Hayward Perflex Extended-Cycle Models: EC65A EC75A

Hayward Perflex Extended-Cycle Manual

Get Hayward Perflex Extended-Cycle PDF manuals and user guides View all Hayward Perflex Extended-Cycle manuals
Add to My Manuals
Save this manual to your list of manuals

Hayward Perflex Extended-Cycle manual content summary:

  • Hayward Perflex Extended-Cycle | Models: EC65A EC75A - Page 1
    OWNER'S MANUAL INSTALLATION, OPERATION & PARTS IS65ING Rev. A MODELS: EC65A, EC75A PERFLEX® SERIES Extended Cycle Basic FILTER Units Basic safety precautions should always be followed, including the following: Failure to follow instructions can cause severe injury and/or death. This is the safety-
  • Hayward Perflex Extended-Cycle | Models: EC65A EC75A - Page 2
    Page 2 of 12 THIS PAGE IS INTENDED TO BE BLANK IS65ING Rev A USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN www.haywardpool.com
  • Hayward Perflex Extended-Cycle | Models: EC65A EC75A - Page 3
    Failure to follow safety and operation instructions could result in violent separation of pump and/or filter components. Strainer cover must be properly secured to pump housing with strainer cover lock ring. Before servicing pool and spa circulation system, filters manual air relief valve must be in
  • Hayward Perflex Extended-Cycle | Models: EC65A EC75A - Page 4
    pool water line, a Super Pump®, Super II™ pump, Max-Flo or TriStar™ pump is required and can be raised two feet above 10. Check for joint leaks before operating system. 11. Refer to pump instruction booklet for pump information. the water line. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona
  • Hayward Perflex Extended-Cycle | Models: EC65A EC75A - Page 5
    , regenerate the filter. REGENERATION (Extending the Cycle) Stop the pump. Move the bump handle down slowly, then up briskly. Repeat 3 times. Restart the pump and filtration will resume at near the original flow and pressure. After each regeneration, and until the filter is cleaned, there may
  • Hayward Perflex Extended-Cycle | Models: EC65A EC75A - Page 6
    Union Nut 1 36 ECX1263 Platform Base 1 37 ECX1275 Pump Mounting Screw 2 38 EC1161 Washer 2 ECX12515 Flex-Tube Nest (EC65) ECX125175 Flex Tube Nest (EC75) 1 (Includes. 13thru 22) USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN www.haywardpool.com
  • Hayward Perflex Extended-Cycle | Models: EC65A EC75A - Page 7
    Hayward-Perflex dealer or service center. No returns may be made directly to the factory without the expressed written authorization of Hayward Pool it may be necessary to regenerate the Perflex filter as frequently as every 2 to 3 hours HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons,
  • Hayward Perflex Extended-Cycle | Models: EC65A EC75A - Page 8
    with pool dirt, algae, 1. Bump-Drain-Recharge. etc. 2. Slow down stroke - brisk upstroke. 2. Bumping incorrectly. Repeat 6 times. 3. Check and straighten or replace. Short cycles. 3. Bump handle bent. 4. Check GPM/LPM output. Regulate 4. Pump output exceeds design flow rate of filter. pump
  • Hayward Perflex Extended-Cycle | Models: EC65A EC75A - Page 9
    properly 3. Bump more frequently. drained. 3. Filter runs too long between bumping. D.E. leaking Filter check valve worn or stuck open. Clean and/or replace. back to pool via skimmer or main drain. Normal if pool contains: 1. Bump-Drain-Recharge more often. Very short cycles when 1. Very
  • Hayward Perflex Extended-Cycle | Models: EC65A EC75A - Page 10
    . To obtain warranty replacements or repair, defective components or parts should be returned, transportation paid, to the place of purchase, or to the nearest authorized Hayward service center. For further Hayward dealer or service center information, contact Hayward customer service department. No
  • Hayward Perflex Extended-Cycle | Models: EC65A EC75A - Page 11
    and winterizing. Perflex - the video. It keeps maintenance at a minimum and pool equipment at a maximum! Just order "Operation and Maintenance" Video Part Number EC-OM-Video-90 and include your check or money order for $9.95* (+ $2.50 for shipping and handling) and mail to: Hayward Pool Products
  • Hayward Perflex Extended-Cycle | Models: EC65A EC75A - Page 12
    Page 12 of 12 THIS PAGE IS INTENDED TO BE BLANK IS65ING Rev A USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN www.haywardpool.com
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Pomona, CA
Clemmons, NC
Nashville, TN
www.haywardpool.com
OWNER’S MANUAL
INSTALLATION, OPERATION & PARTS
MODELS: EC65A, EC75A
PERFLEX
®
SERIES Extended Cycle Basic FILTER Units
SAVE THIS INSTRUCTION MANUAL
IS65ING
Rev. A
Basic safety precautions should always be followed, including the following: Failure to follow instructions can cause severe
injury and/or death.
This is the safety-alert symbol. When you see this symbol on your equipment or in this manual, look for one of the
following signal words and be alert to the potential for personal injury.
WARNING
warns about hazards that
could
cause serious personal injury, death or major property damage and if
ignored presents a potential hazard.
CAUTION
warns about hazards that
will
or
can
cause minor or moderate personal injury and/or property damage
and if ignored presents a potential hazard.
It can also make consumers aware of actions that are unpredictable and unsafe.
The
NOTICE
label indicates special instructions that are important but not related to hazards.