2010 Ford F350 Super Duty Regular Cab Owner Guide 2nd Printing
2010 Ford F350 Super Duty Regular Cab Manual
2010 Ford F350 Super Duty Regular Cab manual content summary:
- 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 1
Controls Heater only Manual heating and air conditioning Dual automatic temperature control 98 98 99 102 Lights Headlamps Turn signal control Bulb replacement 107 107 112 113 Driver Controls Windshield wiper/washer control Steering wheel adjustment Power windows Mirrors Speed control Upfitter - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 2
185 195 Tires, Wheels and Loading Tire information Tire inflation Tire Pressure Monitoring System (TPMS) Vehicle loading Trailer towing Trailer brake controller-integrated Recreational towing 217 219 221 237 244 251 256 262 Driving Starting Brakes Traction Control™ Transmission operation Reverse - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 3
Maintenance and Specifications Engine compartment Engine oil Battery Engine coolant Fuel information Air filter(s) Part numbers Maintenance product specifications and capacities Engine data 345 355 357 360 363 365 371 389 390 391 395 Accessories Ford Extended Service Plan Index 398 400 403 All - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 4
switch will automatically cut off the fuel supply to the engine. The switch can also be activated through sudden vibration (e.g. collision when parking). To reset the switch, refer to the Fuel pump shut-off switch in the Roadside Emergencies chapter. 4 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 5
consult the relevant section of this guide before touching or attempting adjustment of any kind. Protecting the environment We must all play our part in protecting the environment. Correct birth defects or other reproductive harm. 5 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 6
Introduction PERCHLORATE MATERIAL Certain components of this vehicle such as airbag modules, seat belt pretensioners, and button cell batteries may contain Perchlorate Material - Special handling may apply for service or vehicle end of life disposal. See www.dtsc.ca.gov/hazardouswaste/perchlorate. - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 7
Notice to owners of diesel-powered vehicles Read the 6.0 and 6.4 Liter Power Stroke Direct Injection Turbo Diesel Owner's Guide Supplement for information regarding correct operation and maintenance of your Diesel-powered light truck. Notice to owners of pickup trucks and utility type vehicles - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 8
includes information about the performance or status of various systems and modules in the vehicle, such as engine, throttle, steering or brake systems. In order to properly diagnose and service your vehicle, Ford Motor Company, Ford of Canada, and service and repair facilities may access - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 9
activate the service. Ford Motor Company and the vendors it uses to provide you with this information do not store your vehicle travel information. For more information, see Traffic, Directions and Information, Terms and Conditions. See your SYNC supplement for more information. 9 2010 F-250/350 - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 10
may cause severe engine and/or transmission damage; refer to the What is not covered section in The new vehicle limited warranty for your vehicle chapter of your vehicle's Warranty Guide for more information. Some vehicles are equipped with Powertrain Control Systems that can detect and store - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 11
are different from the features and options that are described in this Owner's Guide. A market unique supplement may be supplied that complements this book. By and specifications that are unique to your vehicle. This Owner's Guide is written primarily for the U.S. and Canadian Markets. Features or - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 12
System Brake Fluid Non-Petroleum Based Stability Control System Speed Control Master Lighting Switch Hazard Warning Flasher Fog Lamps-Front Fuse Compartment Fuel Pump Reset Windshield Defrost/Demist Windshield Wash/Wipe Rear Window Defrost/Demist 12 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 13
, or Sparks Explosive Gas Battery Acid Fan Warning Maintain Correct Fluid Level Engine Air Filter Jack MAX MIN Power Steering Fluid Service Engine Soon Passenger Compartment Air Filter Check Fuel Cap Low Tire Pressure Warning 13 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 14
Cluster WARNING LIGHTS AND CHIMES Automatic transmission cluster shown, manual similar Harley-Davidson vehicles Warning lights and gauges can alert you to a vehicle condition that may become serious enough to cause expensive repairs. A warning light may illuminate when a problem exists with - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 15
. Brake system warning light: To ! P confirm the brake system warning light is functional, it will BRAKE momentarily illuminate when the ignition is turned to the on position when the engine is not running, or in a position between on and start, or 15 2010 F-250/350/450/550 (f23) Owners Guide, 2nd - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 16
after releasing the parking brake indicates low brake fluid level and the brake system should be inspected immediately by your servicing authorized dealer. WARNING: Driving a vehicle with the brake system warning light on is dangerous. A significant decrease in braking performance may occur - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 17
Powertrain malfunction/Reduced power/Electronic throttle control (RTT): Displays when the engine has defaulted to a "limp-home" operation or when a transmission problem has been detected and shifting may be restricted. If the light remains on, have the system serviced immediately by your authorized - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 18
. If the light remains illuminated and will not cancel using the Tow/Haul switch located on the end of the gear shift lever, have the system serviced immediately or damage to the transmission could occur. Four-wheel drive low (if 4x4 equipped): Illuminates when LOW four-wheel drive low is engaged - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 19
; refer to Instrument Cluster in your Power Stroke 6.0 and 6.4 Liter Direct Injection Turbo Diesel Owner's Guide Supplement for detailed information on their function. Diesel warning lights: • Glow plug pre-heat • Water in fuel • Low oil pressure Key-in-ignition warning chime: Sounds when the key - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 20
If the warning remains on after the parking brake is off, contact your authorized dealer as airbag readiness warning lamp is inoperable, that there is a fault in the supplemental restraint system. GAUGES Speedometer: Indicates the current vehicle speed. 20 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 21
while the engine is running or hot. Odometer: Registers the total miles (kilometers) of the vehicle. Refer to Standard message center or Optional message center in this chapter on how to switch the display from Metric to English. 21 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 22
/RESET stem once to switch from the odometer to the trip odometer. Press the stem again to select Trip A and Trip B features. To reset the trip, press and hold the stem until it resets. cluster Harley-Davidson instrument cluster 22 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 23
's electrical system checked as soon as possible. Transmission fluid temperature gauge (automatic transmission only): If the gauge is in the: Normal area- the transmission fluid is within the normal operating temperature (between "H" and "C"). 23 2010 F-250/350/450/550 (f23) Owners Guide, 2nd - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 24
than 2 seconds. TRIP Registers the distance of individual journeys. Press and release the SELECT/RESET button on the cluster to toggle between odometer and trip odometer display. To reset, press and hold for less than two seconds. 24 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 25
automatic shut-off points on the fuel pumps at service reset the function) after setting the speed control to get accurate highway fuel economy readings. TBC GAIN (if equipped) Displays the level of trailer brake gain or if the trailer is not connected. 25 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 26
each oil change (approximately 7,500 miles [12,000 km] or 12 months) perform the following: 1. Press and release the setup button to display "OIL LIFE XXX% HOLD RESET = NEW". 2. Press and hold the SELECT/RESET stem for two seconds and release to reset the oil life to 100%. Note: To change oil life - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 27
ENGINE IDLE HOURS (Diesel engine only) 4. CHARGING SYSTEM 5. DOOR AJAR 6. BRAKE SYSTEM 7. XX MILES TO E FUEL LEVEL XXX System warnings System warnings alert you to possible problems or malfunctions in your vehicle's operating systems. 27 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 28
reset by pressing the SELECT/RESET button. This allows you to use the full message center functionality by clearing the message. PARK BRAKE ENGAGED - Displayed when the parking brake is applied (or not fully released). CHECK BRAKE SYSTEM - Displayed when a fault has been detected by the ABS module - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 29
to Trailer towing in the Tires, Wheels and Loading chapter for more information. BRAKE FLUID LEVEL LOW - Indicates the brake fluid level is low and the brake system should be inspected immediately. Refer to Brake fluid in the Maintenance and Specifications chapter. LOW TIRE PRESSURE (if equipped - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 30
soon light be further limited. Dealer service will then be required to restore your vehicle to full-power operation. Note: Diesel Particulate Filter (DPF) regeneration will not initiate at idle or in Power-Take-Off (PTO) mode. When DRIVE TO CLEAN EXHAUST 30 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 31
3 mph (5 km/h). Refer to your Power Stroke 6.0 and 6.4 Liter Direct Injection Turbo Diesel Owner's Guide Supplement for more information. ENGINE OIL CHANGE SOON (Gas engine only) - Displayed when the engine oil life remaining is 5% or less. OIL CHANGE REQUIRED (Gas engine only) - Displayed when the - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 32
release the INFO button until the TRIP A/B appear in the display (this represents the trip mode). Press and hold the RESET button for two seconds to reset. Refer to UNITS later in this section to switch the battery is disconnected. 32 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 33
Press and release RESET in order to start the timer. 2. Press and release RESET to pause the timer. 3. Press and hold RESET until the timer resets. TBC GAIN (if equipped) Displays the level of trailer brake gain or if the trailer is not connected. 33 2010 F-250/350/450/550 (f23) Owners Guide, 2nd - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 34
RECOMMENDED ENGINE OILS. To reset the oil monitoring system to 100% after each oil change (approximately 7,500 miles [12,000 km] or 12 months) perform the following: 1. Press and release the SETUP button to display "OIL LIFE XXX% HOLD RESET = NEW". 34 2010 F-250/350/450/550 (f23) Owners Guide, 2nd - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 35
to change from English to Metric. AUTOLAMP (SEC) This feature keeps your headlights on for up to three minutes after the ignition is switched off. Press the RESET control to select the new Autolamp delay values of 0, 10, 20, 30, 60, 90, 120 or 180 seconds. AUTOLOCK This feature automatically locks - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 36
be "locked in". Perform compass calibration in an open area free from steel structures and high voltage lines. For optimum calibration, turn off all electrical accessories (heater/air conditioning, wipers, etc.) and make sure all vehicle doors are shut. 7. Press the RESET button until the display - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 37
or being reset if a problem or condition is still present and needs your attention. • Some messages can be acknowledged and reset by pressing RESET. This allows you to use the full message center functionality by clearing the message. 37 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 38
a single chime if there are certain faults in the vehicle wiring and trailer wiring/brake system. Refer to Trailer towing in the Tires, Wheels and Loading chapter for more information. TRAILER BRAKE MODULE FAULT (if equipped) - Displayed and accompanied by a single chime in response to faults sensed - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 39
only) - Displayed when the water separator has reached a predetermined capacity and needs to be drained. Refer to your Power Stroke 6.0 and 6.4 Liter Direct Injection Turbo Diesel Owner's Guide Supplement for more information. 39 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 40
to your Power Stroke 6.0 and 6.4 Liter Direct Injection Turbo Diesel Owner's Guide Supplement for more information. Note: If this message is ignored, your vehicle will continue to fill the Diesel Particulate Filter (DPF) with particles (exhaust soot). If cleaning is not permitted, the light will - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 41
3 mph (5 km/h). Refer to your Power Stroke 6.0 and 6.4 Liter Direct Injection Turbo Diesel Owner's Guide Supplement for more information. ENGINE OIL CHANGE SOON (Gas engine only) - Displayed when the engine oil life remaining is 5% or less. OIL CHANGE REQUIRED (Gas engine only) - Displayed when the - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 42
off or until either front door is opened. / (Tuner): Press to 1. manually go up or down the radio frequency. Press and hold for a fast advance through radio frequencies. Also use in AUDIO mode to gain access to various settings. 42 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 43
Entertainment Systems 2. AUDIO: Press AUDIO repeatedly to gain access to the following settings: TREB (Treble): Press AUDIO to reach the treble OFF/Volume: Press VOL PUSH to turn ON/OFF. Turn VOL PUSH to increase/decrease volume. 43 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 44
the window switches and the audio for up to 10 minutes after the ignition has been turned off or until either front door is opened. / : Press / to 1. manually go up or down the radio frequency. Press and hold for a fast advance through radio frequencies. 44 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 45
to the main menu. • SAVE SONG: Press OK to save the currently playing song title in the system's memory. (If you try to save something other than a song, CANT SAVE will appear in the OK. SONG REPLACED will appear in the display. 45 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 46
satellite radio channel. (The system default is disabled.) SONG ALERTS ENABLED/DISABLED will appear in the display. set the strongest local radio stations without losing your original manually set preset stations for AM/FM1/FM2. Use / / 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 47
). For location and further information on auxiliary audio mode, refer to Auxiliary input jack later in this chapter. Satellite radio is available only with a valid SIRIUS radio subscription. Check with your authorized dealer for availability. 47 2010 F-250/350/450/550 (f23) Owners Guide, 2nd - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 48
. Check with your authorized dealer for availability. / OK (Play/Pause): This 6. control is operational in CD/MP3 mode. When a CD/MP3 is playing, press to mode, the system will randomly play all tracks within the current folder. 48 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 49
Press REW to manually reverse in a CD/MP3 track. 12. Memory presets: To set a station: Select frequency band AM/FM1/FM2; tune to a station, press and hold a preset control until sound returns. to view the previous display text. 49 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 50
: Press to enter CD/MP3 mode. If a CD is already loaded into the system, CD/MP3 play will begin where it ended last. 17. CD. (CD eject): Press to eject a 18. CD slot: Insert a CD label side up in the CD slot. 50 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 51
radio mode, press to manually ) or down ( ) the go up ( radio frequency. Press and hold for a fast advance through radio frequencies. In menu mode, use to select various settings. In CD/MP3 mode, press to select the desired disc. 51 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 52
. • SAVE SONG: Press OK to save the currently playing song title in the system's memory. (If you try to save something other than a song, CANT SAVE a song from the system's / to cycle through the saved songs. When the memory. Press 52 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 53
channel. (The system default is disabled.) SONG ALERTS ENABLED/DISABLED will appear in the the strongest local radio stations without losing your original manually set preset stations for AM/FM1/FM2. Use release begin the search. 53 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 54
Entertainment Systems To view the 1 (lowest setting) to 7 (highest setting) allows the radio volume to automatically change slightly with vehicle speed to compensate for road and wind noise. Recommended level (if Press available). 54 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 55
system will bring soft and loud CD passages together for a more consistent listening level. 4. AUX : Press repeatedly to cycle through FES/DVD (if equipped), LINE IN (Auxiliary audio mode, if equipped), SYNC, SAT1, SAT2 and SAT3 modes (satellite radio if equipped). For location This control is - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 56
the system will manually advance in a CD/MP3 track. 11. REW (Rewind): Press REW to manually control until sound returns. Satellite radio is available only with a valid SIRIUS radio subscription. Check with your authorized dealer for availability. 56 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 57
press and release to enter system, CD/MP3 play will begin where it ended last. 17. LOAD: To load a disc into the system, press LOAD. Select a slot number using memory presets 1-6. When the display reads LOAD CD#, load the desired disc, label side up. 57 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 58
be ejected. If the current disc is not removed, the system will reload the disc. 19. CD slot: Insert a CD distracted can result in loss of vehicle control, accident and injury. Ford strongly recommends that drivers use extreme caution 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 59
audio from your portable music player although it may be low. 7. Adjust the sound on your portable music player until it reaches the level of the FM station or CD by switching back and forth between the AUX and FM or CD controls. 59 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 60
Entertainment Systems Troubleshooting: 1. Do not connect the audio input jack to a line level output. Line level outputs are intended for connection to a home stereo and are not compatible with the AIJ. The AIJ will only work correctly with devices that have a headphone output with a volume control. - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 61
fences, traffic lights and thunderstorms can interfere with your reception. • Station overload: When you pass a broadcast tower, a stronger signal may overtake a weaker one and play while the weak station frequency is displayed. 61 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 62
. Due to technical incompatibility, certain recordable and re-recordable compact discs may not function correctly when used in Ford CD players. Do not use any irregular shaped CDs or discs with a scratch protection film attached. 62 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 63
further information. Audio system warranty and service Refer to the Warranty Guide/Customer Information Guide for audio system warranty information. If service is necessary, see will help with navigation through the disc files. 63 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 64
affect satellite radio reception performance: • Antenna obstructions: For optimal reception performance, keep the antenna clear of snow and ice build-up and keep luggage and other material as far away from the antenna as possible. 64 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 65
time, with or without notice to you. Ford Motor Company shall not be responsible for any such programming changes. Satellite radio electronic serial number (ESN): This by pressing the AUX and preset 1 controls simultaneously. 65 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 66
module or system for service. system is working properly. Song title information not available at this time on this channel. The system is working properly. Category information not available at this time on this channel. The system is working properly. 66 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 67
includes a DVD system, two sets of wireless infrared (IR) headphones and a wireless infrared (IR) remote control. 67 Radio Display NO SIGNAL Condition Loss of signal from the SIRIUS satellite or SIRIUS tower to the vehicle antenna. 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 68
DVD-AUX, NON-DVD, OFF. Press the power button to turn the system off. The indicator light will turn off indicating the system is off. Note: The audio from the DVD system will play over all vehicle speakers and can be adjusted by the radio volume control. 68 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 69
or the ignition is in accessory mode. 2. Insert an MP3 disc into the system, label-side up to turn on the DVD system. It will load and automatically begin to play. If there is already a disc in the system, press PLAY on the DVD player. 69 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 70
audio input • Red (3) - right channel audio input 4. Press MEDIA on the DVD system to change the media source to AUX. Note: If your vehicle is equipped with a navigation system, the MEDIA button is only active in dual play mode. 70 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 71
A or B headphone control button. Note: Channel A can access any possible media source (AM, FM1, FM2, SAT (if equipped), CD, DVD, AUX). Channel B can only access DVD and AUX sources. Note: Refer to Single play/Dual play for more information. 71 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 72
on the display screen, press the brightness control on the DVD system. A display will appear at the bottom of the screen indicating the brightness level. The brightness display will only appear when the menu is not displayed. 72 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 73
), CD, DVD, DVD-AUX). Headphone B can only access DVD and DVD-AUX. For further information, refer system. (Reverse): Press and 3. release for the previous chapter or track. Press and hold to reverse search a DVD, Video CD, or FES CD in DVD/CD mode. 73 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 74
AUX video mode, the display will automatically turn on. 8. Infrared (IR) Receiver & Transmitter: System sensor which reads the signals from the remote control headphone volume is controlled with the rotary dial on the right ear piece.) 74 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA ( - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 75
audio system at the same time to perform controls to make various selections when in any menu. When not in a menu, and in / to adjust DVD mode, press the brightness. A display bar will appear at the bottom of the screen indicating the brightness levels. 75 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 76
the remote and player. 1. Power control: Press to turn the FES (Family Entertainment System) ON/OFF. 2. Cursor controls: Use in various active menus then use the MEDIA control to select the desired playing media for the headphones. 76 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 77
4 memory presets on the audio system at the same time to perform the same function. 13. Numeric Keypad: Use the numeric controls to enter in a specific CD/ system set-up menu. 20. SUBTITLE (DVD dependent): Press to turn the subtitle feature ON or OFF. 77 2010 F-250/350/450/550 (f23) Owners Guide, - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 78
shelf life, replace them when the unit fails to control the DVD player. Remove the screw and unlatch the battery cover to access the batteries. The remote control unit uses two AAA batteries which are supplied with the unit. 78 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 79
. Your FES system is equipped with two sets of battery powered, infrared wireless system. Also, wired headphones may be purchased and plugged in where indicated on the left and right hand sides of the system. Refer to Wired Headphones following. 79 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 80
bottom of the cover. Then, lightly press down on top and slide the cover off. When replacing the batteries, use two new batteries (alkaline recommended) and install them with the correct orientation as indicated in the battery housing. 80 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 81
signal is received), the wireless headphones will automatically turn off. They will also turn off after two hours of continuous use as a power save feature. If this happens, simply turn the headphones on again and continue use. 81 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 82
jacks on the sides of the DVD system. The wired headphone jack for Channel A is located on the left side of the FES the volume control on the DVD system. Operation Single play/Dual play Your DVD and audio system work together with 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 83
will automatically activate dual play mode. b. Press the RADIO or MEDIA hard button on the navigation system. Select the 'Rear Zone' tab on the touchscreen and select 'On' for the headphones and 'Enabled' for the rear controls. To return to single zone, select 'Off' for the headphones and 'Disabled - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 84
. Press the Headphone Control button B to change the audio source for Channel B. Press MEDIA to change the audio source for Channel B. This information will display on the DVD system screen. Channel B can listen to either the DVD media or the DVD system auxiliary inputs (DVD-AUX). (Reverse), (Fast - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 85
. Once you have made your selection, press ENTER to confirm. The system default is Angle 1. Aspect ratio Select ASPECT RATIO to select the viewing size and shape of the video displayed on the LCD screen. This is disc dependent. 85 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 86
screen display will immediately change to your selection after the system resumes playback of the DVD. The system default is WIDE (16 system default is English. Subtitles Select SUBTITLES to turn the subtitle option on or off. The system default is OFF. 86 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 87
stop. Playing MP3 discs To play an MP3 disc on your DVD system: 1. Ensure that the vehicle is on or the ignition is in accessory mode. 2. Ensure that the DVD system is on. 3. Insert the MP3 disc into the DVD system, label side up. 87 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 88
Systems capacity - Each disc contains about 650 MB of storage capacity. We do not recommend using high capacity . • Bit rate - The player supports bit rates from 32-320 kbps, recommended only for speech or low fidelity music material. We 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 89
are more susceptible to damage from heat, light and stress than are regular CDs. • function correctly when used in Ford CD and DVD players. accessory mode. 2. Ensure that the navigation system is on. 3. Insert a DVD label-side up into the system. 89 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 90
Systems 4. Use the DVD bezel controls to: Press to play or pause a DVD. Press to stop or eject a DVD. Press and release to go to the previous chapter. Press and hold for a fast reverse search. Press and release , press pause. 90 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 91
(not included) The B headphone jack (5) is located on the right side of the DVD system. Plug in wired headphones (not included) here. Note: The B headphones can only access DVD and AUX modes. They cannot access radio sources. 91 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 92
ways. The DVD system is automatically activated when the vehicle ignition is ON, which allows the rear seat passengers to use the DVD system. There are three levels of control of the FES buttons. The states are FULL (enabled), LOCAL or LOCKED (disabled). To change the level of control, press the - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 93
region 1 DVDs and Mexico systems can only play region 4 DVDs. Systems sold in vehicles targeted for other parts of the world would have different regions. If a playback problem is encountered, please ensure that you are using a disc designed for your vehicle. The region coding can be found stamped - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 94
rays for extensive periods of time. Ultraviolet rays deteriorate the liquid crystal. Be sure to review User Manuals for video games and video game equipment when used as auxiliary inputs for your Family Entertainment System (FES). 94 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 95
or perform at less than maximum capability. To avoid these outcomes, whenever possible avoid exposing your DVD player to: • extremely hot or cold temperatures. • direct sunlight. • high humidity. • a dusty environment. • locations where strong magnetic fields are generated. 95 2010 F-250/350 - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 96
system. Humidity and moisture condensation Moisture in the air controls or into the system. If liquid is accidentally spilled onto the system, immediately turn the system OFF and consult a qualified service excessive pressure while 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 97
, a hands-free communications and entertainment system with special phone and media features. For more information, please refer to the SYNC supplement or to the SYNC section in the Navigation System supplement (if equipped). 97 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 98
using the outside air in inlets. • Remove any snow, ice or leaves from the air intake area at the base of the windshield. To aid in side window defogging/demisting in cold weather: 1. Select . 2. Adjust the temperature control to maintain comfort. 98 2010 F-250/350/450/550 (f23) Owners Guide, 2nd - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 99
. MANUAL HEATING AND AIR CONDITIONING SYSTEMS (IF EQUIPPED) • Manual heating and air conditioning system • Manual heating and air conditioning system with heated mirrors • Manual heating and air conditioning system with heated mirrors and heated seats 99 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 100
Press to turn the heated mirrors on and off. 6. The heated mirrors turn off automatically after 10 minutes. (Heated seats): Press to turn the heated seats on and off. The 7. heated seats turn off when the ignition is turned off. 100 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 101
from the highest setting and put the vehicle's transmission into the P (PARK) gear position (automatic transmission only) to continue to receive cool air from your A/C system. For maximum cooling performance in MAX A/C mode: 1. Move the temperature control to the coolest setting. 2. Set the fan to - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 102
Climate Controls DUAL AUTOMATIC TEMPERATURE CONTROL (DATC) SYSTEMS (IF EQUIPPED) • DATC • DATC with heated mirrors 102 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 103
Press to defrost the outside rear view 3B. mirrors. The heated mirrors will turn off after 10 minutes or can be turned off by pressing the button again. Refer to Power mirrors in the Driver Controls chapter for more information. 103 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 104
location, A/C on or off, and outside or recirculated air, to heat or cool the vehicle to reach the desired temperature. Heated seat controls: Press to turn the heated seats on and off. 16. The heated seats turn off when the ignition is turned off. 104 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 105
highest setting and put the vehicle's transmission into the P (PARK) gear position (automatic transmission only) to continue to receive cool air from your A/C system. For maximum cooling performance (MAX A/C): Automatic operation: 1. Press AUTO for full automatic operation. 2. Do not override A/C or - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 106
) or (panel/floor) modes: 1. Move temperature control to full cold. (recirculated air). Use recirculated air with A/C to 2. Select A/C and provide colder vents, close the vents located in the middle of the instrument panel. 106 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 107
light sensitive automatic on-off control of the exterior lights normally controlled by the headlamp control. The autolamp system also keeps the lights on for approximately 20 seconds. On vehicles equipped with a message center, you can select a delay from 0-180 seconds after the ignition switch - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 108
lever toward the instrument panel to activate. Pull the lever toward you to deactivate. OFF Flash-to-pass Pull toward you slightly to activate and release to deactivate. 108 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 109
universal adaptor all to the same setting, such that the cross-car sight line is no longer blocked, per the instructions for the brand of mechanical aimer used. You can also aim the headlamps visually using the procedure below. 109 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 110
Lights To adjust the headlamps: 1. Park your at this height (masking tape works well). 3. Turn on the low beam headlamps and open the hood. 4. Locate the high intensity area of the beam pattern and place the top edge adjust it. 110 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 111
Lights 5. Locate the vertical adjuster (2) for each headlamp. Adjust the aim by turning the adjuster control either clockwise (to adjust up) or counterclockwise ) • (2) Center height of lamp to ground • (3) 25 feet (7.6 meters) 111 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 112
of the light pattern up to the horizontal line. 6. Repeat Steps 3-5 for the other headlamp. 7. Close the hood and turn off the lamps. TURN SIGNAL CONTROL • Push down to activate the left turn signal. • Push up to activate the right turn signal. 112 2010 F-250/350/450/550 (f23) Owners Guide, 2nd - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 113
, and • any of the remote entry controls are pressed and the ignition is off. BULB REPLACEMENT Lamp assembly condensation Exterior lamps are vented to accommodate normal changes in pressure. Condensation can be a natural by-product of this design. When moist air enters the lamp assembly through the - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 114
lamp 2 9145 License plate lamp 2 194 Cargo lamp 2 906 Mirror turn signal 2 2825 Mirror clearance lamp 2 2825 *Front clearance lamps (2) and front 5 instrument panel lights - see your authorized dealer * Dual rear wheels, or if equipped. 114 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 115
of children's reach. Grasp the bulb only by its plastic base and do not touch the glass. The oil from your hand could cause the bulb to break the next time the headlamps are operated. Install the new bulb(s) in reverse order. 115 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 116
Lights Replacing park/turn and sidemarker lamp bulbs (aerodynamic) 1. Make sure that the headlamps are ring from the headlamp. 4. Disconnect the electrical connector from the headlamp. Install the new bulb(s) in reverse order. 116 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 117
Lights the new bulb(s) in reverse order. Replacing brake/ releasing the two retaining tabs. 3. Rotate the bulb socket counterclockwise and remove from lamp assembly. 4. Pull the bulb straight out of the socket. Install the new bulb(s) in reverse order. 117 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 118
lamp assembly from the vehicle as wiring permits. 3. Remove the bulb socket by rotating it counterclockwise. 4. Pull the bulb straight out of the socket. 118 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 119
the rear bumper to locate the bulb. 2. Twist the bulb socket counterclockwise and carefully pull to remove it from the lamp assembly. 3. Pull out the old bulb from the socket and push in the new bulb. 4. Install the bulb socket in lamp assembly by turning it clockwise. 119 2010 F-250/350/450 - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 120
control is set on the intermittent settings, the speed of the wipers will automatically adjust with the vehicle speed. The faster your vehicle is travelling the faster the wipers will go. Windshield washer: Press the end on during daylight, and the headlamp control is in the autolamp position, the - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 121
location. 3. Release the steering wheel release control. This will lock the steering wheel in position. WARNING: Never adjust the steering column when the vehicle is moving. ILLUMINATED VISOR MIRROR (IF EQUIPPED) Lift the mirror cover 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 122
Controls Storage compartment (if equipped) Press the release surface • A power point inside the utility compartment and on the rear of the console • Laptop storage • Hanging file folder supports • Rear cupholders rear seats. 122 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 123
hang any type of accessory or accessory bracket from the plug. Improper use of the power outlet can cause damage not covered by your warranty. Auxiliary power points can be found in the following locations: • On the instrument panel 123 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 124
hold the switch to close. Rear Window Buffeting: When one or both of the rear windows are open, the vehicle may demonstrate a wind throb or buffeting noise. This noise can be alleviated by lowering a front window approximately two to three inches. 124 2010 F-250/350/450/550 (f23) Owners Guide, 2nd - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 125
with a power rear slide window, the switch is located on the instrument panel behind the right-hand side of the steering wheel. • Press the right side of the control to open the window. • Pull the right side of the control to close the window. 125 2010 F-250/350/450/550 (f23) Owners Guide, 2nd - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 126
mirror or the navigation system (if equipped) when the vehicle is put in R (Reverse). As you shift into any other gear from R (Reverse), the image will remain for a few seconds and then turn off. Refer to Rearview camera system in the Driving chapter. 126 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 127
To activate the heated mirrors, press the heated located on the mirror control climate control panel. The heated mirrors will operate for 10 minutes, then automatically shut off (or shut off when the engine is turned off). In cases of extreme ice and cold, the heater control may need pressing again - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 128
conditions. Note: Ten or more switch activations within one minute, or repeated fold/unfolding of the mirrors while holding the switch rearward during the full travel may cause the system to disable the fold/unfold function to 128 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 129
the left side of the power telescope switch until the mirrors reach their desired position. When the end of travel is reached, it is normal to hear the power telescoping motors running as long as you continue to hold the switch. 129 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 130
Driver Controls • To telescope the mirrors inboard, press and hold the right side of the power telescope switch until the mirrors reach their desired position. Memory mirrors (if equipped) This system allows automatic positioning of the outside rearview mirrors. For more information on this feature, - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 131
remote entry transmitter, keyless entry keypad or memory switch on the driver's door (if equipped with memory feature). Refer to Memory seats/power mirrors/adjustable pedals in the Seating and Safety Restraints chapter. SPEED CONTROL (IF EQUIPPED) With speed control set, you can maintain a set speed - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 132
control The controls for using your speed control are located on the steering wheel for your convenience. 1. Press the ON control and release it. 2. Accelerate to the desired speed. 3. Press the SET + control and release it. 4. Take your foot off the accelerator pedal. on the 5. The indicator light - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 133
operate the Tap-Down function. Press and release this control to decrease the vehicle set speed in small amounts by 1 mph (1.6 km/h). • Depress the brake pedal until the desired vehicle speed is reached, press the SET + control. 133 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 134
some radio and climate control features. Audio control features Press MEDIA to select: • AM, FM1, FM2 • CD (if equipped) • DVD (if equipped) • SAT1, SAT2 or SAT3 (Satellite Radio mode, if equipped). • LINE IN (Auxiliary input jack) 134 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 135
In any mode: • Press VOL + or − to adjust volume. Navigation system hands free control features (if equipped) Press and hold VOICE briefly until icon appears on the the Navigation system, refer to the Navigation System supplement. 135 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA ( - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 136
on the SYNC system, refer to the SYNC supplement. Navigation system/SYNC hands free control features (if equipped) end hold call. For further information on the Navigation system/SYNC system, refer to the Navigation System and SYNC supplements. 136 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 137
, there will also be a relay box located on the driver side end of the instrument panel. See your authorized dealer for service. The relays are coded as shown in RELAY the accompanying illustration. 4 RELAY 3 RELAY 2 RELAY 1 137 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 138
Driver Controls There will also be one power lead for each switch found as a blunt-cut and sealed wire located below the instrument panel and to the left of the steering column. They are coded as follows: Switch AUX 1 AUX 2 AUX 3 AUX 4 Circuit number Wire color CAC05 Yellow CAC06 Green with Brown - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 139
manually opened or closed when the glass panel is shut. To close the shade, pull it toward the front of the vehicle. HOMELINKா WIRELESS CONTROL SYSTEM (IF EQUIPPED) The HomeLink Wireless Control System, located , does not meet 139 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 140
for quicker training and accurate transmission of the radio-frequency signal. 1. Position the end of your hand-held transmitter 1-3 inches (2-8 cm) away from the HomeLink button you wish to program (located on your visor) while keeping the indicator light in view. 2. Simultaneously press and - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 141
until the frequency signal has been accepted by the HomeLink. The indicator light will flash slowly and then rapidly after HomeLink accepts the radio frequency signal. • Proceed with Step 3 in the Programming section. 141 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 142
button. 2. The indicator light will begin to flash after 20 seconds. Without releasing the HomeLink button, follow Step 1 in the Programming section. For questions or comments, contact HomeLink at www.homelink.com or 1-800-355-3515. 142 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 143
camera system connector that remains under the pickup box. 3. Partially lower tailgate and carefully feed tailgate harness up through the gap between the pickup box and the bumper. Place the tailgate harness out of the way under the pickup box. 143 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 144
the step. Note: To reduce risk of falling: • Operate step only when the vehicle is on level surface. • Operate step only in areas with sufficient lighting • Always open flip panel to widen step. 144 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 145
close the tailgate step: 1. Close the step panel, then lift and fully close the tailgate step into the tailgate. 2. Slide serviceable item) if damaged. • Do not tow with grab handle or step frame. Bed extender (if equipped) Your vehicle may be equipped with a cargo management feature in the truck bed - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 146
Controls 2. Open the latches to release the panels. 3. Rotate the panels toward the tailgate. Repeat Steps 1-3 for the other side of the bed extender. 4. Connect the two panels, then rotate both knobs a quarter-turn clockwise to secure the panels. 146 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 147
the tailgate closed when not being used for the purpose of restraining cargo in the tailgate mode. To open the bed extender into grocery mode, follow Steps 1-4 by rotating the panels away from the tailgate. Close the tailgate. 147 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 148
the manual lock button on the door, locking the driver's door with a key, by simultaneously pressing button 7 • 8 and the 9 • 0 controls on the button on the remote entry keypad (if equipped), or using the remote entry transmitter (if equipped). 148 2010 F-250/350/450/550 (f23) Owners Guide, 2nd - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 149
. Power door lock switch autolock enable/disable procedure power door unlock control on the door panel three times. 3. Turn the ignition from the on position to the off position. 4. Press the power door unlock control on the door panel three times. 149 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 150
locked before the driver door is opened. Deactivating/activating autounlock feature There are three methods to enable/disable this feature: • Through your authorized dealer, • by using a power door unlock/lock sequence, 150 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 151
Power door lock switch autounlock enable/disable release the 7 • 8 a second time. 5. Release the 3 • 4. The user should receive a horn chirp to indicate the system has been disabled or a chirp followed by a honk to indicate the system has been enabled. 151 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 152
automatically set the lock for both doors. • Move lock control up to engage the childproof lock. • Move lock control down to disengage the childproof lock. REMOTE ENTRY SYSTEM (IF EQUIPPED) This device complies with part vehicle. 152 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 153
vehicle has switched to one step unlocking. Repeat the procedure to switch back to two-step unlocking. Locking the doors 1. Press and release to lock all the doors. The parking lamps will illuminate if all the doors are closed and locked. 153 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 154
release used to locate your vehicle, mirrors (if equipped) The remote entry system can also control the memory seat/adjustable pedals/mirrors. to automatically move the seat, adjustable pedals and mirrors recall the memory position. 154 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 155
keyfob The keyfob unlock will not recall the memory position. Replacing the battery key ring. DO NOT TAKE THE RUBBER COVER AND CIRCUIT BOARD OFF THE FRONT HOUSING OF transmitter batteries. 4. Insert the new battery. Refer to the diagram 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 156
power mirrors recall Driver 1 settings, and the second transmitter that is programmed will recall turn must end in the on automatically exit the programming mode. The doors will lock, then unlock, to confirm that the programming mode has been exited. 156 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 157
, and 30 minutes after if the dome lamp switch is left on. SECURICODE™ KEYLESS ENTRY SYSTEM You can use the keyless entry keypad to lock or unlock the doors without using a key. The keypad can be operated with the factory set 5-digit entry code; this code is located on the owner's wallet card in the - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 158
digit does not set a driver and will not recall a memory setting. Note: The factory-set code cannot be associated with a memory setting. 5. pressing the control on the remote entry transmitter. • the ignition is turned to the on position. 158 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 159
. Refer to Programming spare keys for instructions on how to program the coded key. Note: The SecuriLock passive anti-theft system is not compatible with non-Ford aftermarket remote start systems. Use of these systems may result in vehicle starting problems and a loss of security protection. Note - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 160
Switching the ignition to the on position with a coded key disarms the vehicle. Replacement keys If your keys are lost or stolen and you don't have an extra coded key, you will need to have your vehicle towed to an authorized dealer. The key codes need to be erased from your vehicle and new coded - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 161
the 3 (on) position (maintain ignition in the 3 (on) position for at least one second, but no more than 10 seconds). This step will program your new key to a coded key. 161 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 162
anti-theft problem with your vehicle, ensure ALL remote entry transmitters are taken to the authorized dealer to aid in troubleshooting. Arming the system When armed, this system will locked and entering the 20 second countdown. 162 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 163
Turn the ignition to the on position with a programmed coded ignition key. Triggering the anti-theft system The armed system will be triggered if any door or hood is opened without using the key or the remote entry transmitter. 163 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 164
the seat's safety belt, resulting in severe covering over the upper structure of the seatback. Properly adjust the seatback to an upright driving/riding position, so that the head restraint is positioned as close as possible to the back of your head. 164 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 165
) • Lift the track release bar to move the seat forward or backward. Ensure the seat is relatched into place. • Pull the handle on the side of the seat up to recline the seat. • Push down the lever located at the bottom of the seatback to quickly fold the seatback forward. 165 2010 F-250/350/450 - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 166
strap and pull the armrest down. To gain access to the storage compartment in your armrest, lift the latch to open the lid. The lid cannot be opened in the upright position. Lift up armrest to return it to a center seatback. 166 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 167
and ride with your seatback upright and the lap belt snug and low across the hips. WARNING: Reclining the seatback can cause an occupant to slide under the seat's safety belt, resulting in severe personal injuries in the event of a collision. 167 2010 F-250/350/450/550 (f23) Owners Guide, 2nd - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 168
, up or down. Using the manual lumbar support The lumbar support control is located on the outboard side of the seat Turn the lumbar support clockwise for more support. Turn the lumbar support counterclockwise for less support. 168 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 169
. The indicator light on the control will illuminate when activated. Memory seats/power mirrors/adjustable pedals (if equipped) This system allows automatic positioning of the driver seat, power mirrors, and adjustable pedals to two programmable positions. The memory seat control is located on the - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 170
so that it is located directly behind your head or as close to that position as possible. The head restraints can be moved up and down. Lift the head restraint so that it is located directly or as close as possible behind your head. 170 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 171
edition in the Driver controls chapter. Rear folding seat system with load floor (if support a cargo load in the forward-folded position. To fold the seatback down, pull down the latch lever located on the bottom seatback to fold the seatback forward. 171 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 172
a vertical storage position, gaining access to the grocery hook located on the underside of the driver-side seat cushion. The • Pull lever on the side of the seat to release seat cushion from storage position. • Push seat cushion down 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 173
locked position. Pull up on the straps located at the sides of the load floor, and rotate forward until resting on the carpet. SAFETY RESTRAINTS Safety restraints precautions WARNING: Always drive and ride with your seatback upright and the lap belt snug and low across the hips. WARNING: To reduce - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 174
lap and shoulder belts 1. Insert the belt tongue into the proper buckle (the buckle closest to the direction the tongue is coming from) until you hear a snap and feel it latch. Make sure the tongue is securely fastened in the buckle. 174 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 175
belts can also be made to lock manually by quickly pulling on the shoulder belt. Automatic locking mode When to use the automatic locking mode In this mode, the shoulder belt is automatically pre-locked. The belt in this chapter. 175 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 176
rear outboard safety belt systems must be checked by an authorized dealer to verify that the "automatic locking retractor" feature for child seats is still functioning properly. In addition, all safety belts should be checked for proper function. 176 2010 F-250/350/450/550 (f23) Owners Guide, 2nd - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 177
of a collision. Front safety belt height adjustment The front outboard seating positions are equipped with safety belt height adjusters. Adjust the height of the shoulder belt so the belt rests across the middle of your shoulder. 177 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 178
belt height, push the button and slide the height adjuster up or down. Release the button and pull down on the height adjuster to make sure it is locked in place. Safety belt belt length so that the tongue can reach the buckle. 178 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 179
movement. Lap belts Adjusting the lap belt WARNING: The lap belt should fit snugly and as low as possible around the hips, not across the waist. • 1st row center seating position on SuperCab and Crew Cab The lap belt does not adjust automatically. 179 2010 F-250/350/450/550 (f23) Owners Guide, 2nd - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 180
Shorten and fasten the belt when not in use. Safety belt warning light and indicator chime The safety belt warning light illuminates in the instrument cluster and a chime sounds to remind the occupants to fasten their safety belts. 180 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 181
turned activate. to the on position...181 If...The driver's safety belt is not buckled before the vehicle has reached at least 3 mph (5 km/h) and 1-2 minutes have elapsed since the ignition switch has been turned to the on position... 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 182
Frontal airbags are not designed to inflate in rear and side crashes or rollovers. "I'd rather be Not a good idea. People who are ejected are 40 thrown clear" times more likely to DIE. Safety belts help prevent ejection, WE CAN'T "PICK OUR CRASH". 182 2010 F-250/350/450/550 (f23) Owners Guide, 2nd - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 183
the performance of the vehicle's airbag system. One-time disable Any time the safety belt is buckled and then unbuckled during an ignition on cycle, the Belt-Minder will be disabled for that ignition cycle only. Deactivating/activating the Belt-Minderா feature (Driver only) The Belt-Minder feature - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 184
within 10 seconds at the end of Step 3, Belt-Minder will automatically exit programming mode without changing its enable status. 4. Within 7 seconds of the light turning on, at a moderate speed, buckle then unbuckle the safety belt. • This will disable the Belt-Minder feature if it is currently - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 185
from certain upper body injuries. Airbags DO NOT inflate slowly; there is a risk of injury from a deploying airbag. WARNING: All occupants of the vehicle, including the driver, should always properly wear their safety belts, even when an air bag supplemental restraint system (SRS) is provided - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 186
. WARNING: Modifying or adding equipment to the front end of the vehicle (including frame, bumper, front end body structure and tow hooks) may affect the performance of the airbag system, increasing the risk of injury. Do not modify the front end of the vehicle. WARNING: Additional equipment such as - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 187
is wrong with the system. Rather, it means the forces were not of the type sufficient to cause activation. Airbags are designed to inflate in frontal and near-frontal collisions, not rollover, side-impact, or rear-impacts. 187 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 188
safing sensors, • a readiness light and tone • and the electrical wiring which connects the components. The diagnostic module monitors its own internal circuits and the supplemental airbag electrical system wiring (including the impact 188 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 189
until the problem and/or light are repaired. If any of these things happen, even intermittently, contact your authorized dealer as soon as possible. Unless serviced, the system may not function properly in the event of a collision. SOS Post-Crash Alert System™ The system automatically flashes the - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 190
in ON, have the passenger air bag switch serviced at your authorized dealer immediately. WARNING: In order to avoid inadvertent activation of the switch, always remove the ignition key from the passenger air bag ON/OFF switch. 190 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 191
of your safety belt system, which was designed to work with the airbag. If you are not a person who meets the requirements stated in the NHTSA/Transport Canada deactivation criteria turning OFF the airbag can increase the risk of serious injury or death in a collision. 191 2010 F-250/350/450/550 - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 192
to work as a safety system with the airbags. Read all airbag warning labels in the vehicle as well as the other important airbag instructions and warnings in this Owner's Guide. NHTSA deactivation criteria (excluding Canada) 1. Infant. An infant (less than 1 year old) must ride in the front seat - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 193
a rear-facing infant seat; or • the infant has a medical condition which, according to the infant's physician, makes it necessary for the infant to ride in the front seat so that the driver can monitor the infant's condition. 193 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 194
belt to move forward enough to incur a serious or fatal injury. The more severe the crash, and the heavier the occupant, the greater the risk is. Be sure the airbag is turned ON for any person who does not qualify under the NHTSA deactivation criteria. 194 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 195
supplemental restraint system (SRS) in this chapter for special instructions about using airbags. Important child restraint precautions WARNING: Always make sure your child is secured properly in a device that is appropriate for their height, age and weight. Child safety restraints must be purchased - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 196
Children Recommended Child size, height, weight, or age belt having the lap belt snug and low belt-positioning booster seat (generally children who are at least across the hips, 4 feet 9 inches (1.45 meters) tall or shoulder belt 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 197
LATCH only Weight and top only) top (lower tether tether anchors anchor) anchor and top tether anchor) Up to 48 lb X X (21 kg) Up to 48 lb X X X (21 kg) Over 48 lb X X (21 kg) Restraint Type Rear facing child seat Forward facing child seat Forward facing child seat WARNING: Air bags can kill - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 198
size, height, weight, or age. Follow the child restraint manufacturer's instructions and warnings provided for installation and use in conjunction with the instructions the shoulder belt under a child's arm or behind the back because it reduces the protection for the upper part of the body and may - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 199
that is recommended for the size and weight of the child. When installing a child safety seat: • Review and follow the information presented in the Airbag supplemental restraint system (SRS) section in this chapter. • Carefully follow all of the manufacturer's instructions included with the safety - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 200
to certain safety belt buckle assemblies and/or LATCH lower anchors, rendering those features potentially unusable. To avoid risk of injury, occupants should only use seating positions where they are able to be properly restrained. 200 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 201
Passenger airbag on/off switch. WARNING: Rear facing child seats should NEVER be placed in the front seats unless the passenger airbag switch is turned off. 2. Pull down on the shoulder belt and then grasp the shoulder belt and lap belt together. 201 2010 F-250/350/450/550 (f23) Owners Guide, 2nd - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 202
in the automatic locking mode. 7. Try to pull the belt out of the retractor to make sure the retractor is in the automatic locking mode (you should not be able to pull more belt out). If the retractor is not locked, repeat Steps 5 and 6. 202 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 203
lap/shoulder belt, and the belt webbing above the tongue is the shoulder belt portion of the combination lap/shoulder belt. WARNING: Always use both lap and shoulder safety belt in the Regular Cab center seating position if applicable. 203 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 204
rear facing child seat. 1. Position the child safety seat in the center seat. WARNING: Airbags can kill or injure a child in a child seat. If you must use a manufacturer's instructions. Be sure that the belt webbing is not twisted. 204 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 205
lean towards the buckle will additionally help to remove remaining slack from the belt. 6. Attach the tether strap (if the child seat is equipped). Refer to Attaching child safety seats with tether straps later in this chapter. 205 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 206
inch (2.5 cm) of movement for proper installation. 8. Ford and shoulder belt and airbag protection for belt. To lengthen the belt, hold the tongue so that its bottom is perpendicular to the direction of webbing while sliding the tongue up the webbing. 206 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 207
instructions. 4. Insert the belt end of the lap belt webbing to tighten the belt inch (2.5 cm) of movement for proper installation. 7. Ford system is composed of three vehicle anchor points: two (2) lower anchors located an accessory for 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 208
with built-in tether strap anchors located behind the seats as described below. the seat cushion or an anchor bracket mounted to the body shell on the back panel. The SuperCab rear seat belt, you can attach the top tether strap. 208 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 209
fit further rearward. 2. Locate the correct anchor for system with load floor section in this chapter for information on how to operate the rear seats. 4. Remove tether cover. 5. Clip the tether strap to the anchor as shown. • Front seats (Regular Cab) 209 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 210
automatic locking mode combination lap and shoulder belts and Installing child safety seats in cinch tongue combination lap and shoulder belt seating positions sections of this chapter for further instructions seat tether straps. 210 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 211
's instructions. A single loop can be used to route and anchor more than one child seat. For example, the center loop can be used as a routing loop for a child safety seat in the center rear seat and as an anchoring loop for child seats installed in the outboard rear seats. 211 2010 F-250/350 - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 212
by your child restraint manufacturer). Many state and provincial laws require that children use approved booster seats until they reach age eight, a height of 4 feet 9 inches (1.45 meters) tall, or 80 lb (36 kg). 212 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 213
• Can the child sit without slouching? • Does the lap belt rest low across the hips? • Is the shoulder belt centered on the shoulder and chest? • Can the child stay lap/shoulder belts, or consider using a high back booster seat. 213 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 214
the ideal fit (center) to a shoulder belt uncomfortably close to the neck and a shoulder belt that could slip off the shoulder. The drawings below also show how the lap belt should be low and snug across the child's hips. 214 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 215
support assemblies (slide bar-if equipped), shoulder belt height adjusters (if equipped), shoulder belt guide on seatback (if equipped), child safety seat LATCH and tether anchors, and attaching hardware, should be inspected after a collision. Refer to the child restraint manufacturer's instructions - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 216
in the Cleaning chapter. WARNING: Failure to inspect and if necessary replace the safety belt assembly or child restraint system under the above conditions could result in severe personal injuries in the event of a collision. 216 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 217
AWD or 4WD (when selected) has the ability to use all four wheels to power itself. This increases traction which may enable you to safely drive over terrain and road conditions that a conventional two-wheel drive vehicle cannot. 217 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 218
wheel drive vehicle in low traction situations, it won't stop any faster than two-wheel drive vehicles. Always drive at a safe speed. How your vehicle differs from other vehicles SUV and trucks a vehicle with a longer wheelbase. 218 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 219
tires, light truck or "LT" type tires, tires with nominal rim diameters of 10 to 12 inches or limited production tires as defined in Title 49 Code of Federal Regulations Part 575.104(c)(2). U.S. Department of Transportation-Tire quality grades: The U.S. Department of Transportation requires Ford - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 220
in order to get the maximum benefit from them. Glossary of tire terminology • Tire label: A label showing the OE (Original Equipment) tire sizes, recommended inflation pressure and the maximum weight the vehicle can carry. 220 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 221
Tires, Wheels and Loading • Tire Identification Number (TIN): A number on the sidewall of each tire providing information about the tire brand and manufacturing plant, tire size and date of manufacture. Also referred to as DOT code. • Inflation pressure: A measure of the amount of air in a tire. • - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 222
or lightly applying the brakes. The shimmy will cease as the vehicle speed decreases. Maximum Permissible Inflation Pressure is the tire manufacturer's maximum permissible pressure and/or the pressure at which the maximum load can be carried by the tire. This pressure is normally 222 2010 F-250/350 - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 223
at the higher of the front and rear inflation pressure as shown on the Tire Label. 6. Visually inspect the tires to make sure there are no nails or other objects embedded that could poke a hole in the tire and cause an air leak. 223 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 224
or seriously under-inflated without first removing the tire from the wheel assembly for inspection. Do not attempt to add air to tires or replace tires or wheels without first taking precautions to protect persons and property. 224 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 225
suspected, have the tire demounted and inspected in case it needs to be repaired or replaced. For your safety, tires that are damaged or show signs of excessive wear should not be used because they are more likely to blow out or fail. 225 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 226
conditions can accelerate the aging process and may require tires to be replaced more frequently. You should replace your spare tire when you replace the road tires or after six years due to aging even if it has not been used. 226 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 227
use of non-recommended tires and wheels could cause steering, suspension, axle or transfer case/power transfer unit failure. If you have questions regarding tire replacement, contact your authorized dealer as soon as possible. 227 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 228
generally be replaced as a pair. The tire pressure sensors mounted in the wheels are not designed to be used in aftermarket wheels. The use of wheels or tires not recommended by Ford Motor Company may affect the operation of your Tire Pressure Monitoring System (if equipped). If the TPMS indicator - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 229
tire wear. Tire rotation Rotating your tires at the recommended interval (as indicated in the scheduled maintenance information that comes with your vehicle) will help your tires wear more evenly, providing better tire performance and longer tire life. 229 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 230
sensors need to be updated. Always perform the TPMS reset procedure after tire rotation. If the system is not reset, it may not provide a low tire pressure warning when necessary. See the TPMS reset procedure in this chapter. 230 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 231
on the sidewall of all tires. This information identifies and describes the fundamental characteristics of the tire and also provides a U.S. DOT Tire Identification Number for safety standard certification and in case of a recall. 231 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 232
. 3. 65: Indicates the aspect ratio which gives the tire's ratio of height to width. 4. R: Indicates a "radial" type tire. 5. 15: Indicates the wheel or rim diameter in inches. If you change your wheel size, you will have to purchase new tires to match the new wheel diameter. 6. 95: Indicates the - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 233
load in kilograms and pounds that can be carried by the tire. Refer to the Safety Compliance Certification Label, which is located on the B-Pillar or the edge of the driver's door, for the correct tire pressure for your vehicle. 233 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 234
's door. The cold inflation pressure should never be set lower than the recommended pressure on the vehicle label. The tire suppliers may have additional markings, notes or warnings such as standard load, radial tubeless, etc. 234 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 235
the rear axle (a total of six or more tires on the vehicle). 4. Maximum Load Single lb (kg) at psi (kPa) cold: Indicates the maximum load and tire pressure when the tire is used as a single; defined as two tires (total) on the rear axle. 235 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 236
16: Indicates the wheel or rim diameter in inches. If you change your wheel size, you will have to purchase new tires to match the new wheel diameter. Location of the tire label You will find a Tire Label containing tire inflation pressure by tire size and other important information located on the - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 237
the replacement or alternate tires and wheels allow the TPMS to continue to function properly. The Tire Pressure Monitoring System complies with part 15 of the FCC rules and with RSS-210 of Industry Canada. Operation is subject to the 237 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 238
the risk of tire failure, loss of control, vehicle rollover and personal injury. Changing tires with TPMS Each road tire is equipped with a tire pressure sensor located inside the tire/wheel cavity. The pressure sensor is attached to the valve stem. The pressure sensor is covered by the tire and is - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 239
Tire Pressure Monitoring System is to warn you when your tires need air. It can also warn you in the event the system is no longer capable of functioning as intended. Please refer to the following chart for information concerning your Tire Pressure Monitoring System: Low Tire Pressure Warning Light - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 240
as necessary.) Check air pressure in the road tires. If any tire is under-inflated, carefully drive the vehicle to the nearest location where air can be added to the tires. Inflate all the tires to the recommended inflation pressure. 240 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 241
. With this information, the system can detect and properly warn of low tire pressures. TPMS reset tips: • To reduce the chances of interference from another vehicle, the TPMS reset procedure should be performed at least 3 feet (1 meter) away from another Ford Motor Company vehicle undergoing the - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 242
by the module for this position. If a double horn is heard, the reset procedure was unsuccessful, and must be repeated. 7. Remove the valve cap from the valve stem on the right front tire. Decrease the air pressure until the horn sounds. 242 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 243
of vehicle control, vehicle rollover, personal injury and death. Additionally, the use of non-recommended tires and wheels could cause steering, suspension, axle or transfer case/power transfer unit failure. Note: Do not use snow chains on vehicles with 20 inch wheels and tires. The tires on your - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 244
tire chains when they are no longer needed. Do not use tire chains on dry roads. • The suspension insulation and bumpers will Weight - is the weight of your new vehicle when you picked it up from your authorized dealer plus any aftermarket equipment. 244 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 245
assembly plant. If any aftermarket or authorized-dealer installed equipment has been installed on the vehicle, the weight of the equipment must be subtracted from the payload listed on the Tire Label in order to determine the new payload. WARNING: The appropriate loading capacity of your vehicle can - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 246
Tires, Wheels and Loading Example only: Cargo Weight - includes all weight added to the Base Curb Weight, including cargo and optional equipment. When towing, trailer tongue load or king pin weight is also part of cargo weight. GAW (Gross Axle Weight) - is the total weight placed on each axle ( - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 247
Tires, Wheels and Loading GAWR (Gross Axle Weight Rating) - is the maximum allowable weight that can be carried by a single axle (front or rear). These numbers are shown on the Safety Compliance Certification Label located on the B-Pillar or the edge of the driver's door. The total load on each axle - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 248
Tires, Wheels and Loading • Example only: WARNING: Exceeding the Safety Compliance Certification Label vehicle weight rating limits could result in substandard vehicle handling or performance, engine, transmission and/or structural damage, serious damage to the vehicle, loss of control and personal - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 249
with lower load carrying capacities than the original tires because they may lower the vehicle's GVWR and GAWR limitations. Replacement tires with a higher limit than the original tires do not increase the GVWR and GAWR limitations. 249 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 250
for the past 2 years. Measuring the inside of the vehicle with the rear seat folded down, you have room for 12-100 lb. (45 kg) bags of cement. Do you have enough load capacity 250 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 251
, refer to your Power Stroke Direct Injection Turbo Diesel Owner's Guide Supplement. Your vehicle may tow a Conventional/Class IV trailer or fifth wheel trailer provided the maximum trailer weight is less than or equal to the maximum trailer weight listed for your engine and rear axle ratio on the - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 252
used. These additional maximum trailer weight and tongue load limitations are listed in the chart/table that follows the listing of GCWRs. Towing a trailer places an additional load on your vehicle's engine, transmission, axle, brakes, tires and suspension. Inspect these components carefully prior - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 253
Tires, Wheels and Loading Engine Maximum GCWR - lb. (kg.) Rear axle Manual Automatic ratio transmission transmission F-250 Pick-up 3.73 15000 (6804) 16000 (7257) 4.10 17000 (7711) 18000 (8165) 4.10 20000 (9072) 21000 (9525) 4.30 22000 (9979) 22500 (10206) F-350 Single Rear Wheel (SRW) Pick-up 3.73 - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 254
a trailer ball hitch or trailer ball) to the bumper or use hitches that clamp onto the vehicle's bumper or attach to the axle. You must distribute the load in your trailer so that 10-15% for conventional towing or 15-25% fifth-wheel towing of the total weight of the trailer is on the tongue. Hitch - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 255
to the bumper. Trailer brakes Electric brakes and manual, automatic or surge-type trailer brakes are safe if installed properly and adjusted to the manufacturer's specifications. The trailer brakes must meet local and Federal regulations. 255 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 256
and effective trailer braking by powering the trailer's electric brakes with a proportional output based on the towing vehicle's brake pressure. WARNING: The Ford TBC has only been verified to be compatible with trailers having electric-actuated drum brakes (one to four axles) and not hydraulic - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 257
lever to the left to activate power to the trailer's electric brakes independent of the tow vehicle's brakes (see the following Procedure for adjusting GAIN section for instructions on proper use of this feature). If the manual control is activated while the brake is also applied, the greater of - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 258
trailer brakes drawing too much current. Note: Your TBC can be diagnosed by your authorized dealer to determine exactly which trailer fault has occurred; however, if the fault is with the trailer this diagnosis is not covered under your Ford warranty. 258 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 259
with the brake system of the vehicle, including ABS, in order to reduce the likelihood of trailer wheel lockup. Therefore, if these systems are not functioning properly the TBC may not function at full performance. • When the vehicle is turned off, the TBC Output is disabled and the display - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 260
Tires, Wheels and Loading • Turn off the speed control. The speed control may shut off automatically when you are towing on long, steep grades. • To eliminate excessive transmission shifting, activate the Tow/Haul feature. This will also assist in transmission cooling. For additional information, - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 261
such that 10-15% of the trailer weight is on the hitch (15-25% for fifth-wheel or gooseneck towing). • Never exceed truck, trailer, receiver, ball, tongue, tire or coupler loading recommendations. • Keep the center-of-gravity low for best handling. Braking • Anticipate the need to stop; allow much - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 262
to ensure that your transmission is not damaged. Note: Put your climate control system in recirculated air mode to prevent exhaust fumes from entering the vehicle. Refer to the Climate Controls chapter for more information. 262 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 263
Tires, Wheels and Loading Transmission Manual Automatic Manual 4X2 or 4x4 with electronic-shift transfer case Drivetrain configuration 4x4 with manual-shift transfer case Requirements for neutral towing Transmission in (N) Neutral; Transfer case in (N) (Neutral); Hublocks set to FREE1 Do not tow - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 264
steering wheel. 3. On- all electrical circuits operational. Warning lights illuminated. Key position when driving. 4. Start- cranks the engine. Release the key as soon as the engine starts. Preparing to start your vehicle Engine starting is controlled by the powertrain control system. This system - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 265
Safety Restraints chapter. 2. Make sure the headlamps and electrical accessories are off. If starting a vehicle with an automatic transmission: 1. Make sure the parking brake is set. 2. Make sure the gearshift is in P (Park). 265 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 266
. Your vehicle has a computer assisted cranking system that assists in starting the engine. After releasing the key from the 4 (start) position, the engine may continue cranking for up to 10 seconds or until the vehicle starts. 266 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 267
to follow engine block heater instructions could result in property damage or physical harm. WARNING: To reduce the risk of electrical shock, do not use your heater with ungrounded electrical systems or two-pronged (cheater) adapters. 267 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 268
for heat anywhere in the electrical hookup once the system has been operating for approximately a half hour. • Finally, have the engine block heater system checked during your fall tune-up to be sure it's in good working order. 268 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 269
not improve system performance and will unnecessarily use additional electricity. Make sure system is unplugged and properly stowed before driving the vehicle. While not in use, make sure the protective cover seals the prongs of the engine block heater cord plug. BRAKES Occasional brake noise is - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 270
light does not illuminate during start up, remains on or flashes, the ABS may be disabled and may need to be serviced. Even when the ABS is disabled, ! P normal braking is still effective. If your BRAKE warning lamp BRAKE illuminates with the parking brake released, have your brake system serviced - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 271
latched in P (Park) (automatic transmission) or in 1 (First) (manual transmission). Note: If your vehicle is equipped with a manual transmission, the engine may be required to run while power accessories operate and the parking brake is set. It is recommended that wheel chocks be used during this - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 272
experience a severe road event, SLOW DOWN. The traction control switch, located on the instrument panel to the left of the climate control system, has an indicator light that illuminates when the system is off. The traction control system will automatically turn on every time the ignition is turned - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 273
Driving If the power steering system breaks down (or if the engine is turned off), you can steer the vehicle manually, but it takes more effort. If the steering wanders or pulls, check for: • an improperly inflated tire • uneven tire wear • loose or worn suspension components • loose or worn - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 274
out the access cover. Insert the tool into the access hole and slide the white override button towards the left. Move the gear shift lever into N (Neutral) while holding the white override disc towards the left. 3. Start the vehicle. 274 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 275
will resume. P (Park) This position locks the transmission and prevents the rear wheels from turning. To put your vehicle in gear: • Start the engine • Press the brake pedal • Move the gearshift lever into the desired gear 275 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 276
position; this engine braking will slow the vehicle and assist the driver in controlling the vehicle when descending a grade. Depending on driving conditions and load conditions, the transmission may downshift, slow the vehicle and control 276 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 277
the amount the brake pedal is depressed. To deactivate the tow/haul feature and return to normal driving mode, press the button on the end of the gearshift lever. The TOW HAUL light will no longer be illuminated. When you shut-off and restart the engine, the transmission will automatically return to - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 278
or damage to the transmission and tires may occur, or the engine may overheat. MANUAL TRANSMISSION OPERATION (IF EQUIPPED) R 1 3 D L 2 4 Using the clutch Manual transmission vehicles have a do not allow engine speed to exceed 278 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 279
km/h) 4 - D (Overdrive) Maximum downshift speeds1 6-speed transmission Shift from: Transfer case position (if equipped)2 2H or 4H 4L 45 mph (72 km/h) 16 mph (26 km/h) D transmission from accidentally being shifted into R (Reverse) from D (Overdrive). 279 2010 F-250/350/450/550 (f23) Owners Guide, - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 280
brake fully. REVERSE SENSING SYSTEM (IF EQUIPPED) The reverse sensing system (RSS) sounds a tone to warn the driver of obstacles near the rear bumper include reduced performance or block the normal detection zone of the RSS system may create false beeps. 280 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 281
may also be heard if items in the truck bed protrude rearward outside the bed. The RSS automatically turns on when the gearshift lever is placed in R (Reverse) and the ignition is on. A control in the message center allows the driver to disable the system, refer to Message center in the Instrument - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 282
system, located on the tailgate, provides a video image, which appears in the rearview mirror or on the navigation screen (if equipped), of the area behind the vehicle. It adds assistance to the driver while reversing or reverse parking the vehicle. To use the camera system, place the transmission - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 283
. WARNING: Do not use the camera system with the tailgate open. If the back end of the vehicle is hit or damaged, then check with your authorized dealer to have your rear video system checked for proper coverage and operation. 283 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 284
so could result in difficult disengagement of the transfer case, increased tire wear and decreased fuel economy. Manual Shift On Stop (MSOS) 4x4 system (if equipped) The 4WD system is engaged or disengaged by rotating the control for both front wheel hub locks from the FREE or LOCK position, then - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 285
operated by a rotary control located on the instrument panel that allows you select 2WD, 4x4 High or 4x4 Low operation. • uses auto-manual hub locks that can be engaged and disengaged automatically based on the 4x4 mode selected. 285 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 286
as the 4x4 system shifts or engages. This is normal. In order to reduce engagement noise, it is recommended that all shifts be performed at speeds below 5 mph (8 km/h). 2H (2WD) - For general on-road driving. Sends power to the rear wheels only. 286 2010 F-250/350/450/550 (f23) Owners Guide, 2nd - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 287
for use on dry pavement. N (Neutral) - Only used when towing the vehicle. 4L (4x4 Low) - For low-speed off-road applications that require extra power such as steep grades, deep sand or pulling a boat out of the water. Sends power to front and rear wheels. This mode is not intended for use on dry - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 288
Shifting from 4H (4x4 High) to 4L (4x4 Low) 1. Bring the vehicle to a stop or a speed below 5 mph (8 km/h). 2. Place the gearshift lever in N (Neutral). If the vehicle is equipped with a manual transmission, also depress the clutch pedal. 288 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 289
Driving 3. Move the transfer case shift lever 2H through N (Neutral) directly to 4L (4x4 Low). 4H 4. If the shift lever does not, or only N partially moves to the 4L (4x4 Low) position, perform a shift with the 4L transmission in N (Neutral) (or clutch pedal depressed) and the vehicle rolling at a - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 290
. 4x4 LOW - For low-speed off-road applications that require extra power such as steep grades, deep sand or pulling a boat out of the water. Sends power to front and rear wheels. This mode is not intended for use on dry pavement. Shifting from 2WD to 4x4 HIGH Rotate the 4x4 control to the 4x4 HIGH - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 291
Neutral). If the vehicle is equipped with a manual transmission, also depress the clutch pedal. 3. Move the 4x4 control to the 4x4 LOW position. 4. Hold the shift conditions until the 4x4 LOW indicator light illuminates. 5. If the 4x4 LOW indicator light flashes continuously for more than 10 seconds - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 292
of the area before driving. Map out your route before driving in the area. To maintain steering and braking control of your vehicle, you must have all four wheels on the ground and they must be rolling, not sliding or spinning. 292 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 293
and reverse gears, stopping between shifts, in a steady pattern. Press lightly on the accelerator in each gear. Do not rock the vehicle if the engine is not at normal operating temperature or damage to the transmission may occur. 293 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 294
vehicle, i.e., turn the steering wheel only as rapidly and as far as required to avoid the emergency. Excessive steering will result in less vehicle control, not more. Additionally, smooth variations of the accelerator and/or brake pedal pressure should be utilized if changes in vehicle speed are - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 295
vehicle. WARNING: If the parking brake is fully released, but the brake warning lamp remains illuminated, the brakes may not be working properly. See your authorized dealer. 4WD Systems 4WD (when you select a 4WD mode), uses all four wheels to power the vehicle. This increases traction, enabling - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 296
Driving Note: If air is released from your tires, the Tire Pressure Monitoring System (TPMS) indicator light may illuminate (if equipped). Mud and water If you must drive through high water, drive slowly. Traction or brake capability may be limited. When driving through water, determine the depth; - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 297
because you might roll over. It is better to back down to a safe location. Apply just enough power to the wheels to climb the hill. Too much power will cause the tires to slip, spin or lose traction, resulting in loss of vehicle control. Descend a hill in the same gear you would use to climb up - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 298
make it more likely the vehicle will roll over as a result of a loss of control. Ford Motor Company recommends that caution be used with any vehicle equipped with a high load or device (such as ladder racks or pickup box cover). 298 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 299
POWER SOURCE Auxiliary equipment called power take-off, or PTO, is often added to the engine or transmission to operate utility equipment. Examples include a wheel-lift for tow trucks, cranes, tools for construction or tire service, and pumping fluids. PTO applications draw auxiliary horsepower - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 300
provide front-to-rear weight balance for proper braking and steering. • Front wheel toe may require re-adjustment to prevent premature uneven tire wear. Specifications are found in the Ford Workshop Manual. • Headlight aim may require re-adjustment. • The tire air pressures recommended for general - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 301
an air bag supplemental restraint system (SRS) is provided. Never remove or defeat the "tripping mechanisms" designed into the snow removal equipment by its manufacturer. Doing so may cause damage to the vehicle and the snow removal equipment as well as possible airbag deployment. 301 2010 F-250 - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 302
air bag supplemental restraint system (SRS) or its fuses. See your Ford or Lincoln Mercury dealer. WARNING: Additional equipment such as snowplow equipment may effect the performance of the airbag sensors increasing the risk of injury. Please refer to the Body Builders Layout Book for instructions - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 303
(56 km) from the disablement location, the member shall be responsible for any mileage costs in excess of 35 miles (56 km). Trailers shall be covered up to $200 if the disabled eligible vehicle requires service at the nearest authorized dealer. If the trailer is disabled, but the towing vehicle is - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 304
. Press in the flasher control and all front and rear direction signals will flash. Press the flasher control again to turn them off. Use it when your vehicle is disabled and is creating a safety hazard for other motorists. 304 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 305
off. 2. Check the fuel system for leaks. 3. If no leaks are apparent, reset the switch by pushing in on the reset button. 4. Turn the ignition on. 5. Wait a few seconds and return the key to off. 6. Make another check for leaks. 305 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 306
Orange Red Blue Tan Natural Cartridge Fuse link maxi cartridge fuses Blue Blue - - Pink Pink Green Green Red Red Yellow Yellow - Brown Black Black 306 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 307
battery before servicing high current fuses. Always replace the cover to the passenger compartment fuse panel before reconnecting the battery. If the battery has been disconnected and reconnected, refer to the Battery section of the Maintenance and Specifications chapter. 307 2010 F-250/350/450 - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 308
entertainment system (FES) Not used (spare) Keypad illumination, Brake-shift interlock (BSI), SPBJB Turn signals Left headlamp (Low beam) Right headlamp (Low beam) Interior lighting, Lighted running boards Cargo lamp, Puddle lamp, Switch backlight 2010 F-250/350/450/550 (f23) Owners Guide, 2nd - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 309
Horn relay feed Power telescoping mirror switch, Demand lamps - underhood and illuminated visor (battery saver) Cluster Ignition switch feed, Passenger compartment fuses 28, 42, 43, 44, and 45, Engine compartment starter relay coil #57 (Diesel engine), Accessory shutoff control module (if equipped - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 310
Protected Circuits Restraints control module (RCM), Passenger airbag deactivation indicator Trailer tow brake controller, Trailer tow battery charge relay coil Not used (spare) Reverse sensing system (RSS), 4x4 module, 4x4 solenoid, Traction control switch, Tow/Haul switch (Diesel engine) Passive - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 311
/Variable blower control (Dual zone climate control) Electronic shift-on-the-fly (ESOF) Lo-Hi Heater mirror Not used Trailer brake controller (TBC) Anti-lock brake system (ABS) module (Pump) Upfitter auxiliary switch #1 Upfitter auxiliary switch #2 311 2010 F-250/350/450/550 (f23) Owners Guide, 2nd - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 312
panel power point Brake on/off (BOO) relay feed Brake switch, Brake switch relay coil, SJB module, 4x4 module Not used Not used A/C clutch Wipers Fuel pump driver module (FPDM), Fuel injectors (Gasoline engines), Diesel fuel control module (DFCM) (Diesel engine) Back-up lamps, Reverse sensing system - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 313
alive power Transmission control module (TCM) (Diesel engine only) Not used ECM power (Diesel engine) Starter relay Power point (Center console - front) Trailer park lamp relay Power point (Center console - rear) Trailer battery charge relay Driver power seat or memory module, Air ride seats Run - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 314
, A/C cycle pressure switch Fuel pump relay diode, PCM/ECM Run/Start power Gasoline engines: Ignition coils Diesel engine: Engine TCM Reverse Camera System (RCS) 58 59 60 61 62 63 64 65 66 67 68 69 70 Relay Relay Diode Diode Diode 15A** 5A 10A** 71 72 73 5A** 15A** 2A** 314 2010 F-250/350/450 - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 315
coil power Gasoline engines: VPWR: PCM Diesel engine: VPWR: ECM ABS module logic 75 76 5A** 20A** 77 10A** * Cartridge fuses ** Mini fuses CHANGING A FLAT TIRE If you get a flat tire while driving: • do not brake heavily. • gradually decrease the vehicle's speed. • hold the steering wheel firmly - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 316
car washing equipment • Try to repair the dissimilar spare tire Use of one of the dissimilar spare tires listed above at any one wheel location can lead to impairment of the following: • Handling, stability and braking performance • Comfort and noise • Ground clearance and parking at curbs - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 317
camper body • Driving vehicles with a load on the cargo rack Drive cautiously when using a full-size dissimilar spare tire/wheel and seek service as soon as possible. Spare tire information Note: If your vehicle is equipped the tire pressure monitoring system (TPMS), the system indicator light will - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 318
block (in both directions) the wheel that is diagonally opposite to the tire being changed. Refer to the instruction sheet (located in the glove box) for detailed tire change instructions. Park on a level surface, activate hazard flashers and set the parking brake. • Automatic transmission: Place - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 319
and slide parts together. To disconnect, depress button and pull apart. • one wheel nut wrench. Slide over square end of jack handle. • Vehicles equipped with dual rear wheels, insert the lug wrench extension into the lug wrench to reach the lug nuts. 319 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 320
parking brake is set, then block (in both directions) the wheel that is diagonally opposite (other side and end of the vehicle) to the tire being changed. WARNING: If the vehicle slips off the jack, you or someone else could be seriously injured. 320 2010 F-250/350/450/550 (f23) Owners Guide, 2nd - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 321
jacked. 1. Turn engine off and block the wheel that is diagonally opposite of the flat tire using the wheel chock, if equipped. If the vehicle is a 4x4, lock the manual hub on the wheel. 2. Remove the jack, jack handle, lug wrench and spare tire from the stowage locations. 3. Use the tip of the - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 322
fits onto the flat area on the outboard side of the differential. • Front passenger side (4x4) Note: View shown from the rear of the vehicle to clearly identify the jack point. Place the jack directly under the axle. • Rear 322 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 323
F-350 Dual Rear Wheel (DRW) and F-450/F-550 vehicles only: 11. Slide the notched end of the jack handle over the release valve and use the handle to slide the jack under the vehicle. Make sure the valve is closed by turning it clockwise. 323 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 324
• Front passenger side (4x4): F-350 DRW Note: View shown from the rear of the vehicle to clearly identify the jack point. Note: Place the jack directly under axle and inboard of the radius arm so that the jack clears the radius arm. 324 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 325
. 14. Use an up-and-down motion with the jack handle to raise the wheel completely off the ground. Hydraulic jacks are equipped with a pressure release valve that prevents lifting loads which exceed the jack's rated capacity. 325 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 326
to all vehicles: 18. Remove the jack and fully tighten the lug nuts in the order shown. Refer to Wheel lug nut torque specifications later in this chapter for the proper lug nut torque specification. 8-lug nut torque sequence 326 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 327
tire and wheel using the spare tire winch mechanism; store the flat in the bed of the truck. 20. Stow the jack, jack handle and lug wrench. Make sure the jack is securely fastened so it does not rattle when driving. 21. Unblock the wheels. The following step applies to F-250/F-350 Single Rear Wheel - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 328
in this manner will fall off or become loose with minimal force or impact. Installing dual rear wheel ornaments 1. Align the ornament with the lug nuts. • (1) is the clip and (2) is an even gap between the ornament and the wheel. 328 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 329
stem facing in the direction specified on the Tire Changing Instructions located in the glove box. 2. Slide the wheel partially under the vehicle and install the retainer through the wheel center. Pull on the cable to align the components at the end of the cable. 3. Turn the jack handle clockwise - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 330
surfaces of the wheel. Installing wheels without correct metal-to-metal contact at the wheel mounting surfaces can cause the wheel nuts to loosen and the wheel to come off while the vehicle is in motion, resulting in loss of control. 330 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 331
vehicle's electrical system. 3. Park the booster vehicle close to the hood of the disabled vehicle making sure the two vehicles do not touch. Set the parking brake on both vehicles and stay clear of the engine cooling fan and other moving parts. 331 2010 F-250/350/450/550 (f23) Owners Guide, 2nd - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 332
. 5. Turn the heater fan on in both vehicles to protect from any electrical surges. Turn all other accessories off. Connecting the Connect the other end of the positive (+) cable to the positive (+) terminal of the assisting battery. 332 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 333
the end of the second cable to the negative (-) terminal of the battery to be jumped. A spark may cause an explosion of the gases that surround the battery. 5. Ensure that the cables are clear of fan blades, belts, moving parts of both engines, or any fuel delivery system parts. 2010 F-250/350 - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 334
at moderately increased speed. 2. Start the engine of the disabled vehicle. 3. Once the disabled vehicle has been started, run both engines for an additional connection of the booster vehicle's battery. 334 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - - - - + + + + - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 335
from the positive (+) terminal of the disabled vehicle's battery. After the disabled vehicle has been started and the jumper cables removed, allow it to idle for several minutes so the engine computer can relearn its idle conditions. 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 336
met: • On Electronic Shift-On-the-Fly (ESOF) vehicles, the 4x4 control is turned to the 2WD position prior to towing. • On manual-shift transfer case vehicles, the front wheel hub locks are in the FREE position prior to towing. 336 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 337
damage to the automatic transmission. Note: On Dual Rear Wheel (DRW) vehicles, an outer rear wheel must be removed prior to using a wheel lift wrecker. Ford Motor Company produces a towing manual for all authorized tow truck operators. Have your tow truck operator refer to this manual for proper - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 338
and resources are available online at www.genuineservice.com. • U.S. dealer locator by Dealer Name, City/State, or Zip Code • Owner Guides • Maintenance Schedules • Recalls • Ford Extended Service Plans • Ford Genuine Accessories 338 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 339
and city where located • The vehicle's current odometer reading In some states, you must directly notify Ford in writing before pursuing remedies under your state's warranty laws. Ford is also allowed a final repair attempt in some states. 339 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 340
18 months of ownership of a new vehicle or the first 18,000 vehicle) OR 3. The vehicle is out of service for repair of nonconformities for a total of Ford Motor Company and to your dealer. If a warranty concern has not been resolved using the three-step 340 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 341
about your new vehicle, the BBB will review the claim for service concern have been unsatisfactory, Ford of Canada participates in an impartial third party mediation/arbitration program administered by the Canadian Motor Vehicle Arbitration Plan (CAMVAP). 341 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 342
dealer cannot help you, contact: FORD MOTOR COMPANY FORD EXPORT OPERATIONS 1555 Fairlane Drive Fairlane Business Park #3 Allen Park, Michigan 48101 U.S.A. Telephone: (313) 594-4857 FAX: (313) 390-0804 Email: [email protected] 342 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 343
(VIN) and new address with Ford Motor Company Export Operations Guide French Owner's Guides can be obtained from your authorized dealer or by writing to: Ford Motor Company of Canada, Limited Service Publications CHQ202 The Canadian Road P.O. Box 2000 Oakville, ON, Canada L6J 5E4 343 2010 F-250 - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 344
group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Ford Motor Company. To contact NHTSA, you may -free number: 1-800-333-0510. 344 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 345
• Immediately remove items such as gasoline, diesel fuel, bird droppings and insect deposits because your authorized dealer. • Remove any exterior accessories, such as antennas, before entering a product as you would a wax to clean bumpers and other chrome parts; allow the cleaner to dry for a few - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 346
paint sealant to come in contact with any non-body (low-gloss black) colored trim, such as grained door handles, roof racks, bumpers, side moldings, mirror housings or the windshield cowl area. The paint sealant will "gray" or stain the parts over time. PAINT CHIPS Your authorized dealer has touch - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 347
Take care when using a power washer to clean the engine. The high-pressure fluid could penetrate the sealed parts and cause damage. • locations. • Cover the highlighted areas to prevent water damage when cleaning the engine. • 5.4L V8 gasoline engine 347 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 348
• 6.8L V10 gasoline engine PLASTIC (NON-PAINTED) EXTERIOR PARTS Use only approved products to clean plastic parts. These products are available from your authorized dealer. • For Premium Windshield Washer Concentrate (ZC-32-A), 348 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 349
use chemical solvents or strong detergents when cleaning the steering wheel or instrument panel to avoid contamination of the airbag system. If a staining liquid like coffee/juice has been using a rubbing motion for 60 seconds. 349 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 350
and low gloss paints that require special the low gloss performed by an authorized dealer or an experienced repair facility. Low gloss paint area The low a clean, dry cloth. When cleaning the low gloss areas: • Do not use paper paint waxes or sealants. Dust the low gloss areas with a clean, dry cloth, or - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 351
cloth seats and safety belts: • Remove dust and loose dirt with a vacuum cleaner. • Remove light stains and soil with rubber, vinyl and plastics, or oil/petroleum-based leather conditioners. These products may cause premature wearing 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 352
covers and should be considered as proof of a genuine leather product. In order to lessen the appearance of certain scratches and other wear marks, apply conditioner on the affected area following the same instructions as in the Conditioning section. 352 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 353
your vehicle frequently. Keep body and door drain holes free from packed dirt. Note: Use care when using a power washer to clean the driveline, especially the driveshaft and interfacing components. The high-pressure fluid could penetrate the sealed parts and cause damage. FORD, LINCOLN AND MERCURY - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 354
-54) Spot and Stain Remover (U.S. only) (ZC-14) Tire Clean and Shine (ZC-28) Ultra-Clear Spray Glass Cleaner (ZC-23) Vinyl Cleaner (Canada only) (CXC-93) Vinyl Conditioner (Canada only) (CXC-94) Wheel and Tire Cleaner (ZC-37-A) 354 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 355
equipped with an automatic transmission, set the parking brake and shift to P (Park). For vehicles equipped with a manual transmission, set the parking brake, press and hold the clutch pedal, place the gearshift in N (Neutral), and release the clutch pedal. 2. Block the wheels. WARNING: To reduce - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 356
front of the vehicle and release the auxiliary latch located below the passenger side of the grille, next to the headlamp. Slide the handle to release the auxiliary latch. 3. Lift the hood until the lift cylinders hold it open. 356 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 357
Turbo Diesel Owner's Guide Supplement for diesel engine component locations. 5.4L V8 gasoline engines 1. Windshield washer fluid reservoir 2. Battery 3. Transmission fluid dipstick (automatic transmission) 4. Engine oil filler cap 5. Engine oil dipstick 6. Power steering fluid reservoir 7. Brake - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 358
2. Battery 3. Automatic transmission fluid dipstick 4. Engine oil filler cap 5. Engine oil dipstick 6. Power steering fluid reservoir 7. Brake fluid reservoir 8. Engine coolant reservoir 9. Air filter assembly 10. Power distribution box 358 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 359
a click is heard. Replace wiper blades at least once per year for optimum performance. Poor wiper quality can be improved by cleaning the wiper blades and the windshield. Refer to Windows and wiper blades in the Cleaning chapter. 359 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 360
the parking brake and ensure the gearshift is securely latched in P (Park) (automatic transmission) or 1 (First) (manual transmission). 4. Open the hood. Protect yourself from engine heat. 5. Locate and carefully remove the engine oil dipstick. • 5.4L/6.8L gasoline engines only; for diesel engine - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 361
cap clockwise 1/4 of a turn until three clicks are heard or until the cap is fully seated. To avoid possible oil loss, DO NOT operate the vehicle with the engine oil level dipstick and/or the engine oil filler cap removed. 361 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 362
not meet Ford material and design specifications, start-up engine noises or knock may be experienced. It is recommended you use the appropriate Motorcraft oil filter or another with equivalent performance for your engine application. 362 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 363
can cause personal injury. Therefore, do not allow flames, sparks or lighted substances to come near the battery. When working near the battery, always shield your face and protect your eyes. Always provide proper ventilation. 363 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 364
trim strategy for optimum driveability and performance. To begin this process: 1. With the vehicle at a complete stop, set the parking brake. 2. Put the gearshift in P (Park) (automatic transmission) or the neutral position (manual transmission), turn off all accessories and start the engine. 3. Run - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 365
If the level falls below, add coolant per the instructions in the Adding engine coolant section. Your vehicle was of coolant falls below 40% or above 60%, the engine parts could become damaged or not work properly. A 50/50 mixture 365 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 366
is hot. Steam and scalding liquids released from a hot cooling system can burn you badly. Also, you can be burned if you spill coolant on hot engine parts. WARNING: Do not put engine coolant is used. DO NOT MIX recycled coolant 366 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 367
let it cool. 2. When the engine is cool, wrap a thick cloth around the coolant pressure relief cap on the coolant reservoir (a translucent plastic bottle). Slowly turn cap counterclockwise (left) until pressure begins to release. 367 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 368
this chapter. If your vehicle is equipped with a diesel engine, refer to the Maintenance product specifications and capacities section of your 6.0 and 6.4 Liter Power Stroke Direct Injection Turbo Diesel Owner's Guide Supplement. 368 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 369
should use a 50/50 mixture of engine coolant and distilled water for optimum cooling system and engine protection. What you should know about fail-safe cooling (if equipped) If ambient temperatures, vehicle load and terrain. 369 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 370
engine soon indicator will illuminate. If the engine reaches a preset over-temperature condition, the engine will automatically switch to alternating cylinder operation. Each disabled cylinder acts as an air pump and cools the engine. When this occurs the vehicle will still operate. However: • The - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 371
changing the fuel filter. Replace the fuel filter with an authorized Motorcraft part. The customer warranty may be void for any damage to the fuel system if an authorized Motorcraft fuel filter which is a cancer-causing agent. 371 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 372
flow of fuel through a fuel pump nozzle can produce static electricity, which can cause a fire if fuel is pumped into an ungrounded fuel container. 372 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 373
can cause severe injuries. To help avoid injuries to you and others: Read and follow all the instructions on the pump island; Turn off your engine when you are refueling; Do not smoke if align the cap properly and reinstall it. 373 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 374
fuel tank or fuel system if the correct genuine Ford or Motorcraft fuel filler cap is not used. WARNING: The fuel system may be under pressure. If the fuel filler loss of vehicle performance, and repairs may not be covered under warranty. 374 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 375
specifications to provide improved performance and emission control system protection for your vehicle. Gasolines that meet the World-Wide Fuel Charter should be used when available. Ask your fuel supplier about gasolines that meet the World-Wide Fuel Charter. Cleaner air Ford endorses the use of - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 376
system service engine soon indicator may come on. For more information on the service engine soon indicator, refer to Warning lights capacity switch to the off position prior to refueling, an error in the reading will result if the engine is left running. 376 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 377
low - medium - high) each time the tank is filled. • Allow no more than two automatic completely and record the initial odometer reading (in miles or kilometers odometer reading. 4. Subtract your initial odometer reading from the current odometer you may be able to change a number of variables and - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 378
. Maintenance • Keep tires properly inflated and use only recommended size. • Operating a vehicle with the wheels out of alignment will reduce fuel economy. • Use recommended engine oil. Refer to Maintenance product specifications and capacities in this chapter. • Perform all regularly scheduled - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 379
Motorcraft or Ford-authorized parts are used for maintenance replacements or for service of components affecting emission control, such non-Ford parts should be equivalent to genuine Ford Motor Company parts in performance and durability. 379 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 380
, which can start a fire. indicator, charging system Illumination of the service engine soon warning light or the temperature warning light, fluid leaks, strange odors, smoke or loss of engine power could indicate that the emission control system is not working properly. An improperly operating or - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 381
the engine. If the service engine indicator blinks eight times, it means that the vehicle is not soon ready for I/M testing; if the service engine soon indicator stays on solid, it means that the vehicle is ready for I/M testing. 381 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 382
engine similar. Refer to Identifying components in the engine compartment in the 6.0 and 6.4 Liter Power Stroke Direct Injection Turbo Diesel Owner Guide Supplement. Check the fluid level when it is at ambient temperature, 20°F-80°F (-7°C-25°C): 1. Check the fluid level in the reservoir. It should - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 383
operating range; there is no need to add fluid. If the fluid levels are outside of the normal operating range, the performance of your brake system could be compromised; seek service from your authorized dealer immediately. 383 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 384
20 miles [30 km]). Verify that the transmission fluid temperature gauge, located on the instrument cluster, is within normal range. 1. Drive the vehicle 20 miles (30 km) or until it reaches normal operating temperature. 384 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 385
for the location of the temperature. Low fluid transmission fluid should be in this range if at normal operating temperature (150°F-170°F [66°C-77°C]). The transmission fluid should be in this range if at ambient temperature (50°F-95°F [10°C-35°C]). 385 2010 F-250/350/450/550 (f23) Owners Guide - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 386
handle and also in the Maintenance product specifications and capacities section in this chapter. Use of a non-approved automatic transmission fluid may cause internal transmission component damage. If necessary, add fluid in 1/2 pint (250 ml) increments through the filler tube until the level - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 387
Maintenance and Specifications Checking and adding manual transmission fluid (if equipped) 1. Clean the filler only fluid that meets Ford specifications. Refer to Maintenance Product Specifications and Capacities in this chapter. 387 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 388
information for the appropriate intervals for changing the air filter element. When changing the air filter element, use only the Motorcraft air filter element listed. Refer to Motorcraft part numbers in this chapter. 388 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 389
and 6.4 Liter Power Stroke Direct Injection Turbo Diesel Owner's Guide Supplement. Note: Do not start your engine with the air cleaner removed and do not remove it while the engine is running. Changing the air filter element 1. Loosen clamp and disconnect sensor. 2. Release three retainer clamps - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 390
clamp on air tube and reconnect sensor. MOTORCRAFT PART NUMBERS Component 5.4L V8/6.8L V10 engines Air filter element FA-1883 Fuel filter FG-1083 Oil filter FL-820-S Battery (standard) BXT-65-650 Battery (optional) BXT-65-750 1 Spark plugs-platinum Remote automatic transmission filter 2, 3 1 For - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 391
axle 5.8 pints (2.8L) Capacity Ford part name Ford part number / Ford specification Spindle bearing Rear axle - F-250/350 (10.50 inch axle)1 Rear axle - F-350 (DANA M80) Rear axle - F-450/550 (Dana S110/S130) Brake fluid (and clutch fluid, if equipped) Engine coolant (5.4L V8 engine)2 2010 F-250 - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 392
and fuel coolant - diesel engine 26.7 quarts (25.3L) Capacity Ford part name Ford part number / Ford specification 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) Maintenance and Specifications Engine oil (includes filter change) - 5.4L V8 and 6.8L V10 gas engines6 Motorcraft - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 393
.4L) - - - - Capacity Ford part name Ford part number / Ford specification 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) Fuel tank - Aft axle (Chassis cab only) Hinges, latches, striker plates, fuel filler door hinge and seat tracks Lock cylinders Transmission / parking brake - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 394
to the 6.0 and 6.4 Liter Power Stroke Direct Injection Turbo Diesel Owner's Guide Supplement 17.5 quarts (16.6L)5 Manual transmission fluid (M6HDW) - diesel engine Automatic transmission fluid (5R110)3 Capacity Ford part name Ford part number / Ford specification 2010 F-250/350/450/550 (f23) Owners - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 395
Maintenance and Specifications ENGINE DATA Engine Cubic inches Required fuel Firing order Spark plug gap Ignition system Compression ratio Drivebelt routing 5.4L V8/6.8L V10 engines 5.4L V8 engine 330 87 octane 1-3-7-2-6-5-4-8 1.0-1.1mm (0.039-0.043 inch) Coil on plug 9.8:1 6.8L V10 engine 415 87 - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 396
1. World manufacturer identifier 2. Brake system / Gross Vehicle Weight Rating (GVWR) / Restraint Devices and their location 3. Make, vehicle line, series, body type 4. Engine type 5. Check digit 6. Model year 7. Assembly plant 8. Production sequence number 396 2010 F-250/350/450/550 (f23) Owners - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 397
following table tells you which transmission each code represents. Code 5 7 T B Description Six-speed manual, Dana (ZF S6-650) Six-speed manual, Dana (Z/F M6HD-W) Five-speed automatic, TorqShift (gas engines) Five-speed automatic, TorqShift (diesel engine) 397 2010 F-250/350/450/550 (f23) Owners - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 398
at: www.fordaccessories.com. Exterior style Bug shields Chrome exhaust tips Deflectors Running boards Splash guards Step bars Wheels Interior style Ambient lighting Electrochromic compass/temperature interior mirrors Floor mats 398 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 399
maximum vehicle performance, keep the following information in mind when adding accessories or equipment to your vehicle: • When adding accessories, equipment, passengers and luggage to your vehicle, do not exceed the total weight capacity of the vehicle or of the front or rear axle (GVWR or GAWR - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 400
discovered the powerful protection of Ford ESP. It is the only extended service plan backed by Ford Motor Company, and provides "peace of mind" protection beyond the New Vehicle Limited Warranty coverage. Up to 500+ Covered Vehicle Components There are four, new-vehicle Extended Service Plans with - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 401
attention for normal "wear": • Wiper blades • Brake pads and linings • Spark plugs • Shock absorbers (except California) • Clutch disc • Belts and hoses Contact your selling Ford, Lincoln, or Mercury dealership today so they can customize a Ford Extended Service Plan that fits your driving lifestyle - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 402
Ford Extended Service Plan 402 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA (fus) - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 403
...58 Auxiliary power point ...123 Axle refill capacities ...391 B Battery ...363 acid, treating emergencies ...363 jumping a disabled battery ...331 maintenance-free ...363 replacement, specifications ...390 servicing ...363 Bed extender ...145 Belt-Minder ...181 Booster seats ...212 Brakes ...269 - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 404
...365 diesel ...7 fail-safe cooling ...369 idle speed control ...363 refill capacities ...391 service points ...357-358 starting after a collision ...305 Engine oil ...360 checking and adding ...360 dipstick ...360 filter, specifications ...362, 390 recommendations ...362 2010 F-250/350/450 - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 405
shut-off switch ...305 Fuses ...306-307 G Gas cap (see Fuel cap) ...373 Gas mileage (see Fuel economy) ...376 Gauges ...20 transmission fluid temperature gauge ...24 H Hazard flashers ...304 Head restraints ...164, 170 Headlamps ...107 aiming ...109, 111 autolamp system ...107 daytime running lights - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 406
207 Lights, warning and indicator ...14 anti-lock brakes (ABS) ...270 Limited-slip axle ...273 Load limits ...244 Loading instructions ...251 Locks autolock ...149 406 childproof ...152 doors ...148 Lug nuts ...330 Lumbar support, seats ...168-169 M Manual transmission ...278 fluid capacities ...391 - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 407
notice ...8 ambulance conversions ...7 diesel-powered vehicles ...7 four-wheel drive vehicles ...302 utility-type vehicles ...7 Speed control ...131 Starting your vehicle ...264-266 jump starting ...331 Steering wheel controls ...134 407 2010 F-250/350/450/550 (f23) Owners Guide, 2nd Printing USA - 2010 Ford F350 Super Duty Regular Cab | Owner Guide 2nd Printing - Page 408
control ...271 Trailer Brake Controller-Integrated ...256 408 Transfer case fluid checking ...388 Transmission automatic operation ...275 brake-shift interlock (BSI) ...274 fluid, checking and adding (automatic) ...384 fluid, checking and adding (manual) ...387 fluid, refill capacities ...391 manual
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
-
101
-
102
-
103
-
104
-
105
-
106
-
107
-
108
-
109
-
110
-
111
-
112
-
113
-
114
-
115
-
116
-
117
-
118
-
119
-
120
-
121
-
122
-
123
-
124
-
125
-
126
-
127
-
128
-
129
-
130
-
131
-
132
-
133
-
134
-
135
-
136
-
137
-
138
-
139
-
140
-
141
-
142
-
143
-
144
-
145
-
146
-
147
-
148
-
149
-
150
-
151
-
152
-
153
-
154
-
155
-
156
-
157
-
158
-
159
-
160
-
161
-
162
-
163
-
164
-
165
-
166
-
167
-
168
-
169
-
170
-
171
-
172
-
173
-
174
-
175
-
176
-
177
-
178
-
179
-
180
-
181
-
182
-
183
-
184
-
185
-
186
-
187
-
188
-
189
-
190
-
191
-
192
-
193
-
194
-
195
-
196
-
197
-
198
-
199
-
200
-
201
-
202
-
203
-
204
-
205
-
206
-
207
-
208
-
209
-
210
-
211
-
212
-
213
-
214
-
215
-
216
-
217
-
218
-
219
-
220
-
221
-
222
-
223
-
224
-
225
-
226
-
227
-
228
-
229
-
230
-
231
-
232
-
233
-
234
-
235
-
236
-
237
-
238
-
239
-
240
-
241
-
242
-
243
-
244
-
245
-
246
-
247
-
248
-
249
-
250
-
251
-
252
-
253
-
254
-
255
-
256
-
257
-
258
-
259
-
260
-
261
-
262
-
263
-
264
-
265
-
266
-
267
-
268
-
269
-
270
-
271
-
272
-
273
-
274
-
275
-
276
-
277
-
278
-
279
-
280
-
281
-
282
-
283
-
284
-
285
-
286
-
287
-
288
-
289
-
290
-
291
-
292
-
293
-
294
-
295
-
296
-
297
-
298
-
299
-
300
-
301
-
302
-
303
-
304
-
305
-
306
-
307
-
308
-
309
-
310
-
311
-
312
-
313
-
314
-
315
-
316
-
317
-
318
-
319
-
320
-
321
-
322
-
323
-
324
-
325
-
326
-
327
-
328
-
329
-
330
-
331
-
332
-
333
-
334
-
335
-
336
-
337
-
338
-
339
-
340
-
341
-
342
-
343
-
344
-
345
-
346
-
347
-
348
-
349
-
350
-
351
-
352
-
353
-
354
-
355
-
356
-
357
-
358
-
359
-
360
-
361
-
362
-
363
-
364
-
365
-
366
-
367
-
368
-
369
-
370
-
371
-
372
-
373
-
374
-
375
-
376
-
377
-
378
-
379
-
380
-
381
-
382
-
383
-
384
-
385
-
386
-
387
-
388
-
389
-
390
-
391
-
392
-
393
-
394
-
395
-
396
-
397
-
398
-
399
-
400
-
401
-
402
-
403
-
404
-
405
-
406
-
407
-
408
 |
 |
Introduction
4
Instrument Cluster
14
Warning lights and chimes
14
Gauges
20
Message center
24
Entertainment Systems
42
AM/FM stereo
42
AM/FM stereo with CD
44
AM/FM stereo with in-dash six CD
51
Auxiliary input jack
58
USB port
60
Satellite radio information
64
Family entertainment system
67
Navigation system
97
SYNC
°
97
Climate Controls
98
Heater only
98
Manual heating and air conditioning
99
Dual automatic temperature control
102
Lights
107
Headlamps
107
Turn signal control
112
Bulb replacement
113
Driver Controls
120
Windshield wiper/washer control
120
Steering wheel adjustment
121
Power windows
124
Mirrors
126
Speed control
131
Upfitter controls
137
Moon roof
138
Table of Contents
1
2010 F-250/350/450/550
(f23)
Owners Guide, 2nd Printing
USA
(fus)