2004 Toyota Tacoma Warranty, Maitenance, Services Guide - Page 30

Maintenance Log: SUVs and Trucks 60,000 Miles or 72 Months ❑ Replace engine oil and oil filter1 ❑ Replace engine air filter ❑ Rotate tires ❑ Replace cabin air filter (if equipped) ❑ Lubricate drive shaft bushing (Land Cruiser) ❑ Lubricate propeller shaft (PreRunner and all 4WD except Highlander and RAV4) ❑ Lubricate wheel bearings (Land Cruiser, 2WD Tacoma) ❑ Replace limited-slip differential oil, if equipped (4WD Highlander, Land Cruiser, 4WD RAV4, 4WD Tacoma, 2WD Tundra) ❑ Replace spark plugs (all models except Highlander and Land Cruiser)2 ❑ Re-torque drive shaft bolt (Highlander, 4WD RAV4) ❑ Re-torque propeller shaft bolt (all models except Highlander and RAV4) ❑ Inspect the following: __ Automatic transmission fluid __ Ball joints and dust covers __ Brake lines and hoses __ Brake linings/drums and brake pads/discs3 __ Charcoal canister 4 __ Drive belts 5 __ Drive shaft boots (Highlander, Land Cruiser, RAV4, 4WD Sequoia, 4WD Tacoma, 4WD Tundra, 4WD 4Runner) __ Engine coolant __ Engine valve clearance __ Front differential oil (4WD models, Highlander, RAV4) __ Exhaust pipes and mountings __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank cap gasket __ Manual transmission oil (RAV4, Tundra, all Tacomas except PreRunner) __ Radiator core and condenser __ Rear differential oil (all models except 2WD Highlander and 2WD RAV4) __ Steering gear box __ Steering linkage and boots __ Transfer case oil (all 4WD models) Additional Maintenance Items for Special Operating Conditions Driving in desert or on dirt roads: ❑ Tighten nuts and bolts on chassis Driving while towing: ❑ Replace front differential oil (Highlander, RAV4 and all 4WD models) ❑ Replace rear differential oil, including limited-slip (all models except 2WD Highlander and 2WD RAV4) ❑ Replace transfer case oil (4WD models) ❑ Replace transmission fluid or oil ❑ Tighten nuts and bolts on chassis Dealer Service Verification: Date: Mileage: 1 2 Reset the oil replacement reminder ("MAINT REQD") light after replacing engine oil, if vehicle is equipped with this light. Required under the terms of the Emission Control Warranty. 3 Inspect thickness measurement and disc runout. 4 Applies to Land Cruiser, Sequoia, Tacoma/Tundra with 5VZ-FE and Tundra/4Runner with 2UZ-FE. Inspect at 60,000 miles or 72 months, whichever comes first. Required only for vehicles in California, Massachusetts and New York. 5 Initial inspection at 60,000 miles/72 months. Inspect every 15,000 miles/18 months thereafter. Scheduled Maintenance Logs 27