Hayward TriStar All TriStar models

Hayward TriStar Manual

Get Hayward TriStar PDF manuals and user guides View all Hayward TriStar manuals
Add to My Manuals
Save this manual to your list of manuals

Hayward TriStar manual content summary:

  • Hayward TriStar | All TriStar models - Page 1
    TriStar is a high performance, high efficiency pump. When replacing most existing pumps, you can use a TriStar pump with a lower horsepower rating than the existing pump. Required: 2" plumbing minimum Recommended: 2 ½" plumbing or larger TriStar Model No. Full Rated --SP3207EE SP3210EE SP3215EE
  • Hayward TriStar | All TriStar models - Page 2
    NEC). Use of non-Hayward replacement parts voids warranty. ATTENTION INSTALLER - THIS MANUAL CONTAINS IMPORTANT INFORMATION ABOUT THE INSTALLATION, OPERATION, AND SAFE USE OF THIS PUMP THAT MUST BE FURNISHED TO THE END USER OF THIS PRODUCT. FAILURE TO READ AND FOLLOW ALL INSTRUCTIONS COULD RESULT IN
  • Hayward TriStar | All TriStar models - Page 3
    areas. - The maximum system flow rate shall not exceed the values shown in the "Pipe Sizing Chart" found at the bottom of page 5 of this manual. - Never use pool or spa if any suction outlet component is damaged, broken, cracked, missing, or not securely attached. - Replace damaged, broken, cracked
  • Hayward TriStar | All TriStar models - Page 4
    install according to defined instructions will void warranty. Product Benefits The new TriStar Pump's advanced fluid dynamic design optimizes the three essential pump elements to deliver superior flow, energy efficiency, and quietness. Plus, the heavy-duty pump and motor construction operates cooler
  • Hayward TriStar | All TriStar models - Page 5
    . Allow adequate access for servicing pump and piping. Pipe Sizing Chart Pipe Size [mm] 1" [32] MAXIMUM RECOMMENDED SYSTEM FLOW RATE BY PIPE SIZE Flow Rate Suction Pipe Pipe Size Flow Rate Suction Pipe Pipe Size Flow Rate GPM [LPM] Length * [mm] GPM [LPM] Length * [mm] GPM [LPM] 20 [75
  • Hayward TriStar | All TriStar models - Page 6
    canopy or access place; use size and type wire required by code. Connect motor ground terminal to electrical service ground. Bond motor to pool structure. Bonding will connect all metal parts within and around the pool with a continuous wire. Bonding reduces the risk of a current passing between
  • Hayward TriStar | All TriStar models - Page 7
    Three-Phase (3Φ) Pump - motor starter required ** Three-Phase (3Φ) Pump - variable-speed applications only (Not available as a stand-alone pump. May only be used with SP3220VSC.) Max Rate Pumps 50 Hz Pumps Start-Up & Operation Prior to Start-Up NOTE - If it is necessary to perform a pressure test
  • Hayward TriStar | All TriStar models - Page 8
    of suction lift and horizontal length of suction pipe. If pump does NOT prime within five minutes, stop motor and determine cause. Be sure all suction and discharge valves are open when pump is running. See Troubleshooting Guide. WWW.HAYWARDPOOL.COM USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
  • Hayward TriStar | All TriStar models - Page 9
    or death. 1. Drain water level below all inlets to the pool. 2. Remove drain plugs and strainer cover from strainer housing. (See Parts Diagram on page 11 of this manual for pump component locations.) 3. Disconnect pump from mounting pad, wiring (after power has been turned OFF), and piping. 4. Once
  • Hayward TriStar | All TriStar models - Page 10
    to be reassembled. Inspect gaskets & replace if necessary. Seal Installation (See Parts Diagram on page 11 of this manual for pump component locations.) 8. Clean and lightly lubricate the motor shaft and seal recesses in the seal plate (item #15) with a dilute solution of nongranulated liquid-type
  • Hayward TriStar | All TriStar models - Page 11
    TriStar™ Pump Series Replacement Parts Parts Diagram Page 11 of 15 Detail of motor canopy with screws. Parts Listing Ref. No. Part No. 1 SPX3200UNKIT 2 SPX3200UG 3 SPX3200A 4 SPX3200DLS SPX3200DLSB 5 SPX3200S 6 SPX3200M 7 SPX3200Z8 8 SPX4000Z1 9 SPX3200B3 10 SPX3200Z1 11 SPX3021R
  • Hayward TriStar | All TriStar models - Page 12
    Kit Housing Bolt Motor Bolt Drain Plug with O-Ring Bracket, Motor Support, TriStar Base, Short Riser, TriStar Base, Tall Riser, TriStar Ctn. Qty. 10 10 10 10 10 10 10 10 10 10 10 1 1 10 1 10 1 1 1 Pump SKU Detail Full Rate Pumps Model P/N SP3205EE SP3207EE SP3210EE SP3215EE SP3220EE SP3230EE
  • Hayward TriStar | All TriStar models - Page 13
    in suction. Check impeller for debris. iv. Remove and replace shaft seal only if it is leaking. Low Flow - Generally, Check For: 1. Clogged or restricted strainer or suction line. Solution: Contact a qualified repair professional. WWW.HAYWARDPOOL.COM USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
  • Hayward TriStar | All TriStar models - Page 14
    whine. Solution: All seal leaks should be replaced at once. © Hayward Pool Products, 2005 All rights reserved. PRODUCT REGISTRATION (Retain For Your Records) DATE OF INSTALLATION INITIAL PRESSURE GAUGE READING (CLEAN FILTER PUMP MODEL HORSEPOWER FILTER MODEL SERIAL NUMBER WWW.HAYWARDPOOL
  • Hayward TriStar | All TriStar models - Page 15
    City State_________ Zip Please send me more information on these other products from Hayward: □ Pump □ Filter □ Automatic Pool Cleaner □ Light □ Chlorinator □ Skimmer □ Heater □ Heat Pump □ Salt/Chlorine Generator □ Controls WWW.HAYWARDPOOL.COM USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
P/N: IS3200
Rev. F
__________________________________________________________________________________________
OWNER’S MANUAL
INSTALLATION, OPERATION, & PARTS
*50HZ Models are not UL Listed.
TriStar
®
Pump Series
The Hayward TriStar Pump is specifically engineered for the demanding requirements of today’s in-ground swimming pool/spa that is
equipped with large capacity filters, heaters, and pool cleaning equipment.
The TriStar is a self-priming pump that includes an
improved seal and impeller design that will provide many years of efficient, dependable, corrosion-free service.
The advanced design
provides superior performance while reducing maintenance requirements.
NOTE -
To prevent potential injury and to avoid
unnecessary service calls, read this manual carefully and completely.
TriStar Pump Replacement Guide
TriStar
TriStar
Super II
Super II
Model No.
Model No.
Model No.
Model No.
Full
Rated
Max
Rated
Full
Rated
Max
Rated
---
SP3207X10
SP3007EEAZ
SP3007X10AZ
SP3207EE
SP3210X15
SP3010EEAZ
SP3010X15AZ
SP3210EE
SP3215X20
SP3015EEAZ
SP3015X20AZ
SP3215EE
SP3220X25
SP3020EEAZ
SP3020X25AZ
SP3220EE
SP3225X30
SP3025EEAZ
SP3025X30AZ
SP3230EE
---
---
---
IMPORTANT – READ CAREFULLY
NOTE -
The TriStar is a high performance, high
efficiency pump.
When replacing most existing
pumps,
you can use a TriStar pump with a lower
horsepower rating than the existing pump.
Required:
2” plumbing minimum
Recommended: 2 ½” plumbing or larger
SAVE THIS INSTRUCTION MANUAL
HAYWARD POOL PRODUCTS
620 DIVISION STREET
ELIZABETH, NJ
07207
(908) 351-5400
WWW.HAYWARDPOOL.COM