2008 Suzuki Grand Vitara Owner's Manual
2008 Suzuki Grand Vitara Manual
2008 Suzuki Grand Vitara manual content summary:
- 2008 Suzuki Grand Vitara | Owner's Manual - Page 1
2008 OWNER'S MANUAL Keep With Vehicle At All Times. Contains Important Information On Safety, Operation & Maintenance. Part No. 99011-66J22-03E July, 2007 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 2
This owner's manual applies to the GRAND VITARA series: 66J001 NOTE: The illustrated model is one of the GRAND VITARA series. © COPYRIGHT SUZUKI MOTOR CORPORATION 2007 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 3
to familiarize yourself with this important information. When planning the regular scheduled maintenance of your SUZUKI, we recommend you visit your local SUZUKI dealership. Their factory-trained technicians will provide the best possible service and use only genuine SUZUKI parts and accessories. - 2008 Suzuki Grand Vitara | Owner's Manual - Page 4
SERVICE STATION GUIDE 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. Fuel (see section 1) Engine hood (see section 5) Tire changing tools (see section 5) Engine oil dipstick (see section 9) Automatic transmission fluid dipstick (see section 9) Engine coolant (see section 9) Windshield washer fluid ( - 2008 Suzuki Grand Vitara | Owner's Manual - Page 5
AND EQUIPMENT OPERATING YOUR VEHICLE DRIVING TIPS VEHICLE LOADING AND TOWING INSPECTION AND MAINTENANCE EMERGENCY SERVICE APPEARANCE CARE GENERAL INFORMATION FUSES AND PROTECTED CIRCUITS SPECIFICATIONS INDEX 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 WARNING Engine exhaust, some of its constituents, and - 2008 Suzuki Grand Vitara | Owner's Manual - Page 6
by your SUZUKI dealer. 1. Air bag warning labels (on both sun visors) 2. Rollover warning label 3. Passenger seat belt warning label 4. Jacking warning label 5. Jacking warning label 6. Fuel filler cap message 7. Transfer switch warning label 8. Brake fluid cap message 9. Engine cooling fan - 2008 Suzuki Grand Vitara | Owner's Manual - Page 7
, as appropriate, used motor oil, coolant, and other fluids, batteries and tires. IF YOU HAVE ANY PROBLEMS WITH YOUR SUZUKI: Please review the New Vehicle Warranty Information booklet supplied with your SUZUKI. Should you have a question or problem regarding the warranty or service of your vehicle - 2008 Suzuki Grand Vitara | Owner's Manual - Page 8
could result in death or injury. 75F135 CAUTION Indicates a potential hazard that could result in vehicle damage. NOTE: Indicates special information to make maintenance easier or instructions clearer. The circle with a slash in this manual means "Don't do this" or "Don't let this happen". 0-2 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 9
such as cellular telephones or CB (Citizen's Band) radios may cause electronic interference with your vehicle's ignition system, resulting in vehicle performance problems. Consult your SUZUKI dealer or qualified service technician for advice on installing such mobile communication equipment. 0-3 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 10
MEMO 0-4 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 11
FUEL RECOMMENDATION FUEL RECOMMENDATION Fuel Recommendation ...1-1 1 65D394 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 12
more than 5% methanol under any circumstances. Fuel system damage or vehicle performance problems resulting from the use of such fuels are not the responsibility of SUZUKI and may not be covered under the New Vehicle Limited Warranty. Fuel Pump Labeling In some states, pumps that dispense - 2008 Suzuki Grand Vitara | Owner's Manual - Page 13
BEFORE DRIVING BEFORE DRIVING Keys ...2-1 Spare Tire Nut Lock (if equipped) ...2-1 2 Door Locks ...2-2 Windows ...2-14 Mirrors ...2-16 Seat Adjustment ...2-17 Head Restraints ...2-19 Seat Belts and Child Restraint Systems ...2-20 Supplemental Restraint System (air bags) ...2-37 60G404 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 14
BEFORE DRIVING Keys EXAMPLE Ignition Key Reminder A buzzer sounds intermittently to remind you to remove the ignition key if it is in the ignition switch when the driver's door is opened. Spare Tire Nut Lock (if equipped) To UNLOCK To LOCK 54G489 Your vehicle comes with a pair of identical - 2008 Suzuki Grand Vitara | Owner's Manual - Page 15
key and turn the top of the key toward the rear of the vehicle. UNLOCK LOCK Power Door Locking System (if equipped) UNLOCK LOCK Rear Side Door Locks Front UNLOCK LOCK 64J002 64J003 Rear To lock a door from inside the vehicle, turn the lock knob forward. Turn the lock knob rearward to unlock the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 16
BEFORE DRIVING Driver's side (when using the power door locking switch) To lock or unlock all the doors simultaneously, depress the front or rear of the switch respectively. NOTE: • If your vehicle is equipped with the keyless entry system, you can also lock or unlock all doors by operating the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 17
switch or insert the key during this time, the light will start to fade out immediately. Be sure the doors are locked after you operate the "LOCK" button. If no door is opened within about 30 seconds after the "UNLOCK" button is operated, the doors will automatically lock again. NOTE: • The maximum - 2008 Suzuki Grand Vitara | Owner's Manual - Page 18
(1) on the door handle of the driver's door, front passenger's door or tailgate. To lock all doors when all doors are unlocked: • Push the request switch on one of the door handles once. The turn signal lights will flash once when the doors are locked. To unlock a door or all doors: • Push the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 19
the doors or start the engine. • Be sure that the driver always carries the remote controller. • If you lose one of the remote controllers, ask your SUZUKI NOTE: The keyless start system may not function correctly in certain environments or under certain operating conditions such as the following: - 2008 Suzuki Grand Vitara | Owner's Manual - Page 20
remote controller: EXAMPLE 66J022 If the remote controller is not in the vehicle under the following conditions, a buzzer sounds intermittently for about 2 seconds and the keyless start system indicator light on the instrument cluster blinks in red: • When the vehicle speed is over 10 km/h (6 mph - 2008 Suzuki Grand Vitara | Owner's Manual - Page 21
DRIVING CAUTION The transmitter/remote controller is a sensitive electronic instrument. To avoid damaging it, do not expose it to dust or moisture or tamper with internal parts time. • To purchase new remote controllers, see your SUZUKI firmly. 4) Make sure the door locks can be operated with the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 22
unlock position. 2. Repeat step 1 two more times. 3. Push the power door locking switch of the driver's door to the lock position. 4. Remove the key from the ignition switch and then insert it again. 5. Repeat step 4 three more times. 6. To start the engine, turn the ignition switch to the "START - 2008 Suzuki Grand Vitara | Owner's Manual - Page 23
BEFORE DRIVING less entry system operate properly by operating each remote controller. 1. For USA This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: 1) This device may not cause harmful interference, and 2) This device must accept any - 2008 Suzuki Grand Vitara | Owner's Manual - Page 24
DRIVING and taillights will blink for about 30 seconds. Also, the horn will sound intermittently for about 30 seconds at the same time. To cancel the "PANIC" mode the transmitter. 3) Close the transmitter firmly. 4) Make sure the door locks can be operated with the transmitter. 5) Dispose of the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 25
DRIVING CAUTION The transmitter/remote controller is a sensitive electronic instrument. To avoid damaging it, do not expose it to dust or moisture or tamper with internal parts transmitters, see your SUZUKI dealer. • Before you begin and release the driver's door switch (1) 3 times, insert the key, and - 2008 Suzuki Grand Vitara | Owner's Manual - Page 26
DRIVING times, system operates properly by operating each transmitter. 1. For USA This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions Canada technical specifications were met. Child Lock System (rear doors) (2) (1) 64J009 Each of the rear doors - 2008 Suzuki Grand Vitara | Owner's Manual - Page 27
The power windows can only be operated when the ignition switch is in the "ON" position. The driver's door has switches (1), (2), (4), (5), to operate the driver's window, the front passenger's window, the rear left window and right window, respectively. 3) Remove the cap (1) by hand. 4) Break the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 28
The passenger's door has a switch (3) to operate the passenger's window. To open a window, push the top part of the switch and to close the window lift up the top part of the switch. The driver's window has an "auto-down" feature for added convenience (at toll booths or drive-through restaurants - 2008 Suzuki Grand Vitara | Owner's Manual - Page 29
by the window. NOTE: If you drive with one of the rear windows open, you may hear a loud sound caused by air vibration. To reduce the sound, open the driver's or front passenger's window, or narrow the rear window opening. Mirrors Inside Rearview Mirror WARNING • Always adjust the mirror with the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 30
than when seen in a flat mirror. The switch to control the power rearview mirrors is located on the driver's door panel. You can adjust the mirrors when the ignition switch is in the "ACC" or "ON" position. To adjust the mirrors: 1) Move the selector switch to the left or right to select the mirror - 2008 Suzuki Grand Vitara | Owner's Manual - Page 31
position when driving, or seat belt effectiveness may be reduced. Seat belts are designed to offer maximum protection when seatbacks are in the upright position. Front seat 64J017 64J016 The adjustment lever for each front seat is located under the front of the seat. To adjust the seat position - 2008 Suzuki Grand Vitara | Owner's Manual - Page 32
BEFORE DRIVING Rear seat Head Restraints Front EXAMPLE (1) 64J019 To adjust the seatback angle of the rear seats: 1) Pull up the lever on the top of a split folding seat. 2) Move the seatback to one of the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 33
BEFORE DRIVING 1) Insert a sharp-pointed tool into the small hole (2). Push the tip into the seat belts at all times, whether or not an air bag is mounted at their seating position, to minimize the risk of severe injury or death in the event of a crash. When installing a child restraint system, - 2008 Suzuki Grand Vitara | Owner's Manual - Page 34
be adjusted as tightly as is comfortable to provide the protection for which they have been designed. A slack belt will provide less protection than one which is snug. (Continued) WARNING (Continued) • Pregnant women should use seat belts, although specific recommendations about driving should - 2008 Suzuki Grand Vitara | Owner's Manual - Page 35
system you purchase meets Federal Motor Vehicle Safety Standards. Read and follow all the directions provided by the manufacturer. • Avoid contamination of seat belt webbing by polishes, oils an upright position when driving, or seat belt effectiveness may be reduced. Seat belts are designed to offer - 2008 Suzuki Grand Vitara | Owner's Manual - Page 36
plate attached to the seat belt across your body and press it into the buckle until you hear a "click". 60A040 To reduce the risk of sliding under the belt during a collision, position the lap portion of the belt across your lap as low on your hips as possible and adjust it to a snug fit 2-23 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 37
BEFORE DRIVING Seat Belt Reminder Driver's seat belt reminder light EXAMPLE 52D249 60A039 NOTE: The word "CENTER" is molded into the buckle for the rear seat center belt. The buckles are designed so a latch plate can not be inserted into the wrong buckle. To unfasten the belt, push the red " - 2008 Suzuki Grand Vitara | Owner's Manual - Page 38
BEFORE DRIVING When the driver and front passenger don't buckle their seat belts, the driver's seat belt reminder light in the instrument cluster and the front passenger's seat belt reminder light in the center of the instrument panel will come on and a buzzer will sound as a reminder to the driver - 2008 Suzuki Grand Vitara | Owner's Manual - Page 39
BEFORE DRIVING Driver's seat belt reminder If the driver's seat belt remains unbuckled with the ignition key in the "ON" position, the driver's seat belt reminder works as follows: 1) The driver's seat belt reminder light will come on for about 20 seconds when the ignition key is turned to the "ON" - 2008 Suzuki Grand Vitara | Owner's Manual - Page 40
properly, it is damaged in any way or the seat belt pretensioners were activated (that is, if the front air bags were activated). Infant restraint - rear seat only Child Restraint Systems 65D209 60G332 Periodically inspect the seat belts to make sure they work properly and are not damaged - 2008 Suzuki Grand Vitara | Owner's Manual - Page 41
's seat, be sure to move the front passenger's seat as far back as possible. WARNING Children could be endangered in a crash if their child restraints are not properly secured in the vehicle. When installing a child restraint system, be sure to follow the instructions below. Be sure to secure the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 42
the methods to secure the child restraint system with the ELR lapshoulder belt and with the A-ELR lapshoulder belt are different. 65D607 65D608 WARNING Do not install a rear-facing child restraint in the front passenger's seat. If the passenger's air bag inflates, a child in a rear-facing child - 2008 Suzuki Grand Vitara | Owner's Manual - Page 43
Install your child restraint system according to the instructions provided by the child restraint system manufacturer. If you install the child restraint system in the front seat, be sure to slide the seat to the rearmost position. After making sure that the seat belt is securely latched: 1) Pull - 2008 Suzuki Grand Vitara | Owner's Manual - Page 44
DRIVING A-ELR type A-ELR type A-ELR type EXAMPLE EXAMPLE EXAMPLE Move to check 83E032 83E036 65D234 2) Allow the extra webbing to retract, and pull the webbing toward the retractor to take up any slack. Make sure that the lap portion of the belt is tight around the child restraint system - 2008 Suzuki Grand Vitara | Owner's Manual - Page 45
BEFORE DRIVING To revert from ALR to ELR Installation with the LATCH System EXAMPLE and Tethers for Children.) The anchors are located where the rear of the seat cushion meets the bottom of the seatback. Install a LATCH-type child restraint system according to the instructions provided by the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 46
DRIVING EXAMPLE owner's manual. Attach the top tether strap, if applicable. If your LATCH restraint has rigid lower connecting bars, these general instructions is securely fastened by trying to move the child restraint system in all directions, especially forward. WARNING The seatback should - 2008 Suzuki Grand Vitara | Owner's Manual - Page 47
does not require a top strap. 3) Hook the top strap to the anchor bracket and tighten the top strap according to the instructions provided by the child restraint system manufacturer. Be sure to attach the top strap to the corresponding anchor located directly behind the child restraint. Do 2-34 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 48
enough, see your authorized SUZUKI dealer for a seat belt extender. Seat belt extenders are available for each seating position except for the rear center position. After inspecting the relationship between the seat belt length, the occupant's body size, and the seat adjustment (the driver's seat - 2008 Suzuki Grand Vitara | Owner's Manual - Page 49
waist. Please refer to the "Seat Adjustment" section and the instructions and precautions about the seat belts WARNING This section of the owner's manual describes your SUZUKI's SEAT BELT PRETENSIONER SYSTEM. Please read and follow ALL these instructions carefully to minimize your risk of severe - 2008 Suzuki Grand Vitara | Owner's Manual - Page 50
be activated only once. If the pretensioners are activated (that is, if the front air bags are activated), have the pretensioner system serviced by an authorized SUZUKI dealer as soon as possible. If the "AIR BAG" light on the instrument cluster does not blink or come on briefly when the ignition - 2008 Suzuki Grand Vitara | Owner's Manual - Page 51
DRIVING 9 7 1 2 10 4 6 8 5 66J132 11 8 3 Your vehicle is equipped with a Supplemental Restraint System consisting of the following components in addition to a lapshoulder belt at each front seating position. 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. Driver's front air bag Front passenger's front air - 2008 Suzuki Grand Vitara | Owner's Manual - Page 52
properly. Have the air bag system inspected by an authorized SUZUKI dealer as soon as possible. 63J259 EXAMPLE 60G032 Front air bags are designed to inflate only in severe frontal collisions. 64J032 The driver's front air bag is located behind the center pad of the steering wheel. The words - 2008 Suzuki Grand Vitara | Owner's Manual - Page 53
has "dual stage" front air bags, which adjust the air bag inflation force according to crash severity. Also, your vehicle has a front passenger sensing system, which turns off the front passenger's air bag and seat belt pretensioner under certain conditions. 62J114 Front air bags will probably not - 2008 Suzuki Grand Vitara | Owner's Manual - Page 54
bag deploys only one time during an accident, seat belts are needed to restrain occupants from further movements during the accident. Therefore, an air bag is NOT a substitute for seat belts. To maximize your protection, ALWAYS WEAR YOUR SEAT BELTS. Be aware that no system can prevent all possible - 2008 Suzuki Grand Vitara | Owner's Manual - Page 55
in the event of a crash. The front passenger sensing system will turn off the front passenger's front air bag and seat belt pretensioner under certain conditions. This system works using a sensor mat that is part of the front passenger's seat. The front passenger sensing system is designed to detect - 2008 Suzuki Grand Vitara | Owner's Manual - Page 56
BEFORE DRIVING bag will not deploy and the seat belt pretensioner will not operate. If you have secured a child in the front passenger seat in a forward-facing child restraint system or booster seat and the "PASS AIR BAG OFF" indicator light is not on, turn the vehicle off, remove the child - 2008 Suzuki Grand Vitara | Owner's Manual - Page 57
BEFORE DRIVING When using a seat belt extender, follow the instructions in the "Seat Belt Extender" section. How the System Works WARNING • Do not spill any liquids on the seat. Liquids can damage the sensors under the front seat. • Have front passenger's sensor mat inspected by your dealer after a - 2008 Suzuki Grand Vitara | Owner's Manual - Page 58
sit up straight; do not lean over the steering wheel or dashboard. Front occupants should not lean on or sleep against the door. Please refer to the "Seat Adjustment" section and the "Seat Belts and Child Restraint Systems" section in the "BEFORE DRIVING" section for details on proper seat and seat - 2008 Suzuki Grand Vitara | Owner's Manual - Page 59
the air bag system if the air bags deploy in a crash. The module records information about overall system status, which sensors activated the deployment, and whether the front seat belts were in use. If the air bags inflate, have the air bags and related components replaced by an authorized SUZUKI - 2008 Suzuki Grand Vitara | Owner's Manual - Page 60
BEFORE DRIVING MEMO 2-47 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 61
COLUMN CONTROLS Ignition Switch ...3-1 Lighting/Turn Signal Control Lever ...3-5 Windshield Wiper and Washer Lever ...3-8 Rear Window Wiper/Washer Switch ...3-9 3 Tilt Steering Lock Lever ...3-10 Cruise Control (if equipped) ...3-10 Remote Audio Controls (if equipped) ...3-12 Horn ...3-12 60G405 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 62
COLUMN CONTROLS Ignition Switch Vehicle Without Keyless Start System EXAMPLE Manual transmission Push Turn to "LOCK" 65D611 60A055 WARNING To avoid possible injury, do not operate controls by reaching through the steering wheel. 60B041 The ignition switch has the following four positions - 2008 Suzuki Grand Vitara | Owner's Manual - Page 63
STEERING COLUMN CONTROLS ACC Accessories such as the radio can operate, but the engine is off. ON This is the normal operating position. All electrical systems are on. START This is the position for starting the engine using the starter motor. The key should be released from this position as soon as - 2008 Suzuki Grand Vitara | Owner's Manual - Page 64
the steering wheel slightly to the right or left while turning the switch. NOTE: You must push the ignition switch in to turn it to the "ACC" position. Also you must push the ignition switch in to return it to the "LOCK" position. ACC (2) Accessories such as the radio can operate, but the engine - 2008 Suzuki Grand Vitara | Owner's Manual - Page 65
. (1) CAUTION • Do not turn the starter motor for more than 15 seconds at a time. If the engine does not start, wait 15 seconds before trying again. If the engine does not start after several attempts, check the fuel and ignition systems or consult your SUZUKI dealer. • Do not leave the ignition - 2008 Suzuki Grand Vitara | Owner's Manual - Page 66
STEERING COLUMN CONTROLS Lighting/Turn Signal Control Lever E/G: Engine IG: Ignition switch ON: Lights ON LIGHT: When it is light around the light sensor (5). DARK: When it is dark around the light sensor (5). Lighting switch position IG OFF Main lights to be operated D.R.L. (1) OFF Parking lights - 2008 Suzuki Grand Vitara | Owner's Manual - Page 67
on the steering column, when the following four conditions are all met. Conditions for Auto-on headlight system operation: 1) It is dark around the light sensor (5). 2) The lighting control lever in the "AUTO" position. 3) The ignition switch is in the "ON" position. 4) The parking brake is released - 2008 Suzuki Grand Vitara | Owner's Manual - Page 68
are dimmer than the low beam, when the following three conditions are all met. Also, the D.R.L. indicator light on the instrument panel comes on. Conditions for D.R.L. system operation: 1) The engine is running. 2) The parking brake is released. 3) The lighting switch is in either the "OFF" or the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 69
STEERING COLUMN CONTROLS Windshield Wiper and Washer Lever Windshield Wipers EXAMPLE MIST OFF INT LO Windshield Washer EXAMPLE EXAMPLE 63J284 HI 63J283 If the lever is equipped with the "INT TIME" control, turn the control forward or rearward to adjust for driving in mist or light rain. - 2008 Suzuki Grand Vitara | Owner's Manual - Page 70
STEERING COLUMN CONTROLS CAUTION To help prevent damage to windshield wiper and washer system components, you should take the following precautions: • Do not continue to hold in the lever when there is no windshield washer fluid being sprayed or the washer motor can be damaged. • Do not attempt to - 2008 Suzuki Grand Vitara | Owner's Manual - Page 71
) LOCK 52D113 When you push the "ON/OFF" switch, the system is on and a "CRUISE" indicator light on the instrument cluster will be on. EXAMPLE 64J037 66J192 The release lever is located under the steering column. To adjust the steering wheel height: 1) Pull up the lock lever to unlock the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 72
STEERING is cleared and you can not use the Resume feature. In this case, reset your CRUISE speed. Speed Turn on the cruise control system by pushing the "ON/OFF" • Slightly depress the brake pedal or clutch pedal, control operation will also be canceled any time the vehicle speed falls below 40 km - 2008 Suzuki Grand Vitara | Owner's Manual - Page 73
(if equipped) You can control basic functions of the audio system with the switches on the steering wheel. For details, refer to "Audio Systems" in the "INSTRUMENT PANEL" section. Horn EXAMPLE 64J040 Press the horn pad on the steering wheel to sound the horn. The horn will sound with the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 74
STEERING COLUMN CONTROLS MEMO 3-13 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 75
Defroster (if equipped) Switch ...4-15 Front Fog Light Switch (if equipped) ...4-16 "ESP OFF" Switch ...4-16 Transfer Switch (if equipped) ...4-17 Glove Box ...4-17 Information Display ...4-17 Theft Deterrent Light ...4-21 Automatic Heating and Air Conditioning System (Climate Control) ...4-21 Audio - 2008 Suzuki Grand Vitara | Owner's Manual - Page 76
ventilator 11. Side ventilator 12. Side defroster 13. Glove box 14. Passenger's air bag 15. Fuse box 16. Hood release 17. Transfer switch (if equipped) 18. "ESP OFF" switch 19. "PASS AIR BAG OFF" indicator/Front passenger's seat belt reminder light EXAMPLE 11 3 12 1 4 8 9 10 14 12 11 6 15 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 77
INSTRUMENT PANEL Instrument Cluster 1. Speedometer 2. Odometer/Tripmeter 3. Odometer/Tripmeter selector meter illumination cancel knob 4. Tachometer 5. Fuel gauge 6. Temperature gauge 7. Warning and indicator lights and EXAMPLE 4 1 5 7 2 3 7 6 66J212 4-2 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 78
INSTRUMENT PANEL Warning and Indicator Lights Front Passenger's Seat Belt Reminder Light For details about the seat belt reminder, refer to "Seat Belts and Child Restraint Systems" in the "BEFORE DRIVING" section. Low Tire Pressure Warning Light WARNING It is absolutely essential that the driver - 2008 Suzuki Grand Vitara | Owner's Manual - Page 79
off after blinking, indicating that the monitoring system has recovered, make sure to have an authorized SUZUKI dealer check the system. WARNING If the low tire pressure warning light comes on and stays on, reduce your speed and avoid abrupt steering and braking. Stop in a safe place as soon as - 2008 Suzuki Grand Vitara | Owner's Manual - Page 80
. • If the brake system warning light comes on at any time during vehicle operation. NOTE: Because the disc brake system is selfadjusting, the fluid level will drop as the brake pads become worn. Replenishing the brake fluid reservoir is considered normal periodic maintenance. 65D529 When the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 81
. The light will come on and stay on. • If the ESP® systems operate continuously such as when driving on slippery roads, the traction control functions of the ESP® systems may be canceled temporarily to avoid overheating the brake pads, and the light will come on. After a short period of time, the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 82
off the road as soon as you can and stop the engine. Check the oil level and add oil if necessary. If there is enough oil, the lubrication system should be inspected by your SUZUKI dealer before you drive the vehicle again. 50G052 This light comes on when the ignition switch is turned to the "ON - 2008 Suzuki Grand Vitara | Owner's Manual - Page 83
will go off after driving a few times after the fuel filler cap is installed fully, the electrical system dries out or the fuel tank is filled. 63J030 65D530 This light monitors inflators, crash sensors, seat belt pretensioners, the front passenger sensing system, and corresponding electrical - 2008 Suzuki Grand Vitara | Owner's Manual - Page 84
not in the vehicle. For details, refer to "Keyless Start System Remote Controller/Keyless Entry System Transmitter" in the "BEFORE DRIVING" section. Turn Signal Indicators 54G391 65D474 This light remains on until all doors (including the tailgate) are completely closed. When the vehicle's speed - 2008 Suzuki Grand Vitara | Owner's Manual - Page 85
indicators: 4-wheel drive high range mode For details, refer to "Using the Transfer Switch" in the "OPERATING YOUR VEHICLE" section. If the indicators (all lights) continue to blink, there is a problem in the transfer system and you should have your vehicle inspected by an authorized SUZUKI dealer - 2008 Suzuki Grand Vitara | Owner's Manual - Page 86
speed in km/h and miles/h. Odometer/Tripmeter When the the distance traveled on short trips or between fuel stops. CAUTION (1) 66J034 (2) (3) 66J035 maintenance schedule regularly for required services. Increased wear or damage to certain parts can result from failure to perform required services - 2008 Suzuki Grand Vitara | Owner's Manual - Page 87
control knob (4) In this position, the meter lights are the dimmest and the other instrument panel lights are turned off. (5) In this position, the instrument panel lights are the brightest. Your vehicle has a system to automatically dim the instrument panel lights when the ignition switch is in the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 88
lights, turn the knob (3) clockwise. To cancel the automatic dimming feature and maintain full brightness, turn the knob (3) clockwise to position (5). Tachometer EXAMPLE Fuel Gauge (2) (1) 64J051 64J052 The tachometer indicates engine speed in revolutions per minute. CAUTION Never drive - 2008 Suzuki Grand Vitara | Owner's Manual - Page 89
converter. NOTE: The activation point of the low fuel warning light (1) varies depending on road conditions (for example, slope or curve) and driving conditions because of fuel moving in the tank. The mark (2) indicates that the fuel filler door is located on the right side of the vehicle. 64J053 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 90
equipped) Switch An indicator light will be lit when the defroster is on. The defroster will only work when the engine is running. To turn the defroster after the window has become clear. When the rear window is fogged, push this switch to clear the window. (2) 64J258 If the outside rearview - 2008 Suzuki Grand Vitara | Owner's Manual - Page 91
may be canceled temporarily to avoid overheating the brake pads. After a short period of time, the ESP® systems (other than ABS) will turn on automatically and the "ESP OFF" indicator light will go out. 66J039 64J058 The front fog light comes on when the fog light switch is pushed in with: • the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 92
by turning the key counterclockwise. (1) Clock (2) Thermometer (3) Instantaneous fuel consumption/Average fuel consumption/Driving range (4) "H" button (5) "M" button (6) "DISP" button (7) Freezing mark WARNING Never drive with the glove box lid open. It could cause injury if an accident occurs - 2008 Suzuki Grand Vitara | Owner's Manual - Page 93
not be changed when the fuel consumption/driving range display is blank. Refer to "Fuel Consumption and Driving Range (3)" in this section. Fuel Consumption and Driving Range (3) This display can be changed to show instantaneous fuel consumption, average fuel consumption, driving range. Also, the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 94
will show a new average fuel consumption value after driving for a short time. 66J200 until the fuel gauge indicates "E" based a current driving conditions. When the remaining fuel in fuel tank reaches a low level, the display "--.-" will appear. If the low fuel warning light comes on, fill the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 95
blinking and the display will stay on. NOTE: The unit indication of the fuel consumption or driving range can not be changed when the fuel consumption/driving range display is blank. 66J201 Driving range NOTE: "MPG" is based on US gallons. NOTE: When you reconnect the negative (-) terminal to the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 96
INSTRUMENT PANEL Theft Deterrent Light EXAMPLE Automatic Heating and Air Conditioning System (Climate Control) Air Outlet (front) EXAMPLE 1 2 1 3 4 2 66J249 3 5 This light will blink with the ignition switch in the "OFF" or "ACC" position. The blinking light is intended to deter theft by - 2008 Suzuki Grand Vitara | Owner's Manual - Page 97
INSTRUMENT PANEL 1. 2. 3. 4. 5. Windshield defroster outlet Side defroster outlet Side outlet Center outlet Floor outlet Center outlet Open Side outlet EXAMPLE Close 64J199 63J045 When "Open", air comes out from the side outlets regardless of the air flow selector position. 4-22 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 98
INSTRUMENT PANEL Description of Controls (1) (2) (3) (4) (5) (6) (7) (8) (9) Temperature selector Blower speed selector Air intake selector Air flow selector Defrost switch "OFF" switch "AUTO" switch Air conditioning switch LCD display (8) (1) (2) (7) (5) (6) (9) (3) (4) 66J234 4-23 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 99
Temperature selector (1) (1) Air conditioning switch (8) Blower speed selector (2) (2) A/C: OFF A/C: ON 66J235 66J236 66J237 Turn this selector to adjust the temperature. This switch is used to turn on and off the air conditioning system. To turn on the air conditioning system, push in the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 100
mode is suitable when driving through an area with polluted air such as a tunnel, or when attempting to quickly cool down the vehicle. FRESH AIR (b) When this mode is selected, outside air is introduced. "FRESH AIR" and "RECIRCULATED AIR" are selected alternately each time the air intake selector is - 2008 Suzuki Grand Vitara | Owner's Manual - Page 101
. NOTE: When the defrost switch (5) is pushed to turn on the defroster, the air conditioning system will come on and the "FRESH AIR" mode will be selected automatically. In very cold weather, however, the air conditioning system will not turn on. Push this switch to turn on the defroster. 64J072 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 102
the air conditioning switch (8) to manually turn the air conditioner on or off according to your preference. When you turn the air conditioning switch off, the climate control system cannot lower the Be careful not to cover the interior temperature sensor (F) located between the steering wheel and - 2008 Suzuki Grand Vitara | Owner's Manual - Page 103
the engine idling. This circulates the refrigerant and oil and helps protect the internal components. Your air conditioner is equipped with air filters. Clean or replace them as specified in the "Maintenance Schedule" in the "INSPECTION AND MAINTENANCE" section. Have this job done by your SUZUKI - 2008 Suzuki Grand Vitara | Owner's Manual - Page 104
on the optical parts of the player, do not use the player for about one hour, this will allow the condensation to disappear normally. • Driving on extremely bumpy or lubricate the rotating parts. Please bring the unit to an authorized SUZUKI dealer or a Clarion service Department. Cautions on - 2008 Suzuki Grand Vitara | Owner's Manual - Page 105
PANEL Never touch the surface. prevent the system from operating properly. 52D348 52D347 To remove disc. • CD-R discs may not be able to playback in this unit due to the recording conditions. • CD-RW discs can not playback in this unit. (B) (C) (B) 52D349 Do not discs will cause damage or 4-30 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 106
INSTRUMENT PANEL Basic Operations Type 1 AM/FM/XM CD PLAYER WITH CD CHANGER CONTROL (1) Power on/off knob Volume control knob (2) Tone/balance/fader control knob (3) Preset button 5 (4) Preset button 6 (1) (2) (3) (4) Type 2 AM/FM/XM 6-CD PLAYER WITH CD CHANGER CONTROL (1) (2) (3) (4) - 2008 Suzuki Grand Vitara | Owner's Manual - Page 107
volume. NOTE: While driving, adjust the volume to an extent that sound and/or noise coming from outside the car can be heard. Adjusting bass/treble/balance/fader 1) Press the tone/balance/fader control knob (2). Each time it is pressed, sound adjustment is changed as follows: Adjusting the AVC (Auto - 2008 Suzuki Grand Vitara | Owner's Manual - Page 108
WITH CD CHANGER CONTROL Display (C) (A) (6) (1) (2) (3) (4) (B) (D) 66J097 (1) (2) (3) (4) (5) (6) (A) (B) (C) (D) Band switch button (FM/AM) Seek up button Seek down button Manual tuning knob Preset buttons (1 to 6) Auto store button (AS)/ Scan button (SCAN) Band Preset channel number Stereo - 2008 Suzuki Grand Vitara | Owner's Manual - Page 109
band switch button (1). Each time the button is pressed, the will light. Radio Reception Radio reception can be affected by environment, atmospheric conditions, or a frequency where a broadcast station is available. Manual tuning Turn the manual tuning knob (4). The frequency being received is - 2008 Suzuki Grand Vitara | Owner's Manual - Page 110
in a parking garage or putting a car cover over your car. • Remove the antenna before putting a car cover over your vehicle. 52D291 • A CD is inserted with its label facing upward. • When there is a CD already loaded in the unit, another CD cannot be loaded at the same time. Do not use force when - 2008 Suzuki Grand Vitara | Owner's Manual - Page 111
CONTROL (Built in CD Player) Display (D) (A) (B) (C) 66J100 (1) (6) (2) (4) (3) (5) (1) (2) (3) (4) (5) (6) (A) (B) (C) (D) CD insertion slot CD eject button Disc button (CD/AUX) Track up button/Fast forward button Track down button/Rewind button Repeat button (RPT) Mode indicator Track number - 2008 Suzuki Grand Vitara | Owner's Manual - Page 112
to remove the ejected single CD. Loading a CD Insert a CD in the CD insertion slot (1). When a CD is loaded, play starts and the CD indicator (A) lights. Ejecting a CD Press the CD eject button (2). If you left a CD ejected for a period of about 15 seconds, it will be automatically drawn inside the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 113
(7) (1) (2) (3) (4) (5) (6) (7) (8) (A) (B) (C) (D) (E) (F) Load button (LOAD) Disc select buttons (1 to 6) CD insertion slot CD eject button Disc button (CD/AUX) Track up button/Fast forward button Track down button/Rewind button Repeat button (RPT) Mode indicator Disc number Track number Play - 2008 Suzuki Grand Vitara | Owner's Manual - Page 114
Only the numbers in the CD indicator that correspond to the loaded slots will light. Ejecting one CD 1) Select the CD you want to remove with the disc . During that period, the shutter located in the depth of the CD insertion slot (3) is opened. After 15 seconds time has elapsed, the indication "In" - 2008 Suzuki Grand Vitara | Owner's Manual - Page 115
the unit in a sequential manner. • Please prepare a location where removed CDs can be stored. • If you leave repeat play, press the repeat button (8) several times to change the repeat play mode to OFF. 2 seconds and then the repeat indicator (F) lights. When all the tracks on the disc currently - 2008 Suzuki Grand Vitara | Owner's Manual - Page 116
(3) (4) (5) (A) (B) (C) (D) (E) (F) (G) Sound control knob Repeat button (RPT) Track up button/Fast forward button Track down button/Rewind button Display button (DISP) Folder number Track number Play time Repeat indicator WMA indicator MP3 indicator CD indicator (2) (5) (3) (4) (1) 66J218 4-41 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 117
(1) to select a folder. Repeat play Press the repeat button (2). Each time the button is pressed, repeat play mode changes as follows: Type 1 TRACK appears in the display for 2 seconds and then the repeat indicator (D) lights. The track currently being played is played repeatedly. • FOLDER REPEAT The - 2008 Suzuki Grand Vitara | Owner's Manual - Page 118
up button Seek down button Manual tuning knob Display button (DISP) Preset button (1 to 6) Scan button (SCAN) Type 2 AM/FM/XM 6-CD PLAYER WITH CD CHANGER CONTROL (A) Band (B) Channel number (C) Category indicator If you want to purchase XM Satellite Radio Service, contact your SUZUKI dealer. It is - 2008 Suzuki Grand Vitara | Owner's Manual - Page 119
the manual CAT indicator (c) lights up and the The first time you use ground-based repeaters are placed in major metropolitan areas, but depending on the geographic situation (for example, if mountains or buildings are on the south side of your vehicle), you may experience reception problems - 2008 Suzuki Grand Vitara | Owner's Manual - Page 120
Display (A) 66J221 (1) Aux button (CD/AUX) (A) Mode indicator Aux function This system has an external input terminal so you can listen to audio from an external device connected to this unit. (1) Type 2 AM/FM/XM 6-CD PLAYER WITH CD CHANGER CONTROL Press the aux button (1). Each time the button - 2008 Suzuki Grand Vitara | Owner's Manual - Page 121
(2) (3) (4) (5) (6) (A) (B) (C) (D) (E) (F) (G) Disc button (CD/AUX) Disc select buttons (1 to 6) Track up button/Fast forward button Track down button/ Category button (CAT) Mode indicator Disc number Track number Play time Repeat indicator Random indicator CD changer number (2) Type 2 AM/FM - 2008 Suzuki Grand Vitara | Owner's Manual - Page 122
1 CD changer 2 OFF DISC RANDOM 66J131 NOTE: This operation should be performed within 2 seconds. To cancel random play, press the category button (6) several times to change the random play mode to OFF. • TRACK RANDOM The tracks in the disc that is loaded are played at random. • DISC RANDOM The - 2008 Suzuki Grand Vitara | Owner's Manual - Page 123
Repeat play Press the repeat button (5). Each time the button is pressed, repeat play mode changes as follows: TRACK REPEAT • TRACK REPEAT The indication "TRACK RPT" appears in the display for 2 seconds and then the repeat indicator (E) lights. The track being currently played is played repeatedly - 2008 Suzuki Grand Vitara | Owner's Manual - Page 124
), CD, External CD-changer (option), AUX (option)), push the switch (3). You can also turn on the audio system by pushing the switch (3). To change the part of the switch (4). (2) (3) (1) (4) 64J041 You can control basic functions of the audio system with the switches on the steering wheel - 2008 Suzuki Grand Vitara | Owner's Manual - Page 125
button/Fast forward button (3) Preset buttons (1 to 6) The anti-theft feature is intended to discourage theft or the audio system by preventing the system from operating when it is moved to a different vehicle. This feature works by allowing you to enter a Personal Identification Number (PIN). When - 2008 Suzuki Grand Vitara | Owner's Manual - Page 126
"0000". 66J118 2) Press the power on/off knob (1) while pressing and holding the track up button (2). The "ENTRY 0000" will blink and the audio system enter PIN-input mode. NOTE: Establish your PIN by combining numbers from 1 to 6 into any 4-digit number. If you forget your PIN, when you remove the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 127
turn off, and you will be able to operate the audio system. NOTE: • If you input your PIN incorrectly will be displayed and the anti-theft function lock mode is entered. If you enter an incorrect PIN fewer than 6 times, the locking time will be for 15 seconds; if you enter an incorrect PIN - 2008 Suzuki Grand Vitara | Owner's Manual - Page 128
Troubleshooting Applicable to every device Phenomenon Power is not turned on. (No sound is produced) Radio Phenomenon Too much noise droplets may form on the internal lens when the car is parked in a humid place. Remedy Eject manual tuning. Fuse is blown. Connections are not properly made. - 2008 Suzuki Grand Vitara | Owner's Manual - Page 129
diagnostic functions to protect the system. If a problem should occur, the display shows the type of error. Refer to the table below and take proper measures to correct the problem. If the problem is corrected, the unit not listed above appears, turn off the unit and contact your SUZUKI dealer. 4-54 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 130
INSTRUMENT PANEL MEMO 4-55 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 131
Luggage Compartment Light ...5-9 Front Seat Heater (if equipped) ...5-9 Assist Grips (if equipped) ...5-10 Coat Hooks (if equipped) ...5-11 Sunroof (if equipped) ...5-11 Engine Hood ...5-13 Cup Holder and Storage Bin (if equipped) ...5-14 Overhead Console Box (if equipped) ...5-15 Accessory Socket - 2008 Suzuki Grand Vitara | Owner's Manual - Page 132
the vehicle. When preparing to drive the vehicle, move the gearshift lever out of the "P" position before releasing the parking brake. Pedals Manual transmission EXAMPLE WARNING (2) (3) 64J081 (1) To set (2) To release (3) To release The parking brake lever is located between the seats. To set - 2008 Suzuki Grand Vitara | Owner's Manual - Page 133
Clutch Pedal (1) (For manual transmission) The clutch pedal is used to disengage the drive to the wheels when starting the engine, stopping or shifting the gearshift lever or transfer lever. Depressing the pedal disengages the clutch. WARNING Do not "ride" the brakes by applying them continuously - 2008 Suzuki Grand Vitara | Owner's Manual - Page 134
and may spray out, causing injury. To reinstall the fuel filler cap: 1) Turn the cap clockwise until you hear several clicks. 2) Close the fuel filler door. 64J253 The fuel filler cap is located on the right rear side of the vehicle. The fuel filler door can be unlocked by pulling up on the opener - 2008 Suzuki Grand Vitara | Owner's Manual - Page 135
luggage compartment cover. 3) Lower the adjustable head restraint fully. WARNING If you need to replace the fuel cap, use a genuine SUZUKI cap. Use of an improper cap can result in a malfunction of the fuel system or emission control system. It may also result in fuel leakage in the event of an - 2008 Suzuki Grand Vitara | Owner's Manual - Page 136
cushion, be careful that your face or hands are not injured from the seat popping up. (2) 8) Hook the strap (4) to the front seat head restraint and re-tighten the adjuster (2) to apply a tension on the strap as shown in the illustration. CAUTION When securing the folded rear seat with a strap - 2008 Suzuki Grand Vitara | Owner's Manual - Page 137
OTHER CONTROLS AND EQUIPMENT WARNING Luggage or other cargo should be stowed in the luggage compartment with the rear seat in an upright position, whenever possible. If you need to carry cargo in the passenger compartment with the rear seat back folded forward, be sure to secure the cargo or it may - 2008 Suzuki Grand Vitara | Owner's Manual - Page 138
AND EQUIPMENT Armrest Center Console Armrest Sun Visor Interior Light Switch Center EXAMPLE (3) (2) (1) 79J161 64J263 CAUTION to handle it by the hard plastic parts or the sun visor can be damaged. (3) (2) (1) 64J211 This light switch has three positions which function as described below - 2008 Suzuki Grand Vitara | Owner's Manual - Page 139
of whether the door is open or closed. (2) The light comes on when the door is opened. After closing all doors (including the tailgate), the light will remain on for about 15 seconds and then fade out. If you insert the key into the ignition switch during that time, the light will start to - 2008 Suzuki Grand Vitara | Owner's Manual - Page 140
(2) remains off regardless of whether the door(s) is(are) opened or closed. Front Seat Heater (if equipped) EXAMPLE 66J047 The luggage compartment light is located at the left side of the rear luggage compartment. When you open any of the doors including the tailgate with the luggage compartment - 2008 Suzuki Grand Vitara | Owner's Manual - Page 141
OTHER CONTROLS AND EQUIPMENT CAUTION To avoid damaging the heater element: • Do not subject the front seats to heavy impacts, such as children jumping on them. • Do not cover the seat with any insulating materials such as blankets or cushions. Assist - 2008 Suzuki Grand Vitara | Owner's Manual - Page 142
part of the sunroof switch or the "SLIDE" part of the sunroof switch when the ignition switch is in the "ON" position. There is a system to prevent being pinched by the sunroof. When the system . WARNING If your vehicle is equipped with side curtain air bags, do not hang sharp items like a hanger - 2008 Suzuki Grand Vitara | Owner's Manual - Page 143
or change the fuses, the features below will not operate. • The system to prevent being pinched by the sliding sunroof. • The system to automatically rearward, push the "SLIDE OPEN" part (2) of the sunroof switch. To side the sunroof forward, push the "TILT UP" part (1) of the sunroof switch. If - 2008 Suzuki Grand Vitara | Owner's Manual - Page 144
body weight on the roof around the sunroof such as by sitting on it. • Be sure to close the sunroof when you leave the vehicle unattended. • Periodically inspect the guide rail for dirt and clean it if any dirt has accumulated. Engine Hood 65D612 64J110 WARNING • Never allow any part of your body - 2008 Suzuki Grand Vitara | Owner's Manual - Page 145
support with the prop rod. To close the engine hood: 1) Lift the hood up slightly and remove the prop rod from the hole. Put the prop rod back to the holding clip. 2) Lower the hood close to the bumper before driving. If it is not, it can fly up unexpectedly during driving, obstructing your view and resulting - 2008 Suzuki Grand Vitara | Owner's Manual - Page 146
lid. 64J289 To use the overhead console box, push on the front edge (1) and open the lid. To close the lid, push the front edge (1) until it latches. Do not put heavy or sharp items in the box. EXAMPLE 64J200 WARNING Never drive with the overhead console box lid open. It could cause injury if - 2008 Suzuki Grand Vitara | Owner's Manual - Page 147
as a lighter, in the compartment. The heat may cause a fire. NOTE: An aftermarket garage door opener can be installed in the front side overhead console box. Accessory Socket (if equipped) EXAMPLE 12-volt accessory sockets are located both on the center console and on the left side of the luggage - 2008 Suzuki Grand Vitara | Owner's Manual - Page 148
Cigarette Lighter (if equipped) EXAMPLE Ashtray (if equipped) EXAMPLE Frame Hooks Front (1) 64J201 64J119 You can fit the ashtray into any of the cup socket, do not use it as an accessory power source. Some accessories' power plug can damage the inner mechanism of the cigarette lighter socket. - 2008 Suzuki Grand Vitara | Owner's Manual - Page 149
Frame hooks are provided at the front and rear of the vehicle. To access the front hook, unhook the lower part of the cover (1) and then only to change wheels. It is important to read the jacking instructions in the "EMERGENCY SERVICE" section of this manual before attempting to use the jack - 2008 Suzuki Grand Vitara | Owner's Manual - Page 150
OTHER CONTROLS AND EQUIPMENT Shopping Hook (if equipped) EXAMPLE Front Seat Back Pocket (if equipped) EXAMPLE Luggage Restraint Loops (if equipped) 66J049 The shopping hooks are located on both sides of the luggage compartment. You can hang the shopping bag or other suitable objects on the hook - 2008 Suzuki Grand Vitara | Owner's Manual - Page 151
driving. They are neither capable of nor intended for preventing cargo from being thrown around in a crash covers are not designed to support items loaded on top of even if they are small and light. Objects on top of the effectiveness of the child restraint system. CAUTION To avoid damaging the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 152
OTHER CONTROLS AND EQUIPMENT rear clearance is established on the other end to swing the cover down and out. front (b) 66J205 3) Lift up both ends of the cover to disengage the attachment points (b). 66J206 5) Tilt the luggage compartment cover, and then remove the compartment cover - 2008 Suzuki Grand Vitara | Owner's Manual - Page 153
OTHER CONTROLS AND EQUIPMENT To stow a luggage compartment cover on the floor of the rear luggage room: To reinstall the luggage compartment cover: (c) (d) (b) 66J209 66J208 1) Fold/roll the luggage compartment cover, and place one end in the quarter window opening (c) to swing the other end into - 2008 Suzuki Grand Vitara | Owner's Manual - Page 154
OTHER CONTROLS AND EQUIPMENT Underfloor Bins (if equipped) EXAMPLE Roof Rails or Roof Rack Anchors (if equipped) Roof rails (e) (A) 66J210 3) Unroll/unfold the cover as you secure the other latches (e). 64J132 Pull up the straps (A) to open the bin. 64J133 CAUTION Do not allow items in the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 155
illustration. To install the cap, put in the front part of the cap, slide the cap in the opposite direction of the arrow (1) weight) exceed the Gross Vehicle Weight Rating (GVWR) listed on the driver's door lock pillar. • Mount and secure the cargo onto the roof rack properly according to the instructions - 2008 Suzuki Grand Vitara | Owner's Manual - Page 156
door openers, entry door locks, security systems, even home lighting. features as required by U.S. federal safety stan- Retain the original transmitter of the RF device you are programming for use in other vehicles as well as for future HomeLink® programming. It is also suggested that upon the sale - 2008 Suzuki Grand Vitara | Owner's Manual - Page 157
6) At the garage door opener receiver (motor-head unit) in the garage, locate the "learn" or "smart" button. This can usually be found where the hanging antenna wire is attached to the motorhead unit. 7) Firmly press and release the "learn" or "smart" button. (The name and color of the button may - 2008 Suzuki Grand Vitara | Owner's Manual - Page 158
gate operators are designed to "time-out" in the same manner. If you live in Canada or you are having difficulties door opener, gate operator, security system, entry door lock, home/office lighting, etc.). For convenience, the handheld transmitter of the device may also be used at any time - 2008 Suzuki Grand Vitara | Owner's Manual - Page 159
Exhaust Gas Warning ...6-1 Daily Inspection Checklist ...6-2 Starting the Engine ...6-2 Engine Block Heater (if equipped) ...6-4 Using the Transmission ...6-5 Using the Transfer Switch (if equipped) ...6-7 Braking ...6-15 Electronic Stability Program (ESP®) ...6-18 Tire Pressure Monitoring System - 2008 Suzuki Grand Vitara | Owner's Manual - Page 160
fan is at high speed with the air intake selector set to "FRESH AIR". • To allow proper operation of your vehicle's ventilation system, keep the air inlet grille in front of the windshield clear of snow, leaves or other obstructions at all times. • Keep the exhaust tailpipe area clear of snow and - 2008 Suzuki Grand Vitara | Owner's Manual - Page 161
. 3) Look for fluid, oil leaks. NOTE: It is normal for water to drip from the air conditioning system after use. 4) Make sure the hood is fully closed and latched. 5) Check the headlights, turn signal lights, brake lights and horn for proper operation. 6) Lock all doors. 7) Adjust the seat and - 2008 Suzuki Grand Vitara | Owner's Manual - Page 162
way to the floor while cranking. This should clear the engine if it is flooded. If you are unable to start the engine using this procedure, consult your SUZUKI dealer. EXAMPLE 66J022 63J265 If the keyless start system blue indicator light illuminates on the instrument cluster, you can turn the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 163
plug the female end into the block heater socket and the male end into a normal, grounded 110-volt AC outlet. CAUTION Secure the block heater cord back to its original position or to the routed position. A loose cord could get caught in the engine accessory drive belt(s) or other moving parts. 6-4 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 164
automatic transmission mode The 4-speed mode is suitable for the following driving conditions: • Driving on hilly, winding roads - You can drive more smoothly with less frequent gearshifting • Going down a steep hill - Some engine braking is provided NOTE: With the transfer switch in the "4L LOCK - 2008 Suzuki Grand Vitara | Owner's Manual - Page 165
is running above idle speed. • Do not rev the engine with the transmission in a drive position ("R", "D", "4", "3" or "L") and the rear wheels not moving. • Do not use the accelerator to hold the vehicle on a hill. Use the vehicle's brakes. Emergency shifting out of "P" (Park) If you are unable - 2008 Suzuki Grand Vitara | Owner's Manual - Page 166
driving or use the clutch to keep the vehicle stationary on a hill. Depress the clutch fully when shifting. • When shifting or starting off, do not race the engine. Racing the engine can shorten engine life and affect smooth shifting. Your vehicle is equipped with a four-mode full-time 4x4 system - 2008 Suzuki Grand Vitara | Owner's Manual - Page 167
OPERATING YOUR VEHICLE (1) (2) (3) (4) (5) (6) (7) (8) (9) (10) (11) Front differential Engine Transmission High/Low clutch Transfer case Center differential Differential lock clutch Chain Rear propeller shaft Rear differential Front propeller shaft (4) (2) (3) (5) (6) (7) (9) (8) (10) (1) (11) - 2008 Suzuki Grand Vitara | Owner's Manual - Page 168
OPERATING YOUR VEHICLE Description of Transfer Switch Positions N (Neutral) In this position, engine power is not supplied to the front or rear axles. Only use this position for towing your vehicle. When you turn the transfer switch to the "N" position, "N" indicator will come on with - 2008 Suzuki Grand Vitara | Owner's Manual - Page 169
OPERATING YOUR VEHICLE 4H (4-wheel drive high range) In this position, engine power is supplied to the front and rear axles. Use this position for normal driving. 64J220 6-10 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 170
VEHICLE 4H LOCK (4-wheel drive high range center differential lock) In this position, engine power is supplied to the front and rear axles and you get better traction than when driving in "4H". Use this position when you need better traction than "4H" provides, such as when driving on slippery roads - 2008 Suzuki Grand Vitara | Owner's Manual - Page 171
, and the "ESP OFF" indicator light will come on. When the transfer switch (if equipped) is turned to the "4L LOCK" position, braketraction control can be activated. Braketraction control brakes the spinning wheel to distribute drive power to the other wheels for increased climbing ability or for - 2008 Suzuki Grand Vitara | Owner's Manual - Page 172
while the vehicle is moving. Position the front wheels straight ahead and turn the switch to shift the transmission in "N" (Neutral) and depress the brake pedal and the clutch pedal fully (if equipped), several times after turning the transfer switch. Be sure to wait until traffic conditions allow - 2008 Suzuki Grand Vitara | Owner's Manual - Page 173
the transfer switch to shift between "N" and "4H", or between "4H LOCK" and "4L LOCK". • Do not shift between "4H" and "4H LOCK" unless the front wheels are in the straight-ahead position and we recommend that the vehicle speed be less than 100 km/h (60 mph). Do not operate the transfer - 2008 Suzuki Grand Vitara | Owner's Manual - Page 174
4 times greater than the braking distance needed at 30 km/h (19 mph). Start to brake the vehicle when there is plenty of distance between your vehicle and the stopping point, and slow down gradually. 4L LOCK 4H LOCK N: Neutral 4H: 4-wheel drive high range mode 4H LOCK: 4-wheel drive high - 2008 Suzuki Grand Vitara | Owner's Manual - Page 175
to a stalled engine or other failures, the system is still fully operational on reserve power and you can bring the vehicle to a complete stop by pressing the brake pedal once and holding it down. The reserve power is partly used up when you depress the brake pedal and reduces each time the pedal is - 2008 Suzuki Grand Vitara | Owner's Manual - Page 176
of the ABS system may have failed. This could cause the rear wheels to skid or the vehicle to spin during braking on a slippery road or hard braking on a dry paved road. If both warning lights come on, drive carefully, avoiding hard braking as much as possible, and ask your SUZUKI dealer to inspect - 2008 Suzuki Grand Vitara | Owner's Manual - Page 177
. This system automatically controls the brakes and engine to help prevent the vehicle from skidding when cornering on a slippery road surface or when turning the steering wheel abruptly. WARNING The ABS may not work properly if tires or wheels other than those specified in the owner's manual are - 2008 Suzuki Grand Vitara | Owner's Manual - Page 178
When the SLIP indicator light comes on and stays on while driving, indicating a malfunction of the ESP® systems (other than ABS), the brake system will function as an ordinary ABS with no additional ESP® functions. WARNING • The ESP® may not work properly if engine related parts such as the muffler - 2008 Suzuki Grand Vitara | Owner's Manual - Page 179
(other than ABS). You should have the systems inspected by an authorized SUZUKI dealer. NOTE: When the "ESP" warning light comes on, or stays on while driving, indicating a malfunction of the ESP® systems (other than ABS), the brake system will function as an ordinary ABS that has no additional - 2008 Suzuki Grand Vitara | Owner's Manual - Page 180
operate continuously, such as when driving on slippery roads, the traction control functions of the ESP® systems may be canceled temporarily to avoid overheating the brake pads, and the "ESP OFF" indicator light will come on. After a short period of time, the ESP® systems (other than ABS) will turn - 2008 Suzuki Grand Vitara | Owner's Manual - Page 181
AND MAINTENANCE" section. WARNING If the low tire pressure warning light does not come on when the ignition is turned to the "ON" position, or comes on and blinks while driving there may be a problem with the tire pressure monitoring system. Have your vehicle inspected by an authorized SUZUKI - 2008 Suzuki Grand Vitara | Owner's Manual - Page 182
EMERGENCY SERVICE" section. Refer to "Replacing Tires and/or Wheels" for instructions on how to restore normal operation of the tire pressure monitoring system after you have had a flat tire. NOTE: • When the tire inflation pressure is adjusted in high altitude areas, the low tire pressure light may - 2008 Suzuki Grand Vitara | Owner's Manual - Page 183
liquid sealants for a flat tire as air pressure sensors can be damaged. • If the low tire pressure warning light comes on frequently, there may be something wrong with one of the tires or with the monitoring system. Have your vehicle inspected by an authorized SUZUKI dealer. • When the TPMS sensor - 2008 Suzuki Grand Vitara | Owner's Manual - Page 184
improperly tuned engine, may cause overheating of the catalyst. This may result in permanent heat damage to the catalyst and other vehicle components. Traveling to CANADA Please note that service for the tire pressure monitoring system may not be available in CANADA should there be any problems or - 2008 Suzuki Grand Vitara | Owner's Manual - Page 185
materials such as dry grass or leaves can come in contact with a hot exhaust system. Avoid "jackrabbit" starts Fast starts away from lights or stop signs will consume fuel unnecessarily and shorten engine life. Start off slowly. Avoid unnecessary stops Avoid unnecessary deceleration and stopping - 2008 Suzuki Grand Vitara | Owner's Manual - Page 186
YOUR VEHICLE EXAMPLE 60A183S Keep the air cleaner clean A dirty air cleaner will cause the fuel injection system to supply too much fuel to the engine for the amount of air being supplied. The result is waste of fuel due to incomplete fuel burning. Keep weight to a minimum The heavier the load - 2008 Suzuki Grand Vitara | Owner's Manual - Page 187
DRIVING TIPS DRIVING TIPS Important Vehicle Design Features To Know ...7-1 On-Pavement Driving ...7-2 Off-Road Driving ...7-4 7 60G409 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 188
though air bags are equipped at the front seating positions, the driver and all passengers should be properly restrained at all times, using the seat belts provided. Refer to the "Seat Belts and Child Restraint Systems" section for instructions on proper use of the seat belts. • Never drive while - 2008 Suzuki Grand Vitara | Owner's Manual - Page 189
TIPS Shorter Wheelbase Along with its higher ground clearance, your vehicle has a shorter wheelbase and shorter front and rear overhangs than many passenger cars. These features combine to allow you to drive your vehicle over hillcrests without hanging up on them or damaging the frame and chassis - 2008 Suzuki Grand Vitara | Owner's Manual - Page 190
Under wet road conditions you should drive at a lower speed than on dry roads due to possible slippage of tires during braking. When driving on icy, snowcovered or muddy roads, reduce your speed and avoid sudden acceleration, abrupt braking or sharp steering movements. Use 4-wheel drive high range - 2008 Suzuki Grand Vitara | Owner's Manual - Page 191
You and your passengers should use the seat belts at all times when driving offroad. For proper seat belt use, refer to the "Seat Belts and Child Restraint Systems" section in this manual. Avoid Sudden Reactions in Mud, Ice or Snow Be careful when off-road conditions are slick. Reduce your speed and - 2008 Suzuki Grand Vitara | Owner's Manual - Page 192
wheel hubs, axles or exhaust tailpipe. Know the depth of the water before you attempt to drive through it. • If water blocks the tailpipe, the engine may not start or run. If the water is deep enough to get drawn into the engine intake system, the engine will be badly damaged. • Submerged brakes - 2008 Suzuki Grand Vitara | Owner's Manual - Page 193
AND MAINTENANCE" section for details. • Do not use tires other than those specified by SUZUKI. Never use different sizes or types of tires on the front and rear wheels. For information regarding the specified tires, refer to the Tire Inflation Pressure Label located on the driver's side door pillar - 2008 Suzuki Grand Vitara | Owner's Manual - Page 194
DRIVING TIPS MEMO 7-7 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 195
VEHICLE LOADING AND TOWING VEHICLE LOADING AND TOWING Vehicle Loading ...8-1 Trailer Towing ...8-2 Towing Your Vehicle (recreational towing) ...8-7 8 54G215 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 196
Gross Vehicle Weight Rating (GVWR), the Gross Axle Weight Rating (GAWR, front and rear) and the Vehicle Capacity Weight. The GVWR and GAWR (front and rear) are listed on the Safety Certification Label which is located below the driver's side door latch striker. The Vehicle Capacity Weight is listed - 2008 Suzuki Grand Vitara | Owner's Manual - Page 197
a safe place and let the engine WARNING Never use a bumper hitch or a hitch which attaches to the axle of your vehicle. Brakes WARNING If trailer brakes are used, you should follow all instructions provided by the manufacturer. Never tap into the brake system of your vehicle. Safety Chains Always - 2008 Suzuki Grand Vitara | Owner's Manual - Page 198
pounds), the trailer must be equipped with trailer brakes. Vehicle/Trailer Weight Limits Before towing, you must make sure that gross trailer weight, gross combined weight, trailer tongue weight, gross vehicle weight and gross axle weight (front and rear) are within specified limits as described - 2008 Suzuki Grand Vitara | Owner's Manual - Page 199
(including all the occupants, accessories and cargo plus the trailer tongue weight). The gross vehicle weight must never exceed the Gross Vehicle Weight Rating (GVWR) listed on the Safety Certification Label. Gross Axle Weight (Front and Rear) is the weight supported by an individual axle with - 2008 Suzuki Grand Vitara | Owner's Manual - Page 200
Weight Rating (GVWR) listed on the Safety Certification Label. Gross axle weight for the front and rear axles must not exceed the Gross Axle Weight Rating (GAWR) listed on the Safety Certification Label. WARNING WARNING Connect trailer lights wheels will be closer than the vehicle wheels Never drive - 2008 Suzuki Grand Vitara | Owner's Manual - Page 201
chocks absorb the load. 4) Fully engage the parking brake. 5) Manual Transmission - Shift into Reverse or first gear and turn off the engine. Automatic Transmission - Shift into Park and turn off the engine. 6) If you have a 4-wheel drive vehicle, make sure the transfer switch is not in "N" (Neutral - 2008 Suzuki Grand Vitara | Owner's Manual - Page 202
must use depends on the specifications of your vehicle: whether it is a 2wheel drive (2WD), 4-wheel drive (4WD) with a transfer switch or 4-wheel drive (4WD) without a transfer switch vehicle. Use the towing instruction table to select the proper towing method for your vehicle, and carefully follow - 2008 Suzuki Grand Vitara | Owner's Manual - Page 203
"N" indicator will come on with the buzzer sound. 4) Make sure the "N" light on the instrument cluster comes on. 5) Shift the manual transmission lever into 2nd gear or the automatic transmission lever into "P" (Park). 6) Turn the ignition key to the "ACC" position to unlock the steering wheel. 8-8 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 204
the engine. With the manual transmission lever in 2nd gear (or the automatic transmission lever in "D") and the transfer switch in neutral, rev the engine for about one minute with the clutch engaged (if equipped), to circulate oil in the transfer case. TOWING METHOD A FOUR WHEELS ON THE GROUND - 2008 Suzuki Grand Vitara | Owner's Manual - Page 205
dolly according to the instructions provided by the dolly manufacturer. 2) Turn the ignition key to the "ACC" position to unlock the steering wheel. 3) Make sure the front wheels are facing straight forward and secure the steering wheel with a steering wheel clamping device designed for towing - 2008 Suzuki Grand Vitara | Owner's Manual - Page 206
VEHICLE LOADING AND TOWING TOWING METHOD B FRONT WHEELS ON THE GROUND AND REAR WHEELS ON A DOLLY. 52D082 8-11 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 207
...9-3 Maintenance Recommended under Severe Driving Conditions ...9-7 Drive Belt ...9-9 Engine Oil and Filter ...9-9 Gear Oil ...9-13 Automatic Transmission Fluid ...9-15 Engine Coolant ...9-17 Windshield Washer Fluid ...9-19 Air Cleaner ...9-20 Spark Plugs ...9-20 Brakes ...9-21 Steering Wheel - 2008 Suzuki Grand Vitara | Owner's Manual - Page 208
fan belt. • When it is necessary to do service work with the engine running, make sure that the parking brake is set fully and the transmission is in Neutral (for manual transmission vehicles) or Park (for automatic transmission vehicles). • Do not touch ignition wires or other ignition system parts - 2008 Suzuki Grand Vitara | Owner's Manual - Page 209
the times when you should perform regular maintenance on your vehicle. This table shows in miles, kilometers and months when you should perform inspections, adjustments, lubrication and other services. These intervals should be shortened if driving is usually done under severe conditions (refer - 2008 Suzuki Grand Vitara | Owner's Manual - Page 210
odometer miles (x 1000) reading or months, whichever comes first. km (x 1000) months ENGINE & EMISSION CONTROL 1. Drive belt Tension check, *adjustment, *replacement *2. Valve lash (clearance) 3. Engine oil and oil filter *4. Cooling system hoses and connections 5. Engine coolant *6. Exhaust pipes - 2008 Suzuki Grand Vitara | Owner's Manual - Page 211
odometer miles (x 1000) reading or months, whichever comes first. km (x 1000) months ENGINE & EMISSION CONTROL 1. Drive belt Tension check, *adjustment, *replacement *2. Valve lash (clearance) 3. Engine oil and oil filter *4. Cooling system hoses and connections 5. Engine coolant *6. Exhaust pipes - 2008 Suzuki Grand Vitara | Owner's Manual - Page 212
*Fluid hose *14. Transfer oil *15. Differential & Extension (for 2WD) oil 16. Steering system Steering wheel movement, *linkage *17. Power steering (if equipped) 18. All Latches, Hinges and Locks 19. Air conditioner filter (if equipped) 7.5 12.5 7.5 15 25 15 22.5 37.5 22.5 30 50 30 37.5 62.5 37.5 45 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 213
check, *replacement 5. Brake pedal stroke check, *adjustment 6. Parking brake lever and *cable Lever movement check, *adjustment 7. Tires (including tire rotation) *8. Wheel discs *9. Wheel bearings *10. Suspension system *11. Propeller shafts/Drive shafts *12. Manual transmission oil 13. Automatic - 2008 Suzuki Grand Vitara | Owner's Manual - Page 214
H - Towing a trailer Severe Condition Code A - Maintenance Maintenance Operation R I I - - C Air cleaner filter element *1 R - - C H Canister air suction filter Brake discs and pads (front) Brake drums and shoes (rear) R I I R Maintenance Interval Every 5000 km (3000 miles) or 3 months Every 10000 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 215
10000 km (6000 miles) or 6 months Every 25000 km (15000 miles) or 15 months Every 10000 km (6000 miles) or 6 months Every 50000 km (30000 miles) or 30 months E H Automatic transmission (A/T) fluid E H Transfer, Differential and Extension oil Bolts and nuts on suspension Drive belt B C - 9-8 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 216
to replace or adjust the belt have it done by your SUZUKI dealer. →: 100 N (22 lbs, 10 kg) press GE: Generator DEFL: Deflection PS: Power steering pump AC: Air conditioner compressor 52D029 Engine Oil and Filter Specified Oil (1) DEFL: 9 - 11 mm (0.35 - 0.43 in.) 5W-30 o 10W-30 C -30 o F -22 PS - 2008 Suzuki Grand Vitara | Owner's Manual - Page 217
AND MAINTENANCE Oil Level Check Engine oil dipstick EXAMPLE FULL ADD Refilling EXAMPLE Open Close 52D084 52D030 It is important to keep the engine oil at the correct level for proper lubrication of your vehicle's engine. Check the oil level with the vehicle on a level surface. The oil level - 2008 Suzuki Grand Vitara | Owner's Manual - Page 218
INSPECTION AND MAINTENANCE Changing Engine Oil and Filter WARNING EXAMPLE New and used oil and solvent can be hazardous. Children and pets may be harmed by swallowing new or used oil or solvent. Repeated, prolonged contact with used engine oil may cause skin cancer. Brief contact with used oil or - 2008 Suzuki Grand Vitara | Owner's Manual - Page 219
AND MAINTENANCE Refill with Oil and Check for Leaks 1) Pour oil through the filler hole and install the filler cap. For the approximate capacity of the oil, refer to the "Capacities" item in the "SPECIFICATIONS" section. 2) Start the engine and look carefully for leaks at the oil filter and - 2008 Suzuki Grand Vitara | Owner's Manual - Page 220
AND MAINTENANCE Gear Oil Specified Gear Oil When replacing gear oil, use gear oil with the appropriate viscosity and grade as shown in the charts below. We highly recommend you use SAE 75W-90 gear oil (SAE 80W-90 for front differential oil, rear differential oil and transfer gear oil). Transmission - 2008 Suzuki Grand Vitara | Owner's Manual - Page 221
The manual transmission, transfer gears, extension case and differentials (front and rear) are lubricated with gear oil. To check the gear oil level in any of the above locations, use the following procedure: 1) Park the vehicle on a level surface. Set parking brake and stop the engine. 2) Remove - 2008 Suzuki Grand Vitara | Owner's Manual - Page 222
the fluid level: 1) To warm up the transmission fluid, drive the vehicle or idle the engine until the temperature gauge indicates normal operating temperature. 2) Then drive for ten more minutes. WARNING After driving the vehicle, gear oil temperature may be high enough to burn you. Wait until the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 223
(about 30 minutes), or the fluid level indication will not be correct. 3) Park your vehicle on level ground. 4) Apply the parking brake and then start the engine in or adding oil, be sure to insert the dipstick securely. Changing Oil 52D032 The handle of the A/T fluid dipstick is colored red for - 2008 Suzuki Grand Vitara | Owner's Manual - Page 224
INSPECTION AND MAINTENANCE Engine Coolant Selection of Coolant To maintain optimum performance and durability of your engine, use SUZUKI Genuine Coolant or equivalent. This type of coolant is best for your cooling system as it: • Helps maintain proper engine temperature. • Gives proper protection - 2008 Suzuki Grand Vitara | Owner's Manual - Page 225
INSPECTION AND MAINTENANCE Engine Coolant Replacement CAUTION • The mixture you use should contain 50% concentration of antifreeze. • If the lowest ambient temperature in your area is expected to be -35 °C (-31°F) or below, use higher concentrations up to 60% following the instructions on the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 226
INSPECTION AND MAINTENANCE EXAMPLE Windshield Washer Fluid Front and rear (if equipped) fluid tank. air in the cooling system. Then, stop the engine. 7) Check the engine coolant level in the radiator again. If the level has gone down, add more engine coolant. Damage may result if the washer motor - 2008 Suzuki Grand Vitara | Owner's Manual - Page 227
50000 km (30000 miles). More frequent replacement is necessary when you drive under dusty conditions. Spark Plugs 66J167 66J009 If the air cleaner is clogged with dust, there will be greater intake resistance, resulting in decreased power output and increased fuel consumption. Check and clean - 2008 Suzuki Grand Vitara | Owner's Manual - Page 228
on (the engine must be running with the parking brake fully disengaged.) Should the light come on, immediately ask your SUZUKI dealer to inspect the brake system. • A rapid fluid loss indicates a leak in the brake system which should be inspected by your SUZUKI dealer immediately. • Brake fluid can - 2008 Suzuki Grand Vitara | Owner's Manual - Page 229
be replaced according to the maintenance schedule. Have the brake fluid replaced by your SUZUKI dealer. With the engine running and the parking brake set, measure the distance between the brake pedal and floor carpet when the pedal is depressed with approximately 300 N (66 lbs, 30 kg) of force. The - 2008 Suzuki Grand Vitara | Owner's Manual - Page 230
AND MAINTENANCE Parking Brake Lever EXAMPLE 200 N (44 lbs, 20 kg) Steering Wheel EXAMPLE "c" "b" 60G104 60A226 66J233 WARNING If you experience any of the following problems with your vehicle's brake system, have the vehicle inspected immediately by your SUZUKI dealer. • Poor braking performance - 2008 Suzuki Grand Vitara | Owner's Manual - Page 231
a typical passenger car tire. (2) Typical Passenger Car Tire Sidewall 64J155 C 64J154 I D J (1) UPPER (2) LOWER Check the steering box case, vane pump and hose connections for leaks or damage. Power Steering Fluid Check the fluid level by looking at the reservoir in the engine compartment when - 2008 Suzuki Grand Vitara | Owner's Manual - Page 232
to grade tires based on three performance factors: treadwear, traction and temperature resistance. Refer to the "Uniform Tire Quality Grading" section for more details. F. Load Rating Load rating is the maximum weight a tire is designed to support in normal service. G. Max Inflation Pressure - 2008 Suzuki Grand Vitara | Owner's Manual - Page 233
those approved by SUZUKI Motor Corporation as standard or optional equipment for your vehicle. 54G307 The front, rear and spare tire pressure specifications for your vehicle are shown below and are listed on the Tire and Loading Information Label, which is located on the driver's door lock pillar - 2008 Suzuki Grand Vitara | Owner's Manual - Page 234
air at a service station until it reaches the recommended pressure. 6) Make sure all tires have the same air pressure (unless the owner's manual indicates otherwise). Tire Inspection WARNING • Air checks: 1) Measure the air pressure with a tire gauge. Adjust the pressure if necessary. Remember - 2008 Suzuki Grand Vitara | Owner's Manual - Page 235
A B C Temperature A B C All Passenger Car Tires Must Conform To Federal Safety Requirements in Addition To These Grades Treadwear The treadwear grade is a comparative rating based on the wear rate of the tire when tested under controlled conditions on a specified government test course. For example - 2008 Suzuki Grand Vitara | Owner's Manual - Page 236
tire marked C may have poor traction performance. Motor Vehicle Safety Standard No. 109. Grades B and A represent higher levels of performance on the laboratory test wheel than the minimum required by law. schedule. After rotation, adjust front and rear tire pressures to the specification listed on - 2008 Suzuki Grand Vitara | Owner's Manual - Page 237
with both hands. 2) Loosen, but do not remove the wheel nuts. 3) Jack up the vehicle (follow the jacking instructions in the "EMERGENCY SERVICE" section in this manual). 4) Remove the wheel nuts and wheel. 5) Install the new wheel and replace the wheel nuts with their cone shaped end facing the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 238
as shown in the illustration. NOTE: How to install the spare wheel: When you install the spare wheel to the vehicle again, handle it in the reverse order of removal. CAUTION To avoid the removal of the spare wheel full cover while driving, be sure to fit the claws (3) of the outer cover of - 2008 Suzuki Grand Vitara | Owner's Manual - Page 239
or has been standing for three hours or more. Curb Weight - the weight of a motor vehicle with standard equipment including the maximum capacity of fuel, oil, and coolant, and, if so equipped, air conditioning and additional weight optional engine. Intended Outboard Sidewall - (1) the sidewall that - 2008 Suzuki Grand Vitara | Owner's Manual - Page 240
Gross Vehicle Weight Rating (GVWR), the Gross Axle Weight Rating (GAWR, front and rear), and the total load capacity, the seating capacity, and the cargo load capacity. The GVWR and GAWR (front and rear) are listed on the Safety Certification Label which is located below the driver's side door latch - 2008 Suzuki Grand Vitara | Owner's Manual - Page 241
cause damage to your tires and lead to poor steering and braking which can result in an accident. The gross vehicle weight (sum of the weights of the loaded vehicle, driver and passengers) must never exceed the Gross Vehicle Weight Rating (GVWR) listed on the Safety Certification Label. In addition - 2008 Suzuki Grand Vitara | Owner's Manual - Page 242
instructions in the "EMERGENCY SERVICE" section of this manual if it is necessary to jump start your vehicle. WARNING Battery posts, terminals and related accessories rinse with clean water. The test indicator on the top of the battery provides information on the condition of the battery. If your - 2008 Suzuki Grand Vitara | Owner's Manual - Page 243
fuse O2 sensor heater fuse 15A THR MOT Throttle motor fuse 20A AT 25A RR DEF 15A HORN 20A FR FOG Automatic transmission fuse Rear defogger fuse Horn fuse Front fog light fuse The main fuse, primary fuses and some of the individual fuses are located in the engine compartment. If the main fuse - 2008 Suzuki Grand Vitara | Owner's Manual - Page 244
INSPECTION AND MAINTENANCE Fuse under the Dash Board PRIMARY FUSE 60A LAMP INDIVIDUAL FUSE Head light, Accessory, Dome light, Sunroof, Hazard light, Door lock, Rear fog light, Stop lamp, Tail light Wiper/Washer, Power window, Seat heater 4WD actuator Radiator fan Radiator fan 64J192 Fuse box (A) - 2008 Suzuki Grand Vitara | Owner's Manual - Page 245
the new one blows in a short period of time, you may have a major electrical problem. Have your vehicle inspected immediately by your SUZUKI dealer. NOTE: Make sure that the fuse box cover always carries spare fuses. OK BLOWN 60A243 65D045 The fuse box is located under the driver's side of the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 246
them carefully. Center Interior Light (if equipped) CAUTION The oils from your skin may cause a halogen bulb to overheat and burst when the lights are on. Grasp a system. This should be carried out by your SUZUKI dealer. NOTE: If it is difficult to replace headlight bulbs or clearance light bulbs - 2008 Suzuki Grand Vitara | Owner's Manual - Page 247
INSPECTION AND MAINTENANCE Rear Interior Light (if equipped) Spot Light (if equipped) Pull down the lens by using a plain screw driver covered with a soft cloth as shown. Ceiling-mount type (if equipped) Headlights Low beam ( - 2008 Suzuki Grand Vitara | Owner's Manual - Page 248
INSPECTION AND MAINTENANCE Open the engine hood. Disconnect the coupler. Remove the sealing rubber. Push the retaining spring forward and unhook it. Then remove the bulb. Install a new bulb in the reverse order of removal. High beam (2) (1) (2) (1) 78F072 Front Fog Light Other General Lights Bulb - 2008 Suzuki Grand Vitara | Owner's Manual - Page 249
INSPECTION AND MAINTENANCE Bulb Parking/Turn signal light License plate light EXAMPLE (1) (3) (4) (2) 54G124 64J163 75F087 (3) Removal (4) the front grille and the headlight housing must be removed for this job. Rear combination light Door illumination light EXAMPLE 64J165 64J164 9-42 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 250
AND MAINTENANCE Luggage compartment light High-mount stop light (if equipped) (1) 64J182 64J166 64J181 To remove a high-mounted stop light housing the following procedure: 1) Open the tailgate, and remove the trim (1) as shown in the illustration. 2) Release the claws of the light housing - 2008 Suzuki Grand Vitara | Owner's Manual - Page 251
MAINTENANCE Wiper Blades (2) 64J183 64J184 3) Close the tailgate. Remove a highmounted stop light housing (2) from the tailgate. 4) Remove the each bulb. 5) Replace the bulbs. To install a high-mounted stop light . If so, consult your SUZUKI dealer for proper replacement method. 9-44 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 252
INSPECTION AND MAINTENANCE For windshield wipers: 52D102 70G119 60A260 1) Hold the wiper arm away from the window. 2) Squeeze lock lever (1) towards wiper arm (2) and remove the wiper frame - 2008 Suzuki Grand Vitara | Owner's Manual - Page 253
INSPECTION AND MAINTENANCE Installation For rear wipers: 52D124 52D125 (3) Retainer 4) If the new blade is provided without the two metal retainers, move them from the old blade to - 2008 Suzuki Grand Vitara | Owner's Manual - Page 254
INSPECTION AND MAINTENANCE Air Conditioning System If you do not use the air conditioner for a long period, such as during winter, it may not give the best performance when you start using it again. To help maintain optimum performance and durability of your air conditioner, it needs to be run - 2008 Suzuki Grand Vitara | Owner's Manual - Page 255
EMERGENCY SERVICE EMERGENCY SERVICE Jacking Instructions ...10-1 Jump Starting Instructions ...10-3 Towing a Disabled Vehicle ...10-4 If the Starter Does Not Operate ...10-4 If the Engine is Flooded ...10-5 If the Engine Overheats ...10-5 If You Can Not Shift Automatic Transmission Gearshift Lever - 2008 Suzuki Grand Vitara | Owner's Manual - Page 256
EMERGENCY SERVICE Jacking Instructions (1) 75F062 64J124 64J194 1) Place the vehicle on level, hard ground. 2) Set the parking brake firmly and shift into "P" (Park) if your vehicle has an automatic transmission, or shift into "R" (Reverse) if your vehicle has a manual transmission. 3) Turn on - 2008 Suzuki Grand Vitara | Owner's Manual - Page 257
Front Rear WARNING • Use the jack only to change wheels on level, hard ground. • Never jack up the vehicle on an inclined surface. • Never raise the vehicle with the jack in a location vehicle when it is supported by the jack. • Never run the engine when the vehicle is supported by the jack and - 2008 Suzuki Grand Vitara | Owner's Manual - Page 258
. When jump starting your vehicle, use the following procedure: 2) Turn off all vehicle accessories, except those necessary for safety reasons (for example, headlights or hazard lights). EXAMPLE Engine Hook Discharged Battery 12V BATTERY Charged Battery 60A270 60A269 1) Use only a 12 volt - 2008 Suzuki Grand Vitara | Owner's Manual - Page 259
the final connection to an unpainted, heavy metal part (i.e. engine hook (3)) of the engine of the vehicle with the discharged battery (1). fuses. If the reason for failure of the starter is not obvious, there may be a major electrical problem. Have the vehicle inspected by your authorized SUZUKI - 2008 Suzuki Grand Vitara | Owner's Manual - Page 260
(Do not operate the starter motor for more than 15 seconds). If the Engine Overheats The engine could overheat temporarily under severe driving conditions. If the engine coolant temperature gauge indicates overheating during driving: 1) Turn off the air conditioner, if equipped. 2) Take the vehicle - 2008 Suzuki Grand Vitara | Owner's Manual - Page 261
EMERGENCY SERVICE If transmission have an electrically operated park-lock feature. If the vehicle's battery is condition. If not, follow the procedure described below. This procedure will permit shifting the transmission out of Park. 1) Be sure the parking brake is firmly applied. 2) If the engine - 2008 Suzuki Grand Vitara | Owner's Manual - Page 262
EMERGENCY SERVICE MEMO 10-7 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 263
APPEARANCE CARE APPEARANCE CARE Corrosion Prevention ...11-1 Vehicle Cleaning ...11-3 60G412 11 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 264
and follow these instructions carefully. vehicle which are not well ventilated to permit quick drying. If you frequently drive on salted roads, time may promote corrosion even though other body sections may be completely dry. 4) High temperatures will cause an accelerated rate of corrosion to parts - 2008 Suzuki Grand Vitara | Owner's Manual - Page 265
drive exhaust system components such as the catalytic converter, exhaust colors in paint, plastic parts and fabrics to fade. Covering your vehicle with a high-quality, "breathable" vehicle cover can help protect the finish from the harmful UV rays in sunlight, and can reduce the amount of dust and air - 2008 Suzuki Grand Vitara | Owner's Manual - Page 266
follow the manufacture's instructions and precautions. Do not use solvent type cleaners or abrasive cleaners. Seat belts Clean seat belts with a mild soap result in fading of the paint or corrosion to various parts of the vehicle body. Cleaning Interior Vinyl upholstery Prepare a solution of soap or - 2008 Suzuki Grand Vitara | Owner's Manual - Page 267
test the brakes before driving to make sure they have maintained their normal effectiveness. When washing the vehicle, follow the instructions below: 1) Flush the underside of body and wheel spots lightly using car parts. • To avoid damaging engine components, do not use pressurized water in the engine - 2008 Suzuki Grand Vitara | Owner's Manual - Page 268
APPEARANCE CARE MEMO 11-5 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 269
GENERAL INFORMATION GENERAL INFORMATION Identification Numbers ...12-1 Safety Certification Label ...12-2 Emission Compliance Label (for U.S.A.) ...12-2 Warranties ...12-2 On-Board Vehicle Computers and Event Data Recorders ...12-3 Reporting Safety Defects ...12-4 54G072 12 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 270
) may be found in the two locations shown in the above illustrations. This number is used to register the vehicle. It is also used to assist your dealer when ordering parts or referring to special service information. Engine Serial Number 66J160 60G152 The engine serial number is stamped on the - 2008 Suzuki Grand Vitara | Owner's Manual - Page 271
at the time of sale. Please read this booklet carefully so you can understand your rights and responsibilities. For U.S.A. The following warranties are provided with your vehicle: • New Vehicle Limited Warranty • Limited Warranty For SUZUKI Parts or Accessories • Emission Components Defect Warranty - 2008 Suzuki Grand Vitara | Owner's Manual - Page 272
. If your vehicle has an Electronic Stability Program (ESP®) system, conditions such as yaw rate, lateral acceleration, and brake fluid pressure are monitored, so that the ESP® system can help the driver control the vehicle in difficult driving situations. Some information may be stored by the on - 2008 Suzuki Grand Vitara | Owner's Manual - Page 273
that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately inform the National Highway Traffic Safety Administration (NHTSA) in addition to notifying American Suzuki Motor Corp. If NHTSA receives similar complaints, it may open an investigation - 2008 Suzuki Grand Vitara | Owner's Manual - Page 274
GENERAL INFORMATION MEMO 12-5 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 275
RR DEF HORN FR FOG MRR HTR FR BLW ABS 2 FUSES PROTECTED CIRCUIT A/C compressor fuse O2 sensor heater fuse Throttle motor fuse Automatic transmission fuse Rear defogger fuse Horn fuse Front fog light fuse Mirror heater fuse Front blower motor fuse ABS actuator fuse In engine compartment 13 13-1 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 276
R H/L ST MTR IGN H/L LO L H/L LO R FUSES PROTECTED CIRCUIT ABS actuator fuse Main fuse Blank Head light high beam fuse, left Head light high beam fuse, right Head light fuse Starter motor fuse Ignition fuse Head light low beam fuse, left Head light low beam fuse, right In engine compartment 13-2 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 277
(20) PINK (30) FUSES IN FUSE BOX ST SIG RR BLOW S/R DOME TAIL D/L ACC METER IG COIL P/W T P/W Starter signal fuse Blank Sun roof motor fuse Dome lamp fuse Tail light fuse Door lock actuator fuse Radio, Remote door mirror fuse Meter fuse Ignition coil fuse Power window fuse Power window fuse 13-3 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 278
FUSES AND PROTECTED CIRCUITS MEMO 13-4 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 279
ground clearance 4WD: 4-wheel drive 2WD: 2-wheel drive UNIT: mm (in.) 4470 (176.0) 1810 (71.3) 1695 (66.7) 1683 (66.3) 2640 (103.9) 1540 (60.6) 1560 (61.4) 200 (7.9) 188 (7.4) M/T: Manual transmission A/T: Automatic transmission 4WD 2WD front rear 4WD 2WD ITEM: Weight Gross axle weight rating - 2008 Suzuki Grand Vitara | Owner's Manual - Page 280
W5W W5W ITEM: Lights Headlight Front fog light Turn signal light Parking light Brake/tail light License plate light Reversing light High mount stop light Door illumination light Dome light Low beam High beam front rear Halogen Spot light Center light Rear light Luggage compartment light 14-2 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 281
the Tire Information Label located on the driver's door lock pillar. ITEM: Steering Toe-in Camber angle Caster angle ITEM: Capacities (approx.) Coolant Fuel tank Engine oil (replaced with filter) Transmission oil Differential gear oil front rear front rear front 0 ± 2 mm (0 ± 0.08 in.) 6 ± 2 mm - 2008 Suzuki Grand Vitara | Owner's Manual - Page 282
SPECIFICATIONS MEMO 14-4 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 283
System (ABS) Warning Light ...4-5 Anti-Lock Braking System (ABS) ...6-19 Armrest ...5-7 Assist Grips ...5-10 Audio Systems ...4-28 Automatic Heating and Air Conditioning System (Climate Control) ...4-21 C Catalytic Converter ...6-25 Changing Engine Oil and Filter ...9-11 Changing Wheels ...9-30 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 284
...5-4 Frame Hooks ...5-17 Front Air Bags ...2-39 Front Fog Light Switch ...4-16 Front Passenger's Seat Belt Reminder Light ...4-3 Front Seat Back Pocket ...5-19 Front Seat Heater ...5-9 Fuel Consumption and Driving Range ...4-18 I Identification Numbers ...12-1 If the Engine is Flooded ...10-5 If - 2008 Suzuki Grand Vitara | Owner's Manual - Page 285
Severe Driving Conditions ...9-7 Maintenance Schedule ...9-2 Malfunction Indicator Light ...4-8 Manual Transmission ...6-7 Mirrors ...2-16 J Jacking Instructions ...10-1 Jump Starting Instructions ...10-3 N National Highway Traffic Safety Administration (NHTSA) ...12-4 K Keyless Entry System - 2008 Suzuki Grand Vitara | Owner's Manual - Page 286
...9-15 Specified Gear Oil ...9-13 Specified Oil ...9-9 Speedometer ...4-11 Spot Light ...5-8 Stability Control System ...6-18 Starting the Engine ...6-2 Steering Wheel ...9-23 Sun Visor ...5-7 Sunroof ...5-11 Supplemental Restraint System (air bags) ...2-37 R Radio Antenna ...4-35 Rear Window - 2008 Suzuki Grand Vitara | Owner's Manual - Page 287
System ...6-18 Trailer Towing ...8-2 Transfer Position Indicator Light ...4-10 Transfer Switch ...4-17 Tripmeter ...4-11 Troubleshooting Vehicle With Keyless Start System ...3-2, 6-3 Vehicle Without Keyless Start System ...3-1 W Warning and Indicator Lights ...4-3 Warranties ...12-2 Washing ...11 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 288
INDEX MEMO 15-6 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 289
Prepared by June, 2007 Part No. 99011-66J22-03E Printed in Japan TP286 - 2008 Suzuki Grand Vitara | Owner's Manual - Page 290
For further details, see "Engine Oil and Filter" in the "INSPECTION AND MAINTENANCE" section. Brake and clutch fluid: DOT3 Automatic transmission fluid: SUZUKI ATF 3317 or Mobil ATF 3309 Tire cold pressure: See the "Tire Information Label" located on the driver's door lock pillar. Made from 100
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
-
101
-
102
-
103
-
104
-
105
-
106
-
107
-
108
-
109
-
110
-
111
-
112
-
113
-
114
-
115
-
116
-
117
-
118
-
119
-
120
-
121
-
122
-
123
-
124
-
125
-
126
-
127
-
128
-
129
-
130
-
131
-
132
-
133
-
134
-
135
-
136
-
137
-
138
-
139
-
140
-
141
-
142
-
143
-
144
-
145
-
146
-
147
-
148
-
149
-
150
-
151
-
152
-
153
-
154
-
155
-
156
-
157
-
158
-
159
-
160
-
161
-
162
-
163
-
164
-
165
-
166
-
167
-
168
-
169
-
170
-
171
-
172
-
173
-
174
-
175
-
176
-
177
-
178
-
179
-
180
-
181
-
182
-
183
-
184
-
185
-
186
-
187
-
188
-
189
-
190
-
191
-
192
-
193
-
194
-
195
-
196
-
197
-
198
-
199
-
200
-
201
-
202
-
203
-
204
-
205
-
206
-
207
-
208
-
209
-
210
-
211
-
212
-
213
-
214
-
215
-
216
-
217
-
218
-
219
-
220
-
221
-
222
-
223
-
224
-
225
-
226
-
227
-
228
-
229
-
230
-
231
-
232
-
233
-
234
-
235
-
236
-
237
-
238
-
239
-
240
-
241
-
242
-
243
-
244
-
245
-
246
-
247
-
248
-
249
-
250
-
251
-
252
-
253
-
254
-
255
-
256
-
257
-
258
-
259
-
260
-
261
-
262
-
263
-
264
-
265
-
266
-
267
-
268
-
269
-
270
-
271
-
272
-
273
-
274
-
275
-
276
-
277
-
278
-
279
-
280
-
281
-
282
-
283
-
284
-
285
-
286
-
287
-
288
-
289
-
290
 |
 |
Part No. 99011-66J22-03E
July, 2007
OWNER’S MANUAL
Keep With Vehicle At All Times.
Contains Important Information
On Safety, Operation & Maintenance.
2008