mount brakelamp bulbs For bulb replacement, see a dealer or qualified technician. 52 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 53
or cornering lamp is located on the front fascia, below the bumper and headlamps. 1. Remove the bulb socket from the supplemental parking lamp by turning counterclockwise. 2. Disconnect the electrical connector. Install the new bulb in reverse order. 53 2004 Freestar (win) Owners Guide (post-2002 - 2004 Ford Freestar | Owner's Manual - Page 54
wiper. OFF - Rear wiper and washer off. For rear wash cycle, rotate (and hold as desired) the rear wiper/washer position. control to either From either position, the control will automatically return to the INT2 or OFF position. 54 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 55
2. Move the steering wheel up or down until you find the desired location. 3. Release the steering wheel release control. This will lock the steering wheel in position. Never adjust the steering wheel when the vehicle is moving. 55 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 56
air temperature are displayed together - side by side. The display, as a whole, can be turned on or off by pressing the momentary push-button on the overhead console. When the vehicle is turned off, the electronics display will remember the last display state. 56 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 57
or Fahrenheit. This is controlled via the Message Center. Please refer to the Message Center in this chapter to change from English to metric. The ignition key must be in the ON or ACCESSORY position. If the outside temperature falls below 3°C (38°F), the display will alternate from "ICE" to the - 2004 Ford Freestar | Owner's Manual - Page 58
Driver Controls 3. Press and hold the momentary seconds per circle (5 MPH). Note: Look for a parking lot away from buildings, light posts, manhole covers, sewer and drainage grates and other metallic objects. Some magnetic fast. 58 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 59
care should be taken to manually control the opening and closing speed of the door. If the door is allowed to slide open or closed unrestrained, personal injury or damage to the door could result. When closing the sliding door, keep the head, hands and other body parts of vehicle occupants out of - 2004 Ford Freestar | Owner's Manual - Page 60
sliding door. With the Power Door Lockout Control in the ON position, either sliding door can be opened or closed by: • pushing and releasing the overhead console right or left hand control. Pressing this control will also simultaneously unlock all doors. 60 2004 Freestar (win) Owners Guide (post - 2004 Ford Freestar | Owner's Manual - Page 61
left hand second row passenger control. The control(s) are located on the trim panel in front of the sliding door. • manually pulling the inside or outside sliding door handle. • by manually moving the door when the door is in the open position. Manually pull the door about 6 inches in the desired - 2004 Ford Freestar | Owner's Manual - Page 62
for service. Sliding Door Child Safety Lock Your vehicle is equipped with a sliding door child safety lock that helps prevent passengers from operating the sliding door by using the inside door handle, refer to the Child safety locks section in this chapter. 62 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 63
. Refer to the Scheduled Maintenance Guide for additional information. INSTRUMENT PANEL STORAGE COMPARTMENT The storage compartment may be used to secure sunglasses or similar sized objects. Press the control to open the storage compartment. 63 2004 Freestar (win) Owners Guide (post-2002-fmt) USA - 2004 Ford Freestar | Owner's Manual - Page 64
control to move the time display backwards. AUXILIARY POWER POINT Power outlets are designed for accessory plugs only. Do not hang any type of accessory or accessory the following locations: • Located on the instrument panel. 64 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 65
Driver Controls • Located next to the second row seat. • Located on the right trim panel in the rear cargo area and hold the bottom part of the rocker switch to open the window. Press and hold the top part of the rocker switch to close the window. 65 2004 Freestar (win) Owners Guide (post-2002-fmt - 2004 Ford Freestar | Owner's Manual - Page 66
delay With accessory delay, the window switches and radio may be used for up to ten minutes after the ignition switch is turned to the OFF position or until either front door is opened. Power vent windows The power vent windows are operated by a single switch located on the instrument panel. Press - 2004 Ford Freestar | Owner's Manual - Page 67
left 1. Select to adjust the right mirror or mirror. 2. Move the control in the direction you wish to tilt the mirror. 3. Return to the center door is open, the indicator in the appropriate mirror will flash indicating people may be entering/exiting the vehicle. 67 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 68
on the speed control. For more information on the AdvanceTrac system see AdvanceTrac Stability Enhancement System section in the Driving chapter. Do not use the speed control in heavy traffic or on roads that are winding, slippery or unpaved. 68 2004 Freestar (win) Owners Guide (post-2002-fmt - 2004 Ford Freestar | Owner's Manual - Page 69
Controls Setting speed control The controls for using your speed control are located on the steering wheel for your convenience. 1. Press the ON control and release it. 2. Accelerate to the desired speed. 3. Press the SET + control and release it. 4. Take your foot off the accelerator pedal. light - 2004 Ford Freestar | Owner's Manual - Page 70
accelerator pedal to get to the desired speed. When the vehicle reaches that speed press and release the SET + control. Reducing speed while using speed control SET + control. Turning off speed control There are two ways to turn off the speed control: 70 2004 Freestar (win) Owners Guide (post-2002 - 2004 Ford Freestar | Owner's Manual - Page 71
speed control OFF control. Note: When you turn off the speed control or the ignition, your speed control set speed memory is erased. STEERING WHEEL CONTROLS (IF EQUIPPED) RADIO CONTROL FEATURES Press MUTE to mute the volume. 71 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 72
Controls communications systems, with the operation of the accelerator or the brake pedal. To seat to the most rearward position 2. Position the driver's side floor mat with the rear of the mat against left (outboard) front edge of seat track mounting bracket. 72 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 73
not stack multiple floor mats over the Ford original equipment floor mats as they are not positively retained. HOMELINK WIRELESS CONTROL SYSTEM (IF EQUIPPED) The HomeLink Wireless Control System, located on the driver's visor, provides a convenient way to replace up to three hand-held transmitters - 2004 Ford Freestar | Owner's Manual - Page 74
steps 6 through 8 to complete programming of a rolling code equipped device. 6. At the garage door opener receiver (motor-head unit) in the garage, locate the "learn" or "smart" button (usually near where the hanging antenna wire is attached to the unit). 7. Press and release the "learn" or "smart - 2004 Ford Freestar | Owner's Manual - Page 75
"Programming" section, replace step 3 with the following: Note: If programming a garage door opener or gate operator door, gate operator, security system, entry door lock, or home or office lighting etc.). For convenience, the hand-held transmitter of the device 75 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 76
Controls light located on your instrument cluster, displays important vehicle information through a constant monitor of vehicle systems system will also notify you of potential vehicle problems with a display of system warnings followed by an indicator chime. 76 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 77
). This value is not the same as the average fuel economy display. The running average fuel economy is reinitialized to a factory default value if the battery is disconnected. INFO SETUP RESET 77 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 78
fuel pumps at service stations • variations with the speed control system engaged to display control down for two seconds to clear display. Display on/off Select this function from the INFO menu to turn the upper two lines of the message center display OFF or ON. 78 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 79
Press and hold the RESET control for 2 seconds to set the language choice. Units (English/Metric) 1. Select this function from the SETUP menu for the current units to be displayed. 2. Press the RESET control to change from English to Metric. 79 2004 Freestar (win) Owners Guide (post-2002-fmt) USA - 2004 Ford Freestar | Owner's Manual - Page 80
level 4. Brake fluid level 5. Doors and liftgate status 6. Exterior lamps status 7. Traction Control status 8. Tire inflation status 9. Fuel level status (hold to reset to relearn) 10. Distance to empty System warnings System warnings alert you to possible problems or malfunctions in your vehicle - 2004 Ford Freestar | Owner's Manual - Page 81
warning conditions still exist within the vehicle. Driver's door ajar Warning cannot be reset Passenger door ajar Left rear door ajar Right rear door ajar Transmission overheated Warning returns after 10 minutes Check traction control (if equipped) Park brake set Check brake system Reduce engine - 2004 Ford Freestar | Owner's Manual - Page 82
lamp replaced. Refer to Replacing headlamp bulbs in the Lights Control system is not operating properly. If this warning stays on, contact your dealer for service as soon as possible. For further information, refer to Traction control in the Driving chapter. 82 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 83
: 1. Press the SETUP control to access the System Check function. 2. Press and release the RESET control to display "OIL LIFE XX% HOLD RESET NEW". 3. Press and hold the RESET control for 2 seconds to display "IF NEW OIL HOLD RESET". 83 2004 Freestar (win) Owners Guide (post-2002-fmt) USA - 2004 Ford Freestar | Owner's Manual - Page 84
your personalized OIL LIFE XX% displayed, press SETUP to continue the system check. DATA ERR. These messages indicate improper operation of the vehicle network communication between electronic modules. • Fuel Computer • Oil life 84 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 85
door open, keep the vents open so outside air comes into the vehicle. POWER LIFTGATE (PLG) (IF EQUIPPED) With this option, you can power open or close the liftgate with the provided controls. • overhead console button • key fob button • outside release handle 85 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 86
Door Lockout Control is located in the overhead console. With the control in the OFF position, power operation is disabled from the liftgate handle release the control to power open the PLG. 2. Press and release the control again to power the PLG closed. 86 2004 Freestar (win) Owners Guide (post- - 2004 Ford Freestar | Owner's Manual - Page 87
. 2. Press and release the control on the bottom of the liftgate trim panel to engage the power assist feature. If a single chime is heard, check to be sure that the Power Door Lockout Switch is set to ON and that the the transaxle is in Park. 87 2004 Freestar (win) Owners Guide (post-2002-fmt) USA - 2004 Ford Freestar | Owner's Manual - Page 88
it is fully latched. Make sure the liftgate is closed to prevent exhaust fumes from being drawn into the vehicle. If you must drive with the liftgate open, keep the climate control vents open so that fresh outside air circulates through the vehicle. 88 2004 Freestar (win) Owners Guide (post-2002 - 2004 Ford Freestar | Owner's Manual - Page 89
Driver Controls CARGO AREA FEATURES Cargo net (if equipped) The cargo structure, or 45 kg (100 lbs) on the roof panel, evenly distributed. If it is not possible to distribute the load, position it as far rearward as possible. 89 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 90
steps 1 and 2 to install the other cross-bar. Note: When the cross-bars are not in use, remove or move the cross-bars to the back of the roof rack for optimum wind noise. 90 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 91
in the ignition. The vehicle can still be locked, with the key in the ignition, using the manual lock button on the door, locking the driver's door with a key, by simultaneously pressing button 7 • 8 and the 9 • 0 controls on the 91 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 92
cannot be opened with the inside handle. • The sliding doors can be opened from the outside when the doors are unlocked. The childproof lock controls are located on front edge of each sliding door and must be set separately for each door. Setting the lock for one door will not automatically set the - 2004 Ford Freestar | Owner's Manual - Page 93
the personal alarm. • arm and disarm the perimeter anti-theft system (if equipped). If there is any potential remote keyless entry problem with your vehicle, ensure ALL remote entry transmitters are taken to your authorized dealer to aid in troubleshooting. 93 2004 Freestar (win) Owners Guide (post - 2004 Ford Freestar | Owner's Manual - Page 94
• Press this control twice within three seconds to open the power sliding door. The interior lamps will illuminate. • Press this control another two times within three seconds to close the power sliding door and turn off the interior lights. 94 2004 Freestar (win) Owners Guide (post-2002-fmt - 2004 Ford Freestar | Owner's Manual - Page 95
manually and control vents open so that fresh outside air doors will lock again, the horn will chirp once, and the parking lamps will flash once more. If any of the doors, the liftgate or the hood are not properly closed, the horn will make two quick chirps. 95 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 96
seated in the battery housing cavity. 5. Snap the two halves back together. Note: Replacement of the battery will not cause the remote transmitter to become deprogrammed from your vehicle. The remote transmitter should operate normally after battery replacement. 96 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 97
Locks and Security Replacing lost remote entry transmitters If you would like to have driver's door lock cylinder, the keyless entry system or the remote entry transmitter is used to unlock the door(s), power sliding doors (if equipped) or liftgate. 97 2004 Freestar (win) Owners Guide (post-2002 - 2004 Ford Freestar | Owner's Manual - Page 98
to the off position for the illuminated entry system to operate. The inside lights will not turn off if: • they have been turned on with the panel dimmer control, or • any door, power sliding door (if equipped) or the liftgate is open. The battery saver will shut off the interior lamps 30 minutes - 2004 Ford Freestar | Owner's Manual - Page 99
This feature automatically locks all vehicle doors when: • all doors are closed, • the ignition is in the 4 (ON) position, • the brake is pressed before reaching 5 km/h (3 mph), and • the vehicle is traveling more than 5 km/h (3 mph). 99 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English - 2004 Ford Freestar | Owner's Manual - Page 100
five seconds, press any control on the remote transmitter and then press the 1 or 2 control on the driver's door panel to associate with the Driver 1 or Driver 2 positions. 4. Repeat this procedure for another remote transmitter if desired. 100 2004 Freestar (win) Owners Guide (post-2002-fmt) USA - 2004 Ford Freestar | Owner's Manual - Page 101
to deactivate and then press the SET control on the driver's door panel again. 3. Repeat this procedure for another remote transmitter if desired. KEYLESS ENTRY SYSTEM (IF EQUIPPED) You can use the keyless entry keypad to: lock or unlock the doors without using a key. activate or deactivate the - 2004 Ford Freestar | Owner's Manual - Page 102
seat/side view mirrors/adjustable pedals feature). Note: The lock motors will ; these codes do not replace the factory-set code. the 1 • 2 control. The door locks will lock and door locks will lock and quickly unlock to confirm programming mode has been exited. 102 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 103
system has been successfully reactivated. To deactivate/reactivate the autolock feature using the power door unlock control You must close all the vehicle doors and position. 2. Press the power door unlock control three times. 103 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 104
SecuriLock passive anti-theft system is not compatible with non-Ford aftermarket remote start systems. Use of these systems may result in vehicle starting problems and a loss of security protection. Theft indicator The theft indicator is located on top of the instrument panel. • When the ignition is - 2004 Ford Freestar | Owner's Manual - Page 105
start" condition if they are too close to the key when starting the engine. If a problem occurs, your vehicle towed to an authorized Ford dealer or a locksmith. The key codes need to be re-coded. Replacing coded keys can be very costly 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 106
least three seconds, but no more than ten seconds]. 2. Turn ignition from the 4 (ON) 1 position back to the 3 (OFF) position in order to remove the first coded key from the ignition. 3. Within ten new spare key(s) programmed. 106 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 107
ignition. Any of the following actions will prearm the alarm system: • Locking the vehicle using the remote entry transmitter. • Locking the vehicle using the keyless entry keypad. • Pressing the interior power door lock control while the door is open. Twenty seconds after one of the above events - 2004 Ford Freestar | Owner's Manual - Page 108
can cause an occupant to slide under the seat's safety belt, resulting in severe personal injuries in the event is located directly or as close as possible behind your head. The head restraints can be moved up and down. Push control to lower head restraint. 108 2004 Freestar (win) Owners Guide ( - 2004 Ford Freestar | Owner's Manual - Page 109
the driver's seat or seatback when the vehicle is moving. Do not pile cargo higher than the seatbacks to avoid injuring people in a collision or sudden stop. Always drive and ride with your seatback upright and the lap belt snug and low across the hips. 109 2004 Freestar (win) Owners Guide (post - 2004 Ford Freestar | Owner's Manual - Page 110
climate control system panel once to activate high heat. • Push twice to activate low heat. • Push a third time to deactivate. The indicator light on the control will illuminate when activated. The heating of the seat turns off after 10 minutes or when the vehicle is turned off. 110 2004 Freestar - 2004 Ford Freestar | Owner's Manual - Page 111
at any time. The memory seat positions are also recalled when you press your remote entry transmitter UNLOCK control. To program the memory seat to remote entry transmitter, refer to Remote entry system in the Locks and security chapter. 111 2004 Freestar (win) Owners Guide (post-2002-fmt) USA - 2004 Ford Freestar | Owner's Manual - Page 112
located directly or as close as possible behind your head. The head restraints can be moved up and down by pulling up on the head restraint. Push button to lower head restraint. Seat mounted cup holders (if equipped) Deploy by pressing the button on top of the cupholder. 112 2004 Freestar (win - 2004 Ford Freestar | Owner's Manual - Page 113
to detach from the seat when subjected to heavy load. The cupholder can be reinstalled by returning to the closed position. Adjusting 2nd row seats (if equipped) Lift control to adjust seat forward or backward. • 2nd row bucket seat (if equipped) 113 2004 Freestar (win) Owners Guide (post-2002-fmt - 2004 Ford Freestar | Owner's Manual - Page 114
bench seat back Pull control forward to adjust seat back. Using same control will fold the seat back flat. Reclining the seatback can cause an occupant to slide under the seat's safety belt, resulting in severe personal injuries in the event of a collision. 114 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 115
to full rear position (if equipped). Note: Place the front row seat in a forward position to allow the 2nd row to be fully upright. Lift the handle located on the rear lower corner of the seat. The seat back will fold flat. 115 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 116
is in motion. • Do not operate the vehicle with seats in tumbled position. Always latch the vehicle seat to the floor, whether the seat is occupied or empty. If not latched, the seat may cause injury during a sudden stop. 116 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 117
row, activate the easy entry system by pulling on the strap on the rear of the seat. This will cause the seatback to flip forward and the seat track latches to open. Push the seat forward to allow easier exit from the third row. 117 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English - 2004 Ford Freestar | Owner's Manual - Page 118
in a forward position to allow the 2nd row seat to be fully upright. 2. Place the 2nd row seat in a rear position to allow the 2nd row seat to be fully upright. 3. Place seat in tumbled position. (See Accessing 3rd row seat) 118 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 119
4. From inside the vehicle, pull up on front floor release handle (yellow). 5. Rotate the seat rearward at a 30 to 45 degree angle. 6. With the assist handle, pull the seat rearward. 7. Remove the seat from vehicle. 119 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 120
both sides of the seat by inserting a seat belt tongue or key into the buckle release slot, pushing upward as shown, and pulling out the mini-tongue on the end of the seat belt. 2. Find the clips attached near the ends of the lap/shoulder belts. 120 2004 Freestar (win) Owners Guide (post-2002-fmt - 2004 Ford Freestar | Owner's Manual - Page 121
trim panel. The end of the shoulder belt must be clipped in order to keep it from striking anything during vehicle operation. 4. Position seatback in full down position. 5. From behind seat pull straight back on the release handles located on each side of the seat, releasing the rear floor latches - 2004 Ford Freestar | Owner's Manual - Page 122
in vehicle. Place first row seat in a forward position to allow the second row seat to be installed. 2. Install seat onto rear pin of front tub at a 30 to 45 degree angle. 3. Rotate the seat forward until it latches onto the front pin. 122 2004 Freestar (win) Owners Guide (post-2002-fmt) USA - 2004 Ford Freestar | Owner's Manual - Page 123
vehicle floor by pushing/pulling on seat. If not latched, the seat may cause injury during a sudden stop. Second row bench seat 1. Position the seat in vehicle. 2. Align seat front hooks to the rear most pins of the front tub. 123 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus - 2004 Ford Freestar | Owner's Manual - Page 124
/pulling on seat. If not latched, the seat may cause injury during a sudden stop. Stowing the third row seat 1. If the comfort guide is on the center lap/shoulder belt, slip the guide off the belt and stow the guide in the pocket on the back of the seat. 124 2004 Freestar (win) Owners Guide (post - 2004 Ford Freestar | Owner's Manual - Page 125
very large objects or items that might damage the center lap/shoulder belt, detach the belt from the seat. Use a key or seat belt tongue to release the buckle. 3. Store the tongue of the sliding latchplate in the belt pocket. 125 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 126
belt pocket to avoid potential damage to the seat. 5. Push the head restraint release buttons and move the head restraints fully down. Remove all objects from the seat and stowage tub. 6. From the rear of the vehicle, fold seat back by pulling and releasing the number 1 strap. 126 2004 Freestar - 2004 Ford Freestar | Owner's Manual - Page 127
go of the number 1 strap before the seat back folds completely, the seat may not stow flat in the tub. Refer to the label attached to the rear of the vehicle seat. 7. Release the cushion latches by pulling the number 2 strap. 127 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 128
the third row seat Ensure seat latching area is free of objects. 1. Lift the seat out of the tub in the floor by pulling up on the exposed strap or handle. Once seat is at a vertical position, push the seat over, letting it fall onto the latches. 128 2004 Freestar (win) Owners Guide (post-2002-fmt - 2004 Ford Freestar | Owner's Manual - Page 129
seat back for improved comfort. To activate the recliner, pull and hold the strap located near the plastic shield in the center of the seat. When seat is adjusted to desired location, release the strap. Reclining the seatback can cause an occupant to slide under the seat's safety belt, resulting - 2004 Ford Freestar | Owner's Manual - Page 130
release the cushion latches by pulling the number 2 strap. Then, pull the seat rearward by the number 3 strap and set the seat on the liftgate scuff plate. The number 1 strap is not used to access this position. 2 Do not sit on the head restraints. 130 2004 Freestar (win) Owners Guide (post-2002 - 2004 Ford Freestar | Owner's Manual - Page 131
severity sensor. • Restraints Control Module (RCM) with impact and safing sensors. • Restraint system warning light and back-up tone. • The electrical wiring for the air bags, crash sensor(s), safety belt pretensioners, front safety belt usage sensors, driver seat position sensor, passenger occupant - 2004 Ford Freestar | Owner's Manual - Page 132
control module (RCM). During a crash, the RCM activates the safety belt pretensioners and/or either one or both stages of the dual-stage air bag supplemental restraints based on crash severity and occupant conditions. The fact that the pretensioners or air bags did not activate for both front seat - 2004 Ford Freestar | Owner's Manual - Page 133
and helps properly position the occupant relative to the air bag to improve protection. The safety belt pretensioners can be either activated alone or, if the collision is of sufficient severity, together with the air bags. 133 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 134
or a back-up tone to indicate the condition of the system. Refer to the Warning light section in the Instrument cluster chapter. Routine maintenance of the Personal Safety System is not required. The Restraints control module (RCM) monitors its own internal circuits and the circuits for the air bag - 2004 Ford Freestar | Owner's Manual - Page 135
2) Never swing the safety belt around your neck over the inside shoulder. 3) Never use a single belt for more than one person. Always transport children 12 years old and under in the back seat and always properly use appropriate child restraints. 135 2004 Freestar (win) Owners Guide (post-2002-fmt - 2004 Ford Freestar | Owner's Manual - Page 136
the seat belt webbing in a controlled manner. This helps reduce the belt force acting on the user's chest. Failure to inspect and replace if necessary the Belt and Retractor assembly after an accident could increase the risk of injury in a collision. 136 2004 Freestar (win) Owners Guide (post - 2004 Ford Freestar | Owner's Manual - Page 137
properly restrained in the rear seat whenever possible. Refer to Safety restraints for children or Safety seats for children later in this chapter. How to use the automatic locking mode • Buckle the combination lap and shoulder belt. 137 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English - 2004 Ford Freestar | Owner's Manual - Page 138
technician after any collision to verify that the automatic locking retractor feature for child seats is still working properly. Safety belt assemblies should be inspected according to the procedures in the Workshop Manual and replaced if either damage or improper operation is noted. Failure to - 2004 Ford Freestar | Owner's Manual - Page 139
the small tongue on the end of the safety belt to the mini-buckle on the left side of the center seat position. The third row center lap/shoulder belt is equipped with a Belt Comfort Guide located in a pocket on the back of the seat. The guide is attached to the driver's side head restraint, and - 2004 Ford Freestar | Owner's Manual - Page 140
Seating and Safety Restraints Conditions of operation If...The driver's safety belt is not buckled before the ignition switch is turned to the ON position...Then...The safety belt warning light illuminates 1-2 minutes and the warning chime sounds 4-8 seconds. The safety belt warning light and - 2004 Ford Freestar | Owner's Manual - Page 141
feature will not activate. The BeltMinder feature is activated - the safety belt warning light illuminates and the warning chime sounds for 6 seconds every 30 seconds, " 3 of 4 fatal crashes occur within 25 miles of home. 141 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 142
chime. Sitting on the safety belt will increase the risk of injury in an accident. To disable (one-time) or deactivate the Belt Minder feature please follow the directions stated below. Reasons given..."Belts are uncomfortable" 142 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English - 2004 Ford Freestar | Owner's Manual - Page 143
quickly buckles then unbuckles the BeltMinder feature for that seating position, the BeltMinder is disabled for the current belt warning light turns off.) • After step 3, the restraint system warning light (airbag light) will be turned on for three seconds. 143 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 144
as described in the Replacing the front seat belt assemblies after a collision section of this chapter. Safety belt assemblies not in use during a collision should also be inspected and replaced if either damage or improper operation is noted. 144 2004 Freestar (win) Owners Guide (post-2002-fmt - 2004 Ford Freestar | Owner's Manual - Page 145
collision. Failure to inspect and if necessary replace the safety belt assembly under the above conditions could result in severe personal injuries in the event of a collision. AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM (SRS) The air bag supplemental restraint system (SRS) is designed to work in - 2004 Ford Freestar | Owner's Manual - Page 146
vehicle, including the driver, should always properly wear their safety belts, even when an air bag supplemental restraint system (SRS) is provided. Always transport children 12 years old and under in the back seat and always properly use appropriate child restraints. The National Highway Traffic - 2004 Ford Freestar | Owner's Manual - Page 147
is indicated by one or more of the following: • The readiness light (same light for front and side air bag system) will either flash or stay lit. • The readiness light will not illuminate immediately after ignition is turned on. 147 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 148
Seating and Safety Restraints • A series of five beeps will be heard. The tone pattern will repeat periodically until the problem and/or light are repaired. If any of these things happen, even intermittently, have the supplemental restraint system serviced at your dealership or by a qualified - 2004 Ford Freestar | Owner's Manual - Page 149
off the front passenger's frontal air bag under certain conditions. The driver's air bag and side air bag are not part of the front passenger sensing system. The front passenger sensing system works with sensors that are part of the front passenger's seat and safety belt. The sensors are designed to - 2004 Ford Freestar | Owner's Manual - Page 150
children 12 and under should be properly restrained in the back seat. When the front passenger seat is occupied and the sensing system has turned off the passenger's frontal air bag, the passenger airbag off or pass airbag off indicator will light and stay lit to remind you that the front passenger - 2004 Ford Freestar | Owner's Manual - Page 151
these instructions may increase the risk of personal injury in the event of a collision. Do not use accessory seat covers. The use of accessory seat covers may prevent the deployment of the side air bags and increase the risk of injury in an accident. 151 2004 Freestar (win) Owners Guide (post - 2004 Ford Freestar | Owner's Manual - Page 152
designed to allow airbag deployment. • The same readiness airbag light, electronic control and diagnostic unit as used for the front air bags. • Two crash sensors located under the outboard side of the front seats, attached to the floor. Side air bags, in combination with seat belts, can help reduce - 2004 Ford Freestar | Owner's Manual - Page 153
Safety Canopy . Failure to follow these instructions may increase the risk of personal injury in the event of a collision. Do not lean your head on the door. The Safety Canopy injure you as it deploys from the headliner. could 153 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus - 2004 Ford Freestar | Owner's Manual - Page 154
(one on each side of vehicle). • A headliner designed to flex open above the side doors to allow Safety Canopy deployment. • The same readiness airbag light, electronic control and diagnostic unit as used for the front airbags. 154 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 155
• Two crash sensors mounted under the front seats (one on each side). • Two crash sensors located at the c-pillar behind the rear doors (one on each side). • Rollover sensor in the restraints control module (RCM). The Safety Canopy system, in combination with seat belts, can help reduce the risk of - 2004 Ford Freestar | Owner's Manual - Page 156
vehicle service manual. If the Safety Canopy is not replaced, the unrepaired area will increase the risk of injury in a collision. Determining if the system is operational The SRS uses a readiness light in the instrument cluster or a tone to indicate the condition of the system. Refer to the Air - 2004 Ford Freestar | Owner's Manual - Page 157
children, unreliable adults, or pets unattended in your vehicle. Child booster seats Children outgrow a typical convertible or toddler seat when they weigh 40 pounds and are around 4 years of age. Although the lap/shoulder belt 157 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 158
bent comfortably at the edge of the seat without slouching? • Does the lap belt rest low across the hips? • Is the shoulder belt centered on the shoulder and chest? • Can the child stay seated like this for the whole trip? 158 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus - 2004 Ford Freestar | Owner's Manual - Page 159
hitting a hard surface in a collision. For this reason, you should never use a booster seat with a lap belt only. It is best to use a booster seat with lap/shoulder belts in the back seat- the safest place for children to ride. 159 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 160
Follow all instructions provided by the manufacturer of the booster seat. Never put the shoulder belt under a child's arm or behind the back because it eliminates the protection for the upper part of the body and may increase the risk of injury or death in a collision. Never use pillows, books, or - 2004 Ford Freestar | Owner's Manual - Page 161
a rear-facing child seat in front of an active air bag. If you must use a forward-facing child seat in the front seat, move the seat all the way back. Children 12 and under should be properly restrained in the rear seat whenever possible. 161 2004 Freestar (win) Owners Guide (post-2002-fmt) USA - 2004 Ford Freestar | Owner's Manual - Page 162
grasp the shoulder belt and lap belt together. 3. While holding the shoulder and lap belt portions together, route the tongue through the child seat according to the child seat manufacturer's instructions. Be sure the belt webbing is not twisted. 162 2004 Freestar (win) Owners Guide (post-2002 - 2004 Ford Freestar | Owner's Manual - Page 163
click as it retracts to indicate it is in the automatic locking mode. 7. Pull the lap belt portion across the child seat toward the buckle and pull up on the shoulder belt while pushing down with your knee on the child seat. 163 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 164
as an accessory for many older safety seats. Contact the manufacturer of your child seat for information about ordering a tether strap. Children should be placed in the rear in an appropriate child safety seat that is properly secured to the vehicle. 164 2004 Freestar (win) Owners Guide (post-2002 - 2004 Ford Freestar | Owner's Manual - Page 165
either anchor can be used for a single LATCH child seat installed at the center of the bench seat. Front passenger seating position (manual adjusting seats only) 1. Position the child safety seat on the passenger seat cushion. 165 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 166
the head restraint, raise the head restraint to let the child seat fit further rearward. 3. Grasp the tether strap and position it to the seat frame. 4. Rotate the tether hook, and clip the tether strap to the seat frame. 166 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 167
strap clip. 6. Install the child safety seat tightly using the LATCH anchors or safety belts. Follow the instructions in this chapter. 7. Tighten the child safety seat tether strap according to the manufacturer's instructions. 167 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus - 2004 Ford Freestar | Owner's Manual - Page 168
. This type of child seat eliminates the need to use safety belts to attach the child seat. For forward-facing child seats, the tether strap must also be attached to the proper tether anchor. See Attaching safety seats with tether straps in this chapter. 168 2004 Freestar (win) Owners Guide (post - 2004 Ford Freestar | Owner's Manual - Page 169
enough to hold two child safety seat attachments and may break, causing serious injury or death. The lower anchors for child seat installation are located at the rear section of the rear seat between the cushion and seat back. 169 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus - 2004 Ford Freestar | Owner's Manual - Page 170
Try to tilt the child seat from side to side. Also try to tug the seat forward. Check to see if the anchors hold the seat in place. If the safety seat is not anchored properly, the risk of a child being injured in a crash greatly increases. 170 2004 Freestar (win) Owners Guide (post-2002-fmt) USA - 2004 Ford Freestar | Owner's Manual - Page 171
vehicle, refer to Starting the engine in this chapter. Extended idling at high engine speeds can produce very high temperatures in the engine and exhaust system, creating the risk of fire or other damage. 171 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 172
information on safety belts and their proper usage, refer to the Seating and Safety Restraints chapter. 2. Make sure the headlamps and electrical accessories are off. 3. Make sure the gearshift is in P (Park). 4. Make sure the parking brake is set. 172 2004 Freestar (win) Owners Guide (post-2002 - 2004 Ford Freestar | Owner's Manual - Page 173
have the vehicle serviced. • If the driver's safety belt is fastened, the Starting the engine Note: Whenever you start your vehicle, release the key as soon as the engine starts. Excessive cranking could damage the starter. light may not illuminate. 173 2004 Freestar (win) Owners Guide (post-2002 - 2004 Ford Freestar | Owner's Manual - Page 174
If the engine still fails to start, press the accelerator to the floor and try again; this will allow not use your heater with ungrounded electrical systems or two-pronged (cheater) adapters. air conditioning to bring in fresh air. 174 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English - 2004 Ford Freestar | Owner's Manual - Page 175
allowing you to retain steering control. Brake Assist (if equipped as part of the AdvanceTrac system) The Brake Assist system provides full braking force during panic braking situations. It detects a rapid application of the brake pedal and 175 2004 Freestar (win) Owners Guide (post-2002-fmt) USA - 2004 Ford Freestar | Owner's Manual - Page 176
not respond to steering inputs, the system will attempt to increase the turning response of the vehicle. AdvanceTrac enhances your vehicle's stability during maneuvers that require all available tire traction, like in wet/snowy/icy road conditions 176 2004 Freestar (win) Owners Guide (post-2002-fmt - 2004 Ford Freestar | Owner's Manual - Page 177
will also have CHECK ADVANCETRAC shown in the display. Have the vehicle system serviced immediately. If the vehicle is stuck in snow or mud or when driving in deep sand, switching off the AdvanceTrac system may be beneficial so the wheels 177 2004 Freestar (win) Owners Guide (post-2002-fmt) USA - 2004 Ford Freestar | Owner's Manual - Page 178
air from under the instrument panel during this severe condition. All these conditions are normal during AdvanceTrac operation. If the AdvaceTrac system control, vehicle rollover, personal injury and death. If you experience a severe road event, SLOW DOWN. 178 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 179
mark on the reservoir). If the power steering system breaks down (or if the engine is turned off), you can steer the vehicle manually, but it takes more effort. If the the brake pedal and shift to N (Neutral). 3 2 1 4 5 179 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 180
shift manually. To put your vehicle in gear, start the engine, depress the brake pedal, then move gearshift lever out of P (Park). Once you place the gearshift lever securely into position, gradually release the brake pedal and use the accelerator as necessary. 180 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 181
engine braking than D (Overdrive). • Use when driving conditions cause excessive shifting from D (Overdrive) to other gears. Examples: city traffic, hilly terrain, heavy loads, trailer towing and when engine braking is required. 181 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 182
brake fully and make sure that the gearshift is securely latched in Park (P). Turn off the ignition whenever you Press lightly on the accelerator in each gear. If necessary, try turning the Traction Control or AdvanceTrac system off 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 183
surfboard racks and any device that may block the normal detection zone of the RSS system may create false beeps. The RSS detects obstacles up to 6 ft. (2 . Once the system detects an object approaching, the tone will sound again. 183 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English ( - 2004 Ford Freestar | Owner's Manual - Page 184
is disabled. If the indicator light illuminates when the RSS is not turned off, it may indicate a failure in the RSS. The system defaults to enabled every time the ignition is turned on. Press the control to disable or enable the system. Keep the RSS sensors (located on the rear bumper/fascia) free - 2004 Ford Freestar | Owner's Manual - Page 185
on the Safety Compliance Certification Label located on the driver's door or door pillar. The total load on each axle must never exceed its GAWR. Exceeding the Safety Certification Label axle weight rating limits could result in substandard vehicle handling, performance, engine, transmission and/or - 2004 Ford Freestar | Owner's Manual - Page 186
handling, performance, engine, transmission and/or structural damage, serious damage to the vehicle, loss of control and personal injury. GCW (Gross Combined Weight) - is the weight of the loaded vehicle (GVW) plus the weight of the fully loaded trailer. 186 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 187
and GAWR limitations. Replacement tires with a higher limit than the originals do not increase the GVWR and GAWR limitations. Exceeding any vehicle weight rating limitation could result in serious damage to the vehicle and/or personal injury. 187 2004 Freestar (win) Owners Guide (post-2002-fmt - 2004 Ford Freestar | Owner's Manual - Page 188
Conditions in the scheduled maintenance guide. • Do not tow a trailer until your vehicle has been driven at least 500 miles (800 km). • Refer to the instructions included with towing accessories for the proper installation and adjustment specifications. 188 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 189
8500 (3856) Hitch type required Class I control and personal injury. Preparing to tow Use the proper equipment for towing a trailer and make sure it is properly attached to your vehicle. See your dealer or a reliable trailer dealer if you require assistance. 189 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 190
lights, brake lights, turn signals and hazard lights are working. Do not splice into the vehicle lamp wiring for trailer lamps. Your vehicle uses an advanced electronic module to control instructions and equipment for hooking up trailer lamps. 190 2004 Freestar (win) Owners Guide (post-2002- - 2004 Ford Freestar | Owner's Manual - Page 191
the speed control. The speed control may shut off automatically when you are towing on long, steep grades. • Consult your local motor vehicle speed service intervals. Refer to your Scheduled Maintenance Guide for more information. Trailer towing tips • Practice turning, stopping and backing up - 2004 Ford Freestar | Owner's Manual - Page 192
transport vehicle) your vehicle can be flat towed (all wheels on the ground) under the following conditions: • Place the transmission in N (Neutral). • Maximum speed is 35 mph (56 km/h). • Maximum distance is 50 miles (80 km). 192 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 193
. In Canada, the card is found in the Owner Information Guide in the glove compartment. U.S. Ford or Mercury vehicle customers who require roadside assistance, call 1-800-241-3673; Lincoln vehicle customers call 1-800-521-4140. 193 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 194
yourself, Ford Motor Company will reimburse a reasonable amount. To obtain reimbursement information, U.S. Ford or our website at www.ford.ca. HAZARD FLASHER CONTROL The hazard flasher is located on the instrument panel by the radio. 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 195
Roadside Emergencies This switch is located behind the service panel on the right side of the cargo area. To reset the switch: 1. Turn the ignition OFF. 2. Check the fuel system for leaks. 3. If no leaks are apparent, reset the switch by pushing in on the reset button. 4. Turn the ignition ON. 5. - 2004 Ford Freestar | Owner's Manual - Page 196
compartment fuse panel The fuse panel is located below and to the left of the steering wheel by the brake pedal. Remove the panel cover to access the fuses. To remove the fuse panel cover, pull up on the latch on the right or left side of the cover. 196 2004 Freestar (win) Owners Guide (post-2002 - 2004 Ford Freestar | Owner's Manual - Page 197
) LED feed Auxiliary radio Auxiliary climate control system/Power Liftgate Module/Left and right power sliding door module/Data Link Connector (DLC)/Clock B+ feeds Brake-Shift Interlock (BSI) Run feed, Climate control system Run feed 12 5A 197 2004 Freestar (win) Owners Guide (post-2002-fmt) USA - 2004 Ford Freestar | Owner's Manual - Page 198
Roadside Emergencies Fuse/Relay Location 13 Fuse Amp Rating 5A Passenger Compartment Fuse Panel Description Compass/Driver heated seat/Passenger heated seats/Reverse sensing system/Power Liftgate Module/Power sliding door Run feeds Underhood fuse box Run feed, Front blower Run feed Brake On-Off (BOO - 2004 Ford Freestar | Owner's Manual - Page 199
sliding door SJB accessory #2 (driver power window) Auxiliary blower motor Anti-lock Brake System (ABS) #2 (coil power) Power liftgate SJB accessory #1 (passenger window, radio, vent windows) Left power seat/heated seat ABS #1 (pump motor) Rear defroster 199 2004 Freestar (win) Owners Guide (post - 2004 Ford Freestar | Owner's Manual - Page 200
15A* Power Distribution Box Description Front climate control system blower motor Right power seat/heated seat Left-hand power sliding door Powertrain Control Module (PCM) power Horn A/C clutch High beams Starter Fuel pump Not used Not used Auxiliary blower Trailer park lamps Left trailer stop/turn - 2004 Ford Freestar | Owner's Manual - Page 201
wiper motor Rear wiper motor Premium sound radio Cigar lighter SJB #1 - Center High-Mounted Stop Lamp (CHMSL), License plate lamps, OBD II, Dome lamp, Auxiliary blend doors, Switch illumination (feeds F-8, F-9, F-10 and F-11) Radio (non-premium) SJB #4 - Back-up lamps, Theft sounder, Door locks - 2004 Ford Freestar | Owner's Manual - Page 202
Fuse/Relay Fuse Amp Power Distribution Box Description Location Rating 66 20A* 2nd row seat power point 67 20A* Ignition switch #2 fan motor (Vehicles with trailer tow package only) Low-speed cooling fan circuit breaker (Vehicles with trailer tow package only) 202 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 203
the system, refer to Servicing your tires in the Maintenance and specifications chapter. If you use the temporary spare tire continuously or do not follow these precautions, the tire could fail, causing you to lose control of the vehicle, possibly injuring yourself or others. 203 2004 Freestar (win - 2004 Ford Freestar | Owner's Manual - Page 204
provided by Ford. If the dissimilar spare tire or wheel is damaged, it should be replaced rather than repaired. When driving with the dissimilar spare tire/wheel, do not: • Exceed 70 mph (113 km/h) • Use more than one dissimilar spare tire/wheel at a time 204 2004 Freestar (win) Owners Guide (post - 2004 Ford Freestar | Owner's Manual - Page 205
panel located on the right rear quarter panel interior trim. Attached to the jack with a clip. Inside tire tether kit, next to jack. Jack handle Flat tire tether, wing screw and cable tie Jack extension tool (cargo Attached to the jack kit. van model only) 205 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 206
Emergencies Removing the jack and tools 1. Locate the access panel on the interior trim. Rotate the two panel retaining clips and remove the panel. 2. Remove the jack and lug nut cable is slack and tire can be slid rearward. 206 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 207
) retainer by rotating the top portion one-quarter turn and remove it from the outer hole in the tire. • Secondary lock in unlocked position 207 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 208
• Secondary lock in locked position Note: Do not stow the full size tire or any flat tire under the vehicle. Tire change procedure When one 1. Park on a level surface, activate hazard flashers and set parking brake. 208 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 209
with the tapered end of the wheel nut wrench. Insert and twist the handle, then pry against the wheel. 7. Loosen each wheel lug nut one-half turn counterclockwise but do not remove them until the wheel is raised off the ground. 209 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 210
Ford Accessory Running Boards have been installed, use the jack adapters supplied with the running boards as described on the inside of the jack storage area. 8. Locate the jack notch next to the door handle counterclockwise. 210 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 211
in the proper stowage locations. Stowing the full-size tire Failure to follow these instructions may result in personal tether cable kit, by installing it on the luggage back panel and turning the wing screw clockwise. You will hear 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 212
the ground with the valve stem facing in the direction specified on the Tire Changing Instructions located with the jack hardware. 2. Slide the wheel partially under the vehicle and install the wrench until the hex nut ratchets. 212 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 213
turn the jack handle increases significantly and for nut and bolt threads free of dirt and rust. Use only Ford recommended replacement fasteners. When a wheel is installed, always remove any corrosion, dirt control. Bolt size 213 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 214
and remove any excessive corrosion before you attach the battery cables. Ensure that vent caps are tight and level. 5. Turn the heater fan on in both vehicles to protect any electrical surges. Turn all other accessories off. 214 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 215
. Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery. 2. Connect the other end of the positive (+) cable to the positive (+) terminal of the assisting battery. 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - - - + - + + + 215 - 2004 Ford Freestar | Owner's Manual - Page 216
clear of fan blades, belts, moving parts of both engines, or any fuel delivery system parts. Jump starting 1. Start the engine of the booster vehicle and run the engine at moderately increased speed. 2. Start the engine of the disabled vehicle. 216 2004 Freestar (win) Owners Guide (post-2002-fmt - 2004 Ford Freestar | Owner's Manual - Page 217
surface. Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery. 2. Remove the jumper cable on the negative (-) connection of the booster vehicle's battery. 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - - - - + + + + 217 - 2004 Ford Freestar | Owner's Manual - Page 218
the positive (+) terminal of the disabled vehicle's battery. After the disabled vehicle has been started and the jumper cables removed, allow it to idle for several minutes so the engine computer can relearn its idle conditions. 218 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus - 2004 Ford Freestar | Owner's Manual - Page 219
or incorrectly, vehicle damage may occur. Ford Motor Company produces a towing manual for all authorized tow truck operators. Have your tow truck operator refer to this manual for proper hook-up and towing procedures for your vehicle. 219 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English - 2004 Ford Freestar | Owner's Manual - Page 220
Customer Assistance Customer Assistance GETTING THE SERVICES YOU NEED At home You must take your Ford vehicle to an authorized Ford dealer for warranty repairs. While any Ford dealership handling your vehicle line will provide warranty service, we recommend you return to your selling dealer who - 2004 Ford Freestar | Owner's Manual - Page 221
Ford Motor Company of Canada, Limited P.O. Box 2000 Oakville, Ontario L6J 5E4 1-800-565-3673 (FORD) www.ford.ca If you own a Lincoln vehicle and are away from home when your vehicle needs service Dispute Settlement Board (U.S.). 221 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 222
SETTLEMENT BOARD (U.S. ONLY) The Dispute Settlement Board is: • an independent, third-party arbitration program for warranty disputes. • available free to owners and lessees of qualifying Ford Motor Company vehicles. 222 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 223
discontinue this service without notice and without incurring obligations per applicable state law. What kinds of cases does the Board review? Unresolved warranty repair concerns or vehicle performance concerns as on Ford and Lincoln Mercury cars and Ford and Lincoln Mercury light trucks which are - 2004 Ford Freestar | Owner's Manual - Page 224
license. • The date of repair(s) and mileage at the time of occurrence(s). • The current mileage. • The name of the dealer(s) who sold or serviced the vehicle. • A brief description of your unresolved concern. • A brief summary of the action taken by the dealer(s) and Ford Motor Company. • The names - 2004 Ford Freestar | Owner's Manual - Page 225
-related vehicle service concern have been unsatisfactory, Ford of Canada participates in an impartial third party mediation/arbitration program administered by the Canadian Motor Vehicle Arbitration Plan (CAMVAP). The CAMVAP program is a straight-forward and relatively speedy alternative to resolve - 2004 Ford Freestar | Owner's Manual - Page 226
binding both to you and Ford of Canada. CAMVAP services are available in all emission control system and may cause engine knocking or serious engine damage. Ford Motor Company/Ford of Ford Motor Company Worldwide Direct Market Operations. 226 2004 Freestar (win) Owners Guide (post-2002 - 2004 Ford Freestar | Owner's Manual - Page 227
non-conformity likely to cause death or serious bodily injury OR 2. Four or more repair attempts are made on the same nonconformity (a defect or condition that substantially impairs the use, value or safety of the vehicle) OR 227 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 228
366-0123 in the Washington D.C. area) or write to: NHTSA 400 Seventh Street U.S. Department of Transportation Washington, D.C. 20590 You can also obtain other information about motor vehicle safety from the Hotline. 228 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 229
exterior accessories, such as antennas, parts over time. • Do not allow paint sealant to come in contact with the sliding door electrical contact switches. Paint sealant or other contaminants could interfere with the proper operation of the power locks or power 229 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 230
when using a power washer to clean the engine. The high-pressure fluid could penetrate the sealed parts and cause damage. • Do not spray a hot engine with cold water to avoid cracking the engine block or other engine components. 230 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 231
running engine may cause internal damage. PLASTIC (NON-PAINTED) EXTERIOR PARTS Use only approved products to clean plastic parts. These products are available from your dealer. • For routine , as they may cause scratches. 231 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 232
or glass cleaners as these may damage the finish. INTERIOR For fabric, carpets, cloth seats, safety belts and seats equipped with side air bags: • Remove dust and loose dirt with a vacuum cleaner. • Remove light stains and soil with Motorcraft Extra Strength Upholstery Cleaner (ZC-41). • If grease - 2004 Ford Freestar | Owner's Manual - Page 233
. If this occurs, the leather should be cleaned immediately to avoid permanent staining. UNDERBODY Flush the complete underside of your vehicle frequently. Keep body and door drain holes free from packed dirt. 233 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 234
Cleaner (Canada only) (CXC-93) Motorcraft Vinyl Conditioner (Canada only) (CXC-94) Motorcraft Deluxe Leather Cleaner (ZC-38-A) Motorcraft Car Care Kit (ZC-26) Ford Premium Car Wash Concentrate (F2SZ-19523-WC) Motorcraft Carlite Glass 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 235
easy location. • We provide a scheduled maintenance guide which makes tracking routine service easy. If your vehicle requires professional service, your dealership can provide the necessary parts and service. Check your Warranty Guide/Owner Information Guide to find out which parts and services are - 2004 Ford Freestar | Owner's Manual - Page 236
and Specifications OPENING THE HOOD 1. Inside the vehicle, pull the hood release handle located under the bottom left corner of the instrument panel. 2. Go to the front of the vehicle and release the auxiliary latch that is located under the front center of the hood. 3. Lift the hood and secure - 2004 Ford Freestar | Owner's Manual - Page 237
2. Air filter assembly 3. Power distribution box 4. Battery 5. Automatic transmission fluid dipstick 6. Engine oil dipstick 7. Engine oil filler cap 8. Windshield washer fluid reservoir 9. Engine coolant reservoir 10. Power steering fluid reservoir 237 2004 Freestar (win) Owners Guide (post - 2004 Ford Freestar | Owner's Manual - Page 238
use a washer fluid that meets Ford specification WSB-M8B16-A2. Refer to in the cooling system may harm engine and cooling system components. Checking and drain into the oil pan. 3. Set the parking brake and ensure the gearshift is securely latched in P (Park). 238 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 239
yourself from engine heat. 5. Locate and carefully remove the engine oil service technician. 7. Put the indicator back in and ensure it is fully seated. Adding engine oil 1. Check the engine oil. For instructions, refer to Checking the engine oil in this chapter. 239 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 240
and ensure it is fully seated. 5. Fully install the filters are designed for added engine protection and long life. If a replacement oil filter is used that does not meet Ford material and design specifications, start-up engine noises or knock may be experienced. 240 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 241
can cause personal injury. Therefore, do not allow flames, sparks or lighted substances to come near the battery. When working near the battery, always shield your face and protect your eyes. Always provide proper ventilation. 241 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 242
Battery posts, terminals and related accessories contain lead and lead compounds. Wash hands after handling. To account for customer driving habits and conditions, your automatic transaxle electronically controls one minute. 242 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 243
50/50 engine coolant and water concentration. If the concentration of coolant falls below 40% or above 60%, the engine parts could become damaged or not work properly. A 50-50 mixture of coolant and water provides the following: 243 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 244
to the Scheduled Maintenance Guide for service interval schedules. • Be sure to read and understand Precautions when servicing your vehicle in this coolant, antifreeze or windshield washer fluid outside of its specified function and vehicle location. 244 2004 Freestar (win) Owners Guide (post- - 2004 Ford Freestar | Owner's Manual - Page 245
OR only), meeting Ford Specification WSS-M97B51-A1. Note: Use of Motorcraft Cooling System Stop Leak Pellets, VC-6, , to reach a vehicle service location. In this instance, the cooling system must be drained and refilled with a 50 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 246
) of engine coolant per month, have your dealer check the engine cooling system. Your cooling system may have a leak. Operating an engine with a low level of coolant can result in engine overheating and possible engine damage. 246 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 247
Ford Motor Company does NOT recommend the use of recycled engine coolant in vehicles originally equipped with Motorcraft Premium Gold Engine Coolant since a Ford much fluid your vehicle's cooling system can hold, refer to Refill 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English ( - 2004 Ford Freestar | Owner's Manual - Page 248
when handling automotive fuel: • Extinguish all smoking materials and any open flames before fueling your vehicle. • Always turn off the vehicle before fueling. • Automotive fuels can be harmful or fatal if swallowed. Fuel such as gasoline is highly toxic and if 248 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 249
the filler neck. Never smoke while refueling. Fuel vapor is extremely hazardous under certain conditions. Care should be taken to avoid inhaling excess fumes. The flow of fuel through with the fuel container while filling. 249 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 250
. The use of leaded fuel is prohibited by law and could damage your vehicle. Do not use fuel containing methanol. It can damage critical fuel system components. 250 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 251
provide improved performance and emission control system protection for your vehicle. Gasolines that meet the World-wide Fuel Charter should be used when available. Ask your fuel supplier about gasolines that meet the World-wide Fuel Charter. 251 2004 Freestar (win) Owners Guide (post-2002-fmt) USA - 2004 Ford Freestar | Owner's Manual - Page 252
guide for the appropriate intervals for changing the fuel filter. Replace the fuel filter with an authorized Motorcraft part. The customer warranty may be void for any damage to the fuel system if an authorized Motorcraft fuel filter 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 253
traveled. Calculation 2: Divide total miles traveled by total gallons used. Keep a record for at least one month and record the type of driving (city or highway). This will provide an accurate estimate of the vehicle's fuel 253 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 254
• Keep tires properly inflated and use only recommended size. • Operating a vehicle with the wheels out of alignment will reduce fuel economy. • Use recommended engine oil. Refer to Lubricant specifications in this chapter. 254 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 255
to comply with applicable exhaust emission standards. To make sure that the catalytic converter and other emission control components continue to work properly: • Use only the specified fuel listed. • Avoid running out of fuel. 255 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 256
vehicle and to its emissions system. If other than Ford, Motorcraft or Ford-authorized parts are used for maintenance replacements or for service of components affecting emission control, such non-Ford parts should be equivalent to genuine Ford Motor Company parts in performance and durability. Do - 2004 Ford Freestar | Owner's Manual - Page 257
Service engine soon light on. If the vehicle's powertrain system or its battery has just been serviced, the on-board diagnostics system is reset to a "not ready for I/M test" condition. To ready the on-board diagnostics system . 257 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 258
and "MAX" lines are within the normal operating range, there is no need to add fluid. If the fluid levels are outside of the normal operating range, the performance of your brake system could be compromised, seek service from your dealer immediately. 258 2004 Freestar (win) Owners Guide (post-2002 - 2004 Ford Freestar | Owner's Manual - Page 259
ranges. Allow sufficient time for each gear to engage. 4. Latch the gearshift lever in P (Park) and leave the engine chapter for the location of the dipstick. 6. Install the dipstick making sure it is fully seated in the filler 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 260
be caused by an overheating condition. Adjusting automatic transmission fluid levels Before adding any fluid, make sure the correct type is used. The type of fluid used is normally and maximum section width. For example: 260 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 261
under controlled conditions on a specified indoor laboratory test wheel. Sustained high temperature can cause the material of the tire to degenerate and reduce tire life, and excessive temperature can lead to sudden tire failure. The grade C corresponds to a level of performance 261 2004 Freestar - 2004 Ford Freestar | Owner's Manual - Page 262
the pressure on one or more tires (note: tire pressures are often adjusted during oil change service) • Inflating a low tire will not clear the Low Tire Warning indicator light. Only resetting the system will clear the light. 262 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 263
light will flash three times as the low tire warning system begins to initialize. The system High - above 62 mph (100 km/h) This system may not function properly under the following conditions: • Uneven tread wear. • Driving on loose 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 264
a heavy load or towing a trailer. • A different tire was replaced and was not the same brand, type, size, speed rating, load carrying capacity and DOT code as the other tire on the same axle. • System was not reset after tire rotation, air pressure adjustment, a tire change, wheel alignment or tire - 2004 Ford Freestar | Owner's Manual - Page 265
wheel size, you will have to purchase new tires to match the new wheel diameter. 6. 95: Indicates the tire's load index. It is an index that relates to how much weight a tire can carry. You may find this information in your owner's guide. If not, contact a local tire dealer. 265 2004 Freestar (win - 2004 Ford Freestar | Owner's Manual - Page 266
a standard condition of load and inflation pressure. The tires on your vehicle may operate at different conditions for load it was manufactured, the next two are the tire size code and the last four numbers represent the week and 266 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 267
under controlled conditions on door. The cold inflation pressure should never be set lower than the recommended pressure on the vehicle label. The tire suppliers may have additional markings, notes or warnings such as standard load, radial tubeless, etc. 267 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 268
maximum load and tire pressure when the tire is used as a single; a single is defined as when two tires (total) are put on the rear axle. 268 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 269
by tire size and other important information located on the B-Pillar or the driver's door. TIRE CARE service station gauges may be inaccurate. Ford recommends the use of a digital or dial type tire pressure gauge rather than a stick type tire pressure gauge. 269 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 270
Replace the valve cap. 5. Repeat this procedure for each tire, including the spare. Note: Some spare tires require higher inflation pressure than the other tires. Check the tire label on the B pillar or the driver's door for the recommended spare tire pressure. 270 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 271
an air leak. 7. Check the sidewalls to make sure there are no gouges, cuts or bulges. Tire and wheel alignment A bad should be corrected by a qualified technician at a Ford or Lincoln/Mercury dealer. Front wheel drive (FWD as indicated in the Scheduled Maintenance Guide that comes with your vehicle) - 2004 Ford Freestar | Owner's Manual - Page 272
Maintenance and Specifications • Front Wheel Drive (FWD) vehicles (front tires at top of diagram) 272 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 273
can reduce the ability of tread to grip the road in adverse (wet, snowy, etc.) conditions. Visually check your tires for uneven wear, looking for high and low areas or unusually smooth areas. Also check for signs of tire damage. 273 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 274
the use of non-recommended tires and wheels could cause steering, suspension, axle or transfer case/power transfer unit failure. If you have questions regarding tire replacement, see an authorized Ford or Lincoln/Mercury dealer. 274 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 275
under-inflated or damaged, deflate it, remove wheel and replace it with your spare tire and wheel. If you cannot detect a cause, have the vehicle towed to the nearest repair facility or tire dealer to have the vehicle inspected. 275 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 276
conditions creates the possibility of loss of vehicle control. Driving at very high speeds for extended periods of time may result in damage to vehicle components. Snow tires must be the same size using snow tires and chains. 276 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 277
such as Motorcraft or equivalent replacement parts. The customer warranty may be void for any damage to the engine if such spark plugs are not used. Refer to Vehicle Emissions Control Information (VECI) decal for spark plug gap information. 277 2004 Freestar (win) Owners Guide (post-2002-fmt) USA - 2004 Ford Freestar | Owner's Manual - Page 278
can be used. 2 Add the coolant type originally equipped in your vehicle. 278 Without rear 14.0L (14.8 heater quarts) With rear heater 15.0L (15.9 quarts) All Fill to line on reservoir All 98.4L (26.0 gallons) All 13.0L (13.7 quarts) 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus - 2004 Ford Freestar | Owner's Manual - Page 279
Premium Gold Engine Coolant (yellow colored) Motorcraft SAE 5W20 Premium Synthetic Blend Motor Oil (US) Motorcraft SAE 5W-20 Super Premium Motor Oil (Canada) Ford part number PM-1 Ford specification ESA-M6C25-A and DOT 3 3 Door weatherstrips Engine coolant XL-6 VC-7-A (U.S., except CA and OR), VC - 2004 Ford Freestar | Owner's Manual - Page 280
Maintenance and Specifications Ford part name Door latch, hood Multi-Purpose latch, auxiliary Grease hood latch, door and liftgate hinges, striker plates, seat tracks, sliding door both sides (upper and lower track) and fuel filler door hinge. Lock cylinders Penetrating and Lock Lubricant Power - 2004 Ford Freestar | Owner's Manual - Page 281
only brake fluids certified to meet Ford specifications. DOT 3 fluid is recommended Guide to determine the correct service interval. ENGINE DATA Engine Cubic inches Required fuel Firing order Ignition system P235/60R16 tires. 281 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 282
Maintenance and Specifications 4 1 282 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 283
label may be located. The Certification label is located on the front door latch pillar on the located on the driver side instrument panel. (Please note that in the graphic XXXX is representative of your vehicle identification number.) XXXXXXXXXXXXXXXXX 283 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 284
manufacturer identifier 2. Brake type and gross vehicle weight rating (GVWR) 3. Vehicle line, series, body type 4. Engine type 5. Check digit 6. is located on the door pillar. The following table tells you which transmission or transaxle each code represents. 284 2004 Freestar (win) Owners Guide ( - 2004 Ford Freestar | Owner's Manual - Page 285
J L P X Y 5 Transmission/Transaxle Description Front wheel drive manual transaxle 5-speed overdrive (MTX75) 5-speed overdrive (M5) Front wheel ) 4-speed overdrive (CD4E) Rear wheel drive manual transaxle 5-speed (Mazda M5) 285 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 286
Maintenance and Specifications Code U A Transmission/Transaxle Description Rear wheel drive automatic transmission 4-speed overdrive (4R70W) 5-speed overdrive (5R55N) 286 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 287
is made from high quality materials and meets or exceeds Ford's rigorous engineering and safety specifications. Ford Motor Company will repair or replace any properly dealer-installed Genuine Ford Accessory found to be defective in factory-supplied materials or workmanship during the warranty - 2004 Ford Freestar | Owner's Manual - Page 288
FCC or CRTC regulations and should be installed only by a qualified service technician. • Mobile communications systems may harm the operation of your vehicle, particularly if they are not properly designed for automotive use. 288 2004 Freestar (win) Owners Guide (post-2002-fmt) USA English (fus) - 2004 Ford Freestar | Owner's Manual - Page 289
64 Axle lubricant specifications ...279 B Battery ...241 acid, treating emergencies ...241 jumping a disabled battery ...214 maintenance-free ...241 replacement, specifications ...277 servicing ...241 BeltMinder ...140 Brakes ...175 anti-lock ...175 anti-lock brake system (ABS) warning light ...175 - 2004 Ford Freestar | Owner's Manual - Page 290
56 Controls power seat ...109 steering column ...71 Coolant checking and adding ...243 refill capacities ...247, 278 specifications ...279, 281 Cruise control (see Speed control) ...68 Cupholder(s) ...112 Customer Assistance ...193 Ford accessories for your vehicle ...234 Ford Extended Service Plan - 2004 Ford Freestar | Owner's Manual - Page 291
lights ...44 flash to pass ...45 high beam ...44 replacing bulbs ...50 turning on and off ...43 Heating heating and air conditioning system ...33, 35 HomeLink universal transceiver (see Garage door opener) ...76 Homelink wireless control system ...73 Hood ...236 I Ignition ...171, 281 Infant seats - 2004 Ford Freestar | Owner's Manual - Page 292
47 Liftgate ...85, 89, 95 Lights, warning and indicator ...10 anti-lock brakes (ABS) ...175 Load limits ...184 Locks autolock ...99 childproof ...92 doors ...91 Low tire warning ...15, 262 Lubricant specifications ...279, 281 Luggage rack ...89 Lumbar support, seats ...111 M Message center ...76-77 - 2004 Ford Freestar | Owner's Manual - Page 293
for children ...160 Seat belts (see Safety restraints) ...131 Seats ...108 child safety seats ...160 front seats ...108-111 memory seat ...100, 111 second row seats ...113-114, 117 third row seats ...117, 124, 128-129 SecuriLock passive anti-theft system ...105 Servicing your vehicle ...235 Spare - 2004 Ford Freestar | Owner's Manual - Page 294
Lights) ...10 Washer fluid ...238 Water, Driving through ...184 Windows power ...65 rear wiper/washer ...54 Windshield washer fluid and wipers ...54 checking and adding fluid ...238 liftgate reservoir ...238 replacing wiper blades ...55 Wrecker towing ...219 294 2004 Freestar (win) Owners Guide - 2004 Ford Freestar | Owner's Manual - Page 295
295 - 2004 Ford Freestar | Owner's Manual - Page 296
296
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
-
101
-
102
-
103
-
104
-
105
-
106
-
107
-
108
-
109
-
110
-
111
-
112
-
113
-
114
-
115
-
116
-
117
-
118
-
119
-
120
-
121
-
122
-
123
-
124
-
125
-
126
-
127
-
128
-
129
-
130
-
131
-
132
-
133
-
134
-
135
-
136
-
137
-
138
-
139
-
140
-
141
-
142
-
143
-
144
-
145
-
146
-
147
-
148
-
149
-
150
-
151
-
152
-
153
-
154
-
155
-
156
-
157
-
158
-
159
-
160
-
161
-
162
-
163
-
164
-
165
-
166
-
167
-
168
-
169
-
170
-
171
-
172
-
173
-
174
-
175
-
176
-
177
-
178
-
179
-
180
-
181
-
182
-
183
-
184
-
185
-
186
-
187
-
188
-
189
-
190
-
191
-
192
-
193
-
194
-
195
-
196
-
197
-
198
-
199
-
200
-
201
-
202
-
203
-
204
-
205
-
206
-
207
-
208
-
209
-
210
-
211
-
212
-
213
-
214
-
215
-
216
-
217
-
218
-
219
-
220
-
221
-
222
-
223
-
224
-
225
-
226
-
227
-
228
-
229
-
230
-
231
-
232
-
233
-
234
-
235
-
236
-
237
-
238
-
239
-
240
-
241
-
242
-
243
-
244
-
245
-
246
-
247
-
248
-
249
-
250
-
251
-
252
-
253
-
254
-
255
-
256
-
257
-
258
-
259
-
260
-
261
-
262
-
263
-
264
-
265
-
266
-
267
-
268
-
269
-
270
-
271
-
272
-
273
-
274
-
275
-
276
-
277
-
278
-
279
-
280
-
281
-
282
-
283
-
284
-
285
-
286
-
287
-
288
-
289
-
290
-
291
-
292
-
293
-
294
-
295
-
296
 |
 |
Introduction
4
Instrument Cluster
10
Warning and control lights
10
Gauges
15
Entertainment Systems
18
AM/FM stereo
18
AM/FM stereo with CD
20
AM/FM stereo with in-dash six CD
23
AM/FM stereo cassette with CD
26
Climate Controls
33
Manual heating and air conditioning
33
Rear window defroster
42
Lights
43
Headlamps
43
Turn signal control
47
Bulb replacement
49
Driver Controls
54
Windshield wiper/washer control
54
Steering wheel adjustment
55
Power windows
65
Mirrors
66
Speed control
68
Message center
76
Locks and Security
91
Keys
91
Locks
91
Anti-theft system
94
Table of Contents
1