Dell Unity XT 680 EMC WEEE Disassembly Instructions TRPE
Dell Unity XT 680 Manual
 |
View all Dell Unity XT 680 manuals
Add to My Manuals
Save this manual to your list of manuals |
Dell Unity XT 680 manual content summary:
- Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 1
WEEE DISASSEMBLY INSTRUCTIONS for the TRPE Storage Processor Enclosure Abstract This document provides Electrical and Electronic Equipment (WEEE) directive. The document does not replace disposal instructions in EMC contracts, or those included in EMC Product and Residuals Disposal Guidelines. April - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 2
. For the most up-to-date listing of EMC product names, see EMC Corporation Trademarks on EMC.com. Part Number: 300-015-310 WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 2 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 3
Table of Contents 1.0 Document Purpose...4 2.0 Important Notice ...4 3.0 How to Use these Instructions 4 4.0 Related Documentation ...4 5.0 Brand Owner Identification ...4 6.0 Acronyms ...5 7.0 Product Identification...7 8.0 Product Photos ...8 9.0 Locating Main Assemblies with Reportable Materials - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 4
Review 14.0 Disassembling the TRPE Storage Processor Enclosure for removal procedures. 4.0 Related Documentation EMC provides separate WEEE disassembly instructions per product platform. Contact the EMC WEEE administrator at [email protected] to request additional documentation as required. 5.0 Brand - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 5
Polyethylene Mercury Interconnect Module Link Control Card Low-Density Polyethylene Lead Polybrominated Biphenyls Polybrominated Diphenyl Ethers Polycarbonate Printed Circuit Board Polychlorinated Terphenyl Palladium WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 5 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 6
Polyvinyl Chloride Restriction of Hazardous Substances Serial Attached SCSI Storage Processor Storage Processor Enclosure Solid State Disk Volt Waste Electrical and Electronic Equipment WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 6 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 7
TRPE 2U, Storage Processor Enclosure (SPE) 100-562-440 Note: The part number cited denotes the base chassis (includes midplane). Each platform supports many different EMC products. Contact your EMC Sales Representative for productspecific part numbers. 8.89 cm (H) x 48.26 cm (W) x 60.96 cm (D) 20 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 8
8.0 Product Photos Figure 1. Front view Figure 2. Rear view WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 8 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 9
4 4 3 3 Figure 4 TRPE rear components Table 3 Decoder and Disassembly Sequence Item Component Item Component 1 Four Power Cooling/Modules 3 Management Modules 2 Two CPU Modules 4 I/O Modules WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 9 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 10
Item Component 5 DIMMs Compartment Cover (ABS plastic) 7 Two Air Flappers (ABS plastic) 6 Optional Solid State Disk (SSD) (aluminum) 8 Two Plastic Latches (Plastic, other) WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 10 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 11
DIMMs (PCB Etch) 13 Five Heat Sinks (aluminum) 11 Real Time Clock (RTC ) Battery 14 Insulator Plate on bottom of SP (non-ferrous) WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 11 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 12
, 110-048-xxx Table 6 Decoder and Disassembly Sequence Item Component Item Component 15 DIMMs (PCB Etch) 17 Real Time Clock (RTC ) Battery Note: No DIMMs installed in Figure 8 16 Heat Sinks (aluminum) 18 PCB WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 12 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 13
Two Heat Fins (non-ferrous) 23 Fan (inside module) 20 Five Coils, one of five (copper) 22 PCB 24 Fan Wiring (inside module) WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 13 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 14
and Disassembly Sequence Item Component 25 Capacitors 26 Coils (copper) Item Component 27 PCB 28 Fan and attached wiring (not shown, inside module) WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 14 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 15
9 Decoder and Disassembly Sequence Item Component 29 Wiring in Power Terminals (not visible until the I/O module cage is removed, see Figure 28) 30 Chassis (ferrous, sheet metal) 31 Midplane PCB WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 15 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 16
See to Table 11 identify materials. I/O Modules Management Modules Yes See Follow the instructions in Related Documentation to obtain the appropriate WEEE disassembly instructions for EMC I/O modules. Yes Follow the instructions in Related Documentation to obtain the appropriate WEEE disassembly - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 17
Component SSD Photo Disassembly Required? No See 14.4 Removing the Optional SSD WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 17 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 18
11.0 Identifying PCBs for Recycling DIMMs SP, Part Number: 110-113-xxx SP, Part Number: 110-048-xxx WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 18 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 19
AC Power Supply PCB Midplane PCB WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 19 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 20
their casing where appropriate) of a surface greater than 100 cm2 and all those back-lighted with gas discharge lamps Absent Absent Absent Absent WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 20 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 21
, such as oils and acids in particular Components containing refractory ceramic fibers Photo-conducting drums containing cadmium or selenium Absent Absent Absent Absent WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 21 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 22
Cover 7 SP Air Flappers Power/Cooling Module (AC type and DC type) 23,28 Fan Assembly Absent or not at an appreciable level WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 22 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 23
appreciable level Absent or not at an appreciable level Absent or not at an appreciable level SP Latches All PCBs (Fiberglass) Various Components WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 23 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 24
Compartment Cover 32 g >PC+ABS-FR(40)< Fan Assembly in Power/Cooling Module (both AC and DC versions) 268 g >PC+ABS-FR(40)< WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 24 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 25
with batteries are processed in a shredder. - Replace only with the battery type recommended by the equipment manufacturer. - Discard used batteries according to manufacturer's instructions. - Do not attempt to reuse or install batteries in any other system, for any other purpose. WEEE Disassembly - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 26
.0 Disassembling the TRPE Storage Processor Enclosure 14.1 Removing I/O Modules or Management Modules Follow the instructions in Related Documentation to obtain the appropriate WEEE disassembly instructions for EMC I/O modules. 14.2 Removing a Power/Cooling Module 1. Locate and press the orange tab - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 27
from the assembly, and disconnect or cut the wiring. Heat Fin Heat Fin Figure 17. Removing materials on the power/cooling module PCB WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 27 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 28
away from each other to fully release the CPU module. 3. Pull the CPU module from the chassis. Figure 18. Releasing the CPU module WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 28 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 29
the plastic latches, and remove. DIMMs Cover Air Flappers Figure 19. Removing the plastic DIMMs compartment cover, Two air flappers, and plastic latches WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 29 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 30
in a shredder. - Replace only with the battery type recommended by the equipment manufacturer. - Discard used batteries according to manufacturer's instructions. - Do not attempt to reuse or install batteries in any other system, for any other purpose. 1. Flip over the CPU module and detach the non - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 31
. - Replace only with the battery type recommended by the equipment manufacturer. - Discard used batteries according to manufacturer's instructions. - Do not attempt to reuse or install batteries in any other system, for any other purpose. 1. Remove the four Phillips head screws that attach the PCB - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 32
, and lift up and remove SSD filler panel (or SSD drive). Figure 23. Optional SSD (aluminum) 4. Remove SSD Filler Panel (or SSD drive). WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 32 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 33
24. Chassis top cover 3. Slide back and lift off the chassis top cover. Metal Center Wall Figure 25. Remove the chassis top cover WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 33 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 34
screws that attach the I/O module cage to the chassis. 6. Slide the I/O module cage back and lift out. Figure 27. Removing the I/O module cage WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 34 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 35
that attach the midplane PCB to the drive cage. 9. Remove the midplane PCB. Figure 29. Locating the six screws on the midplane PCB WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 35 - Dell Unity XT 680 | EMC WEEE Disassembly Instructions TRPE - Page 36
flip chip packages RoHS Exemption 24: Lead in solders for the soldering to machined through hole discoidal and planar array ceramic multilayer capacitors WEEE Disassembly Instructions for the TRPE Storage Processor Enclosure 36
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
 |
 |
Abstract
This document provides clear guidance for end-of-life recyclers on how to
identify and disassemble reportable materials in compliance with the Waste
Electrical and Electronic Equipment (WEEE) directive. The document does
not replace disposal instructions in EMC contracts, or those included in EMC
Product and Residuals Disposal Guidelines.
April 2013
WEEE DISASSEMBLY INSTRUCTIONS
for the TRPE Storage Processor Enclosure