Hayward Universal H-Series Low NOx Owner's Manual: H150FDN H200FDN
Hayward Universal H-Series Low NOx Manual
View all Hayward Universal H-Series Low NOx manuals
Add to My Manuals
Save this manual to your list of manuals |
Hayward Universal H-Series Low NOx manual content summary:
- Hayward Universal H-Series Low NOx | Owner's Manual: H150FDN H200FDN - Page 1
POOL AND SPA/HOT TUB HEATERS H250FDN & H250FDP; H350FDN & H350FDP; H400FDN & H400FDP MODELS OWNER'S MANUAL FOR YOUR SAFETY WARNING: If the information in these instructions is not followed exactly, a fire or explosion may result causing property damage, injury, or death. - Do not store or use - Hayward Universal H-Series Low NOx | Owner's Manual: H150FDN H200FDN - Page 2
8 Maintaining proper water chemistry 8 Lighting & Operating instructions label 10 Operation: Set point adjustment 11 Fahrenheit versus Celsius 11 Keypad inputs 11 Winterization 11 Spring start-up 12 Error codes 12 Warranty...14 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons - Hayward Universal H-Series Low NOx | Owner's Manual: H150FDN H200FDN - Page 3
shock, the electrician must comply with installation instructions and must bond the heater accordingly. In addition, the licensed electrician must also conform to local electrical codes for bonding requirements. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville,TN Tel - Hayward Universal H-Series Low NOx | Owner's Manual: H150FDN H200FDN - Page 4
heater and to all metal parts of swimming pool or spa, and to all electrical equipment, metal piping (except gas piping), and conduit within 5 ft. (1.5 m) of inside walls of swimming pool Local codes. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville,TN Tel: 908-351 - Hayward Universal H-Series Low NOx | Owner's Manual: H150FDN H200FDN - Page 5
death. Before servicing pool and spa water circulation system, all system and pump controls must be in off position and filter manual air relief to install according to defined instructions may result in severe personal injury or death. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, - Hayward Universal H-Series Low NOx | Owner's Manual: H150FDN H200FDN - Page 6
a means for water to exit the pool and into the pump circulating system. A unit for measuring pressure below atmospheric ("suction" or "vacuum") (1.0 inch Hg = .491 PSI) See Suction Outlet An abbreviation for pounds per square inch. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons - Hayward Universal H-Series Low NOx | Owner's Manual: H150FDN H200FDN - Page 7
contains instructions for installation, operation, maintenance, troubleshooting, and parts lists for the safe use of the swimming pool/spa/hot tub heaters. Hayward strongly recommends that the owner read the manual before using the swimming pool/spa/hot tub heater. If after reviewing the manual any - Hayward Universal H-Series Low NOx | Owner's Manual: H150FDN H200FDN - Page 8
pool/spa water test kit to check your water frequently (at least weekly). Use the following guidelines to help protect your heater's heat exchanger: Chlorine Bromine pH Total Alkalinity Calcium Hardness Salt Recommended Level 1 - 3 ppm 2 - 4 ppm 7.4 - 7.6 80 - 120 ppm 200 - 400 ppm Effect of Low - Hayward Universal H-Series Low NOx | Owner's Manual: H150FDN H200FDN - Page 9
bypass feature is also advantageous for service needs and for the ability to remove the heater from the water path when not heating. Refer to page 25 in the installation manual for further information. Heater operation: Full lighting and shutdown instructions are included on the lighting & operating - Hayward Universal H-Series Low NOx | Owner's Manual: H150FDN H200FDN - Page 10
10 Figure 3: Lighting & Operating Instructions label USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville,TN Tel: 908-351-5400 www.haywardpool.com - Hayward Universal H-Series Low NOx | Owner's Manual: H150FDN H200FDN - Page 11
STANDBY" to either "SPA" or "POOL" there may be up to a water must be drained from the heater when it is out of service, to prevent damage to the heater and piping. Draining the heat exchanger is recommended as part of the season's shutdown procedures. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS - Hayward Universal H-Series Low NOx | Owner's Manual: H150FDN H200FDN - Page 12
. 4. Turn the gas supply to the heater "ON". 5. Set the temperature control using the keypad to "POOL" or "SPA" displayed on the heater display board. Contact a qualified service company for assistance code will display if 120V polarity is reversed, low voltage is detected, or if error the ground - Hayward Universal H-Series Low NOx | Owner's Manual: H150FDN H200FDN - Page 13
string opens the heater shuts down and goes into lockout. Automatic LO restart is 2 minutes after the error condition is corrected and the limit string closes. EE EEPROM error An error was detected in the ignition control circuit board. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA - Hayward Universal H-Series Low NOx | Owner's Manual: H150FDN H200FDN - Page 14
contributed to by an external source of energy; 10. A pool/spa heater is a water containing device. Leakage of water from this device can be expected at some time due to malfunction or the limitations USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville,TN Tel: 908-351-5400 - Hayward Universal H-Series Low NOx | Owner's Manual: H150FDN H200FDN - Page 15
BE USED OR STORED IN THE VICINITY OF THE HEATER OR IN ANY LOCATION FROM WHICH FUMES COULD REACH THE HEATER. For your comfort, enjoyment and safety, please read the enclosed operating instructions carefully. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville,TN Tel: 908-351 - Hayward Universal H-Series Low NOx | Owner's Manual: H150FDN H200FDN - Page 16
Hayward Pool Products, Inc. 620 Division St. Elizabeth, NJ 07207 Hayward Pool Products, Inc. Hayward Pool Products, Inc. 2875 Pomona Boulevard 2880 Plymouth Drive Pomona, CA 91768 Oakville, Ontario L6H 5R4 Hayward S.A. Zoming de Jumet B6040 Jumet, Belgique © 2004 Hayward Imprimé aux U.S.A.
FOR YOUR SAFETY
WARNING
:
If the information in these
instructions is not followed exactly, a fire
or explosion may result causing property
damage, injury, or death.
-
Do not store or use gasoline or other flam
-
mable vapors or liquids in the vicinity of this
or any other appliance.
WHAT TO DO IF YOU SMELL GAS:
•
Do not try to light any appliance.
•
Do not touch any electrical switch; do not use
any phone in your building.
•
Immediately call your gas supplier from a
neighbor’s phone. Follow the gas supplier’s
instructions.
•
If you cannot reach your gas supplier, call the
fire department.
- Installation and service must be performed by
a qualified installer, service agency, or the gas
supplier.
POOL AND SPA/HOT TUB HEATERS
H250FDN & H250FDP; H350FDN & H350FDP;
H400FDN & H400FDP MODELS
OWNER’S MANUAL
FOR YOUR SAFETY
This product must be installed and serviced by authorized personnel, qualified in pool/spa
heater installation. Improper installation and/or operation can create carbon monoxide gas
and flue gases that can cause serious injury, property damage, or death.
1301640701
REV D MMYY