2005 Toyota Tacoma Warranty, Maitenance, Services Guide
2005 Toyota Tacoma Manual
2005 Toyota Tacoma manual content summary:
- 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 1
your vehicle receives first-quality service and parts, Toyota recommends having maintenance checks and visual inspections. These procedures are explained in the "Vehicle Maintenance and Care" section of the Owner's Manual. Be sure to perform these procedures regularly to ensure the most trouble - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 2
date of service, mileage at time of service and a description of service and/or parts installation performed. show that you maintained your vehicle. However, damage or failures caused by lack of proper maintenance are not covered under warranty. Maintenance Providers Maintenance and repair services - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 3
Vehicle Identification Using the Maintenance Log Charts Maintenance Log: Cars Maintenance Log: SUVs and Trucks Explanation of Maintenance Items com. From the site's home page, select the "Owners" link, then select "Service & Maintenance." This will bring you to the screen shown below, where you will - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 4
Vehicle Identification Model In-service date Selling dealership Key number Body style Mileage at delivery Selling dealership phone number Vehicle Identification Number 2 - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 5
so that you obtain maintenance when recommended. If you are a low-mileage driver, mark your calendar to remind yourself to obtain maintenance every six months. each chart. Note: You should perform these additional maintenance services if you drive primarily under any of the special operating - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 6
: Cars 5,000 Miles or 6 Months u Replace engine oil and oil filter u Rotate tires (except MR2 Spyder) u Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions2 Driving in desert or on dirt roads: u Inspect ball joints and dust covers - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 7
Maintenance Log: Cars 15,000 Miles or 18 Months u Replace engine oil and oil filter 1 u Rotate tires (except MR2 Spyder) u Clean cabin air filter (Camry) u Tighten drive shaft bolt (Corolla and Corolla Matrix) u Visually inspect brake linings/drums and brake pads/discs u Inspect the following: __ - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 8
Maintenance Log: Cars 20,000 Miles or 24 Months u Replace engine oil and oil filter u Rotate tires (except MR2 Spyder) u Replace cabin air filter (Corolla and Corolla Matrix, if equipped) u Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 9
Spyder) u Replace cabin air filter (Camry and Camry Solara) u Replace engine air filter u Replace spark plugs (ECHO)3 u Tighten drive shaft bolt (Corolla and Corolla Matrix) u Inspect the following: __ Ball joints and dust covers __ Brake lines and hoses __ Brake linings/drums and brake pads/discs4 - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 10
Cars 35,000 Miles or 42 Months u Replace engine oil and oil filter u Rotate tires (except MR2 Spyder) u Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions2 Driving in desert or on dirt roads: u Inspect ball joints and dust covers - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 11
Maintenance Log: Cars 45,000 Miles or 54 Months u Replace engine oil and oil filter 1 u Rotate tires (except MR2 Spyder) u Clean cabin air filter (Camry) u Tighten drive shaft bolt (Corolla and Corolla Matrix) u Visually inspect brake linings/drums and brake pads/discs u Inspect the following: __ - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 12
Cars 50,000 Miles or 60 Months u Replace engine oil and oil filter u Rotate tires (except MR2 Spyder) u Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions2 Driving in desert or on dirt roads: u Inspect ball joints and dust covers - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 13
MR2 Spyder) u Replace cabin air filter (if equipped) u Replace engine air filter u Replace spark plugs (ECHO)3 u Tighten drive shaft bolt (Corolla and Corolla Matrix) u Inspect the following: __ Ball joints and dust covers __ Brake lines and hoses __ Brake linings/drums and brake pads/discs4 __ - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 14
Cars 65,000 Miles or 78 Months u Replace engine oil and oil filter u Rotate tires (except MR2 Spyder) u Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions2 Driving in desert or on dirt roads: u Inspect ball joints and dust covers - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 15
Maintenance Log: Cars 75,000 Miles or 90 Months u Replace engine oil and oil filter 1 u Rotate tires (except MR2 Spyder) u Clean cabin air filter (Camry) u Tighten drive shaft bolt (Corolla and Corolla Matrix) u Visually inspect brake linings/drums and brake pads/discs u Inspect the following: __ - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 16
Maintenance Log: Cars 80,000 Miles or 96 Months u Replace engine oil and oil filter1 u Rotate tires (except MR2 Spyder) u Replace cabin air filter (Corolla and Corolla Matrix, if equipped) u Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 17
Corolla Matrix 4WD) u Replace manual transmission oil u Replace rear differential oil8 u Replace transfer case oil7 u Tighten nuts and bolts on chassis Dealer Service Verification: Date: Mileage: 1 2 Reset the oil replacement reminder ("MAINT REQD") light after replacing engine oil, if vehicle is - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 18
Cars 95,000 Miles or 114 Months u Replace engine oil and oil filter u Rotate tires (except MR2 Spyder) u Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions2 Driving in desert or on dirt roads: u Inspect ball joints and dust covers - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 19
Maintenance Log: Cars 105,000 Miles or 126 Months u Replace engine oil and oil filter 1 u Rotate tires (except MR2 Spyder) u Clean cabin air filter (Camry) u Tighten drive shaft bolt (Corolla and Corolla Matrix) u Visually inspect brake linings/drums and brake pads/discs u Inspect the following: __ - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 20
Maintenance Log: Cars 110,000 Miles or 132 Months u Replace engine oil and oil filter u Rotate tires (except MR2 Spyder) u Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions2 Driving in desert or on dirt roads: u Inspect ball - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 21
(except MR2 Spyder) u Replace cabin air filter (if equipped) u Replace engine air filter u Replace spark plugs3 u Tighten drive shaft bolt (Corolla and Corolla Matrix) u Inspect the following: __ Ball joints and dust covers __ Brake lines and hoses __ Brake linings/drums and brake pads/discs4 __ - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 22
5,000 Miles or 6 Months u Replace engine oil and oil filter u Rotate tires u Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions2 Driving in desert or on dirt roads: u Inspect ball joints and dust covers u Inspect drive shaft boots3 - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 23
000 Miles or 18 Months u Replace engine oil and oil filter1 u Rotate tires u Lubricate propeller shaft4 u Re-torque drive shaft bolt (4WD RAV4) u Re-torque propeller shaft bolt (all models except Highlander and RAV4) u Visually inspect brake linings/drums and brake pads/discs u Inspect the following - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 24
,000 Miles or 24 Months u Replace engine oil and oil filter u Rotate tires u Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions2 Driving in desert or on dirt roads: u Inspect ball joints and dust covers u Inspect drive shaft boots3 - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 25
drums and brake pads/discs7 __ Drive shaft boots3 __ Engine coolant8 __ Exhaust pipes and mountings __ Front differential oil (4WD models, Highlander and RAV4) __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank cap gasket __ Manual transmission oil (RAV4 - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 26
,000 Miles or 42 Months u Replace engine oil and oil filter u Rotate tires u Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions2 Driving in desert or on dirt roads: u Inspect ball joints and dust covers u Inspect drive shaft boots3 - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 27
000 Miles or 54 Months u Replace engine oil and oil filter1 u Rotate tires u Lubricate propeller shaft4 u Re-torque drive shaft bolt (4WD RAV4) u Re-torque propeller shaft bolt (all models except Highlander and RAV4) u Visually inspect brake linings/drums and brake pads/discs u Inspect the following - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 28
,000 Miles or 60 Months u Replace engine oil and oil filter u Rotate tires u Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions2 Driving in desert or on dirt roads: u Inspect ball joints and dust covers u Inspect drive shaft boots3 - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 29
coolant10 __ Engine valve clearance (except Tacoma with 2TR-FE) __ Front differential oil (4WD models, Highlander, RAV4) __ Exhaust pipes and mountings __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank cap gasket __ Manual transmission oil (RAV4, Tundra - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 30
,000 Miles or 78 Months u Replace engine oil and oil filter u Rotate tires u Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions2 Driving in desert or on dirt roads: u Inspect ball joints and dust covers u Inspect drive shaft boots3 - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 31
000 Miles or 90 Months u Replace engine oil and oil filter1 u Rotate tires u Lubricate propeller shaft4 u Re-torque drive shaft bolt (4WD RAV4) u Re-torque propeller shaft bolt (all models except Highlander and RAV4) u Visually inspect brake linings/drums and brake pads/discs u Inspect the following - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 32
engine oil and oil filter1 u Rotate tires u Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions2 Driving in desert or on dirt roads: u Inspect ball joints and dust covers u Inspect drive shaft boots3 u Inspect engine air filter - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 33
brake pads/discs8 __ Drive belts __ Drive shaft boots3 __ Engine coolant9 __ Exhaust pipes and mountings __ Front differential oil (4WD models, Highlander and RAV4) __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank cap gasket __ Manual transmission oil - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 34
000 Miles or 114 Months u Replace engine oil and oil filter u Rotate tires u Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions2 Driving in desert or on dirt roads: u Inspect ball joints and dust covers u Inspect drive shaft boots3 - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 35
Miles or 126 Months u Replace engine oil and oil filter1 u Rotate tires u Lubricate propeller shaft4 u Re-torque drive shaft bolt (4WD RAV4) u Re-torque propeller shaft bolt (all models except Highlander and RAV4) u Visually inspect brake linings/drums and brake pads/discs u Inspect the following - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 36
000 Miles or 132 Months u Replace engine oil and oil filter u Rotate tires u Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions2 Driving in desert or on dirt roads: u Inspect ball joints and dust covers u Inspect drive shaft boots3 - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 37
coolant9 __ Engine valve clearance (except Tacoma with 2TR-FE) __ Front differential oil (4WD models, Highlander, RAV4) __ Exhaust pipes and mountings __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank cap gasket __ Manual transmission oil (RAV4, Tundra - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 38
, fluid leakage, broken parts and excessive wear. Check the pads for excessive wear and the discs for runout, excessive wear and fluid leakage. Replace any deteriorated or damaged parts. A qualified technician should perform these operations. Cabin Air Filter Replace at specified intervals. Driving - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 39
A qualified technician should perform these operations. Engine Air Filter Replace at specified intervals. When performing inspections, check for damage, excessive wear and oiliness, and replace if necessary. Engine Coolant Drain and flush the cooling system and refill with an ethylene-glycol type - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 40
and hangers for cracks, deterioration and damage. Start the engine and listen carefully for any exhaust gas leakage. Tighten connections or replace parts as necessary. Fuel Lines and Connections, Fuel Tank Band and Fuel Tank Vapor Vent System Hoses Visually inspect for corrosion, damage, cracks and - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 41
parts. A qualified technician should perform these operations. Timing Belt Replace every 90,000 miles. A qualified technician should perform this operation. Tire Rotation Tires should be rotated at specified intervals according to the instructions in the Owner's Manual. When rotating tires, check - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 42
Notes 40 - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 43
Notes 41 - 2005 Toyota Tacoma | Warranty, Maitenance, Services Guide - Page 44
Notes 42