HP Surestore 80ex Adding 1 Drive to the C1100 Series Jukebox - C1156-90000
HP Surestore 80ex - Optical Jukebox Manual
View all HP Surestore 80ex manuals
Add to My Manuals
Save this manual to your list of manuals |
HP Surestore 80ex manual content summary:
- HP Surestore 80ex | Adding 1 Drive to the C1100 Series Jukebox - C1156-90000 - Page 1
upgrade, obtain the following: * The downloadable code required for this upgrade. FTP this code from hpgrsg.gr.hp.com (15.38.89.10) using an "anonymous" login. Further download instructions are available at that address. * A PC with a SCSI interface and appropriate cables * A utility to download the - HP Surestore 80ex | Adding 1 Drive to the C1100 Series Jukebox - C1156-90000 - Page 2
©Hewlett-Packard Company, 1996 - HP Surestore 80ex | Adding 1 Drive to the C1100 Series Jukebox - C1156-90000 - Page 3
Adding 1 Drive to the C1100 Series Jukebox ESD Precautions The optical disk jukebox contains very sensitive electrical components. It is EXTREMELY IMPORTANT that you -3033 • 5 - M3x6 T10 screws - # 0515-2382 • 1 - product upgrade label sheet (Upgrade to: ) - # 5181-9902 • 1 - these instructions 3 - HP Surestore 80ex | Adding 1 Drive to the C1100 Series Jukebox - C1156-90000 - Page 4
so they can be replaced to their ORIGINAL positions. Failure to follow this practice results in a serious loss of file system integrity. 1. Bring the jukebox "down." Procedures for bringing this jukebox offline depend on the specific host system. Coordinate with the system administrator to prepare this - HP Surestore 80ex | Adding 1 Drive to the C1100 Series Jukebox - C1156-90000 - Page 5
Installing the 1-Drive Upgrade Caution Wear a grounding strap when working inside the outer shell of this jukebox. 1. Remove the jukebox cover by removing the four T-25 screws on that hold the cover to the rear panel. 2. Slide the cover toward the rear of the unit. - HP Surestore 80ex | Adding 1 Drive to the C1100 Series Jukebox - C1156-90000 - Page 6
the Access Panel ************ Figure 2: Removing the access panel 4. Pull the picker up to the top of the chassis and insert a T-25 screw in the service hole, which holds the picker at the top of the chassis (Figure 3). ***** Fastening the picker out of the way ***** Figure 3: Fastening the picker - HP Surestore 80ex | Adding 1 Drive to the C1100 Series Jukebox - C1156-90000 - Page 7
5. Remove the 3 cartridge "stop" screws (T-15). Figure 4: Cartridge "stop" screws Accessing Components in the Front Bezel 6. Remove the two T-25 screws that secure the front bezel to the chassis. These screws are located behind the bezel as shown in Figure 5. Figure 5: Front bezel mounting screws 7 - HP Surestore 80ex | Adding 1 Drive to the C1100 Series Jukebox - C1156-90000 - Page 8
Tilted out ***** Figure 6: Front panel tilted out 8. Remove the RFI shield. Note The cables/connectors for the additional drive are already in place in the jukebox. You will only have to mount the drive and connect it to the cables. 8 - HP Surestore 80ex | Adding 1 Drive to the C1100 Series Jukebox - C1156-90000 - Page 9
just above the current drive. Insert 1 T-10 screw through the right side of the chassis to support the drive . a. Hold the drive up by its front (inside the jukebox) and insert the other T-10 screw on the right side. 11. Using an extension on your Torx driver, insert and tighten the 2 T-10 - HP Surestore 80ex | Adding 1 Drive to the C1100 Series Jukebox - C1156-90000 - Page 10
, 16. Release the T-25 screw holding the picker in its stowed position at the top of the chassis. 17. Connect the power cable. Turn the jukebox on. 18. Run Test 2, the Wellness Test, to verify that the upgrade has been successful. 19. Re-mount the access panel and outside cover. 10 - HP Surestore 80ex | Adding 1 Drive to the C1100 Series Jukebox - C1156-90000 - Page 11
the serial number. Select the appropriate label - Use the C1115 label when upgrading a C1100 (single-ended interface) jukebox. Use a C1116 label when upgrading a C1101 (differential interface) jukebox. Figure 10: Location of the product label Figure 11: Adding the upgrade label 21. Remove power from - HP Surestore 80ex | Adding 1 Drive to the C1100 Series Jukebox - C1156-90000 - Page 12
12
Adding 1 Drive to the
C1100 Series Jukebox
HP Part No.
C1156-90000
Printed in USA June, 1996
Edition 1
0696
Important! Read This First
BEFORE
starting this upgrade, obtain the following:
*
The downloadable code required for this upgrade. FTP this code
* A PC with a SCSI interface and appropriate cables
from
hpgrsg.gr.hp.com (15.38.89.10
)
using an "anonymous" login.
Further download instructions are available at that address.
* A utility to download the code - DOWNLD2 or
HP TOOLSET
(Version 1.95ce
This upgrade requires code to be
downloaded to the controller PCA and the drives.
or later) from CoComp