Compaq 6515b HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai
Compaq 6515b - Notebook PC Manual
View all Compaq 6515b manuals
Add to My Manuals
Save this manual to your list of manuals |
Compaq 6515b manual content summary:
- Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 1
HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC Maintenance and Service Guide - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 2
and Windows Vista are either trademarks or registered trademarks of Microsoft Corporation in the United States and/or other countries. SD Logo is a trademark of its proprietor. The information contained herein is subject to change without notice. The only warranties for HP products and services are - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 3
. Do not allow another hard surface, such as an adjoining optional printer, or a soft surface, such as pillows or rugs or clothing, to block airflow. Also, do not allow the AC adapter to contact the skin or a soft surface, such as pillows or rugs or clothing, during operation. The computer and the - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 4
iv Safety warning notice - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 5
storage devices ...30 Miscellaneous parts ...31 Sequential part number listing ...32 4 Removal and replacement procedures Preliminary replacement requirements 39 Tools required ...39 Service considerations ...39 Plastic parts ...39 Cables and connectors 40 Drive handling 40 Grounding guidelines - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 6
drive ...60 Keyboard ...62 Internal memory module ...65 RTC battery ...66 WWAN module ...67 Switch cover ...68 Fan ...69 Heat sink ...71 Processor ...73 Display assembly ...75 Top cover ...79 Speaker assembly ...83 Media Card Reader/USB connector board 84 System board ...86 PC Card/audio board - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 7
14.1-inch, WXGA+ display specifications 101 Hard drive specifications ...102 Primary 6-cell, Li-ion battery specifications 103 DVD±RW and CD-RW Super Multi Double-Layer Combo Drive specifications 104 DVD/CD-RW Combo Drive specifications 105 DVD-ROM drive ...106 System DMA specifications ...107 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 8
in Windows 141 Initiating a recovery from the hard drive recovery partition 141 9 Connector pin assignments Audio-out (headphone) ...142 Audio-in (microphone) ...142 External monitor ...143 RJ-11 (modem) ...144 RJ-45 (network) ...144 S-Video-out ...145 Universal Serial Bus ...145 10 Power cord set - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 9
Category Processors Chipsets Graphics Panels Memory Description HP Compaq 6515b HP Compaq 6515b Notebook PC without Notebook PC with WWAN WWAN AMD Turion™ ● Support privacy film √ √ ● Two SODIMM slots, both customer accessible/ √ √ upgradable (memory slot under the keyboard must be - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 10
Hard drives Optical drives Diskette drive Audio Description ● Supports dual-channel memory HP Compaq 6515b HP Compaq 6515b Notebook PC without Notebook PC with WWAN WWAN ● Supports the following configurations: ◦ 4096 MB total system memory (2048 MB × 2, dual-channel) ◦ 2048 MB total system - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 11
Category Modem Ethernet Wireless External media card Ports Description HP Compaq 6515b HP Compaq 6515b Notebook PC without Notebook PC with WWAN WWAN ● 56K data/fax modem (MDC1.5) √ √ ● Modem cable included in Brazil, the Czech Republic, France, Greece, Hungary, Israel, Latin America, - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 12
AC adaptor connector ● Travel battery connector ● USB ports (4) ● VGA port (Dsub 15-pin) supporting 1600 × 1200 external resolution @ 75 Hz, hot plug/ unplug, and auto detect HP Compaq 6515b HP Compaq 6515b Notebook PC without Notebook PC with WWAN WWAN Docking Docking support √ √ Keyboard - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 13
Description HP Compaq 6515b HP Compaq 6515b Notebook PC without Notebook PC with WWAN WWAN Certified: SuSe Linux Enterprise Desktop (SLED) 10 Supported: Windows Vista Enterprise End-user replaceable parts: √ √ ● AC adapter ● Hard drive ● Memory module ● Optical drive ● Primary battery - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 14
Hard drives Optical drives Diskette drive Description HP Compaq 6510b HP Compaq 6510b Notebook PC without Notebook PC with WWAN WWAN ● Two SODIMM slots, both customer accessible/ √ √ upgradable (memory slot under the keyboard must be populated first) ● DDRII PC2-5300 (667-MHz) ● Supports - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 15
Category Audio Description ● Azalia HP Compaq 6510b HP Compaq 6510b Notebook PC without Notebook PC with WWAN WWAN on LAN (on AC power only) ● Network interface card (NIC) power down Wireless Integrated wireless options by way of wireless module Wireless local area network (WLAN) options: - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 16
AC adaptor connector ● Travel battery connector ● USB ports (4) ● VGA port (Dsub 15-pin) supporting 1600 × 1200 external resolution @ 75 Hz, hot plug/ unplug, and auto detect HP Compaq 6510b HP Compaq 6510b Notebook PC without Notebook PC with WWAN WWAN Docking Docking support √ √ Keyboard - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 17
Windows Vista Home Basic ● Windows Vista Business 32/64 ● FreeDOS ● Windows® XP Professional Certified: SuSe Linux Enterprise Desktop (SLED) 10 Supported: Windows Vista Enterprise End-user replaceable parts: √ √ ● AC adapter ● Hard drive ● Memory module ● Optical drive ● Primary battery - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 18
, and fingerprint reader Item Component (1) Power button Function ● When the computer is off, press the button to turn on the computer. ● When the computer is on, press the button to shut down the computer. ● When the computer is in the Sleep state (Windows Vista) or in Standby (Windows XP), press - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 19
To learn more about power settings, follow these steps: ● In Windows Vista, select Start > Control Panel > System and Maintenance > Power Options. ● In Windows XP, select Start > Control Panel > Performance and Maintenance > Power Options. Turns off the display if the display is closed while the - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 20
the Sleep state (Windows Vista) or in Standby (Windows XP). ● Blinking rapidly: An AC adapter with a higher power rating should be connected. ● Off: The computer is off or in Hibernation. ● On: An integrated wireless device, such as a wireless local area network (WLAN) device, a wireless wide-area - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 21
power source, the light stays off until the battery reaches a low battery level. ● Blinking green: The hard drive or optical drive is being accessed. ● Amber: HP 3D DriveGuard has temporarily parked the internal hard drive. Item Component (1) esc key (2) fn key (3) Windows logo key (4) Windows - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 22
(4) Right TouchPad button* Functions like the right button on an external mouse. *This table describes factory settings. View or change pointing device preferences as follows: ● In Windows Vista, select Start > Control Panel > Hardware and Sound > Mouse. ● In Windows XP, select Start > Control - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 23
All wireless devices are turned off. ● On: The computer is on. ● Blinking: The computer is in the Sleep state (Windows Vista) or in Standby (Windows XP). ● Blinking rapidly: An AC adapter with a higher power rating should be connected. ● Off: The computer is off or in Hibernation. ● Amber: A battery - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 24
button (3) Power connector (4) Vent (5) USB ports (2) (6) Audio-out (headphone) jack (7) Audio-in (microphone) jack (8) 1394 port (select models only) Function Supports optional Type I or Type II 32-bit (CardBus) or 16-bit PC Cards. Ejects a PC Card from the PC Card slot. Connects an AC adapter - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 25
or stolen. Connects a network cable. Connects an external drive (4) RJ-11 (modem) jack Function ● Secure Digital (SD) Memory Card ● MultiMediaCard (MMC) ● Memory Stick (MS) ● Memory Stick Pro (MSP) ● Memory Stick Duo Adapter ● xD-Picture Card (XD) Connect optional USB devices. Reads optical discs - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 26
fan to cycle on and off during routine operation. Contains a Bluetooth device. Connects an optional docking device. Contains the memory module slot and the WLAN module slot. CAUTION: To prevent an unresponsive system, replace the wireless module only with a wireless module authorized for use in the - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 27
3 Illustrated parts catalog Serial number location When ordering parts or requesting information, provide the computer serial number and model number located on the bottom of the computer. Serial number location 19 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 28
Computer major components 20 Chapter 3 Illustrated parts catalog - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 29
Item Description Spare part number (1) Display assemblies 14.1-inch, WXGA display assembly for use only with HP Compaq 6515b computer models 443895-001 with WWAN capability 14.1-inch, WXGA, BrightView display assembly for use only with HP Compaq 6515b computer models without WWAN capability - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 30
6515b computer models 443912-001 For use with HP Compaq 6510b computer models 446920-001 Thermal Material Kits (not illustrated) For use in all countries and regions except Japan and Asia/Pacific 413706-001 For use Japan and Asia/Pacific countries and regions 445853-001 (7) Memory modules - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 31
Kit (see Plastics Kit on page 28 for more Plastics Kit spare part information): 443905-001 (9a) PC Card slot bezel (9b) Hard drive cover (includes 2 captive screws, secured by C-clips) (9c) Memory/WLAN module compartment cover (includes 1 captive screw, secured by a C-clip) (9d) Bluetooth - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 32
Item Description Spare part number (13) RTC battery 449137-001 (14) System boards For use with HP Compaq 6515b computer models with WWAN capability (includes WWAN 443896-001 module slot) For use with HP Compaq 6515b computer models without WWAN capability (does not include WWAN module slot) - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 33
Item Description Spare part number the Maldives, Mali, Malta, the Marshall Islands, Martinique, Mauritania, For use in Israel and Japan 441530-291 802.11a/b/g/n Intel WLAN module for use with HP Compaq 6510b computer models: ● For use in Antigua and Barbuda, Argentina, Aruba, the Bahamas, - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 34
Item Description Spare part number Swaziland, Sweden, Switzerland, Taiwan, Tajikistan, Tanzania, Togo, Tonga, Trinidad ● For use in Japan 441075-291 802.11a/b/g Intel WLAN modules for use with HP Compaq 6510b computer models: ● For use in Antigua and Barbuda, Argentina, Australia, the Bahamas - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 35
-001 (24) Optical drives (include bezel and optical drive bracket) DVD±RW and CD-RW Super Multi Double-Layer Combo Drive with LightScribe 443903-001 DVD±RW and CD-RW Super Multi Double-Layer Combo Drive 443904-001 DVD/CD-RW Combo Drive 443901-001 DVD-ROM drive 443902-001 Computer major - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 36
Plastics Kit Item Description Spare part number Plastics Kit 443905-001 (1) PC Card slot bezel (2) Hard drive cover (includes 2 captive screws, secured by C-clips) (3) Memory/WLAN module compartment cover (includes 1 captive screw, secured by a C-clip) (4) Bluetooth module compartment cover ( - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 37
Cable Kit Item Description Cable Kit (1) Modem module cable (includes RJ-11 connector and cable) (2) Microphone (includes receiver and cable) (3) Bluetooth module cable Spare part number 443887-001 Cable Kit 29 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 38
, 7200-rpm 80-GB, 5400-rpm (2) Optical drives (include bezel and optical drive bracket) DVD±RW and CD-RW Super Multi Double-Layer Combo Drive with LightScribe DVD±RW and CD-RW Super Multi Double-Layer Combo Drive DVD/CD-RW Combo Drive DVD-ROM drive Spare part number 443920-001 443919-001 445939-001 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 39
parts Description AC adapters 90-watt PFC AC adapter for use in Africa, Europe, and the Middle East 90-watt PFC AC adapter for use in North America Power cords Torx T8M2.5×7.0 screw ● Torx T8M2.5×6.0 screw Smart card reader module Spare part number 416421-021 391173-001 246959-011 246959-201 246959 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 40
-001 1024-MB memory module (667-MHz, PC-5300, 1-DIMM) 416421-021 90-watt PFC AC adapter for use in Africa, Europe, and the Middle East 417506-001 2048-MB memory module (667-MHz, PC-5300, 1-DIMM) 430871-001 Mobile AMD Sempron 3400+ 1.8-GHz processor for use with HP Compaq 6515b computer models in - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 41
Spare part number 430872-001 430874-001 430875-001 430876-001 441074-001 441074-011 441075-001 441075-002 441075-291 441082-001 441082-002 441082-003 441082-291 441086-001 Description Mobile AMD Sempron 3500+ 1.8-GHz processor for use with HP Compaq 6515b computer models in all countries and - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 42
the People's Republic of China, and South Korea 802.11a/b/g/n Intel WLAN module for use with HP Compaq 6510b computer models in Japan 802.11b/g Broadcom WLAN module for use in Canada, the Cayman Islands , Somalia, South Africa, South Korea, Spain, Sri Lanka, 34 Chapter 3 Illustrated parts catalog - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 43
module for use in Japan Media Card Reader/USB connector board 6-cell, 2.20-Ah, 47-Wh battery 6-cell, 2.55-Ah, 55-Wh battery Base enclosure (includes 6 rubber feet) Cable Kit PC Card/audio board assembly AMD Turion TL-52 1.6-GHz processor for use with HP Compaq 6515b computer models only in Japan and - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 44
for use with HP Compaq 6515b computer models in all countries and regions except Japan and Asia/Pacific (256 KB of L2 cache) Fan 80-GB, 5400-rpm hard drive 120-GB, 5400-rpm hard drive 160-GB, 5400-rpm hard drive Top cover (includes TouchPad, TouchPad cable, and fingerprint reader) Keyboard for use - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 45
Keyboard for use in Greece Thermal Material Kit for use in Japan and Asia/Pacific countries and regions 80-GB, 7200-rpm hard drive AMD Turion MK-38 2.2-GHz processor for use with HP Compaq 6515b computer models in all countries and regions except Japan and Asia/Pacific (512 KB of L2 cache) Display - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 46
number 443887-001. See Cable Kit on page 29 for more Cable Kit spare part information. Display enclosure Mobile AMD Sempron 3800+ 2.2-GHz processor for use with HP Compaq 6515b computer models in all countries and regions except Japan and Asia/Pacific (256 KB of L2 cache) AMD Turion TL-50 1.6-GHz - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 47
) away from the work area to prevent damage. Plastic parts Using excessive force during disassembly and reassembly can damage plastic parts. Use care when handling the plastic parts. Apply pressure only at the points designated in the maintenance instructions. Preliminary replacement requirements 39 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 48
shut it down through the operating system. Before handling a drive, be sure that you are discharged of static electricity. While handling a drive, avoid touching the connector. Before removing a diskette drive or optical drive, be sure that a diskette or disc is not in the drive and be sure that the - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 49
the degree of sensitivity. Networks built into many integrated circuits provide some protection, but in many cases, ESD contains enough power to alter device parameters ,000 V 21,000 V 11,000 V 55% 7,500 V 3,000 V 400 V 400 V 2,000 V 3,500 V 7,000 V 5,000 V Preliminary replacement requirements 41 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 50
parts and assemblies with conductive or approved containers or packaging. ● Keep ESD-sensitive parts in their containers until the parts ESD-sensitive parts from assemblies in ● Use conductive field service tools, such as cutters ● Handle ESD-sensitive components, parts, and assemblies by the case - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 51
of shoes or boots. On conductive floors or dissipative floor mats, use foot straps on both feet with a minimum of one megohm resistance between the operator and ground. ground cords of one megohm resistance ● Static-dissipative tables or floor mats with hard ties to the ground ● Field service kits - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 52
unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery on page 46). 5. Remove the real-time clock (RTC) battery (see RTC battery on page 66). 6. Wait approximately 5 minutes. 7. Replace the RTC battery and reassemble - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 53
, that must be removed, replaced, or loosened when servicing the computer. Make special note of each screw and screw lock size and location during removal and replacement. Serial number Report the computer serial number to HP when requesting information or ordering spare parts. The serial number is - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 54
it down through the operating system. 2. Disconnect all external devices connected to the computer. 3. Disconnect the power from the computer by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. Remove the battery: 1. Turn the computer upside - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 55
before disassembling the computer operating system. 2. Disconnect all external devices connected to the computer. 3. Disconnect the power from the computer by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 56
the operating system. 2. Disconnect all external devices connected to the computer. 3. Disconnect the power from the computer by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery on page 46). Remove the display - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 57
(1) from the display enclosure as far as the cables attached to it allow. 8. Disconnect the display panel cable (2) and the backlight cable (3) from the display inverter. 9. Remove the display inverter. Reverse this procedure to install the display inverter. Component replacement procedures 49 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 58
operating system. 2. Disconnect all external devices connected to the computer. 3. Disconnect the power from the computer by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery on page 46). Remove the hard drive - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 59
6. Remove the hard drive (4) from the hard drive bay. 7. If it is necessary to replace the hard drive bracket, remove the four Phillips PM3.0×3.0 hard drive bracket screws (1) from each side of the hard drive. 8. Lift the bracket (2) straight up to remove it from the hard drive. Reverse this - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 60
shut it down through the operating system. 2. Disconnect all external devices connected to the computer. 3. Disconnect the power from the computer by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery on page 46 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 61
cover (2), swing it forward, and remove the cover. NOTE: The Bluetooth module compartment cover is included in the Plastics Kit, spare part number 443905-001. 4. Remove the Bluetooth module (1) from the computer. 5. Disconnect the Bluetooth module cable (2) from the module. 6. Remove the Bluetooth - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 62
connected to the computer. 3. Disconnect the power from the computer by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery on page 46). Remove the expansion memory module: 1. Loosen the Phillips PM2.0×5.0 screw - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 63
4. Remove the memory module (2) by pulling the module away from the slot at an angle. NOTE: Memory modules are designed with a notch (3) to prevent incorrect installation into the memory module slot. Reverse this procedure to install the expansion memory module. Component replacement procedures 55 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 64
WWAN module are not interchangeable. Description Spare part number 802.11a/b/g/n Broadcom WLAN modules for use and Japan 441530-291 802.11a/b/g/n Intel WLAN modules for use with HP Compaq 6510b computer models: ● For use in Antigua and Barbuda, Argentina 4 Removal and replacement procedures - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 65
Description Spare part number Rica, Croatia, Cyprus, the Czech Republic, use in Japan 441082-291 802.11a/b/g Intel WLAN modules for use with HP Compaq 6510b computer models: ● For use in Antigua and Barbuda, Argentina, Australia, 441090-001 Virgin Islands Component replacement procedures 57 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 66
operating system. 2. Disconnect all external devices connected to the computer. 3. Disconnect the power from the computer by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery on page 46). 5. Remove the memory - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 67
3. Remove the WLAN module (4) by pulling the module away from the slot at an angle. NOTE: WLAN modules are designed with a notch (5) to prevent incorrect installation. Reverse this procedure to install the WLAN module. Component replacement procedures 59 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 68
by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery on page 46). 5. Remove the memory/WLAN module compartment cover (see Expansion memory module on page 54). Remove the optical drive: 1. Position the computer - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 69
5. If it is necessary to replace the optical drive bracket, remove the two Phillips PM2.0×3.0 screws (1) that secure the bracket to the optical drive. 6. Remove the optical drive bracket (2). Reverse this procedure to reassemble and install the optical drive. Component replacement procedures 61 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 70
operating system. 2. Disconnect all external devices connected to the computer. 3. Disconnect the power from the computer by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery on page 46). 5. Remove the memory - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 71
that secure the keyboard to the computer. 3. Turn the computer display-side up, with the front toward you. 4. Open the computer as far as possible. 5. Slide the four keyboard retention tabs . 6. Lift the rear edge of the keyboard (2) and swing it toward you until it rests on the palm rest. Component - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 72
7. Release the zero insertion force (ZIF) connector (1) to which the keyboard cable is attached and disconnect the keyboard cable (2) from the system board. 8. Remove the keyboard. Reverse this procedure to install the keyboard. 64 Chapter 4 Removal and replacement procedures - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 73
operating system. 2. Disconnect all external devices connected to the computer. 3. Disconnect the power from the computer by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery on page 46). 5. Remove the memory - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 74
operating system. 2. Disconnect all external devices connected to the computer. 3. Disconnect the power from the computer by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery on page 46). 5. Remove the memory - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 75
operating system. 2. Disconnect all external devices connected to the computer. 3. Disconnect the power from the computer by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery on page 46). 5. Remove the memory - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 76
shut it down through the operating system. 2. Disconnect all external devices connected to the computer. 3. Disconnect the power from the computer by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery on page 46 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 77
shut it down through the operating system. 2. Disconnect all external devices connected to the computer. 3. Disconnect the power from the computer by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery on page 46 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 78
automatically when high temperature conditions exist. These conditions are affected by high external temperatures, system power consumption, power management/battery conservation configurations, battery fast charging, and software applications. Exhaust air is displaced through the ventilation grill - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 79
shut it down through the operating system. 2. Disconnect all external devices connected to the computer. 3. Disconnect the power from the computer by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery on page 46 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 80
be thoroughly cleaned from the surfaces of the heat sink (1) and the processor and system board components (2) each time the heat sink is removed. Thermal material is included with all heat sink and processor spare part kits. Reverse this procedure to install the heat sink. 72 Chapter 4 Removal and - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 81
the computer. 3. Disconnect the power from the computer by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery on page 46). 5. Release the keyboard (see Keyboard on page 62). Component replacement procedures 73 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 82
. The illustration below shows the processor removal steps for the HP Compaq 6515b computer model. NOTE: The illustration below shows the processor removal steps for the HP Compaq 6510b computer model. Reverse this procedure to install the processor. 74 Chapter 4 Removal and replacement procedures - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 83
by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery on page 46). 5. Remove the memory/WLAN module compartment cover (see Expansion memory module on page 54). 6. Disconnect the wireless antenna cables from the - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 84
17.0 screw (1) and the Torx T8M2.5×7.0 screw (2) that secure the display assembly to the computer. 4. Position the computer with the rear panel toward you. 5. Remove the four Torx T8M2.5×9.0 screws (1) that secure the display assembly to the computer. 76 Chapter 4 Removal and replacement procedures - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 85
it (2). CAUTION: When installing the display assembly, be sure that the wireless antenna cables routed out of the display assembly right hinge are routed and , blue sequence. Failure to follow these routing instructions can result in degradation of the computer's WLAN and WWAN performance. Component - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 86
it is necessary to replace the display hinges, remove the following: (1) Four rubber screw covers from the display bezel top edge NOTE: The display bezel rubber screw covers are included in the Plastics Kit, spare part number 44305-001. (2) Four Torx T8M2.5×6.0 screws from the display bezel top edge - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 87
The left and right display hinges are available using spare part number 447204-001. Reverse this procedure to install the display assembly. Top cover Description Top cover (includes TouchPad, TouchPad cable, and fingerprint reader) Spare part number 443921-001 Component replacement procedures 79 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 88
from the computer by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery on page 46). 5. Remove the following components: a. Hard drive (see Hard drive on page 50) b. Memory/WLAN module compartment cover (see - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 89
side up, with the front toward you. 6. Disconnect the TouchPad cable (1) and the fingerprint reader board cable (2) from the system board. 7. Remove the microphone (3) from the clip built into the top cover and top cover (2) toward you until it rests at an angle. Component replacement procedures 81 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 90
disconnect the microphone cable (1) from the PC Card/audio board and remove it. NOTE: The microphone is available in the Cable Kit, spare part number 443887-001. 13. If it is necessary to replace the Bluetooth module cable, disconnect the cable (2) from the system board and remove the cable from the - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 91
from the computer by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery on page 46). 5. Remove the following components: a. Hard drive (see Hard drive on page 50) b. Memory/WLAN module compartment cover (see - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 92
it down through the operating system. 2. Disconnect all external devices connected to the computer. 3. Disconnect the power from the computer by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 84 Chapter 4 Removal and replacement procedures - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 93
memory module on page 54) c. Optical drive (see Optical drive on page 60) d. Keyboard (see Keyboard on page 62) e. Switch cover (see Switch cover on page 68) f. Display assembly (see Display assembly on page 75) g. Top cover (see Top cover on page 79) Remove the Media Card Reader/USB connector - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 94
from the computer by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery on page 46). 5. Remove the following components: a. Hard drive (see Hard drive on page 50) b. Memory/WLAN module compartment cover (see - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 95
PC Card/audio board assembly (see PC Card/audio board assembly on page 89) ● Modem module (see Modem module on page 90) ● SIM slot board (see SIM slot board on page 92) Remove the system board: 1. Press the PC Card eject button (1) twice. The first press releases the PC Card eject button from the PC - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 96
5. Use the optical drive connector (1) to lift the right side of the system board (2) until the rear left corner of the system board (3) clears the base enclosure. 6. Remove the system board (4) by pulling it away from the top cover at an angle until it clears the top cover Reverse the preceding - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 97
from the computer by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery on page 46). 5. Remove the following components: a. Hard drive (see Hard drive on page 50) b. Memory/WLAN module compartment cover (see - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 98
from the computer by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery on page 46). 5. Remove the following components: a. Hard drive (see Hard drive on page 50) b. Memory/WLAN module compartment cover (see - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 99
page 71) h. Display assembly (see Display assembly on page 75) i. Top cover (see Top cover on page 79) j. System board (see System board on page 86) k. PC Card/audio board assembly (see PC Card/audio board assembly on page 89) Remove the modem module: 1. Turn the PC Card/audio board assembly upside - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 100
from the computer by first unplugging the power cord from the AC outlet and then unplugging the AC adapter from the computer. 4. Remove the battery (see Battery on page 46). 5. Remove the following components: a. Hard drive (see Hard drive on page 50) b. Memory/WLAN module compartment cover (see - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 101
2. Lift the SIM slot board (1) straight up and remove it, making note of the location of the pins (2) on the SIM slot board and their alignment with the system board. Reverse this procedure to install the SIM slot board. Component replacement procedures 93 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 102
, ROM-based utility that can be used even when the operating system is not working or will not load. NOTE: Some of the Computer Setup menu items listed in this guide may not be supported by your computer. NOTE: Pointing devices are not supported in Computer Setup. You must use the keyboard to - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 103
, and System Configuration menus. 1. Open Computer Setup by turning on or restarting the computer, and then pressing f10 while the "F10 = ROM Based Setup" message is displayed in the lower-left corner of the screen. Because Computer Setup is not Windows-based, it does not support the TouchPad - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 104
computer and the batteries in the system. ● View specification information for the processor, cache and memory size, system ROM, video revision, and keyboard controller version. Replace the configuration settings in Computer Setup with the original factory settings. (Password settings and security - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 105
any computer hard drive and on optional MultiBay hard drives. ● Change a DriveLock user password or master password. NOTE: DriveLock settings are accessible only when you enter Computer Setup by turning on (not restarting) the computer. Enable/disable support for smart card and Java™ Card power-on - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 106
support allows the following: ◦ Use of a USB keyboard, mouse, and hub in Computer Setup even when a Windows operating system is not running. ◦ Startup from bootable USB devices, including a hard drive, diskette drive, or optical drive connected by a USB port to the computer or to an optional docking - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 107
power by turning off the LAN when not in use. ● Enable/disable SATA Native Mode. ● Enable/disable Dual Core CPU. ● Enable/disable Secondary Battery Fast Charge. ● Choose Bit-shift or LBA assisted HDD Translation Mode. ● Enable/disable Windows direct application launcher. ● Enable/disable HP Lockout - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 108
Weight (with optical drive, hard drive, and battery) Input power Operating voltage Operating current Temperature Operating (not writing to optical disc) Operating (writing to optical disc) Nonoperating Relative humidity Operating Nonoperating Maximum altitude (unpressurized) Operating (14.7 to 10 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 109
surfaces. The computer operates well within this range of temperatures. 14.1-inch, WXGA+ display specifications Dimensions Height Contrast ratio Brightness Pixel resolution Pitch Format Configuration Backlight Character display Total power consumption Viewing angle Metric U.S. 21.3 cm 28.5 cm - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 110
ms 13 ms Maximum 24 ms 24 ms 24 ms Logical blocks 312,560,640 234,420,480 156,280,320 Disc rotational speed 5400 rpm 5400 rpm 7200 and 5400 rpm Operating temperature 5°C to 55°C (41°F to 131°F) *1 GB = 1 billion bytes when referring to hard drive storage capacity. Actual accessible - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 111
Primary 6-cell, Li-ion battery specifications Dimensions Height Width Depth Weight Energy Voltage Amp-hour capacity Watt-hour capacity Temperature Operating Nonoperating Metric 2.0 cm 20.3 cm 5.3 cm 0.34 kg 14.4 V 2.2 Ah and 2.55 Ah 47 Wh and 55Wh 5°C to 45°C 0°C to 60°C U.S. 0.79 in 7.99 in 2. - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 112
-RW Super Multi Double-Layer Combo Drive specifications Applicable disc Center hole diameter Disc diameter Standard disc Mini disc Disc thickness Track pitch Access time Random Full stroke Audio output level Cache buffer Data transfer rate 24X CD-ROM 8X DVD-ROM 24X CD-R 16X CD-RW 8X DVD+R 4X DVD+RW - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 113
DVD/CD-RW Combo Drive specifications Applicable disc Center hole diameter Disc diameter Standard disc Mini disc Disc thickness Track pitch Access time Random Full stroke Audio output level Cache buffer Data transfer rate 24X CD-ROM 8X DVD 24X CD-R 24X CD-RW Transfer mode Startup time Stop time - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 114
DVD-ROM drive Applicable disc Center hole diameter Disc diameter Standard disc Mini disc Disc thickness Track pitch Access time Random Full stroke Audio output level Cache buffer Data transfer rate CD-R (24X) CD-RW (10X) CD-ROM (24X) DVD (8X) Multiword DMA mode 2 Startup time Stop time DVD-ROM (DVD - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 115
Hardware DMA System function DMA0 Not applicable DMA1* Not applicable DMA2* Not applicable DMA3 Not applicable DMA4 Direct memory access controller DMA5* Available for PC Card DMA6 Not assigned DMA7 Not assigned *PC Card controller can use DMA 1, 2, or 5. System DMA specifications - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 116
-/102-Key or Microsoft® Natural Keyboard IRQ2 IRQ3 IRQ4 IRQ5* IRQ6 IRQ7* IRQ8 Cascaded Intel 82801DB/DBM USB2 Enhanced Host Controller-24CD COM1 Conexant AC-Link Audio Intel 82801DB/DBM SMBus Controller-24C3 Data Fax Modem with SmartCP Diskette drive Parallel port System CMOS/real-time clock IRQ9 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 117
Unused Port A Unused Interrupt controller no. 2 Unused DMA controller no. 2 Unused Coprocessor busy clear/reset Unused Unused Secondary fixed disk controller Unused Primary fixed disk controller Unused JoyStick (decoded in ESS1688) Unused Entertainment audio System I/O address specifications 109 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 118
Reserved serial port Unused Infrared port Unused Unused Secondary diskette drive controller Parallel port (LPT1/default) Unused FM synthesizer-OPL3 Unused VGA Reserved (parallel port/no EPP support) VGA PC Card controller in CPU Unused Internal modem "A" diskette controller Serial port (COM1/default - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 119
04800000-07FFFFFF 04800000-07FFFFFF 08000000-080FFFFF 08200000-FFFEFFFF FFFF0000-FFFFFFFF System function Base memory Video memory Video BIOS Unused System BIOS Extended memory Super extended memory Unused Video memory (direct access) Unused System BIOS System memory map specifications 111 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 120
7 Screw listing This section provides specification and reference information for the screws and screw locks used in the computer. All screws and screw locks listed in this section are available in the Screw Kit, spare part number 443906-001. 112 Chapter 7 Screw listing - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 121
Head diameter 5.0 mm Where used: (1) Two screws that secure the hard drive cover to the computer (screws are captured on the cover by C-clips captured on the cover by a C-clip) (3) One screw that secures the memory/WLAN module compartment cover to the computer (screw is captured on the cover by - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 122
Phillips PM2.5×13.0 captive screw Color Black Quantity 1 Length 13.0 mm Thread 2.5 mm Head diameter 6.0 mm Where used: One screw that secures the hard drive to the computer 114 Chapter 7 Screw listing - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 123
Phillips PM3.0×3.0 screw Color Silver Quantity 4 Length 3.0 mm Thread 3.0 mm Head diameter 5.0 mm Where used: 4 screws that secure the hard drive bracket to the hard drive Phillips PM3.0×3.0 screw 115 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 124
Phillips PM2.5×3.0 screw Color Black Quantity 6 Length 3.0 mm Thread 2.5 mm Head diameter 5.0 mm Where used: 2 screws that secure the WLAN module to the computer Where used: 2 screws that secure the WWAN module to the computer 116 Chapter 7 Screw listing - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 125
Where used: 2 screws that secure the modem module to the PC Card/audio board assembly Phillips PM2.5×3.0 screw 117 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 126
Color Black Quantity 18 Length 9.0 mm Thread 2.5 mm Head diameter 5.0 mm Where used: (1) One screw that secures the optical drive to the computer (2) Four screws that secure the display assembly to the computer Where used: 11 screws that secure the top cover to the computer 118 Chapter 7 Screw - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 127
Where used: 2 screws that secure the top cover to the computer Torx T8M2.5×9.0 screw 119 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 128
Phillips PM2.0×3.0 screw Color Black Quantity 11 Length 3.0 mm Thread 2.0 mm Head diameter 4.5 mm Where used: 2 screws that secure the optical drive bracket to the optical drive 120 Chapter 7 Screw listing - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 129
Where used: 8 screws that secure the display hinges to the display panel Where used: One screw that secures the speaker assembly to the computer Phillips PM2.0×3.0 screw 121 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 130
Black Phillips PM2.5×8.0 captive screw Color Black Quantity 3 Length 8.0 mm Thread 2.5 mm Head diameter 5.0 mm Where used: 3 screws that secure the keyboard to the computer 122 Chapter 7 Screw listing - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 131
Torx T8M2.5×17.0 screw Color Black Quantity 1 Length 17.0 mm Thread 2.5 mm Head diameter 5.0 mm Where used: One screw that secures the display assembly left hinge to the computer Torx T8M2.5×17.0 screw 123 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 132
T8M2.5×7.0 screw Color Black Quantity 3 Length 7.0 mm Thread 2.5 mm Head diameter 5.0 mm Where used: One screw that secures the display assembly right hinge to the computer Where used: 2 screws that secure the bottom edge of the display bezel to the display assembly 124 Chapter 7 Screw listing - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 133
Torx T8M2.5×6.0 screw Color Black Quantity 10 Length 6.0 mm Thread 2.5 mm Head diameter 5.0 mm Where used: 4 screws that secure the top edge of the display bezel to the display enclosure Where used: 6 screws that secure the display panel to the display enclosure Torx T8M2.5×6.0 screw 125 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 134
Hex HM5.0×9.0 screw lock Color Silver Quantity 2 Length 9.0 mm Thread 2.5 mm Head diameter 5.0 mm Where used: 2 screw locks that secure the top cover to the computer 126 Chapter 7 Screw listing - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 135
5.0 mm Thread 2.5 mm Head diameter 5.0 mm Where used: (1) Two screws that secure the speaker assembly to the base enclosure (2) Two screws that secure the Media Card Reader/USB connector board to the base enclosure Phillips PM2.5×5.0 screw 127 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 136
Where used: (1) Three screws that secure the system board and the PC Card/audio board assembly to the base enclosure (2) One screw that secures the SIM slot board to the system board (3) One screw that secures the PC Card/audio board assembly to the system board 128 Chapter 7 Screw listing - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 137
Silver Phillips PM2.5×8.0 captive screw Color Silver Quantity 1 Length 8.0 mm Thread 2.5 mm Head diameter 5.0 mm Where used: One captive screw that secures the fan to the computer Silver Phillips PM2.5×8.0 captive screw 129 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 138
Phillips PM2.5×8.0 screw Color Silver Quantity 1 Length 8.0 mm Thread 2.5 mm Head diameter 5.0 mm Where used: One screw that secures the fan to the computer 130 Chapter 7 Screw listing - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 139
Phillips PM2.0×6.0 screw Color Silver Quantity 4 Length 6.0 mm Thread 2.0 mm Heat width 4.5 mm Where used: 4 screws that secure the heat sink to the computer Phillips PM2.0×6.0 screw 131 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 140
Backup and recovery in Windows Vista Creating recovery discs After setting up the computer for the first time, be sure to create a set of recovery discs of the full factory image. The recovery discs are used to start up (boot) the computer and recover the operating system and software to factory - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 141
power. NOTE: Drivers, utilities, and applications installed by HP can be copied to a CD or to a DVD using HP Backup & Recovery Manager. Backing up specific files or folders You can back up specific files or folders to the recovery partition on the hard drive, to an optional external hard drive - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 142
you are saving the full factory image, including the Windows® operating system, software applications, and all personal files and folders. NOTE: A copy of the entire hard drive image can be stored on another hard drive, on a network drive, or on recovery discs that you create. NOTE: This process may - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 143
recovery disc into the optical drive and restart the computer. 3. Follow the on-screen instructions. Performing a recovery from the hard drive There are 2 ways to initiate a recovery from the hard drive: ● From within Windows ● From the recovery partition Backup and recovery in Windows Vista 135 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 144
the on-screen instructions. Initiating a recovery from the hard drive recovery partition To initiate a recovery from the hard drive recovery partition, follow these steps: 1. Back up all personal files. 2. Restart the computer, and then press f11 before the Windows operating system loads. 3. Click - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 145
Backup and recovery in Windows XP Creating recovery discs After setting up the computer for the first time, be sure to create a set of recovery discs of the full factory image. The recovery discs are used to start up (boot) the computer and recover the operating system and software to factory - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 146
power. NOTE: Drivers, utilities, and applications installed by HP can be copied to a CD or to a DVD using HP Backup and Recovery Manager. Backing up specific files or folders You can back up specific files or folders to the recovery partition on the hard drive, to an optional external hard drive - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 147
you are saving the full factory image, including the Windows® operating system, software applications, and all personal files and folders. NOTE: A copy of the entire hard drive image can be stored on another hard drive, on a network drive, or on recovery discs that you create. NOTE: This process may - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 148
) or at specific events, such as at system restart or when you dock to an optional docking station (select models only). To schedule backups: 1. Select Start > All Programs > HP Backup & Recovery > HP Backup Scheduler. 2. Follow the on-screen instructions. Performing a recovery NOTE: You can only - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 149
the hard drive recovery partition, follow these steps: 1. Back up all personal files. 2. Restart the computer, and then press f11 before the Windows operating system loads. 3. Click a recovery option, and then click Next. 4. Follow the on-screen instructions. Backup and recovery in Windows XP 141 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 150
9 Connector pin assignments Audio-out (headphone) Pin Signal 1 Audio out, left channel 2 Audio out, right channel 3 Ground Audio-in (microphone) Pin Signal 1 Audio signal in 2 Audio signal in 3 Ground 142 Chapter 9 Connector pin assignments - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 151
External monitor Pin Signal 1 Red analog 2 Green analog 3 Blue analog 4 Not connected 5 Ground 6 Ground analog 7 Ground analog 8 Ground analog 9 +5 VDC 10 Ground 11 Monitor detect 12 DDC 2B data 13 Horizontal sync 14 Vertical sync 15 DDC 2B clock External monitor 143 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 152
RJ-11 (modem) Pin 1 2 3 4 5 6 RJ-45 (network) Signal Unused Tip Ring Unused Unused Unused Pin Signal 1 Transmit + 2 Transmit - 3 Receive + 4 Unused 5 Unused 6 Receive - 7 Unused 8 Unused 144 Chapter 9 Connector pin assignments - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 153
S-Video-out Pin Signal 1 S-VHS color (C) signal 2 Composite video signal 3 S-VHS intensity (Y) signal 4 S-VHS color ground 5 TV-CD 6 S-VHS intensity ground 7 Composite video ground Universal Serial Bus Pin Signal 1 +5 VDC 2 Data - 3 Data + 4 Ground S-Video-out 145 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 154
set requirements The wide range input feature of the computer permits it to operate from any line voltage from 100 to 120 volts AC or from 220 to 240 volts AC. The 3-conductor power cord set included with the computer meets the requirements for use in the country or region where the equipment is - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 155
of the agency responsible for evaluation in the country or region where it will be used. 5. The flexible cord must be Type VCTF, 3-conductor, 0.75-mm² conductor size. Power cord set fittings (appliance coupler and wall plug) must bear the certification mark of the agency responsible for evaluation - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 156
of the battery in general household waste. Follow the local laws and regulations in your area for computer battery disposal. Display WARNING! disassembly instructions for the display assembly. The display assembly must be disassembled to gain access to the backlight (1) and the liquid crystal display - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 157
Perform the following steps to disassemble the display assembly: 1. Remove all screw covers (1) and screws (2) that secure the display bezel to the display assembly. 2. Lift up and out on the left and right inside edges (1) and the top and bottom inside edges (2) of the display bezel until the bezel - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 158
all screws (1) that secure the display panel assembly to the display enclosure. 6. Remove the display panel assembly (2) from the display enclosure. 7. Turn the display panel assembly upside down. 8. Remove all screws that secure the display panel frame to the display panel. 9. Use a sharp-edged - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 159
10. Remove the display panel frame (2) from the display panel. 11. Remove the screws (1) that secure the backlight cover to the display panel. 12. Lift the top edge of the backlight cover (2) and swing it outward. 13. Remove the backlight cover. 14. Turn the display panel right-side up. Display 151 - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 160
15. Remove the backlight cables (1) from the clip (2) in the display panel. 16. Turn the display panel upside down. WARNING! The backlight contains mercury. Exercise caution when removing and handling the backlight to avoid damaging this component and causing exposure to - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 161
the LCD panel. 20. Remove the screws (2) that secure the LCD panel to the display rear panel. 21. Release the LCD panel (3) from the display rear panel. 22. Release the tape (4) that secures the LCD panel to the display rear panel. 23. Remove the LCD panel. 24. Recycle the LCD panel and backlight - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 162
18 buttons info 11 PC Card eject 16 power 10 presentation 11 volume mute 11 wireless 11 C Cable Kit contents 29 spare part number 22, 29, 35 cables, service considerations 40 caps lock light 12 chipset, product description 1, 5 CMOS clearing 44 components bottom 18 buttons 10 fingerprint reader - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 163
101 display switch 11 docking connector 18 docking support, product description 4, 8 drive light 13, 15 DriveLock password 97 drives boot order 98 preventing damage 40 DVD-ROM drive location 17 precautions 40 removal 60 spare part number 27, 30, 35, 60 specifications 106 DVD/CD-RW Combo Drive - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 164
73 spare part numbers 23, 32, 35, 37, 38, 73 product description audio 2, 7 chipset 1, 5 diskette drive 2, 6 docking support 4, 8 Ethernet 3, 7 external media cards 3, 7 graphics 1, 5 hard drives 2, 6 keyboard 4, 8 memory module 1, 6 modem module 3, 7 operating system 4, 9 optical drives 2, 6 panels - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 165
removal 83 spare part number 24, 35, 83 speakers 15 specifications battery 103 computer 100 display 101 DVD-ROM drive 106 DVD/CD-RW Combo Drive 105 DVD±RW and CD-RW Combo Drive 104 hard drive 102 I/O addresses 109 interrupts 108 memory map 111 optical drive 104, 105, 106 system DMA 107 startup - Compaq 6515b | HP Compaq 6515b Notebook PC and HP Compaq 6510b Notebook PC - Mai - Page 166
HP Compaq 6515b Notebook PC and
HP Compaq 6510b Notebook PC
Maintenance and Service Guide