2007 Mercury Mountaineer Scheduled Maintenance Guide 1st Printing
2007 Mercury Mountaineer Manual
2007 Mercury Mountaineer manual content summary:
- 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 1
2007 Model Year Scheduled Maintenance Guide Vehicle Identification Number (VIN): Owner Name: Address: All rights reserved. Reproduction by any means, electronic or mechanical including photocopying, recording or by any information storage and retrieval system or translation in whole or part is - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 2
the importance of routine and dealer performed maintenance on your vehicle, please visit the Ford Customer Service website. You'll also find important warranty information, customer assistance, technical expertise, frequently asked questions and much more. The website location is: www.genuineservice - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 3
Checks and Services Focus, Freestar, Freestyle, Fusion, Grand Marquis, LS, Milan, Montego, Monterey, Mustang, Taurus, Thunderbird, Town Car and Zephyr Special Operating Conditions & Exceptions Special Operating Conditions ...42-45 Exceptions ...46-47 Motorcraft Premium Gold Engine Coolant Change - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 4
why we've put together the Scheduled Maintenance Guide; basically, it outlines what service your vehicle may require and when. The focus is on maintaining your vehicle while it's running great, which goes a long way toward preventing major repairs and expenses later. Here are a few suggestions to - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 5
. You will find further information under ЉExceptionsЉ on page 46 • Engine oil and Motorcraft Premium Gold Engine Coolant - time and mileage based interval • Class A Motorhome - change the brake fluid and automatic transmission fluid • Rear axle maintenance and lubrication Last of all, if you're - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 6
dealership recognizes the competitive landscape of maintenance and light repair automotive services. With factory-trained technicians, and one-stop service from routine maintenance like oil changes and tire rotations to repairs like brake service, check out the value your Ford and Lincoln Mercury - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 7
equipped. and lubricate door rubber weatherstrips. and clean body and door drain holes. safety warning lamps (brake, ABS, air bag, safety belt) for operation. engine cooling system level and strength. battery connections and clean if necessary. clutch fluid level, if equipped. Retightening lug nuts - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 8
or Lincoln Mercury dealers: Air Conditioning Check Engine Light All Wheel Drive and 4X4 Automatic Transmission Engine Cooling and Cabin Heating Steering and Suspension Charge/Start/Battery Wheel Alignment Anti-Lock Brake System When parts on your vehicle need replacing, you should not settle - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 9
health of your vehicle's battery during any service visit. The Motorcraft Tested Tough Max Series with its Љlong-lifeЉ design outlasted other long-life batteries by up to 200%. That's one reason why we stand behind this battery with a national 3 year, free-replacement and prorated-cost thereafter - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 10
of Ford Motor Company engineers. In addition, all Ford Original Equipment replacement brake pads, shoes, rotors and drums are vehicle tested for durability and noise suppression while being Federal Motor Vehicle Safety Standard (FMVSS) compliant. The right brake parts and repair work are essential - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 11
Lincoln Mercury Dealerships offer collision repair services. Ask your selling dealership about their capabilities to help with collision repair. Parts Genuine Ford Collision Parts are designed, engineered, and warranted by Ford Motor Company. See your dealer for limited warranty details. They are - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 12
oil and fluid leaks. Inspect engine air filter. Inspect half shaft dust boots, if equipped. Check shocks and struts and other suspension components for leaks and damage. Inspect steering and linkage. Inspect accessory drive belt(s). Inspect clutch operation, if equipped. 12 Scheduled Maintenance - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 13
's a comprehensive way to perform a thorough inspection of your vehicle. It is your receipt that gives you immediate feedback! You'll know what's been checked, what's okay, as well as those things that may require future or immediate attention. The multi-purpose vehicle inspection is one more way to - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 14
Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system. Inspect wheel ends for endplay and noise. Inspect engine cooling system and hoses. Inspect steering linkage, ball joints, suspension and, if equipped, half shafts, driveshaft and U-joints. Replace cabin air filter - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 15
❑ Change engine oil and replace oil filter. ❑ replaced, consider visiting your Ford or Lincoln Mercury dealership for name-brand tires and people who know your vehicle. And if your Ford or Lincoln Mercury dealership sells the name-brand tire, they can also honor the tire manufacturer's warranty - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 16
VANS & SUVS 30,000 miles ❑ Change engine oil and replace oil filter. ❑ Inspect tires for wear and rotate. ❑ Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system. Inspect wheel ends for endplay and noise. Inspect engine cooling system and hoses. Inspect exhaust - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 17
brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system. Inspect wheel ends for endplay and noise. Inspect engine cooling system and hoses. Inspect steering linkage, ball joints, suspension and, if equipped, half shafts, driveshaft and U-joints. Replace cabin air filter - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 18
health of your vehicle's battery during any service visit. The Motorcraft Tested Tough Max Series with its Љlong-lifeЉ design outlasted other long-life batteries by up to 200%. That's one reason why we stand behind this battery with a national 3 year, free-replacement and prorated-cost thereafter - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 19
VANS & SUVS 60,000 miles ❑ Change engine oil and replace oil filter. ❑ Inspect tires for wear and rotate. ❑ Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system. Inspect wheel ends for endplay and noise. Inspect engine cooling system and hoses. Inspect exhaust - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 20
brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system. Inspect wheel ends for endplay and noise. Inspect engine cooling system and hoses. Inspect steering linkage, ball joints, suspension and, if equipped, half shafts, driveshaft and U-joints. Replace cabin air filter - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 21
Change engine oil and replace oil filter. engineers. In addition, all Ford Original Equipment replacement brake pads, shoes, rotors, and drums are vehicle tested for durability and noise suppression while being Federal Motor Vehicle Safety Standard (FMVSS) compliant. The right brake parts and repair - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 22
VANS & SUVS 90,000 miles ❑ Change engine oil and replace oil filter. ❑ Inspect tires for wear and rotate. ❑ Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system. Inspect wheel ends for endplay and noise. Inspect engine cooling system and hoses. Inspect exhaust - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 23
Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system. Inspect wheel ends for endplay and noise. Inspect engine cooling system and hoses. Inspect steering linkage, ball joints, suspension and, if equipped, half shafts, driveshaft and U-joints. Replace cabin air filter - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 24
optimal tire life. Multi-point inspection (recommended) DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: 115,000 miles ❑ Change engine oil and replace oil filter. ❑ Inspect tires for wear. Rotation recommended for ❑ optimal tire life. Multi-point inspection (recommended) DEALER VALIDATION: RO - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 25
VANS & SUVS 120,000 miles ❑ Change engine oil and replace oil filter. ❑ Inspect tires for wear and rotate. ❑ Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system. Inspect wheel ends for endplay and noise. Inspect engine cooling system and hoses. Inspect exhaust - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 26
brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system. Inspect wheel ends for endplay and noise. Inspect engine cooling system and hoses. Inspect steering linkage, ball joints, suspension and, if equipped, half shafts, driveshaft and U-joints. Replace cabin air filter - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 27
Change engine oil and replace oil filter. engineers. In addition, all Ford Original Equipment replacement brake pads, shoes, rotors, and drums are vehicle tested for durability and noise suppression while being Federal Motor Vehicle Safety Standard (FMVSS) compliant. The right brake parts and repair - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 28
transmission/transaxle fluid and filter (filter not required on CD4E). Change rear axle lubricant on all rear wheel drive (RWD) vehicles (see pages 42 and 46). Replace accessory drive belt(s) (if not replaced within last 100,000 miles). Replace climate-controlled seat filters if equipped (Navigator - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 29
Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system. Inspect wheel ends for endplay and noise. Inspect engine cooling system and hoses. Inspect steering linkage, ball joints, suspension and, if equipped, half shafts, driveshaft and U-joints. Replace cabin air filter - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 30
CARS & MINIVANS 20,000 miles ❑ Change engine oil and replace oil filter. ❑ Inspect tires for wear. Rotation recommended for ❑ optimal tire life. Multi-point inspection (recommended) DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: 25,000 miles ❑ Change engine oil and replace oil filter - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 31
NORMAL SCHEDULE CARS & MINIVANS 30,000 miles ❑ Change engine oil and replace oil filter. ❑ Inspect tires for wear and rotate. ❑ Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system. Inspect wheel ends for endplay and noise. Inspect engine cooling system and hoses. - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 32
Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system. Inspect wheel ends for endplay and noise. Inspect engine cooling system and hoses. Inspect steering linkage, ball joints, suspension and, if equipped, half shafts, driveshaft and U-joints. Replace cabin air filter - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 33
CODE: MILEAGE: 60,000 miles ❑ Change engine oil and replace oil filter. ❑ Inspect tires for wear and rotate. ❑ Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system. Inspect wheel ends for endplay and noise. Inspect engine cooling system and hoses. Inspect exhaust - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 34
brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system. ❑ Inspect wheel ends for endplay and noise. ❑ Inspect engine cooling system and hoses. ❑ Inspect steering linkage, ball joints, suspension and, if equipped, half shafts, driveshaft and U-joints. ❑ Replace cabin air - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 35
replacement brake pads, shoes, rotors, and drums are vehicle tested for durability and noise suppression while being Federal Motor Vehicle Safety Standard (FMVSS) compliant. The right brake parts and repair work are essential to ensure your brake system operates as it should. Normal Schedule Cars - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 36
NORMAL SCHEDULE CARS & MINIVANS 90,000 miles ❑ Change engine oil and replace oil filter. ❑ Inspect tires for wear and rotate. ❑ Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system. Inspect wheel ends for endplay and noise. Inspect engine cooling system and hoses. - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 37
Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system. Inspect wheel ends for endplay and noise. Inspect engine cooling system and hoses. Inspect steering linkage, ball joints, suspension and, if equipped, half shafts, driveshaft and U-joints. Replace cabin air filter - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 38
CODE: MILEAGE: 120,000 miles ❑ Change engine oil and replace oil filter. ❑ Inspect tires for wear and rotate. ❑ Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system. Inspect wheel ends for endplay and noise. Inspect engine cooling system and hoses. Inspect exhaust - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 39
Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system. Inspect wheel ends for endplay and noise. Inspect engine cooling system and hoses. Inspect steering linkage, ball joints, suspension and, if equipped, half shafts, driveshaft and U-joints. Replace cabin air filter - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 40
of your vehicle's battery during any service visit. The Motorcraft Tested Tough Max Series with its Љlong-lifeЉ design outlasted the competitive long-life batteries by up to 200%. That's one reason why we stand behind this battery with a national 3 year, free-replacement and prorated-cost thereafter - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 41
or a CVT). Change rear axle lubricant on all rear wheel drive (RWD) vehicles (see pages 42 and 46). Replace accessory drive belt(s) (if not replaced within last 100,000 miles). Replace climate-controlled seat filter if equipped (LS and Monterey). Replace climate-controlled seat cushion filter, if - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 42
/or low-speed driving for long distances as in heavy commercial use such as delivery, taxi, patrol car or livery Every 3,000 miles, 3 months or Change engine oil and replace oil filter 200 hours of engine operation Every 3,000 miles or 3 months Lube front lower control arm and steering linkage ball - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 43
6R60 transmission) Check air filter restriction gauge, replace filter as required (Focus only) Every 50,000 miles Change rear axle lubricant (E450 and F450/550 only) Every 60,000 miles Change transfer case fluid As required Replace engine air filter As required Replace cabin air filter (if equipped - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 44
SPECIAL OPERATING CONDITIONS Special Operating Conditions Log DEALER VALIDATION: DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: DEALER - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 45
SPECIAL OPERATING CONDITIONS Special Operating Conditions Log DEALER VALIDATION: DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: DEALER - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 46
48) Normal Vehicle Axle Maintenance ❑ Rear axles and power take off (PTO) units containing synthetic lubricant and light duty trucks equipped with Ford-design axles are lubricated for life. These lubricants are not to be checked or changed unless a leak is suspected, service is required or the axle - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 47
, where noted, on pages 42-43. California Fuel Filter Replacement ❑ If vehicle is registered in California, the California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of - 2007 Mercury Mountaineer | Scheduled Maintenance Guide 1st Printing - Page 48
RECORD Current mileage goes here => Add 50,000 miles to the current miles + 50,000 Next change due at this mileage => Or Today's date goes here => Add 3 years + 00 / 00 / 03 Date of next change => whichever comes first Dealer Stamp P & A CODE R.O.# Current mileage goes here => Add 50,000 miles to
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
 |
 |
2007 Model Year
Scheduled Maintenance Guide
Vehicle Identification Number (VIN):
Owner Name:
Address:
All rights reserved. Reproduction by any means, electronic or mechanical including photocopying, recording or by any
information storage and retrieval system or translation in whole or part is not permitted without written authorization
from Ford Motor Company. Ford may change the contents without notice and without incurring obligation.
Copyright © 2004 Ford Motor Company
Scheduled Maintenance
1