2004 Toyota Corolla Owners Manual
2004 Toyota Corolla Manual
2004 Toyota Corolla manual content summary:
- 2004 Toyota Corolla | Owners Manual - Page 1
'04 Corolla_U (L/O 0306) SECTION Overview of instruments and controls 1− 1 OPERATION OF INSTRUMENTS AND CONTROLS Instrument panel overview ...2 Instrument cluster overview ...4 Indicator symbols on the instrument panel ...6 1 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 2
9. Glove box 10. Portable ashtray 11. Rear console box 12. Cup holders 13. Power outlet 14. Parking brake lever 15. Automatic transmission selector lever or manual transmission gear shift lever 16. Hood lock release lever 17. Window lock switch 2 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 3
1. Headlight, turn signal and front fog light switches 2. Wiper and washer switches 3. Emergency flasher switch 4. Car audio 5. Clock 6. Front passenger's seat belt reminder light 7. Rear window defogger switch 8. Auxiliary boxes 9. Power outlet or cigarette lighter 10. Air conditioning controls 11 - 2004 Toyota Corolla | Owners Manual - Page 4
0306) Instrument cluster overview "Type A 1. Service reminder indicators and indicator lights 2. Tachometer 3. Speedometer 4. Engine coolant temperature gauge 5. Fuel gauge 6. Trip meter reset knob 7. Odometer, two trip meters and outside temperature display 4 2004 COROLLA from Oct. '03 Prod - 2004 Toyota Corolla | Owners Manual - Page 5
'04 Corolla_U (L/O 0306) "Type B 1. Service reminder indicators and indicator lights 2. Tachometer 3. Speedometer 4. Engine coolant temperature gauge 5. Fuel gauge 6. Trip meter reset knob 7. Odometer, two trip meters and outside temperature display 5 2004 COROLLA from Oct. '03 Prod. (OM12859U - 2004 Toyota Corolla | Owners Manual - Page 6
Low engine oil pressure warning light∗1 or Brake system warning light∗1 or Driver's seat belt reminder light∗1 Anti −lock brake system warning light∗1 Front passenger's seat belt reminder light∗1 Open door warning light∗1 Discharge warning light∗1 SRS warning light∗1 Low windshield washer fluid - 2004 Toyota Corolla | Owners Manual - Page 7
light Cruise control indicator light∗2 ∗1 : ∗2 : ∗3 : For details, see "Service reminder indicators and warning buzzers" on page 88 in Section 1 −6. If this light flashes, see "Cruise control" on page 102 in Section 1−7. This symbol equipped only on vehicles sold in Canada. 7 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 8
'04 Corolla_U (L/O 0306) 8 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 9
0306) SECTION Keys and Doors 1− 2 10 10 17 19 21 22 24 25 OPERATION OF INSTRUMENTS AND CONTROLS Keys ...Side doors ...Power windows ...Trunk lid ...Toyota vehicle intrusion protection system (TVIP) ...Hood ...Fuel tank cap ...Electric moon roof ... 9 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 10
of keys. 1. Master keys-These keys work in every lock. 2. Sub key-This key will not work in the trunk. To protect items locked if you need additional keys, duplicates can be made by a Toyota dealer using the key number. We recommend writing down the key 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 11
instrument panel light control" on page 79 in Section 1−5.) CAUTION Do not pull the inside handle of the front doors while driving. The doors will open and an accident may occur. Toyota strongly recommends that is open and the key is in the ignition. 11 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 12
key to "ON". D Unlock all the doors with the key or wireless remote control transmitter. D Unlock the driver's door or front pasPassenger's side senger's door with the inside lock knob, and then unlock all the doors with the power door lock switch. 12 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 13
. To unlock: Push the "UNLOCK" switch once to unlock the driver's door alone. Pushing the switch twice within 3 seconds unlocks all the doors simultaneously. Each time the "UNLOCK" switch is pushed, the turn signal lights will flash twice. Unlocking operation 13 2004 COROLLA from Oct. '03 Prod - 2004 Toyota Corolla | Owners Manual - Page 14
transmitter such as a radio station or an airport which can interfere with normal operation of the transmitter. D The battery may have been consumed. Check the battery in the transmitter. To replace the battery, see "REPLACING TRANSMITTER BATTERY". 14 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 15
only with the same or equivalent type recommended by a Toyota dealer. z Dispose of used batteries according to the local laws. Replace the transmitter battery by following these procedures: 1. Using a coin or equivalent, open the transmitter case. 15 2004 COROLLA from Oct. '03 Prod. (OM12859U - 2004 Toyota Corolla | Owners Manual - Page 16
the transmitter battery insertion and that dust or oils do not adhere to the transmitter case. z Close the transmitter case securely. After replacing the battery, check that the transmitter operates properly. If the transmitter still does not operate properly, contact your Toyota dealer. 2. Remove - 2004 Toyota Corolla | Owners Manual - Page 17
also has switches that control the passengers' windows. The window moves as long as you hold the switch. To open: Push down the switch. To close: Pull up the switch. If you push in the window lock switch on the driver's door, the passengers' windows cannot be operated. 17 2004 COROLLA from Oct - 2004 Toyota Corolla | Owners Manual - Page 18
window switches and get trapped in a window. Unattended person (particularly a small child) can be involved in a serious accident. D Before you close the power windows, always make sure there is nobody around the power windows. You must also make sure the heads, hands and other parts of the bodies - 2004 Toyota Corolla | Owners Manual - Page 19
up to make sure it is securely closed. To open the trunk lid from the driver's seat, pull up on the lock release lever. 19 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 20
lid. The phosphorescent (glow−in−the−dark) handle will continue to glow for a time after the trunk lid is closed. Exposing the handle to stronger light will cause it to glow longer. 20 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 21
dial is in the DOOR position. (See "Interior/instrument panel light control" on page 79 in Section 1−5.) The system detects a threat under any of the following conditions: TVIP is a theft deterrent system. If someone attempts to damage or break into your vehicle, the system sounds the alarm while - 2004 Toyota Corolla | Owners Manual - Page 22
You can check the system battery terminal is disconnected and then reconnected. D The ignition is hotwired. After one minute, the alarm automatically stops and the indicator light starts control transmitter. D Place the ignition switch in the "ON" position. 22 2004 COROLLA from Oct. '03 Prod - 2004 Toyota Corolla | Owners Manual - Page 23
to your head or body. NOTICE Be sure to return the its clip before closing ing the hood with the could cause the hood support rod to the hood. Clossupport rod up to bend. 2. In front of the vehicle, pull up the auxiliary catch lever and lift the hood. 3. Hold the hood open - 2004 Toyota Corolla | Owners Manual - Page 24
sparks or allow open flames when refueling. The fumes are flammable. D When opening the cap, do not remove the cap quickly. In hot weather, fuel under pressure could cause injury by spraying out of the filler neck if the cap is suddenly removed. 24 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 25
prevent fuel spillage in case of an accident. D Use only a genuine Toyota fuel tank cap for replacement. It is designed to regulate fuel tank pressure. The sun shade will be opened together with the roof. To close: Push the switch on the front side. As a precaution when closing, the roof stops at - 2004 Toyota Corolla | Owners Manual - Page 26
switch is being pushed and stop when released. D Before you close the moon roof, always make sure there is nobody around the moon roof. You must also make sure nobody places his or her head, hands and other parts of the body hands and other parts of the bodies of all moon roof switches and get - 2004 Toyota Corolla | Owners Manual - Page 27
systems 1− 3 28 28 31 32 33 41 48 53 OPERATION OF INSTRUMENTS AND CONTROLS Seats ...Front seats ...Fold −down rear seat ...Head restraints ...Seat belts ...SRS driver airbag and front passenger airbag ...SRS side airbags ...Child restraint ... 27 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 28
controls. D During driving, do not allow any passengers to stand up or move around between seats. Otherwise, severe injuries can occur in the event of emergency braking or a collision. D Move your seat to the rear as far as you can while still reaching the pedals comfortably. 28 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 29
Do not modify or replace the seats or upholstery of the seats with side airbags. Such change may prevent the side airbag system from activating correctly, disable the system or cause the side airbag system to inflate accidentally, resulting in death or serious injury. 29 2004 COROLLA from Oct. '03 - 2004 Toyota Corolla | Owners Manual - Page 30
under the seat or near the moving parts. Otherwise, your hands or fingers may be caught and injured. 1. SEAT POSITION ADJUSTING LEVER Hold the center of the lever and pull it up. Then slide the seat to the desired position with slight body pressure and release the lever. 2. SEAT HEIGHT ADJUSTING - 2004 Toyota Corolla | Owners Manual - Page 31
sitting up straight and well back in the seats. If you are reclined, the lap belt may slide past your hips and apply restraint forces directly to the abdomen. In the the webbing of the rear center seat belt when the right seatback is folded down. 31 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 32
RETURNING REAR SEAT Make sure the shoulder belt pass through the guide when returning the seatback up. D Make sure the seat belts are not twisted or caught in the seatback and are arranged in the proper position and are ready to use. Front Rear 32 2004 COROLLA from Oct. '03 Prod. (OM12859U - 2004 Toyota Corolla | Owners Manual - Page 33
and as low as possible over the hips and not on the waist. Injured person. Toyota recommends the use of a seat belt. Depending on the injury, first check with your doctor for specific recommendations. CAUTION D Adjust the center of the head restraint so that it is closest to the top of your ears - 2004 Toyota Corolla | Owners Manual - Page 34
get caught or pinched in the seat or doors. Tab D Inspect the belt system periodically. Check for cuts, fraying, and loose parts. Damaged parts should be replaced. Do not disassemble or modify the system. Buckle D Keep the belts clean and dry. If they need cleaning, use a mild soap solution or - 2004 Toyota Corolla | Owners Manual - Page 35
the portion upward through the latch D If the seat belt does not function normally, immediately contact your Toyota dealer. Do not use the seat until the seat belt is fixed, because it cannot protect an adult occupant or your child from injury. 35 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 36
anchor is locked in position. To release the belt, press the buckle release button and allow the belt to retract. If the belt does not retract smoothly, pull it out and check for kinks or twists. Then make sure it remains untwisted as it retracts. 36 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 37
seat belt, the seat belt will not securely hold the child restraint system, which could cause death or serious injury to the child or other passengers in the event of collision. CAUTION When using the seat belt extender, observe the following precautions. Failure to follow these instructions could - 2004 Toyota Corolla | Owners Manual - Page 38
contact your Toyota dealer. Do not use the seat until the seat belt is belts snugly restrain the occupants. The seat belt pretensioners are activated even with no passenger in the front seat. The seat belt pretensioners and SRS airbags may not operate together in all collisions. 38 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 39
the illustration. 1. Front airbag sensors 2. Seat belt pretensioner assemblies 3. Airbag sensor assembly 4. SRS warning light The seat belt pretensioners are controlled by the airbag sensor assembly. The airbag sensor assembly consists of a safing sensor and airbag sensor. 39 2004 COROLLA from Oct - 2004 Toyota Corolla | Owners Manual - Page 40
Corolla_U (L/O 0306) If any of the this indicates or seat belt Toyota dealer following conditions occurs, a malfunction of the airbags pretensioners. Contact your as soon as possible. D When the ignition key is turned to the "ON" position, the light does not come on, remains on or flashes. D The - 2004 Toyota Corolla | Owners Manual - Page 41
. The SRS front airbags help reduce injuries mainly to the driver's or front passenger's head or chest caused by hitting the vehicle interior. The front passenger airbag is activated even with no passenger in the front seat. Always wear your seat belt properly. 41 2004 COROLLA from Oct. '03 - 2004 Toyota Corolla | Owners Manual - Page 42
involved in a side or rear collision, if it rolls over, or if it is involved in a low− speed frontal collision. But, whenever a collision of any type causes sufficient forward deceleration of the vehicle, deployment of the SRS front airbags may occur. 42 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 43
passenger (airbag and inflator) 3. Driver's seat belt buckle switch 4. Driver's seat position sensor 5. Airbag sensor assembly 6. Airbag module for driver (airbag and inflator) 7. SRS warning light The airbag sensor assembly consists of a safing sensor and airbag sensor. 43 2004 COROLLA from Oct - 2004 Toyota Corolla | Owners Manual - Page 44
any object or part of the body between the occupant and the airbag module; sit straight and well back into the seat; wear the available seat belt properly; and sit as far as possible from the airbag module, while still maintaining control of the vehicle. Parts of the airbag module (steering wheel - 2004 Toyota Corolla | Owners Manual - Page 45
53 in this Section. D Toyota strongly recommends that all infants and children be placed in the rear seat of the vehicle and be properly restrained. D Do not put anything or any part of your baby on or in front of the dashboard or steering wheel pad that houses the front airbag system. They might - 2004 Toyota Corolla | Owners Manual - Page 46
airbag sensors, driver's seat position sensor, driver's seat belt buckle switch, seat belt pretensioner assemblies, inflators, warning light, interconnecting wiring and power sources. (For details, see "Service reminder indicators and warning buzzers" on page 88 in Section 1 −6.) 46 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 47
or seat belt Toyota dealer following conditions occurs, a malfunction of the airbags pretensioners. Contact your as soon as possible. NOTICE Do not disconnect the battery cables before contacting your Toyota dealer. D When the ignition key is turned to the "ON" position, the light does not - 2004 Toyota Corolla | Owners Manual - Page 48
no passenger in the front seat. Always wear your seat belt properly. D Do not allow anyone to lean his/her head or any part of his/her body against the front door or the area of the seat from which the SRS side airbag deploys even if he/she is a child seated in the - 2004 Toyota Corolla | Owners Manual - Page 49
. 1. SRS warning light 2. Side airbag modules (airbag and inflator) 3. Side airbag sensors 4. Airbag sensor assembly The SRS side airbag system is controlled by the airbag sensor assembly. The airbag sensor assembly consists of a safing sensor and airbag sensor. 49 2004 COROLLA from Oct. '03 - 2004 Toyota Corolla | Owners Manual - Page 50
lateral motion of the occupants. When the airbags inflate, they produce a fairly loud noise and release some smoke and residue along distributing your weight evenly in the seat. Do not apply excessive weight to the outer side of the seats on vehicles with side airbags. 50 2004 COROLLA from Oct. - 2004 Toyota Corolla | Owners Manual - Page 51
of the side structure of the passenger compartment z Repairs made on or near the console or front seat D Do not modify or replace the seats or upholstery of the seats with side airbags. Such changes may prevent the side airbag system from activating correctly, disable the system or cause - 2004 Toyota Corolla | Owners Manual - Page 52
Corolla_U (L/O 0306) If any of the this indicates or seat belt Toyota dealer following conditions occurs, a malfunction of the airbags pretensioners. Contact your as soon as possible. D When the ignition key is turned to the "ON" position, the light does not come on, remains on or flashes. D The - 2004 Toyota Corolla | Owners Manual - Page 53
the battery cables before contacting your Toyota dealer. Toyota strongly urges seat belt or child restraint system depending on the age and size of the child. Holding a airbag could inflate with considerable speed and force. Otherwise, the child may be killed or seriously injured. 53 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 54
system Child restraint systems are classified into the following 3 types depending on the child's age and size. (A) Infant seat (B) Convertible seat (C) Booster seat Install the child restraint system following the instructions provided by its manufacturer. Your vehicle has anchor brackets for - 2004 Toyota Corolla | Owners Manual - Page 55
'04 Corolla_U (L/O 0306) -Installation with seat belt (A) Infant seat (C) Booster seat (A) INFANT SEAT INSTALLATION An infant seat must be used in rear − facing position only. (B) Convertible seat 55 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 56
inflation of the front passenger airbag could cause death or serious injury to the child if the rear −facing child restraint system is installed on the front passenger seat. 1. Run the lap and shoulder belt through or around the infant seat following the instructions provided by its manufacturer - 2004 Toyota Corolla | Owners Manual - Page 57
infant seat securely, make sure the belt is in the lock mode before letting the belt retract. 3. While pressing against the seat let the shoulder it will go to hold ly. the infant seat firmly cushion and seatback, belt retract as far as the infant seat secure- 57 2004 COROLLA from Oct. '03 Prod - 2004 Toyota Corolla | Owners Manual - Page 58
belt will move freely again and be ready to work for an adult or older child passenger. (B) CONVERTIBLE SEAT INSTALLATION A convertible seat must be used in forward−facing or rear −facing position depending on the age and size of the child. When installing, follow the manufacturer's instructions - 2004 Toyota Corolla | Owners Manual - Page 59
airbags, do not allow the child to lean his/her head or any part of his/her body against the front door or the area of the seat from which the side airbags possible, because the front passenger airbag could inflate with considerable speed of the front passenger airbag could cause death or serious injury - 2004 Toyota Corolla | Owners Manual - Page 60
the child or front seat occupant(s) may be killed or seriously injured in case of sudden braking or a collision. 1. Run the lap and shoulder belt through or around the convertible seat following the instructions provided by its manufacturer and insert the tab into the buckle taking care not to twist - 2004 Toyota Corolla | Owners Manual - Page 61
, let the shoulder belt retract as far as it will go to hold the convertible seat securely. CAUTION Push and pull the child restraint system in different directions to be sure it is secure. Follow all the installation instructions provided by its manufacturer. 61 2004 COROLLA from Oct. '03 - 2004 Toyota Corolla | Owners Manual - Page 62
convertible seat, press the buckle release button and allow the belt to retract completely. The belt will move freely again and be ready to work passenger airbag could inflate with considerable speed and force. Otherwise, the child may be killed or seriously injured. 62 2004 COROLLA from Oct - 2004 Toyota Corolla | Owners Manual - Page 63
'04 Corolla_U (L/O 0306) D On vehicles with side airbags, do not allow the child to lean his/her head or any part of his/her body against the front door or the area of the seat from which the side airbags deploy even if the child is seated in the child restraint system. It is dangerous - 2004 Toyota Corolla | Owners Manual - Page 64
system on the seat until the seat belt is fixed. 2. To remove the child restraint system, press the buckle release button and allow the belt to retract. Follow the procedure below for a child restraint system that requires the use of a top strap. 64 2004 COROLLA from Oct. '03 Prod. (OM12859U - 2004 Toyota Corolla | Owners Manual - Page 65
of the anchor bracket. TO USE THE ANCHOR BRACKET: 1. Outside anchor brackets only- Remove the head restraint. 2. Open the lid of the anchor bracket. 65 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 66
system with a seat belt on the vehicle. CAUTION Make sure the top strap is securely latched, and check that the child restraint system is secure by pushing and pulling it in different directions. Follow all the installation instructions provided by its manufacturer. 66 2004 COROLLA from Oct. '03 - 2004 Toyota Corolla | Owners Manual - Page 67
lower connector system. CHILD RESTRAINT INSTALLATION Type A- 1. Widen the clearance between the anchorages and tighten the lower straps. Type B- 1. Widen the clearance between the seat the buckles onto the anchorages. Canada only Type A Canada only Type B SYSTEM If your child restraint system has - 2004 Toyota Corolla | Owners Manual - Page 68
instruction manual equipped with each product. CAUTION D When using the lower anchorages for the child restraint system, be sure that there are no irregular objects around the anchorages or that the seat belt in case of sudden braking or a collision. 68 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 69
) SECTION Steering wheel and Mirrors 1− 4 70 70 72 72 73 OPERATION OF INSTRUMENTS AND CONTROLS Tilt steering wheel ...Outside rear view mirrors ...Anti−glare inside rear view mirror ...Auto anti−glare inside rear view mirror ...Vanity mirrors ... 69 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 70
. To change the steering wheel angle, hold the steering size or distance of any object seen in the outside rear view mirror on the passenger's side because it is a convex mirror. Any object seen in a convex mirror will look smaller and farther away than when seen in a flat mirror. 70 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 71
, use the switches. 1. Master switch-To select the mirror to be adjusted Push the switch to "L" (left) or "R" (right). 2. Control switch-To move the mirror Push the switch in the desired direction. Mirrors can be adjusted when the key is in the "ACC" or "ON" position. 71 2004 COROLLA from Oct - 2004 Toyota Corolla | Owners Manual - Page 72
rear of your vehicle in the mirror. To reduce glare from the headlights of the vehicle behind you during night driving, operate the lever on anti − glare function. The function is designed to reduce glare from the headlights of the vehicle behind you during night driving. When the ignition key is - 2004 Toyota Corolla | Owners Manual - Page 73
light. To turn off the automatic function, push the " " switch. To turn on the automatic function again, push the " " switch. Adjust it before driving so that the rear view is in the best condition. When the inside air , etc. Front passenger's side 73 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 74
'04 Corolla_U (L/O 0306) Driver's side only-To use the vanity mirror, open the cover. 74 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 75
76 78 79 79 80 81 82 OPERATION OF INSTRUMENTS AND CONTROLS Headlights and turn signals ...Emergency flashers ...Front fog lights ...Interior/instrument panel light control ...Personal lights ...Windshield wipers and washer ...Rear window defogger ... 75 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 76
is activated. Also, the other exterior lights and instrument panel lights automatically turn on or off. Light reminder buzzer A buzzer will remind you to turn the lights off when the driver's door is opened if you remove the key with the headlight switch on. 76 2004 COROLLA from Oct. '03 Prod - 2004 Toyota Corolla | Owners Manual - Page 77
daytime running light control sensor is on the top of the driver's side instrument panel. Do not place anything on the instrument panel, and/or do not affix anything on the windshield to block this sensor. D The engine is running. D The parking brake is released. D The headlight/turn signal lever - 2004 Toyota Corolla | Owners Manual - Page 78
lanes. To signal a lane change, move the lever up or down to the pressure point (position 2) and hold it. If the turn signal indicator lights (green lights) on the instrument panel flash faster than normal, a front or rear turn signal bulb is burned out. See "Replacing light bulbs" on page 243 in - 2004 Toyota Corolla | Owners Manual - Page 79
control transmitter, the light will come on and remain on for 15 seconds before fading out. To prevent the battery being discharged, the light will automatically turn off when the key is removed and the door is left opened with the dial in the DOOR position for 20 minutes or more. 79 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 80
the battery from discharging, the lights will turn off automatically 20 minutes after you turn the ignition switch to the "ACC" or "LOCK" position. Type B only-The lights will come on again when you open any of the doors, and the light will remain on for 20 minutes. Type B 80 2004 COROLLA from - 2004 Toyota Corolla | Owners Manual - Page 81
This function will be canceled when you turn the ignition switch to the "ON" position. With interval adjuster: couple of times after the washer squirts. For instructions on adding washer fluid, see "Adding washer fluid" on page 243 in Section 7−3. In 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 82
for a long time could cause the battery to discharge, especially during stop−and light will illuminate to indicate the defogger is operating. Push the switch once again to turn the defogger off. The system will automatically shut off after the defogger has operated about 15 minutes. 82 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 83
OPERATION OF INSTRUMENTS AND CONTROLS Gauges, Meters and Service reminder indicators Fuel gauge ...Engine coolant temperature gauge ...Tachometer ...Odometer and two trip meters ...Outside temperature display ...Service reminder indicators and warning buzzers ... 83 2004 COROLLA from Oct. '03 Prod - 2004 Toyota Corolla | Owners Manual - Page 84
switch is on. Nearly full-Needle at "F" Nearly empty-Needle at "E" It is a good idea to keep the tank over 1/4 full. The needle moves when braking level warning light may come on Toyota dealer as soon as possible. Engine coolant temperature gauge Type A Type A Type B Type B 84 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 85
D Idling for a long period with the air conditioning on in stop−and−go traffic. D Towing a trailer. NOTICE z Do not remove the thermostat in the engine cooling system as this may cause the engine to overheat. The thermostat is designed to control the flow of coolant to keep the temperature of the - 2004 Toyota Corolla | Owners Manual - Page 86
hold the knob until the meter is set to zero. The same process can be applied for resetting the trip meter B. Outside temperature display This meter displays the odometer and two trip meters when the ignition switch disconnected. Fahrenheit display 86 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 87
of the outside air temperature sensor, " −−" will appear on the display. If " −−" appears on the display, contact your Toyota dealer. There may be a case that "−−" appears momentarily when the ignition is quickly turned to "ON". It is normal if it goes out soon. 87 2004 COROLLA from Oct. '03 - 2004 Toyota Corolla | Owners Manual - Page 88
parking brake is off, stop immediately and contact Toyota dealer. (a) or (b) (indicator and buzzer) Fasten driver's seat belt. (c) Fasten front passenger's seat belt. (d) Stop and check. (e) or Take vehicle to Toyota dealer. (f) Fill up tank. (g) Stop and check. 88 2004 COROLLA from - 2004 Toyota Corolla | Owners Manual - Page 89
. If brake system warning light is also on, stop immediately and contact Toyota dealer. (h) or (i) Close all doors. (j) Take vehicle to Toyota dealer immediately. (k) Add washer fluid. (l) Key reminder buzzer Remove key. (m) Light reminder buzzer Turn off lights. 89 2004 COROLLA from - 2004 Toyota Corolla | Owners Manual - Page 90
to 8 seconds. (c) Front Passenger's Reminder Light Seat Belt D When the brake fluid level is low...CAUTION It is dangerous to continue driving normally when the brake fluid level is low. Have your vehicle checked at your Toyota dealer in the following cases: This light reminds you to buckle up the - 2004 Toyota Corolla | Owners Manual - Page 91
driving, there is a problem somewhere in the charging system. The engine ignition will continue to operate, however, until the battery is discharged. Turn off the air conditioning, blower, radio, etc., and drive directly to the nearest Toyota dealer or repair shop. D Loose fuel tank cap If the fuel - 2004 Toyota Corolla | Owners Manual - Page 92
's seat belt buckle switch, seat belt pretensioner assemblies, inflators, warning light, interconnecting wiring and power sources. If either of the following conditions occurs, this indicates a malfunction somewhere in the parts monitored by the warning light system. Contact your Toyota dealer as - 2004 Toyota Corolla | Owners Manual - Page 93
with the key removed from the ignition switch. CHECKING SERVICE REMINDER INDICATORS (except the low fuel level warning light and low windshield washer fluid level warning light*) 1. Apply the parking brake. 2. Open one of the doors. The open door warning light should come on. 3. Close the door. The - 2004 Toyota Corolla | Owners Manual - Page 94
'04 Corolla_U (L/O 0306) 94 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 95
0306) SECTION 1− 7 OPERATION OF INSTRUMENTS AND CONTROLS Ignition switch, Transmission and Parking brake Ignition switch with steering lock ...96 Automatic transmission ...97 Manual transmission ...100 Parking brake ...101 Cruise control ...102 95 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 96
key when the vehicle is moving, as this will lock the steering wheel and result in loss of steering control. NOTICE Do not leave the key in the "ON" position if the engine is not running. The battery will discharge and the ignition could be damaged. 96 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 97
on) 2: Stronger engine braking With the brake pedal depressed, shift while holding the lock release button in. (The ignition switch must be in "ON" position.) Shift while holding the lock release button in. L: Maximum engine braking Shift normally. Overdrive switch 97 2004 COROLLA from Oct - 2004 Toyota Corolla | Owners Manual - Page 98
and releasing the overdrive switch, engine braking will not be enabled because the cruise control is not cancelled. For ways to decrease the vehicle speed, see "Cruise control" on page 102 in this Section. (c) Normal driving 1. Start the engine as instructed in "How to start the engine" on page 170 - 2004 Toyota Corolla | Owners Manual - Page 99
, the overdrive should be turned off. Be sure to turn the switch on immediately afterward. D When towing a trailer, in order to maintain engine braking efficiency, do not use overdrive. NOTICE Never shift into reverse while the vehicle is moving. 99 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 100
lever" on page 199 in Section 4. Under cold engine conditions For constant −speed cruise or constant −speed cruise after deceleration High altitude -Higher than 1219 m (4000 ft.) Upshifting The shift pattern is conventional as shown above. Press the clutch pedal down fully while shifting, and then - 2004 Toyota Corolla | Owners Manual - Page 101
D If it is difficult to shift into reverse, put the transmission in neutral, release the clutch pedal momentarily, and then try again. D When towing a trailer, in order to maintain engine braking efficiency, do not use fifth gear. CAUTION Be careful when downshifting on a slippery surface. Abrupt - 2004 Toyota Corolla | Owners Manual - Page 102
in relation to the cruise control set speed, cancel the cruise control then downshift the transmission to use engine braking to slow down. CAUTION To avoid accidental cruise control engagement, keep the "CRUISE ON−OFF" switch off when not using the cruise control. 102 2004 COROLLA from Oct. '03 - 2004 Toyota Corolla | Owners Manual - Page 103
other than for the above cases, have your vehicle checked by your Toyota dealer at the earliest opportunity. RESETTING TO A FASTER SPEED Push For manual transmission: While driving with the cruise control on, do not shift to neutral without depressing the clutch pedal, as this may cause engine - 2004 Toyota Corolla | Owners Manual - Page 104
conditions then occurs, there is some trouble in the cruise control system. D The indicator light does not come on. D The indicator light flashes again. D The indicator light goes out after it comes on. If this is the case, contact your Toyota dealer and have your vehicle inspected. 104 2004 - 2004 Toyota Corolla | Owners Manual - Page 105
'04 Corolla_U (L/O 0306) SECTION Car audio system 1− 8 OPERATION OF INSTRUMENTS AND CONTROLS Reference ...106 Using your audio system ...106 Car audio system operating hints ...119 105 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 106
AND OFF Push "PWR·VOL" to turn the audio system on and off. Push "AM", "FM 1·2", "TAPE" or "CD" to turn on that function without pushing "PWR·VOL". Type 1: AM·FM radio/compact disc player (with cassette player and compact disc changer controllers) Type 2: AM·FM radio/cassette player/compact disc - 2004 Toyota Corolla | Owners Manual - Page 107
and balance controls, see the description of your own system. Tone How good an audio program sounds changing the right/left balance will increase the volume of one group of sounds while decreasing the volume of another. YOUR RADIO ANTENNA Your vehicle has a mast type antenna. To remove the antenna - 2004 Toyota Corolla | Owners Manual - Page 108
'04 Corolla_U (L/O 0306) -Controls and features "Type 1 Details of specific buttons, controls and features are described in the alphabetical list that follows. 108 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 109
to fast forward or reverse through a compact disc track, push and hold in the fast forward or reverse button. When you release the CD", the system changes to the automatic changer. If the player malfunctions, your audio system will display one of the six following error messages. 109 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 110
changer lid is open. Close the compact disc changer lid. If the malfunction is not rectified, take your vehicle to your Toyota dealer. CONTROL / MODE (Audio control and mode adjustment) Manual are listening to a tape that was recorded with Dolbyr B Noise Reduction, B" will push the " " button. The " - 2004 Toyota Corolla | Owners Manual - Page 111
noise changer only- To randomly play all the tracks in the magazine: Push and hold to work correctly switch from cassette or compact disc operation to radio operation. PWR·VOL (Power and Volume) Push "PWR·VOL" to turn the audio system on and off. Turn "PWR·VOL" to adjust the volume. 111 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 112
all the tracks on the disc, it will stop scanning. Compact disc changer only- Scanning the first track of all the discs in the magazine: Push and hold "SCAN" until you hear a ·SCAN" will appear on the "FF 1" or "REW 1" will appear on the display. 112 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 113
automatically reverse sides and start playing the other side. There must be at least 3 seconds of blank space between tracks for the track button to work correctly. In addition, the feature may not work well with some spoken word, live, or classical recordings. 113 2004 COROLLA from Oct. '03 Prod - 2004 Toyota Corolla | Owners Manual - Page 114
'04 Corolla_U (L/O 0306) "Type 2 Details of specific buttons, controls and features are described in the alphabetical list that follows. 114 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 115
to fast forward or reverse through a compact disc track, push and hold in the fast forward or reverse button. When you release the CD", the system changes to the automatic changer. If the player malfunctions, your audio system will display one of the six following error messages. 115 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 116
changer lid is open. Close the compact disc changer lid. If the malfunction is not rectified, take your vehicle to your Toyota dealer. CONTROL / MODE (Audio control and mode adjustment) Manual are listening to a tape that was recorded with Dolbyr B Noise Reduction, B" will push the " " button. The " - 2004 Toyota Corolla | Owners Manual - Page 117
audio system is off, you can turn on the radio by pushing "FM1·2". Also, push "FM1·2" to switch order for the repeat feature to work correctly. Compact Disc Player There are feature. Compact disc changer only- Repeating a disc: Push and hold "RPT" until you 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 118
all the tracks on the disc, it will stop scanning. Compact disc changer only- Scanning the first track of all the discs in the magazine: Push and hold "SCAN" until you hear a ·SCAN" will appear on the button until "REW 3" appears on the display. 118 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 119
may cause a noise from the speakers of the audio system which you are listening to. However, this does not indicate a malfunction. RADIO RECEPTION Usually, a problem with radio reception does not mean there is a problem with your radio-it is just the normal result of conditions outside the vehicle - 2004 Toyota Corolla | Owners Manual - Page 120
common reception problems that probably do not indicate a problem two signals to reach your antenna at the same time. If to sound alternately strong and weak noise, such as high tension power lines, lightening, or electrical motors type is recommended.) 120 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 121
is intended for use with 12 cm (4.7 in.) discs only. D Extremely high temperatures can keep your compact disc player from working. On hot days, use the air conditioning to cool the vehicle interior before you listen to a disc. D Bumpy roads or other vibrations may make your compact disc player - 2004 Toyota Corolla | Owners Manual - Page 122
see a pin hole, hold the disc up to the light.) To clean a compact disc: Wipe it with a soft, lint−free cloth that has been dampened with water. Wipe in a straight line from the center to the edge of the from moisture, heat, and direct sunlight. 122 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 123
'04 Corolla_U (L/O 0306) SECTION Air conditioning system 1− 9 124 127 127 130 130 OPERATION OF INSTRUMENTS AND CONTROLS Controls ...Air flow selector settings ...Operating tips ...Side vents ...Checking and replacing the air conditioning filter ... 123 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 124
'04 Corolla_U (L/O 0306) Controls 1. "A/C" button (on some models) 2. Air intake selector 3. Temperature selector 4. Fan speed selector 5. Air flow selector 124 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 125
air intake selector mode changes to FRESH automatically to clean up the front view quickly. It is not possible to return to RECIRCULATE in this position. Air -Air flows from both the floor vents and the instrument panel vents. 3. Floor-Air flows mainly from the floor vents. 125 2004 COROLLA from - 2004 Toyota Corolla | Owners Manual - Page 126
is a problem in the air conditioning system and the air conditioning automatically shuts off. If this happens, take your vehicle to a Toyota dealer for service. Air intake selector Press the button to select the air source. 1. Recirculate (indicator light is on)-Recirculates the air inside the - 2004 Toyota Corolla | Owners Manual - Page 127
the front seats clear to allow air to circulate throughout the vehicle. D On cold days, set the fan speed to high for a minute to help clear the intake ducts of snow or moisture. This can reduce the amount of fogging on the windows. : On some models 127 2004 COROLLA from Oct. '03 Prod. (OM12859U - 2004 Toyota Corolla | Owners Manual - Page 128
Temperature-Towards blue zone Air intake-FRESH (outside air) Air flow-PANEL Air conditioning-OFF D Press the "A/C" button on for dehumidified heating. D Choose floor/windshield air flow to heat the vehicle interior while defrosting or defogging the windshield. 128 2004 COROLLA from Oct. '03 Prod - 2004 Toyota Corolla | Owners Manual - Page 129
blow cold air on the windshield-the difference between the outside and inside temperatures could make the fogging worse. Defrosting The outside of the windshield For best results, set controls to: Fan speed-Any setting except "OFF" Temperature-Towards red zone Air intake-FRESH (outside air) Air flow - 2004 Toyota Corolla | Owners Manual - Page 130
mode. To maintain the air conditioning efficiency, inspect and replace the air conditioning filter according to the maintenance schedule. (For scheduled maintenance information, please refer to the "Scheduled Maintenance Guide" or "Owner's Manual Supplement".) 130 2004 COROLLA from Oct. '03 Prod - 2004 Toyota Corolla | Owners Manual - Page 131
screw with a Phillips−head screwdriver and slide off the damper as shown. 2. Push each side of the glove box to disconnect the claws. 3. Remove the filter cover while pushing in both ends of the cover. 131 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 132
, keep the arrow pointing up. INFORMATION The air filter should be installed properly in position. The use of air conditioning with the air filter removed may cause deteriorated dustproof performance and then affect air conditioning performance. 132 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 133
equipment 1− 10 134 134 135 136 140 140 141 142 142 OPERATION OF INSTRUMENTS AND CONTROLS Clock ...Cigarette lighter and portable ashtray ...Power outlets ...Compass ...Glove box ...Auxiliary boxes ...Rear console box ...Cup holders ...Floor mat ... 133 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 134
from the clock, the time display will automatically be set to 1:00 (one o'clock). When the instrument panel lights are engine is not running, the key must be in the "ACC" position. Do not hold the cigarette lighter pressed in. Use a Toyota genuine cigarette lighter or equivalent for replacement - 2004 Toyota Corolla | Owners Manual - Page 135
accessories. for The key fuse from being blown, do not use the electricity over the total vehicle capacity of 12 V/120W. z To prevent the battery from being discharged, do not use the power outlets longer than necessary when the engine console box 135 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 136
mirror.) D The battery has been disconnected works conditions: D The vehicle is stopped immediately after turning. D The compass does not adjust while the vehicle is stopped. D The ignition switch is turned off immediately after turning. D The vehicle is on an inclined surface. 136 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 137
the vehicle, then push and hold the both personal light switches until the zone number appears on the display. Then push the right side or left side personal light switch, referring to the following map may cause malfunction of the compass sensor. 137 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 138
Do not adjust the display while the vehicle is moving. Be sure to adjust the display only when the vehicle is stopped. Zone number 138 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 139
purchased your Toyota. And then always perform circling calibration after the battery has been removed, replaced or disconnected. may not change after a turn. To rectify this, stop the vehicle and push and hold the both personal light switches until "C" 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 140
(L/O 0306) Glove box Auxiliary boxes To open the glove box door, pull the lever. Type A Type C To use the box, pull on the handle. CAUTION To reduce the chance of closed while driving. D Do not use the auxiliary box as an ashtray. Type B 140 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 141
. CAUTION To reduce the chance of injury in case of an accident or a sudden stop, always keep the console box closed while driving. CONSOLE BOX To access the rear console box, pull up the lock release lever while raising the rear console box lid. 141 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 142
cup holder is designed for holding cups or drink−cans size. If the floor carpet and floor mat have 2 holes, then they are designed for use with locking clips. Fix the floor mat with locking clips into the holes in the floor carpet. Front D To reduce the chance of injury in Rear 142 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 143
'04 Corolla_U (L/O 0306) CAUTION Make sure the floor mat is properly placed on the floor carpet. If the floor mat slips and interferes with the movement of the pedals during driving, it may cause an accident. 143 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 144
'04 Corolla_U (L/O 0306) 144 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 145
before driving your Toyota Break −in period ...Fuel ...Fuel pump shut off system ...Operation in foreign countries ...Three −way catalytic converters ...Engine exhaust cautions ...Facts about engine oil consumption ...Iridium−tipped spark plugs ...Brake system ...Brake pad wear limit indicators - 2004 Toyota Corolla | Owners Manual - Page 146
the first 800 km (500 miles). Toyota recommends the use of gasoline that contains detergent additives to avoid build−up of engine deposits. However, all gasoline sold in the U.S. contains detergent additives to keep clean and/or clean intake systems. 146 2004 COROLLA from Oct. '03 Prod. (OM12859U - 2004 Toyota Corolla | Owners Manual - Page 147
vehicle performance problems. z If driveability problems occur (poor hot starting, vaporizing, engine knock, etc.), discontinue the use. z Take care not to spill gasohol during refueling. Gasohol may cause paint damage. FUEL TANK CAPACITY 50 L (13.2 gal., 11.0 lmp. gal.) 147 2004 COROLLA from Oct - 2004 Toyota Corolla | Owners Manual - Page 148
has leaked onto the ground, it is the fuel system has been damaged and it is in need of repair. In this case, do not restart the engine. The three−way catalytic converter is an emission control device installed in the exhaust system. The purpose is to reduce pollutants in the exhaust gas. CAUTION - 2004 Toyota Corolla | Owners Manual - Page 149
the engine becomes difficult to start or stalls frequently, take your vehicle in for a check−up as soon as possible. Remember, your Toyota dealer knows your vehicle and its three−way catalytic converter system best. z To ensure that the three−way catalytic converter and the entire emission control - 2004 Toyota Corolla | Owners Manual - Page 150
used to lubricate the stems of the intake valves. Some of this oil is sucked into the combustion chamber together with the intake air and is burned along with the fuel. High temperature exhaust gases also burn the oil used to lubricate the exhaust valve stems. 150 2004 COROLLA from Oct. '03 Prod - 2004 Toyota Corolla | Owners Manual - Page 151
maintenance is to keep the engine oil at the optimum level so that oil function will not be impaired. Therefore, it is essential that the oil level be checked regularly. Toyota recommends that the oil level be checked every time you refuel the vehicle. Brake system The tandem master cylinder - 2004 Toyota Corolla | Owners Manual - Page 152
for a few seconds when the engine is started or just after the vehicle begins to move. This means that the anti −lock brake system is in the self −check mode, and does not indicate a malfunction. When the anti −lock brake system is activated, the following conditions may occur. They do not indicate - 2004 Toyota Corolla | Owners Manual - Page 153
size at appropriate pressure: The anti −lock brake system detects vehicle speeds using the speed sensors for respective wheels' turning speeds. The use of tires other than specified may fail to detect the accurate turning speed resulting in a longer stopping distance. Type B 153 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 154
is required. If you hear a squealing or scraping noise while driving, have the brake pads checked and replaced by your Toyota dealer as soon as possible. Expensive rotor damage can result if the pads are not replaced when necessary. D The light does not come on when the ignition key is turned - 2004 Toyota Corolla | Owners Manual - Page 155
is the primary identification number for your Toyota. It is used in registering the ownership of your vehicle. The vehicle identification number (VIN) is also on the Certification Label. The engine number is stamped on the engine block as shown. 155 2004 COROLLA from Oct. '03 Prod. (OM12859U - 2004 Toyota Corolla | Owners Manual - Page 156
vehicle thefts by facilitating the tracing and recovery of parts from stolen vehicles. The label is designed so the label. Transferring these labels intact from one part to another, will be impossible. Suspension and characteristics, resulting in loss of control. NOTICE You should not attempt to - 2004 Toyota Corolla | Owners Manual - Page 157
1. Tire size- For details, see "-Tire size" on details, see "Checking and replacing tires" on page TYPE"- A tubeless tire does not have a tube inside the tire and air is directly filled in the tire. A tube type tire has a tube inside the tire and the tube maintains the air pressure. 157 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 158
maximum cold tire inflation pressure- For details, see "Checking and replacing tires" on page 232. 9. Maximum cold tire inflation pressure- This means the pressure to 4. Tire size code 5. Manufacturer's optional tire type code 6. Manufacturing week 7. Manufacturing year 158 2004 COROLLA from Oct. - 2004 Toyota Corolla | Owners Manual - Page 159
-Name of each section of tire This illustration indicates typical tire size. 1. Tire use (P=Passenger car, T=Temporary use) 2. Section Sidewall 3. Shoulder 4. Tread 5. Belt 6. Inner liner 7. Reinforcing rubber 8. Carcass 9. Rim lines 10.Bead wires 11. Chafer 159 2004 COROLLA from Oct. '03 Prod. - 2004 Toyota Corolla | Owners Manual - Page 160
conditions on specified government test surfaces of asphalt and concrete. A tire marked C may have poor traction performance. Warning: The traction grade assigned to this tire is based on braking (straight ahead) traction tests and does not include cornering (turning) traction. 160 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 161
to the generation of heat and its ability to dissipate heat when tested under controlled conditions on a specified indoor laboratory test wheel. Sustained high temperature can cause the material can cause heat buildup and possible tire failure. 161 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 162
or not) The weight of a motor vehicle with standard equipment including the maximum capacity of fuel, oil, and coolant, and, if so equipped, air conditioning and additional weight optional engine The sum of- (a) Curb weight; (b) Accessory weight; (c) Vehicle capacity weight; and (d) Production - 2004 Toyota Corolla | Owners Manual - Page 163
options weighing over 2.3 kg (5 lb.) in excess of those standard items which they replace, not previously considered in curb weight or accessory weight, including heavy duty brakes, ride levelers, roof rack, heavy duty battery, and special trim The rated cargo and luggage load plus 68 kg (150 lb - 2004 Toyota Corolla | Owners Manual - Page 164
that is determined by distributing to each axle its share of the curb weight, accessory weight, and normal occupant weight (distributed in accordance with Table 1 that follows) and dividing by loaded vehicle 2 in front 2 in front, 1 in second seat 164 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 165
may increase or decrease depending on the size (weight) and the number of occupants. For weight. CAUTION D To prevent cargo and luggage from sliding forward during braking, do not stack anything in the enlarged trunk. Keep cargo and luggage low, as close to the floor as possible. 165 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 166
seat belts properly fastened. Otherwise, they are much more likely to suffer serious bodily injury, in the event of sudden braking or manual to determine how this reduces the available cargo and luggage load capacity of your vehicle. For details about trailer towing, see page 174. 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 167
the combined weight of 166 484 lb.) From this condition, if 3 more passengers with the combined weight of 176 kg (388 luggage load equaling the combined weight of occupants who got on total load capacity (combined weight of occupants plus cargo total load of occupant's weight and the cargo load is - 2004 Toyota Corolla | Owners Manual - Page 168
as this can cause dangerous handling characteristics, resulting in loss of control. D Do not use tires other than the manufacturer's designated tires, and never mix tires or wheels of the sizes different from the originally equipped tires and wheels. 168 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 169
AND DRIVING Starting and driving Before starting the engine ...How to start the engine ...Tips for driving in various conditions ...Winter driving tips ...Dinghy towing ...Trailer towing ...How to save fuel and make your vehicle last longer ... 3 170 170 171 172 173 174 179 169 2004 COROLLA from - 2004 Toyota Corolla | Owners Manual - Page 170
belts. How to start the engine- (a) Before cranking 1. Apply the parking brake firmly. 2. Turn off unnecessary lights and accessories. 3. Manual transmission: Press the clutch pedal to the floor and shift the transmission into neutral. Hold the clutch pedal to the floor until the engine is started - 2004 Toyota Corolla | Owners Manual - Page 171
systems. z Do not race a cold engine. z If the engine becomes difficult to start or stalls frequently, have the engine checked immediately. Tips for driving in various conditions D Always slow down in gusty crosswinds. This will allow you much better control. D Washing your vehicle or driving - 2004 Toyota Corolla | Owners Manual - Page 172
Do not use alcohol type antifreeze or plain water alone. When it is extremely cold, we recommend to use 60% solution for your Toyota, to provide protection down to about −50_C ( −58_F). Do not use more than 70% solution for better coolant performance. Check the condition of the battery and cables - 2004 Toyota Corolla | Owners Manual - Page 173
. CAUTION Dinghy towing requires special equipment and accessories. Please refer to your service outlet of the motorhome manufacture for the recommended equipment. NOTICE Dinghy towing does not eliminate the possibility of damage to your vehicle. 173 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 174
, turn the ignition switch to the "ACC" position. 3. Release the parking brake. After dinghy towing, let the engine idle for more than 3 minutes before driving the vehicle. NOTICE Do not tow your vehicle from the rear. This may cause serious damage to your vehicle. 174 2004 COROLLA from Oct. '03 - 2004 Toyota Corolla | Owners Manual - Page 175
, hitch and trailer tongue load. It also includes the weight of any special equipment installed on your vehicle. D The total trailer weight (trailer weight plus its cargo load) must not exceed 680 kg (1500 lb.). Exceeding this weight is dangerous. 175 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 176
and the vehicle. If damage occurs to the coupling unit or hitch ball, there is danger of the trailer wandering over into another lane. D Toyota recommends trailers with brakes that conform to any applicable federal and state/provincial regulations. 176 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 177
agency for the correct type of wiring and relays for your trailer. Check for correct operation of the turn signals and stop lights each time you hitch up. Direct splicing may damage your vehicle's electrical system and cause a malfunction of your lights. BREAK−IN SCHEDULE D Check that your vehicle - 2004 Toyota Corolla | Owners Manual - Page 178
. Avoid sudden braking as you may skid, resulting in jackknifing and loss of control. This is especially true on wet or slippery surfaces. tion. If your vehicle has a manual transmission, prevent excessive clutch slippage by keeping engine rpm low and not racing the engine. Always start out in first - 2004 Toyota Corolla | Owners Manual - Page 179
the transmission in "P" position (automatic) or the clutch pedal depressed (manual), start the engine. (With an automatic transmission, be sure to keep the brake pedal depressed.) 2. Shift into gear. 3. Release the parking brake (also foot brake on automatic transmission vehicles) and slowly pull or - 2004 Toyota Corolla | Owners Manual - Page 180
, dirty plugs, dirty oil and grease, brakes not adjusted, etc. all lower engine performance and contribute to poor fuel economy. For longer life of all parts and lower operating costs, keep all maintenance work on schedule, and if you often drive under severe conditions, see that your vehicle - 2004 Toyota Corolla | Owners Manual - Page 181
OF AN EMERGENCY In case of an emergency If your vehicle will not start ...If your engine stalls while driving ...If your vehicle overheats ...If you have a flat lose your wireless remote control transmitter ... 4 182 185 185 186 195 196 199 199 200 181 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 182
. This may overheat the starter and wiring systems. NOTICE Do not pull − or push−start the vehicle. It may damage the vehicle or cause a collision when the engine starts. Also the three−way catalytic converter may overheat and become a fire hazard. 182 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 183
. Turn off all unnecessary lights and accessories. 2. If required, remove all the vent plugs from the booster and discharged batteries. Lay a cloth over the open vents on the batteries. (This helps reduce the explosion hazard, personal injuries and burns.) 3. If the engine in the vehicle with the - 2004 Toyota Corolla | Owners Manual - Page 184
to or near any part that moves when the engine is cranked. CAUTION When making the connections, to avoid serious injury, do not lean over the battery or accidentally let the jumper cables or clamps touch anything except the correct battery terminals or the ground. 184 2004 COROLLA from Oct. '03 - 2004 Toyota Corolla | Owners Manual - Page 185
emergency flashers. Put the transmission in "P" (automatic) or neutral (manual) and apply the parking brake. Turn off the air conditioning if it is being used. 2. If coolant or steam is boiling out of the radiator or reservoir, stop the engine. Wait until the steam subsides before opening the hood - 2004 Toyota Corolla | Owners Manual - Page 186
the radiator cap when the engine and radiator are hot. Serious injury could result from scalding hot fluid and steam blown out under pressure. When jacking, be sure to observe the following to reduce the possibility of personal injury: D Follow jacking instructions. 186 2004 COROLLA from Oct - 2004 Toyota Corolla | Owners Manual - Page 187
0306) D Do not put any part of your body under the vehicle supported by the jack. Otherwise, personal injury may occur. D Do not start or run the engine while your vehicle is supported by the jack. D Stop the vehicle on a level firm ground, firmly set the parking brake and put the transmission in - 2004 Toyota Corolla | Owners Manual - Page 188
replace the tire. See also the tire information on page 232 in Section 7 −2 for details on the tread wear indicators and other service information. CAUTION D The compact spare tire was designed especially for your Toyota without compact spare tire 188 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 189
a collision or sudden braking. To remove the spare tire: 1. Raise the luggage compartment floor. 2. On vehicles with compact spare tire, take the tool holder with tools out. 3. Loosen the bolt with spacer and remove it. Then take the spare tire out of the vehicle. 189 2004 COROLLA from Oct. '03 - 2004 Toyota Corolla | Owners Manual - Page 190
removal steps in reverse order to prevent it from flying forward during a collision or sudden braking. -Removing wheel ornament (steel wheels only) 2. Block the wheel diagonally opposite the flat the ornament to avoid unexpected personal injury. 190 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 191
'04 Corolla_U (L/O 0306) -Loosening wheel nuts CAUTION Never use oil or grease on the bolts or nuts. The nuts may loose and the wheels may fall off, which the correct jack point as shown. Make sure the jack is positioned on a level and solid place. 191 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 192
the vehicle is supported by the jack alone. -Changing wheels 6. After lift, double −check that it is properly positioned. 7. Remove the wheel nuts and change tires. Lift the started through its hole. Wiggle the tire and press it back over the other bolts. 192 2004 COROLLA from Oct. '03 Prod. - 2004 Toyota Corolla | Owners Manual - Page 193
The nuts may loose and the wheels may fall off, which could cause a serious accident. If there is oil or grease on any bolt or nut, clean it. Before putting on wheels, remove any corrosion on the the tire and see if you can tighten them more. 193 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 194
When lowering the vehicle, make sure all portions of your body and all other persons around will not be injured as 103 N·m (10.5 kgf·m, 76 ft·lbf), as soon as possible after changing wheels. Otherwise, the nuts may loosen and the wheels may fall off, which 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 195
'04 Corolla_U (L/O 0306) -After changing wheels 11. Check the air pressure of the replaced tire. Adjust the air pressure to the specification designed on page 255 in Section 8. If the pressure is lower, drive slowly to the nearest service station and fill to the correct pressure. Do not forget to - 2004 Toyota Corolla | Owners Manual - Page 196
and other parts. z Do not race the engine and avoid spinning service from a Toyota dealer or commercial tow truck service, tow your vehicle carefully in accordance with the instructions condition. If they are damaged, use a towing dolly. -From rear 196 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 197
sling type truck, either from the front or rear. This may cause body damage. NOTICE Do not tow with the key removed or in the "LOCK" position when towing from the rear without a towing dolly. The steering lock mechanism is not strong enough to hold the front wheels straight. 197 2004 COROLLA from - 2004 Toyota Corolla | Owners Manual - Page 198
in good condition. Before towing, release the parking brake and put the transmission in neutral (manual) or "N" (automatic). The key must be in "ACC" (engine off) or "ON" (engine running). CAUTION If the engine is not running, the power assist for the brakes and steering will not work so steering - 2004 Toyota Corolla | Owners Manual - Page 199
hole to override of "P" the but- 2. Pry up the cover with a flat −bladed screwdriver or equivalent. 6. Start the engine. For your safety, keep the brake pedal depressed. Be sure to have the system checked by your Toyota dealer as soon as possible. 199 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 200
. At the same time, you must bring all of the remaining transmitters to have them registered again as well. You can use the wireless remote control system with the new transmitter. Contact your Toyota dealer for detailed information. 200 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 201
'04 Corolla_U (L/O 0306) SECTION CORROSION PREVENTION AND APPEARANCE CARE Corrosion prevention and appearance care 5 Protecting your Toyota from corrosion ...202 Washing and waxing your Toyota ...203 Cleaning the interior ...205 201 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 202
corrosion from starting. If the chips or scratches have gone through the bare metal, have a qualified body shop make the repair. Care is especially important if you live in particular areas or operate your vehicle under certain environmental conditions: D Road salt or dust control chemicals will - 2004 Toyota Corolla | Owners Manual - Page 203
it off with water and check if the ornament is damaged. The following cases may cause weakness to the paint or corrosion to the body and parts. Wash your vehicle as soon as possible. D When driving in a coastal area D When driving on a road sprinkled with antifreeze D When having coal tar, tree - 2004 Toyota Corolla | Owners Manual - Page 204
's instructions and antenna, make sure it is removed before driving your Toyota through an automatic car wash. NOTICE Always remove the plastic bumpers if your vehicle is re−painted and placed in a high heat paint waxing booth. High temperatures could damage the bumpers. 204 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 205
dirt do not come off, repeat the procedure. Commercial foaming− type vinyl cleaners are also available which work well. Follow the manufacturer's instructions. Carpets Use a good foam−type clean the carpets. shampoo to D Vehicles with side airbags: Be careful not to splash water or spill liquid on - 2004 Toyota Corolla | Owners Manual - Page 206
Air conditioning control panel, car audio, instrument panel, console panel, and switches Use a soft damp cloth for cleaning. Soak a clean soft cloth in water or lukewarm water then lightly cleaning or whenever any part of the leather gets to avoid oil spots. 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 207
leather when warm. z Improper cleaning of the leather upholstery could result in discoloration or staining. If you have any questions about the cleaning of your Toyota, your local Toyota dealer will be pleased to answer them. 207 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 208
'04 Corolla_U (L/O 0306) 208 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 209
maintenance ...Does your vehicle need repairing? ...Emissions Inspection and Maintenance (I/M) programs ... 6 210 211 213 214 For scheduled maintenance information, please refer to the "Scheduled Maintenance Guide" or "Owner's Manual Supplement". 209 2004 COROLLA from Oct. '03 Prod. (OM12859U - 2004 Toyota Corolla | Owners Manual - Page 210
required to be serviced at regular intervals. For details of your maintenance schedule, read the "Scheduled Maintenance Guide" or "Owner's Manual Supplement". It is recommended that any replacement parts used for maintenance or for the repair of the emission control system be Toyota supplied. The - 2004 Toyota Corolla | Owners Manual - Page 211
information. Battery condition Check the battery condition by the indicator color. See page 240 in Section 7 −3 for additional information. Brake fluid level Make sure the brake fluid level is correct. See page 228 in Section 7 −2 for additional information. Engine oil level Check the level - 2004 Toyota Corolla | Owners Manual - Page 212
other lights are all working. Check headlight aim. Service reminder indicators and warning buzzers Check that all service reminder indicators and warning buzzers function properly. Steering wheel Be alert for changes in steering condition, such as hard steering or strange noise. Seats Check that - 2004 Toyota Corolla | Owners Manual - Page 213
on a level road D Strange noises related to suspension movement D Loss of brake effectiveness; spongy feeling brake or clutch pedal; pedal almost touches floor; vehicle pulls to one side when braking D Engine coolant temperature continually higher than normal 213 2004 COROLLA from Oct. '03 Prod - 2004 Toyota Corolla | Owners Manual - Page 214
system. When the OBD system determines that a problem exists somewhere in the emission control system, the malfunction indicator lamp comes on. In this case, your vehicle may not pass the I/M test and need to be repaired. Contact your Toyota dealer to service the vehicle. Even does pass have if the - 2004 Toyota Corolla | Owners Manual - Page 215
'04 Corolla_U (L/O 0306) SECTION DO−IT−YOURSELF MAINTENANCE Introduction 7− 1 216 217 217 219 220 Engine compartment overview ...Fuse locations ...Do −it−yourself service precautions ...Positioning the jack ...Parts and tools ... 215 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 216
overview 1. Power steering fluid reservoir 2. Engine oil level dipstick 3. Engine coolant reservoir 4. Engine oil filler cap 5. Brake fluid reservoir 6. Fuse block 7. Battery 8. Radiator 9. Electric cooling fan 10. Condenser 11. Windshield washer fluid tank 216 2004 COROLLA from Oct. '03 - 2004 Toyota Corolla | Owners Manual - Page 217
that improper or incomplete servicing may result in operating problems. Performing do−it −yourself maintenance during the warranty period may affect your warranty coverage. Read the separate Toyota Warranty statement for details and suggestions. This Section gives instructions only for those items - 2004 Toyota Corolla | Owners Manual - Page 218
fans or radiator grille. With the ignition on, the electric cooling fans will automatically start to run if the engine coolant temperature is high and/or the air conditioning is on. D Be extremely cautious when working on the battery. It contains poisonous and corrosive sulfuric acid. D When the - 2004 Toyota Corolla | Owners Manual - Page 219
to reduce the possibility of personal injury: D Follow jacking instructions. D Do not put any part of your body Front under the vehicle supported by the jack. Personal injury may occur. D Do not start or run the engine while your vehicle is supported by the jack. D Stop the vehicle on a level - 2004 Toyota Corolla | Owners Manual - Page 220
Funnel (only for adding oil) CHECKING LEVEL THE ENGINE COOLANT D Rag or paper towel D Funnel (only for adding fluid) CHECKING BATTERY CONDITION Tools: Parts (if level is low): D "Toyota Genuine Long Life Coolant" or equivalent See page 226 in Section 7 −2 for details about coolant type selection - 2004 Toyota Corolla | Owners Manual - Page 221
WASHER FLUID Parts: D Water D Washer fluid containing antifreeze (for winter use) Tools: D Funnel REPLACING LIGHT BULBS Parts: D Bulb with same number and wattage rating as original (See charts in "Replacing light bulbs" on page 243 in Section 7−3.) Tools: D Screwdriver 221 2004 COROLLA from - 2004 Toyota Corolla | Owners Manual - Page 222
'04 Corolla_U (L/O 0306) 222 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 223
229 232 234 235 237 237 Checking the engine oil level ...Checking the engine coolant level ...Checking the radiator and condenser ...Checking brake fluid ...Checking power steering fluid ...Checking tire inflation pressure ...Checking and replacing tires ...Rotating tires ...Installing snow tires - 2004 Toyota Corolla | Owners Manual - Page 224
to drop the engine oil on the vehicle components. If the oil level is below or only slightly above the low level, add engine oil of the same type as already in the engine. Add oil O.K. Too full Remove the oil filler cap and add engine oil in small quantities at a time, checking the dipstick. We - 2004 Toyota Corolla | Owners Manual - Page 225
5W−30 is the best choice for good fuel economy, and good starting in cold weather. If SAE 5W−30 oil is not available, SAE 10W−30 oil may be used. However, it should be replaced with SAE 5W−30 at the next oil change. Oil identification marks Either or both API registered marks are added to some - 2004 Toyota Corolla | Owners Manual - Page 226
leak, have your Toyota dealer test the cap pressure and check for leaks in the cooling system. CAUTION To prevent burning yourself, do not remove the radiator cap when the engine is hot. Coolant type selection Use of improper coolants may damage your engine cooling system. Your coolant must contain - 2004 Toyota Corolla | Owners Manual - Page 227
condition, take your vehicle to a Toyota dealer. CAUTION To prevent burning yourself, be careful not to touch the radiator or condenser when the engine is hot. NOTICE To prevent damage to the radiator and condenser, do not perform the work by yourself. NOTICE Do not use alcohol type antifreeze - 2004 Toyota Corolla | Owners Manual - Page 228
may also check the level when the fluid is cold (about room temperature, 10_C-30_C or 50_F-85_F) if the engine has not been run for about five hours. NOTICE If you spill some of the fluid, be sure to wash it off with water to prevent it from damaging the parts or paint. 228 2004 COROLLA from - 2004 Toyota Corolla | Owners Manual - Page 229
After replacing the reservoir cap, visually check the steering box case, vane pump and hose connections for leaks or damage. CAUTION The reservoir tank may be hot so be careful not to burn yourself. NOTICE Avoid overfilling, or the power steering could be damaged. Type A Type B 229 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 230
at the proper level. The recommended cold tire inflation pressures, tire sizes and the combined weight of occupants and cargo (vehicle capacity weight) are described on page 252 and 255. They are also on the tire and loading information label. Either type A or type B of the tire and loading - 2004 Toyota Corolla | Owners Manual - Page 231
gauge 5. After completing the tire inflation pressure measurement and adjustment, apply soap water to the valve and check the leakage. 6. Install the tire valve cap. If the gauge and the air pump are not available, have your vehicle checked by your Toyota dealer. CAUTION Be sure to reinstall the - 2004 Toyota Corolla | Owners Manual - Page 232
internal damage, the tire should be replaced. If a tire often goes flat or cannot be properly repaired due to the size or location of a cut or other damage, it should be replaced. If you are not sure, consult with your Toyota dealer. CHECKING YOUR TIRES Check the tires tread for the tread wear - 2004 Toyota Corolla | Owners Manual - Page 233
. Using any other size or type of tire may seriously affect handling, ride, speedometer/odometer calibration, ground clearance, and clearance between the body and tires or snow chains. Check that the maximum load of the replaced tire is greater than 1/2 of the Gross Axle Weight Ratings (GAWR) of - 2004 Toyota Corolla | Owners Manual - Page 234
tire change procedure. When rotating tires, check for uneven wear and damage. Abnormal wear is usually caused by incorrect tire pressure, improper wheel alignment, out − of −balance wheels, or severe braking. Vehicles with compact spare tire Vehicles without compact spare tire 234 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 235
size, as this may cause dangerous handling characteristics resulting in loss of control. Otherwise, an accident may occur resulting in death or serious injuries. D Do not drive with the snow tires incorrectly inflated. D Never drive over 120 km/h (75 mph) with any type of snow tires. 235 2004 - 2004 Toyota Corolla | Owners Manual - Page 236
. braking, as use of chains may adversely affect vehicle handling. D Avoid sharp turns or locked−wheel D When driving with chains installed, be sure to drive carefully. Slow down before entering curves to avoid losing control of the vehicle. Otherwise an accident may occur. 236 2004 COROLLA from - 2004 Toyota Corolla | Owners Manual - Page 237
Toyota dealer. A wheel of a different size or type may adversely affect handling, wheel and bearing life, brake cooling, speedometer/odometer calibration, stopping ability, headlight aim, bumper height, vehicle ground clearance, and tire or snow chain clearance to the body and chassis. Replacement - 2004 Toyota Corolla | Owners Manual - Page 238
'04 Corolla_U (L/O 0306) 238 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 239
Corolla_U (L/O 0306) SECTION DO−IT−YOURSELF MAINTENANCE Electrical components 7− 3 240 241 242 243 243 Checking battery condition ...Battery recharging precautions ...Checking and replacing fuses ...Adding washer fluid ...Replacing light bulbs ... 239 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 240
of water or milk. Follow with milk of magnesia, beaten raw egg or vegetable oil. Then go immediately for emergency help. Check the battery for corroded or loose terminal connections, cracks, or loose hold−down clamp. a. If the battery is corroded, wash it off with a solution of warm water and baking - 2004 Toyota Corolla | Owners Manual - Page 241
the battery when washing it. CHECKING BY INDICATOR Check the battery condition by the indicator color. Indicator color Type A Green Type B Blue Condition Good Charging necessary. Have battery checked by your Toyota dealer. Have battery checked by your Toyota dealer. Type A Green Dark Clear or light - 2004 Toyota Corolla | Owners Manual - Page 242
for emergencies. If the headlights or other electrical components do not work, check the fuses. If any of the fuses are blown, they must be replaced. Good Type C Blown See "Fuse locations" on page 217 in Section 7−1 for locations of the fuses. Turn the ignition switch and inoperative component off - 2004 Toyota Corolla | Owners Manual - Page 243
where temperatures range below freezing point, use washer fluid containing antifreeze. This product is available at your Toyota dealer and most auto parts stores. Follow the manufacturer's directions for how much to mix with water. Replacing light bulbs- The following illustrations show how to gain - 2004 Toyota Corolla | Owners Manual - Page 244
side marker/front turn signal lights Front fog lights Rear side marker and stop/tail lights Rear turn signal lights Back −up lights High mounted stoplight License plate lights Interior light Bulb No. 9005 9006 W 60 55 Type A B Light bulbs Personal light (on the switch panel of the electric moon - 2004 Toyota Corolla | Owners Manual - Page 245
−head screwdriver and move the air cleaner duct as shown in the illustration. Remove and install the clip as shown in the following illustrations. Removing clip 2. Turn the bulb base counterclockwise to the front of the vehicle as shown. Installing clip 245 2004 COROLLA from Oct. '03 Prod - 2004 Toyota Corolla | Owners Manual - Page 246
lights 3. Unplug the connector while depressing the lock release. If the connector is tight, wiggle it. 4. Install a new bulb and connector into the mounting hole. Aiming is not necessary after replacing the bulb. When aiming adjustment is necessary, contact your Toyota dealer. 246 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 247
'04 Corolla_U (L/O 0306) -Front fog lights 1. Loosen the retainer nut and take out the front fog light unit. 2. Unplug the connector while depressing on the tab. If the connector is tight, wiggle it. 3. Turn the cover counterclockwise and remove it. 247 2004 COROLLA from Oct. '03 Prod. ( - 2004 Toyota Corolla | Owners Manual - Page 248
spring. To install the bulb, align the cutouts of the bulb with the protrusions of the mounting hole. 6. Connect the cords and install the cover by turning it clockwise. Then plug in the connector. 7. Install the front fog light unit and tighten the nut. 248 2004 COROLLA from Oct. '03 Prod - 2004 Toyota Corolla | Owners Manual - Page 249
'04 Corolla_U (L/O 0306) -Rear side marker, stop/tail and rear turn signal lights -Back −up lights a: Rear side marker and stop/tail lights b: Rear turn signal light Use a flat−bladed screwdriver or equivalent. 249 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 250
'04 Corolla_U (L/O 0306) -High mounted stoplight -License plate lights If either of the license plate lights burns out, contact your Toyota dealer. NOTICE Do not try to replace the license plate light bulbs by yourself. You may damage the vehicle. 250 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 251
'04 Corolla_U (L/O 0306) SECTION SPECIFICATIONS Specifications Dimensions and weights ...Engine ...Fuel ...Service specifications ...Tires ...Fuses ... 8 252 252 252 253 255 255 251 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 252
Dimensions and weights mm (in.) Overall length Overall width Overall height∗ Wheelbase Front tread Rear tread ∗: Engine Model: 1ZZ−FE Type: 4 cylinder weight (occupants + luggage), kg (lb.): 385 (850) Towing capacity (trailer weight + cargo weight), kg (lb.): 680 (1500) 252 2004 COROLLA from - 2004 Toyota Corolla | Owners Manual - Page 253
) Service specifications ENGINE Valve clearance (engine cold), mm (in.): Intake 0.15-0.25 (0.006-0.010) Exhaust 0.25-0.35 (0.010-0.014) Spark plug type: DENSO SK16R11 NGK IFR5A11 Spark plug gap, mm(in.): 1.1 (0.043) ENGINE LUBRICATION Oil capacity (drain and refill), L (qt., Imp. qt.): With filter - 2004 Toyota Corolla | Owners Manual - Page 254
the lights turned off. Charging rates: 5 A max. CLUTCH Pedal free play, mm (in.): 5-15 (0.2-0.6) Fluid type: SAE J1703 or FMVSS No.116 DOT 3 MANUAL TRANSAXLE Oil capacity, L (qt., Imp. qt.): 1.9 (2.0, 1.7) Oil type: Gear oil API GL−4 or GL−5 Recommended oil viscosity: SAE 75W−90 254 2004 COROLLA - 2004 Toyota Corolla | Owners Manual - Page 255
103 (10.5, 76) NOTE: For a complete information on tires (e.g. replacing tires or replacing wheels), see "Checking tire inflation pressure" through "Aluminum wheel precautions", pages 229 through 237, in Section 7 −2. (kgf/cm 2 Engine compartment 255 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 256
cigarette lighter, car audio system, clock, power rear view mirror control, shift lock control system 29. GAUGE 10 A: Gauges and meters, air conditioning system, daytime running light system, charging system, auto anti −glare inside rear view mirror, power windows, cruise control system, rear window - 2004 Toyota Corolla | Owners Manual - Page 257
UP 10 A: Engine control system Fuses (type B) 32. ABS NO.1 30 A: Anti −lock brake system 33. RDI FAN 30 A: Electric cooling fan 34. ABS NO.2 40 A: Anti −lock brake system 35. HEAD MAIN 40 A: "HEAD LH UPR", "HEAD RH UPR", "HEAD LH LWR" and "HEAD RH LWR" fuses 36. HTR 40 A: Air conditioning system 37 - 2004 Toyota Corolla | Owners Manual - Page 258
'04 Corolla_U (L/O 0306) 258 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 259
'04 Corolla_U (L/O 0306) SECTION Reporting safety defects for U.S. owners 9 REPORTING SAFETY DEFECTS FOR U.S. OWNERS Reporting safety defects for U.S. owners ...260 259 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 260
remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Toyota Motor Sales, U.S.A., Inc. To contact NHTSA, you may either also obtain other information about motor vehicle safety from the Hotline. 260 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 261
the occupants follow the instructions carefully. Doing so will help you enjoy many years of safe and trouble−free motoring. For important information about this manual and your Toyota, read the following pages carefully. When it comes to service, remember that your Toyota dealer knows your vehicle - 2004 Toyota Corolla | Owners Manual - Page 262
these warnings carefully to avoid possible injury or damage. The types of warnings, what they look like, and how they are used in this manual are explained as follows: Safety symbol CAUTION This is a of damage to your vehicle and its equipment. ii 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 263
imply, designed to work with, and be supplemental to, seat belts and are not substitutes for them. SRS airbags can be very effective in reducing the risk of head and chest injuries by preventing contact of the head and chest with interior portions of the vehicle. iii 2004 COROLLA from Oct. '03 - 2004 Toyota Corolla | Owners Manual - Page 264
an occupant is too close to an airbag, or if an object or some part of his or her body has been placed between the occupant and the airbag at the time of deployment. This is just one example of how the instructions in Section 1−3 of this Owner's Manual will help ensure proper use of the - 2004 Toyota Corolla | Owners Manual - Page 265
harm. D Battery posts, terminals and related accessories contain lead and lead compounds. Wash your hands after handling. Used engine oil contains chemicals that have caused cancer in laboratory animals. Always protect your skin by washing thoroughly with soap and water. v 2004 COROLLA from Oct - 2004 Toyota Corolla | Owners Manual - Page 266
/sequential multiport fuel injection system, cruise control system, anti −lock brake system, SRS airbag system and seat belt pretensioner system, be sure to check with your Toyota dealer for precautionary measures or special instructions regarding installation. vi 2004 COROLLA from Oct. '03 Prod - 2004 Toyota Corolla | Owners Manual - Page 267
and braking ability, leading to an accident. Check the tire inflation pressure periodically and be sure to keep the load limits given in this Owner's Manual. For details about tire inflation pressure and load limits, see pages 165 and 229. Scrapping of your Toyota The SRS airbag and seat belt - 2004 Toyota Corolla | Owners Manual - Page 268
'04 Corolla_U (L/O 0306) viii 2004 COROLLA from Oct. '03 Prod. (OM12859U) - 2004 Toyota Corolla | Owners Manual - Page 269
−Conserving" or ILSAC multigrade engine oil is recommended. See page 224 for detailed information. Automatic transaxle fluid: Toyota Genuine ATF Type T −IV See page 254 for detailed information. Tire information: See pages 229 through 237. Tire inflation pressure: See page 255. Publication No - 2004 Toyota Corolla | Owners Manual - Page 270
of your new vehicle as the people who built it. The Toyota authorized Repair Manual tells you how to maintain your vehicle and enables you to correctly moment you drive it off the showroom floor. The Toyota authorized Repair Manual is packed with literally everything you need to know to perform your - 2004 Toyota Corolla | Owners Manual - Page 271
valve clearance adjustment and engine oil and filter replacement. Where to obtain the Repair Manual The repair manual for COROLLA, written in English, may be purchased as applicable from any Toyota dealer. Pub. Name: 2004 COROLLA Repair Manual Pub. No.: RM1037U1 RM1037U2 2004 COROLLA from Oct. '03 - 2004 Toyota Corolla | Owners Manual - Page 272
'04 Corolla_U (L/O 0306) WE REALLY CARE ABOUT YOU Ċ PLEASE BUCKLE UP Toyota has made a special effort to encourage use of seat belts. Toyota belts are: D Comfortable D Easy to use D Convenient We encourage you to use your belts every time you drive. U 2004 COROLLA from Oct. '03 Prod. (OM12859U)