Husqvarna HD775HW Owners Manual

Husqvarna HD775HW Manual

Get Husqvarna HD775HW PDF manuals and user guides View all Husqvarna HD775HW manuals
Add to My Manuals
Save this manual to your list of manuals

Husqvarna HD775HW manual content summary:

  • Husqvarna HD775HW | Owners Manual - Page 1
    . Theuseofanygasolineexceeding 10% ethanol (E10) will void the product warranty. 532 44 58-68 Rev. 3 Operator's Manual Owner's Manual HD775HW / 961430086 Please read the operator's manual carefully and make sure you understand the instructions before using the machine. English
  • Husqvarna HD775HW | Owners Manual - Page 2
    you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this lawn mower. Please read and retain this manual. The instructions will enable you to
  • Husqvarna HD775HW | Owners Manual - Page 3
    using your lawn mower. • Follow the instructions under "Maintenance" and "Storage" sections of this operator's manual. PRODUCT manufacturer's recommended parts, when necessary. • Mower blade is sharp and can cut. Wrap the blade or wear gloves, and use extra caution when servicing it. Oil
  • Husqvarna HD775HW | Owners Manual - Page 4
    SAFETY AND INSTRUCTIONAL DECALS 4 ASSEMBLY 4-5 PRODUCT OVERVIEW 6 OPERATION 7-11 MAINTENANCE 12-16 SERVICE AND ADJUSTMENTS 17-18 STORAGE 19-20 TROUBLESHOOTING 21 WARRANTY 22-25 KNOW YOUR LAWN MOWER READ THIS OPERATOR'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR LAWN MOWER. Compare the
  • Husqvarna HD775HW | Owners Manual - Page 5
    mower to bagging or discharging, see "TO CONVERT MOWER" in the Operation section of this manual. MOWING POSITION 1 TO REMOVE LAWN MOWER FROM CARTON 1. Remove loose parts included with mower to "TO ADJUST HANDLE" in the Service and Adjustments section of this manual. 4 Figure 3 1. Operator presence
  • Husqvarna HD775HW | Owners Manual - Page 6
    PRODUCT OVERVIEW 1 2 11 12 10 9 3 4 5 6 8 7 Figure 5 1. Drive control levers 2. Operator presence control bar 3. Grass catcher 4. Single point height adjuster 5. Engine oil cap with dipstick 6. Muffler 7. Spark plug 8. Housing 9. Air filter 10. Gas filler cap 11. Handle knob 12. Starter
  • Husqvarna HD775HW | Owners Manual - Page 7
    : The blade turns when the engine is running. ENGINE ZONE CONTROL CAUTION: Federal regulations require an engine control to be installed on this lawn mower in order to minimize the risk of blade contact injury. Do not under any circumstances attempt to defeat the function of the operator control
  • Husqvarna HD775HW | Owners Manual - Page 8
    was shipped ready to be used as a mulcher. To convert to bagging or discharging: REAR BAGGING 1. Lift rear door of the lawn mower and place the grass catcher frame hooks onto the grass bag brackets (Figure 10). 2. To convert to mulching operation, remove grass catcher and close rear
  • Husqvarna HD775HW | Owners Manual - Page 9
    see "ENGINE" in the Maintenance section of this manual. ADD GASOLINE IMPORTANT: Fill fuel tank to bottom engine while in storage. To avoid engine problems, the fuel system should be emptied before Use fresh fuel next season. See Storage Instructions for additional information. Never use engine or
  • Husqvarna HD775HW | Owners Manual - Page 10
    to keep from overloading the engine and leaving clumps of grass clippings. It may also be necessary to reduce ground speed and/or run the lawn mower over the area a second time. • For extremely heavy cutting, reduce the width of cut by overlapping previously cut path and mow slowly. • For better
  • Husqvarna HD775HW | Owners Manual - Page 11
    : FOR BEST PERFORMANCE, KEEP MOWER HOUSING FREE OF BUILT-UP GRASS AND TRASH. SEE "CLEANING" IN THE MAINTENANCE SECTION OF THIS MANUAL. • The special mulching blade will recut the grass clippings many times and reduce them in size so that as they fall onto the lawn they will disperse into the
  • Husqvarna HD775HW | Owners Manual - Page 12
    hours of use. GENERAL RECOMMENDATIONS The warranty on this lawn mower does not cover items that have been subjected to operator abuse or negligence. To receive full value from the warranty, operator must maintain mower as instructed in this manual. Some adjustments will need to be made periodically
  • Husqvarna HD775HW | Owners Manual - Page 13
    . 5. Install the blade bolt with the lock washer and hardened washer into blade adapter and crankshaft. 6. Use block of wood between blade and lawn mower housing and tighten the blade bolt, turning clockwise. • The recommended tightening torque is 35-40 ft. lbs. IMPORTANT: BLADE BOLT IS HEAT TREATED
  • Husqvarna HD775HW | Owners Manual - Page 14
    lawn mower or engine. • The blade can be sharpened with a file or on a grinding wheel. Do not attempt to sharpen while on the mower. • To check blade balance, you will need a 5/8" diameter steel bolt, pin, or a cone balancer. (When using a cone balancer, follow the instructions API service
  • Husqvarna HD775HW | Owners Manual - Page 15
    aside on a clean surface. 3. Tip lawn mower on its side as shown and drain oil into a suitable container. Rock lawn mower back and forth to remove any oil trapped 100 hours of operation or every season, whichever occurs first. Service air cleaner more often under dusty conditions. NOTE: The air
  • Husqvarna HD775HW | Owners Manual - Page 16
    water supply and check for leaks at the fitting. If no leaks are present, start engine (as described in the Operation section of this manual) and let engine run until the underside of the lawn mower is clean. 1 1 2 1. Clamp 2. Fuel filter Figure 22 CLEANING IMPORTANT: FOR BEST PERFORMANCE, KEEP
  • Husqvarna HD775HW | Owners Manual - Page 17
    injury, BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS: 1. Release control bar and stop engine. 2. Make sure the blade and all moving parts have completely stopped. 3. Disconnect spark plug wire from spark plug and place where it cannot come in contact with plug. LAWN MOWER TO ADJUST CUTTING HEIGHT
  • Husqvarna HD775HW | Owners Manual - Page 18
    and adjustment. CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your lawn mower to an authorized service center for repair and/or adjustment. IMPORTANT: NEVER TAMPER WITH THE ENGINE GOVERNOR, WHICH IS FACTORY SET FOR
  • Husqvarna HD775HW | Owners Manual - Page 19
    in a clean, dry area. 1. Clean entire lawn mower (See "CLEANING" in the Maintenance section of this manual). 2. Lubricate as shown in the Maintenance section of this manual. 3. Be sure that all nuts, bolts, screws, and pins are securely fastened. Inspect moving parts for damage, breakage and wear
  • Husqvarna HD775HW | Owners Manual - Page 20
    FUEL SYSTEM PARTS SUCH AS CARBURETOR ENGINE" in the Maintenance section of this manual). CYLINDER 1. Remove spark plug. 2. Pour /or dirt in your gasoline will cause problems. • If possible, store your unit indoors MOWER WHILE ENGINE AND EXHAUST AREAS ARE STILL WARM. CAUTION: Never store the lawn mower
  • Husqvarna HD775HW | Owners Manual - Page 21
    TROUBLESHOOTING POINTS PROBLEM CAUSE CORRECTION Does not start 1. Dirty air filter. 1. Clean/replace air upper handle before pulling starter rope. 2. Contact a qualified service center. 3. Replace blade adapter. 4. Move lawn mower to cut grass or other hard surface before starting. Grass
  • Husqvarna HD775HW | Owners Manual - Page 22
    , such as throttle cable, belt guides adjustments; and c. Preventative maintenance as outlined in the operator's manual. In addition, you must cease using the product immediately upon any failure or damage. The product should be taken to an authorized Husqvarna servicing dealer prior to any further
  • Husqvarna HD775HW | Owners Manual - Page 23
    in the operator's manual; (k) Tampering after initial operational problem or failure occurs. shell only - mechanical components/parts such as belts, pulleys, NOT covered: (a) Abrasion to mower decks, including sand wear; (b) HOW TO OBTAIN SERVICE 10. Authorized Husqvarna Servicing Dealer/Center. In
  • Husqvarna HD775HW | Owners Manual - Page 24
    Lawn Tractors: Frame, Chassis, Front Axle 5 Years No Warranty Engine* * * Transmission (if made by Husqvarna Battery Other Non-Expendable Components Residential Zero Turn Mowers ( MZ & EZ ) Engine* Transmission ** Year Parts Only) *2 Years-1365GN (2nd Year Parts Only) * No Warranty 24
  • Husqvarna HD775HW | Owners Manual - Page 25
    Parts (e.g., belts, blades, etc.) 30 days No Warranty No Warranty Parts & Accessories (if replaced in Warranty Service) Replacement parts parts & labor, with Hydro-Gear Distributor network. EZ - One (1) Year Commercial warranty, parts & labor, with Husqvarna. Two (2) Year Consumer warranty, parts
  • Husqvarna HD775HW | Owners Manual - Page 26
    05/02/2012 BY/TH/TH/BY
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
English
532 44 58-68 Rev. 3
Operator’s Manual
Owner’s Manual
HD775HW / 961430086
Gasoline containing up to 10% ethanol (E10) is accept-
able for use in this machine. The use of any gasoline ex-
ceeding10%ethanol(E10)willvoidtheproductwarranty.
Please read the operator's manual carefully and make sure
you understand the instructions before using the machine.