2007 Ford Freestar Owner Guide 2nd Printing
2007 Ford Freestar Manual
2007 Ford Freestar manual content summary:
- 2007 Ford Freestar | Owner Guide 2nd Printing - Page 1
with CD stereo with in-dash six CD 19 19 21 24 27 Climate Controls Manual heating and air conditioning Rear window defroster 35 35 44 Lights Headlamps Turn signal control Bulb replacement 45 45 49 51 Driver Controls Windshield wiper/washer control Steering wheel adjustment Power windows - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 2
Table of Contents Seating and Safety Restraints Seating Safety restraints Airbags Child restraints 113 113 138 247 247 252 Customer Assistance Reporting safety defects (U.S. only) Reporting safety defects (Canada only) 253 260 260 Cleaning 261 2 2007 Freestar (win) Owners Guide (post-2002-fmt - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 3
Table of Contents Maintenance and Specifications Engine compartment Engine oil Battery Engine coolant Fuel information Air filter(s) Part numbers Maintenance product specifications and capacities Engine data 268 270 272 275 278 283 297 302 303 305 Accessories Index 308 310 All rights reserved. - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 4
other reproductive harm. PERCHLORATE MATERIAL Certain components of this vehicle such as air bag modules, seat belt pretensioners, and button cell batteries may contain Perchlorate Material - Special handling may apply for service or vehicle end of life disposal. See www.dtsc.ca.gov/hazardouswaste - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 5
ring seating. See Engine oil in the Maintenance and Specifications chapter for more information on oil usage. SPECIAL NOTICES New Vehicle Limited Warranty For a detailed description of what is covered and what is not covered by your vehicle's New Vehicle Limited Warranty, refer to the Warranty Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 6
not the driver and passenger seatbelts were buckled; • how far (if at all) the driver was depressing the accelerator and/or the brake pedal; • how fast the vehicle was traveling; and • where the driver was positioning the steering wheel. 6 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 7
. Driving while distracted can result in loss of vehicle control, accident and injury. Ford strongly recommends that drivers use extreme caution when using any Refer to this Owner's Guide for all other required information and warnings. 7 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 8
Child Seat Lower Anchor Brake System Brake Fluid Non-Petroleum Based Speed Control Powertrain Malfunction Master Lighting Switch Hazard Warning Flasher Fog Lamps-Front Fuse Compartment Fuel Pump Reset Windshield Defrost/Demist Windshield Wash/Wipe Rear Window Defrost/Demist 8 2007 Freestar - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 9
, Flames, or Sparks Explosive Gas Battery Acid Fan Warning Maintain Correct Fluid Level Engine Air Filter Jack MAX MIN Power Steering Fluid Emission System Passenger Compartment Air Filter Check Fuel Cap Low Tire Pressure Warning 9 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 10
problem exists with one of your vehicle's functions. Many lights will illuminate when you start your vehicle to make sure the bulb works. If any light remains on after starting the vehicle, refer to the respective system warning light for additional information. 10 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 11
warning light does not illuminate at this time, seek service immediately from your authorized dealer. Illumination after releasing the parking brake indicates low brake fluid level and the brake system should be inspected immediately by your authorized dealer. 11 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 12
as possible. Charging system: Illuminates when the battery is not charging properly. Engine oil pressure: Illuminates when the oil pressure falls below the normal range, refer to Engine oil in the Maintenance and Specifications chapter. 12 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 13
checked. Refer to Inflating Your Tires in the Tires, Wheels and Loading chapter. When the ignition is first turned to ON, the light will illuminate for 3 seconds to ensure the bulb is working. If the light Center • With Message Center 13 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 14
• With Message Center Displays which door or the liftgate is open. Turn signal: Illuminates when the left or right turn signal or the hazard lights are turned on. If the indicators stay on or flash faster, check for a burned out bulb. 14 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 15
the key is not in the ignition) and the driver's door is opened. Turn signal warning chime: Sounds when the turn signal lever has been activated to signal a turn and not turned off after the vehicle is driven more than 2 miles (3.2 km). 15 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 16
and "C"). If it enters the red section, the engine is overheating. Stop the vehicle as soon as safely possible, switch off the engine and let the engine cool. Never remove the coolant reservoir cap while the engine is running or hot. 16 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 17
. The temperature display in the overhead console (if equipped) will also be changed. • With Message Center Refer to Message Center in the Driver Controls chapter on how to switch the display RESET button for three seconds to reset. 17 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 18
continuously at the top of the scale may damage the engine. Fuel gauge: Indicates approximately how much fuel is left the fuel filler door is located. Refer to Filling the tank in the Maintenance and Specifications chapter for more information. 18 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 19
to 1. manually go up or down the radio frequency. Also use in menu mode to select various settings. 2. Audio: Press to audio between the left and right speakers. / / SEEK . Use Fade: Press to adjust the audio between the front and rear speakers. / / SEEK . Use 19 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 20
to flash. / to manually decrease / increase the hours. Press CLK Press again to set the minutes. When this audio is used in cargo vans where no rear speakers are installed in the vehicle, fading to the rear speakers will result in no audio output. 20 2007 Freestar (win) Owners Guide (post-2002-fmt - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 21
the following modes: Autoset: Allows you to set the strongest local radio stations without losing your original manually set preset stations for AM/FM1/FM2 . Press / / SEEK to set. MENU to access adjust the bass setting. Use / / SEEK . 21 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 22
dash clock, refer to Clock in the Driver Controls chapter for instructions on how to set the time. 4. Aux: Press to toggle between FES/DVD and AUX modes. If no auxiliary sources are available, NO AUX AUDIO to repeat the current CD track. 22 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 23
manually advance in a CD track. 11. Rewind: Press to manually back on. 17. CD: Press to enter CD mode. If a CD is already loaded into the system, CD play will begin where it ended last. 18. CD eject: Press to eject a CD. 19. CD slot: Insert a CD label side up. 23 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 24
CD sound system (if equipped) / Tuner: Press to 1. manually go up or down the radio frequency. Also use in menu to adjust the bass setting. Use Balance: Press to adjust the audio between the left and right speakers. / / SEEK . Use 24 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 25
, NO AUX AUDIO will be displayed. To return to radio mode, press AM/FM. 6. Tape eject: Press to eject a tape. 7. Text: In CD mode, displays track title, artist name, and disc title (if available). 8. Shuffle: Press to play CD tracks in random order. 25 2007 Freestar (win) Owners Guide (post - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 26
is turned off, the volume will come back on at a "nominal" listening level when the ignition switch is turned back on. 18. CD: Press to enter CD mode. If a CD is already loaded into the system, CD play will begin where it ended last. 26 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 27
or CD tracks. Press again to stop. When this radio is used in cargo vans where no rear speakers are installed in the vehicle, fading to the rear speakers will result in no audio output. Premium In-Dash Six CD Sound System (if equipped) 27 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 28
/minutes. displayed. Press If your vehicle is equipped with an in-dash clock, refer to Clock in the Driver Controls chapter for instructions on how to set the time. Autoset: Allows you to set store the last one in the remaining presets. 28 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 29
between FES/DVD and AUX modes. If no auxiliary sources are available, NO AUX AUDIO will be displayed. CD track. 10. Fast forward: Press to manually advance in a CD track. 11. Rewind: Press to manually reverse in a CD track. 12. Memory presets 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 30
auxiliary audio controls. This feature allows the front and middle seat passengers to listen to different media sources (radio, cassette, CD or DVD) simultaneously. (However, the front and middle-seat passengers cannot listen to two different radio stations at the same time.) 30 2007 Freestar (win - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 31
and MEMORY controls to make adjustments to the playing media. Parental control Simultaneously press the radio preset controls 3 and 5 to enable/disable the rear seat audio controls as well as the Family Entertainment system (if equipped). COMPRESS 31 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 32
, electric fences, traffic lights and thunderstorms can interfere with your reception. • Station overload: When you pass a broadcast tower, a stronger signal may overtake a weaker one and play while the weak station frequency is displayed. 32 2007 Freestar (win) Owners Guide (post-2002-fmt) USA - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 33
periods of time. • For vehicles equipped with a six disc CD changer, don't insert more than one disc into each slot of the CD changer magazine. • Clean using a circular motion. 33 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 34
system warranty information. If service is necessary, see your dealer or qualified technician. FAMILY ENTERTAINMENT SYSTEM (IF EQUIPPED) Your vehicle may be equipped with a Family Entertainment System (FES). Refer to the DVD Supplement Guide for further information on your system. 34 2007 Freestar - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 35
A/C: Press to activate/deactivate air conditioning. Use with recirculated air to improve cooling performance and efficiency. Engages automatically in MAX A/C, and . 6. Fan speed adjustment: Controls the volume of air circulated in the vehicle. 35 2007 Freestar (win) Owners Guide (post-2002-fmt) USA - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 36
airflow temperature with the front control. The rear cabin airflow temperature will match the driver airflow temperature setting when only the center rear temperature REAR ) is illuminated. The rear cabin airflow temperature light ( 36 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 37
that will interfere with the airflow to the back seats. • Remove any snow, ice or leaves from the air intake area at the base of the windshield. • For maximum cooling performance (MAX A/C): In the MAX A/C mode: • Move the temperature control selector to the coldest setting. • Set the fan to the - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 38
control to full heat. 4. Set the fan speed to the highest setting. 5. Direct the outer instrument panel vents towards the side windows. Do not place objects on top of the instrument panel as these objects may become projectiles in a collision or sudden stop. . 38 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 39
later in this chapter for more information. Rear fan speed control: Press to enable the auxiliary system 5. R or to adjust the rear fan speed from the front control. The rear fan speed settings available are 4, 3, 2, 1 and O (OFF). 39 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 40
airflow location, A/C on or off, and outside or recirculated air, to heat or cool the vehicle to reach the desired temperature. 17. REAR: Press to enable the control located in the rear seat. Press again to turn the auxiliary system off. 40 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 41
2, 1 and O (OFF). Passenger heated seat control: Press once to activate the high 6. heat setting (2 indicator lights). Press again to activate the low heat setting (1 indicator light). Press again to deactivate the passenger heated seat. 41 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 42
airflow location, A/C on or off, and outside or recirculated air, to heat or cool the vehicle to reach the desired temperature. 19. REAR: Press to enable the control located in the rear seat. Press again to turn the auxiliary system off. 42 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 43
the airflow to the back seats. • Remove any snow, ice or leaves from the air intake area at the base of the windshield. • For maximum cooling performance (MAX A/C): In AUTO mode, press AUTO control and set to desired temperature. or , A/C and recirculated In manual override control, select and set - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 44
sharp objects to clean the inside of the rear window or to remove decals from the inside of the rear window. This may cause damage to the heated grid lines and will not be covered by your warranty. CABIN AIR FILTER Your vehicle is equipped with a cabin air filter. The cabin air filter restricts the - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 45
Lights HEADLAMP CONTROL Turns the lamps off. Turns on the parking lamps, instrument panel lamps, license plate lamps and tail lamps. Turns the headlamps on. P Note: Some vehicles may be equipped with a headlamps on with wipers feature. In order for this feature to work: • the ignition must be in - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 46
Lights To program the auto lamp exit time delay: 1. Start with the ignition in the OFF position and the headlamp control in the autolamp the headlamp control is in the OFF, parking lamps or autolamp position, • and the transmission must be out of PARK. 46 2007 Freestar (win) Owners Guide (post - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 47
does not activate your tail lamps and generally may not provide adequate lighting during these conditions. Failure to activate your headlamps under these conditions may result in a collision. Battery saver The battery saver will shut off the exterior lamps and interior lamps, except the hazard - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 48
open the hood. 4. On the wall or screen you will observe a light pattern with high intensity flat segments at the top edge of the pattern. If the flat edges are not at the horizontal reference line, the beam will need to be adjusted. 48 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 49
the driver intends to turn. INTERIOR LAMPS The interior lights illuminate when: • any door is opened (and the operation switch is in the remote entry controls are pressed and the ignition is OFF (and the operation switch is in the middle position). 49 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 50
the panel dimmer control is moved to the passenger side position. When the control is in the middle position, the lamp will only come on when a door is opened. If the control is moved to the driver's side position, the lamp will not come on at all. 50 2007 Freestar (win) Owners Guide (post-2002-fmt - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 51
moist air enters the headlamp(s) through the vents, there is a possibility that condensation can occur. This condensation is normal and will clear within 45 minutes of headlamp operation. Replacing exterior bulbs Check the operation of all the bulbs frequently. 51 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 52
lamp T-562 Front seat footwell 194 Front door mounted courtesy lamp 168 Visor vanity lamp - Slide on Rail system (SOR) 37 All replacement bulbs are clear in color except where noted. To replace all instrument panel lights - see your authorized dealer. 52 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 53
the hood. 2. Remove the two headlamp retaining pins to release the headlamp assembly, then pull the headlamp assembly forward to expose the bulb socket. 53 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 54
Lights 3. To remove the side marker bulb, turn the bulb socket counterclockwise, and pull the bulb straight out of the new bulb(s) in reverse order. Replacing high-mount brakelamp bulbs For bulb replacement, see your authorized dealer. 54 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 55
Lights Replacing license plate lamp bulb The license plate bulbs are located in the license plate housing assembly on the liftgate. To change the license plate bulbs: 1. Make sure the headlamp switch is in the OFF position. 2. Remove the license lamp screw from the assembly. 3. Pull the lamp down - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 56
is empty. This may cause the washer pump to overheat. Check the washer fluid level frequently. Do not operate the wipers when the windshield position. control to either From either position, the control will automatically return to the INT2 or OFF position. 56 2007 Freestar (win) Owners Guide (post - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 57
until you find the desired location. 3. Release the steering wheel release control. This will lock the steering wheel in position. Never adjust the the visor back into the headliner, visor must be retracted before moving it back towards the windshield. 57 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 58
or ACCESSORY position. If the outside temperature falls below 3°C (38°F), the display will alternate from "ICE" to the outside temperature at a two second rate for one minute. Compass The vehicle heading is displayed as one of N, NE, E, SE, S, SW, W and NW. 58 2007 Freestar (win) Owners Guide (post - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 59
Driver Controls The compass reading may be affected when you drive near large buildings, bridges, power lines and powerful broadcast for 5 seconds, the compass writes the displayed zone VAR number to memory and exits Zone Variation Mode 59 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 60
of travel, firmly push the door against the bump stop to engage the hold open mechanism to restrain the door. When operating the door on a gradient, special care should be taken to manually control the opening and closing speed of the door. 60 2007 Freestar (win) Owners Guide (post-2002-fmt) USA - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 61
damage to the door. If the vehicle is parked on a downhill grade, the door could slam shut and could result in injury or damage to the door. Ensure that the open door is secure against the stop before allowing passengers to enter or exit the vehicle. 61 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 62
or pinched in an uncontrolled sliding door. To power open or close the PSD from the Overhead console: Push and release the overhead console right or left hand control. Pressing this control will also simultaneously unlock all doors. 62 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 63
, the door(s) can be opened manually with the inside or outside handles. With the Power Door Lockout control in the OFF position, the overhead console right and left hand controls and the Remote Entry System remain functional. Disabling the PSD may be 63 2007 Freestar (win) Owners Guide (post - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 64
door by pressing the PSD control on the overhead console. 5. Wait five (5) seconds and repeat Steps 3 and 4 then go on to Step 6. 6. Repeat Steps 3-5 for opposite door. If the door still does not operate correctly: 7. Ensure the ignition is in the OFF position 64 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 65
CENTER CONSOLE (IF EQUIPPED) Your vehicle may be equipped with a utility compartment. INSTRUMENT PANEL STORAGE COMPARTMENT The storage compartment may be used to secure sunglasses or similar sized objects. Press the control to open the storage compartment. 65 2007 Freestar (win) Owners Guide (post - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 66
or accessory bracket from the plug. Improper use of the power outlet can cause damage not covered by your warranty. Do not use the power point for operating the cigarette lighter element (if equipped). To prevent the fuse from being blown, do not use the power point(s) over the vehicle capacity of - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 67
Controls • Located next to the second row seat. • Located on the right trim panel in the rear cargo area. Cigar/Cigarette lighter (if equipped) Do not plug optional electrical accessories damage not covered by your warranty. POWER WINDOWS 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 68
to open fully without holding the control down. Push the switch completely down accessory delay, the window switches and radio may be used for up to ten minutes after the ignition switch is turned to the OFF position or until either front door 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 69
: 1. Rotate the control clockwise to adjust the right mirror and rotate the control counterclockwise to adjust the left mirror. 2. Move the control in the direction you wish to tilt the mirror. 3. Return to the center position to lock mirrors in place. 69 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 70
Driver Controls Heated door is open, the indicator in the appropriate mirror will flash indicating people may be entering/exiting the vehicle. Fold-away mirrors Fold the side mirrors in carefully when driving through a narrow space, like an automatic car wash. 70 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 71
and hold the rocker control to adjust accelerator and brake pedal toward you or control The controls for using your speed control are located on the steering wheel for your convenience. 1. Press the ON control and release it. 2. Accelerate to the desired speed. 71 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 72
until you get to the desired speed, then release the control. You can also use the SET + control to operate the Tap-Up function. Press and release this control to increase the vehicle set speed in small amounts by 1 mph (1.6 km/h). 72 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 73
off the speed control: • Depress the brake pedal. This will not erase your vehicle's previously set speed. • Press the speed control OFF control. Note: When you turn off the speed control or the ignition, your speed control set speed memory is erased. 73 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 74
Press MUTE to mute the volume. HOMELINKா WIRELESS CONTROL SYSTEM (IF EQUIPPED) The HomeLink Wireless Control System, located on the driver's visor, provides garage doors, entry gate operators, security systems, entry door locks, and home or office lighting. 74 2007 Freestar (win) Owners Guide ( - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 75
end of your hand-held transmitter 1-3 inches (2-8 cm) away from the HomeLink button you wish to program (located on your visor) while keeping the indicator light in view. 75 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 76
Controls 3. Simultaneously press and hold both the chosen HomeLink and hand-held transmitter buttons until the HomeLink indicator light changes from a slow to a rapidly blinking light. Now you may release both the HomeLink and hand-held transmitter buttons. Note: Some entry gates and garage door - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 77
, entry door lock, or home or office lighting etc.). For convenience, the hand-held transmitter of the device may also be used at any time. In the event that there are still programming difficulties, contact HomeLink at www.homelink.com or 1-800-355-3515. 77 2007 Freestar (win) Owners Guide (post - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 78
release the button. 2. The indicator light will begin to flash after 20 problems with a display of system warnings followed by an indicator chime. Selectable features Reset Press this control to select and reset functions shown in the INFO menu and SETUP menu. 78 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 79
This control remaining in your tank under normal driving conditions. Remember to turn the ignition OFF when is reinitialized to a factory default value if the battery is disconnected. Average Fuel Economy (AFE) Select service stations 79 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 80
Select this function from the INFO menu to turn the upper two lines of the message center display OFF or ON. Setup menu Press this control for the following displays: • Language • Units (English/Metric) • System Check INFO SETUP RESET 80 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 81
check Selecting this function from the SETUP menu causes the message center to cycle through each of the systems being monitored. For each of the monitored systems, the message center will indicate a warning message for three seconds when there is a malfunction. 81 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 82
. • They will not reappear until an ignition OFF-ON cycle has been completed. • Warning returns upon another event. This acts as a reminder that these warning conditions still exist within the vehicle. 82 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 83
left park lamp Check right park lamp Check left headlamp Check right headlamp Check left turn lamp Washer fluid low Check right turn lamp Low fuel level Change oil soon Low tire pressure Tire pressure monitor fault Tire pressure sensor fault Check brake lamps DRIVER'S DOOR AJAR. Displayed when the - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 84
life left reaches 0%, the OIL CHANGE REQUIRED message will be displayed. An oil change is required whenever indicated by the message center. USE ONLY RECOMMENDED ENGINE OILS. 84 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 85
". 4. Press and hold the RESET control to display "OIL LIFE SET TO 100%". Your oil life is now reset. To reset the oil monitoring system to your personalized oil life %: 1. Press the SETUP control to access the System Check function. 85 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 86
• Fuel Computer • Oil life • Charging system • Door sensor • Liftgate sensor • Exterior lamps • Traction control • Washer fluid • Brake Fluid Contact your authorized dealer as soon as possible if these messages occur on a regular basis. 86 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 87
is closed to prevent exhaust fumes from being drawn into the vehicle. This will also prevent passengers and cargo from falling out. If you must drive with the liftgate door open, keep the vents open so outside air comes into the vehicle. 87 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 88
controls. • overhead console button • remote entry transmitter button • outside release handle • liftgate trim-mounted switch (closing) Opening and Closing the PLG: The PLG controls to a wall/garage door. The PLG could be damaged from the contact. Do not attempt to manually force the PLG to travel - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 89
seconds to close the PLG and turn off the interior lights. Refer to Remote Entry System in the Locks and Security chapter. To power open the PLG with outside release handle: 1. Ensure that the Power Door Lockout Control in the overhead console is ON. 2. Ensure that the PLG is unlocked, using the - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 90
. Resetting the PLG: The power liftgate may not operate properly if any of the following conditions occur: • a low voltage or dead battery • disconnected battery • the liftgate has been left open or unlatched for more than six (6) hours 90 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 91
pouch net secures lightweight objects in the cargo area. Attach the net to the anchors provided. Do not put more than 50 lbs. (22 kg) in the net. The cargo net is not designed to restrain objects during a collision or heavy braking. 91 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 92
Driver Controls Utility hooks The utility hooks can be used to hang small items. Do not hang more than 20 lb. (12 are adjustable). 2. Slide the cross-bar to the desired location. 3. Tighten the thumbwheel at both ends of the cross-bar. 92 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 93
Driver Controls To remove the cross-bar assembly (if equipped): 1. Remove rear support covers from the rear rails. Place a small object into the pin holes and slide the cover out towards the rear slide the crossbar out simultaneously. 93 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 94
cross-bar. 3. Install both support covers by sliding the covers back into the channel and pushing gently into place. Note: When the cross-bars are not in use, remove or move the cross-bars to the back of the roof rack for optimum wind noise. 94 2007 Freestar (win) Owners Guide (post-2002-fmt) USA - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 95
), or using the lock button on the remote entry transmitter (if equipped). Unlocking the liftgate during a battery failure In the event of a vehicle power failure affecting the liftgate latch, the liftgate can be unlocked manually. 95 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 96
This feature automatically locks all vehicle doors when: • all doors are closed, • the ignition is in the 4 (ON) position, • the brake is pressed before reaching 5 mph (8 km/h), and • the vehicle increases to more than 5 mph (8 km/h). 96 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 97
taken place, • the brake is depressed while vehicle speed is less than 5 mph (8 km/h), • all vehicle doors become closed again, Press the power door unlock control three times. 3. Turn the ignition key from the 4 (ON) position to the 3 (OFF) position. 97 2007 Freestar (win) Owners Guide (post-2002- - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 98
Press the power door unlock control three times. 5. Turn the ignition back to the 4 (ON) position. The horn will chirp. 6. Press the unlock control, then press the lock control. The horn range could be caused by: • weather conditions, 98 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 99
allows you to: • lock or unlock all vehicle doors and liftgate without a key. • unlock/open a driver's side power sliding door and/or passenger side power sliding door (if equipped). • unlock/open the power liftgate (PLG) (if equipped). 99 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 100
• Press this control twice within three seconds to open the power sliding door. The interior lamps will illuminate. • Press this control another two times within three seconds to close the power sliding door and turn off the interior lights. 100 2007 Freestar (win) Owners Guide (post-2002-fmt - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 101
closed and locked. and release again within three seconds to confirm that all the 2. Press doors and liftgate are closed and locked. Note: The doors will lock again, the horn will chirp once, and the parking lamps will flash once more. 101 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 102
2. Within 5 five seconds, press any control on the remote transmitter which you would like to deactivate and then press the SET control on the driver's door panel again. 3. Repeat this procedure for another remote transmitter if desired. 102 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 103
cavity. 5. Snap the two halves back together. Note: Replacement of the battery will not cause the remote transmitter to become deprogrammed from your vehicle. The remote transmitter should operate normally after battery replacement. 103 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 104
of six) available before beginning this procedure. Note: Ensure the brake pedal is not 4 depressed during this sequence. 3 To reprogram the transmitters. 10. The doors will lock, then unlock, to confirm that the programming mode has been exited. 104 2007 Freestar (win) Owners Guide (post-2002-fmt) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 105
off position for the illuminated entry system to operate. The inside lights will not turn off if: • they have been turned on with the panel dimmer control, or • any door, power sliding door (if equipped) or the liftgate is open. The battery saver will shut off the interior lamps 30 minutes after the - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 106
vehicle serviced by your authorized dealer. You may also perform the following power door lock power door unlock control 3 times. 2. Turn the ignition to the 3 (OFF) position, then press the power door unlock control 3 Lights chapter. 106 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 107
sixth digit if you wish to have the personal entry code recall memory position Driver 1 or Driver 2 (if equipped with the memory seat/side view mirrors/adjustable pedals feature). Note: The lock motors will cycle, locked then unlocked. 107 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 108
• The factory code will work even after you have set doors, press the 3 • 4 control within five seconds. To lock all doors, press the 7 • 8 and the 9 • 0 at the same time. You do not need to enter the keypad code first. Note: The interior lamps will turn off. 108 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 109
to help prevent the engine from being started unless a coded key programmed to your vehicle is used. The SecuriLock passive anti-theft system is not compatible with non-Ford aftermarket remote start systems. Use of these systems may result in vehicle starting problems and a loss of security - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 110
momentary "no start" condition if they are too close to the key when starting the engine. If a problem occurs, turn the ignition to the 2 (OFF) position and restart the engine with all other objects entire procedure before you begin. 110 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 111
from the 4 (ON) 1 position back to the 3 (OFF) position in engine and the theft indicator will flash on and off and you may repeat Steps 1 through 5. If failure repeats, bring your vehicle to your authorized dealer to have the new spare key(s) programmed. 111 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 112
problem with your vehicle, ensure ALL remote entry transmitters are taken to the authorized dealer to aid in troubleshooting. Arming the system When armed 's door lock cylinder. • Use a SecuriLock key to move the ignition to the 4 (ON) or 5 (START) position. 112 2007 Freestar (win) Owners Guide ( - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 113
can cause an occupant to slide under the seat's safety belt, resulting in severe personal injuries in the event of a collision. Do not pile cargo higher than the seatbacks to reduce the risk head restraints can be moved up and down. 113 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 114
front manual seat (if equipped) Never adjust the driver's seat or seatback when the vehicle is moving. Always drive and ride with your seatback upright and the lap belt snug and low across the hips. Lift handle to move seat forward or backward. Pull lever up to adjust seatback. 114 2007 Freestar - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 115
with the seat back reclined too far can take off weight from the seat cushion and affect the decision of the passenger sensing system, resulting in serious injury or death in a crash. Always sit upright against your seatback, with your feet on the floor. 115 2007 Freestar (win) Owners Guide (post - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 116
the seat and the center console (if equipped). Check Passenger Airbag Disable Indicator for proper Airbag Status. Refer to Front Passenger Sensing System chapter for additional details. Failure to follow these instructions may interfere with the front passenger seat sensing system. The control is - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 117
adjustable pedals to two programmable positions. The memory seat control is located on the door next to the window 1 2 inside from the mirror. • To program position one, move the driver seat to the desired position using the seat controls. Press the SET control. The SET control indicator light will - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 118
behind your head. The head restraints can be moved up and down by pulling up on the head restraint. Push button to lower head restraint. Seat mounted cup holders (if equipped) Deploy by pressing the button on top of the cupholder. 118 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 119
to the closed position. Use only soft cups in the cupholder. Hard objects can injure you in a collision. Adjusting 2nd row seats (if equipped) Lift control to adjust seat forward or backward. • 2nd row bucket seat (if equipped) 119 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 120
bench seat back Pull control forward to adjust seat back. Using same control will fold the seat back flat. Reclining the seatback can cause an occupant to slide under the seat's safety belt, resulting in severe personal injuries in the event of a collision. 120 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 121
adjusted to full rear position (if equipped). Note: Place the front row seat in a forward position to allow the 2nd row to be fully upright. Lift the handle located on the rear lower corner of the seat. The seat back will fold flat. 121 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 122
handle will tumble the seat forward, allowing easier access to the third row seat. After entering the 3rd row seat, return the seat from the tumbled position and latch it to the floor. Operate recline control to return the seatback to the upright position. 122 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 123
latched, the seat may cause injury during a sudden stop. Second row bench seat tip slide feature 1. Push the side easy-entry control handle forward and allow the seat back to flip forward. 2. Push the seat forward to allow access to the third row. 123 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 124
the third row. After exiting the third row, push rearward on the cushion of the seat to return the seat to its original position. Push the seatback rearward until it latches. This will latch and lock the seatback and the seat track. 124 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 125
upright. 2. Place the 2nd row seat in a rear position to allow the 2nd row seat to be fully upright. 3. Place seat in tumbled position. (See Accessing 3rd row seat) 4. From inside the vehicle, pull up on front floor release handle. 125 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 126
. Second row bench seat 1. Detach the lap/shoulder belts from both sides of the seat by inserting a safety belt tongue or key into the buckle release slot, pushing upward as shown, and pulling out the mini-tongue on the end of the safety belt. 126 2007 Freestar (win) Owners Guide (post-2002-fmt - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 127
Seating and Safety Restraints 2. Find the clips attached near the ends of the lap/shoulder belts. 3. Clip the end of the The end of the shoulder belt must be clipped in order to keep it from striking anything during vehicle operation. 127 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 128
belt buckle is near the center aisle of the vehicle. The seatback must be folded flat prior to installation. 1. Position the seat in vehicle. Place first row seat in a forward position to allow the second row seat to be installed. 128 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 129
and Safety Restraints 2. Install seat onto rear pin of front tub at a 30 to 45 degree angle. 3. Rotate the seat forward until it latches onto the front pin. 4. Rotate seat rearward until the back of the seat latches onto the floor. 129 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 130
that it has fully latched. An unlatched seat may become dangerous in the event of a sudden stop or collision. Second row bench seat 1. Position the seat in vehicle. 2. Align seat front hooks to the rear most pins of the front tub. 130 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 131
. If not latched, the seat may cause injury during a sudden stop. Stowing the third row seat 1. If the comfort guide is on the center lap/shoulder belt, slip the guide off the belt and stow the guide in the pocket on the back of the seat. 131 2007 Freestar (win) Owners Guide (post-2002-fmt) USA - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 132
carry very large objects or items that might damage the center lap/shoulder belt, detach the belt from the seat. Use a key or safety belt tongue to release the buckle. 3. Store the tongue of the sliding latchplate in the belt pocket. 132 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 133
Store the tongue of the sliding latchplate in the belt pocket to avoid potential damage to the seat. 5. Push the head restraint release buttons and move the head restraints fully down. Remove all objects from the seat and stowage tub. 133 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 134
't let go of the number 1 strap before the seat back folds completely, the seat may not stow flat in the tub. Refer to the label attached to the rear of the vehicle seat. 7. Release the cushion latches by pulling the number 2 strap. 134 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 135
the third row seat Ensure seat latching area is free of objects. 1. Lift the seat out of the tub in the floor by pulling up on the exposed strap or handle. Once seat is at a vertical position, push the seat over, letting it fall onto the latches. 135 2007 Freestar (win) Owners Guide (post-2002-fmt - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 136
to allow for adjustment of the seat back for improved comfort. To activate the recliner, pull and hold the strap located near the plastic shield in the center of the seat. When seat is adjusted to desired location, release the strap. 136 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 137
latches by pulling the number 2 strap. Then, pull the seat rearward by the number 3 strap and set the seat on the liftgate scuff plate. The number 1 strap is not used to access this position. 2 Do not sit on the head restraints. 137 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 138
sensors. • Restraint system warning light and back-up tone. • The electrical wiring for the airbags, crash sensor(s), safety belt pretensioners, front safety belt usage sensors, driver seat position sensor, front passenger sensing system, and indicator lights. 138 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 139
sensor allows your Personal Safety System to tailor the deployment level of the driver dual-stage airbag based on seat position. The system is designed to help protect smaller drivers sitting close to the driver airbag by providing a lower airbag output level. 139 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 140
safety belts are fastened. This information allows your Personal Safety System to tailor the airbag deployment and safety belt pretensioner activation depending upon safety belt usage. Refer to Safety belt section in this chapter. 140 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 141
the problem and warning light are repaired. If any of these things happen, even intermittently, have the Personal Safety System serviced at an authorized dealer immediately. Unless serviced, the system may not function properly in the event of a collision. 141 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 142
safety belts, even when an air bag supplemental restraint system (SRS) is provided. It is extremely dangerous to ride in a cargo area, inside or outside of under in the back seat and always properly use appropriate child restraints. 142 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 143
, if you brake hard, turn front seats to controlled manner. This helps reduce the belt force acting on the user's chest. Failure to inspect and replace if necessary the Belt and Retractor assembly after an accident could increase the risk of injury in a collision. 143 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 144
For example, if the driver brakes suddenly or turns a corner seat whenever possible. Refer to Safety restraints for children or Safety seats for children later in this chapter. How to use the automatic locking mode • Buckle the combination lap and shoulder belt. 144 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 145
automatic locking mode Ford Motor Company child seats is still working properly. Safety belt assemblies should be inspected by an authorized dealer and must be replaced if either damage or improper operation is noted. Failure 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 146
in the center position of the 3rd row seat. To adjust the comfort guide: • Slip the shoulder belt into the belt guide. • Slide the guide up or down along the head restraint post so that the belt is centered on the occupant's shoulder. 146 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 147
. These retractors should be replaced if they were used in any accident in which the front airbags deploy. If the safety belt assemblies are not replaced, there may be increased risk of injury in the event of a subsequent collision. 147 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 148
Seating and Safety Restraints Failure to inspect and if necessary replace the safety belt assembly under the above conditions could result in severe personal injuries in the event of a collision. Safety belt warning light and indicator chime The safety belt warning light illuminates in the - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 149
Seating and Safety Restraints Both the driver's and passenger's safety belt safety belt warning light illuminates and the warning chime sounds for 6 seconds every 30 seconds, repeating for approximately 5 minutes or until the safety belts are buckled. 149 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 150
. 1 in 4 of us will be seriously injured in a crash during our lifetime. 3 of 4 fatal crashes occur within 25 miles (40 km) of home. We design our don't work" "Traffic is light" "Belts wrinkle my clothes" "The people I'm with don't wear belts" 150 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 151
have an airbag" Consider...Airbags offer greater protection when used with safety belts. Frontal airbags are not designed to inflate in rear and side crashes or : • The parking brake is set • The gearshift is in P (Park) (automatic transmission) 151 2007 Freestar (win) Owners Guide (post-2002-fmt) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 152
confirmation, the restraint system warning light will flash 4 times per second for 3 seconds, followed by 3 seconds with the light off, then followed by the restraint system warning light flashing 4 times per second for 3 seconds again. 152 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 153
slowly; there is a risk of injury from a deploying airbag. All occupants of the vehicle, including the driver, should always properly wear their safety belts, even when an air bag supplemental restraint system (SRS) is provided. 153 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 154
equipment to the front end of the vehicle (including frame, bumper, front end body structure and tow hooks) may affect the performance of the airbag system, increasing the risk of injury. Do not modify the front end of the vehicle. 154 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 155
. Failure to follow these instructions may increase the risk of injury in a collision. Airbags can kill or injure a child in a child seat. NEVER place a rear-facing child seat in front of an active airbag. If you must use a forward-facing child seat in the front seat, move the seat all the way back - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 156
driver and passenger airbag modules (which include the inflators and airbags). • side airbags (if equipped). Refer to Side airbag system later in this chapter. • Safety Canopy system (if equipped). Refer to Safety canopy system later in this chapter. 156 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 157
will not inflate) the front passenger's frontal airbag under certain conditions. The front passenger sensing system works with sensors that are part of the front passenger's seat and safety belt. The sensors are designed to detect the presence of a properly seated occupant and determine if the front - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 158
the Љpassenger airbag offЉ or Љpass airbag offЉ indicator lamp is lit, it is possible that the person isn't sitting properly in the seat. If this happens: • Turn the vehicle off and ask the person to place the seatback in the full upright position. 158 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 159
restrained in the back seat. After all occupants have adjusted their seats and put on seat, the passenger airbag will be disabled. Even though the passenger airbag is disabled, the Љpass airbag offЉ lamp may or may not be illuminated according to the table below. 159 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 160
seat or between the seat and the center console (if equipped). Check the "passenger airbag off" or "pass airbag off" indicator lamp for proper airbag status. Failure to follow these instructions may interfere with the front passenger seat sensing system. 160 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 161
a warning indicator light in the instrument cluster or a back-up tone to indicate the condition of the system. Refer to the Warning lights and chimes section in the Instrument Cluster chapter. Routine maintenance of the airbag is not required. 161 2007 Freestar (win) Owners Guide (post-2002-fmt - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 162
may come into contact with a deploying airbag. Failure to follow these instructions may increase the risk of personal injury in the event of a collision. Do not use accessory seat covers. The use of accessory seat covers may prevent the deployment of the side airbags and increase the risk of injury - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 163
the outboard bolster of the driver and front passenger seatbacks. • A special seat cover designed to allow airbag deployment. • The same readiness airbag light, electronic control and diagnostic unit as used for the front airbags. • Two crash sensors located under the outboard side of the front - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 164
as it deploys from the headliner. Do not attempt to service, repair, or modify the Safety Canopy system, its fuses, the A, B, C or D pillar trim, or the headliner on a vehicle containing a Safety Canopy. See your authorized dealer. 164 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 165
to flex open above the side doors to allow Safety Canopy deployment. • The same readiness airbag light, electronic control and diagnostic unit as used for the front airbags. • Two crash sensors mounted under the front seats (one on each side). • Two crash sensors located at the c-pillar behind the - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 166
. The Safety Canopy system (including the A, B, C, and D pillar trim) must be inspected and serviced by an authorized dealer. If the Safety Canopy is not replaced, the unrepaired area will increase the risk of injury in a collision. 166 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 167
vehicle. When possible, always place children under age 12 in the rear seat of your vehicle. Accident statistics suggest that children are safer when properly restrained in the rear seating positions than in the front seating position. 167 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 168
lift the child up so that the lap belt rests low across the hips and the knees bend comfortably. Booster seats may also make the shoulder belt fit better and more comfortably. Try to keep the belt near the middle of the shoulder. 168 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 169
and no head restraint, a backless booster seat may place your child's head (top of ear level) above the top of the seat. In this case, move the backless booster to another seating position with a higher seat back and lap/shoulder belts. 169 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 170
close to the neck and a shoulder belt that could slip off the shoulder. If the booster seat slides on the vehicle seat, placing a rubberized mesh sold as shelf or carpet liner under the booster seat may improve this condition. 170 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 171
for the size and weight of the child. Carefully follow all of the manufacturer's instructions with the safety seat you put in your vehicle. If you do not install and use the safety seat properly, the child may be injured in a sudden stop or collision. 171 2007 Freestar (win) Owners Guide (post - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 172
chapter. Carefully follow all of the manufacturer's instructions included with the safety seat you put in your vehicle. If you do not install and use the safety seat properly, the child may be injured in a sudden stop or collision. 172 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 173
on the ceiling and buckle the small tongue on the end of the belt to the mini-buckle on the left side of the center seat position. 2. Pull down on the shoulder belt and then grasp the shoulder belt and lap belt together. 173 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 174
and lap belt portions together, route the tongue through the child seat according to the child seat manufacturer's instructions. Be sure the belt webbing is not twisted. 4. Insert the to indicate it is in the automatic locking mode. 174 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 175
as an accessory for many older safety seats. Contact the manufacturer of your child seat for information about ordering a tether strap. Children should be placed in the rear in an appropriate child safety seat that is properly secured to the vehicle. 175 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 176
, or either anchor can be used for a single LATCH child seat installed at the center of the bench seat. Front passenger seating position (manual adjusting seats only) 1. Position the child safety seat on the passenger seat cushion. 176 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 177
of the safety seat hits the head restraint, raise the head restraint to let the child seat fit further rearward. 3. Grasp the tether strap and position it to the seat frame. 4. Rotate the tether hook, and clip the tether strap to the seat frame. 177 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 178
tether strap clip. 6. Install the child safety seat tightly using the LATCH anchors or safety belts. Follow the instructions in this chapter. 7. Tighten the child safety seat tether strap according to the manufacturer's instructions. 178 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 179
type of child seat eliminates the need to use safety belts to attach the child seat. For forward-facing child seats, the tether strap must also be attached to the proper tether anchor. See Attaching safety seats with tether straps in this chapter. 179 2007 Freestar (win) Owners Guide (post-2002-fmt - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 180
strong enough to hold two child safety seat attachments and may break, causing serious injury or death. The lower anchors for child seat installation are located at the rear section of the rear seat between the cushion and seat back. 180 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 181
Try to tilt the child seat from side to side. Also try to tug the seat forward. Check to see if the anchors hold the seat in place. If the safety seat is not anchored properly, the risk of a child being injured in a crash greatly increases. 181 2007 Freestar (win) Owners Guide (post-2002-fmt) USA - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 182
AA, A, B, and C. The grades represent the tire's ability to stop on wet pavement as measured under controlled conditions on specified government test surfaces of asphalt and concrete. A tire marked C may have poor traction performance. 182 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 183
controlled conditions on a specified indoor laboratory test wheel. Sustained high temperature can cause the material of the tire to degenerate and reduce tire life, and excessive temperature can lead to sudden tire failure Metric tires]. 183 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 184
check the tire inflation pressure, including the spare (if equipped), at least monthly and before long trips. You are strongly urged to buy a reliable tire pressure gauge, as automatic service station gauges may be inaccurate. Ford . 184 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 185
"bleed" or reduce air pressure. The tires are hot from driving and it is normal for pressures to increase above recommended cold pressures. A hot tire at or below recommended cold inflation pressure could be significantly under-inflated. 185 2007 Freestar (win) Owners Guide (post-2002-fmt) USA - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 186
and maintain at 60 psi (4.15 bar). For Full Size and Dissimilar spare tires (see Dissimilar Spare Tire/Wheel Information that could poke a hole in the tire and cause an air leak. 7. Check the sidewalls to make sure there are no gouges, cuts 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 187
frequent high loading conditions can accelerate the aging process and may require tires to be replaced more frequently. You should replace your spare tire when you replace the road tires or after six years due to aging even if it has not been used. 187 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 188
injury and death. Additionally the use of non-recommended tires and wheels could cause steering, suspension, axle or transfer case/power transfer unit failure. If you have questions regarding tire replacement, see an authorized dealer. 188 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 189
sensors mounted in the wheels (originally installed on your vehicle) are not designed to be used in aftermarket wheels. The use of wheels or tires not recommended by Ford Do not run over curbs or hit the tire against a curb when parking 189 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 190
. Tire and wheel alignment A bad jolt from hitting a curb or pothole can cause the front end of your vehicle to wheels may be out of alignment. Have an authorized dealer check the wheel alignment periodically. Wheel misalignment in the front 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 191
tires show uneven wear ask an authorized dealer to check for and correct any wheel misalignment, tire imbalance or mechanical problem involved before tire rotation. Note: Your vehicle may standard certification and in case of a recall. 191 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 192
at different conditions for load and inflation pressure. These speed ratings may need to be adjusted for the difference in conditions. The ratings range from 81 mph (130 km/h) to 186 mph (299 km/h). These ratings are listed in the following chart. 192 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 193
it is not required by federal law. Letter rating Speed rating - mph (km/h) M 81 mph (130 are the tire size code and the information is used to contact customers if a tire defect requires door, for the correct tire pressure for your vehicle. 193 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 194
Loading 12. Treadwear, Traction and Temperature Grades • Treadwear: The treadwear grade is a comparative rating based on the wear rate of the tire when tested under controlled conditions on a specified government test course. For example, a tire graded 150 would wear one and one-half (11⁄2) times - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 195
a tire, designated by the Tire and Rim Association (T&RA), that is intended for service on light trucks. 2. Load Range/Load Inflation Limits: Indicates the tire's load-carrying capabilities and as two tires (total) on the rear axle. 195 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 196
temporary service on cars, SUVs, minivans and light trucks. size and other important information located on the B-Pillar or the edge of the driver's door. Refer to the payload description and graphic in the Vehicle loading - with and without a trailer section. 196 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 197
two conditions: checked periodically (at least monthly) using a tire gauge, see Inflating your tires in this chapter. Failure to properly maintain your tire pressure could increase the risk of tire failure, loss of control, vehicle rollover and personal injury. 197 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 198
and put back on your vehicle. To restore the full functionality of the Tire Pressure Monitoring System, have the damaged road wheel/tire repaired and remounted on your vehicle. For additional information, refer to Changing tires with TPMS in this section. 198 2007 Freestar (win) Owners Guide (post - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 199
System is to warn you when your tires need air. It can also warn you in the event the cause Customer Action Required Warning Light Solid Warning Light Tire(s) 1. Check your light remains ON, have the system inspected by your authorized dealer. 199 2007 Freestar (win) Owners Guide (post-2002-fmt) USA - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 200
TPMS warning for low tire pressure. If the low tire pressure warning light is ON, visually check each tire to verify that no tire is flat. (If one or more tires are flat, repair as necessary.) Check air pressure in the road tires. If 200 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 201
chains when they are no longer needed. Do not use tire chains on dry roads. • The suspension insulation and bumpers will help prevent vehicle damage. Do not remove these components from your vehicle when using snow tires and chains. 201 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 202
equipment. It does not include passengers, cargo, or optional equipment. Vehicle Curb Weight - is the weight of your new vehicle when you picked it up from your authorized dealer plus any aftermarket equipment. Payload - is the combined weight of cargo and passengers that the vehicle is carrying - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 203
have reached the maximum payload of your vehicle, do not add more cargo, even if there is space available. Overloading or improperly loading your vehicle can contribute to loss of vehicle control and vehicle rollover. Example only: 203 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 204
. Note: For trailer towing information refer to Trailer towing found in this chapter or the RV and Trailer Towing Guide provided by your authorized dealer. GVW (Gross Vehicle Weight) - is the Vehicle Curb Weight + cargo + passengers. 204 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 205
driver's door. The GVW must never exceed the GVWR. Exceeding the Safety Compliance Certification Label vehicle weight rating limits could result in substandard vehicle handling or performance, engine, transmission and/or structural damage, serious damage to the vehicle, loss of control and personal - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 206
in Step 4. 6. If your vehicle will be towing a trailer, load from your trailer will be transferred to your vehicle. Consult this manual to determine how this reduces the available cargo and luggage load capacity of your vehicle. 206 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 207
= - 240 lb. No, you do not have enough cargo capacity to carry that much weight. In metric units, the calculation would be: 635 kg - Weight Rating specified for your vehicle on the Safety Compliance Certification Label found on the edge of the driver's door. 207 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 208
installed, if applicable, per instructions located in the service kit. If your vehicle has the optional trailer tow package it comes with heavy duty cooling fans, auxiliary transmission fluid cooler, an auxiliary engine oil cooler (4.2L engine only), heavy duty battery, trailer tow wiring (including - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 209
load of your loaded trailer when figuring the total weight. Towing trailers beyond the maximum recommended gross trailer weight exceeds the limit of the vehicle and could result in engine damage, transmission damage, structural damage, loss of control and personal injury. Preparing to tow Use the - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 210
of having a collision greatly increase. The braking system of the tow vehicle is rated for operation at the GVWR not GCWR. Trailer lamps Trailer lamps are required on most towed vehicles. Make sure all running lights, brake lights, turn signals and hazard lights are working. Do not splice into the - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 211
• To aid in engine/transmission cooling and A/C efficiency during hot weather while stopped in traffic, place the gearshift lever in P (Park). • Vehicles with trailers should not be parked on a grade. If you must park on a grade, place wheel chocks under the trailer's wheels. 211 2007 Freestar (win - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 212
flatbed transport vehicle) your vehicle can be flat towed (all wheels on the ground) under the following conditions: • Place the transmission in N (Neutral). • Maximum speed is 35 mph (56 km/h). • Maximum distance is 50 miles (80 km). 212 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 213
lever and allows key removal. 1 3. OFF, shuts off the engine and all accessories without locking the steering wheel. This position also allows the automatic transmission shift lever to be moved from the P (Park) position without the brake pedal being depressed. When the key is in the ignition and in - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 214
safety belts and their proper usage, refer to the Seating and Safety Restraints chapter. 2. Make sure the headlamps and electrical accessories are off. 3. Make sure the gearshift is in P (Park). 4. Make sure the parking brake is set. 214 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 215
lights. Starting the engine Note: Whenever you start your vehicle, release the key as soon as the engine starts. Excessive cranking could damage the starter. 1. Turn the key to 5 (START) 4 without pressing the accelerator 3 pedal fumes. 215 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 216
on the brake BRAKE system warning light. Four-wheel anti-lock brake system (ABS) Your vehicle is equipped with an Anti-lock Braking System (ABS). This system helps you maintain steering control during emergency stops by keeping the brakes from locking. Noise from the ABS pump motor and brake pedal - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 217
detected, the system will remain activated as long as the brake pedal is depressed. The system is deactivated by releasing the brake pedal. When the system activates, the brake pedal will travel with very little effort; this is normal. 217 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 218
determines whether an engine torque reduction or brake application is needed to help control the vehicle. If control of the vehicle. Driving conditions which may activate AdvanceTrac include: • Accelerating on a slippery surface • Taking a turn too fast 218 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 219
through the obstacle. Some drivers may notice a slight movement of the brake pedal when the AdvanceTrac performs a system self-check. During AdvanceTrac operation you may experience the following: • A rumble or grinding noise 219 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 220
with a low power steering fluid level (below the MIN mark on the reservoir). • Some noise is normal during operation. If the noise is excessive, check for a low power steering fluid level before seeking service by your authorized dealer. 220 2007 Freestar (win) Owners Guide (post-2002-fmt) USA - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 221
out of P (Park) with the ignition in the 4 (ON) position and the brake pedal depressed: 1. Apply the parking brake. 2. Insert the key and turn it to the 3 (OFF) position. Apply the brake pedal and shift to N (Neutral). 3 2 1 4 5 221 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 222
shift manually. To put your vehicle in gear, start the engine, depress the brake pedal, then move gearshift lever out of P (Park). Once you place the gearshift lever securely into position, gradually release the brake pedal and use the accelerator as necessary. 222 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 223
Hold the brake pedal down while engine braking than D (Overdrive). • Use when driving conditions cause excessive shifting from D (Overdrive) to other gears. Examples: city traffic, hilly terrain, heavy loads, trailer towing and when engine braking is required. 223 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 224
transmission and tires may occur, or the engine may overheat. REVERSE SENSING SYSTEM (IF EQUIPPED) The Reverse Sensing System (RSS) sounds a tone to warn the driver of obstacles near the rear bumper performance or a false activation. 224 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 225
from the rear bumper with a decreased coverage area at the outer corners of the bumper, (refer to the figures for approximate zone coverage areas). As you move closer to the obstacle, the rate of the tone , the tone will sound again. 225 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 226
into the transmission and cause internal transmission damage. Once through the water, always dry the brakes by moving your vehicle slowly while applying light pressure on the brake pedal. Wet brakes do not stop the vehicle as quickly as dry brakes. 226 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 227
trailer is disabled, but the towing vehicle is operational, the trailer does not qualify for any roadside services. Canadian customers refer to your Customer Information Guide for information on: • coverage period • exact fuel amounts 227 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 228
direction signals will flash. Press the flasher control again to turn them off. Use it when your vehicle is disabled and is creating a safety hazard for other motorists. Note: With extended use, the flasher may run down your battery. 228 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 229
fuse. Check the appropriate fuses before replacing any electrical components. 15 Note: Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire. 229 2007 Freestar (win) Owners Guide (post - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 230
rating and color COLOR Fuse rating brake pedal. Remove the panel cover to access the fuses. To remove the fuse panel cover, pull up on the latch on the right or left side of the cover. To remove a fuse use the fuse puller tool provided on the fuse panel cover. 230 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 231
, DVD Passive Anti-theft System (PATS) LED feed Auxiliary radio Auxiliary climate control system/Power Liftgate Module/Left and right power sliding door module/Data Link Connector (DLC)/Clock B+ feeds 7 8 10A 10A 9 10 11 10A 5A 5A 231 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 232
module/Brake pressure switch/Speed control Run/Start PATS/Cluster/Air bag LED/Powertrain Control Module (PCM) relay Run/Start Liftgate Start feed, Radio Start feed Starter relay power START 13 5A 14 15 16 5A 10A 5A 17 10A 18 10A 19 5A 20 21 10A 10A 232 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 233
disconnected and reconnected, refer to the Battery section of the Maintenance and Specifications chapter. To remove the cover of the power distribution box, pull the release latches at both ends of the cover, then pull the cover up. 233 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 234
Right power seat/heated seat Left-hand power sliding door Powertrain Control Module (PCM) power Horn A/C clutch High beams Starter Fuel pump Not used Not used Auxiliary blower Trailer park lamps Left trailer stop/turn lamps Right trailer stop/turn lamps 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 235
vent Alternator Adjustable pedals (non-memory) or memory module Trailer tow park lamps Heated mirrors Front wiper motor Rear wiper motor Premium sound radio Not used SJB #1 - Center High-Mounted Stop Lamp (CHMSL), License plate lamps, OBD II, Dome lamp, Auxiliary blend doors, Switch illumination - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 236
2nd and 3rd row seat power points Ignition switch #2 feed Not used Not used Not used Not used Not used PCM A/C clutch 63 64 65 20A* 20A* 30A* 66 20A* 67 20A* 70 - 71 - 72 - 73 - 74 - 75 Diode 76 Diode * Mini Fuse ** Cartridge Fuse 236 2007 Freestar (win) Owners Guide (post-2002-fmt - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 237
driving: • do not brake heavily. • gradually decrease the vehicle's speed. • hold the steering wheel firmly. • slowly move to a safe place on the side of the road. • If your low tire warning light is on, refer to Low tire warning in this chapter. 237 2007 Freestar (win) Owners Guide (post-2002-fmt - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 238
maximum vehicle load rating listed on the Safety Compliance Label • Tow a trailer • Use snow chains on the end of the vehicle with the dissimilar spare tire • Use more than one dissimilar spare tire at a time • Use commercial car washing equipment 238 2007 Freestar (win) Owners Guide (post-2002-fmt - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 239
the dissimilar spare tire/wheel The usage of a full-size dissimilar spare tire/wheel can lead to impairment of the following: • Handling, stability and braking performance • Comfort and noise • Ground clearance and parking at curbs • Winter weather driving capability • Wet weather driving capability - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 240
forward of the rear bumper. Behind the access panel located on the right rear quarter panel interior trim. Attached to the jack with a clip. Inside tire tether kit, next to jack. Attached to the jack kit. Jack handle Flat tire tether, wing screw Jack extension tool (cargo van model only) Removing - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 241
: Do not stow the full size tire or any flat tire under the vehicle. Stowing the primary tether Note: If no tire is to be stowed under the vehicle, raise the primary tether by turning the wrench clockwise until the hex nut ratchets. 241 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 242
off the jack, you or someone else could be seriously injured. 1. Park on a level surface, activate hazard flashers and set parking brake. 2. Place gearshift lever in P (Park), turn engine off, and block the diagonally opposite wheel. 242 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 243
cover or center ornament: • To remove a bolt-on wheel cover (if equipped) loosen the plastic nuts on the center ornament with the wheel nut wrench. Then, remove the wheel cover tapered end of the wheel nut wrench. Insert and twist the handle, then pry against the wheel. 5. Loosen each wheel lug nut - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 244
Ford Accessory Running Boards have been installed, use the jack adapters supplied with the running boards as described on the inside of the jack storage area. 6. Locate the jack notch next to the door the jack handle counterclockwise. 244 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 245
properly secured. Cargo van only: 1. Remove the perforated section of the vinyl mat in the center floor area in order to install the wing screw. 2. Using the tether cable kit located with the jack, pass the cable retainer through center of the wheel. 245 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 246
plate is resting flat against the tire. 6. Repeat this tightness check procedure when servicing the spare tire pressure (every six months, per Scheduled Maintenance Guide), or at any time that the spare tire is disturbed through service of other components. 246 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 247
and rust. Use only Ford recommended replacement fasteners. When wheel hub, brake drum or brake disc that control. JUMP STARTING The gases around the battery transmission. Over time, the adaptive learning process will fully update transmission operation. 247 Bolt size 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 248
sure the two vehicles do not touch. Set the parking brake on both vehicles and stay clear of the engine cooling fan and other moving parts. 4. Check all battery terminals and remove any excessive corrosion before you attach the battery cables. Ensure that vent caps are tight and level. 5. Turn - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 249
negative (-) terminal of the battery to be jumped. A spark may cause an explosion of the gases that surround the battery. 5. Ensure that the cables are clear of fan blades, belts, moving parts of both engines, or any fuel delivery system parts. 2007 Freestar (win) Owners Guide (post-2002-fmt) USA - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 250
the disabled vehicle has been started, run both engines for an additional three minutes before disconnecting the the assisting (boosting) battery. 2. Remove the jumper cable on the negative (-) connection of the booster vehicle's battery. 250 2007 Freestar (win) Owners Guide (post-2002-fmt) USA - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 251
cable from the positive (+) terminal of the disabled vehicle's battery. After the disabled vehicle has been started and the jumper cables removed, allow it to idle for several minutes so the engine computer can relearn its idle conditions. 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 252
or incorrectly, vehicle damage may occur. Ford Motor Company produces a towing manual for all authorized tow truck operators. Have your tow truck operator refer to this manual for proper hook-up and towing procedures for your vehicle. 252 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 253
perform all warranty repairs. This means that, depending on the warranty repair needed, Ford Motor Company Customer Relationship Center P.O. Box 6248 Dearborn, MI 48121 1-800-392-3673 (FORD) (TDD for the hearing impaired: 1-800-232-5952) www.customersaskford.com 253 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 254
your vehicle needs service, or if you need more help than the authorized dealer could provide, after following the steps described above, contact the Ford Customer Relationship Center to • The vehicle identification number (VIN) 254 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 255
nonconformity (a defect or condition that substantially impairs the use, value or safety of the vehicle) OR 3. The vehicle is out of service for repair of nonconformities for a total of more than 30 calendar days (not necessarily all at one time) 255 2007 Freestar (win) Owners Guide (post-2002-fmt - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 256
Claim Form that you will need to complete, provide proof of vehicle ownership, sign and return the Customer Claim Form to the BBB. Upon receipt, the BBB will review the claim for eligibility under the Program Summary Guidelines. 256 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 257
• Benefits during the warranty period depending on the plan you purchase (such as: reimbursement for rentals; coverage for certain maintenance and wear items). • Protection against covered repair costs after your Bumper-to-Bumper Warranty expires. 257 2007 Freestar (win) Owners Guide (post-2002-fmt - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 258
control system and may cause engine knocking or serious engine damage. Ford Motor Company/Ford of Canada is not responsible for any damage caused by use of improper fuel. Using leaded fuel may also result in difficulty importing your vehicle back into the U.S. If your vehicle must be serviced - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 259
card, check or money order.) Obtaining a French owner's guide French Owner's Guides can be obtained from your authorized dealer or by writing to: Ford Motor Company of Canada, Limited Service Publications CHQ202 The Canadian Road P.O. Box 2000 Oakville, ON, Canada L6J 5E4 259 2007 Freestar (win - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 260
safercar.gov. REPORTING SAFETY DEFECTS (CANADA ONLY) If you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately inform Transport Canada, using their toll-free number: 1-800-333-0510. 260 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 261
the chrome surface. • After polishing chrome bumpers, apply a coating of Motorcraft Premium Liquid Wax (ZC-53-A), available from your authorized dealer, or an equivalent quality product to help protect from environmental effects. 261 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 262
non-body (low-gloss black) colored trim, such as grained door handles, roof racks, bumpers, side moldings, mirror housings or covers. Chemical-strength cleaners, or cleaning chemicals, in combination with brush agitation to remove brake dust 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 263
-pressure fluid could penetrate the sealed parts and cause damage. • Do not spray a hot engine with cold water to avoid cracking the engine block or other engine components. • Spray Motorcraft Engine Shampoo and Degreaser (ZC-20) on all parts that require cleaning and pressure rinse clean. • Cover - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 264
Dash & Vinyl Cleaner (ZC-38-A) on the instrument panel and interior trim areas. • Avoid cleaners or polishes that increase the gloss of the upper portion of the instrument panel. The dull finish in this area helps protect the driver from undesirable windshield reflection. 264 2007 Freestar - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 265
for 60 seconds. 5. Following this, wipe area dry with a clean white cotton cloth. INTERIOR For fabric, carpets, cloth seats, safety belts and seats equipped with side airbags: • Remove dust and loose dirt with a vacuum cleaner. • Remove light stains and soil with Motorcraft Professional Strength - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 266
with leather upholstery. If this occurs, the leather should be cleaned immediately to avoid permanent staining. UNDERBODY Flush the complete underside of your vehicle frequently. Keep body and door drain holes free from packed dirt. 266 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 267
) (ZC-14) Motorcraft Tire Clean and Shine (ZC-28) Motorcraft Triple Clean (U.S. only) (ZC-13) Motorcraft Ultra-Clear Spray Glass Cleaner (ZC-23) Motorcraft Vinyl Cleaner (Canada only) (CXC-93) Motorcraft Wheel and Tire Cleaner (ZC-37-A) 267 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 268
your authorized dealer can provide the necessary parts and service. Check your Warranty Guide/Customer Information Guide to find out which parts and services are covered. Use only recommended fuels, lubricants, fluids and service parts conforming to specifications. Motorcraft parts are designed and - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 269
and Specifications OPENING THE HOOD 1. Inside the vehicle, pull the hood release handle located under the bottom left corner of the instrument panel. 2. Go to hood opening positions. Use the location which best suits your needs. 269 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 270
1. Brake fluid reservoir 2. Air filter assembly 3. Power distribution box 4. Battery 5. Automatic transmission fluid dipstick 6. Engine oil dipstick 7. Engine oil filler cap 8. Windshield washer fluid reservoir 9. Engine coolant reservoir 10. Power steering fluid reservoir 270 2007 Freestar (win - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 271
fluid in the engine coolant reservoir. Washer fluid placed in the cooling system may harm engine and cooling system components. Checking and adding washer fluid for the liftgate Washer fluid for the liftgate is supplied by the same reservoir as the windshield. 271 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 272
on level ground. 2. Turn the engine off and wait a few minutes for the oil to drain into the oil pan. 3. Set the parking brake and ensure the gearshift is securely latched in P (Park). 4. Open the hood. Protect yourself from engine heat. 272 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 273
remove the engine oil level indicator (dipstick). 6. Wipe the indicator clean. Insert the engine oil must be added to raise the level within the normal operating range. • If required, add engine oil to the engine. Refer to Adding engine oil in this chapter. 273 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 274
, some oil must be removed from the engine by an authorized dealer. 7. Put the indicator back in and ensure it is fully seated. Adding engine oil 1. Check the engine oil. For instructions, refer to Checking the engine oil in this chapter. 2. If the engine oil level is not within the normal range - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 275
and could lead to engine damage that is not covered by Ford warranty. Change your engine oil and filter according to the appropriate schedule listed in scheduled maintenance information. Ford production and aftermarket (Motorcraft) oil filters are designed for added engine protection and long life - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 276
or lighted substances to come near the battery. When working near the battery, always Battery posts, terminals and related accessories contain lead and lead compounds. Wash hands after handling. To account for customer driving habits and conditions, your automatic transaxle electronically controls - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 277
Controls chapter. • Always dispose of automotive batteries in a responsible manner. Follow your local authorized standards for disposal. Call your local authorized recycling center to find out more about recycling automotive batteries. RE LE AD TU RN RECYCLE 277 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 278
following: • Freeze protection down to -34°F (-36°C). • Boiling protection up to 265°F (129°C). • Protection against rust and other forms of corrosion. • Enables calibrated gauges to work properly. 278 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 279
to the reservoir. Refer to Adding engine coolant in this chapter. Note: Automotive fluids are not interchangeable; do not use engine coolant, antifreeze or windshield washer fluid outside of its specified function and vehicle location. 279 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 280
-A1. Refer to Maintenance product specifications and capacities in this chapter. Note: Use of Motorcraft Cooling System Stop Leak Pellets or an equivalent product meeting Ford specification WSS-M99B37-B6, may darken the color of Motorcraft Premium Gold Engine Coolant from yellow to golden tan. • Do - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 281
(1.0 liter) of engine coolant per month, have your authorized dealer check the engine cooling system. Your cooling system may have a leak. Operating an engine with a low level of coolant can result in engine overheating and possible engine damage. 281 2007 Freestar (win) Owners Guide (post-2002-fmt - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 282
corrosion protection characteristics of the engine coolant and may cause engine damage. • Decreased engine coolant concentrations below 40% will decrease the freeze protection characteristics of the engine coolant and may cause engine damage. 282 2007 Freestar (win) Owners Guide (post-2002-fmt) USA - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 283
cooling system and engine protection. FUEL FILTER For fuel filter replacement, see your authorized dealer. Refer to scheduled maintenance information for the appropriate intervals for changing the fuel filter. Replace the fuel filter with an authorized Motorcraft part. The customer warranty may be - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 284
seek medical attention. Failure to seek proper conditions. Care should be taken to avoid inhaling excess fumes. The flow of fuel through a fuel pump nozzle can produce static electricity, which can cause a fire if fuel is pumped into an ungrounded fuel container. 284 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 285
on or if "Service Engine Soon/Check Engine" indicator comes on and stays on when you start the engine, the fuel filler cap may not be properly installed. Turn off the engine, remove the fuel filler cap, align the cap properly and reinstall it. 285 2007 Freestar (win) Owners Guide (post-2002-fmt - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 286
indicate that these additives can cause your vehicle's emission control system to deteriorate more rapidly. Repairs to correct the effects of using a fuel for which your vehicle was not designed may not be covered by your warranty. 286 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 287
knocks lightly. However, if it knocks heavily under most driving conditions while you are using fuel with the recommended octane rating, see your authorized dealer to prevent any engine damage. 87 Fuel quality If you are experiencing starting, rough idle or hesitation driveability problems, try - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 288
For more information on the "check • The engine" or the "service engine soon" indicator, refer to Warning lights and chimes in the Instrument Cluster of the advertised capacity of the fuel tank due to the empty reserve still present in the tank. 288 2007 Freestar (win) Owners Guide (post-2002-fmt) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 289
error in the reading will result if the engine is left running. • Use the same filling rate setting (low - medium - high) each time the vehicle's fuel economy under current driving conditions. Additionally, keeping records during summer and 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 290
engine oil. Refer to Maintenance product specifications and capacities in this chapter. • Perform all regularly scheduled maintenance items. Follow the recommended maintenance schedule and owner maintenance checks found in scheduled maintenance information. 290 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 291
vehicle to comply with applicable exhaust emission standards. To make sure that the catalytic converter and other emission control components continue to work properly: • Use only the specified fuel listed. • Avoid running out of fuel. 291 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 292
on the Vehicle Emission Control Information Decal located on or near the engine. This decal identifies engine displacement and gives some tune up specifications. Please consult your Warranty Guide for complete emission warranty information. 292 2007 Freestar (win) Owners Guide (post-2002-fmt) USA - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 293
is on or not working properly (bulb is burned test if the out), or if the OBD-II system has determined that some of the emission control systems have not been properly checked. In this case, the vehicle is considered not ready for I/M testing. 293 2007 Freestar (win) Owners Guide (post-2002-fmt - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 294
still not ready for I/M testing, the above driving cycle will have to be repeated. POWER STEERING FLUID Check the power steering fluid. Refer to the scheduled maintenance guide for the service interval schedules. If adding fluid is necessary, use only MERCON ATF. 1. Start the engine and let it run - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 295
level surface and engage the parking brake. 3. With the parking brake engaged and your foot on the brake pedal, start the engine and move the gearshift lever through all of the gear ranges. Allow sufficient time for each gear to engage. 295 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 296
condition. Adjusting automatic transmission fluid levels Before adding any fluid, make sure the correct type is used. The type of fluid used is normally indicated on the dipstick. Refer to Maintenance product specifications and capacities in this chapter. 296 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 297
vehicle damage and/or personal burn injuries do not start your engine with the air cleaner removed and do not remove it while the engine is running. 1. Disconnect the Mass Air Flow Sensor electrical connector from the air outlet tube. 297 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 298
Maintenance and Specifications Reposition the locking clip (on the connector) and squeeze connector to remove. 2. Loosen the hose clamp located closest to the air cleaner. 3. Remove the air cleaner assembly from the vehicle. 298 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 299
from the air filter housing. 6. Wipe the air filter housing and cover clean to remove any dirt or debris and to ensure good sealing. 7. Install a new air filter element. Be careful not to crimp the filter element edges between the air filter housing and cover. 299 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 300
8. Replace the air filter housing cover and secure the clamps. Be sure all the tabs on the bottom edge are properly aligned. 9. Reinstall the air cleaner assembly into the vehicle. Ensure the tabs on the inlet tube are secure in the sheet metal. 300 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 301
Do not use oil-impregnated air filter elements. Failure to use the correct air filter element may result in severe engine damage. The customer warranty may be voided for any damage to the engine if the correct air filter element is not used. 301 2007 Freestar (win) Owners Guide (post-2002-fmt) USA - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 302
plugs with ones that meet Ford material and design specifications for your vehicle, such as Motorcraft or equivalent replacement parts. The customer warranty may be void for any damage to the engine if such spark plugs are not used. 302 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 303
MAINTENANCE PRODUCT SPECIFICATIONS AND CAPACITIES Item Brake fluid Door weatherstrips 14.8 quarts (14.0L) 15.9 quarts (15.0L) Motorcraft Premium Gold Engine Coolant with bittering agent (yellow colored)3 - Engine coolant without rear heater Engine coolant with rear heater Cooling system stop leak - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 304
Lock Lubricant 2007 Freestar (win) Owners Guide (post-2002-fmt) USA (fus) Maintenance and Specifications Ford part name Ford part number / Ford specification XL-1 / None XT-2-QDX / MERCON XT-5-QM / MERCONV Use only brake fluids certified to meet Ford specifications. DOT 3 fluid is recommended - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 305
ratio 3.9 L OHV V6 engine 232 87 octane 1-4-2-5-3-6 EDIS 0.052-0.056 inch (1.32-1.42mm) 9.36:1 4.2L OHV V6 engine 256 87 octane 1-4-2-5-3-6 EDIS 0.052-0.056 inch (1.32-1.42mm) 9.27:1 Engine drivebelt routing • 3.9L V6 and 4.2L V6 Engines 305 2007 Freestar (win) Owners Guide (post-2002-fmt) USA - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 306
driver's door. Vehicle identification number (VIN) The vehicle identification number is located on the driver side instrument panel. Please note that in the graphic, XXXX is representative of your vehicle identification number. XXXXXXXXXXXXXXXXX 306 2007 Freestar (win) Owners Guide (post-2002 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 307
information: 1. World manufacturer identifier 2. Brake system / Gross Vehicle Weight Rating (GVWR) / Restraint System 3. Vehicle line, series, body type 4. Engine type 5. Check digit 6. Model year 7. Assembly plant 8. Production sequence number TRANSMISSION/TRANSAXLE CODE DESIGNATIONS You can find - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 308
Deflectors Headlamps, fog lights and Daytime Running Lamps (DRLs) Splash guards Interior style Consoles Electrochromatic compass/temperature interior mirrors Floor mats Lifestyle Ash cup / smoker's package Cargo organization and management 308 2007 Freestar (win) Owners Guide (post-2002-fmt - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 309
only by a qualified service technician. • Mobile , such as anti-lock braking systems, amateur radio users who accessories or components that are added to the vehicle by the authorized dealer or the owner may adversely affect battery performance and durability. 309 2007 Freestar (win) Owners Guide - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 310
a disabled battery ...247 maintenance-free ...275 replacement, specifications ...302 servicing ...275 Belt-Minder ...148 Brakes ...216 anti-lock ...216-217 anti-lock brake system (ABS) warning light ...217 fluid, checking and adding ...295 fluid, refill capacities ...303 fluid, specifications - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 311
...59 Console ...65 overhead ...58 Controls power seat ...115 steering column ...74 Coolant checking and adding ...278 refill capacities ...282, 303 specifications ...303 Cruise control (see Speed control) ...71 Cupholder(s) ...118 Customer Assistance ...227 Ford Extended Service Plan ...257 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 312
and air conditioning system ...35-36 312 Homelink wireless control system ...74 Hood ...269 I Ignition ...213, 305 Illuminated visor mirror ...57 Infant seats (see Safety seats) ...171 Inspection/maintenance (I/M) testing ...293 Instrument panel ...65 cleaning ...264 cluster ...10 lighting up - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 313
71 Power adjustable foot pedals ...71 Power distribution box (see Fuses) ...233 Power door locks ...95-96 Power liftgate ...88, 101 Power mirrors ...69 Power point ...66 Power steering ...220 fluid, checking and adding ...294 fluid, refill capacity ...303 fluid, specifications ...303 Power Windows - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 314
...164 Safety defects, reporting ...260 Safety restraints ...138, 142-145 Belt-Minder ...148 extension assembly ...147 for adults ...143-145 for children ...167-168 Occupant Classification Sensor ...140 safety belt maintenance ...147 warning light and chime ...148 Safety seats for children ...171 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 315
Index fluid, refill capacities ...303 lubricant specifications ...303 Transmission brake-shift interlock (BSI) ...221 fluid, checking and adding (automatic) ...295 Turn signal ...49 V Vehicle Identification Number (VIN) ...306 Vehicle loading ...202 Ventilating your vehicle ...216 W Warning lights ( - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 316
316 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 317
317 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 318
318 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 319
319 - 2007 Ford Freestar | Owner Guide 2nd Printing - Page 320
320
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
-
101
-
102
-
103
-
104
-
105
-
106
-
107
-
108
-
109
-
110
-
111
-
112
-
113
-
114
-
115
-
116
-
117
-
118
-
119
-
120
-
121
-
122
-
123
-
124
-
125
-
126
-
127
-
128
-
129
-
130
-
131
-
132
-
133
-
134
-
135
-
136
-
137
-
138
-
139
-
140
-
141
-
142
-
143
-
144
-
145
-
146
-
147
-
148
-
149
-
150
-
151
-
152
-
153
-
154
-
155
-
156
-
157
-
158
-
159
-
160
-
161
-
162
-
163
-
164
-
165
-
166
-
167
-
168
-
169
-
170
-
171
-
172
-
173
-
174
-
175
-
176
-
177
-
178
-
179
-
180
-
181
-
182
-
183
-
184
-
185
-
186
-
187
-
188
-
189
-
190
-
191
-
192
-
193
-
194
-
195
-
196
-
197
-
198
-
199
-
200
-
201
-
202
-
203
-
204
-
205
-
206
-
207
-
208
-
209
-
210
-
211
-
212
-
213
-
214
-
215
-
216
-
217
-
218
-
219
-
220
-
221
-
222
-
223
-
224
-
225
-
226
-
227
-
228
-
229
-
230
-
231
-
232
-
233
-
234
-
235
-
236
-
237
-
238
-
239
-
240
-
241
-
242
-
243
-
244
-
245
-
246
-
247
-
248
-
249
-
250
-
251
-
252
-
253
-
254
-
255
-
256
-
257
-
258
-
259
-
260
-
261
-
262
-
263
-
264
-
265
-
266
-
267
-
268
-
269
-
270
-
271
-
272
-
273
-
274
-
275
-
276
-
277
-
278
-
279
-
280
-
281
-
282
-
283
-
284
-
285
-
286
-
287
-
288
-
289
-
290
-
291
-
292
-
293
-
294
-
295
-
296
-
297
-
298
-
299
-
300
-
301
-
302
-
303
-
304
-
305
-
306
-
307
-
308
-
309
-
310
-
311
-
312
-
313
-
314
-
315
-
316
-
317
-
318
-
319
-
320
 |
 |
Introduction
4
Instrument Cluster
10
Warning lights and chimes
10
Gauges
16
Entertainment Systems
19
AM/FM stereo
19
AM/FM stereo with CD
21
AM/FM stereo cassette with CD
24
AM/FM stereo with in-dash six CD
27
Climate Controls
35
Manual heating and air conditioning
35
Rear window defroster
44
Lights
45
Headlamps
45
Turn signal control
49
Bulb replacement
51
Driver Controls
56
Windshield wiper/washer control
56
Steering wheel adjustment
57
Power windows
67
Mirrors
69
Speed control
71
Message center
78
Locks and Security
95
Keys
95
Locks
95
Anti-theft system
109
Table of Contents
1
2007 Freestar
(win)
Owners Guide (post-2002-fmt)
USA
(fus)