2011 Ford E150 Super Duty Passenger Owner's Manual
2011 Ford E150 Super Duty Passenger Manual
2011 Ford E150 Super Duty Passenger manual content summary:
- 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 1
information Navigation system SYNC 29 29 31 38 40 43 46 46 Climate Controls Heater only Manual heating and air conditioning 47 47 48 Lights Headlamps Turn signal control Bulb replacement 50 50 Keys Locks Anti-theft system 72 72 72 81 1 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 2
201 201 210 218 220 Roadside Emergencies Getting roadside assistance Hazard flasher control Fuel pump shut-off switch Fuses and relays Changing tires Wheel lug nut torque Jump starting Wrecker towing 225 225 226 227 229 237 246 247 253 2 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 3
263 268 Maintenance and Specifications Engine compartment Engine oil Battery Engine coolant Fuel information Air filter(s) Part numbers Maintenance product specifications and capacities Engine data 270 272 274 277 280 286 306 308 309 313 Accessories Ford Extended Service Plan Index 317 319 - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 4
particular vehicle. Furthermore, due to printing cycles it may describe options before they are generally available. Remember to pass on this Owner's Guide when reselling the vehicle. It is an integral part of the vehicle. WARNING: Fuel pump shut-off switch (Diesel and Stripped Chassis vehicles only - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 5
service or order to give the moving parts a chance to break in. Drive your new vehicle at least 1,000 miles (1,600 km) before towing a trailer. For more detailed information about towing a trailer, refer to Trailer towing in the Tires, Wheels and Loading chapter. 5 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 6
Restraints chapter. Failure to follow the specific warnings and instructions could result in personal injury. WARNING: Front seat mounted rear-facing child or infant seats should NEVER be placed in front of an active passenger airbag. Notice to owners of diesel-powered vehicles Read the 6.0 and - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 7
diagnostic information may also be accessed electronically by Ford Motor Company and Ford authorized service facilities, and that the diagnostic information may be used for any purpose. See your SYNC supplement for more information. 7 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 8
pursuant to court order or where required by law enforcement, other government authorities or other third parties acting with lawful authority. Other parties may seek to access the information independently of Ford Motor Company and Ford of Canada. 8 2010 Econoline (eco) Owners Guide, 3rd Printing - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 9
and the vendors it uses to provide you with this information do not store your vehicle travel information. For more information, see Traffic, Directions and Information, Terms and Conditions. See your SYNC supplement for more information. 9 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 10
device or feature that may take your focus off the road. Your primary responsibility is the safe operation of your vehicle. We recommend against the use of any handheld device while driving and that you comply with all applicable laws. 10 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 11
EXPORT UNIQUE (NON-UNITED STATES/CANADA) VEHICLE SPECIFIC INFORMATION For your particular global region, your vehicle may be equipped with features and options that are different from the features and options that are described in this Owner's Guide. A market unique supplement may be supplied that - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 12
Non-Petroleum Based Stability Control System Speed Control Master Lighting Switch Hazard Warning Flasher Fog Lamps-Front Fuse Compartment Fuel Pump Reset Windshield Defrost/Demist Windshield Wash/Wipe Rear Window Defrost/Demist 12 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 13
Flames, or Sparks Explosive Gas Battery Acid Fan Warning Maintain Correct Fluid Level Engine Air Filter Jack MAX MIN Power Steering Fluid Service Engine Soon Passenger Compartment Air Filter Check Fuel Cap Low Tire Pressure Warning 13 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 14
engine soon: The service engine soon indicator light illuminates when the ignition is first turned to the on position to check the bulb and to indicate whether the vehicle is ready for Inspection/Maintenance (I/M) testing. Normally, the Service engine soon 14 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 15
cap may not be properly installed. Continued driving with this light on may cause the Service Engine Soon warning light to come on, refer to Fuel filler cap in the Maintenance and Specification chapter. Brake system warning light: To ! P confirm the brake system warning light is functional, it will - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 16
and Specifications chapter. Engine coolant temperature (RTT): Displays when the engine coolant temperature is high. Stop the vehicle as soon as possible, switch off the engine and let cool. Refer to Engine coolant in the Maintenance and Specifications chapter. 16 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 17
cap while the engine is running or hot Tow/Haul feature has been activated. Refer to the Driving chapter for transmission function and operation. If the light flashes steadily, have the system serviced immediately, damage to the transmission could occur. 17 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 18
ignition in the off or accessory position and the driver's door is opened. Headlamps on warning chime: Sounds when the headlamps or parking lamps are on, the ignition is off (the key is not in the ignition) and the driver's door is opened. 18 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 19
. At normal operating temperature, the needle will be in the normal range (between "H" and "C"). If it enters the red section, the engine is overheating. Stop the vehicle as soon as safely possible, switch off the engine and let the engine cool. 19 2010 Econoline (eco) Owners Guide, 3rd Printing - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 20
normal operating range (between "L" and "H"). If the needle falls below the normal range, stop the vehicle, turn off the engine and check the engine oil level. Add oil if needed. If the oil level is correct, have your vehicle checked by your authorized dealer. 20 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 21
fuel economy, which is based on your recent driving history of 500 miles (800 km). This value is not the same as the average fuel economy display. The running average fuel economy is re-initialized to a factory default value if the battery is disconnected. 21 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 22
= NEW This displays the remaining oil life. An oil change is required whenever indicated by the message center and according to the recommended maintenance schedule. USE ONLY RECOMMENDED ENGINE OILS. 22 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 23
/RESET stem to change the Oil Life Start Value. Each release and press will reduce the value by 10%. Note: Oil life start value of 100% equals 7,500 miles (12,000 near the rear bumper, and functions only when R (Reverse) gear is selected. 23 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 24
will correct itself after a few days of operating your vehicle in normal conditions. If the compass still appears to be inaccurate, a manual calibration may be necessary. Refer to Compass seconds to enter the compass zone adjustment mode. 24 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 25
objects or structures. Switch off all non-essential electrical accessories (heated rear window, heater, A/C, map lamps, wiper the vehicle, the message center reverts back to normal operation and the CAL will display until a successful calibration Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 26
center is as follows: 1. XXX% OIL LIFE (Gas engine only) 2. ENGINE HOURS 3. CHARGING SYSTEM 4. BRAKE SYSTEM 5. TBC GAIN = FUEL LEVEL XXX System warnings System warnings alert you to possible problems or malfunctions in your vehicle's operating Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 27
be inspected immediately. Refer to Brake fluid in the Maintenance and Specifications chapter. CHECK REAR PARK AID (if equipped) - Displayed when the transmission is in R (Reverse). Refer to Reverse sensing system in the Driving chapter. 27 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 28
between 5% and 0%, the ENGINE OIL CHANGE SOON message will be displayed. OIL CHANGE REQUIRED - Displayed when the oil life left reaches 0%, the OIL CHANGE REQUIRED message will be displayed. OIL LIFE OK displays after you have changed the oil. 28 2010 Econoline (eco) Owners Guide, 3rd Printing USA - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 29
been turned off or until either front door is opened. / : Press / to 1. manually go up or down the radio frequency. Press and hold for a fast advance through radio frequencies. Also use in AUDIO mode to gain access to various settings. 29 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 30
the fade feature. Use the audio between the front (F) and back (B) speakers. TREB (Treble): Press to adjust the treble setting. Use SEEK to adjust. BASS (Bass): Press to adjust the bass setting. Use SEEK to adjust and the clock setting. 30 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 31
all applicable laws. Accessory delay: Your vehicle is equipped with accessory delay. With this feature, the radio and other electrical devices may be used for up to ten minutes after the ignition is turned off or until either front door is opened. 31 2010 Econoline (eco) Owners Guide, 3rd Printing - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 32
the clock: Press MENU until SET HOURS or SET MINUTES is / to manually increase/decrease. Press MENU again displayed. Use to disengage clock mode. SATELLITE RADIO MENU (if equipped): Press MENU when channel, the system will alert you with 32 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 33
manually set preset stations for AM/FM1/FM2. Use turn on/off. When the six strongest stations are filled, the station stored in preset 1 will begin playing. If there are less than six strong stations, the system will store the last one in the remaining presets. 33 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 34
. Use you will not be able to search for RBDS equipped stations or view the station name or type. To search for specific RBDS audio between the to reach the fade setting. Use back (B) and front (F) speakers. SPEED VOL (Speed sensitive volume, Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 35
/ to MENU until COMPRESS ON/OFF appears in the display. Use toggle ON/OFF. When COMPRESS is ON, the system will bring (if equipped), press seek to the previous/next channel. If a specific category is selected, SEEK, SEEK to seek to the (Jazz, Rock Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 36
/Pause): This control is operational in CD/MP3 mode. the radio display. OK: Use in various menu selections. 7. disc will shuffle in random order. In MP3 folder mode, to manually advance in a CD/MP3 track. 11. REW (Rewind): Press REW to manually Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 37
the system, CD/MP3 play will begin where it ended last. If no CD is loaded, NO DISC will appear in the display. 37 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 38
the following instructions when attaching your portable music device to the audio system. If your vehicle is equipped with a navigation system, refer to Auxiliary input jack section in the Audio features chapter of your Navigation system supplement. 38 2010 Econoline (eco) Owners Guide, 3rd - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 39
and FM or CD controls. Troubleshooting: 1. Do not connect the audio player volume down. If the problems persist, replace or recharge the used with headphones as the AIJ does not provide control (play, pause, etc.) over the attached portable music player. 39 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 40
responsibility is the safe operation of the vehicle. We recommend against the use of any handheld support this feature. For further information on this feature, refer to Accessing and using your USB port in the SYNC supplement or Navigation system supplement. 40 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 41
an approved CD cleaner. • Wipe discs from the center out. Don't: • Expose discs to direct sunlight or heat sources for extended periods of time. • Clean using a circular motion. 41 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 42
compact discs may not function correctly when used in Ford CD players. Do not use any irregular shaped CDs or discs with warranty and service Refer to the Warranty Guide/Customer Information Guide for audio system warranty information. If service Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 43
7 .doc .ppt .xls In track mode, the system will display and play the structure as if it were only one level deep (all .mp3 files will be played, regardless of being in a specific folder). In folder mode, call SIRIUS at 1-888-539-7474. 43 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 44
service fee is required in order to receive SIRIUS service. Vehicles that are equipped with a factory installed SIRIUS satellite radio system include hardware and a limited subscription term, which begins on the date of sale . 44 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 45
an ignition key cycle, your receiver may have a fault. See your authorized dealer for service. Channel no longer This previously available. available channel is no longer available. Tune to another INVALID CHNL UNSUBSCRIBED NO TEXT 45 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 46
No action required. The programming in process may take up to progress. three minutes. Satellite service has Call SIRIUS at 1-888-539-7474 to been deactivated by re-activate or resolve information, please refer to the SYNC supplement. 46 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 47
. : Distributes outside air through the windshield defroster vents. Operating tips • To reduce fog build-up on the windshield in the OFF position. • Do not put objects under the front seats that will interfere with the air flow to the back seats Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 48
Climate Controls MANUAL HEATING AND AIR CONDITIONING SYSTEM (IF equipped). See the following for a brief description on each control. MAX A/C: Uses recirculated air to cool the vehicle. Air flows from the instrument panel vents vents. 48 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 49
HI. REAR FAN SPEED ADJUSTMENT (IF EQUIPPED) The rear fan controls adjust the volume of air circulated in the rear of the vehicle. 49 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 50
conditions may result in a collision. High beams Push the lever toward the instrument panel to activate. Pull the lever toward you to deactivate. 50 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 51
of the universal adaptor all to the same setting, such that the cross-car sight line is no longer blocked, per the instructions for the brand of mechanical aimer used. You can also aim the headlamps visually using the procedure below. 51 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 52
line marked in step 2, a pair of vertical lines (5) must be marked at the center line of the headlamps on the wall or screen. 52 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 53
vehicle does not require horizontal aim adjustments. To adjust the headlamps: 1. Park the vehicle directly in front of a wall or screen on a level surface, approximately 25 feet (7.6 meters) away. • (1) as the horizontal reference line. 53 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 54
Lights 5. Locate the vertical adjuster on the back of each headlamp, then use a long Phillips #2 screwdriver to turn the adjuster either counterclockwise (to adjust down) or when you open the doors or fully rotate the headlamp control. 54 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 55
during normal operation. Clearing time may take as long as 48 hours under dry weather conditions. Examples of acceptable condensation are: • Presence of thin mist (no streaks, drip marks or droplets) • Fine mist covers less than 50% of the lens 55 2010 Econoline (eco) Owners Guide, 3rd Printing - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 56
3157K lamp High-mount brakelamp 2 912 Cargo lamp 1 211-2 Dome lamp (standard) 1 912 Map/reading lamp 2 211-2 All replacement bulbs are clear in color except where noted. To replace all instrument panel lights - see your authorized dealer 56 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 57
plastic base and do not touch the glass. The oil from your hand could cause the bulb to break the next time the headlamps are operated. Note: If the bulb is accidentally touched, it should be cleaned with alcohol before being used. 57 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 58
removal procedures in reverse order. Replacing front parking lamp/turn signal bulbs 1. Make sure the headlamp control is in the off position. 2. Remove the headlamp assembly. Refer to Replacing headlamp bulbs in this section. Aerodynamic 58 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 59
order. Replacing side marker bulbs 1. Make sure the headlamp control is in the off position. 2. Remove the headlamp assembly. Refer to Replacing headlamp bulbs in this section. Aerodynamic Sealed beam 3. Rotate the bulb socket counterclockwise and remove. 59 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 60
, follow the removal procedures in reverse order. Replacing high-mount brakelamp bulbs On vehicles without a rear headliner, the interior cargo lamp (if equipped) must be removed new bulb, follow the removal procedures in reverse order. 60 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 61
. 3. Carefully pull the bulb straight out of the socket and push in the new bulb. To install the lamp, follow the removal procedures in reverse order. 61 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 62
blades and cause the wiper motor to burn out. Before operating the wiper on a dry windshield, always use the windshield washer. In freezing weather, be sure the wiper blades are not frozen to the windshield before operating the wipers. 62 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 63
type of accessory or accessory bracket from the plug. Improper use of the power outlet can cause damage not covered by your warranty. Auxiliary power ) Do not use the power point for operating the cigarette lighter element (if equipped). 63 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 64
capacity usage of your power point, the engine is required to be running to avoid unintentional discharge of the battery. To prevent the battery from being discharged: • do not use the power point longer than necessary when the engine . 64 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 65
the sensors on the front and back of the interior rear view mirror since this may impair proper mirror performance. Do not clean the housing or glass of any mirror with harsh abrasives, fuel or other petroleum-based cleaning products. 65 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 66
if equipped) The spotter mirror only can be tilted from top to bottom. Move the lower mirror manually up/down to increase side and rear visibility. Apply pressure only in the center of the spotter as this may lead to a mirror fracture. 66 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 67
The mirrors can be manually folded forward or backwards for narrow spaces tow mirror. The telescoping feature (if equipped) allows the mirror to extend approximately 3.15 inches (80 mm). This feature is especially useful to the driver when towing a trailer. 67 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 68
foot on the accelerator pedal. WARNING: Do not use the speed control in heavy traffic or on roads that are winding, slippery or unpaved. Using speed control The speed controls are located on the the vehicle to the previously set speed. 68 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 69
Press and hold COAST until you get to the desired speed, then release. You can also use COAST to operate the tap-down function. Press and release COAST to decrease the vehicle set speed in 1 mph SYNC system, refer to the SYNC supplement. 69 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 70
Relays in the Roadside Emergencies chapter. See your authorized dealer for service. There will also be one power lead for each switch found as a blunt-cut and sealed wire located in the underhood cowl shield above the engine block PCM. 70 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 71
CAC07 Violet with Green Trace CAC08 Brown Fuse 30A 30A 10A 15A More detailed information about Upfitter switches can be found at https://www.fleet.ford.com/truckbbas/. 71 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 72
any gear putting the vehicle in motion, and • the vehicle attains a speed greater than 12 mph (20 km/h) for greater than two seconds. 72 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 73
this feature: • Through your authorized dealer, or • by using a power door unlock/lock procedure, or • by using the instrument cluster message center (if equipped). Refer to Message center chirp once to confirm the procedure is complete. 73 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 74
off or to accessory; and • the driver door is opened within 10 minutes of the ignition being turned off or to accessory. Note: The dealer, or • by using a power door unlock/lock sequence, or • by using the instrument cluster message center Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 75
door trim panel. The front doors are locked and the cargo doors are double-locked. • Unlock the vehicle with the key fob or use the power door lock on the front door. The front doors are unlocked and the cargo doors remain double-locked. 75 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 76
doors from outside vehicle is with the key. For vehicles equipped with manual door locks: • The front door locks can be locked by using either the key or the manual door lock. • In order to activate the E-Guard Cargo Protection System™, use the key or the manual door lock to lock the side and back - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 77
entry transmitter is approximately 33 feet (10 meters). A decrease in operating range could be caused by: • weather conditions, • nearby radio towers, • structures around the vehicle, or • other vehicles parked next to your vehicle. 77 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 78
order to aid in troubleshooting the problem. Note: If the vehicle is equipped with the E-Guard Cargo Protection System™ the remote transmitter Unlock command will only unlock the front the 2. Press passenger doors and the rear cargo doors. The Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 79
accessory or on position to deactivate the alarm. Note: The panic alarm will only operate when the ignition is in the off position. Replacing the battery The remote entry transmitter uses THE FRONT HOUSING OF THE REMOTE ENTRY TRANSMITTER. 79 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 80
are not present during programming procedure, the ones missing during programming will no longer operate the vehicle. Note: Ensure the brake pedal is not 4 depressed during this sequence and 1 turn from the 2 (lock) position to 3 (off). 80 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 81
or accessory to operate. The engine immobilization system. This system is designed to help prevent the engine from being started unless a coded key programmed to your vehicle is used. The use of the wrong type of coded key may lead to a "no-start" condition. 81 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 82
will not flash. • When the ignition is in the on position, the indicator will glow for three seconds to indicate the engine is enabled. Automatic arming The vehicle is armed immediately after switching the ignition to the off position. 82 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 83
need to have your vehicle towed to an authorized dealer. The coded keys can be very costly. Store an extra programmed key use SecuriLock keys. • You must have two previously programmed coded keys (keys that already operate your vehicle's engine Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 84
then go out. If the key was not successfully programmed, it will not start your vehicle's engine and the theft indicator light will flash on and off rapidly. If failure repeats, bring your procedure from Step 1 for each additional key. 84 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 85
. WARNING: Do not pile cargo higher than the seatbacks to front row outboard non-adjustable head restraints. WARNING: To minimize the risk of neck injury in the event of a crash, the driver and passenger occupants should not sit in and/or operate Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 86
that cargo or any objects are not trapped behind the seatback. After returning the seatback to its original position, pull on the seatback to ensure that it has fully latched. An unlatched seat may become dangerous in the event of a sudden stop or collision. 86 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 87
softness. Adjusting the front power seat (if equipped) The control is located on the outboard side of the seat cushion. Press to raise or lower the front portion of the seat cushion. Press to raise or lower the rear portion of the seat cushion. 87 2010 Econoline (eco) Owners Guide, 3rd Printing - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 88
Seating and Safety Restraints Press the control to move the seat forward, backward, up or down. REAR SEATS Rear captains chair adjust - passenger side only Pull the lever to adjust the seat forward or backward. 88 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 89
Seating and Safety Restraints Quick-release captains chair (7 passenger configuration- second row only) To remove the seat: 1. Disengage the lap/shoulder belt from the seat. If not latched, the seat may cause injury during a sudden stop. 89 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 90
the lap/shoulder belt from the seat by inserting a key or small screwdriver into the slot in the detachable anchor and lifting upward (2nd row passenger side only). 90 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 91
belt to the stationary portion of the shoulder belt coming out of the trim panel. The end of the shoulder belt must be clipped in order to keep it from striking anything during vehicle operation. 91 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 92
from the striker pins with adequate ergonomic assistance. Due to the weight of the seat, it must be handled by at least two front hooks to the LH/RH front striker pins prior to lowering the rear latch mechanism and aligning them with the rear striker pins. 92 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 93
any cargo to the passenger cannot protect the child from injury in a collision. WARNING: All occupants of the vehicle, including the driver, should always properly wear their safety belts, even when an airbag supplemental restraint system (SRS) is provided. 93 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 94
ride in a cargo area, inside or specific safety belt assembly which is made up of one buckle and one tongue that are designed to be used as a pair. 1) Use a child anywhere near them. WARNING: Front and rear seat occupants, including pregnant women Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 95
from the buckle. • Front and rear seats All safety restraints in the vehicle are combination lap and shoulder belts. All of the passenger combination lap and shoulder belts help reduce forward movement of the driver and passengers. 95 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 96
on the driver safety belt. This mode should be used any time a child safety seat, except a booster, is installed in passenger front or rear seating position (if equipped). Children 12 years vehicle sensitive (emergency) locking mode. 96 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 97
feature or any other safety belt function is not operating properly when checked by an authorized dealer. Failure the start of the crash. WARNING: The driver and front passenger safety belt system (including retractors, buckles and height adjusters Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 98
and a chime sounds to remind the occupants to fasten their safety belts. Conditions of operation If...The driver's safety belt is not buckled before the ignition switch is turned to the light and the warning chime will remain off. 98 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 99
safety belt upper anchorage and seatback which should be as upright as possible; this can improve comfort. 99 "I'm not going far" "Belts are uncomfortable" 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 100
accident. Belt-Minder reminds us to take a few seconds to buckle up. Safety belts, when used properly, reduce risk of death to front seat occupants by 45% in cars, and by 60% in light trucks. Nearly 1 of for that ignition cycle only. 100 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 101
Belt-Minder system activated for yourself and others who may use the vehicle. To reduce the risk of injury, do the ignition switch to the ON position. DO NOT START THE ENGINE. 2. Wait until the safety belt warning light turns off (Approximately Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 102
too short for you when fully extended. Use the shortest extender assembly that will provide adequate fit. WARNING: Do not use extensions to change the fit of the shoulder belt across the torso. AIRBAG SUPPLEMENTAL RESTRAINT SYSTEM (SRS) 102 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 103
the safety belt to help protect the driver and right front passenger from certain upper body injuries. Airbags DO NOT inflate forward-facing child in the front seat, move the seat all the way back and use appropriate restraints. WARNING: National Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 104
a collision. WARNING: Airbags can kill or injure a child in a child seat. NEVER place a rear-facing child seat in front of an active airbag. If you must use a forward-facing child seat in the front seat, move the seat all the way back. 104 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 105
restrained as far away from the airbag module as possible while maintaining vehicle control. The SRS consists of: • driver and passenger airbag modules (which include the inflators and airbags) • one or more impact and safing sensors 105 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 106
if the system is operational The SRS uses a readiness light in repeat periodically until the problem and/or light are as possible. Unless serviced, the system may not front, side, side curtain or Safety Canopy ) or the safety belt pretensioners. 106 2010 Econoline (eco) Owners Guide, - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 107
the face of the switch to be sure the switch is in the proper position in accordance with these instructions and warnings. Failure to put the switch in a proper position can increase the risk of serious injury or death in a collision. 107 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 108
dealer as soon as possible. WARNING: In order to avoid inadvertent activation of the switch, always remove the ignition key from the passenger air bag ON/OFF switch. WARNING: An . This indicates that the passenger airbag is operational. 108 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 109
passenger airbag switch is in the ON position and the ignition switch is in ON, have the passenger airbag switch serviced at an authorized dealer immediately. The passenger and right front passenger seating positions have been specifically designed Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 110
warning labels in the vehicle as well as the other important airbag instructions and warnings in this Owner's Guide. NHTSA deactivation criteria (excluding Canada) 1. Infant. An infant (less than 1 year old) must ride in the front seat because: • the vehicle has no rear seat; • the vehicle has - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 111
risk for the passenger if the airbag deploys; and • makes the potential harm from the passenger airbag deployment greater than the potential harm from turning OFF the airbag and experiencing a crash without the protection offered by the airbag 111 2010 Econoline (eco) Owners Guide, 3rd Printing USA - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 112
front passenger. These particular belts are specifically weight. Child safety restraints must be purchased separately from the vehicle. Failure to follow these instructions and guidelines may result in an increased risk of serious injury or death to your child. 112 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 113
and weight thresholds from NHTSA and other safety organizations or are the minimum requirements of law. Ford recommends checking with a NHTSA Certified Child Passenger Safety Technician recommended by your child restraint manufacturer) 113 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 114
for Children Recommended Child size, height, weight, or age restraint type Larger Children who have outgrown or no Use a vehicle children longer properly fit in restrained in the rear seating positions than in a front seating position. 114 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 115
the instructions and warnings provided by the vehicle manufacturer. A safety seat that is improperly installed or utilized, is inappropriate for your child's height, age, or weight or does not properly fit the child may increase the risk of serious injury or death. 115 2010 Econoline (eco) Owners - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 116
back because it reduces the protection for the upper part of the body and may increase the risk of weight. All children are shaped differently. The child height, age and weight Ford recommends checking with a NHTSA Certified Child Passenger Safety Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 117
lap and shoulder belts Check to make sure the child seat is properly secured before each use. Children 12 and under should be properly restrained in a rear seating position whenever possible. If all children cannot be seated and 117 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 118
, properly restrain the largest child in the front seat. When installing a child safety seat with combination lap/shoulder belts: • Use the correct safety belt buckle for that seating in a seat with a combination lap and shoulder belt. 118 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 119
portions together, route the tongue through the child seat according to the child seat manufacturer's instructions. Be sure the belt webbing is not twisted. 4. Insert the belt tongue into the is latched securely by pulling on it. 119 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 120
the additional weight of the child is added to the child restraint. It also helps to achieve the proper snugness of the child seat to the vehicle. Sometimes, a slight lean towards the buckle will additionally help to remove remaining slack from the belt. 120 2010 Econoline (eco) Owners Guide, 3rd - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 121
Motor Company recommends the use of a child safety seat having a top tether strap. See Attaching child safety seats with tether straps and Recommendations for attaching safety restraints for children in this chapter for more information. 121 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 122
Seating and Safety Restraints Your vehicle has LATCH lower anchors for child seat installation at the following locations: • Five passenger crew van • Seven passenger wagon • Eight passenger wagon • Eleven passenger wagon 122 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 123
passenger wagon • Fifteen passenger wagon The LATCH lower anchors are located at the rear section of the rear seat between the cushion and seatback. Follow the child seat manufacturer's instructions death. Each time you use the safety seat, check Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 124
passenger and 15 passenger configuration is not equipped with LATCH anchors and is spaced closer to the row of seats in front, Do not use forward using either the safety belt, the lower anchors of the LATCH system, or both, you can attach the top tether strap. 124 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 125
the following steps to install a child safety seat with tether anchors: Front passenger seating position The tether can be attached directly to the rear of the front seat. 1. Adjust the front right-hand passenger seat full forward. 125 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 126
back of the front right-hand passenger seat as shown. 3. Clip the tether strap hook to the seat pedestal at the location shown. If the tether strap is clipped incorrectly, the child safety seat may not be retained properly in the event of a collision. 126 2010 Econoline (eco) Owners Guide, 3rd - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 127
Restraints 4. Adjust the front right hand passenger seat to the full rearward position. 5. Tighten the child safety seat tether strap according to the manufacturer's instructions. If the safety seat right hand second row bucket seat. 127 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 128
, use of child seats is not recommended for these seating position locations. 1. For any three-passenger bench seat, place the child safety seat on the left hand outboard position, the center position, or the right hand outboard position as desired. * * 128 2010 Econoline (eco) Owners Guide, 3rd - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 129
) is used to improve the fit of the vehicle safety belt. Children outgrow a typical child seat (e.g., convertible or toddler seat) when they weigh about 40 lb (18 kg) and are around four (4) years of age. Consult your child safety seat owner guide for the weight, height, and age limits specific to - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 130
seating position, may help provide a good shoulder belt fit. When children should use booster seats Children need to use booster seats from the time they outgrow the toddler seat until they are big seated like this for the whole trip? 130 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 131
belts, or consider using a high back booster seat. • High back booster seats If, with a backless booster seat, you cannot find a seating position that adequately supports your child's head, a high back booster seat would be a better choice. 131 2010 Econoline (eco) Owners Guide, 3rd Printing USA - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 132
seat manufacturer's instructions. The importance of shoulder belts Using a booster use a booster seat with lap/shoulder belts in the back seat. Move a child to a different seating location if the shoulder belt does not stay positioned on the shoulder during use. 132 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 133
belt guide on seatback (if equipped), child safety seat LATCH and tether anchors, and attaching hardware, should be inspected after a collision. Refer to the child restraint manufacturer's instructions for additional inspection and maintenance information specific to the child restraint. Ford Motor - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 134
use appropriate restraints to minimize the risk of injury or ejection. Study your owner's guide and any supplements for specific information about equipment features, instructions for safe driving and additional precautions to reduce the risk of an accident or serious injury. 134 2010 Econoline - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 135
may be: • Higher - to allow higher load carrying capacity and to allow it to travel over rough terrain without maneuverability in tight spaces, particularly in off-road use. As a result of the above dimensional differences passenger car. 135 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 136
pneumatic passenger car tires. They do not apply to deep tread, winter-type snow tires, space-saver or temporary use spare tires their use, however, and may depart significantly from the norm due to variations in driving habits, service practices Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 137
grade C corresponds to a level of performance which all passenger car tires must meet under the Federal Motor Vehicle Safety to give many thousands of miles of service, but they must be maintained in order to get the maximum benefit from them. Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 138
the vehicle. • Rim: The metal support (wheel) for a tire or a tire and tube assembly upon which the tire beads are seated. INFLATING YOUR TIRES Safe operation of your vehicle requires that your tires pressure and not appear to be flat! 138 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 139
if it is less than the maximum inflation pressure information found on the tire. The Ford recommended tire inflation pressure is found on the Safety Compliance Certification Label or Tire Label air pressure inside to go up as you drive. 139 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 140
for each tire, including the spare. Note: Some spare tires operate at a higher inflation pressure than the other tires. For description): Store and maintain at the higher of the front and rear inflation pressure as shown on the Safety Compliance Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 141
the trajectory area. WARNING: An inflated tire and rim can be very dangerous if improperly used, serviced or maintained. To reduce the risk of serious injury, never attempt to re-inflate a tire to protect persons and property. 141 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 142
in case it needs to be repaired or replaced. For your safety, tires that are damaged or show signs of excessive wear should not be used because they are more likely to blow out or fail. 142 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 143
tire inspected by a tire professional. Tires can be damaged during off-road use, so inspection after off-road use is also recommended. WARNING: Age Tires degrade over time depending on many due to aging even if it has not been used. 143 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 144
. Additionally the use of non-recommended tires and wheels could cause steering, suspension, axle or transfer case/power transfer unit failure. If you have questions regarding tire replacement, contact your authorized dealer as soon as possible. 144 2010 Econoline (eco) Owners Guide, 3rd Printing - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 145
the TPMS may be damaged (if equipped). Safety practices Driving habits have a great deal to do with your tire mileage and safety. • Observe posted speed limits • Avoid fast starts, stops and turns • Avoid potholes and objects on the road 145 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 146
The tires may fail and injure a passenger or bystander. Highway hazards No matter how cannot detect a cause, have the vehicle towed to the nearest repair facility or tire dealer curb or pothole can cause the front end of your vehicle to become Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 147
mechanical problem involved before used in a tire rotation. Note: After having your tires rotated, inflation pressure must be checked and adjusted to the vehicle requirements. WARNING: If the tire label shows different tire pressures for the front Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 148
rear wheels it is recommended that the front and rear tires (in pairs) be wheel misalignment, tire imbalance or mechanical problem involved before tire rotation. Note: it is intended for temporary use only and should not be used in a tire rotation. Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 149
may operate at different conditions for load and inflation pressure. These speed ratings may need to be adjusted for the difference in conditions. The ratings range from 81 mph (130 km/h) to 186 mph (299 km/h). These ratings are listed in the following chart. 149 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 150
and Snow, or AT: All Terrain, or AS: All Season. 10. Tire Ply Composition and Material Used: Indicates the number of plies or the number of layers of rubber-coated fabric in the tire tread for the correct tire pressure for your vehicle. 150 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 151
tire when tested under controlled conditions on a specified government test course. For example, a tire graded 150 would wear one and one-half (11⁄2) times as well on the government course as a tire standard load, radial tubeless, etc. 151 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 152
tire, designated by the Tire and Rim Association (T&RA), that is intended for service on light trucks. 2. Load Range/Load Inflation Limits: Indicates the tire's tire is used as a single; defined as two tires (total) on the rear axle. 152 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 153
a type of tire, designated by the Tire and Rim Association (T&RA), that is intended for temporary service on cars, SUVs, minivans and light trucks. 2. 145: Indicates the nominal width of the tire in - with and without a trailer section. 153 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 154
and can lead to tire failure. Under-inflation also reduces fuel efficiency and tire tread life, and may affect the vehicle malfunction indicator to indicate when the system is not operating properly. The TPMS malfunction indicator is combined with Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 155
operation. WARNING: The tire pressure monitoring system is NOT a substitute for manually checking tire pressure. The tire pressure should be checked periodically (at least monthly) using - the pressure sensor is banded to the wheel. 155 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 156
is recommended that you always have your tires serviced by an authorized dealer. The tire pressure should be checked periodically (at least monthly) using an accurate tire gauge, refer to Inflating all the way down to the seal. 1 156 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 157
the damaged road wheel/tire repaired and remounted on your vehicle. For additional information, refer to Changing tires with TPMS in this section. 157 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 158
your system is not operating properly The main front and rear tire pressures, the TPMS system must be retrained following every tire rotation. Refer to Tire rotation in this chapter. Spare tire in use TPMS malfunction Tire rotation without sensor training 158 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 159
and your spare tire is not in use and the TPMS warning light still driving in a normal manner, a typical passenger tire inflation pressure may increase approximately 2 in ambient temperature. This lower pressure value may be detected by the TPMS as Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 160
are rotated to determine which set of tires are on the front and which are on the rear. With this information, the system performed at least 3 feet (1 meter) away from another Ford Motor Company vehicle undergoing the TPMS reset procedure at the Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 161
the key in the ignition. 3. Cycle the ignition to the on position with the engine off. 4. Turn the hazard flashers on then off three times. This must be display TRAIN LEFT FRONT TIRE, seek service from your authorized dealer. 161 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 162
using the following TPMS reset sequence starting with the left front tire in the following clockwise order: • Left front (Driver's side front tire) • Right front (Passenger's side front tire) • Right rear (Passenger for more information. 162 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 163
after tire rotation is provided with vehicles that have different front and rear tire pressures. The tool is located with your Owner's Guide materials. Please take the tool with the provided Velcro strip and release the brake pedal. 163 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 164
start the engine. If the FRONT TIRE. If after repeated attempts to enter the reset mode, the horn does not sound, the TPMS indicator does not flash and the message center does not display TRAIN LEFT FRONT TIRE, contact your authorized dealer as soon as possible. 164 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 165
using the following TPMS reset sequence starting with the left front tire in the following clockwise order: 1. Left front tire (Front driver's side) 2. Right front tire (Front passenger's side) 3. Right rear tire (Rear passenger possible. 165 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 166
this does not work, remove the chains to prevent damage to your vehicle. • Remove the tire chains when they are no longer needed. Do not use tire chains on dry roads. 166 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 167
full tank of fuel and all standard equipment. It does not include passengers, cargo, or optional equipment. Vehicle Curb Weight - is the weight of your new vehicle when you picked it up from your authorized dealer plus any aftermarket equipment. 167 2010 Econoline (eco) Owners Guide, 3rd Printing - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 168
weight the vehicle should carry). Once you have reached the maximum payload of your vehicle, do not add more cargo, even if there is space available. Overloading or improperly loading your vehicle can contribute to loss of vehicle control and vehicle rollover. 168 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 169
Weight, including cargo and optional equipment. When towing, trailer tongue load or king pin weight is also part of cargo weight. GAW (Gross Axle Weight) - is the total weight placed on each axle (front and rear) - including vehicle curb weight and all payload. 169 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 170
allowable weight of the fully loaded vehicle (including all options, equipment, passengers and cargo). The GVWR is shown on the Safety Compliance Certification Label located on the B-Pillar or the edge of the driver's door. The GVW must never exceed the GVWR. 170 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 171
Compliance Certification Label vehicle weight rating limits could result in substandard vehicle handling or performance, engine, transmission and/or structural damage, serious damage to the vehicle, loss of control and personal injury. 171 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 172
maximum allowable weight of the vehicle and the loaded trailer - including all cargo and passengers - that the vehicle can handle without risking damage. (Important: The towing vehicle's braking system is rated for operation at GVWR, not at GCWR.) Separate functional brakes should be used for safe - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 173
1,400 lb. and there will be five 150 lb. passengers in your vehicle, the amount of available cargo and luggage load capacity is 650 lb. (1400-750 (5 x 150) = 650 lb.). In metric units (635-340 (5 x 68) = 295 kg.) 5. Determine the combined weight of luggage and cargo being loaded on the vehicle. That - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 174
to the maximum trailer weight listed for your engine and rear axle ratio on the following charts. Your vehicle's load capacity is designated by weight, not by volume, so you cannot necessarily use all available space when loading a vehicle. 174 2010 Econoline (eco) Owners Guide, 3rd Printing USA - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 175
Rear Maximum Loaded frontal area of Engine axle GCWR - lb Trailer Weight trailer - ft2 ratio (kg) (m2) - lb (kg) E-150 Regular/RV Van (8520 GVWR) 11500 4.6L 3.73 6000 (2722) 60 (5.52) (5216) 12000 4.6L 4.10 6500 (2948) 60 (5.52) (5443) E-150 Regular Wagon (7/8 Passenger) (8520 GVWR) 11500 4.6L 3.73 - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 176
E-150 Regular Wagon (7/8 Passenger) (8600 GVWR) 13000 7000 (3175) 60 (5.52) 5.4L 3.73 (5897) 13000 5.4L 4.10 7000 (3175) 60 (5.52) (5897) E-250 Regular/RV Van (8900 GVWR) 11500 6000 (2722) 60 (5.52) 4.6L 3.73 (5216) 12000 6500 (2948) 60 (5.52) 4.6L 4.10 (5443) 176 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 177
52) 5.4L 4.10 (5896) E-350 Regular/RV Van (9500 GVWR) 13000 5.4L 3.73 7300 (3311) 60 (5.52) (5897) 13000 7300 (3311) 60 (5.52) 5.4L 4.10 (5897) 15000 6.8L 3.73 9100 (4128) 60 (5.52) (6804) 18500 6.8L 4.10 10000 (4536) 60 (5.52) (8391) 177 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 178
GVWR) 13000 5.4L 3.73 6500 (2948) 60 (5.52) (5897) 13000 5.4L 4.10 6500 (2948) 60 (5.52) (5897) E-350 Extended Wagon (11 Passenger) (9500 GVWR) 15000 6.8L 3.73 8300 (3765 ) 60 (5.52) (6804) 18500 6.8L 4.10 10000 (4536) 60 (5.52) (8391) 178 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 179
Weight Rating)/Trailer Weights Maximum Maximum Rear Maximum Loaded frontal area of Engine axle GCWR - lb Trailer Weight trailer - ft2 ratio (kg) (m2) - lb (kg) E-350 Extended Wagon (14/15 Passenger 6.8L 4.10 10000 (4536) 60 (5.52) (8391) 179 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 180
, Wheels and Loading GCWR (Gross Combined Weight Rating)/Trailer Weights Maximum Maximum Rear Maximum Loaded frontal area of Engine axle GCWR - lb Trailer Weight trailer - ft2 ratio (kg) (m2 ) 18500 6.8L 4.10 10000 (4536) 60 (5.52) (8391) 180 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 181
, Wheels and Loading GCWR (Gross Combined Weight Rating)/Trailer Weights Maximum Maximum Rear Maximum Loaded frontal area of Engine axle GCWR - lb Trailer Weight trailer - ft2 ratio (kg) (m2 18500 6.8L 4.10 10000 (4536) 60 (5.52) (8391) 181 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 182
Tires, Wheels and Loading GCWR (Gross Combined Weight Rating)/Trailer Weights Maximum Maximum Rear Maximum Loaded frontal area of Engine axle GCWR - lb Trailer Weight trailer - ft2 ratio (kg) (m2) - 5.4L 4.10 8700 (3946) 60 (5.52) (5897) 182 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 183
Tires, Wheels and Loading GCWR (Gross Combined Weight Rating)/Trailer Weights Maximum Maximum Rear Maximum Loaded frontal area of Engine axle GCWR - lb Trailer Weight trailer - ft2 ratio (kg) (m2) 6.8L 4.10 10000 (4536) 60 (5.52) (8391) 183 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 184
Tires, Wheels and Loading GCWR (Gross Combined Weight Rating)/Trailer Weights Maximum Maximum Rear Maximum Loaded frontal area of Engine axle GCWR - lb Trailer Weight trailer - ft2 ratio (kg) (m2) 6.8L 4.56 10000 (4536) 60 (5.52) (9072) 184 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 185
this chapter. Preparing to tow Use the proper equipment for towing a trailer and make sure it is properly attached to your vehicle. Contact your authorized dealer or a reliable trailer dealer as soon as possible if you require assistance. 185 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 186
If you use a rental trailer, follow the instructions that the rental agency gives to you. Do not attach safety chains to the bumper. Trailer brakes Electric brakes and manual, automatic or surge-type trailer brakes are safe if installed properly and adjusted to the manufacturer's specifications. The - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 187
OUTPUT = //////: When the vehicle's brake pedal is pushed, or when the manual control is activated, bar indicators will illuminate in the instrument cluster message center displayed during manual activation without a trailer connected. 187 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 188
point. A GAIN setting of 6.0 is a good starting point for heavier loads. 5. In a traffic-free environment, tow the trailer on a dry, level surface at a speed of 20-25 mph (30-40 km/h) and squeeze the manual control lever completely. 188 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 189
used only for manual tow vehicle. • Avoid towing in adverse weather conditions. The TBC does not provide anti-lock control of the trailer wheels. Trailer wheels can lock-up on slippery surfaces, resulting in reduced stability of trailer and tow vehicle. 189 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 190
for hooking-up trailer lamps. Using a step bumper (if equipped) The rear bumper is equipped with an integral hitch and only requires a ball with a one inch (25.4 mm) shank diameter. The bumper has a 5,000 lb (2,270 kg) trailer weight and 500 lb (227 kg) tongue weight capacity. If it is necessary to - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 191
starts. • Do not tow a trailer for the first 500 miles (800 km) after changing the rear axle lube. • Vehicles with trailers should not be parked on a grade. If you must park on a grade, place wheel chocks under the trailer's wheels. 191 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 192
four (4) wheels off the ground such as when using a car-hauling trailer. Otherwise, no recreational towing is permitted. In case of a roadside emergency with a disabled vehicle, see Wrecker towing in the Roadside Emergencies chapter. 192 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 193
system, creating the risk of fire or other damage. WARNING: Do not park, idle, or drive your vehicle in dry grass or other dry ground cover. The emission system heats up the engine compartment and exhaust system, which can start a fire. 193 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 194
garage door before you start the engine. See Guarding against exhaust fumes in this chapter for more instructions. WARNING: If you smell exhaust electrical accessories are off. • Make sure the parking brake is set. • Make sure the gearshift is in P (Park). 194 2010 Econoline (eco) Owners Guide, - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 195
grade ethanol (same as with unleaded gasoline). If summer grade ethanol is used in cold weather conditions, 0°F to 32°F (-18°C to 0°C), you may experience increased cranking times, rough idle or hesitation until the engine has warmed up. 195 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 196
. The block heater system is most effective when outdoor temperatures reach below 0°F (-18°C). For flexible fuel vehicles, if operating with E85 ethanol, an engine block heater must be used if ambient temperature is below 0°F (-18°C). 196 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 197
the block heater, especially the cord, is in good condition before use. • Make sure that when in operation, the extension cord plug /engine block heater cord plug connection is free and clear of water in order to prevent possible shock or fire. • Be sure that areas where the vehicle is parked are - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 198
shock or fire. Be sure to check for heat anywhere in the electrical hookup once the system has been operating for approximately a half hour. • Finally, have the engine block heater system checked during your fall tune-up to be sure it's in good working order. How to use the engine block heater - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 199
Driving Using ABS When hard braking is start up, remains on or flashes, the ABS may be disabled and may need to be serviced. Even when the ABS is disabled, ! P normal braking is still effective. If your BRAKE brake is released. ! P BRAKE 199 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 200
will allow your vehicle to make better use of available traction in these conditions. During TCS operation, the traction control active light will flash and the engine will not "rev-up" when you on once the vehicle is no longer stuck. 200 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 201
front center console, the tunnel, and the front seats in order operator's ability to control the vehicle, potentially resulting in a loss of vehicle control, vehicle rollover, personal injury and death. If your AdvanceTrac with RSC system activates, SLOW DOWN. 201 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 202
automatically enables each time the engine is started. All features operate. If the "sliding car" icon illuminates steadily, verify that the AdvanceTrac with RSC system is not manually SERVICE RSC NOW, have the system serviced by an authorized dealer immediately. 202 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 203
down. In this situation, TCS will use only engine power reduction or transfer to help control the engine traction control and brake traction control system may be deactivated in certain situations. See the Switching off AdvanceTrac with RSC section following. 203 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 204
operates by applying brakes to one or more of the wheels individually and, if necessary, reducing engine road, or vice versa • Cornering while towing a heavily loaded trailer (refer to Trailer towing in the Tires, Wheels and Loading chapter). Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 205
or if the vehicle is above 20 mph (32 km/h) or by turning off and restarting the engine. If you switch off the AdvanceTrac with RSC system below 20 mph will illuminate steadily. Pressing /h) Not illuminated Enabled Enabled Enabled 205 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 206
a few seconds when the engine is running. • Do not operate the vehicle with a low steering pump fluid level before seeking service by your authorized dealer. • Do (or if the engine is turned off), you can steer the vehicle manually, but it takes Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 207
handles differently from other commonly driven passenger vehicles, making it more difficult to control in an emergency situation. Placing any load on the roof also raises the center of gravity and increases the potential for rollover. 207 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 208
passenger van should select one or two experienced drivers to drive the van on a regular basis. These drivers will gain valuable experience handling the van. This experience will help make each trip safer. The van should be operated injury. Use all Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 209
has blown or the vehicle's brake lamps are not operating properly. Refer to Fuses and relays in the Roadside Emergencies your authorized dealer as soon as possible if this procedure is used. WARNING: Do not drive your vehicle until you verify that Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 210
vehicle in gear: 1. Start the engine 2. Press the brake pedal 3. Move the gearshift lever into the desired gear To put your vehicle in P (Park): 1. Come to a complete stop 2. Move the gearshift lever and securely latch it in P (Park) 210 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 211
, trailer towing and when engine braking is required. • To return to O/D (Overdrive), press the transmission control switch. The O/D OFF lamp will not be illuminated. • O/D (Overdrive) is automatically returned each time the key is turned off. 211 2010 Econoline (eco) Owners Guide, 3rd Printing - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 212
fuel flow to the engine while decelerating. This fuel economy benefit service or repair, the transmission will need to relearn the normal shift strategy parameters, much like having to reset your radio stations when your vehicle battery has been disconnected. 212 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 213
and downshifts through gears one through five. D (Overdrive) with Tow/Haul on The tow/haul feature improves transmission operation when towing a trailer or a heavy load. All transmission gear ranges are available when using tow/haul. 213 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 214
3 (Third) provides engine braking. 2 (Second) Use 2 (Second) to start-up on slippery roads or to provide additional engine braking on downgrades. 1 (First) • Provides maximum engine braking. • Allows upshifts by moving gearshift lever. 214 2010 Econoline (eco) Owners Guide, 3rd Printing USA - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 215
put your vehicle in gear: • Start the engine • Press the brake pedal • Move the gearshift lever into the desired gear To put your vehicle in P (Park): • Come to a complete stop • Move the gearshift lever and securely latch it in P (Park) 215 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 216
transmission control switch. The O/D OFF lamp will not be illuminated. • O/D (Overdrive) is automatically returned each time the key is turned off. 3 (Third) Transmission starts and operates in third gear only. 216 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 217
engine braking. 2 (Second) Use 2 (Second) to start-up on slippery roads or to provide additional engine braking on downgrades. 1 (First) • Provides maximum engine for cornering at speeds as high as passenger cars any more than low-slung sports cars Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 218
) sounds a tone to warn the driver of obstacles near the rear bumper when the R (Reverse) is selected and the vehicle is moving at : To help avoid personal injury, always use caution when in reverse and when using the RSS. WARNING: This system is Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 219
warning goes away, the radio will return to the previous value. The RSS automatically turns on when the gearshift lever is bumper/fascia, leaving it misaligned or bent, the sensing zone may be altered causing inaccurate measurement of obstacles or false alarms. 219 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 220
vehicle orientation and/or road condition. • (1) Rear bumper • (2) Red zone • (3) Yellow zone • (4) Green zone • (5) Centerline of vehicle Always use caution while backing. Objects in the red zone assist in parking or trailer hookup. 220 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 221
the vehicle. WARNING: Do not use the camera system with the backdoor open. If the back end of the vehicle is hit or damaged, then check with your authorized dealer to have your rear video system checked for proper coverage and operation. 221 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 222
operating in order to get a clear image in the dark. If either of the lamps are not operating, stop using the camera system, at least in the dark, until the lamp(s) are replaced and functioning. Servicing in the Driver Controls chapter. 222 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 223
they appear. VEHICLE USED AS A STATIONARY POWER SOURCE Auxiliary equipment called power take-off or PTO, is often added to the engine or transmission to operate utility equipment. Examples include a wheel-lift for tow trucks, cranes, tools for construction or tire service and pumping fluids. PTO - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 224
www.fleet.ford.com/truckbbas, and through the Ford Truck Body Builders Advisory Service. Gas engine vehicles are qualified for up to 10 minutes of continuous operation as a stationary power source, due to the potential for the normal venting of fuel vapors. For stationary PTO operation of extended - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 225
trailer is disabled, but the towing vehicle is operational, the trailer does not qualify for any roadside services. Canadian customers refer to your Customer Information Guide for information on: • coverage period • exact fuel amounts 225 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 226
the ignition. Press in the flasher control and all front and rear direction signals will flash. Press the flasher control again to turn them off. Use it when your vehicle is disabled and is creating a safety hazard for other motorists. 226 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 227
has had a substantial jolt. After an accident, if the engine cranks but does not start, this switch may have been activated. On diesel-powered vehicles, this switch is located in the front passenger's footwell, by the kick panel. 227 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 228
a fuel pump shut-off feature that stops the flow of fuel to the engine. fuel leaks after a collision may increase the risk of fire and serious injury. Ford Motor Company recommends that the fuel system be inspected by an authorized dealer after any collision. 228 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 229
with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire. Standard fuse amperage rating and color COLOR Fuse Red Yellow Yellow - Brown Black Black 229 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 230
with an auxiliary battery, disconnecting the primary under-hood battery DOES NOT remove power from all circuits. To remove a fuse use the fuse puller tool provided on the inside of the fuse panel cover. The fuses are coded as follows. 230 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 231
5 Fuse Amp Rating 30A 15A 15A 30A 10A Protected Circuits Not used (spare) Not used (spare) Not used (spare) Not used (spare) Passenger compartment fuse panel (SPDJB)/Brake-shift interlock Turn signal, Hazard, 15A 15A 15A 20A 10A 10A 20A 5A 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 232
30A circuit breaker Relay Power distribution box The power distribution box is located in the engine compartment. The power distribution box contains high-current fuses that protect your vehicle's main electrical systems from overloads. 232 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 233
battery before servicing high current and reconnected, refer to the Battery section of the Maintenance and Specifications chapter. The high-current fuses are coded as follows. Fuse/Relay tow battery charge Fuel pump Trailer tow park lamp Upfitter #4 233 2010 Econoline (eco) Owners Guide, 3rd Printing - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 234
relay (diesel engine only) - Not used G8VA relay A/C clutch G8VA relay Horn relay (Stripped chassis) HC Micro relay Run/start - Not used - Not used 20A* Back up lamp 10A* A/C clutch 10A* Brake on/off (BOO) switch 18 19 20 21 22 23 24 25 26 27 28 29 30 234 2010 Econoline (eco) Owners Guide, 3rd - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 235
engine only) Diagnostic connector (stripped chassis) Fuel pump Upfitter #3 Upfitter #4 PCM keep alive power, Canister vent, PCM relay coil ABS coil Trailer tow stop lamp/turn signal Wiper motor Not used ** 20A** 30A** - 20A** 10A* 10A* 235 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 236
30A** - 20A** - 30A** 20A* 20A* 10A* Protected Circuits Fuel pump relay coil (gas engine only) PCM (diesel engine only) Diesel fuel conditioner module (DFCM) (diesel engine only) Trailer tow park lamp Trailer tow backup lamp Not used One touch integrated start (OTIS) (diode) Auxiliary battery (diode - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 237
flat serviced by an authorized dealer in order to used. WARNING: Refer to Tire pressure monitoring system (TPMS) in the Tires, Wheels and Loading chapter for important information. If the tire pressure monitor sensor becomes damaged, it will no longer function. 237 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 238
Label • Tow a trailer • Use snow chains on the end of the vehicle with the dissimilar spare tire • Use more than one dissimilar spare tire at a time • Use commercial car Winter weather driving capability • Wet weather driving capability 238 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 239
intended for temporary use only. This means if you need to use it, you should replace it as soon as possible. Stopping and securing your vehicle 1. Park on a level surface. 2. Activate the warning flashers. 3. Place the gearshift in P (Park). 239 2010 Econoline (eco) Owners Guide, 3rd Printing USA - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 240
the parking brake and turn the engine off. Spare tire information The screw and anti-theft bracket. If finger pressure will not remove the thumb screw, use the lug wrench to loosen the screw. 2. Remove the access plug under the left 240 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 241
Pull far enough off the road to avoid the danger of being hit when operating the jack or changing the wheel. Note: Passengers should not remain in the vehicle when the vehicle is being jacked. 1. tire and jack from the storage location. 241 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 242
-hand side of the cargo area. 3. Remove any part of your body under the vehicle while changing a tire. Do not start the engine when your vehicle is on the jack. The jack is only meant for changing the tire. 2. Position the jack to raise the front or rear wheel. 242 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 243
Roadside Emergencies • Never use the front or rear differential as a jacking point. Rear axle jacking points - All models except E-350 Dual Rear Wheel (DRW) and E-450: Rear axle jacking points - E-350 Dual Rear Wheel (DRW) and E-450: 243 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 244
the pin on the front surface of the front axle. Do not on the studs with the flange facing toward the wheel. 6. Use the lug nut wrench to screw the lug nut snugly against the specifications later in this chapter for the proper lug nut torque specification): 244 2010 Econoline (eco) Owners Guide, - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 245
Emergencies WARNING: Never use wheels or lug the ground with the valve stem facing in the direction specified on the Tire Changing Instructions located with the jack hardware. 2. Slide the wheel partially under the vehicle and install . 245 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 246
of dirt and rust. Use only Ford recommended replacement fasteners. On all two-piece flat wheel nuts, apply one drop of motor oil between the flat washer and the nut. Do not apply motor oil to the wheel nut threads or the wheel stud threads. 246 2010 Econoline (eco) Owners Guide, 3rd Printing USA - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 247
with a gasoline engine; if your vehicle is equipped with a diesel engine, refer to the 6.0 and 6.4 Liter Power Stroke Direct Injection Turbo Diesel Owner's Guide Supplement for the an automatic transmission may cause transmission damage. 247 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 248
all other accessories off. Connecting the jumper cables 1. Connect the positive (+) jumper cable to the positive (+) terminal of the discharged battery. Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery. 248 2010 Econoline (eco) Owners Guide, 3rd - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 249
of the positive (+) cable to the positive (+) terminal of the assisting battery. 3. Connect the negative (-) cable to the negative (-) terminal of the assisting battery. 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - - - + + - + + 249 - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 250
vehicle and run the engine at moderately increased speed. 2. Start the engine of the disabled vehicle. 3. Once the disabled vehicle has been started, run both engines for an additional three minutes before disconnecting the jumper cables. 250 2010 Econoline (eco) Owners Guide, 3rd Printing USA - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 251
ground metal surface. Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery. 2. Remove the jumper cable on the negative (-) connection of the booster vehicle's battery. 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - - - - + + + + 251 - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 252
the disabled vehicle's battery. After the disabled vehicle has been started and the jumper cables removed, allow it to idle for several minutes so the engine computer can relearn its idle conditions. 252 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - - - + + - + + - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 253
or incorrectly, vehicle damage may occur. Ford Motor Company produces a towing manual for all authorized tow truck operators. Have your tow truck operator refer to this manual for proper hook-up and towing procedures for your vehicle. 253 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 254
). Refer to Brake-shift interlock in the Driving chapter for specific instructions if you cannot move the gear shift lever into N (Neutral). • Maximum speed is not to exceed 35 mph (56 km/h). • Maximum distance is 50 miles (80 km). 254 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 255
online at www.genuineservice.com. • U.S. dealer locator by Dealer Name, City/State, or Zip Code • Owner Guides • Maintenance Schedules • Recalls • Ford Extended Service Plans • Ford Genuine Accessories • Service specials and promotions. 255 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 256
and Canada: Ford Motorhome Customer Assistance Center 900 N. Lake Havasu Avenue Lake Havasu City, AZ 86403 1-800-444-3311 Open 365/24/7 In order to help service your motorhome vehicle and make of your vehicle • date of vehicle purchase 256 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 257
and reimburse the buyer in an amount equal to the actual price paid or payable by the consumer (less a reasonable allowance for consumer use). The consumer has the right to choose whether to receive a refund or replacement vehicle. 257 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 258
or condition that substantially impairs the use, value or safety of the vehicle) OR 3. The vehicle is out of service for repair of nonconformities for Using the information provided below, please call or write to request a program application. You will be asked 258 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 259
warranty the BBB will review the claim for eligibility cost Ford of Canada. CAMVAP services are available in all territories and provinces. For more information, without charge or obligation, call your CAMVAP Provincial Administrator directly at 1-800-207-0685. 259 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 260
, contact a regional office or owner relations/customer relationship office. The use of leaded fuel in your vehicle without proper conversion may damage the effectiveness of your emission control system and may cause engine knocking or serious engine damage. Ford Motor Company/Ford of Canada is not - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 261
investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Ford Motor Company. 261 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 262
ONLY) If you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately inform Transport Canada, using their toll-free number: 1-800-333-0510. 262 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 263
a wax to clean bumpers and other chrome parts; allow the cleaner to dry for a few minutes, then wipe off the haze with a clean, dry rag. • Never use abrasive materials such as steel wool or plastic pads as they can scratch the chrome surface. 263 2010 Econoline (eco) Owners Guide, 3rd Printing USA - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 264
racks, bumpers, side moldings, mirror housings or the windshield cowl area. The paint sealant will "gray" or stain the parts over time repairing paint chips. • Always read the instructions before using the products. ALUMINUM WHEELS AND WHEEL COVERS Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 265
• Never wash or rinse the engine while it is hot or running; water in the running engine may cause internal damage. • Never wash or rinse any ignition coil, spark plug wire or spark plug well, or the area in and around these locations. 265 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 266
blades using a sponge or soft cloth with a neutral detergent or mild-abrasive cleaning solution. After cleaning, rinse the windshield and wiper blades with clean water. The windshield is clean if beads do not form when you rinse the windshield with water. 266 2010 Econoline (eco) Owners Guide, 3rd - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 267
products such as insect repellent and suntan lotion in order to avoid possible damage to the interior painted surfaces. • Do not use household or glass cleaners as these may damage Strength Carpet & Upholstery Cleaner (ZC-54). 267 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 268
the material, spot-clean the area first with Motorcraft Spot and Stain Remover (ZC-14). In Canada, use Motorcraft Multi-Purpose Cleaner (CXC-101). • If a ring forms on the fabric after spot cleaning, drain holes free from packed dirt. 268 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 269
Ford or Lincoln Mercury authorized dealer has many quality products available to clean your vehicle and protect its finishes. These quality products have been specifically engineered to -93) Motorcraft Wheel and Tire Cleaner (ZC-37-A) 269 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 270
dealer can provide the necessary parts and service. Check your Warranty Guide/Customer Information Guide to find out which parts and services are covered. Use only recommended fuels, lubricants, fluids and service parts conforming to specifications. Motorcraft parts are designed and built to - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 271
left corner of the instrument panel. HOOD 2. Go to the front of the vehicle and push the auxiliary latch, located in the center top of the grille, to the left to release the hood. 3. Lift the hood and secure it with the prop rod. 271 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 272
reservoir 2. Engine oil filler cap 3. Automatic transmission fluid dipstick 4. Air filter assembly 5. Engine oil dipstick 6. Power steering fluid reservoir 7. Brake fluid reservoir 8. Engine coolant reservoir 9. Power distribution box 10. Battery 272 2010 Econoline (eco) Owners Guide, 3rd Printing - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 273
specifications and capacities in this chapter. State or local regulations on volatile organic compounds may restrict the use you operate your vehicle in temperatures below 40°F (5°C), use washer fluid with antifreeze protection. Failure to use Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 274
lower and upper holes or between the MIN and MAX marks (depending on application), the oil level is acceptable. DO NOT ADD OIL. 274 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 275
the filler cap clockwise 1/4 of a turn until three clicks are heard or until the cap is fully seated. To avoid possible oil loss, DO NOT operate the vehicle with the engine oil level dipstick and/or the engine oil filler cap removed. 275 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 276
engine's warranty, use Motorcraft SAE 5W-20 or an equivalent SAE 5W-20 oil meeting Ford specification WSS-M2C930-A. SAE 5W-20 oil provides optimum fuel economy and durability performance meeting all requirements for your vehicle's engine. Refer to Maintenance product specifications and capacities - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 277
operation is considered normal and will fully update transmission operation to its optimum shift feel. Note: Electrical or electronic accessories or components added to the vehicle by the dealer or the owner your battery during storage. 277 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 278
, the engine must relearn its idle and fuel trim strategy for optimum driveability and performance. Flexible fuel vehicles (FFV) must also relearn the ethanol content of the fuel for optimum driveability and performance. To begin this process: 278 2010 Econoline (eco) Owners Guide, 3rd Printing - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 279
. • For flexible fuel vehicles, if you are operating on E85, you may experience poor starts or an inability to start the engine and driveability problems until the fuel trim and ethanol content batteries. RE LE AD TU RN RECYCLE 279 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 280
gauges. When the engine is cold, check the level of the engine coolant in the reservoir. • The engine coolant should be at the FULL COLD level or within the COLD FILL RANGE as listed on the engine coolant reservoir (depending upon application). 280 2010 Econoline (eco) Owners Guide, 3rd Printing - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 281
in the vehicle. Mixing of engine coolants may harm your engine's cooling system. The use of an improper coolant may harm engine and cooling system components and may void the warranty. Refer to Maintenance product specifications and capacities in this chapter. Note: Do not use stop leak pellets or - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 282
concentration (refer to Checking engine coolant). If the concentration is not 50/50 (protection to -34°F/-36°C), drain some coolant and adjust the concentration. It may take several drains and additions to obtain a 50/50 coolant concentration. 282 2010 Econoline (eco) Owners Guide, 3rd Printing USA - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 283
and may cause engine damage. • If available, refer to the chart on the coolant container to ensure the coolant concentration in your vehicle will provide adequate freeze protection at the temperatures in which you drive in the winter months. 283 2010 Econoline (eco) Owners Guide, 3rd Printing USA - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 284
illuminate. • The engine coolant temperature If the engine reaches a preset over-temperature condition, the engine will automatically switch to alternating cylinder operation. Each disabled cylinder acts as an air pump and cools the engine. 284 2010 Econoline (eco) Owners Guide, 3rd Printing USA - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 285
or hot. 5. Re-start the engine and take your vehicle to an authorized dealer. Driving the vehicle without repairing the engine problem increases the chance of engine damage. Take your vehicle to an authorized dealer as soon as possible. 285 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 286
and ethanol are highly toxic and if swallowed can cause death or permanent injury. If fuel is swallowed, call a physician immediately, even if no symptoms are immediately apparent. The toxic effects of fuel may not be visible for hours. 286 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 287
blends may contain up to 75% denatured ethanol (Ed75) and up to 25% unleaded gasoline to enhance cold engine starts. Severely cold weather may require additional measures for reliable starting. Refer to Starting in the Driving chapter. 287 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 288
do not leave the fuel pump unattended when refueling your vehicle - this is against the law in some places; Keep children away from the fuel pump; never let children pump fuel. Do not use personal electronic devices while refueling. 288 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 289
replace it with a fuel filler cap that is designed for your vehicle. The customer warranty may be void for any damage to the fuel tank or fuel system if the correct genuine Ford, Motorcraft or other certified fuel filler cap is not used. 289 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 290
to use fuel or fuel additives with metallic compounds, including manganese-based additives. Note: Use of any fuel other than those recommended may cause powertrain damage, a loss of vehicle performance, and repairs may not be covered under warranty. 290 2010 Econoline (eco) Owners Guide, 3rd - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 291
gasoline. "Premium" unleaded gasoline is not recommended for vehicles designed to use "Regular" unleaded gasoline because it may cause these problems to become more pronounced. If the problems persist, see your authorized dealer. 291 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 292
out of fuel and on a steep grade, more than 1 gallon (3.8L) may be required. indicator may come on. For more • The service engine soon indicator, refer to information on the service engine soon Warning lights and chimes in the Instrument Cluster chapter. 292 2010 Econoline (eco) Owners Guide, 3rd - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 293
measure of fuel economy. We do not recommend taking fuel economy measurements during the first 1,000 miles (1,600 km) of driving (engine break-in period). You will get a more accurate measurement after 2,000 miles-3,000 miles (3,000 km-5,000 km). Filling the tank The advertised fuel capacity of the - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 294
speeds (traveling at 55 mph [88 km/h] uses 15% less fuel than traveling at 65 mph [105 km/h]). • Revving the engine before turning it off may reduce fuel economy. • Using the air conditioner or defroster may reduce fuel economy. 294 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 295
size. • Operating a vehicle with the wheels out of alignment will reduce fuel economy. • Use recommended engine oil. Refer to Maintenance product specifications and capacities in this chapter. • Perform all regularly scheduled maintenance items. Follow the recommended maintenance schedule and owner - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 296
vehicle. The EPA fuel economy estimates should be your guide for the fuel economy comparisons with other vehicles. Your fuel economy may vary depending upon the method of operation and conditions. Note: Vehicles over 8,500 GVW (Gross Vehicle Weight) will not have fuel economy information printed on - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 297
malfunctions present, the service engine soon indicator should stay off the next time the engine is started. A driving cycle consists of a cold engine startup followed by mixed city/highway driving. No additional vehicle service is required. 297 2010 Econoline (eco) Owners Guide, 3rd Printing USA - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 298
have symptoms that are apparent, continued driving with the service engine soon indicator on can result in increased emissions, lower fuel economy, reduced engine and transmission smoothness, and lead to more costly repairs. Readiness for Inspection/Maintenance (I/M) testing Some state/provincial - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 299
the brake pedal after the engine has been turned off will give a false power steering fluid level reading. 5. Recheck the fluid level on the dipstick. Do not add fluid if the level is between the arrows in the FULL COLD range. 299 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) FULL - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 300
to Maintenance product specifications and capacities in this chapter for the proper fluid type. BRAKE FLUID • E-150/E-250/E-350 Single the normal operating range, the performance of the system could be compromised; seek service from your Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 301
Specifications With the parking brake engaged and your foot on the brake pedal, start the engine and move the gearshift lever through all of the gear ranges. Allow sufficient time operating temperature or ambient temperature. 301 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 302
the ambient temperature is above 50°F (10°C). However, if fluid is added at this time, an overfill condition could result when the vehicle reaches normal operating temperature. 302 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 303
at normal operating temperature (150°F-170°F [66°C-77°C]). DON'T ADD IF IN CROSSHATCHED AREA • CHECK WHEN HOT IDLING IN PARK ADD COLD HOT DO NOT ADD The transmission fluid should be in this range if at ambient temperature (50°F-95°F [10°C-35°C]). 303 2010 Econoline (eco) Owners Guide, 3rd - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 304
specifications and capacities in this chapter. Use of a non-approved automatic transmission fluid may cause internal transmission component damage. If necessary, add fluid in 1/2 pint (250 ml) increments through the filler tube until the level is correct. 304 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 305
Maintenance and Specifications DON'T ADD IF IN CROSSHATCHED use supplemental transmission fluid additives, treatments or cleaning agents. The use of these materials may affect transmission operation and result in damage to internal transmission components. 305 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 306
listed. Refer to Motorcraft part numbers in this chapter. WARNING: To reduce the risk of vehicle damage and/or personal burn injuries do not start your engine with the air cleaner removed and do not remove it while the engine is running. 306 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 307
air inlet tube to the radiator support. Note: Failure to use the correct air filter element may result in severe engine damage. The customer warranty may be void for any damage to the engine if the correct air filter element is not used. 307 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 308
design specifications for your vehicle, such as Motorcraft or equivalent replacement parts. The customer warranty may be void for any damage to the engine if such spark plugs are not used. 2 Also available with 6.0L diesel engine/TorqShift transmission. 308 2010 Econoline (eco) Owners Guide, 3rd - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 309
-M6C62-A or WSS-M6C65-A1 Capacity Ford part name Ford part number / Ford specification 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) Maintenance and Specifications 23.8 quarts (22.6L) 26.0 quarts (24.6L) 28.8 quarts Motorcraft Premium (27.2L) Gold Engine Coolant VC-7-B / with Bittering - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 310
310 Item Cooling system stop leak pellets - Capacity Ford part name Ford part number / Ford specification Engine oil 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) Maintenance and Specifications Engine oil-diesel engine Power steering fluid 13.9 quarts (13.1L)3 18.8 quarts (17.7L)3 5.9 - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 311
(M248) E-150/E-350 Dana conventional axle fluid M70FF (M267FF) E-350 Dana conventional axle fluid M70HD (M273HD) E-450 Windshield washer fluid 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) Capacity Ford part name Ford part number / Ford specification Maintenance and Specifications 311 - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 312
Item Capacity Ford part name Ford part number / Ford specification - - 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) Fuel tank-all regular and extended length vans and wagons Fuel tank-138 inch wheelbase (except E-Super Duty) Fuel tank-158 inch wheelbase (except E-Super Duty) Fuel tank - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 313
Maintenance and Specifications ENGINE DATA 4.6L V8 5.4L V8 6.8L V10 Engine Engine Engine Cubic inches 281 330 415 87 octane or 87 octane 87 octane or Required fuel E852 E852 Firing order 1-3-7-2-6-5-4-8 1-3-7-2-6-5-4-8 1-6-5-10-2-7-3-8-4-9 Ignition system Coil on plug Coil on plug Coil on plug 0.041 - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 314
Maintenance and Specifications • 4.6L V8, 5.4L V8 and 6.8L V10 engines with A/C IDENTIFYING YOUR VEHICLE Safety Compliance Certification Label (complete Ford built vehicles) The of the driver's door or the edge of the driver's door. 314 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 315
2. Brake system / Gross Vehicle Weight Rating (GVWR) / Restraint Devices and their location 3. Make, vehicle line, series, body type 4. Engine type 5. Check digit 6. Model year or more stages by two or more separate manufacturers. 315 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 316
Certification Label. The following table tells you which transmission each code represents. Description Four-speed automatic overdrive (4R75E) Five-speed automatic TorqShift with Tow/Haul Five-speed automatic 5R110W-Hi/Torque Code Q T B 316 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 317
store at: www.fordaccessories.com. Exterior style Bug shields Deflectors Running boards Interior style Cargo organization Electrochromic compass/temperature interior mirrors Floor mats Lifestyle Trailer hitches and towing accessories 317 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 318
: • When adding accessories, equipment, passengers and luggage to your vehicle, do not exceed the total weight capacity of the vehicle or of the front or rear axle (GVWR or GAWR as indicated on the Safety Compliance Certification label). Consult your authorized dealer for specific weight information - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 319
get: • Reliable, quality service anywhere you go. • Factory-trained technicians. • Genuine Ford and Motorcraft Parts. Rental car reimbursement If your vehicle is kept overnight for covered repairs, you are eligible for rental car coverage, including Bumper-to-Bumper warranty repairs, or manufacturer - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 320
Ford Extended Service Plan that fits your driving lifestyle and budget. Interest free finance options available Take advantage of our installment payment plan, just a 10% down payment will provide you with an affordable no interest, no-fee payment opportunity. 320 2010 Econoline (eco) Owners Guide - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 321
Ford Extended Service Plan 321 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 322
117 in front seat ...117 in rear seat ...117 LATCH ...121 recommendations ...115 tether anchorage hardware ...127 Child safety seats - booster seats ...130 Cleaning your vehicle engine compartment ...265 exterior ...268 instrument panel ...267 interior ...267 2010 Econoline (eco) Owners Guide, 3rd - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 323
309 service points ...272-273 starting after a collision ...227 Engine block heater ...196 Engine oil ...274 checking and adding ...274 dipstick ...274 filter, specifications ...276, 308 recommendations ...276 refill capacities ...309 specifications ...309 323 2010 Econoline (eco) Owners Guide, 3rd - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 324
vehicle ...207 Fuel ...286 calculating fuel economy ...22, 293 cap ...289 capacity ...309 choosing the right fuel ...290 comparisons with EPA fuel economy estimates ...296 detergent in fuel ...291 filling your vehicle with fuel ...286, 289, 293 filter, specifications ...286, 308 fuel pump shut-off - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 325
, refill capacity ...309 fluid, specifications ...309 Power Windows ...64 Preparing to drive your vehicle ...207 R Radio ...29, 31 Rear-view camera system ...220 Recommendations for attaching safety restraints for children ...115 Relays ...229 325 2010 Econoline (eco) Owners Guide, 3rd Printing - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 326
Servicing your vehicle ...270 Setting the clock AM/FM single CD ...32 AM/FM stereo ...30 326 SOS Post Crash Alert ...106 Spare tire (see Changing the Tire) ...240 Spark plugs, specifications ...308, 313 Special notice ...7 ambulance conversions Econoline (eco) Owners Guide, 3rd Printing USA (fus) - 2011 Ford E150 Super Duty Passenger | Owner's Manual - Page 327
fluid ...273 Water, Driving through ...224 Windows power ...64 Windshield washer fluid and wipers ...62 checking and adding fluid ...273 replacing wiper blades ...273 Wrecker towing ...253 327 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus)
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
-
101
-
102
-
103
-
104
-
105
-
106
-
107
-
108
-
109
-
110
-
111
-
112
-
113
-
114
-
115
-
116
-
117
-
118
-
119
-
120
-
121
-
122
-
123
-
124
-
125
-
126
-
127
-
128
-
129
-
130
-
131
-
132
-
133
-
134
-
135
-
136
-
137
-
138
-
139
-
140
-
141
-
142
-
143
-
144
-
145
-
146
-
147
-
148
-
149
-
150
-
151
-
152
-
153
-
154
-
155
-
156
-
157
-
158
-
159
-
160
-
161
-
162
-
163
-
164
-
165
-
166
-
167
-
168
-
169
-
170
-
171
-
172
-
173
-
174
-
175
-
176
-
177
-
178
-
179
-
180
-
181
-
182
-
183
-
184
-
185
-
186
-
187
-
188
-
189
-
190
-
191
-
192
-
193
-
194
-
195
-
196
-
197
-
198
-
199
-
200
-
201
-
202
-
203
-
204
-
205
-
206
-
207
-
208
-
209
-
210
-
211
-
212
-
213
-
214
-
215
-
216
-
217
-
218
-
219
-
220
-
221
-
222
-
223
-
224
-
225
-
226
-
227
-
228
-
229
-
230
-
231
-
232
-
233
-
234
-
235
-
236
-
237
-
238
-
239
-
240
-
241
-
242
-
243
-
244
-
245
-
246
-
247
-
248
-
249
-
250
-
251
-
252
-
253
-
254
-
255
-
256
-
257
-
258
-
259
-
260
-
261
-
262
-
263
-
264
-
265
-
266
-
267
-
268
-
269
-
270
-
271
-
272
-
273
-
274
-
275
-
276
-
277
-
278
-
279
-
280
-
281
-
282
-
283
-
284
-
285
-
286
-
287
-
288
-
289
-
290
-
291
-
292
-
293
-
294
-
295
-
296
-
297
-
298
-
299
-
300
-
301
-
302
-
303
-
304
-
305
-
306
-
307
-
308
-
309
-
310
-
311
-
312
-
313
-
314
-
315
-
316
-
317
-
318
-
319
-
320
-
321
-
322
-
323
-
324
-
325
-
326
-
327
 |
 |
Introduction
4
Instrument Cluster
14
Warning lights and chimes
14
Gauges
19
Message center
21
Entertainment Systems
29
AM/FM stereo
29
AM/FM stereo with CD
31
Auxiliary input jack
38
USB port
40
Satellite radio information
43
Navigation system
46
SYNC
°
46
Climate Controls
47
Heater only
47
Manual heating and air conditioning
48
Lights
50
Headlamps
50
Turn signal control
54
Bulb replacement
55
Driver Controls
62
Windshield wiper/washer control
62
Steering wheel adjustment
63
Power windows
64
Mirrors
65
Speed control
68
Upfitter controls
70
Locks and Security
72
Keys
72
Locks
72
Anti-theft system
81
Table of Contents
1
2010 Econoline
(eco)
Owners Guide, 3rd Printing
USA
(fus)