2011 Toyota Tundra Double Cab Warranty, Maitenance, Services Guide
2011 Toyota Tundra Double Cab Manual
2011 Toyota Tundra Double Cab manual content summary:
- 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 1
TUNDRA 2 0 1 1 MAINTENANCE GUIDE WARRANTY & www.toyota.com OWNER INFORMATION CHANGE FORM If your name or address has changed or you purchased your Toyota as a used vehicle, please complete and mail the attached card, even if your warranty coverage has expired. This will enable Toyota to contact - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 2
CUSTOMER LOYALTY WC13 TOYOTA MOTOR SALES USA INC PO BOX 2991 TORRANCE CA 90509-9809 - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 3
page identifies the section you are in. For more information about our vehicles, our company or the products and services available for your vehicle, please visit Toyota's official Web site, www.toyota.com. We wish you many miles of safe and pleasurable driving, and we look forward to serving you - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 4
Coverages at a Glance 4 5 7 8 10 Your Warranties in Detail General Warranty Provisions New Vehicle Limited Warranty Federal Emission Control Warranty California Emission Control Warranty Tire Limited Warranty 11 12 16 22 28 Your Responsibilities Operation and Maintenance Obtaining Warranty - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 5
Items Vehicle Identification 35 37 38 54 70 74 Find It Online For your convenience, scheduled maintenance information for your vehicle is also available at www.ToyotaOwnersOnline.com. From the site's home page, go to the "Scheduled Maintenance" link. Then select your vehicle's model name, model - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 6
the card at the back of this booklet if you change your address or if you've purchased this vehicle from a previous owner. To provide you with added protection against unexpected service costs, we offer Toyota Extra Care vehicle service agreements and Toyota Auto Care pre-paid maintenance programs - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 7
WARRANTY THE NEW WORLD OF ANTI-THEFT TECHNOLOGY This Toyota vehicle may be equipped with an electronic "immobilizer" anti-theft system. When the key is inserted to key codes and service procedures for electronically registering replacement keys is restricted. Only a Toyota dealer or certain bonded/ - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 8
the immobilizer if all registered master keys have been lost. If a Toyota dealer is not available, please refer to www.aloa.org to find a bonded/registered locksmith who performs high security key service. KEEPING THE KEY SAFE Replacing an immobilizer key may be costly. It is advisable to keep - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 9
to all 2011 model-year Toyotas sold and serviced by authorized Toyota dealerships in Toyota dealer. • The warranty repairs will take longer than one day to complete. • The warrantable condition requires extensive diagnosis. • The parts needed for the warranty repairs are not readily available - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 10
oth Toyota and your Toyota dealer are dedicated to serving your automotive needs. Your complete satisfaction is our first priority. Should you have a problem Toyota and the names of your selling and servicing dealerships. Step 1 Discuss the situation with a dealership manager, such as the service - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 11
Program (CDSP). A brochure about the program is found in your glove box. For additional information, call the Toyota Customer Experience Center at However, the programs may be changed without notice. For the most current information about the programs, call the Toyota Customer Experience Center at ( - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 12
Warranty Coverages at a Glance WARRANTY 10 Introduction - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 13
be made by the servicing Toyota dealership and/or Toyota. Parts scheduled to be replaced as required maintenance are warranted until their first replacement only. Which Vehicles Are Covered These warranties apply to all 2011 model year Tundra vehicles distributed by Toyota that are originally sold - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 14
housing and all internal parts, engine control computer, water pump, fuel pump, seals and gaskets. Restraint Systems Warranty This warranty covers repairs needed to correct defects in materials or workmanship of any seatbelt or air bag system supplied by Toyota, subject to the exceptions - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 15
installation of non-Genuine Toyota Accessories • Lack of or improper maintenance, including use of fluids other than those specified in the Owner's Manual • Installation of non-Genuine Toyota Parts • Airborne chemicals, tree sap, road debris (including stone chips), rail dust, salt, hail, floods - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 16
Limited Warranty WARRANTY Maintenance Expense Normal maintenance services such as: • Engine tune-ups • Replacement of fluids and filters • Lubrication • Cleaning and polishing • Replacement of spark plugs and fuses • Replacement of worn wiper blades, brake pads/linings and clutch linings Vehicles - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 17
New Vehicle Limited Warranty WARRANTY DISPUTE RESOLUTION If a dispute arises regarding your warranty coverage, please follow the steps described under "If You Need Assistance" on pages 8-9. Please note that you must use the Dispute Settlement Program (or, in California, the CDSP) before seeking - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 18
Federal Emission Control Warranty WARRANTY WHAT IS COVERED AND HOW LONG Emission Defect Warranty Toyota warrants that your vehicle: or 24,000 miles from the vehicle's in-service date, whichever occurs first. Additionally, components marked "8/80" in the parts list on pages 17-18 have coverage of - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 19
use of replacement parts not equivalent in quality or design to original equipment parts. Provisions under the "What Is Not Covered" section of the New Vehicle Limited Warranty also apply to this warranty. WARRANTY PARTS LIST Air/Fuel Metering System • Air/fuel ratio feedback control system • Cold - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 20
claim solely because you used a service provider other than a Toyota dealership for maintenance and repairs. However, any failure or noncompliance caused by improper maintenance or repairs is not covered by this warranty. Ignition System • Distributor and internal parts • Ignition coil and ignitor - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 21
and maintain the quality built into your vehicle's emission control systems, Toyota recommends the use of Genuine Toyota Parts when servicing or repairing the systems. Warranty coverage is not dependent upon the use of any particular brand of replacement parts and you may elect to use non-Genuine - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 22
20460 Vehicles equipped with a California Certified Emission Control System that are sold, registered and operated in California or any state that adopts California emission warranty provisions are also covered by the California Emission Control Warranty (see page 22). Currently, Connecticut, Maine - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 23
and which were not in general use before 1968.) 3) We have performed all emission control system preparations required by Toyota prior to the sale of the vehicle as set forth in Toyota's current pre-delivery service manual. 4) Except as may be provided in Paragraph 5, if this vehicle fails an EPA - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 24
to which this warranty applies. Vehicles covered by this warranty are also covered by the Federal Emission Control Warranty (see page 16). The California Air Resources Board (CARB) and Toyota are pleased to explain the emission control system warranty for your 2011 vehicle. In California, new motor - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 25
all necessary repairs and adjustments will be made by Toyota to ensure that your vehicle passes the test. This is your Emission Control System PERFORMANCE WARRANTY. • If an emissions-related part listed on pages 17-18 is defective, the part will be repaired or replaced by Toyota. This is your SHORT - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 26
The parts listed here are covered for seven years or 70,000 miles from the vehicle's in-service date, whichever occurs first. Air/Fuel Metering System • Air pump • Engine control computer (engine control module) • Fuel pump • Throttle body Air Induction System • Intake manifold and intake air - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 27
because you used a service provider other than a Toyota dealership for maintenance and repairs. However, any failure or noncompliance caused by improper maintenance or repairs is not covered by this warranty. Ignition System • Knock sensor Other Parts Used in Above Systems • Transmission solenoid - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 28
and maintain the quality built into your vehicle's emission control systems, Toyota recommends the use of Genuine Toyota Parts when servicing or repairing the systems. Warranty coverage is not dependent upon the use of any particular brand of replacement parts and you may elect to use non-Genuine - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 29
Control Warranty WARRANTY REPAIR DELAYS If a Toyota dealership is unable to complete repairs on your vehicle within 30 days, you may have the repairs made under Toyota from or report complaints to: California Air Resources Board Mobile Source Control Division 9528 Telstar Avenue P.O. Box 8001 - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 30
The tires that come as original equipment on your vehicle are warranted by their manufacturer and not Toyota. A separate warranty statement for the tires is in your glove box. To obtain service for a tire defect, take the tire to an authorized dealer of the tire manufacturer. (Refer to your local - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 31
Operation and Maintenance WARRANTY GENERAL INFORMATION You are responsible for ensuring that your Toyota is operated and maintained according to the instructions in the Owner's Manual and this booklet. You should keep detailed records of vehicle maintenance, since under some circumstances they may - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 32
an extensive inventory of Genuine Toyota Parts to meet your vehicle service needs. And because it is linked electronically to Toyota's Parts Distribution Centers, the dealership has quick access to any parts it may not have in stock. Genuine Toyota Parts are covered by their own warranty (see - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 33
unsafe to drive and there is no Toyota dealership reasonably available to make repairs, you may perform the repairs yourself or have them performed by another automotive service provider. Toyota will reimburse you for any of the repairs that are covered by warranty. To receive reimbursement, present - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 34
Notes WARRANTY 32 Your Responsibilities - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 35
of performance, safety and reliability from your Toyota. It can also increase your vehicle's with other important information related to vehicle service, you'll find factory-recommended maintenance Owner's Manual. Be sure to perform these procedures regularly to ensure the most trouble-free operation - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 36
should change your vehicle's oil and filter). Failure to do so can cause oil starvation and or oil gelling, which can result in severe damage to your vehicle and require costly repairs that are not covered by the New Vehicle Limited Warranty. Maintenance Providers Maintenance and repair services - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 37
ensure that your vehicle receives first-quality service and parts, Toyota recommends having maintenance performed by an authorized Toyota dealership. Toyota dealership technicians are experts on Toyota vehicles, and they use Genuine Toyota Parts designed to your vehicle's exact specifications. When - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 38
and CareЉ section of the Owner's Manual. Be sure to perform these procedures regularly to ensure the most trouble-free operation of your vehicle. SuperChrome and Alloy Wheel Care If you purchased genuine Toyota accessory Aluminum Alloy Wheels, follow these cleaning guidelines to maintain the - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 39
these inspections every day: • Check ball joints and dust covers • Check brake lines and hoses • Check brake pads/disc • Check differential oil • Check drive shaft boots • Check engine air filter • Check nuts and bolts on chassis and body • Check steering linkage and boots • Check transfer case oil - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 40
driver's floor mat Inspect and adjust all fluid levels Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions 2 Driving on dirt roads or dusty roads: Inspect ball joints and dust covers - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 41
's floor mat Clean cabin air filter Inspect and adjust all fluid levels Lubricate propeller shaft (4WD) Re-torque propeller shaft bolt Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Inspect the following: __ Ball joints and dust covers __ - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 42
driver's floor mat Inspect and adjust all fluid levels Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions 2 Driving on dirt roads or dusty roads: Inspect ball joints and dust covers - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 43
's floor mat Inspect and adjust all fluid levels Lubricate propeller shaft (4WD) Re-torque propeller shaft bolt Replace cabin air filter Replace engine air filter Replace engine oil and oil filter 1 Rotate tires Inspect the following: __ Automatic transmission fluid __ Ball joints and dust covers __ - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 44
driver's floor mat Inspect and adjust all fluid levels Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions 2 Driving on dirt roads or dusty roads: Inspect ball joints and dust covers - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 45
's floor mat Clean cabin air filter Inspect and adjust all fluid levels Lubricate propeller shaft (4WD) Re-torque propeller shaft bolt Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Inspect the following: __ Ball joints and dust covers __ - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 46
driver's floor mat Inspect and adjust all fluid levels Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions 2 Driving on dirt roads or dusty roads: Inspect ball joints and dust covers - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 47
's floor mat Inspect and adjust all fluid levels Lubricate propeller shaft (4WD) Re-torque propeller shaft bolt Replace cabin air filter Replace engine air filter Replace engine oil and oil filter 1 Rotate tires Inspect the following: __ Automatic transmission fluid __ Ball joints and dust covers __ - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 48
driver's floor mat Inspect and adjust all fluid levels Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions 2 Driving on dirt roads or dusty roads: Inspect ball joints and dust covers - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 49
's floor mat Clean cabin air filter Inspect and adjust all fluid levels Lubricate propeller shaft (4WD) Re-torque propeller shaft bolt Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Inspect the following: __ Ball joints and dust covers __ - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 50
driver's floor mat Inspect and adjust all fluid levels Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions 2 Driving on dirt roads or dusty roads: Inspect ball joints and dust covers - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 51
's floor mat Inspect and adjust all fluid levels Lubricate propeller shaft (4WD) Re-torque propeller shaft bolt Replace cabin air filter Replace engine air filter Replace engine oil and oil filter 1 Rotate tires Inspect the following: __ Automatic transmission fluid __ Ball joints and dust covers __ - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 52
Schedule A - 5.7L Engines 95,000 miles or 114 months Check installation of driver's floor mat Inspect and adjust all fluid levels Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs 100,000 miles or 120 months Check installation of driver's - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 53
's floor mat Clean cabin air filter Inspect and adjust all fluid levels Lubricate propeller shaft (4WD) Re-torque propeller shaft bolt Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Inspect the following: __ Ball joints and dust covers __ - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 54
driver's floor mat Inspect and adjust all fluid levels Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions 2 Driving on dirt roads or dusty roads: Inspect ball joints and dust covers - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 55
or 144 months Check installation of driver's floor mat Inspect and adjust all fluid levels Lubricate propeller shaft (4WD) Re-torque propeller shaft bolt Replace cabin air filter Replace engine air filter Replace engine oil and oil filter 1 Replace spark plugs 4 Rotate tires Inspect the following - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 56
driver's floor mat Inspect and adjust all fluid levels Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions 2 Driving on dirt roads or dusty roads: Inspect ball joints and dust covers - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 57
of driver's floor mat Clean cabin air filter Inspect and adjust all fluid levels Lubricate propeller shaft (4WD) Re-torque propeller shaft bolt Rotate tires Visually inspect brake linings/drums and brake pads/discs Note: If 0W-20 oil WAS NOT used at the last oil change, replace engine oil and - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 58
ball joints and dust covers Inspect drive shaft boots (4WD) Inspect engine air filter Inspect steering linkage and boots Lubricate propeller shaft (4WD) 3 Re-torque propeller shaft bolt 3 Replace engine oil and oil filter 1 Tighten nuts and bolts on chassis and body Driving while towing, using - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 59
's floor mat Inspect and adjust all fluid levels Lubricate propeller shaft (4WD) Re-torque propeller shaft bolt Replace cabin air filter Replace engine air filter Replace engine oil and oil filter 1 Rotate tires Inspect the following: __ Automatic transmission fluid __ Ball joints and dust covers __ - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 60
installation of driver's floor mat Inspect and adjust all fluid levels Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Note: If 0W-20 oil WAS NOT used at the last oil change, replace engine oil and oil filter.1 Additional Maintenance Items - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 61
of driver's floor mat Clean cabin air filter Inspect and adjust all fluid levels Lubricate propeller shaft (4WD) Re-torque propeller shaft bolt Rotate tires Visually inspect brake linings/drums and brake pads/discs Note: If 0W-20 oil WAS NOT used at the last oil change, replace engine oil and - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 62
ball joints and dust covers Inspect drive shaft boots (4WD) Inspect engine air filter Inspect steering linkage and boots Lubricate propeller shaft (4WD) 3 Re-torque propeller shaft bolt 3 Replace engine oil and oil filter 1 Tighten nuts and bolts on chassis and body Driving while towing, using - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 63
's floor mat Inspect and adjust all fluid levels Lubricate propeller shaft (4WD) Re-torque propeller shaft bolt Replace cabin air filter Replace engine air filter Replace engine oil and oil filter 1 Rotate tires Inspect the following: __ Automatic transmission fluid __ Ball joints and dust covers __ - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 64
installation of driver's floor mat Inspect and adjust all fluid levels Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Note: If 0W-20 oil WAS NOT used at the last oil change, replace engine oil and oil filter.1 Additional Maintenance Items - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 65
of driver's floor mat Clean cabin air filter Inspect and adjust all fluid levels Lubricate propeller shaft (4WD) Re-torque propeller shaft bolt Rotate tires Visually inspect brake linings/drums and brake pads/discs Note: If 0W-20 oil WAS NOT used at the last oil change, replace engine oil and - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 66
ball joints and dust covers Inspect drive shaft boots (4WD) Inspect engine air filter Inspect steering linkage and boots Lubricate propeller shaft (4WD) 3 Re-torque propeller shaft bolt 3 Replace engine oil and oil filter 1 Tighten nuts and bolts on chassis and body Driving while towing, using - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 67
's floor mat Inspect and adjust all fluid levels Lubricate propeller shaft (4WD) Re-torque propeller shaft bolt Replace cabin air filter Replace engine air filter Replace engine oil and oil filter 1 Rotate tires Inspect the following: __ Automatic transmission fluid __ Ball joints and dust covers __ - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 68
months Check installation of driver's floor mat Inspect and adjust all fluid levels Replace engine coolant 4 Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Note: If 0W-20 oil WAS NOT used at the last oil change, replace engine oil and oil - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 69
of driver's floor mat Clean cabin air filter Inspect and adjust all fluid levels Lubricate propeller shaft (4WD) Re-torque propeller shaft bolt Rotate tires Visually inspect brake linings/drums and brake pads/discs Note: If 0W-20 oil WAS NOT used at the last oil change, replace engine oil and - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 70
ball joints and dust covers Inspect drive shaft boots (4WD) Inspect engine air filter Inspect steering linkage and boots Lubricate propeller shaft (4WD) 3 Re-torque propeller shaft bolt 3 Replace engine oil and oil filter 1 Tighten nuts and bolts on chassis and body Driving while towing, using - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 71
or 144 months Check installation of driver's floor mat Inspect and adjust all fluid levels Lubricate propeller shaft (4WD) Re-torque propeller shaft bolt Replace cabin air filter Replace engine air filter Replace engine oil and oil filter 1 Replace spark plugs 4 Rotate tires Inspect the following - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 72
by a qualified technician immediately. Cabin Air Filter Clean or replace at specified intervals. Driving in heavy traffic, on dirt roads or in urban, desert or dusty areas may shorten filter's life. More frequent replacement may be necessary. Ball Joints and Dust Covers Check the suspension and - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 73
. • Always properly secure the driver's floor mat using the retaining hooks. • Never install another floor mat on top of the existing driver's floor mat. • Never install the driver's floor mat upside down. MAINTENANCE Engine Air Filter Replace at specified intervals. When performing inspections - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 74
Vapor Vent System Hoses Visually inspect for corrosion, damage, cracks, and loose or leaking connections. Tighten connections or replace parts as necessary. Fuel Tank Cap Gasket Visually inspect for cracks, deterioration and damage and replace if necessary. Nuts and Bolts on Chassis and Body Re - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 75
molybdenum-disulfide lithium-base chassis grease, and re-torque the bolt. Only a qualified technician should perform this operation Tire Rotation Tires should be rotated according to the instructions in the Owner's Manual. When rotating tires, check for damage and uneven wear. Replace if necessary - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 76
Vehicle Identification Model In-service date Selling dealership MAINTENANCE Key number Body style Mileage at delivery Selling dealership phone number Vehicle Identification Number 74 Maintenance Log - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 77
Notes MAINTENANCE Maintenance Log 75 - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 78
Notes MAINTENANCE 76 Maintenance Log - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 79
TUNDRA 2 0 1 1 F F V MaIntEnanCE GUIDE warranty & www.toyota.com OWNER INFORMATION CHANGE FORM If your name or address has changed or you purchased your Toyota as a used vehicle, please complete and mail the attached card, even if your warranty coverage has expired. This will enable Toyota to - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 80
CUSTOMER LOYALTY WC13 TOYOTA MOTOR SALES USA INC PO BOX 2991 TORRANCE CA 90509-9809 - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 81
page identifies the section you are in. For more information about our vehicles, our company or the products and services available for your vehicle, please visit Toyota's official Web site, www.toyota.com. We wish you many miles of safe and pleasurable driving, and we look forward to serving you - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 82
Coverages at a Glance 4 5 7 8 10 Your Warranties in Detail General Warranty Provisions New Vehicle Limited Warranty Federal Emission Control Warranty California Emission Control Warranty Tire Limited Warranty 11 12 16 22 28 Your Responsibilities Operation and Maintenance Obtaining Warranty - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 83
Items Vehicle Identification 35 37 38 54 58 Find It Online For your convenience, scheduled maintenance information for your vehicle is also available at www.ToyotaOwnersOnline.com. From the site's home page, go to the "Scheduled Maintenance" link. Then select your vehicle's model name, model - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 84
the card at the back of this booklet if you change your address or if you've purchased this vehicle from a previous owner. To provide you with added protection against unexpected service costs, we offer Toyota Extra Care vehicle service agreements and Toyota Auto Care pre-paid maintenance programs - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 85
Key THE NEW WORLD OF ANTI-THEFT TECHNOLOGY This Toyota vehicle may be equipped with an electronic "immobilizer" anti-theft system. When the key is to key codes and service procedures for electronically registering replacement keys is restricted. Only a Toyota dealer or certain bonded/registered - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 86
the immobilizer if all registered master keys have been lost. If a Toyota dealer is not available, please refer to www.aloa.org to find a bonded/registered locksmith who performs high security key service. KEEPING THE KEY SAFE Replacing an immobilizer key may be costly. It is advisable to keep - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 87
all 2011 model-year Toyotas sold and serviced by authorized Toyota dealerships Toyota dealer. WARRANTY • The warranty repairs will take longer than one day to complete. • The warrantable condition requires extensive diagnosis. • The parts needed for the warranty repairs are not readily available - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 88
oth Toyota and your Toyota dealer are dedicated to serving your automotive needs. Your complete satisfaction is our first priority. Should you have a problem Toyota and the names of your selling and servicing dealerships. Step 1 Discuss the situation with a dealership manager, such as the service - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 89
Program (CDSP). A brochure about the program is found in your glove box. For additional information, call the Toyota Customer Experience Center at , the programs may be changed without notice. For the most current information about the programs, call the Toyota Customer Experience Center at (800 - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 90
Warranty Coverages at a Glance WARRANTY 10 Introduction - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 91
be made by the servicing Toyota dealership and/or Toyota. Parts scheduled to be replaced as required maintenance are warranted until their first replacement only. Which Vehicles Are Covered These warranties apply to all 2011 model year Tundra vehicles distributed by Toyota that are originally sold - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 92
housing and all internal parts, engine control computer, water pump, fuel pump, seals and gaskets. Restraint Systems Warranty This warranty covers repairs needed to correct defects in materials or workmanship of any seatbelt or air bag system supplied by Toyota, subject to the exceptions - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 93
installation of non-Genuine Toyota Accessories • Lack of or improper maintenance, including use of fluids other than those specified in the Owner's Manual • Installation of non-Genuine Toyota Parts • Airborne chemicals, tree sap, road debris (including stone chips), rail dust, salt, hail, floods - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 94
Limited Warranty Maintenance Expense WARRANTY Normal maintenance services such as: • Engine tune-ups • Replacement of fluids and filters • Lubrication • Cleaning and polishing • Replacement of spark plugs and fuses • Replacement of worn wiper blades, brake pads/linings and clutch linings Vehicles - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 95
New Vehicle Limited Warranty DISPUTE RESOLUTION If a dispute arises regarding your warranty coverage, please follow the steps described under "If You Need Assistance" on pages 8-9. Please note that you must use the Dispute Settlement Program (or, in California, the CDSP) before seeking remedies - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 96
Federal Emission Control Warranty WHAT IS COVERED AND HOW LONG Emission Defect Warranty WARRANTY Toyota warrants that your vehicle: or 24,000 miles from the vehicle's in-service date, whichever occurs first. Additionally, components marked "8/80" in the parts list on pages 17-18 have coverage of - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 97
use of replacement parts not equivalent in quality or design to original equipment parts. Provisions under the "What Is Not Covered" section of the New Vehicle Limited Warranty also apply to this warranty. WARRANTY PARTS LIST Air/Fuel Metering System • Air/fuel ratio feedback control system • Cold - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 98
and internal parts • Ignition coil and ignitor • Ignition wires • Spark plugs* Positive Crankcase Ventilation (PCV) System • Oil filler cap • PCV valve or orifice * Warranted until first required maintenance under terms of the California Emission Control Warranty. 8/80 = Covered for eight - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 99
maintenance or repairs is not covered by this warranty. REPLACEMENT PARTS To ensure optimum performance and maintain the quality built into your vehicle's emission control systems, Toyota recommends the use of Genuine Toyota Parts when servicing or repairing the systems. Warranty coverage is not - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 100
agree to a delay, or when a delay is caused by factors beyond the control of Toyota or the dealership. For information on how to obtain service under the Emission Defect Warranty, see page 31, "Obtaining Warranty Service." IF YOU HAVE QUESTIONS If you have questions or concerns about your federal - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 101
and which were not in general use before 1968.) 3) We have performed all emission control system preparations required by Toyota prior to the sale of the vehicle as set forth in Toyota's current pre-delivery service manual. 4) Except as may be provided in Paragraph 5, if this vehicle fails an EPA - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 102
to which this warranty applies. Vehicles covered by this warranty are also covered by the Federal Emission Control Warranty (see page 16). The California Air Resources Board (CARB) and Toyota are pleased to explain the emission control system warranty for your 2011 vehicle. In California, new motor - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 103
all necessary repairs and adjustments will be made by Toyota to ensure that your vehicle passes the test. This is your Emission Control System PERFORMANCE WARRANTY. • If an emissions-related part listed on pages 17-18 is defective, the part will be repaired or replaced by Toyota. This is your SHORT - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 104
parts. Provisions under the "What Is Not Covered" section of the New Vehicle Limited Warranty also apply to this warranty. Air/Fuel Metering System • Air pump • Engine control computer (engine control module) • Fuel pump • Throttle body Air Induction System • Intake manifold and intake air - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 105
used a service provider other than a Toyota dealership for maintenance and repairs. However, any failure or noncompliance caused by improper maintenance or repairs is not covered by this warranty. WARRANTY Ignition System • Knock sensor Other Parts Used in Above Systems • Transmission solenoid - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 106
and maintain the quality built into your vehicle's emission control systems, Toyota recommends the use of Genuine Toyota Parts when servicing or repairing the systems. Warranty coverage is not dependent upon the use of any particular brand of replacement parts and you may elect to use non-Genuine - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 107
Control Warranty REPAIR DELAYS If a Toyota dealership is unable to complete repairs on your vehicle within 30 days, you may have the repairs made under Toyota information from or report complaints to: California Air Resources Board Mobile Source Control Division 9528 Telstar Avenue P.O. Box 8001 El - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 108
WARRANTY The tires that come as original equipment on your vehicle are warranted by their manufacturer and not Toyota. A separate warranty statement for the tires is in your glove box. To obtain service for a tire defect, take the tire to an authorized dealer of the tire manufacturer. (Refer to your - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 109
you're getting the best possible service for your vehicle when you take it to a Toyota dealership. GENERAL INFORMATION You are responsible for ensuring that your Toyota is operated and maintained according to the instructions in the Owner's Manual and this booklet. You should keep detailed - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 110
an extensive inventory of Genuine Toyota Parts to meet your vehicle service needs. And because it is linked electronically to Toyota's Parts Distribution Centers, the dealership has quick access to any parts it may not have in stock. WARRANTY Genuine Toyota Parts are covered by their own warranty - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 111
unsafe to drive and there is no Toyota dealership reasonably available to make repairs, you may perform the repairs yourself or have them performed by another automotive service provider. Toyota will reimburse you for any of the repairs that are covered by warranty. To receive reimbursement, present - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 112
Notes WARRANTY 32 Your Responsibilities - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 113
of performance, safety and reliability from your Toyota. It can also increase your vehicle's with other important information related to vehicle service, you'll find factory-recommended maintenance Owner's Manual. Be sure to perform these procedures regularly to ensure the most trouble-free operation - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 114
important to regularly replace the engine oil and oil filter. Failure to do so can cause oil gelling, which can result in severe damage to your vehicle and require costly repairs that are not covered by the New Vehicle Limited Warranty. Maintenance Providers Maintenance and repair services may be - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 115
ensure that your vehicle receives first-quality service and parts, Toyota recommends having maintenance performed by an authorized Toyota dealership. Toyota dealership technicians are experts on Toyota vehicles, and they use Genuine Toyota Parts designed to your vehicle's exact specifications. When - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 116
and CareЉ section of the Owner's Manual. Be sure to perform these procedures regularly to ensure the most trouble-free operation of your vehicle. SuperChrome and Alloy Wheel Care If you purchased genuine Toyota accessory Aluminum Alloy Wheels, follow these cleaning guidelines to maintain the - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 117
these inspections every day: • Check ball joints and dust covers • Check brake lines and hoses • Check brake pads/disc • Check differential oil • Check drive shaft boots • Check engine air filter • Check nuts and bolts on chassis and body • Check steering linkage and boots • Check transfer case oil - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 118
driver's floor mat Inspect and adjust all fluid levels Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions 2 Driving on dirt roads or dusty roads: Inspect ball joints and dust covers - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 119
floor mat Clean cabin air filter Inspect and adjust all fluid levels Lubricate propeller shaft (4WD) Re-torque propeller shaft bolt Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Inspect the following: Ball joints and dust covers Brake - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 120
driver's floor mat Inspect and adjust all fluid levels Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions 2 Driving on dirt roads or dusty roads: Inspect ball joints and dust covers - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 121
's floor mat Inspect and adjust all fluid levels Lubricate propeller shaft (4WD) Re-torque propeller shaft bolt Inspect the following: Replace cabin air filter Replace engine air filter Replace engine oil and oil filter Rotate tires 1 Automatic transmission fluid Ball joints and dust covers - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 122
driver's floor mat Inspect and adjust all fluid levels Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions 2 Driving on dirt roads or dusty roads: Inspect ball joints and dust covers - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 123
's floor mat Clean cabin air filter Inspect and adjust all fluid levels Lubricate propeller shaft (4WD) Re-torque propeller shaft bolt Inspect the following: Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Ball joints and dust covers - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 124
driver's floor mat Inspect and adjust all fluid levels Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions 2 Driving on dirt roads or dusty roads: Inspect ball joints and dust covers - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 125
's floor mat Inspect and adjust all fluid levels Lubricate propeller shaft (4WD) Re-torque propeller shaft bolt Inspect the following: Replace cabin air filter Replace engine air filter Replace engine oil and oil filter Rotate tires 1 Automatic transmission fluid Ball joints and dust covers - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 126
driver's floor mat Inspect and adjust all fluid levels Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions 2 Driving on dirt roads or dusty roads: Inspect ball joints and dust covers - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 127
87 months Check installation of driver's floor mat Inspect and adjust all fluid levels Replace engine oil 1 DEALER SERVICE VERIFICATION: DATE: MILEAGE: 75,000 miles or 90 months Check installation of driver's floor mat Clean cabin air filter Inspect and adjust all fluid levels Lubricate propeller - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 128
driver's floor mat Inspect and adjust all fluid levels Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions 2 Driving on dirt roads or dusty roads: Inspect ball joints and dust covers - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 129
's floor mat Inspect and adjust all fluid levels Lubricate propeller shaft (4WD) Re-torque propeller shaft bolt Inspect the following: Replace cabin air filter Replace engine air filter Replace engine oil and oil filter Rotate tires 1 Automatic transmission fluid Ball joints and dust covers - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 130
installation of driver's floor mat Inspect and adjust all fluid levels Replace engine oil 1 DEALER SERVICE VERIFICATION: DATE: MILEAGE: 95,000 miles or 114 months Check installation of driver's floor mat Inspect and adjust all fluid levels Replace engine oil and oil filter 1 Rotate tires Visually - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 131
months Check installation of driver's floor mat Inspect and adjust all fluid levels Replace engine oil 1 DEALER SERVICE VERIFICATION: DATE: MILEAGE: 105,000 miles or 126 months Check installation of driver's floor mat Clean cabin air filter Inspect and adjust all fluid levels Lubricate propeller - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 132
driver's floor mat Inspect and adjust all fluid levels Replace engine oil and oil filter 1 Rotate tires Visually inspect brake linings/drums and brake pads/discs Additional Maintenance Items for Special Operating Conditions 2 Driving on dirt roads or dusty roads: Inspect ball joints and dust covers - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 133
SERVICE VERIFICATION: DATE: MILEAGE: 120,000 miles or 144 months Check installation of driver's floor mat Inspect and adjust all fluid levels Lubricate propeller shaft (4WD) Re-torque propeller shaft bolt Inspect the following: Replace cabin air filter Replace engine air filter Replace engine - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 134
qualified technician immediately. Cabin Air Filter Clean or replace at specified intervals. Driving in heavy traffic, on dirt roads or in urban, desert or dusty areas may shorten filter's life. More frequent replacement may be necessary. Ball Joints and Dust Covers MAINTENANCE Check the suspension - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 135
of the existing driver's floor mat. • Never install the driver's floor mat upside down. Your Toyota is equipped with Genuine Toyota Super Long-Life Coolant. The replacement intervals for engine coolant recommended in this booklet are based on replacement with Genuine Toyota Super Long-Life Coolant - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 136
freeplay in the steering wheel. Inspect the linkage for bending and damage and the dust boots for deterioration, cracks and damage. Replace any damaged parts. A qualified technician should perform these operations. MAINTENANCE Nuts and Bolts on Chassis and Body Re-tighten the seat-mounting - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 137
of Maintenance Items Tire Rotation Tires should be rotated according to the instructions in the Owner's Manual. When rotating tires, check for damage and uneven wear. Replace if necessary. Transfer Case Oil Inspect or replace at specified intervals. When performing inspections, check for signs of - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 138
Vehicle Identification Model In-service date Selling dealership Key number Body style Mileage at delivery Selling dealership phone number Vehicle Identification Number MAINTENANCE 58 Maintenance Log - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 139
Notes MAINTENANCE Maintenance Log 59 - 2011 Toyota Tundra Double Cab | Warranty, Maitenance, Services Guide - Page 140
Notes MAINTENANCE 60 Maintenance Log