Dell Latitude CPx J Service Manual

Dell Latitude CPx J Manual

Get Dell Latitude CPx J PDF manuals and user guides View all Dell Latitude CPx J manuals
Add to My Manuals
Save this manual to your list of manuals

Dell Latitude CPx J manual content summary:

  • Dell Latitude CPx J | Service Manual - Page 1
  • Dell Latitude CPx J | Service Manual - Page 2
  • Dell Latitude CPx J | Service Manual - Page 3
    rights reserved. Reproduction in any manner whatsoever without the written permission of Dell Computer Corporation is strictly forbidden. Trademarks used in this text: Dell, the DELL logo, and Latitude are trademarks of Dell Computer Corporation. Other trademarks and trade names may be used in this
  • Dell Latitude CPx J | Service Manual - Page 4
    -Replaceable Parts and Assemblies 10 Hard-Disk Drive Assembly 11 Removing the Hard-Disk Drive Assembly 11 Replacing the Hard-Disk Drive Assembly 11 Modular Bay Devices (Diskette Drive, CD-ROM Drive, DVD-ROM Drive, CD-RW Drive, SuperDisk LS-120 Drive, Battery, or Travel Module) . . . . 12 Memory
  • Dell Latitude CPx J | Service Manual - Page 5
    Figure 19. Computer Orientation 1 Main Battery Removal 3 Screw Identification 3 Disconnecting a Cable from an Interface Connector 5 Exploded View-Computer 10 Hard-Disk Drive Assembly Removal 11 Modular Bay Device Removal 12 Memory Module Removal 13 Removing the Keyboard Assembly Screws 14
  • Dell Latitude CPx J | Service Manual - Page 6
    Assembly Removal 36 Module Latch Assemblies Removal 37 Left Module Latch and Spring 38 Table 1. Table 2. Screw Placement Mat With Component Screw Counts and Sizes 4 Parts and Assemblies 6 vii
  • Dell Latitude CPx J | Service Manual - Page 7
    for using this manual to service Dell computer systems is a basic knowledge of PCs and prior training in PC troubleshooting techniques. In addition to information provided in this manual, Dell provides the User's Guide for troubleshooting procedures and instructions on using the Dell Diagnostics to
  • Dell Latitude CPx J | Service Manual - Page 8
    performing the procedures in this manual, the locations or directions relative to the computer are as shown in Figure 1 unless otherwise specified. back of computer left side right side front of computer support.dell.com Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual 1
  • Dell Latitude CPx J | Service Manual - Page 9
    lines from the computer. 5. Disconnect all other external cables from the computer. 6. Remove any installed PC Cards or plastic blanks from the PC Card slot. 7. Remove any installed devices in the modular device bay. 2 Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual
  • Dell Latitude CPx J | Service Manual - Page 10
    to the graphic in the illustration to check for correct length. M2.5x20 M2.5x10 M3.0x5 M2.5x4 M2.5x4 M3.0x3 M2.0x3 support.dell.com Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual 3
  • Dell Latitude CPx J | Service Manual - Page 11
    to lay out and keep track of the component screws. Hard-Disk Drive Assembly: M3.0 x 5 (1 each) Keyboard Assembly: M2.5 x 10 (7 each) Display Assembly: system) Thermal Cooling Assembly and Exhaust Fan: M2.5 x 4 (2 each) 4 Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual
  • Dell Latitude CPx J | Service Manual - Page 12
    computer's interface connectors are zero insertion force (ZIF) connectors. These connectors are not removable, but they must be released to disconnect the cable from them (see Figure 4). movable part closed. support.dell.com Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual 5
  • Dell Latitude CPx J | Service Manual - Page 13
    MOD, HD, xxxxGB, I, F2, yyMM, zzz* CUS, HD xxxxGB, I, yyMM, zzz* Hard-disk drive interface board PWA, INTERCON, HD * Substitute the drive capacity for xxxxGB, the drive height for yyMM, and zzz for the manufacturer's name. 6 Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual
  • Dell Latitude CPx J | Service Manual - Page 14
    , ZPS 14.1-inch flex cable ASSY, CBL, FLX, TFT 12.1-inch flex cable ASSY, CBL, FLX, W/EXTN,12.1 14 14 16 16 14 16, 17 support.dell.com Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual 7
  • Dell Latitude CPx J | Service Manual - Page 15
    module, 64-MB CUS, 64MB, DIMM, SDRAM Customer kit, memory module, 128-MB CUS, 128MB, DIMM, SDRAM Customer kit, memory module, 192-MB CUS, 192MB, DIMM, SDRAM Customer kit, memory module, 256-MB CUS, 256MB, DIMM, SDRAM 8 Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual
  • Dell Latitude CPx J | Service Manual - Page 16
    shield ASSY, SHLD, EMI, PRC, MET 12 Service Kit, latch, slider, Button Foot, Rubber, Black (4 each) Foot, Rubber, Strike Zone, Black LTCH, BTN, Module Foot, Rbr, Blk Foot, Rbr, Strike Zone, Blk support.dell.com Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual 9
  • Dell Latitude CPx J | Service Manual - Page 17
    apply to your system) system board main battery case plug for modem bottom case assembly modular bay device The following subsections provide instructions for removing and replacing field-replaceable parts and assemblies. 10 Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual
  • Dell Latitude CPx J | Service Manual - Page 18
    Push the drive assembly into the opening on the left side of the computer. 2. Slide the drive door down until it aligns with the cover. 3. Turn the computer over and replace the 5-mm screw on the drive door. support.dell.com Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual 11
  • Dell Latitude CPx J | Service Manual - Page 19
    ). 2. Close the display, and turn the computer upside down on a flat work surface. 3. Release the memory module cover. Insert a flat-blade screwdriver under the indentation in the bottom case assembly and lift the cover. 12 Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual
  • Dell Latitude CPx J | Service Manual - Page 20
    in the socket. Memory modules are keyed, or designed to fit into their sockets, in only one direction. The slots on the system board are notched so that the memory module can be firmly seated only one way. support.dell.com Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual 13
  • Dell Latitude CPx J | Service Manual - Page 21
    reinstall it. 4. Replace the memory module cover. 1. Remove the main battery and secondary battery (if present). 2. Close the display assembly, and turn the computer upside down on a flat work surface. 10-mm screws (7) M2.5x10 14 Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual
  • Dell Latitude CPx J | Service Manual - Page 22
    blank key palmrest 6. Lift the keyboard out of the palmrest. 7. Rotate the keyboard over the left edge of the computer (see Figure 11). 8. Rest the key face of the keyboard on the left side of the computer. support.dell.com Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual 15
  • Dell Latitude CPx J | Service Manual - Page 23
    stick ZIF interface connector. 3. Connect the keyboard cable to the connector on the system board. Ensure that the contact side of this cable is face down when you insert the cable into the keyboard ZIF interface connector. 16 Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual
  • Dell Latitude CPx J | Service Manual - Page 24
    palmrest. 7. Carefully turn the computer over and reinstall the seven 10-mm screws. Start by installing the outermost screws on the left and right sides of the computer and then work inward to the center. support.dell.com Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual 17
  • Dell Latitude CPx J | Service Manual - Page 25
    assembly arm M2.5x4 M2.0x3 1. Remove the main battery and secondary battery (if present). 2. Remove the keyboard assembly. 3. Remove the two 3-mm screws on the securing the microprocessor shield to the microprocessor module. 18 Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual
  • Dell Latitude CPx J | Service Manual - Page 26
    of the module aligned with white marks on the front and back edge of the processor board (see Figure 12). 1. Align the microprocessor connector on the left side of the module and shield (see Figure 12). support.dell.com Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual 19
  • Dell Latitude CPx J | Service Manual - Page 27
    main battery and secondary battery (if present). 2. Remove the keyboard. 3. Close the display and remove the three 4-mm screws, labeled with a " circle D," from the back of the computer (see LCD panel as a complete assembly. 20 Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual
  • Dell Latitude CPx J | Service Manual - Page 28
    the display assembly. 2. Remove the four 4-mm screws located at the top of the bezel on the front of the display assembly (see Figure 14). support.dell.com Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual 21
  • Dell Latitude CPx J | Service Manual - Page 29
    slightly from the display assembly, allowing just enough space for the flex cable to pass through the opening. 7. Slide the cable through the opening. 22 Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual
  • Dell Latitude CPx J | Service Manual - Page 30
    the display-assembly hinge cover. 8. Reinstall the 4-mm screw that secures the metal cable clip to the left hinge of the display-assembly top cover. support.dell.com Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual 23
  • Dell Latitude CPx J | Service Manual - Page 31
    the connector. If you have trouble, check to make sure the LCD flex cable is aligned correctly and try again. 3. Lay the LCD panel in the top cover. 4. Reinstall the six 3-mm screws securing the LCD panel to the top cover. 24 Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual
  • Dell Latitude CPx J | Service Manual - Page 32
    and carefully disconnect the flex cable from the connector on the left edge of the LCD panel. 4. Remove the LCD panel from the top cover. support.dell.com Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual 25
  • Dell Latitude CPx J | Service Manual - Page 33
    left hinge of the display-assembly top cover. 6. Find the manufacturer's name on the back of the LCD panel that is to be installed. 26 Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual
  • Dell Latitude CPx J | Service Manual - Page 34
    jumpers are used. If you are installing a Torisan LCD panel, the bottom jumper is used. See the sticker on the inverter shield for more information. support.dell.com Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual 27
  • Dell Latitude CPx J | Service Manual - Page 35
    connect to the LCD panel (see Figure 17). Do not force the LCD flex cable into the connector. If you have trouble, check to make sure the LCD flex cable is folded correctly and try again. 6. Lay the LCD panel in the top cover. 28 Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual
  • Dell Latitude CPx J | Service Manual - Page 36
    5-mm screws to secure the LCD panel to the top cover. 1. Remove the main battery and secondary battery (if present). 2. Remove the device from the modular bay (if present). 3. Remove 14 and Figure 16). support.dell.com Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual 29
  • Dell Latitude CPx J | Service Manual - Page 37
    pad and the palmrest. 20-mm screws (5) M2.5x20 1. Remove the main battery and secondary battery (if present). 2. Remove the device from the modular bay (if present). 3. Remove the keyboard. 4. Remove the display assembly. 30 Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual
  • Dell Latitude CPx J | Service Manual - Page 38
    the palmrest to the computer. These screws, labeled with a " circle P," are located underneath the front edge of the computer (see Figure 19). 7. Turn the computer right-side up on assembly (see Figure 20). support.dell.com Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual 31
  • Dell Latitude CPx J | Service Manual - Page 39
    on the palmrest bracket. Then position the reserve battery on the palmrest bracket to minimize slack in the cable. Carefully reposition the reserve battery EMI spring clip before securing the two 4-mm palmrest bracket screws. 32 Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual
  • Dell Latitude CPx J | Service Manual - Page 40
    can be removed (see Figure 21). 1. Remove the main battery and secondary battery (if present). 2. Remove the keyboard assembly. 3. Remove the display assembly. 4. Remove the screw and washer (see Figure 21). support.dell.com Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual 33
  • Dell Latitude CPx J | Service Manual - Page 41
    4-mm screw with captive washer on the far left side of the computer between the hard-disk drive assembly and the PC Card slot. Locate and remove the 4-mm screw with captive washer on the the captive washers (see Figure 22). 34 Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual
  • Dell Latitude CPx J | Service Manual - Page 42
    computer. Follow the instructions on the display screen. NOTE: After replacing the system board assembly, be sure to enter the system's service tag number into the BIOS of the replacement system board assembly. support.dell.com Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual
  • Dell Latitude CPx J | Service Manual - Page 43
    -fan power cable from the connector on the system board. 10. Remove the two 4-mm screws securing the thermal cooling assembly and exhaust fan, and then remove the thermal cooling assembly and exhaust fan (see Figure 23). 36 Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual
  • Dell Latitude CPx J | Service Manual - Page 44
    1. Remove the main battery and secondary battery (if present). 2. Remove the device from the modular bay. 3. Remove the keyboard assembly. 4. Remove the display assembly. 5. Remove the palmrest assembly. support.dell.com Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual 37
  • Dell Latitude CPx J | Service Manual - Page 45
    newly installed latch moves smoothly and freely when pushed and released. 9. Repeat steps 6 through 8 for the latch on the right side. bumps (2) wear ribs (2) 38 Dell Latitude CPt V/CPt S Series and CPx H/CPx J Series Service Manual
  • Dell Latitude CPx J | Service Manual - Page 46
    , 12 battery (reserve) removal, 32 CD-ROM drive removal, 12 computer exploded view, 10 working inside, 2 diskette drive removal, 12 display assembly bezel, removal, 21 removal, 20 display assembly latch removal, 29 display panel, 12.1-inch LCD removal, 25 replacement, 28 field-replaceable parts and
  • Dell Latitude CPx J | Service Manual - Page 47
    , 3 sockets memory module, 13 SuperDisk LS-120 drive removal, 12 system board assembly removal, 18 thermal cooling assembly removal, 36 tools, 2 travel module removal, 12 ZIF connectors, 5 palmrest assembly removal, 30 2 Dell Latitude CPt V/CPt S Series and CPx H/Cpx J Series Service Manual
  • Dell Latitude CPx J | Service Manual - Page 48
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
ZZZ±GHOO±²RP
±
'HOO±²/DWLWXGH±²&3W²9³&3W²6²6HULHV²
DQG²²&3[²+³&3[²-²6HULHV
6(59,&(³0$18$/