Hayward 1 Hp Power-Flo Lx Pump W/Side Expert Line PowerFlo-and-EP-Pump-Series-
Hayward 1 Hp Power-Flo Lx Pump W/Side Expert Line Manual
View all Hayward 1 Hp Power-Flo Lx Pump W/Side Expert Line manuals
Add to My Manuals
Save this manual to your list of manuals |
Hayward 1 Hp Power-Flo Lx Pump W/Side Expert Line manual content summary:
- Hayward 1 Hp Power-Flo Lx Pump W/Side Expert Line | PowerFlo-and-EP-Pump-Series- - Page 1
II™ / EP Pump Series Owner's Manual Contents Product Warnings 2 Installation 4 Start-Up & Operation 6 Shaft Seal Replacement..........7 Troubleshooting 8 Replacement Parts 10 Warranty 11 Registration 12 INSTALLATION, OPERATION, & PARTS IMPORTANT SAFETY INSTRUCTIONS Basic safety precautions - Hayward 1 Hp Power-Flo Lx Pump W/Side Expert Line | PowerFlo-and-EP-Pump-Series- - Page 2
clamp due to pressure in the system, which could cause property damage, severe personal injury, or death. Before servicing pool and spa water circulation system, all system and pump controls must be in off position and filter manual air relief valve must be in open position. Before starting system - Hayward 1 Hp Power-Flo Lx Pump W/Side Expert Line | PowerFlo-and-EP-Pump-Series- - Page 3
Failure to follow safety and operation instructions could result in violent separation of pump and/or filter components. Strainer cover must be properly secured to pump housing with strainer cover lock ring. Before servicing pool and spa circulation system, filters manual air relief valve must be in - Hayward 1 Hp Power-Flo Lx Pump W/Side Expert Line | PowerFlo-and-EP-Pump-Series- - Page 4
. Place supports near pump. To avoid strain left by a gap at last connection, start all piping at pump and run pipe AWAY from pump. NEVER use suction pipe SMALLER than pump suction connections. Suction pipe inlet must be lower than pump inlet port. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS USE - Hayward 1 Hp Power-Flo Lx Pump W/Side Expert Line | PowerFlo-and-EP-Pump-Series- - Page 5
to ground and disconnect power before it becomes dangerous to pool users. For size of GFCI required and test procedures for GFCI, see manufacturer's instructions. In case of a power outage, check GFCI for tripping, which will prevent normal pump operation. Reset if necessary. NOTE: If you do not use - Hayward 1 Hp Power-Flo Lx Pump W/Side Expert Line | PowerFlo-and-EP-Pump-Series- - Page 6
inlets to the pool. 2. Remove drain plug from bottom of strainer body. 3. Disconnect pump from base. 4. Once the pump is removed of water, re-install the strainer lid and strainer plug. 5. Store pump in a dry enclosure. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS USE ONLY HAYWARD GENUINE REPLACEMENT - Hayward 1 Hp Power-Flo Lx Pump W/Side Expert Line | PowerFlo-and-EP-Pump-Series- - Page 7
. Contact your local authorized Hayward Dealer or service center if you have any questions. C. The National Electrical Code requires either a three (3) foot maximum twist-lock cord set with a GFCI protected receptacle or hard wire (conduit) connection for swimming pool pump installation. Do not use - Hayward 1 Hp Power-Flo Lx Pump W/Side Expert Line | PowerFlo-and-EP-Pump-Series- - Page 8
's instructions; Cartridge filters - clean or replace cartridge. 3. Air leak in suction (bubbles issuing from return fittings). Re-tighten using Teflon tape. 4. Plugged or restricted impeller or impeller sheared off. Replace including new seal assembly. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS - Hayward 1 Hp Power-Flo Lx Pump W/Side Expert Line | PowerFlo-and-EP-Pump-Series- - Page 9
to wear or damage. See "Shaft Seal Change Instructions" in this manual. DATE OF INSTALLATION INITIAL PRESSURE GAUGE READING (CLEAN FILTER PUMP MODEL HORSEPOWER FILTER MODEL SERIAL NUMBER USE ONLY HAYWARD GENUINE REPLACEMENT PARTS USE ONLY HAYWARD GENUINE REPLACEMENT PARTS 9 9 - Hayward 1 Hp Power-Flo Lx Pump W/Side Expert Line | PowerFlo-and-EP-Pump-Series- - Page 10
HP ---- ---- Motor (for SP1580) - 1 HP ---- SPX1510Z1XE Motor (for SP1580X15) - 1-1/2 HP ---- SPX1515Z1E Motor (for SW1585X20) - 2 HP ---- SPX1520Z1ESC (i.e. SPX1510Z2E) *All Twist Lock versions for each pump have "TL" at end of part number (i.e. SP1580TL) Model No. SP1750, 1775, 1780 - Hayward 1 Hp Power-Flo Lx Pump W/Side Expert Line | PowerFlo-and-EP-Pump-Series- - Page 11
any Acts of God. Parts that fail or become Hayward Authorized Service Center please visit us at www.haywardpool.com. Hayward shall not be responsible for cartage, removal, repair or installation labor or any other such costs incurred in obtaining warranty replacements or repair. The Hayward Pool - Hayward 1 Hp Power-Flo Lx Pump W/Side Expert Line | PowerFlo-and-EP-Pump-Series- - Page 12
10 days of purchase/installation or register online. PowerFlo LX™ / PowerFlo II™ / EP Pump Series Warranty Card Registration Register online at www.hayward.com Please Print Clearly: Years Pool has been in service First Name Last Name 1 year 1-3 4-5 6-10 11-15 >15 Street Address Purchased
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
1
PowerFlo LX
™
/ PowerFlo II
™
/ EP
Pump Series
Owner’s Manual
INSTALLATION, OPERATION, & PARTS
IMPORTANT SAFETY INSTRUCTIONS
Hayward Pool Products
620 Division Street, Elizabeth, NJ 07207
Phone: (908) 355-7995
www.haywardnet.com
Contents
Product Warnings……….………2
Installation……….……………..…4
Start-Up & Operation…….…….6
Shaft Seal Replacement……….7
Troubleshooting…………………..8
Replacement Parts………..….…10
Warranty …………………………..…11
Registration………………………….12
ISPFSERIES
Rev G
Basic safety precautions should always be followed, including the following: Failure to follow instructions can
cause severe injury and/or death.
This is the safety-alert symbol. When you see this symbol on your equipment or in this manual, look for
one of the following signal words and be alert to the potential for personal injury.
W
A
R
N
I
N
G
warns about hazards that c
o
u
l
d
cause serious personal injury, death or major property
damage and if ignored presents a potential hazard.
C
A
U
T
I
O
N
warns about hazards that w
i
l
l
or c
a
n
cause minor or moderate personal injury and/or property
damage and if ignored presents a potential hazard.
It can also make consumers aware of actions that are
unpredictable and unsafe.
The N
O
T
I
C
E
label indicates special instructions that are important but not related to hazards.