2009 Ford F450 Owner's Manual
2009 Ford F450 Manual
2009 Ford F450 manual content summary:
- 2009 Ford F450 | Owner's Manual - Page 1
Climate Controls Heater only Manual heating and air conditioning Dual automatic temperature control 80 80 81 84 Lights Headlamps Turn signal control Bulb replacement 89 89 94 95 Driver Controls Windshield wiper/washer control Steering wheel adjustment Power windows Mirrors Speed control Upfitter - 2009 Ford F450 | Owner's Manual - Page 2
256 262 267 274 Driving Starting Brakes Traction Control™ Transmission operation Reverse sensing system Reverse camera 275 275 280 282 285 292 294 Roadside Emergencies Getting roadside assistance Hazard flasher control Fuel pump shut-off switch Fuses and relays Changing tires Wheel lug nut torque - 2009 Ford F450 | Owner's Manual - Page 3
(Canada only) 350 356 356 Cleaning Maintenance and Specifications Engine compartment Engine oil Battery Engine coolant Fuel information Air filter(s) Part numbers Maintenance product specifications and capacities Engine data 357 367 369 372 375 377 383 402 404 405 409 Accessories Index 412 414 - 2009 Ford F450 | Owner's Manual - Page 4
cut off the fuel supply to the engine. The switch can also be activated through sudden vibration (e.g. collision when parking). To reset the switch, refer to the Fuel pump shut-off switch in the Roadside Emergencies chapter. 4 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 5
certain products of component wear contain or emit chemicals known to the State of California to cause cancer and birth defects or other reproductive harm. 5 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 6
For a detailed description of what is covered and what is not covered by your vehicle's New Vehicle Limited Warranty, refer to the Warranty Guide/Customer Information Guide that is provided to you along with your Owner's Guide. 6 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 7
or status of various systems and modules in the vehicle, such as engine, throttle, steering or brake systems. In order to properly diagnose and service your vehicle, Ford Motor Company, Ford of Canada, and service and repair facilities may access vehicle diagnostic information through a direct - 2009 Ford F450 | Owner's Manual - Page 8
to access the information in the Powertrain Control System. This information will likely identify if any unauthorized modifications have been made to the system and may be used to determine if repairs will be covered by warranty. 8 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 9
the driving task when it is safe to do so. Notice to owners of diesel-powered vehicles Read the 6.0 and 6.4 Liter Power Stroke Direct Injection Turbo Diesel Owner's Guide Supplement for information regarding correct operation and maintenance of your Diesel-powered light truck. 9 2009 F-250/350/450 - 2009 Ford F450 | Owner's Manual - Page 10
to the Driving chapter. Using your vehicle as an ambulance If your light truck is equipped with the Ford Ambulance Preparation Package, it may be utilized as an ambulance. Ford urges ambulance manufacturers to follow the recommendations of the Ford Incomplete Vehicle Manual, Ford Truck Body Builder - 2009 Ford F450 | Owner's Manual - Page 11
that manufacturer. Ford Ambulance Preparation Package is only available on certain Diesel engine equipped vehicles. Using your vehicle as a stationary power source (PTO) Refer to the Driving chapter for more information and guidelines for operating a vehicle equipped with an aftermarket power take - 2009 Ford F450 | Owner's Manual - Page 12
Brake System Brake Fluid Non-Petroleum Based Stability Control System Speed Control Master Lighting Switch Hazard Warning Flasher Fog Lamps-Front Fuse Compartment Fuel Pump Reset Windshield Defrost/Demist Windshield Wash/Wipe Rear Window Defrost/Demist 12 2009 F-250/350/450/550 (f23) Owners - 2009 Ford F450 | Owner's Manual - Page 13
, or Sparks Explosive Gas Battery Acid Fan Warning Maintain Correct Fluid Level Engine Air Filter Jack MAX MIN Power Steering Fluid Service Engine Soon Passenger Compartment Air Filter Check Fuel Cap Low Tire Pressure Warning 13 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 14
Instrument Cluster WARNING LIGHTS AND CHIMES Vehicles equipped with a manual transmission Automatic transmission 14 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 15
and Specifications chapter. Solid illumination after the engine is started indicates the On Board Diagnostics System (OBD-II) has detected a malfunction. Refer to On board diagnostics (OBD-II) in the Maintenance and Specifications 15 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 16
: If the ABS light stays illuminated or ABS continues to flash, a malfunction has been detected, have the system serviced immediately by your authorized dealer. Normal braking is still functional unless the brake warning light also is illuminated. 16 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 17
to Engine oil in the Maintenance and Specifications chapter. Low tire pressure warning (if equipped): Illuminates when your tire pressure is low. If the light remains on at start up or while driving, the tire pressure should be checked. Refer to Inflating Your Tires in the Tires, Wheels and Loading - 2009 Ford F450 | Owner's Manual - Page 18
dealer. Refer to Traction Control™ in the Driving chapter for more information Check fuel cap (RTT): Displays when the fuel cap may not be properly installed. Continued driving with this light on may cause the Service engine soon warning light to come on. Refer to Fuel filler cap in the Maintenance - 2009 Ford F450 | Owner's Manual - Page 19
when the left or right turn signal or the hazard lights are turned on. If the indicators stay on or flash faster, check for a burned out bulb. High beams: Illuminates when the high beam headlamps are turned on. 4x4 HIGH 19 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 20
a diesel engine, it has some unique warning lights; refer to Instrument Cluster in your 6.0 and 6.4 Liter Power Stroke Direct Injection Turbo Diesel Owner's Guide Supplement for detailed information on their function. Diesel warning lights: • Glow plug pre-heat • Water in fuel • Low oil pressure - 2009 Ford F450 | Owner's Manual - Page 21
Instrument Cluster GAUGES Speedometer: Indicates the current vehicle speed. Standard instrument cluster Harley-Davidson instrument cluster 21 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 22
. If equipped with a one button message center (Select/Reset), press and release the SELECT/RESET button on the cluster to toggle between odometer and trip odometer display. To reset, press and hold for less than two seconds. 22 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 23
instrument cluster Harley-Davidson instrument cluster Engine hour meter (if equipped): Registers the accumulated time the engine has been running. Press and release the message center INFO button until this is displayed. 23 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 24
transmission only): Indicates the battery voltage when the ignition is in the on position. If the pointer moves and stays outside the normal operating range, have the vehicle's electrical system checked as soon as possible. 24 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 25
in the Yellow or Red area, stop the vehicle and verify the airflow is not restricted such as snow or debris blocking airflow through the grill. If the gauge continues to show high temperatures, see your authorized dealer. 25 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 26
off or until either front door is opened. / (Tuner): Press to 1. manually go up or down the radio frequency. Press and hold for a fast advance through radio frequencies. Also use in AUDIO mode to gain access to various settings. 26 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 27
flash, / / SEEK to adjust. To adjust minutes, press CLK then use / / again to make the minutes start to flash and use to adjust. Press CLK again to exit the clock setting mode. SEEK 3. toggle between the clock and radio frequency. 27 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 28
Driving while distracted can result in loss of vehicle control, accident and injury. Ford strongly recommends that drivers use extreme caution when using SIRIUS radio subscription. Check with your authorized dealer for availability. 28 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA ( - 2009 Ford F450 | Owner's Manual - Page 29
the following settings: Setting the clock: Press MENU until SET HOUR or SET MINUTES is displayed. Use / / SEEK, SEEK to adjust the hours/minutes. SATELLITE RADIO MENU (if equipped): Press MENU that you would like to delete, press 29 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 30
radio subscription. Check with your Use / / SEEK, SEEK to adjust the audio between the left (L) and right (R) speakers. FADE: Press MENU to reach the fade setting. Use / / SEEK, SEEK to adjust the audio between the back (B) and front (F) speakers. 30 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 31
ON/OFF. When COMPRESS Use is ON, the system will bring the soft and loud CD passages together for a more consistent listening level. 4. AUX: Press repeatedly to radio subscription. Check with your authorized dealer for availability. 31 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 32
radio is available only with a valid SIRIUS radio subscription. Check with your authorized dealer for availability. / OK (Play/Pause): This 6. control is operational in CD/MP3 mode. When a CD/MP3 OFF will appear in the display. 32 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 33
channel then press and hold a preset control until sound returns. Satellite radio is available only with a valid SIRIUS radio subscription. Check with your authorized dealer for availability. 13 and the SIRIUS long channel name. 33 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 34
. Press again to stop. Satellite radio is available only with a valid SIRIUS radio subscription. Check with your authorized dealer for availability. 14. AM/FM: Press AM/FM to select AM/FM1 a CD label side up in the CD slot. 34 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 35
radio mode, press to manually ) or down ( ) the go up ( radio frequency. Press and hold for a fast advance through radio frequencies. In menu mode, use to select various settings. In CD/MP3 mode, press to select the desired disc. 35 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus - 2009 Ford F450 | Owner's Manual - Page 36
Entertainment Systems Satellite radio is available only with a valid SIRIUS radio subscription. Check with your authorized dealer for availability. 2. (Phone): Press to access appear in the display for confirmation. Press OK again 36 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 37
available only with a valid SIRIUS radio subscription. Check with your authorized dealer for availability. AUTOSET: Press in / / SEEK to toggle RBDS ON/OFF. When the display. Use RBDS is OFF, you will not be able to search for RBDS 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 38
increasing vehicle speed to compensate for road and wind noise. / / SEEK, SEEK to adjust. Use The default setting is off; increasing your vehicle speed will not change the volume the previous/next folder (if Press available). 38 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 39
subscription. Check with your authorized dealer for availability. to 6. / OK (Play/Pause): This control is operational in CD/MP3 mode. When a CD/MP3 is playing, press to pause or play the current CD. The CD status will display in the radio display. 39 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 40
Entertainment Systems OK: Use in various menu selections. If your vehicle is equipped with preset control until sound returns. Satellite radio is available only with a valid SIRIUS radio subscription. Check with your authorized dealer for availability. 40 2009 F-250/350/450/550 (f23) Owners Guide, - 2009 Ford F450 | Owner's Manual - Page 41
stop. Satellite radio is available only with a valid SIRIUS subscription. Check with your authorized dealer for availability. 14. AM/FM: Press number using memory presets 1-6. When the display reads LOAD CD#, load the desired disc, label side up. 41 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 42
any device that may take their focus off the road. The driver's primary responsibility is the safe operation of their vehicle. Only use cell phones and other devices not essential to the driving task when it is safe to do so. 42 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 43
the following instructions when attaching your using the auxiliary input jack: 1. Begin with the vehicle parked and the radio turned off. 2. Ensure that the battery switching back and forth between the AUX and FM or CD controls. 43 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 44
box, Driving while distracted can result in loss of vehicle control, accident and injury. Ford strongly recommends that drivers use extreme caution when using use cell phones and other devices not essential to the driving task when it is safe to do so. 44 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 45
fences, traffic lights and thunderstorms can interfere with your reception. • Station overload: When you pass a broadcast tower, a stronger signal may overtake a weaker one and play while the weak station frequency is displayed. 45 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 46
. Due to technical incompatibility, certain recordable and re-recordable compact discs may not function correctly when used in Ford CD players. Do not use any irregular shaped CDs or discs with a scratch protection film attached. 46 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 47
. Audio system warranty and service Refer to the Warranty Guide/Customer Information Guide for audio system warranty information. If service is necessary, see your folders will help with navigation through the disc files. 47 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 48
extension will be played. Other files will be ignored by the system. This enables you to use the same MP3 disc for a variety of tasks on your work computer, home computer and your in vehicle system. 1 .mp3 1 .mp3 2 2 3 possible. 48 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 49
time, with or without notice to you. Ford Motor Company shall not be responsible for any such programming changes. Satellite Radio Electronic Serial Number (ESN): This display by pressing AUX and Preset 1 control simultaneously. 49 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 50
Condition your authorized dealer for service. INVALID CHNL Channel no working properly. NO TEXT Category Category information not available information not at this time on this channel. The available. system is working properly. Radio Display ACQUIRING 50 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 51
FES features and controls as well as the very important safety information. Quick start Your Family Entertainment System includes a DVD system, two sets of wireless infrared (IR) headphones and a wireless infrared (IR) remote control. 51 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 52
CDs. To ensure proper disc operation, check the disc for finger prints and scratches. Clean the disc with a soft cloth, wiping from the center to the edge. 1. Ensure that the vehicle is on or the ignition is in accessory mode. 52 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 53
system The DVD system can be used to connect and play auxiliary electronic devices such as game systems, personal camcorders, video cassette recorders, etc. 1. Ensure that the vehicle is on or the ignition is in accessory mode. 53 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 54
active (able to be controlled). 2. Press MEDIA to change the audio source of the active channel (A or B). The audio source will be shown on the display. You may change the active channel by pressing the A or B headphone control button. 54 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 55
on the display screen, press the brightness control on the DVD system. A display will appear at the bottom of the screen indicating the brightness level. The brightness display will only appear when the menu is not displayed. 55 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 56
15 12 13 11 10 7 9 8 1. Headphone control A/B: Press to select either the A or B headphone source SAT (if equipped), CD, DVD, DVD-AUX). Headphone B can only access DVD and DVD-AUX. For further information, refer to Single play/ 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 57
control and sends audio signals to the infrared (IR) wireless headphones. 9. LCD screen: The eight inch diagonal screen rotates down to view and up into housing to store when not in use is controlled with the rotary dial on the right ear piece.) 57 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 58
, DVD-AUX). The controls: Use the cursor controls to make various selections when in any menu. When not in a menu, and in / to adjust DVD mode, press the brightness. A display bar will appear at the bottom of the screen indicating the brightness levels. 58 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 59
menu screen. 5. ANGLE (DVD dependent): Press to select the angle to view the scene. 6. Channel A/B: Press to select either A or B headphones and then use the MEDIA control to select the desired playing media for the headphones. 59 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 60
perform the same function. 13. Numeric Keypad: Use the numeric controls to enter in a specific CD/MP3 track or DVD-AUX. Channel B can only access DVD and AUX sources. 16. VIDEO: Press to cycle through video states: DVD-DISC, DVD-AUX, 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 61
shelf life, replace them when the unit fails to control the DVD player. Remove the screw and unlatch the battery cover to access the batteries. The remote control unit uses two AAA batteries which are supplied with the unit. 61 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 62
infrared wireless headphones may be purchased for use with the system. Also, wired headphones may be purchased and plugged in where indicated on the left and right hand sides of the system. Refer to Wired Headphones following. 62 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 63
remove the screw at the bottom of the cover. Then, lightly press down on top and slide the cover off. When replacing the batteries, use two new batteries (alkaline recommended) and install them with the correct orientation as indicated in the battery housing. 63 2009 F-250/350/450/550 (f23) Owners - 2009 Ford F450 | Owner's Manual - Page 64
signal is received), the wireless headphones will automatically turn off. They will also turn off after two hours of continuous use as a power save feature. If this happens, simply turn the headphones on again and continue use. 64 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 65
: The driver should never use the headphones while driving the vehicle. Using headphones may prevent the driver volume using the volume control on the DVD system. Operation Single play/Dual play Your DVD and audio system work together 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 66
Control button B to change the audio source for Channel B. Press MEDIA to change the audio source for Channel B. This information will display on the DVD system screen. Channel B can listen to either the DVD media or the DVD system auxiliary inputs (DVD-AUX). 66 2009 F-250/350/450/550 (f23) Owners - 2009 Ford F450 | Owner's Manual - Page 67
aftermarket audio system (Headphone only mode) When the Family Entertainment System (FES) detects that the original radio supplied by Ford Motor Company has been removed from the vehicle, the Family Entertainment System will work -AUX, 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 68
change to your selection after the system resumes playback of the DVD. The system default is WIDE (16:9). Language Select LANGUAGE to select the language you would like to use for audio output (English, Spanish, French). This is disc dependent. 68 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 69
which track you would like to play. You can also use the cursor controls to highlight COMPRESSION, SHUFFLE or SCAN. Once you have highlighted the desired track or function, press ENTER on the DVD bezel to confirm your selection. 69 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 70
: 1. Ensure that the vehicle is on or the ignition is in accessory mode. 2. Ensure that the DVD system is on. 3. Insert the 650 MB of storage capacity. We do not recommend using high capacity discs containing 700MB of storage. • Disc 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 71
Use care when handling and playing CD-R and CD-RW discs, which are more susceptible to damage from heat, light and stress than are regular CDs. • Always insert and remove used in disc playback is extremely harmful to the eyes. 71 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 72
compact discs may not function correctly when used in Ford CD and DVD players. Irregular shaped CDs accessory mode. 2. Ensure that the navigation system is on. 3. Insert a DVD label-side up into the system. 4. Use the DVD bezel controls 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 73
source is highlighted. Also located here are the various auxiliary jacks which can be used to plug in a VCR, camcorder, video games, etc. The specific jacks are as follows: 1. Yellow: video input 2. White: left channel audio input 73 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 74
included) here. Note: The B headphones can only access DVD and AUX modes. They cannot access radio sources. Audio displays Your DVD system use the DVD system. There are three levels of control of the FES buttons. The states are FULL (enabled), LOCAL or 74 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 75
technology must be authorized by Macrovision Corporation, and is intended for home and other limited viewing uses only unless otherwise authorized by Macrovision Corporation. Reverse engineering or disassembly is prohibited. 75 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 76
to driving and to the road. Pull off the road in a safe place before inserting or extracting DVDs from the system. A remote control is included in the system to allow the rear seat occupants to operate the FES functions without distracting the driver. 76 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 77
determined by turning the equipment off and on, the user is encouraged to consult the dealer or an experienced radio/TV technician for help. 77 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 78
are removed. Do not spray the screen directly with water or glass cleaning solvents. Overspray from these fluids could drip down into the internal electronics of the screen and cause damage. Do not apply excessive pressure while cleaning the screen. 78 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 79
out to the edge. Do not use circular motion. Compatibility with aftermarket audio systems (headphone only mode) When the Family Entertainment System (FES) detects that the original radio supplied by Ford Motor Company has been removed from the vehicle, the FES will work in a state referred to as - 2009 Ford F450 | Owner's Manual - Page 80
using the outside air in inlets. • Remove any snow, ice or leaves from the air intake area at the base of the windshield. To aid in side window defogging/demisting in cold weather: 1. Select . 2. Adjust the temperature control to maintain comfort. 80 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 81
. MANUAL HEATING AND AIR CONDITIONING SYSTEMS (IF EQUIPPED) • Manual heating and air conditioning system • Manual heating and air conditioning system with heated mirrors • Manual heating and air conditioning system with heated mirrors and heated seats 81 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 82
manually in any other airflow selection except defrost. Recirculation may turn off automatically in all airflow selections except MAX A/C. 5. A/C: Press to activate/deactivate air conditioning. Use with recirculated air off. 82 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 83
defogging and demisting in cold weather: 1. Select 2. Select A/C. 3. Set the temperature control to maintain comfort. 4. Set the fan speed to highest setting. 5. Direct the outer instrument panel vents towards the side windows. . 83 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 84
Climate Controls DUAL AUTOMATIC TEMPERATURE CONTROL (DATC) SYSTEMS (IF EQUIPPED) • DATC • DATC with heated mirrors 84 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 85
heated mirrors will turn off after 10 minutes or can be turned off by pressing the button again. Refer to Power mirrors in the Driver Controls chapter for more information. 85 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 86
off, and outside or recirculated air, to heat or cool the vehicle to reach the desired temperature. Heated seat controls: Press to turn the heated seats on and off. 16. The heated seats turn off when the ignition is turned off. 86 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 87
: 1. Select air distribution. (recirculated air). Use (recirculated air) with 2. Select A/C and A/C to provide colder airflow. 3. Set the temperature to 60°F (16°C). 4. Set highest fan speed initially, then adjust to maintain comfort. 87 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 88
In (panel) or (panel/floor) modes: 1. Move temperature control to full cold. (recirculated air). Use recirculated air with A/C to 2. Select A/C and provide colder airflow. 3. Set highest fan speed initially, then adjust to maintain comfort. To aid in side window defogging/demisting in cold weather - 2009 Ford F450 | Owner's Manual - Page 89
. The fog lamps can be turned on only when the headlamp , or control is in the position and the high beams are not turned on. Pull headlamp control towards you to turn fog lamps on. The fog lamp will illuminate. indicator light 89 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 90
under these conditions may result in a collision. High beams Push the lever toward the instrument panel to activate. Pull the lever towards you to deactivate. OFF Flash to pass Pull toward you slightly to activate and release to deactivate. 90 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 91
universal adaptor all to the same setting, such that the cross-car sight line is no longer blocked, per the instructions for the brand of mechanical aimer used. You can also aim the headlamps visually using the procedure below. 91 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 92
Lights To adjust the headlamps: 1. Park your vehicle on a level surface about 25 feet (7.6 meters) away from a vertical plain surface (3). Check your headlamp alignment at night or in a dark area so that next step to adjust it. 92 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 93
Lights 5. Locate the vertical adjuster (2) for each headlamp. Adjust the aim by turning the adjuster control either clockwise (to adjust up) or counterclockwise ) • (2) Center height of lamp to ground • (3) 25 feet (7.6 meters) 93 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 94
of the light pattern up to the horizontal line. 6. Repeat Steps 3-5 for the other headlamp. 7. Close the hood and turn off the lamps. TURN SIGNAL CONTROL • Push down to activate the left turn signal. • Push up to activate the right turn signal. 94 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 95
: • Water puddle inside the lamp • Large water droplets, drip marks or streaks present on the interior of the lens Take your vehicle to dealer for service if any of the above conditions of unacceptable moisture are present. 95 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 96
Lights Replacing exterior bulbs Check the operation of all the bulbs frequently. Function Number Trade number of in color except where noted. To replace all instrument panel lights - see your authorized dealer * Dual rear wheels, or if equipped. 96 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 97
Lights Replacing headlamp bulbs (aerodynamic) 1. Make sure that the headlamps are off and open the hood. 2. Remove the oil from your hand could cause the bulb to break the next time the headlamps are operated. Install the new bulb(s) in reverse order. 97 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 98
assembly straight out. 4. Remove the bulb assembly, (1) sidemarker or (2) park/turn by turning it counterclockwise and pulling it straight out. 5. Pull the old bulb out from the socket. Install the new bulb(s) in reverse order. 98 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus - 2009 Ford F450 | Owner's Manual - Page 99
Lights Replacing headlamp bulbs (sealed beam) 1. Make sure that the headlamps are off and open the hood. 2. Remove the three screws and one bolt from the top and bottom of the park lamp/bezel assembly. 3. Remove and open the hood. 99 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 100
headlamps are off and then open the tailgate to expose the lamp assemblies. 2. Remove the two bolts from the tail lamp assembly and carefully pull the lamp assembly from the tailgate pillar by releasing the two retaining tabs. 100 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 101
brakelamp bulbs 1. Make sure the headlamps are off. 2. Remove the two screws and lamp assembly from vehicle as wiring permits. 3. Remove the bulb socket by rotating counterclockwise. 4. Pull the bulb straight out of the socket. 101 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 102
the bulb socket counterclockwise and carefully pull to remove it from the lamp assembly. 3. Pull out the old bulb from the socket and push in the new bulb. 4. Install the bulb socket in lamp assembly by turning it clockwise. 102 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 103
pump to overheat. Check the washer fluid motor to burn out. Before operating the wiper on a dry windshield, always use the windshield washer. In freezing weather, be sure the wiper blades are not frozen to the windshield before operating the wipers. 103 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 104
. WARNING: Do not use the Tow/Haul feature when driving in icy or slippery conditions as the increased engine braking can cause the rear wheels to slide and the vehicle to swing around with the possible loss of vehicle control. 104 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus - 2009 Ford F450 | Owner's Manual - Page 105
Driver Controls ILLUMINATED VISOR MIRROR (IF EQUIPPED) Lift the mirror cover to used to secure sunglasses or a similar object and the front tab can be used for holding tickets, paper, envelopes, etc. The front bin may be used to store small objects. 105 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 106
-Cabela's Edition (if equipped) Your vehicle may be equipped with a lockable compartment in the center console and a lockable storage area under the rear seats. Center console storage Use the vehicle's ignition key to lock/unlock the compartment. 106 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 107
for operating the cigarette lighter element (if equipped). To prevent the fuse from being blown, do not use the power point(s) over the vehicle capacity of 12 VDC/180W. If the power point or cigar lighter socket is not working, a 107 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 108
Roadside Emergencies chapter for information on checking and replacing fuses. To have full capacity usage of your power point, the engine is required to be running to avoid unintentional discharge of the battery. To prevent the battery from being discharged: • do not use the power point longer than - 2009 Ford F450 | Owner's Manual - Page 109
inches or • Opening a 3rd Row Power Quarter Glass, for vehicles equipped with this option One touch down Allows the driver's window to open fully without holding the control down. Push the switch proximity of the window openings. 109 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 110
on the instrument panel behind the right-hand side of the steering wheel. • Press the right side of the control to open the window. • Pull the right side of the control to close the window. Accessory delay With accessory delay, the window switches may be used for up to 10 minutes after the ignition - 2009 Ford F450 | Owner's Manual - Page 111
the left mirror. 2. Move the control in the direction you wish to tilt the mirror. 3. Return to the center position to lock mirrors in place. The spotter mirror below the main glass (if equipped) must be adjusted manually. 111 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 112
position. 2. Momentarily pull the switch rearward to auto fold in. 3. Momentarily pull the switch rearward again to fold back to design position. Note: When powerfolding the mirrors, it is normal to hear the sound of the motors. 112 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 113
glass appears loose or vibrates when driving, it is possible that the mirrors have been manually folded or telescoped. To minimize the the motors. This will cause a loud click and the mirrors will jerk during re-synchronization. This is normal. 113 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 114
Controls Telescoping mirrors (if equipped) The telescoping feature allows the mirror to extend approximately 2.75 inches (70 mm). This feature is especially useful to the driver when towing a trailer. Mirrors can be manually . 114 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 115
P (Park) position. Press and hold the rocker control to adjust accelerator and brake pedal toward you or away from you. WARNING: Never adjust the accelerator and brake pedal with feet on the pedals while the vehicle is moving. 115 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 116
. 1. Press the ON control and release it. 2. Accelerate to the desired speed. 3. Press the SET + control and release it. 4. Take your foot off the accelerator pedal. on the 5. The indicator light instrument cluster will turn on. 116 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus - 2009 Ford F450 | Owner's Manual - Page 117
. Press and release this control to increase the vehicle set speed in small amounts by 1 mph (1.6 km/h). • Use the accelerator pedal to get to the desired speed. When the vehicle reaches that speed press and release the SET + control. 117 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 118
the speed control OFF control. Note: When you turn off the speed control or the ignition, your speed control set speed memory is erased. STEERING WHEEL CONTROLS (IF EQUIPPED) These controls allow you to operate some radio and climate control features. 118 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 119
Driver Controls Audio control features Press MEDIA to select: • AM, FM1, FM2 • CD (if equipped) • DVD (if equipped) • SAT1, SAT2 or SAT3 ( hold to forward or reverse the CD. In any mode: • Press VOL + or − to adjust volume. 119 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 120
free control features (if equipped) Press VOICE briefly until the icon appears on the voice Navigation display to use the voice command feature. to activate phone mode or Press answer a phone call. Press and to exit phone mode or end hold call. 120 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 121
, there will also be a relay box located on the driver side end of the instrument panel. See your authorized dealer for service. The relays are coded as shown in RELAY the accompanying illustration. 4 RELAY 3 RELAY 2 RELAY 1 121 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 122
. They are coded as follows: Switch AUX 1 AUX 2 AUX 3 AUX 4 Circuit number Wire color CAC05 Yellow CAC06 Green with Brown Trace CAC07 Violet with Green Trace CAC08 Brown Fuse 30A 30A 10A the vehicle with the roof fully opened. 122 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 123
, entry door locks, and home or office lighting. WARNING: When programming your HomeLink Wireless Control System to a garage door or gate, be sure that people and objects are out of the way to prevent potential injury or damage. 123 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 124
and hold the just-trained HomeLink button and observe the indicator light. • If the indicator light stays on constantly, programming is complete and your device should activate when the HomeLink button is pressed and released. 124 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 125
until the frequency signal has been accepted by the HomeLink . The indicator light will flash slowly and then rapidly after HomeLink accepts the radio frequency signal. • Proceed with Step 3 in the Programming section. 125 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 126
device to HomeLink using a HomeLink button light will begin to flash after 20 seconds. Without releasing the HomeLink button, follow Step 1 in the Programming section. For questions or comments, contact HomeLink at www.homelink.com or 1-800-355-3515. 126 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 127
to Empty • Average Fuel Economy • Setup Menu • System check • Blank Odometer/Trip odometer Refer to Gauges in the Instrument Cluster chapter. Engine hour meter (if equipped) Refer to Gauges in the Instrument Cluster chapter. 127 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus - 2009 Ford F450 | Owner's Manual - Page 128
the highway fuel economy for future reference. It is important to press the SELECT/RESET button (press and hold for two seconds in order to reset the function) after setting the speed control to get accurate highway fuel economy readings. 128 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 129
) or six months to another value, proceed to Step 3. 3. Once "OIL LIFE SET TO XXX%" is displayed, release and press the SELECT/RESET button to change the oil life start value. Each release and press will reduce the value by 10%. 129 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 130
through each of the systems being monitored. The sequence of the system check report and how it appears in the message center is as follows: 1. OIL LIFE 2. ENGINE HOURS 3. ENGINE IDLE HOURS (Diesel engine only) 4. CHARGING SYSTEM 130 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 131
Driver Controls 5. AIR FILTER (Diesel engine only) 6. DOOR AJAR 7. BRAKE SYSTEM 8. TBC GAIN = XX.X NO TRAILER (if equipped and no trailer connected) 9. TBC GAIN = XX.X OUTPUT = ////// (if equipped and trailer connected) 10. XX MILES TO E FUEL LEVEL XXX Oil Life XXX% HOLD RESET = NEW An oil change is - 2009 Ford F450 | Owner's Manual - Page 132
key is turned from off to on. Warning can be cleared by pressing the RESET button. Warning can reappear if the condition is still present. Warning will reappear on the next ignition key-cycle if the condition still exists. 132 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 133
filter drive complete (diesel engine only) Oil life change soon (gas engine only) Oil change required (gas engine only) Status PARK BRAKE ENGAGED - Displayed when the parking brake is applied (or not fully released). CHECK BRAKE SYSTEM - Displayed when a fault has been detected by the ABS module - 2009 Ford F450 | Owner's Manual - Page 134
to come on, contact your authorized dealer as soon as possible. CHECK AIR FILTER (Diesel engine only) - Refer to Instrument Cluster in your 6.0 and 6.4 Liter Power Stroke Direct Injection Turbo Diesel Owner's Guide Supplement. 134 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 135
. OK TO DRIVE (Diesel engine only) - Displayed when the time counter has reached 0 (zero) and the engine is sufficiently warm enough to drive in extremely cold weather (refer to the ENGINE WARMING description mentioned previously). 135 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 136
shows the percentage of oil life left. OIL CHANGE REQUIRED (Gas engine only) - Displayed when the oil life left reaches 0%, the OIL CHANGE REQUIRED message will be displayed. OIL LIFE OK displays after you have changed the oil. 136 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus - 2009 Ford F450 | Owner's Manual - Page 137
using the panel dimmer control when parking lamps or headlamps are on, refer to Panel dimmer control in the Lights chapter. Selectable features Reset Press this button to select and reset functions shown in the INFO menu and SETUP menu. RESET SETUP INFO 137 2009 F-250/350/450/550 (f23) Owners - 2009 Ford F450 | Owner's Manual - Page 138
on your recent driving history of 500 miles (800 km). This value is not the same as the average fuel economy display. The running average fuel economy is reinitialized to a factory default value if the battery is disconnected. RESET SETUP INFO 138 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 139
system engaged to display a stabilized average. 2. Record the highway fuel economy for future reference. It is important to press the RESET control after setting the speed control to get accurate highway fuel economy readings. Drive timer (Elapsed travel timer) Select this function from the INFO - 2009 Ford F450 | Owner's Manual - Page 140
systems being monitored. The sequence of the system check report and how it appears in the message center is as follows: 1. OIL LIFE (Gas engine only) 2. ENGINE HOURS 3. ENGINE IDLE HOURS (Diesel engine only) 4. CHARGING SYSTEM 140 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 141
Driver Controls 5. AIR FILTER (Diesel engine only) 6. DOOR AJAR 7. BRAKE SYSTEM 8. TBC GAIN = XX.X NO TRAILER (if equipped and no trailer connected) 9. TBC GAIN = XX.X OUTPUT = ////// (if equipped and trailer connected) 10. FUEL LEVEL Oil Life XXX% HOLD RESET = NEW An oil change is required whenever - 2009 Ford F450 | Owner's Manual - Page 142
the compass will correct itself after a few days of operating your vehicle in normal conditions. If the compass still appears to be inaccurate, a manual calibration may be necessary. Refer to Compass zone/calibration adjustment. 142 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 143
voltage lines. For optimum calibration, turn off all electrical accessories (heater/air conditioning, wipers, etc.) and make sure all vehicle doors are shut. 7. Press the RESET button to start the compass calibration function. 143 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 144
last selected feature if there are no more warning messages. This allows you to use the full functionality of the message center after you acknowledge the warning by pressing the RESET button and clearing the warning message. 144 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 145
by pressing the RESET button. Warning can Tire monitor fault (if equipped) reappear if the condition is still present. Warning will reappear on the Tire sensor fault (if equipped) next ignition key-cycle if the condition still exists. 145 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 146
) Exhaust filter drive complete (diesel engine only) Oil life change soon (gas engine only) Oil change required (gas engine only) PARK BRAKE ENGAGED - Displayed when the parking brake is applied (or not fully released). CHECK BRAKE SYSTEM - Displayed when a fault has been detected by the ABS module - 2009 Ford F450 | Owner's Manual - Page 147
to come on, contact your authorized dealer as soon as possible. CHECK AIR FILTER (Diesel engine only) - Refer to Instrument Cluster in your 6.0 and 6.4 Liter Power Stroke Direct Injection Turbo Diesel Owner's Guide Supplement. 147 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 148
. The diesel engine shutdown is a (Regulatory) requirement which may be required of a particular diesel vehicle for sale in States requiring this feature. ENGINE TURNED OFF (Diesel engine only) - Displayed after the 30 second countdown. 148 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 149
shows the percentage of oil life left. OIL CHANGE REQUIRED (Gas engine only) - Displayed when the oil life left reaches 0%, the OIL CHANGE REQUIRED message will be displayed. OIL LIFE OK displays after you have changed the oil. 149 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus - 2009 Ford F450 | Owner's Manual - Page 150
that remains under the pickup box. 3. Partially lower tailgate and carefully feed tailgate harness up through the gap between the pickup box and the bumper. Place the tailgate harness out of the way under the pickup box. 150 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus - 2009 Ford F450 | Owner's Manual - Page 151
the step. Note: To reduce risk of falling: • Operate step only when the vehicle is on level surface. • Operate step only in areas with sufficient lighting • Always open flip panel to widen step. 151 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 152
may be equipped with a cargo management feature in the truck bed. Note: This feature is not intended for off-road usage. To open the bed extender into tailgate mode: 1. Pull the locking pin toward the center of the vehicle. 152 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 153
Controls 2. Open the latches to release the panels. 3. Rotate the panels toward the tailgate. Repeat Steps 1-3 for the other side of the bed extender. 4. Connect the two panels, then rotate both knobs a quarter-turn clockwise to secure the panels. 153 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 154
always be kept in the grocery mode or stowed position with the tailgate closed when not in use. To open the bed extender into grocery mode, follow Steps 1-4 by rotating the panels away from the tailgate. Close the tailgate. 154 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 155
, using the manual lock button on the door, locking the driver's door with a key, by simultaneously pressing button 7 • 8 and the 9 • 0 controls on the button on the remote entry keypad (if equipped), or using the remote entry transmitter (if equipped). 155 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 156
to the on position. 2. Press the power door unlock control on the door panel three times. 3. Turn the ignition from the on position to the off position. 4. Press the power door unlock control on the door panel three times. 156 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 157
control, then press the lock control. doors. 3. Enter factory-set 5-digit entry code. 4. Press and hold the 3 • 4. accessory position. Note: The doors will not autounlock if the vehicle has been electronically locked before the driver door is opened. 157 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 158
dealer, • by using a power door unlock/lock sequence, • using a keypad procedure (if enable/disable the autounlock feature, press the lock control, then press the unlock control. The horn will chirp once if autounlock was code. 158 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 159
interference received, including interference that may cause undesired operation. Changes or modifications not expressly approved by the party responsible for compliance could void the user's authority to operate the equipment. 159 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 160
range could be caused by: • weather conditions, • nearby radio towers, • structures dealer in order to aid in troubleshooting the problem. Two step door unlocking 1. Press control on the overhead lamp is not set to the off position. 160 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 161
entry system can also control the memory seat/adjustable pedals/mirrors. to automatically move the seat, adjustable pedals and mirrors to Press the desired memory position (the seat position corresponds to the transmitter being used). 161 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 162
unlock will now recall the memory position. battery: 1. Twist a thin coin between the two halves of the remote entry transmitter near the key ring. DO NOT TAKE THE RUBBER COVER AND CIRCUIT BOARD OFF THE FRONT HOUSING OF THE REMOTE ENTRY TRANSMITTER. 162 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 163
keyless entry keypads and remote entry transmitters (maximum of four) available before beginning this procedure. Note: Do not press the brake pedal anytime during this sequencing, as doing so will invalidate the procedure. 163 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 164
lock control is pressed, or • the vehicle is locked using the keyless entry keypad (if equipped), or • after 25 seconds of illumination. Note: On some vehicles, the perimeter lamps illuminated entry feature will not activate in daylight conditions. 164 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 165
vehicle serviced by lights if: • the ignition switch is turned to the on position, or • the remote transmitter lock control is pressed, or • the 7 • 8 and the 9 • 0 controls on the keyless entry keypad are pressed, or • after 25 seconds of illumination. 165 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 166
The inside lights will not turn off if: • they have been turned on with the dimmer control, or • any door is open. The battery saver will will not recall a memory setting. Note: The factory-set code cannot be associated with a memory setting. 166 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 167
entry code. To unlock all doors, press the 3 • 4 control within five seconds. To lock all doors, press the 7 • 8 and the 9 • 0 at the same time. You do not need to enter the keypad code first. Note: The interior lamps will turn off. 167 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 168
instructions on how to program the coded key. Note: The SecuriLock™ passive anti-theft system is not compatible with non-Ford aftermarket remote start systems. Use of these systems may result in vehicle starting problems engine. 168 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 169
. If two previously programmed coded keys are not available, you must bring your vehicle to your authorized dealer to have the spare coded key(s) programmed. Please read and understand the entire procedure before you begin. 169 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus - 2009 Ford F450 | Owner's Manual - Page 170
the new coded key(s) will not start the vehicle's engine and the theft indicator will flash on and off and you may repeat Steps 1 through 5. If failure repeats, bring your vehicle to your authorized dealer to have the new spare key(s) programmed. 170 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 171
Turn the ignition to the on position with a programmed coded ignition key. Triggering the anti-theft system The armed system will be triggered if any door or hood is opened without using the key or the remote entry transmitter. 171 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 172
of a trimmed foam covering over the upper structure of the seatback. Properly adjust the seatback to an upright driving/riding position, so that the head restraint is positioned as close as possible to the back of your head. 172 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus - 2009 Ford F450 | Owner's Manual - Page 173
return the seat to the upright position. 40/20/40 split bench seat (if equipped) • Lift the track release bar to move the seat forward or backward. Ensure the seat is relatched into to quickly fold the seatback forward. 173 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 174
strap and pull the armrest down. To gain access to the storage compartment in your armrest, lift the latch to open the lid. The lid cannot be opened in the upright position. Lift up armrest to return it to a center seatback. 174 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 175
(if equipped) • Lift the bar to move avoid injuring people in a collision or sudden stop. WARNING: Always drive and ride with your seatback upright and the lap belt snug and . The control is located on the outboard side of the seat cushion. 175 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 176
, up or down. Using the manual lumbar support The lumbar support control is located on the outboard side of the seat Turn the lumbar support clockwise for more support. Turn the lumbar support counterclockwise for less support. 176 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 177
the features to the drive position. 2. Move all the memory features to the desired positions. 3. Press and hold one of the memory buttons for approximately two seconds. 4. A tone will be heard when the memory save is complete. 177 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus - 2009 Ford F450 | Owner's Manual - Page 178
it is located directly behind your head or as close to that position as possible. The head restraints can be moved up and down. Lift the head restraint so that it is located directly or as close as possible behind your head. 178 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 179
Crew Cab rear 60/40 split bench seatback is not intended to support a cargo load in the forward-folded position. To fold the seatback down, pull down the latch lever located on the bottom seatback to fold the seatback forward. 179 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 180
may become dangerous in the event of a sudden stop or collision. To gain access to the cupholders and tray, pull down on the armrest. 180 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 181
WARNING: Always drive and ride with your , even when an airbag supplemental restraint system ( using a safety belt properly. WARNING: In a rollover crash, an unbelted person is significantly more likely to die than a person wearing a safety belt. 181 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 182
buckle and one tongue that are designed to be used as a pair. 1) Use the shoulder belt on the outside shoulder only. sunny weather; they could burn a small child. Check seat covers and buckles before you place a child anywhere near 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 183
The belt will still retract to remove any slack in the shoulder belt. The automatic locking mode is not available on the driver safety belt. This mode should be used any time a child safety seat children later in this chapter. 183 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 184
Restraints How to use the automatic locking checked by an authorized dealer to verify that the "automatic locking retractor" feature for child seats is still functioning properly. In addition, all safety belts should be checked for proper function. 184 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 185
is not operating properly when checked by an authorized dealer. Failure is designed to pay out webbing in a controlled manner. This feature is designed to help reduce belt assembly under the above conditions could result in severe 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 186
it is locked in place. Safety belt with cinch tongue (Regular cab center seating position and Super Cab/Crew Cab rear center seating positions) The cinch tongue will slide up and down the so that the tongue can reach the buckle. 186 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 187
seating position and Super Cab/Crew is not twisted. If the belt is twisted, remove the twist. 3. Insert the belt tongue into the cinch tongue adjusts to your movement. However, if you brake hard, turn hard, or if your vehicle receives 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 188
and fasten the belt when not in use. Safety belt warning light and indicator chime The safety belt warning light illuminates in the instrument cluster and a chime sounds to remind the occupants to fasten their safety belts. 188 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 189
warning light illuminates and the warning chime sounds for 6 seconds every 30 seconds, repeating for approximately 5 minutes or until safety belt is buckled. The Belt-Minder feature will not activate. The Belt-Minder feature will not activate. 189 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 190
Frontal airbags are not designed to inflate in rear and side crashes or rollovers. "I'd rather be Not a good idea. People who are ejected are 40 thrown clear" times more likely to DIE. Safety belts help prevent ejection, WE CAN'T "PICK OUR CRASH". 190 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 191
vehicle's air bag system. driving the vehicle. Belt-Minder activation and deactivation procedure 1. Turn the ignition switch to the on position. (DO NOT START THE ENGINE) 2. Wait until the safety belt warning light turns off. (Approximately 1 minute) 191 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 192
the end of the webbing on the label. Also, use the safety belt extension only if the safety belt is too short for you when fully extended. WARNING: Do not use extensions to change the fit of the shoulder belt across the torso. 192 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 193
restrained in a rear seating position. WARNING: The National Highway Traffic Safety Administration (NHTSA) recommends a minimum distance of at least 10 inches (25 cm) between an occupant's chest and the driver airbag module. 193 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 194
. WARNING: Removing the blocker beam without installing snow plow attachment hardware may effect airbag deployment in a crash. Do not operate the truck unless either the blocker beam or snow plow attachment hardware is installed on the vehicle. 194 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 195
is wrong with the system. Rather, it means the forces were not of the type sufficient to cause activation. Airbags are designed to inflate in frontal and near-frontal collisions, not rollover, side-impact, or rear-impacts. 195 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 196
SRS consists of: • driver and passenger airbag modules (which include the inflators and airbags), • one or more impact and safing sensors, • a readiness light and tone • and the electrical wiring which connects the components. 196 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 197
the remote entry transmitter. The feature will continue to operate until the vehicle runs out of power. Disposal of airbags and airbag equipped vehicles See authorized dealer. Airbags MUST BE disposed of by qualified personnel. 197 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 198
in ON, have the passenger air bag switch serviced at your authorized dealer immediately. WARNING: In order to avoid inadvertent activation of the switch, always remove the ignition key from the passenger air bag ON/OFF switch. 198 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 199
was designed to work with the airbag. If you are not a person who meets the requirements stated in the NHTSA/Transport Canada deactivation criteria turning OFF the airbag can increase the risk of serious injury or death in a collision. 199 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 200
use work as a safety system with the airbags. Read all airbag warning labels in the vehicle as well as the other important airbag instructions and warnings in this Owner's Guide constantly monitor the child's condition. 2. Child age 1 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 201
can constantly monitor the child's condition. 3. Medical condition. A passenger has a medical condition which, according to his or her physician: • causes the passenger airbag to pose a special risk seat space is insufficient; or 201 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 202
their height, age and weight. Child safety restraints must be purchased separately from the vehicle. Failure to follow these instructions and guidelines may result in an increased risk of serious injury or death to your child. 202 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus - 2009 Ford F450 | Owner's Manual - Page 203
snug 4 feet 9 inches (1.45 meters) tall or and low across the greater than 80 lb (36 kg) or 100 lb hips, shoulder belt (45 kg) if recommended by child recentered across straint manufacturer) the shoulder and chest, and seatback upright. 203 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 204
(lower Weight Type and tether anchors top anchor and top tether tether ananchor) chor) Rear fac- Up to X X ing child 48 lb seat (21 kg) Forward Up to X X X facing 48 lb child seat (21 kg) Forward Over facing 48 lb X X child seat (21 kg) 204 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 205
size, height, weight, or age. Follow the child restraint manufacturer's instructions and warnings provided for installation and use in conjunction with the instructions upper part of the body and may increase the risk of injury or death in a collision. 205 2009 F-250/350/450/550 (f23) Owners Guide, - 2009 Ford F450 | Owner's Manual - Page 206
(as specified by your child safety seat manufacturer) should always properly wear safety belts. SAFETY SEATS FOR CHILDREN Infant and/or toddler seats Use a safety seat that is recommended for the size and weight of the child. 206 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 207
lap/shoulder belts: • Use the correct safety belt buckle for that seating position. • Insert the belt tongue into the proper buckle until you hear a snap and feel it latch. Make sure the tongue is securely fastened in the buckle. 207 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus - 2009 Ford F450 | Owner's Manual - Page 208
design, you may block access to certain safety only use seating airbag switch is turned off, See Passenger airbag on/off switch. WARNING: Rear facing child seats should NEVER be placed in the front seats unless the passenger airbag switch is turned off. 208 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 209
portions together, route the tongue through the child seat according to the child seat manufacturer's instructions. Be sure the belt webbing is not twisted. 4. Insert the belt tongue into is latched securely by pulling on it. 209 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 210
additional weight of the child is added to the child restraint. It also helps to achieve the proper snugness of the child seat to the vehicle. Sometimes, a slight lean towards the buckle will additionally help to remove remaining slack from the belt. 210 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 211
forward. There should be no more than one inch (2.5 cm) of movement for proper installation. 11. Ford recommends checking with a NHTSA Certified Child Passenger Safety Technician (CPST the child safety seat in the center seat. 211 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 212
use a forward-facing child seat in the front seat, move seat all the way back. WARNING: Rear facing child seats should NEVER be placed in front of an active airbag. manufacturer's instructions. Be sure that the belt webbing is not twisted. 212 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 213
to remove the remaining slack that will exist once the additional weight of remove remaining slack from the belt. 6. Attach the tether strap (if the child seat is equipped). Refer to Attaching child safety seats with tether straps later in this chapter. 213 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 214
in an appropriate child seat or with the use of a booster. 1. Lengthen the lap belt. To lengthen the belt, hold the tongue so that its bottom is perpendicular to the direction of webbing while sliding the tongue up the webbing. 214 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 215
instructions. inch (2.5 cm) of movement for proper installation. 7. Ford recommends checking with a NHTSA Certified Child Passenger Safety Technician (CPST) to make certain the child restraint is properly installed. Note: For Super use 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 216
tether anchor as shown. The tether strap may not work properly if attached somewhere other than the correct tether anchor. Once the child safety seat has been installed using the safety belt, you can attach the top tether strap. 216 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 217
to the Rear folding seat system with load floor section in this chapter for information on how to operate the rear seats. 4. Remove tether cover. 5. Clip the tether strap to the anchor as shown. • Front seats (Regular Cab) 217 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 218
the child safety seat. 7. Tighten the child safety seat tether strap according to the manufacturer's instructions. If the safety seat is not anchored properly, the risk of a child being injured in a collision greatly increases. 218 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 219
along the bottom edge of the rear window) in the SuperCab. These loops are to be used as both routing loops and anchor loops for up to three child safety seat tether straps. hook onto the loop behind an adjacent seating position. 219 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 220
seat manufacturer's instructions. A single loop can be used to route and anchor more than one child seat. For example, the center loop can be used as a seats, Ford Motor Company recommends use of a belt-positioning booster. 220 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 221
lap/shoulder safety belts fit better. They lift the child up so that the lap belt use approved booster seats until they reach age eight, a height of 4 feet 9 inches (1.45 meters) tall, or 80 lb (36 kg). Booster seats should be used 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 222
, or consider using a high back booster seat. • High back booster seats If, with a backless booster seat, you cannot find a seating position that adequately supports your child's head, a high back booster seat would be a better choice. 222 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 223
the risk of a child's head hitting a hard surface in a collision. For this reason, you should never use a booster seat with a lap belt only. It is generally best to use a booster seat with lap/shoulder belts in the back seat. 223 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 224
instructions for additional inspection and maintenance information specific to the child restraint. Ford Motor Company recommends that all safety belt assemblies in use conditions could result in severe personal injuries in the event of a collision. 224 2009 F-250/350/450/550 (f23) Owners Guide, - 2009 Ford F450 | Owner's Manual - Page 225
AWD or 4WD (when selected) has the ability to use all four wheels to power itself. This increases traction which may enable you to safely drive over terrain and road conditions that a conventional two-wheel drive vehicle cannot. 225 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 226
and drive over the crest of a hill without getting hung up or damaging underbody components. All other things held equal, a shorter wheelbase may make your vehicle quicker to respond to steering inputs than a vehicle with a longer wheelbase. 226 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 227
Regulations Part 575.104(c)(2). U.S. Department of Transportation-Tire quality grades: The U.S. Department of Transportation requires Ford Motor Company to give you the following information about tire grades exactly as the government has written it. 227 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 228
grade for this tire is established for a tire that is properly inflated and not overloaded. Excessive speed, underinflation, or excessive loading, either separately or in combination, can cause heat buildup and possible tire failure. 228 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 229
weight the vehicle can carry. • Tire Identification Number (TIN): A number on the sidewall of each tire providing information about the tire brand and manufacturing plant, tire size and date of manufacture. Also referred to as DOT code. • Inflation pressure: A measure of the amount of air in a tire - 2009 Ford F450 | Owner's Manual - Page 230
others, use a tire gauge to check pressure of all tires and adjust if required. At least once a month and before long trips, inspect each tire and check the tire pressure with a tire gauge (including spare, if equipped). Inflate all tires to the inflation pressure recommended by Ford Motor Company - 2009 Ford F450 | Owner's Manual - Page 231
Tires, Wheels and Loading under-inflation of the tires, improper tires (load range, size, or type), or vehicle modifications such as lift-kits. In the event that your vehicle experiences shimmy, you should slowly reduce speed by either lifting off the accelerator pedal or lightly applying the brakes - 2009 Ford F450 | Owner's Manual - Page 232
light truck tires. Tire service, including adjusting tire pressure, removing the tire from the wheel assembly for inspection. Do not attempt to add air to tires or replace tires or wheels without first taking precautions to protect persons and property. 232 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 233
suspected, have the tire demounted and inspected in case it needs to be repaired or replaced. For your safety, tires that are damaged or show signs of excessive wear should not be used because they are more likely to blow out or fail. 233 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 234
high loading conditions can accelerate the aging process and may require tires to be replaced more frequently. You should replace your spare tire when you replace the road tires or after six years due to aging even if it has not been used. 234 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 235
. Additionally the use of non-recommended tires and wheels could cause steering, suspension, axle or transfer case/power transfer unit failure. If you have questions regarding tire replacement, contact your authorized dealer as soon as possible. 235 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 236
vehicle. It is recommended that the two front tires or two rear tires generally be replaced as a pair. The tire pressure sensors mounted in the wheels are not designed to be used in aftermarket wheels. The use of wheels or tires not recommended by Ford Motor Company may affect the operation of your - 2009 Ford F450 | Owner's Manual - Page 237
wheel drive (FWD) vehicles and those with an independent rear suspension (if equipped) may require alignment of all four wheels. The tires should also be balanced periodically. An unbalanced tire and wheel assembly may result in irregular tire wear. 237 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 238
have a dissimilar spare tire/wheel it is intended for temporary use only and should not be used in a tire rotation. Note: After having your tires rotated, inflation pressure must be checked and adjusted to the vehicle requirements. 238 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 239
you have a dissimilar spare tire/wheel it is intended for temporary use only and should not be used in a tire rotation. Note: After having your tires rotated, inflation pressure must be checked and adjusted to the vehicle requirements. 239 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 240
or rim diameter in inches. If you change your wheel size, you will have to purchase new tires to match the new wheel diameter. 6. 95: Indicates the tire's load index. It is an index that relates to how much weight a tire can carry. You may find this information in your Owner's Guide. If not, contact - 2009 Ford F450 | Owner's Manual - Page 241
of 2001. The numbers in between are identification codes used for traceability. This information is used to contact customers if a tire defect requires a recall. 9. M+S or M/S: Mud and Snow, or AT: All Terrain, or AS: All Season. 241 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 242
's door. The cold inflation pressure should never be set lower than the recommended pressure on the vehicle label. The tire suppliers may have additional markings, notes or warnings such as standard load, radial tubeless, etc. 242 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus - 2009 Ford F450 | Owner's Manual - Page 243
(a total of six or more tires on the vehicle). 4. Maximum Load Single lb. (kg) at psi (kPa) cold: Indicates the maximum load and tire pressure when the tire is used as a single; defined as two tires (total) on the rear axle. 243 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 244
containing tire inflation pressure by tire size and other important information located on the B-Pillar or the edge of the driver's door. Refer to the payload description and graphic in the Vehicle loading - with and without a trailer section. 244 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 245
functioning properly. Always check the TPMS malfunction indicator after replacing one or more tires or wheels on your vehicle to ensure that the replacement or alternate tires and wheels allow the TPMS to continue to function properly. 245 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 246
It is recommended that you always have your tires serviced by an authorized dealer. The tire pressure should be checked periodically (at least monthly) using an accurate tire gauge, refer to Inflating your tires in this chapter. 246 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 247
. To restore the full functionality of the Tire Pressure Monitoring System, have the damaged road wheel/tire repaired and remounted on your vehicle. For additional information, refer to Changing tires with TPMS in this section. 247 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 248
not in use and the light remains ON, have the system inspected by your authorized dealer. On vehicles with different front and rear tire pressures, the TPMS system must be retrained following every tire rotation. Refer to Tire rotation in this chapter. 248 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 249
as necessary.) Check air pressure in the road tires. If any tire is under-inflated, carefully drive the vehicle to the nearest location where air can be added to the tires. Inflate all the tires to the recommended inflation pressure. 249 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 250
front and rear tires. TPMS reset tool A special TPMS reset tool to reset your TPMS after tire rotation is provided with vehicles that have different front and rear tire pressures. The tool is located with your Owner's Guide materials. 250 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 251
functions (the battery is not replaceable), please contact your authorized dealer to obtain a replacement. To verify that your TPMS reset tool is working, press and release the button on the center of the TPMS tool. The red light should illuminate 251 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 252
seconds. 1. Place the ignition in the off position and keep the key in the ignition. 2. Press and release the brake pedal. 3. Cycle the ignition from off to on three (3) times ending in the on position-DO NOT start the engine. 252 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 253
TRAIN LEFT FRONT TIRE. If after repeated attempts to enter the reset mode, the horn does not does not flash and the message center sound, the TPMS indicator does not display TRAIN LEFT FRONT TIRE, seek service from your authorized dealer. 253 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 254
heard, move the vehicle to rotate the wheels at least a 1⁄4-turn and repeat the procedure starting with Step 1. • If a double horn chirp is heard even after the wheels were repositioned, seek service from your authorized dealer. 254 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 255
(of the same size and specifications) be used, as chains may chip aluminum wheels. Follow these guidelines when using snow tires and chains: • Use only SAE Class S chains. • Install chains securely, verifying that the chains do not touch any wiring, brake lines or fuel lines. • Drive cautiously. If - 2009 Ford F450 | Owner's Manual - Page 256
plant. If any aftermarket or authorized-dealer installed equipment has been installed on the vehicle, the weight of the equipment must be subtracted from the payload listed on the Tire Label in order to determine the new payload. 256 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 257
your vehicle, do not add more cargo, even if there is space available. Overloading or improperly loading your vehicle can contribute to loss of vehicle control and vehicle rollover. Example only: 257 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 258
Tires, Wheels and Loading Cargo Weight - includes all weight added to the Base Curb Weight, including cargo and optional equipment. When towing, trailer tongue load or king pin weight is also part of cargo weight. GAW (Gross Axle Weight) - is the total weight placed on each axle (front and rear) - - 2009 Ford F450 | Owner's Manual - Page 259
including all cargo and passengers - that the vehicle can handle without risking damage. (Important: The towing vehicle's braking system is rated for operation at GVWR, not at GCWR.) Separate functional brakes should be used for 259 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 260
XXX kg or XXX lb." on your vehicle's placard. 2. Determine the combined weight of the driver and passengers that will be riding in your vehicle. 3. Subtract the combined weight of the driver and passengers from XXX kg or XXX lb. 260 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 261
Tires, Wheels - 198 540 = -103 kg. You will need to reduce the load weight by at least 240 lb. (104 kg). If you remove 3-100 lb. (45 kg) cement bags, then the load calculation would be: 1400 - (2 x 220) - (9 - 198 - 405 = 32 kg. 261 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 262
trucks with aftermarket equipment: Weigh your vehicle at a certified scale and subtract this actual curb weight, hitch hardware, and the driver's weight from the GCWR listed for your vehicle series, engine, transmission and drive axle ratio (refer to 262 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 263
trailer and hitch used. These additional maximum trailer weight and tongue load limitations are listed in the chart/table that follows the listing of GCWRs. Towing a trailer places an additional load on your vehicle's engine, transmission, axle, brakes, tires and suspension. Inspect these components - 2009 Ford F450 | Owner's Manual - Page 264
Tires, Wheels and Loading Engine Maximum GCWR - lb. (kg.) Rear axle Manual Automatic ratio transmission transmission F-350 Dual Rear Wheel (DRW) Pick-up 4.10 17500 (7938) 18500 (8391) 4.10 20500 (9299) 21500 (9752) 4.30 22500 (10206) 23000 (10433) F-350 Single Rear Wheel (SRW) Chassis Cab 3.73 15000 - 2009 Ford F450 | Owner's Manual - Page 265
or use hitches that clamp onto the vehicle's bumper or attach to the axle. You must distribute the load in your trailer so that 10%-15% for conventional towing or 15%-25% fifth-wheel towing of the total weight of the trailer is on the tongue. 265 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 266
a trailer using a load equalizing hitch, always use the following procedure: 1. Park the unloaded vehicle on a level surface. With the ignition on and all doors closed, allow the vehicle to stand for several minutes so that it can level. 266 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 267
rated for operation at the GVWR not GCWR. Integrated trailer brake controller (if equipped) Your vehicle may be equipped with a fully integrated electronic Trailer Brake Controller (TBC). When used properly, the TBC helps ensure 267 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus - 2009 Ford F450 | Owner's Manual - Page 268
Tires, Wheels and Loading smooth and effective trailer braking by powering the trailer's electric brakes with a proportional output based on the towing vehicle's brake pressure. WARNING: The Ford TBC has only been verified to be compatible with trailers having electric-actuated drum brakes (one to - 2009 Ford F450 | Owner's Manual - Page 269
display in the instrument cluster message center. 4. Use the GAIN adjustment (+/-) buttons to increase or decrease the GAIN setting to the desired starting point. A GAIN setting of 6.0 is a good starting point for heavier loads. 269 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 270
lever on the TBC should be used only for manual activation of trailer brakes to assist with proper adjustment of the GAIN. Misuse, such as application during trailer sway, could cause instability of trailer and/or tow vehicle. 270 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 271
stops and brake gradually. • Do not exceed the GCWR rating or transmission damage may occur. • Your vehicle may be equipped with a temporary or conventional spare tire. If the spare tire is different in size (diameter and/or width), tread 271 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 272
direction. Loading • Keep the center-of-gravity low for best handling. • Trailer loads should be evenly distributed front to back and left to right. 272 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 273
that 10%-15% of the trailer weight is on the hitch. (15%-25% for fifth-wheel or gooseneck towing.) • Never exceed truck, trailer, receiver, ball, tongue, tire or coupler loading recommendations. Braking • The trailer brakes must be inspected and serviced at intervals specified by the manufacturer - 2009 Ford F450 | Owner's Manual - Page 274
Put your climate control system in recirculated air mode to prevent exhaust fumes from entering the vehicle. Refer to the Climate controls chapter for more information. Transmission Manual Automatic Manual Drivetrain configuration 4x4 with manual-shift transfer case 4X2 or 4x4 with electronic-shift - 2009 Ford F450 | Owner's Manual - Page 275
and allows key removal. 2. Accessory- allows the electrical accessories such as the radio to operate while the engine is not running. This position also unlocks the steering wheel. 3. On- all electrical circuits operational. Warning lights illuminated. Key position when driving. 4. Start- cranks the - 2009 Ford F450 | Owner's Manual - Page 276
from the air induction inlet. The following starting instructions are for vehicles equipped with a gasoline engine; if your vehicle is equipped with a Diesel engine, refer to Starting the engine in your 6.0 and 6.4 Liter Power Stroke Direct Injection Turbo Diesel Owner's Guide Supplement. Before - 2009 Ford F450 | Owner's Manual - Page 277
key as soon as the engine begins cranking. Your vehicle has a computer assisted cranking system that assists in starting the engine. After releasing the key from the 4 (start) position, the engine may continue cranking for up to 277 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus - 2009 Ford F450 | Owner's Manual - Page 278
to follow engine block heater instructions could result in property damage or physical harm. WARNING: To reduce the risk of electrical shock, do not use your heater with ungrounded electrical systems or two-pronged (cheater) adapters. 278 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 279
block heater, especially the cord, is in good condition before use. • Make sure that when in operation, the extension cord plug /engine block heater the engine block heater system checked during your fall tune-up to be sure it's in good working order. 279 2009 F-250/350/450/550 (f23) Owners Guide, - 2009 Ford F450 | Owner's Manual - Page 280
during ABS braking; any pulsation or mechanical noise you may feel or hear is normal. In addition, the ABS performs a self-check after you start the engine and begin to drive away. A brief mechanical noise may be heard during this test. This is normal. 280 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 281
Driving ABS warning lamp The ABS lamp in the instrument cluster momentarily illuminates ABS when the ignition is turned on. If the light does not illuminate during start up, remains on or flashes, the ABS may be disabled and may need to be serviced. Even when the ABS is disabled, ! P normal braking - 2009 Ford F450 | Owner's Manual - Page 282
, the traction control light will illuminate and the engine will not "rev-up" when you push further on the accelerator. This is normal system behavior and should be no reason for concern. Also, if traction control is on when the vehicle is put 282 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 283
low power steering pump fluid level before seeking service by your dealer. • Heavy or uneven efforts may be caused by low power steering fluid. Check for low power steering pump fluid level before seeking service by your dealer. 283 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 284
person is significantly more likely to die than a person wearing a seat belt. Utility vehicles and trucks have larger tires and increased ground clearance, giving the vehicle a higher center of gravity than a passenger car. 284 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 285
and the brake pedal depressed: 1. Apply the parking brake. Turn the ignition key to 1 (off), then remove the key. Locate the access cover plate for the brake-shift interlock override. It is located on top of the steering column shroud. 285 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 286
position and remove the key whenever you leave your vehicle. WARNING: If the parking brake is fully released, but the brake warning lamp remains illuminated, the brakes may not be working properly. See your authorized dealer as soon as possible. 286 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 287
shifting into and out of R (Reverse). N (Neutral) With the gearshift lever in N (Neutral), the vehicle can be started and is free to roll. Hold the brake pedal down while in this position. 287 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 288
driving position for the best fuel economy use the Tow/Haul feature when driving in icy or slippery conditions as the increased engine braking can cause the rear wheels to slide and the vehicle to swing around with the possible loss of vehicle control. 288 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 289
or damage to the transmission may occur. Do not rock the vehicle for more than a minute or damage to the transmission and tires may occur, or the engine may overheat. MANUAL TRANSMISSION OPERATION (IF EQUIPPED) R 1 3 D L 2 4 289 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 290
not overspeed the engine when going downhill or steep grades. If equipped, use the tachometer and do not allow engine speed to exceed the redline area. Operating the engine beyond the recommended speeds can cause severe engine damage. 290 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 291
Driving Shift according to the following shift speed charts: Upshifts when accelerating (recommended for best fuel economy) 6-speed a stop. Use 2H or 4H for 4WD equipped vehicles. Downshift at lower speeds when driving on slippery 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 292
, particularly those close to the ground. WARNING: Certain add-on devices such as large trailer hitches, bike or surfboard racks and any device that may block the normal detection zone of the RSS system may create false beeps. 292 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 293
the truck bed protrude rearward outside the bed. The RSS automatically turns on when the gearshift lever is placed in R (Reverse) and the ignition is on. An RSS control sensors are covered, it will affect the accuracy of the RSS. 293 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 294
Driving If your vehicle sustains damage to the rear bumper/fascia, leaving it and/or road condition. • (1) Rear bumper • (2) Red zone • (3) Yellow zone • (4) Green zone • (5) Centerline of vehicle Always use caution while backing. 294 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 295
distorted, it may be covered with water droplets, snow, mud or any other substance. If this occurs, clean the camera lens before using the camera system. WARNING: higher speeds might limit your reaction time to stop the vehicle. 295 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 296
can be selected when additional driving power is desired. 4WD operation is not recommended on dry pavement. Doing so could result in difficult disengagement of the transfer case, increased tire wear and decreased fuel economy. 296 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus - 2009 Ford F450 | Owner's Manual - Page 297
equipped with wheel ornaments that cover the 4x4 manual hub lock. These ornaments must be removed to access the manual hub locks. Electronic Shift On the Fly (ESOF) 4x4 system (if equipped) If equipped with the electronic shift 4WD System, and the instrument panel control is moved to 4X4 LOW while - 2009 Ford F450 | Owner's Manual - Page 298
). • 4x4 LOW - momentarily 4x4 illuminates when the ignition is LOW turned to the ON position. Illuminates when 4L (4x4 Low) is engaged. Flashes when shifting into or out of 4L (4x4 Low) or if the range shift conditions are not met (ESOF systems only). 298 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 299
on-road driving. Sends power to the rear wheels only. 4H (4x4 High) - For winter and off-road conditions. Sends power to front and rear wheels. This mode is not intended for use on dry pavement. N (Neutral) - Only used when towing the vehicle. 4L (4x4 Low) - For low-speed off-road applications - 2009 Ford F450 | Owner's Manual - Page 300
2H (2WD). 4H 4. If the transfer case will not N engage into 4H (4x4 High) or 2H (2WD), perform a shift with the 4L transmission in N (Neutral) (or clutch pedal depressed) and the vehicle rolling at a speed below 5 mph (8 km/h). 300 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 301
This is normal. 2WD - For general on-road driving. Sends power to the rear wheels only. 4x4 HIGH - For winter and off-road conditions. Sends power to front and rear wheels. This mode is not intended for use on dry pavement. 4x4 LOW - For low-speed off-road applications that require extra power such - 2009 Ford F450 | Owner's Manual - Page 302
4x4 HIGH with the rear wheels slipping. Shifting from 4x4 HIGH to 2WD Rotate the 4x4 control to 2WD at any forward speed. Disengagement of the transfer case and front hubs may be delayed due to torque bind which is caused by driving on dry hard surfaces or performing tight turns while using the 4x4 - 2009 Ford F450 | Owner's Manual - Page 303
Driving 3. Move the 4x4 control to the 4x4 LOW position. 4. Hold the shift conditions until the 4x4 LOW indicator light illuminates. 5. If the 4x4 LOW indicator light flashes continuously for more than 10 seconds, allow the vehicle to move at a speed below 5 mph (8 km/h), then repeat steps 2 through - 2009 Ford F450 | Owner's Manual - Page 304
and braking control of your vehicle, you must have all four wheels on the ground and they must be rolling, not sliding or spinning. Basic operating principles • Do not use 4WD on dry, hard surfaced roads. Doing so will produce excessive noise, increase tire wear and may damage drive components - 2009 Ford F450 | Owner's Manual - Page 305
control, vehicle rollover and/or personal injury. Use all available road surface to return the vehicle to a safe direction of travel. • In the event of an emergency stop, avoid skidding the tires and do not attempt any sharp steering wheel movements. 305 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 306
illuminated, the brakes may not be working properly. See your authorized dealer. 4WD Systems 4WD (when you select a 4WD mode), uses all four wheels to power the vehicle. This increases traction, enabling you to drive over terrain and road conditions that a conventional two-wheel drive vehicle cannot - 2009 Ford F450 | Owner's Manual - Page 307
slowly while applying light pressure on the brake pedal. Be cautious of sudden changes in vehicle speed or direction when you are driving in mud. Even 4WD vehicles can lose traction in slick mud. As when you are driving over sand, apply the accelerator slowly and avoid spinning your wheels. If the - 2009 Ford F450 | Owner's Manual - Page 308
over. Whenever driving on a hill, determine beforehand the route you will use. Do not drive over the crest of a hill without seeing what conditions are on the other side. Do not drive in reverse over a hill without the aid of an observer. 308 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 309
a 4WD vehicle may accelerate better than a two-wheel drive vehicle in snow and ice, it won't stop any faster, because as in other vehicles, braking occurs at all four wheels. Do not become overconfident as to road conditions. 309 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 310
or removing parts (such as lift kits or stabilizer bars) or by using replacement parts not equivalent to the original factory equipment. Any modifications to a vehicle that raise the center of gravity can make it more likely the vehicle will roll over as a result of a loss of control. Ford Motor - 2009 Ford F450 | Owner's Manual - Page 311
and proper operation. Ford Super Duty Vehicles are qualified for use as a stationary power source, within limits detailed in the Ford Truck Body Builders Layout Book, found at www.fleet.ford.com/truckbbas, and through the Ford Truck Body Builders Advisory Service. Gas engine vehicles are qualified - 2009 Ford F450 | Owner's Manual - Page 312
Driving SNOWPLOWING Ford recommends that the Super Duty F-Series used for snow removal include the Snow Plow Package Option. Installing the snowplow Weight limits and guidelines for selecting and installing the snowplow can be found in the Ford Truck Body Builders Layout Book, Snowplow section, - 2009 Ford F450 | Owner's Manual - Page 313
vehicle and the snow removal equipment as well as possible airbag deployment. WARNING: Do not attempt to service, repair, or modify the air bag supplemental restraint system (SRS) or its fuses. See your Ford or Lincoln Mercury dealer. 313 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 314
5 mph (8 km/h). • Shift transfer case to 4x4 HIGH (4WD High) when plowing larger areas or light snow at higher speeds. Do not exceed 15 mph (24 km/h). • Do not shift the transmission from a forward gear to R (Reverse) until the engine is at idle and the wheels are stopped. • If the vehicle is stuck - 2009 Ford F450 | Owner's Manual - Page 315
Owner Guide portfolio. Roadside assistance will cover: • a flat tire change with a good spare (except vehicles that have been supplied with a tire inflation kit) • battery jump start • lock-out assistance (key replacement cost is the customer's responsibility) • fuel delivery - Independent Service - 2009 Ford F450 | Owner's Manual - Page 316
signals will flash. Press the flasher control again to turn them off. Use it when your vehicle is disabled and is creating a safety hazard for other motorists. Note: With extended use, the flasher may run down your battery. 316 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 317
ignition off. 2. Check the fuel system for leaks. 3. If no leaks are apparent, reset the switch by pushing in on the reset button. 4. Turn the ignition on. 5. Wait a few seconds and return the key to off. 6. Make another check for leaks. 317 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 318
Grey Violet Pink Tan Brown Red Blue Yellow Natural Green Maxi fuses Yellow - Green Orange Red Blue Tan Natural Cartridge Fuse link maxi cartridge fuses Blue Blue - - Pink Pink Green Green Red Red - Yellow - Brown - Black 318 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 319
servicing high current fuses. Always replace the cover to the passenger compartment fuse panel before reconnecting the battery. If the battery has been disconnected and reconnected, refer to the Battery section of the Maintenance and Specifications chapter. 319 2009 F-250/350/450/550 (f23) Owners - 2009 Ford F450 | Owner's Manual - Page 320
System (FES) Not used (spare) Keypad illumination, Brake-Shift Interlock (BSI), SPBJB Turn signals Left headlamp (Low beam) Right headlamp (Low beam) Interior lighting, Lighted running boards Cargo lamp, Puddle lamp, Switch backlight 320 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 321
Diesel engine), Engine compartment starter relay diode (gasoline engines) Radio Not used (spare) Not used (spare) Not used (spare) Restraints Control Module (RCM), Passenger Airbag Deactivation Indicator 321 26 27 10A 20A 28 29 30 31 32 5A 5A 5A 10A 10A 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 322
tow brake controller, Trailer tow battery charge relay coil Not used (spare) Reverse Sensing System (RSS), 4x4 module, 4x4 solenoid, Traction control switch, Tow/Haul switch (Diesel engine) Passive Anti-Theft System (PATS) transceiver, Cluster control Dual automatic or Manual climate control, PTC - 2009 Ford F450 | Owner's Manual - Page 323
(ESOF) Lo-Hi Heater mirror Not used Trailer Brake Controller (TBC) ABS module (Pump) Upfitter auxiliary switch #1 Upfitter auxiliary switch #2 ABS module (Coil) Cigar lighter Instrument panel power point Brake On/Off (BOO) relay feed 323 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 324
16 17 18 Fuse Amp Rating 5A** - - Relay Relay Relay Protected Circuits Brake switch, Brake switch relay coil, SJB module, 4x4 module Not used Not used A/C clutch Wipers Fuel Pump Driver Module (FPDM), Fuel injectors (Gasoline engines), Diesel Fuel Control Module (DFCM) (Diesel engine) Back-up lamps - 2009 Ford F450 | Owner's Manual - Page 325
only) ESOF relay hi-lo Wiper motor PCM relay coil, PCM relay (Gasoline engines only) Not used Not used PCM power bus (Fuses 68, 70, 72, 74, 76) (Diesel engine only) Starter solenoid Trailer tow park lamps Trailer tow battery charge Power Distribution Box (PDB) bus (fuses 67, 69, 71, 73, 75, 77 - 2009 Ford F450 | Owner's Manual - Page 326
, VCT, IMTV Diesel engine: VPWR: Engine loads Back-up relay coil power Gasoline engines: VPWR: PCM Diesel engine: VPWR: ECM ABS module logic 71 72 73 74 5A** 15A** 2A** 20A** 75 76 5A** 20A** 77 10A** * Cartridge fuses ** Mini fuses 326 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 327
in brand, size or appearance from the road tires and wheels and can be one of three types: 1. T-type mini-spare: This spare tire begins with the letter "T" for tire size and may have "Temporary Use Only" molded in the sidewall 327 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 328
full-size dissimilar spare tire/wheel, do not: • Exceed 70 mph (113 km/h) • Use more than one dissimilar spare tire/wheel at a time • Use commercial car washing equipment • Use snow chains on the end of the vehicle with the dissimilar spare tire/wheel 328 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 329
camper body • Driving vehicles with a load on the cargo rack Drive cautiously when using a full-size dissimilar spare tire/wheel and seek service as soon as possible. Spare tire information Note: If your vehicle is equipped the tire pressure monitoring system (TPMS), the system indicator light will - 2009 Ford F450 | Owner's Manual - Page 330
: Place gearshift lever in R (Reverse). • Electronic Shift-On-the-Fly (ESOF) 4x4: Place transfer case in 4x4 HIGH or 4x4 LOW before turning off the engine. • Manual shift transfer case 4x4: Place transfer case in 4H or 4L. 330 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 331
box Under the jack tool kit Jack handle, lug wrench, lug wrench extension (only available on Dual Rear Wheel [DRW] vehicles) and wheel chock (only available on Single Rear Wheel [SRW] vehicles equipped with a diesel engine) Key and spare tire lock Jack instruction sheet Removing the spare tire - 2009 Ford F450 | Owner's Manual - Page 332
is in P (Park) (automatic transmission) or R (Reverse) (manual transmission). To help prevent the vehicle from moving when you change the tire, be sure that the parking brake is set and the diagonally opposite wheel is blocked. 332 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 333
danger of being hit when operating the jack or changing the wheel. 1. Turn engine off and block the wheel that is diagonally opposite of the flat tire using the wheel chock, if equipped. If the vehicle is a 4x4, lock the manual hub on the wheel. 2. Remove the jack, jack handle, lug wrench and spare - 2009 Ford F450 | Owner's Manual - Page 334
the jack fits onto the flat area on the outboard side of the differential. • Front passenger side (4x4) Note: View shown from the rear of the vehicle to clearly identify the jack point. Place the jack directly under the axle. 334 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 335
any part of your body under the vehicle while changing a tire. Do not start the engine when your vehicle is on the jack. The jack is only meant for changing the tire. 7. Turn the jack handle clockwise until the wheel is completely off the ground and high enough to install the spare tire. 8. Remove - 2009 Ford F450 | Owner's Manual - Page 336
to the following guides: • Front (4x2): F-350 DRW Note: Place jack directly under I-beam. • Front driver side (4x4): F-350 DRW Note: Make sure the jack fits onto the flat area on the outboard side of the differential housing. 336 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 337
rear of the vehicle to clearly identify the jack point. Note: Place the jack directly under axle and inboard of the radius arm so that the jack clears the radius arm. • Front: F-450/F-550 • Rear: F-350 DRW • Rear: F-450/F-550 337 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 338
14. Use an up-and-down motion with the jack handle to raise the wheel completely off the ground. Hydraulic jacks are equipped with a pressure release valve that prevents lifting loads which exceed the jack's rated capacity. 15. Remove the lug nuts with the lug wrench. 16. Replace the flat tire with - 2009 Ford F450 | Owner's Manual - Page 339
tire and wheel using the spare tire winch mechanism; store the flat in the bed of the truck. 20. Stow the jack, jack handle and lug wrench. Make sure the jack is securely fastened so it does not rattle when driving. 21. Unblock the wheels. The following step applies to F-250/F-350 Single Rear Wheel - 2009 Ford F450 | Owner's Manual - Page 340
ornament so that all of the retention clips are sitting on the flange of the lug nuts. 2 3. Use your hand or rubber mallet to tap the ornament in a star pattern. There should be an even gap between the ornament and the wheel. 340 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 341
on the ground with the valve stem facing in the direction specified on the Tire Changing Instructions located in the glove box. 2. Slide the wheel partially under the vehicle and install the retainer through the wheel center. Pull on the cable to align the components at the end of the cable. 3. Turn - 2009 Ford F450 | Owner's Manual - Page 342
(tire rotation, changing a flat tire, wheel removal, etc.). Wheel lug nut torque* lb.ft. N•m M14 x 1.5 165 224 * Torque specifications are for nut and bolt threads free of dirt and rust. Use only Ford recommended replacement fasteners. On all two-piece flat wheel nuts, apply one drop of motor oil - 2009 Ford F450 | Owner's Manual - Page 343
update transmission operation. 1. Use only a 12-volt supply to start your vehicle. 2. Do not disconnect the battery of the disabled vehicle the parking brake on both vehicles and stay clear of the engine cooling fan and other moving parts. 343 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 344
of the discharged battery. Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery. 2. Connect the other end of the positive (+) cable to the positive (+) terminal of the assisting battery. 344 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 345
be jumped. A spark may cause an explosion of the gases that surround the battery. 5. Ensure that the cables are clear of fan blades, belts, moving parts of both engines, or any fuel delivery system parts. 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - - - + + + + - 345 - 2009 Ford F450 | Owner's Manual - Page 346
metal surface. Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery. 2. Remove the jumper cable on the negative (-) connection of the booster vehicle's battery. 346 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - - - - + + + + - 2009 Ford F450 | Owner's Manual - Page 347
from the positive (+) terminal of the disabled vehicle's battery. After the disabled vehicle has been started and the jumper cables removed, allow it to idle for several minutes so the engine computer can relearn its idle conditions. 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus - 2009 Ford F450 | Owner's Manual - Page 348
equipment. Do not tow with a slingbelt. Ford Motor Company has not approved a slingbelt towing procedure. On 4x2 vehicles, it is acceptable to tow the vehicle with the front wheels on the ground and the rear wheels off the ground using a wheel lift On 4x4 vehicles, it is recommended that your - 2009 Ford F450 | Owner's Manual - Page 349
transmission. Note: On Dual Rear Wheel (DRW) vehicles, an outer rear wheel must be removed prior to using a wheel lift wrecker. Ford Motor Company produces a towing manual for all authorized tow truck operators. Have your tow truck operator refer to this manual for proper hook-up and towing - 2009 Ford F450 | Owner's Manual - Page 350
at www.genuineservice.com. • U.S. dealer locator by Dealer Name, City/State, or Zip Code • Owner Guides • Maintenance Schedules • Recalls • Ford Extended Service Plans • Ford Genuine Accessories • Service specials and promotions. 350 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 351
located • The vehicle's current odometer reading In some states, you must directly notify Ford in writing before pursuing remedies under your state's warranty laws. Ford is also allowed a final repair attempt in some states. 351 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 352
Plaza Drive Mail Drop 3NE-B Dearborn, MI 48126 THE BETTER BUSINESS BUREAU (BBB) AUTO LINE PROGRAM (U.S. ONLY) Your satisfaction is important to Ford Motor Company and to your dealer. If a warranty concern has not been resolved using the three-step 352 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 353
receipt, the BBB will review the claim for eligibility service concern have been unsatisfactory, Ford of Canada participates in an impartial third party mediation/arbitration program administered by the Canadian Motor Vehicle Arbitration Plan (CAMVAP). 353 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 354
to a foreign country, contact the appropriate foreign embassy or consulate. These officials can inform you of local vehicle registration regulations and where to find unleaded fuel. 354 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 355
, contact a regional office or owner relations/customer relationship office. The use of leaded fuel in your vehicle without proper conversion may damage the effectiveness of your emission control system and may cause engine knocking or serious engine damage. Ford Motor Company/Ford of Canada is not - 2009 Ford F450 | Owner's Manual - Page 356
Customer Assistance Obtaining a French owner's guide French Owner's Guides can be obtained from your authorized dealer or by writing to: Ford Motor Company of Canada, Limited Service Publications CHQ202 The Canadian Road P.O. Box 2000 Oakville, ON, Canada L6J 5E4 REPORTING SAFETY DEFECTS (U.S. ONLY) - 2009 Ford F450 | Owner's Manual - Page 357
bumpers and other chrome parts; allow the cleaner to dry for a few minutes, then wipe off the haze with a clean, dry rag. • Never use abrasive materials such as steel wool or plastic pads as they can scratch the chrome surface. 357 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus - 2009 Ford F450 | Owner's Manual - Page 358
the correct color. • Remove particles such as bird droppings, tree sap, insect deposits, tar spots, road salt and industrial fallout before repairing paint chips. • Always read the instructions before using the products. ALUMINUM WHEELS AND WHEEL COVERS Aluminum wheels and wheel covers are coated - 2009 Ford F450 | Owner's Manual - Page 359
and pressure rinse clean. • Never wash or rinse the engine while it is running; water in the running engine may cause internal damage. • Cover the highlighted areas to prevent water damage when cleaning the engine. • 5.4L V8 gasoline engine 359 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 360
gasoline engine PLASTIC (NON-PAINTED) EXTERIOR PARTS Use only approved products to clean plastic parts. These products are available from your authorized dealer. • For routine cleaning, use Motorcraft Detail Wash (ZC-3-A). • If tar or grease spots are present, use Motorcraft Bug and Tar Remover (ZC - 2009 Ford F450 | Owner's Manual - Page 361
remove the hot wax deposited on the wiper blade and windshield from automated car wash facilities. Be sure to replace wiper blades when they appear worn or do not function properly. • Do not use abrasives, as they may cause scratches. • Do not use fuel, kerosene, or paint thinner to clean any parts - 2009 Ford F450 | Owner's Manual - Page 362
23). For removal of fine scuffs and scratches, use Scotch-Britet use exterior paint waxes or sealants. Dust the low gloss areas with a clean, dry cloth, or use Motorcraft Dusting Cloth (ZC-24 or ZC-25) or Motorcraft Dusting Cloth Mitts (ZC-47). 362 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 363
coating on the seat. Note: In some instances, color or dye transfer can occur when wet clothing comes in contact with leather upholstery. If this occurs, the leather should be cleaned immediately to avoid permanent staining. 363 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 364
covers and should be considered as proof of a genuine leather product. In order to lessen the appearance of certain scratches and other wear marks, apply conditioner on the affected area following the same instructions as in the Conditioning section. 364 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 365
Bug and Tar Remover (ZC-42) Motorcraft Car Care Kit (ZC-26) Motorcraft Car Wash (Canada only) (CXC-83) Motorcraft Custom Bright Metal Cleaner (ZC-15) Motorcraft Custom Clear Coat Polish (ZC-8-A) Motorcraft Custom Vinyl Protectant (ZC-40-A) 365 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 366
-Clear Spray Glass Cleaner (ZC-23) Vinyl Cleaner (Canada only) (CXC-93) Vinyl Conditioner (Canada only) (CXC-94) Wash and Wax (Canada only) (CXC-95) Wheel and Tire Cleaner (ZC-37-A) 366 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 367
) material away from the battery and all fuel related parts. Working with the engine off • Automatic transmission: 1. Set the parking brake and shift to P (Park). 2. Turn off the engine and remove the key. 3. Block the wheels. • Manual transmission: 1. Set the parking brake, depress the clutch pedal - 2009 Ford F450 | Owner's Manual - Page 368
Maintenance and Specifications 2. Block the wheels. WARNING: To reduce the risk of vehicle damage and/or personal burn injuries, do not start your engine with the air cleaner removed and do not remove it while the engine is running. OPENING THE HOOD 1. Inside the vehicle, pull the hood release - 2009 Ford F450 | Owner's Manual - Page 369
2. Battery 3. Transmission fluid dipstick (automatic transmission) 4. Engine oil filler cap 5. Engine oil dipstick 6. Power steering fluid reservoir 7. Brake fluid reservoir 8. Engine coolant reservoir 9. Air filter assembly 10. Power distribution box 369 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 370
2. Battery 3. Transmission fluid dipstick (automatic transmission) 4. Engine oil filler cap 5. Engine oil dipstick 6. Power steering fluid reservoir 7. Brake fluid reservoir 8. Engine coolant reservoir 9. Air filter assembly 10. Power distribution box 370 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 371
the reservoir completely. Only use a washer fluid that meets Ford specification WSB-M8B16-A2. Do not use any special washer fluid such engine coolant reservoir. Washer fluid placed in the cooling system may harm engine and cooling system components. 371 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 372
the parking brake and ensure the gearshift is securely latched in P (Park) (automatic transmission) or 1 (First) (manual transmission). 4. Open the hood. Protect yourself from engine heat. 5. Locate and carefully remove the engine oil dipstick. 372 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 373
viscosity. Remove the engine oil filler cap and use a funnel to pour the engine oil into the opening. 3. Recheck the engine oil level. Make sure the oil level is not above the normal operating range on the engine oil level dipstick. 373 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 374
Motorcraft replacement oil filters are designed for added engine protection and long life. If a replacement oil filter is used that does not meet Ford material and design specifications, start-up engine noises or knock may be experienced. 374 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 375
can cause personal injury. Therefore, do not allow flames, sparks or lighted substances to come near the battery. When working near the battery, always shield your face and protect your eyes. Always provide proper ventilation. 375 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 376
be adversely affected until the idle trim is eventually relearned. If the battery has been disconnected or a new battery has been installed, the clock and the preset radio stations must be reset once the battery is reconnected. 376 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 377
below, add coolant per the instructions in the Adding engine coolant section. Your vehicle was factory-filled with a 50/50 engine coolant and water concentration. If the concentration of coolant falls below 40% or above 60%, the engine parts could become damaged or not work properly. A 50/50 mixture - 2009 Ford F450 | Owner's Manual - Page 378
be burned if you spill coolant on hot engine parts. WARNING: Do not put engine coolant in the windshield washer fluid container. If sprayed on the windshield, engine coolant could make it difficult to see through the windshield. 378 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 379
vehicles which have a coolant degas system with a pressurized cap, or if it is necessary to remove the coolant pressure relief cap on the radiator of a vehicle with an overflow system, follow these steps to add engine coolant. 379 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 380
coolant per month, have your authorized dealer check the engine cooling system. Your cooling system may have a leak. Operating an engine with a low level of coolant can result in engine overheating and possible engine damage. 380 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 381
Capacities section of your 6.0 and 6.4 Liter Power Stroke Direct Injection Turbo Diesel Owner's Guide Supplement. Fill your engine coolant reservoir as outlined in Adding engine coolant in this section. Severe climates If you drive in extremely cold climates (less than -34°F [-36°C]): • It may be - 2009 Ford F450 | Owner's Manual - Page 382
will completely shut down, causing steering and braking effort to increase. Once the engine temperature cools, the engine can be re-started. Take your vehicle to a service facility as soon as possible to minimize engine damage. 382 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 383
system may be under pressure. If the fuel filler cap is venting vapor or if you hear a hissing sound, wait until it stops before completely removing the fuel filler cap. Otherwise, fuel may spray out and injure you or others. 383 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 384
the skin. If fuel is splashed on the skin and/or clothing, promptly remove contaminated clothing and wash skin thoroughly with soap and water. Repeated or prolonged skin contact with fuel liquid or vapor causes skin irritation. 384 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 385
NOT fill a fuel container while it is in the vehicle (including the cargo area). • Keep the fuel pump nozzle in contact with the fuel container while filling. • DO NOT use a device that would hold the fuel pump handle in the fill position. 385 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 386
. WARNING: If you do not use the proper fuel filler cap, excessive pressure or vacuum in the fuel tank may damage the fuel system or cause the fuel cap to disengage in a collision, which may result in possible personal injury. 386 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 387
octane rating. These products have not been approved for your engine and could cause damage to the fuel system. Repairs to correct the effects of using an aftermarket product in your fuel may not be covered by your warranty. 387 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 388
come on. For more • The service engine soon indicator, refer to information on the service engine soon Warning lights and chimes in the Instrument Cluster chapter. ESSENTIALS OF GOOD FUEL ECONOMY Measuring techniques Your best source of information about actual fuel economy is you, the driver. You - 2009 Ford F450 | Owner's Manual - Page 389
5. Follow one of the simple calculations in order to determine fuel economy: Calculation 1: Divide total miles traveled by total gallons used. Calculation 2: Multiply liters used by 100, then divide by total kilometers traveled. 389 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 390
• Driving at reasonable speeds (traveling at 55 mph [88 km/h] uses 15% less fuel than traveling at 65 mph [105 km/h]). • Revving the engine before turning it off may reduce fuel economy. • Using the air conditioner or defroster may reduce fuel economy. • You may want to turn off the speed control in - 2009 Ford F450 | Owner's Manual - Page 391
kg] of weight carried). • Adding certain accessories to your vehicle (for example bug deflectors, rollbars/light bars, running boards, ski/luggage racks) may reduce fuel economy. • To maximize the fuel economy, drive with the tonneau cover installed (if equipped). • Using fuel blended with alcohol - 2009 Ford F450 | Owner's Manual - Page 392
service of components affecting emission control, such non-Ford parts should be equivalent to genuine Ford Motor Company parts in performance and durability. WARNING: Do not park, idle, or drive your vehicle in dry grass or other dry ground cover. The emission system heats up the engine compartment - 2009 Ford F450 | Owner's Manual - Page 393
not have symptoms that are apparent, indicator on can continued driving with the service engine soon result in increased emissions, lower fuel economy, reduced engine and transmission smoothness, and lead to more costly repairs. 393 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 394
up to its normal operating temperature. Once started, do not turn off the engine until the above driving cycle is complete. If the vehicle is still not ready for I/M testing, the above driving cycle will have to be repeated. 394 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 395
information. If adding fluid is necessary, use only MERCON ATF. • Gasoline engine shown; diesel engine similar. Refer to Identifying components in the engine compartment in the 6.0 and 6.4 Liter Power Stroke Direct Injection Turbo Diesel Owner Guide Supplement. Check the fluid level when it is at - 2009 Ford F450 | Owner's Manual - Page 396
operating range; there is no need to add fluid. If the fluid levels are outside of the normal operating range the performance of your brake system could be compromised; seek service from your authorized dealer immediately. 396 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 397
km]). If your vehicle has been operated for an extended period at high speeds, in city traffic during hot weather or pulling a trailer, the vehicle should be turned off for about 30 minutes to allow fluid to cool before checking. 397 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 398
brake pedal, start the engine and move the gearshift lever through all of the gear ranges. Allow sufficient time for each gear to engage. 4. Latch the gearshift lever in P (Park) and leave the engine running. 5. Remove °C-35°C]). 398 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 399
and/or possible damage. Do not use supplemental transmission fluid additives, treatments or cleaning agents. The use of these materials may affect transmission operation and result in damage to internal transmission components. 399 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 400
and Specifications Checking and adding manual transmission fluid (if equipped) 1. Clean the filler plug. 2. Remove the filler Use only fluid that meets Ford specifications. Refer to Maintenance Product Specifications and Capacities in this chapter. 400 2009 F-250/350/450/550 (f23) Owners Guide, - 2009 Ford F450 | Owner's Manual - Page 401
fluid through the filler opening so that the fluid level is at the bottom of the opening. Use only fluid that meets Ford specifications. Refer to the Maintenance product specifications and capacities section in this chapter. 401 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 402
Direct Injection Turbo Diesel Owner's Guide Supplement. Note: Do not start your engine with the air cleaner removed and do not remove it while the engine is running. Changing the air filter element 1. Loosen clamp and disconnect sensor. 402 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 403
a new air filter. 4. Install a new air filter element into the tray assembly. 5. Return air filter cover to original position making sure the four tabs are engaged and secure the three clamps. Tighten clamp on air tube and reconnect sensor. 403 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 404
damage to the engine if such spark plugs are not used. 3 Also available with 6.4L diesel engine and TorqShift transmission. Part number is FT-176. 4 Also available with 6.4L diesel engine and TorqShift transmission. Part number is FT-175. 404 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing - 2009 Ford F450 | Owner's Manual - Page 405
part name Ford part number / Ford specification Spindle bearing Rear axle - F-250/350 (10.50 inch axle)1 Rear axle - F-350 (DANA M80) Rear axle - F-450/550 (Dana S110/S130) Brake fluid (and clutch fluid, if equipped) Engine coolant (5.4L V8 engine)2 405 2009 F-250/350/450/550 (f23) Owners Guide - 2009 Ford F450 | Owner's Manual - Page 406
part number / Ford specification 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) Maintenance and Specifications Engine oil (includes filter change) - diesel engine Fuel tank - Mid-ship tank (optional on Chassis Cab) Fuel tank - Short box Fuel tank - Long box Fuel tank - Aft axle - 2009 Ford F450 | Owner's Manual - Page 407
Grease XG-4 or XL-5 / ESB-M1C93-B Lock cylinders Capacity Ford part name Ford part number / Ford specification 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) Transmission / parking brake linkages and pivots, brake and clutch pedal shaft (if equipped) - Motorcraft Premium Long - 2009 Ford F450 | Owner's Manual - Page 408
blend motor oil is not mandatory. Engine oil need only meet the requirements of Ford specification WSS-M2C930-A and the API Certification mark. Windshield washer fluid 3.5 quarts (3.3L) Capacity Ford part name Ford part number / Ford specification 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 409
routing 5.4L V8/6.8L V10 engines 5.4L V8 engine 330 87 octane 1-3-7-2-6-5-4-8 1.0-1.1mm (0.039-0.043 inch) Coil on plug 9.8:1 6.8L V10 engine 415 87 octane 1-6-5-10-2-7-3-8-4-9 1.0-1.1mm (0.039-0.043 inch) Coil on plug 9.2:1 409 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 410
number is located on the driver side instrument panel. Please note that in the graphic, XXXX is representative of your vehicle identification number. XXXXXXXXXXXXXXXXX 410 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 411
which transmission each code represents. Code 5 7 T B Description Six-speed manual, Dana (ZF S6-650) Six-speed manual, Dana (Z/F M6HD-W) Five-speed automatic, TorqShift (gas engines) Five-speed automatic, TorqShift (diesel engine) 411 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 412
Ford's rigorous engineering and safety specifications. Ford Motor Company will repair or replace any properly dealer-installed Genuine Ford Accessories Tonneau covers Wheels Interior style Electrochromic compass/temperature interior mirrors Floor mats 412 2009 F-250/350/450/550 (f23) Owners Guide, - 2009 Ford F450 | Owner's Manual - Page 413
Antennas in the area of the driver's side hood. • Electrical or electronic accessories or components that are added to the vehicle by the authorized dealer or the owner may adversely affect battery performance and durability. 413 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 414
Accessory delay ...110 Air cleaner filter ...402, 404 Air conditioning ...84 Airbag supplemental restraint system ...193 and child safety seats ...195 description ...193 disposal ...197 driver airbag ...195 indicator light ...197 operation ...195 passenger airbag ...195 passenger deactivation switch - 2009 Ford F450 | Owner's Manual - Page 415
377 diesel ...9 fail-safe cooling ...382 idle speed control ...375 refill capacities ...405 service points ...369-370 starting after a collision ...317 Engine oil ...372 checking and adding ...372 dipstick ...372 filter, specifications ...374, 404 415 2009 F-250/350/450/550 (f23) Owners Guide, 3rd - 2009 Ford F450 | Owner's Manual - Page 416
and off ...89 Heating heater only system ...80 heating and air conditioning system ...81, 84 Homelink wireless control system ...123 Hood ...368 I Ignition ...275, 409 Illuminated visor mirror ...105 Infant seats (see Safety seats) ...206 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA - 2009 Ford F450 | Owner's Manual - Page 417
(power) ...111 signal ...115 Moon roof ...122 Motorcraft parts ...383, 404 N Navigation system ...79 O Octane rating ...387 Oil (see Engine oil) ...372 Overdrive ...104 P Parking brake ...281 Parts (see Motorcraft parts) ...404 417 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 418
...404, 409 Special notice ...11 ambulance conversions ...10 diesel-powered vehicles ...9 four-wheel drive vehicles ...314 utility-type vehicles ...10 Speed control ...116 Starting your vehicle ...275-277 jump starting ...343 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing USA (fus) - 2009 Ford F450 | Owner's Manual - Page 419
278 W Warning lights (see Lights) ...14 Washer fluid ...371 Water, Driving through ...311 Windows power ...108 Windshield washer fluid and wipers ...103 checking and adding fluid ...371 replacing wiper blades ...372 Wrecker towing ...348 419 2009 F-250/350/450/550 (f23) Owners Guide, 3rd Printing
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
-
101
-
102
-
103
-
104
-
105
-
106
-
107
-
108
-
109
-
110
-
111
-
112
-
113
-
114
-
115
-
116
-
117
-
118
-
119
-
120
-
121
-
122
-
123
-
124
-
125
-
126
-
127
-
128
-
129
-
130
-
131
-
132
-
133
-
134
-
135
-
136
-
137
-
138
-
139
-
140
-
141
-
142
-
143
-
144
-
145
-
146
-
147
-
148
-
149
-
150
-
151
-
152
-
153
-
154
-
155
-
156
-
157
-
158
-
159
-
160
-
161
-
162
-
163
-
164
-
165
-
166
-
167
-
168
-
169
-
170
-
171
-
172
-
173
-
174
-
175
-
176
-
177
-
178
-
179
-
180
-
181
-
182
-
183
-
184
-
185
-
186
-
187
-
188
-
189
-
190
-
191
-
192
-
193
-
194
-
195
-
196
-
197
-
198
-
199
-
200
-
201
-
202
-
203
-
204
-
205
-
206
-
207
-
208
-
209
-
210
-
211
-
212
-
213
-
214
-
215
-
216
-
217
-
218
-
219
-
220
-
221
-
222
-
223
-
224
-
225
-
226
-
227
-
228
-
229
-
230
-
231
-
232
-
233
-
234
-
235
-
236
-
237
-
238
-
239
-
240
-
241
-
242
-
243
-
244
-
245
-
246
-
247
-
248
-
249
-
250
-
251
-
252
-
253
-
254
-
255
-
256
-
257
-
258
-
259
-
260
-
261
-
262
-
263
-
264
-
265
-
266
-
267
-
268
-
269
-
270
-
271
-
272
-
273
-
274
-
275
-
276
-
277
-
278
-
279
-
280
-
281
-
282
-
283
-
284
-
285
-
286
-
287
-
288
-
289
-
290
-
291
-
292
-
293
-
294
-
295
-
296
-
297
-
298
-
299
-
300
-
301
-
302
-
303
-
304
-
305
-
306
-
307
-
308
-
309
-
310
-
311
-
312
-
313
-
314
-
315
-
316
-
317
-
318
-
319
-
320
-
321
-
322
-
323
-
324
-
325
-
326
-
327
-
328
-
329
-
330
-
331
-
332
-
333
-
334
-
335
-
336
-
337
-
338
-
339
-
340
-
341
-
342
-
343
-
344
-
345
-
346
-
347
-
348
-
349
-
350
-
351
-
352
-
353
-
354
-
355
-
356
-
357
-
358
-
359
-
360
-
361
-
362
-
363
-
364
-
365
-
366
-
367
-
368
-
369
-
370
-
371
-
372
-
373
-
374
-
375
-
376
-
377
-
378
-
379
-
380
-
381
-
382
-
383
-
384
-
385
-
386
-
387
-
388
-
389
-
390
-
391
-
392
-
393
-
394
-
395
-
396
-
397
-
398
-
399
-
400
-
401
-
402
-
403
-
404
-
405
-
406
-
407
-
408
-
409
-
410
-
411
-
412
-
413
-
414
-
415
-
416
-
417
-
418
-
419
 |
 |
Introduction
4
Instrument Cluster
14
Warning lights and chimes
14
Gauges
21
Entertainment Systems
26
AM/FM stereo
26
AM/FM stereo with CD
28
AM/FM stereo with in-dash six CD
35
Auxiliary input jack
42
USB port
44
Satellite radio information
48
Family entertainment system
51
Navigation system
79
SYNC
°
79
Climate Controls
80
Heater only
80
Manual heating and air conditioning
81
Dual automatic temperature control
84
Lights
89
Headlamps
89
Turn signal control
94
Bulb replacement
95
Driver Controls
103
Windshield wiper/washer control
103
Steering wheel adjustment
104
Power windows
108
Mirrors
110
Speed control
116
Upfitter controls
121
Moon roof
122
Message center
127
Table of Contents
1
2009 F-250/350/450/550
(f23)
Owners Guide, 3rd Printing
USA
(fus)