2010 Polaris Ranger EV Owners Manual

2010 Polaris Ranger EV Manual

Get 2010 Polaris Ranger EV PDF manuals and user guides View all 2010 Polaris Ranger EV manuals

2010 Polaris Ranger EV manual content summary:

  • 2010 Polaris Ranger EV | Owners Manual - Page 1
  • 2010 Polaris Ranger EV | Owners Manual - Page 2
    WARNING Read, understand, and follow all of the instructions and safety precautions in this manual and on all product labels. Failure to follow the safety precautions could result in serious injury or death.
  • 2010 Polaris Ranger EV | Owners Manual - Page 3
    The text is printed on 100% recycled with 40% post-consumer waste (PCW).
  • 2010 Polaris Ranger EV | Owners Manual - Page 4
    . Make sure passenger reads and understands all safety labels. Watch for branches or other hazards that could enter vehicle. READ OWNER'S MANUAL. FOLLOW ALL INSTRUCTIONS AND WARNINGS. For your nearest Polaris dealer, call 1-800-POLARIS or visit www.polarisindustries.com Polaris Sales Inc., 2100 Hwy
  • 2010 Polaris Ranger EV | Owners Manual - Page 5
    operation of your vehicle, be sure to follow the instructions and recommendations in this owner's manual. Your manual contains instructions for minor maintenance, but information about major repairs is outlined in the Polaris Service Manual and should be performed only by a factory certified Master
  • 2010 Polaris Ranger EV | Owners Manual - Page 6
    reprinting or reuse of the depictions and/or procedures contained within, whether whole or in part, is expressly prohibited. Printed in U.S.A. 2010 RANGER EV Owner's Manual P/N 9922614 2
  • 2010 Polaris Ranger EV | Owners Manual - Page 7
    TABLE OF CONTENTS Introduction ...4 Safety ...7 Features and Controls ...22 Operation ...38 Maintenance ...56 Specifications ...80 Polaris Products...82 Troubleshooting ...83 Warranty ...84 Maintenance Log ...90 Index ...92 3
  • 2010 Polaris Ranger EV | Owners Manual - Page 8
    your area. The following signal words and symbols appear throughout this manual and on your vehicle. Your safety is involved when these words symbols are used. Become familiar with their meanings before reading the manual. The safety alert symbol indicates a potential personal injury hazard. WARNING
  • 2010 Polaris Ranger EV | Owners Manual - Page 9
    on hills or over obstacles, if you fail to take proper precautions. • Read this owner's manual. Understand all safety warnings, precautions and operating procedures before operating the vehicle. Keep this manual with the vehicle. • This vehicle is an ADULT VEHICLE ONLY. NEVER operate this vehicle if
  • 2010 Polaris Ranger EV | Owners Manual - Page 10
    INTRODUCTION Vehicle Identification Numbers Record your vehicle's identification numbers and key number in the spaces provided. Remove the spare key and store it in a safe place. A key can be duplicated only by ordering a key blank (using your key number) and mating it with one of your existing
  • 2010 Polaris Ranger EV | Owners Manual - Page 11
    of the labels on the vehicle carefully. If any of the labels depicted in this manual differ from the labels on your vehicle, always read and follow the instructions of the labels on the vehicle. If any label becomes illegible or comes off, contact your Polaris dealer to purchase a replacement
  • 2010 Polaris Ranger EV | Owners Manual - Page 12
    this unit could result in serious personal injury, will void the warranty, and can result in permanent damage to the vehicle. • Refer to your Owner's Manual or contact your local Polaris dealer with any questions. 7176206 Battery Compartment Warning 8
  • 2010 Polaris Ranger EV | Owners Manual - Page 13
    with storage or weather cover on vehicle or with the cab enclosure doors closed, as fire and explosion are possible. • Refer to Owner's Manual or contact your local Polaris dealer with any questions. TO MAXIMIZE BATTERY LIFE • Always check and maintain water level monthly. Use only distilled water
  • 2010 Polaris Ranger EV | Owners Manual - Page 14
    the floor of the vehicle. Battery damage will occur. • Batteries require regular maintenance. • Failure to maintain batteries in accordance with the owners manual can result in battery damage, vehicle malfunction, fire and/or severe injury or death. • Max towing speed 25 mph (40 km/h) - drivetrain
  • 2010 Polaris Ranger EV | Owners Manual - Page 15
    sudden braking. • Make sure passenger reads and understands all safety labels. • Watch for branches or other hazards that could enter vehicle. LOCATE AND READ OWNER'S MANUAL. FOLLOW ALL INSTRUCTIONS AND WARNINGS. 7176169 11
  • 2010 Polaris Ranger EV | Owners Manual - Page 16
    Operator Safety WARNING Serious injury or death can result if you do not follow these instructions and procedures, which are outlined in further detail within your owner's manual. • Read this manual and all labels carefully. Follow the operating procedures described. • Never allow anyone under age
  • 2010 Polaris Ranger EV | Owners Manual - Page 17
    excessively slippery or loose surfaces. Never go over the top of a hill at high speed. • Always follow the proper procedures outlined in this manual for traveling downhill and for braking on hills. Check the terrain carefully before descending a hill. Never travel downhill at high speed. Avoid going
  • 2010 Polaris Ranger EV | Owners Manual - Page 18
    exceed the stated load capacity for this vehicle. Cargo should be properly distributed and securely attached. Reduce speed and follow the instructions in this manual for hauling cargo or pulling a trailer. Allow a greater distance for braking. • Always set the park brake and remove the key when
  • 2010 Polaris Ranger EV | Owners Manual - Page 19
    Operator Safety Equipment Modifications SAFETY We strongly recommend that consumers do not install on a Polaris RANGER any equipment that may increase the speed or power of the vehicle, or make any other modifications to the vehicle for these purposes. Any modifications to the original equipment
  • 2010 Polaris Ranger EV | Owners Manual - Page 20
    the vehicle properly in different situations and on different types of terrain. All operators must read and understand the Owner's Manual and all warning and instruction labels before operating the vehicle. Seat Belts Riding in this vehicle without wearing the seat belt increases the risk of
  • 2010 Polaris Ranger EV | Owners Manual - Page 21
    to make sure it's in safe operating condition. Always follow all inspection and maintenance procedures and schedules described in the owner's manual. Using Alcohol or Drugs Operating the vehicle after consuming alcohol or drugs could adversely affect operator judgment, reaction time, balance and
  • 2010 Polaris Ranger EV | Owners Manual - Page 22
    Operator Safety Operating a Damaged Vehicle Operating a damaged vehicle can result in an accident. After any overturn or accident, have a qualified service dealer inspect the entire machine for possible damage, including (but not limited to) brakes, accelerator, steering system and electrical system
  • 2010 Polaris Ranger EV | Owners Manual - Page 23
    Operator Safety Turning Improperly SAFETY Turning improperly could cause loss of traction, loss of control, accident or overturn. Always follow proper procedures for turning. Never turn abruptly or at sharp angles. Never turn at high speeds. Practice turning at slow speeds before attempting to
  • 2010 Polaris Ranger EV | Owners Manual - Page 24
    Improperly descending a hill could cause loss of control or overturn. Always follow proper procedures for traveling down hills as described in the owner's manual. • Use the brake pedal to control speed when descending a hill. Never travel down a hill at high speed. • Always descend a hill with the
  • 2010 Polaris Ranger EV | Owners Manual - Page 25
    system. Precautions During Maintenance Always disconnect the main power connector before servicing or unplugging any electrical components. See page 34. Always follow all safety instructions in the maintenance portion of this owner's manual, as well as the following: • Make sure the vehicle is
  • 2010 Polaris Ranger EV | Owners Manual - Page 26
    FEATURES AND CONTROLS Component Locations ROPS Cab Frame Console Charging Cord (in glove box) Hip Bar Cargo Box Headlights Front Bumper/Brush Guard 22
  • 2010 Polaris Ranger EV | Owners Manual - Page 27
    Component Locations FEATURES AND CONTROLS Tailgate Latch Releases Tailgate Receiver Hitch CV Boot/Rear Caliper Trailer Hitch Bracket This vehicle is equipped with a receiver hitch bracket for a trailer hitch. Trailer towing equipment is not supplied with this vehicle. To avoid injury and
  • 2010 Polaris Ranger EV | Owners Manual - Page 28
    FEATURES AND CONTROLS Console 1 2 3 4 5 10 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 9 8 7 6 Park Brake Lever Headlight Switch Drive Mode Switch Battery Discharge Indicator Hour Meter Charge Status Indicator 12V Auxiliary Outlet AWD Switch Direction Selector Key Switch Indicator Lights 11 24
  • 2010 Polaris Ranger EV | Owners Manual - Page 29
    Console FEATURES AND CONTROLS Battery Discharge Indicator The battery discharge indicator displays the amount of charge removed (used) from fully charged batteries. When the batteries are fully charged, the right-most bar illuminates, indicating 0% has been used. The charge status indicator will
  • 2010 Polaris Ranger EV | Owners Manual - Page 30
    for disconnection, then see your dealer promptly if this feature fails to operate properly. Always apply the service brakes before engaging or releasing the park brake. 1. Apply the brakes. 2. Pull the park brake the glove compartment. See page 72 for charging instructions. Charging Cord 26
  • 2010 Polaris Ranger EV | Owners Manual - Page 31
    AC voltage or high internal charger temperature exists; open hood to improve air flow. Charger error exists; reset charger power and refer to Troubleshooting Guide on page 31. Key Switch Move the direction selector switch to neutral, then turn the key to the ON position to activate the electrical
  • 2010 Polaris Ranger EV | Owners Manual - Page 32
    FEATURES AND CONTROLS Console Drive Mode Switch CAUTION! Changing the drive mode switch position while driving could result in an automatic increase or decrease in speed without a change to accelerator pedal pressure. High Maximum Range Press the top of the switch to select high mode. Use high
  • 2010 Polaris Ranger EV | Owners Manual - Page 33
    (1WD). This mode of operation is well suited to turf driving or when active traction is not needed. See page 54 for Differential Lock operating instructions. Headlight Switch Press the top of the switch to turn the headlights on. Press the bottom of the switch to turn the headlights off. On
  • 2010 Polaris Ranger EV | Owners Manual - Page 34
    key is in the ON position. Indicator Panel Indicator Malfunction Status Steady Indicates Electrical malfunction (flash sequence on controller indicates type; see troubleshooting guide on page 31) Key was turned on in forward or reverse (switch to neutral, then to forward or reverse) Park Brake
  • 2010 Polaris Ranger EV | Owners Manual - Page 35
    Controller or motor out of temperature range Software fault Charge Status Indicator Troubleshooting Guide The code definitions provided are for informational purposes only. Please see your charger (interrupt AC power for 15 seconds); return to qualified service provider if fault persists 4 5 6 31
  • 2010 Polaris Ranger EV | Owners Manual - Page 36
    . The batteries are located under the seat. See page 73 for battery access instructions. Always observe all battery safety warnings and safe handling procedures as outlined on vehicle safety labels and in this manual. Refer to the battery maintenance section beginning on page 71. Battery Handling
  • 2010 Polaris Ranger EV | Owners Manual - Page 37
    Batteries FEATURES AND CONTROLS Battery Conditioning New batteries cannot initially hold all of their capacity. The approximate capacity of the battery pack increases as the number of charge cycles increases. # of Charge Cycles: Percent of Full Capacity: New 80% 15 90% 30 95% 45 100% Ambient
  • 2010 Polaris Ranger EV | Owners Manual - Page 38
    components. When disconnected, the main power connector disconnects the battery pack from all electrical components, with the exception of the contactor. After servicing the vehicle, the main power connector should be the last connection to be made. The main power connector is located under the
  • 2010 Polaris Ranger EV | Owners Manual - Page 39
    , release the accelerator pedal. Electric motor braking provides braking when the pedal is released. For additional speed control or to stop the vehicle, apply the service brakes. Brake Pedal Accelerator Pedal 35
  • 2010 Polaris Ranger EV | Owners Manual - Page 40
    in any way. No device can assure occupant protection in the event of a rollover. Always follow all safe operating practices outlined in this manual to avoid vehicle rollover. ROPS Cab Frame Roll-Over Protection System (ROPS) WARNING! Vehicle rollover could cause severe injury or death. Always
  • 2010 Polaris Ranger EV | Owners Manual - Page 41
    Seat Belts FEATURES AND CONTROLS This Polaris vehicle is equipped with three-point lap and diagonal seat belts for the operator and passenger. Always make sure the seat belts are secured for all riders before operating. The center of the seat is NOT equipped with a seat belt. Never allow a
  • 2010 Polaris Ranger EV | Owners Manual - Page 42
    overturn, which may result in serious injury or death. Read and understand all safety warnings outlined in the safety section of this owner's manual. Pre-Ride Inspection Failure to inspect and verify that the vehicle is in safe operating condition before operating increases the risk of an accident
  • 2010 Polaris Ranger EV | Owners Manual - Page 43
    Driving Procedure OPERATION 1. 2. 3. 4. 5. 6. 7. 8. 9. Disconnect the charging cable (if connected). Wear a helmet and eye protection. Sit in the driver's seat and fasten the seat belt. Apply the brakes. Place the direction selector in neutral (N). Turn the key to the ON position. Wait about a
  • 2010 Polaris Ranger EV | Owners Manual - Page 44
    OPERATION Driving Procedure 10. Keeping both hands on the steering wheel, release the brake pedal and gradually push the accelerator toward the floor to begin driving. 11. Drive slowly. Practice maneuvering and using the accelerator and brakes on level surfaces. 12. Do not carry a passenger until
  • 2010 Polaris Ranger EV | Owners Manual - Page 45
    Driving On Slippery Surfaces WARNING OPERATION Skidding or sliding can cause loss of control or overturn (if tires regain traction unexpectedly). When operating on slippery surfaces such as ice or loose gravel, reduce speed and use extra caution to reduce the chance of skidding or sliding out of
  • 2010 Polaris Ranger EV | Owners Manual - Page 46
    OPERATION Driving Uphill Whenever traveling uphill, follow these precautions: 1. Always travel straight uphill. 2. Avoid steep hills (15° maximum). 3. Keep both feet on the floor. 4. Always check the terrain carefully before ascending any hill. 5. Never climb hills 15° maximum with excessively
  • 2010 Polaris Ranger EV | Owners Manual - Page 47
    Driving on a Sidehill (Sidehilling) OPERATION Driving on a sidehill is not recommended. Improper procedure could cause loss of control or overturn. Avoid crossing the side of any hill unless absolutely necessary. If crossing a sidehill is unavoidable, follow these precautions: 1. Slow down. 2.
  • 2010 Polaris Ranger EV | Owners Manual - Page 48
    OPERATION Driving Through Water Your Polaris vehicle can operate through water up to a maximum recommended depth equal to the floorboards. NOTICE: Serious damage can occur to the electrical system and batteries if the vehicle is operated in water deeper than the floorboards. Follow these
  • 2010 Polaris Ranger EV | Owners Manual - Page 49
    Driving Over Obstacles OPERATION Follow these precautions when operating over obstacles: 1. Always check for obstacles before operating in a new area. 2. Look ahead and learn to read the terrain. Be constantly alert for hazards such as logs, rocks and low hanging branches. 3. Travel slowly and use
  • 2010 Polaris Ranger EV | Owners Manual - Page 50
    OPERATION Driving in Reverse Follow these precautions when operating in reverse: 1. Always check for obstacles or people behind the vehicle. Always inspect left and right fields of vision before backing. 2. Always avoid backing downhill. 3. Back slowly. 4. Apply the brakes lightly for stopping. 5.
  • 2010 Polaris Ranger EV | Owners Manual - Page 51
    Parking on an Incline OPERATION 15° maximum Avoid parking on an incline if possible. If it's unavoidable, follow these precautions: 1. Apply the brakes. 2. Set the park brake. 3. Place the direction selector in neutral. 4. Turn the key off. 5. Block the rear wheels on the downhill side. 47
  • 2010 Polaris Ranger EV | Owners Manual - Page 52
    with extra caution. Always attach the tow load to the hitch point designated for your vehicle. HEAVY LOADS CAN CAUSE BRAKING AND CONTROL PROBLEMS. Use extreme caution when applying brakes with a loaded vehicle. Avoid terrain or situations that may require backing downhill. USE EXTREME CAUTION when
  • 2010 Polaris Ranger EV | Owners Manual - Page 53
    Hauling Cargo OPERATION The RANGER has been designed to carry or tow specific capacities. Always read and understand the load distribution warnings listed on the warning labels. Move the drive mode switch to low mode if needed. See page 28. The total load (operator, passenger, accessories, cargo
  • 2010 Polaris Ranger EV | Owners Manual - Page 54
    OPERATION Dumping the Cargo Box 1. Select a level site to dump the cargo box. Do not attempt to dump or unload the vehicle while parked on an incline. 2. Apply the brakes. 3. Set the park brake. 4. Place the direction selector in neutral. 5. Turn the key off. 6. Dismount the vehicle. 7. Ensure that
  • 2010 Polaris Ranger EV | Owners Manual - Page 55
    Towing Loads OPERATION Towing improperly can alter vehicle handling and may cause loss of control or brake instability. Always follow these precautions when towing: 1. Never load more than 150 lbs. (68.1 kg) tongue weight on the towing bracket. 2. Do not operate the vehicle faster than 10 mph (16
  • 2010 Polaris Ranger EV | Owners Manual - Page 56
    OPERATION Parking the Vehicle 1. Apply the brakes. Stop the vehicle on a level surface. 2. When parking inside a garage or other structure, be sure that the structure is well ventilated and that the vehicle is not close to any source of flame or sparks, including any appliance with pilot lights. 3.
  • 2010 Polaris Ranger EV | Owners Manual - Page 57
    Transporting the RANGER OPERATION When transporting the RANGER for a long distance or on public streets, always use a trailer with an approved load rating greater than the RANGER's curb vehicle weight of 1700 lbs. (771 kg) plus any installed accessories or cargo. Follow these guidelines when
  • 2010 Polaris Ranger EV | Owners Manual - Page 58
    OPERATION All Wheel Drive (AWD) Press the top of the rocker switch to engage All Wheel Drive (AWD). Once enabled, the AWD remains enabled until the switch is turned off. The AWD switch may be turned on or off while the vehicle is moving. When the AWD switch is on, the front gearcase will
  • 2010 Polaris Ranger EV | Owners Manual - Page 59
    for at least 10 feet (3 m). 3. Stop completely. 4. Move the direction selector to forward and drive forward. 5. If the front gearcase remains locked after following these instructions, return the vehicle to your dealer for service. 55
  • 2010 Polaris Ranger EV | Owners Manual - Page 60
    riding conditions and an average vehicle speed of approximately ten (10) miles per hour. Vehicles subjected to severe use must be inspected and serviced more frequently. Severe Use Definition • Frequent immersion in mud, water or sand • Racing or race-style high RPM use • Prolonged low speed, heavy
  • 2010 Polaris Ranger EV | Owners Manual - Page 61
    Periodic Maintenance Chart Item Maintenance Interval (whichever comes first) Hours Calendar Q Steering MAINTENANCE Perform all services at whichever maintenance interval is reached first. Remarks Miles (Km) Check operation; apply dielectric grease if replacing Inspect periodically Inspect and
  • 2010 Polaris Ranger EV | Owners Manual - Page 62
    MAINTENANCE Lubrication Recommendations Check and lubricate all components at the intervals outlined in the Periodic Maintenance Chart beginning on page 56, or more often under severe use, such as wet or dusty conditions. Items not listed in the chart should be lubricated at the general lubrication
  • 2010 Polaris Ranger EV | Owners Manual - Page 63
    Gearcases Gearcase Specification Chart Gearcase Main Gearcase (Transaxle) Front Gearcase MAINTENANCE Lubricant Capacity 20.3 oz. (600 ml) 5.1 oz. (150 ml) Fill Plug Torque 14 ft. lbs. (19.4 Nm) 8-10 ft. lbs. (11-13.6 Nm Drain Plug Torque 14 ft. lbs. (19.4 Nm) 11 ft. lbs. (15 Nm) Premium ATV
  • 2010 Polaris Ranger EV | Owners Manual - Page 64
    MAINTENANCE Gearcases Main Gearcase (Transaxle) Oil Change The drain plug is located on the lower right side of the main gearcase, near the fill plug. Refer to the Gearcase Specifications Chart on page 59 for recommended lubricants, capacities and torque specifications. 1. Remove the fill plug. 2.
  • 2010 Polaris Ranger EV | Owners Manual - Page 65
    Gearcases Front Gearcase MAINTENANCE Always check and change the front gearcase oil at the intervals outlined in the Periodic Maintenance Chart beginning on page 56. Maintain the oil level even with the bottom thread of the fill plug hole. Refer to the Gearcase Specifications Chart on page 59 for
  • 2010 Polaris Ranger EV | Owners Manual - Page 66
    MAINTENANCE Gearcases Front Gearcase Oil Change 1. Support the vehicle securely with a jackstand. 2. Remove the front tire on the driver's side. 3. Remove the fill plug. 4. Place a drain pan under the drain plug on
  • 2010 Polaris Ranger EV | Owners Manual - Page 67
    Brakes Brake Fluid MAINTENANCE The front and rear brakes are hydraulic disc type brakes. Press down on the brake pedal to engage the brakes. See page 35. Inspect the brake system routinely. Inspect the level of the brake fluid before each operation. WARNING! After opening a bottle of brake fluid,
  • 2010 Polaris Ranger EV | Owners Manual - Page 68
    MAINTENANCE Brakes Brake Inspection 1. Check the brake system for fluid leaks. 2. Check the brake pedal for excessive travel or a spongy feel. 3. Check the friction pads for wear, damage and looseness. 4. Inspect the brake disc spline and pad wear surface for excessive wear. 5. Change pads when worn
  • 2010 Polaris Ranger EV | Owners Manual - Page 69
    Steering Wheel Inspection MAINTENANCE Check the steering wheel for specified freeplay and smooth operation at the intervals outlined in the Periodic Maintenance Chart beginning on page 56. 1. Position the vehicle on a level surface. 2. Lightly turn the steering wheel left and right. There should
  • 2010 Polaris Ranger EV | Owners Manual - Page 70
    Always follow all tire maintenance procedures as outlined in this manual and on the labels on the vehicle. Always use original the following items occasionally for tightness, and if they've been loosened for maintenance service. Do not lubricate the stud or the lug nut. Nut Type Lug Nut Location
  • 2010 Polaris Ranger EV | Owners Manual - Page 71
    tire wear and vehicle handling, which can result in serious injury or death. Always ensure that all nuts are torqued to specification. Do not service axle nuts that have a cotter pin installed. See your Polaris dealer. 3. Attach the wheel nuts and washers and finger tighten. 4. Carefully lower the
  • 2010 Polaris Ranger EV | Owners Manual - Page 72
    shorten the life of the lamp. Headlight Lamp Replacement 1. Open the hood. CAUTION! Hot components can cause burns to skin. Allow lamps to cool before servicing. Wiring Harness 2. Unplug the headlamp from the wiring harness. Be sure to pull on the connector, not on the wiring. 3. Turn the lamp
  • 2010 Polaris Ranger EV | Owners Manual - Page 73
    Lights Headlight Beam Adjustment MAINTENANCE X X 8" (20 cm) 25 ft. (7.6 m) 1. Place the vehicle on a level surface with the headlight approximately 25 ft. (7.6 m) from a wall. 2. Measure the distance from the floor to the center of the headlight and make a mark on the wall at the same height.
  • 2010 Polaris Ranger EV | Owners Manual - Page 74
    MAINTENANCE Lights Brake Lights When the brake pedal is depressed, the console brake light comes on. Check the brake light before each ride. 1. Turn the key to the ON position. 2. Depress the brake pedal. The brake light should come on after about 10mm (0.4 in.) of pedal travel. If the light doesn't
  • 2010 Polaris Ranger EV | Owners Manual - Page 75
    Batteries WARNING MAINTENANCE Battery posts, terminals and related components contain lead and lead compounds, chemicals known to cause cancer and reproductive harm. Always wash your hands after touching or handling the batteries. WARNING Charging a damaged battery can result in serious injury.
  • 2010 Polaris Ranger EV | Owners Manual - Page 76
    MAINTENANCE Batteries Battery Charging When not in use, park the vehicle and connect the battery charger. The vehicle's charging cord is located inside the glove box. WARNING! Failure to provide adequate ventilation while charging batteries can result in an explosion. Hydrogen gas is emitted during
  • 2010 Polaris Ranger EV | Owners Manual - Page 77
    tap water to enter the batteries. Battery Replacement With proper care and maintenance as outlined in this owner's manual, battery life could be extended up to four years or longer, depending on the amount of use. batteries or battery cables. Always see your dealer for battery-related service. 73
  • 2010 Polaris Ranger EV | Owners Manual - Page 78
    MAINTENANCE Batteries Battery Fluid A poorly maintained battery will deteriorate rapidly. Check the battery fluid level often. Add only distilled water. Tap water contains minerals that are harmful to a battery. Unless the plates are exposed before charging, distilled water should be added to a
  • 2010 Polaris Ranger EV | Owners Manual - Page 79
    Cleaning and Storage Washing the Vehicle MAINTENANCE Keeping your Polaris vehicle clean will not only improve its appearance but it can also extend the life of various components. NOTICE: High water pressure may damage components. Polaris recommends washing the vehicle by hand or with a garden
  • 2010 Polaris Ranger EV | Owners Manual - Page 80
    the Vehicle Polaris recommends the use of common household aerosol furniture polish for polishing the finish on your Polaris vehicle. Follow the instructions on the container. Polishing Tips • Avoid the use of automotive products, some of which can scratch the finish of your vehicle. • Always
  • 2010 Polaris Ranger EV | Owners Manual - Page 81
    and liberally apply a weather resistant wax to each polished chrome wheel. Choose a product suitable for chrome finishes. Read and follow the product labels and instructions. Removing Corrosion If light rust is found on the chrome finish, use steel wool (#0000-OTT grade) to remove it. Gently rub the
  • 2010 Polaris Ranger EV | Owners Manual - Page 82
    MAINTENANCE Storage Tips Cleaning and Storage Clean the Exterior Make any necessary repairs and clean the vehicle as recommended. See page 75. Inspect and Lubricate Inspect all cables and lubricate all areas of the vehicle as recommended in the Periodic Maintenance Chart beginning on page 56.
  • 2010 Polaris Ranger EV | Owners Manual - Page 83
    Storing the Vehicle MAINTENANCE Any time the vehicle will be parked for more than a few hours, follow the recommended storage procedures: 1. Make any necessary repairs and clean the vehicle. See page 75. 2. Clean the batteries. See page 73. 3. Store the vehicle out of the sun in a cool, dry place.
  • 2010 Polaris Ranger EV | Owners Manual - Page 84
    SPECIFICATIONS RANGER EV Dimensions Dry Weight Ground Clearance Length Width Height Wheelbase Turning Radius Box Dimensions (Inside) Box Capacity Payload Capacity Hitch Towing Capacity Cargo System Seating Skid Plate Motor configuration Motor peak Controller Battery pack Maximum speed Range (in Max
  • 2010 Polaris Ranger EV | Owners Manual - Page 85
    SPECIFICATIONS RANGER EV Brake System Brakes Park Brake 4-Wheel hydraulic disc w/dual bore front calipers Dash-mounted lever-activated mechanical park brake Suspension Front suspension Rear suspension Tires Tire pressure Cup holders Indicator panel Charge indicator Hour meter Auxiliary power Rider
  • 2010 Polaris Ranger EV | Owners Manual - Page 86
    POLARIS PRODUCTS Part Number 2871653 2872276 2877922 2877923 2871312 2871322 2871423 2871515 2871551 2871329 2872189 Description Gearcase Lubricants Premium ATV Angle Drive Fluid (8 oz./237 ml) Premium ATV Angle Drive Fluid (2.5 gal./9.5 l) Demand Drive Plus Fluid (qt./.95 l) Demand Drive Plus
  • 2010 Polaris Ranger EV | Owners Manual - Page 87
    TROUBLESHOOTING Vehicle Will Not Operate Possible Cause Low battery voltage Loose battery connections Loose contactor connections Loose electronic control box connections Solution Recharge the battery overnight
  • 2010 Polaris Ranger EV | Owners Manual - Page 88
    the Polaris RANGER against defects in material or workmanship. Polaris also supports a one year limited supplier warranty covering defects in material or workmanship set-up of your vehicle is very important in ensuring trouble-free operation. Purchasing a machine in the crate or without proper dealer
  • 2010 Polaris Ranger EV | Owners Manual - Page 89
    for purposes other than for which it was manufactured, or for any damages which occur during trailer transit or as a result of unauthorized service or the use of unauthorized parts. In addition, this warranty does not cover physical damage to paint or finish, stress cracks, tearing or puncturing
  • 2010 Polaris Ranger EV | Owners Manual - Page 90
    WARRANTY LIMITATIONS OF WARRANTIES AND REMEDIES Warranty applies to the product only and does not allow for coverage of personal loss. Some items are considered "consumable," meaning they are considered part of normal maintenance or part of completing an effective repair. The following items are
  • 2010 Polaris Ranger EV | Owners Manual - Page 91
    WARRANTY LIMITATIONS OF WARRANTIES AND REMEDIES This warranty does not cover the use of unauthorized lubricants, chemicals, or fuels that are not compatible with the vehicle. The exclusive remedy for breach of this warranty shall be, at Polaris' exclusive option, repair or replacement of any
  • 2010 Polaris Ranger EV | Owners Manual - Page 92
    use of non-recommended lubricants may not be covered by warranty. Exported Vehicles EXCEPT WHERE SPECIFICALLY REQUIRED BY LAW, THERE IS NO WARRANTY OR SERVICE BULLETIN COVERAGE ON THIS VEHICLE IF IT IS SOLD OUTSIDE THE COUNTRY OF THE SELLING DEALER'S AUTHORIZED LOCATION. This policy does not apply
  • 2010 Polaris Ranger EV | Owners Manual - Page 93
    must be done by an authorized Polaris dealer. If you move or are traveling within the country where your vehicle was purchased, Warranty or Service Bulletin repairs may be requested from any authorized Polaris dealer who sells the same line as your vehicle. Outside the Country where your vehicle
  • 2010 Polaris Ranger EV | Owners Manual - Page 94
    MAINTENANCE LOG Use the following chart to record periodic maintenance. DATE MILES (KM) OR HOURS TECHNICIAN SERVICE PERFORMED / COMMENTS 90
  • 2010 Polaris Ranger EV | Owners Manual - Page 95
    MAINTENANCE LOG DATE MILES (KM) OR HOURS TECHNICIAN SERVICE PERFORMED / COMMENTS 91
  • 2010 Polaris Ranger EV | Owners Manual - Page 96
    INDEX A Accelerator Pedal...35 All Wheel Drive ...54-55 Disengaging AWD...55 Locking the Differential ...54 Auxiliary 12-Volt Terminal Board . 25 Auxiliary Outlets ...25 AWD ...54-55 AWD Switch ...29 Axle Nut Torque ...66 D Differential Locking ...54 Direction Selector ...29 Discharge Indicator ...
  • 2010 Polaris Ranger EV | Owners Manual - Page 97
    INDEX H Hauling Cargo...48-49 Headlight Beam Adjustment...69 Headlight Lamp Replacement ...68 Headlight Switch...29 Hitch Bracket ...23 Hitch Weight...51 Hour Meter ...25 O Obstacles...45 Oil Change Front Gearcase ...62 Main Gearcase ...60 Transaxle...60 Oil Level Front Gearcase ...61 Main Gearcase
  • 2010 Polaris Ranger EV | Owners Manual - Page 98
    ...67 Wheel Removal ...67 Towing Loads ...51 Towing Speed ...51 Towing the Vehicle ...52 Trailer Hitch Bracket ...23 Transaxle ...59-60 Transporting the RANGER ...53 Troubleshooting Vehicle Will Not Operate ...83 Charge Status Indicator ...31 Malfunction Indicator ...31 94
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
  • 53
  • 54
  • 55
  • 56
  • 57
  • 58
  • 59
  • 60
  • 61
  • 62
  • 63
  • 64
  • 65
  • 66
  • 67
  • 68
  • 69
  • 70
  • 71
  • 72
  • 73
  • 74
  • 75
  • 76
  • 77
  • 78
  • 79
  • 80
  • 81
  • 82
  • 83
  • 84
  • 85
  • 86
  • 87
  • 88
  • 89
  • 90
  • 91
  • 92
  • 93
  • 94
  • 95
  • 96
  • 97
  • 98