HP Surestore 660ex Capacity Upgrade For C1104/05 Series Jukeboxes - C1159-9000
HP Surestore 660ex - Optical Jukebox Manual
 |
View all HP Surestore 660ex manuals
Add to My Manuals
Save this manual to your list of manuals |
HP Surestore 660ex manual content summary:
- HP Surestore 660ex | Capacity Upgrade For C1104/05 Series Jukeboxes - C1159-9000 - Page 1
be downloaded to the controller PCA and the drives. BEFORE starting this upgrade, obtain the following: * The downloadable code required for this upgrade. FTP this code from hpgrsg.gr.hp.com (15.38.89.10) using an "anonymous" login. Further download instructions are available at that address. * A PC - HP Surestore 660ex | Capacity Upgrade For C1104/05 Series Jukeboxes - C1159-9000 - Page 2
©Hewlett-Packard Company, 1996 - HP Surestore 660ex | Capacity Upgrade For C1104/05 Series Jukeboxes - C1159-9000 - Page 3
Upgrade Options a. After you install this capacity upgrade (C1159F/G/H), you are able to install 1 or more 2-drive upgrades ( C1158F/G/H). ESD Precautions The optical disk jukebox contains very sensitive electrical components. It is EXTREMELY IMPORTANT that you follow the proper procedures for - HP Surestore 660ex | Capacity Upgrade For C1104/05 Series Jukeboxes - C1159-9000 - Page 4
12 sets) - # C1100-44x00 • 6 - magazine guides, 6 slot (makes 3 sets) - # C1160-41x15 1 - SCSI terminator, wide differential - # A1658-62024 • 3 - drive brackets - # C1107-60x47 • 12 - screws (RLG) - # C1159F and C1159G kits only) • 1 - these instructions Note The "x" in the part numbers listed in - HP Surestore 660ex | Capacity Upgrade For C1104/05 Series Jukeboxes - C1159-9000 - Page 5
loss of file system integrity. 1. Look in the jukebox front "window" and make sure that there are no disks in any drive. Use the control panel to eject any disk still in a drive. 2. Bring the jukebox "down." Procedures for bringing this jukebox offline depend on the specific host system. Coordinate - HP Surestore 660ex | Capacity Upgrade For C1104/05 Series Jukeboxes - C1159-9000 - Page 6
Installing a Capacity Upgrade Caution When doing this conversion, be sure that disk cartridges are not moved from their original slot locations. If you need to remove the cartridges, record their SLOT LOCATIONS and ORIENTATION so they can be replaced to their ORIGINAL positions. Failure to follow - HP Surestore 660ex | Capacity Upgrade For C1104/05 Series Jukeboxes - C1159-9000 - Page 7
2: Screws on the RFI panel Caution Put on a grounding strap to work inside the outer shell of this jukebox. 3. Install the 110 cartridge slots. Refer to Figure 1 for an overview of where these slots will be . Although there are 114 slots added, only 110 of these slots can be used by the jukebox. 7 - HP Surestore 660ex | Capacity Upgrade For C1104/05 Series Jukeboxes - C1159-9000 - Page 8
Figure 3: Location of 8-slot and 6-slot magazine sets after upgrade Figure 4: Magazine tabs and spring latch (right side) 8 - HP Surestore 660ex | Capacity Upgrade For C1104/05 Series Jukeboxes - C1159-9000 - Page 9
the picture). If this latch does not catch (click into place), the guide is not correctly mounted and could come out during use. When installing the magazines in the left stack (as you face the interior of the jukebox during this step) you will have to slip the magazines under a small - HP Surestore 660ex | Capacity Upgrade For C1104/05 Series Jukeboxes - C1159-9000 - Page 10
SCSI interface module. Note The new interface module you will assemble has 2 SCSI interface PCAs to support future upgrades to the number of drives (upgrading to 8, 10, or 12 drives). Figure 6: Location of the interface module and mounting screws a. Remove the current interface module. 1. Disconnect - HP Surestore 660ex | Capacity Upgrade For C1104/05 Series Jukeboxes - C1159-9000 - Page 11
((Place the interface module and interface board aside.)) 4. Install the new, lower interposer PCA below the one currently in the jukebox. Figure 6 shows the location of this PCA and Figure 7 shows how cables are routed from the upper interposer PCA and the new, lower interposer PCA. - HP Surestore 660ex | Capacity Upgrade For C1104/05 Series Jukeboxes - C1159-9000 - Page 12
. Figure 8: GPIO cable connection to the lower interposer PCA d. Place the additional ferrite clip that comes with this kit around the new SCSI cable going to the upper interposer PCA. Attach this clip on top of the one is currently there. See Figure 9 for placement. Figure 9: Placement of the - HP Surestore 660ex | Capacity Upgrade For C1104/05 Series Jukeboxes - C1159-9000 - Page 13
5. Attach the power cables. Refer to Figure 10 for proper power cable connections. Figure 10: Paths for connection of power cables a. Connect the interposer PCA power cable. 1. Connect the 2 connectors on the power cable to the lower interposer PCA (at the upper and middle power connectors on the - HP Surestore 660ex | Capacity Upgrade For C1104/05 Series Jukeboxes - C1159-9000 - Page 14
the first (lower) PCA with standoff screws Figure 12: Installing the second (upper) PCA - adding jumper c. Mount the new interface module on the jukebox. 1. Connect the upper interposer-to-interface SCSI cable to the "bottom" SCSI interface PCA ("bottom" is closest to the module enclosure). Mount the - HP Surestore 660ex | Capacity Upgrade For C1104/05 Series Jukeboxes - C1159-9000 - Page 15
module, and can be moved freely. 3. Replace cables and terminators as required by customer needs. Note The C1104F/G/H (1/2 capacity) jukebox was shipped with a single-ended and a differential terminator. This capacity upgrade includes additional single-ended and differential terminators for use on - HP Surestore 660ex | Capacity Upgrade For C1104/05 Series Jukeboxes - C1159-9000 - Page 16
upgrade, skip to Step 8. a. Remove the 2 T-20 screws from each of the 3 front plates that cover the lower drive locations. b. Insert each drive enclosure and secure it by inserting and tightening 2 T-20 screws. Note The RFI strips tend to compress the enclosure sides. Keep the front of the - HP Surestore 660ex | Capacity Upgrade For C1104/05 Series Jukeboxes - C1159-9000 - Page 17
PCA 8. Download the latest code to the controller PCA and drives. You will use an external SCSI connector on the interface module. 9. Run the Wellness Test to verify installation. 10. Remove power from the jukebox. 11. Label the jukebox (see the following Note for guidance on which label to use - HP Surestore 660ex | Capacity Upgrade For C1104/05 Series Jukeboxes - C1159-9000 - Page 18
10 drives = C1110F/G/H 12 drives = C1112F/G/H Choose the label that has the same product suffiix (F, G, or H) that the original product had. 12. Reconnect external SCSI interface cables as previously installed at the site. 13. Replace the 3 right-side and 3 rear panels. 14. Bring the jukebox online
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
 |
 |
Capacity Upgrade
For C1104/05 Series Jukeboxes
HP Part No.
C1159-90001
Printed in USA June, 1996
Edition 1
0596
Important! Read This First
BEFORE
starting this upgrade, obtain the following:
*
The downloadable code required for this upgrade. FTP this code
* A PC with a SCSI interface and appropriate cables.
from
hpgrsg.gr.hp.com (15.38.89.10
)
using an "anonymous" login.
Further download instructions are available at that address.
* A utility to download the code - DOWNLD2 or
HP TOOLSET (Version 1.95ce
This upgrade requires code to be downloaded to the controller PCA and the drives.
or later) from CoComp