Husqvarna YTH24V54XLS Owners Manual

Husqvarna YTH24V54XLS Manual

Get Husqvarna YTH24V54XLS PDF manuals and user guides View all Husqvarna YTH24V54XLS manuals
Add to My Manuals
Save this manual to your list of manuals

Husqvarna YTH24V54XLS manual content summary:

  • Husqvarna YTH24V54XLS | Owners Manual - Page 1
    07002 YTH24V54XLS Owner's Manual Gasoline containing up to 10% ethanol (E10) is acceptable for use in this machine. The use of any gasoline exceeding 10% ethanol (E10) will void the product warranty. 532 44 17-61
  • Husqvarna YTH24V54XLS | Owners Manual - Page 2
    lose traction with the ground and cause you to lose control of your tractor. WARNING Engine exhaust, some of its constituents, and certain vehicle components and follow all instructions on the machine and in the manual before starting. • Do not put hands or feet near rotating parts or under the
  • Husqvarna YTH24V54XLS | Owners Manual - Page 3
    and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction labels, as necessary
  • Husqvarna YTH24V54XLS | Owners Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized servicecenter/ department We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Husqvarna YTH24V54XLS | Owners Manual - Page 5
    UNASSEMBLED PARTS Mower Front Wheel (1) 1-1/4 O.D. Washer (1) Shoulder Bolt (1) 3/8-16 Locknut (1) Wheel Mower (5) 1-3/16 O.D. Washers (1) Small Retainer Springs (2) Rear Lift Link Assemblies If Equipped (1) 3/4 O.D. Washers (1) Front (5) Large Lift
  • Husqvarna YTH24V54XLS | Owners Manual - Page 6
    cable installation see "REPLACING BATTERY" in the "Service and Adjustments" section in this manual. LABEL Fig. 2 NOTE: You may now roll your tractor off the skid. Follow the appropriate instruction on the next page to remove the tractor from the skid. Warning: Before starting, read, understand
  • Husqvarna YTH24V54XLS | Owners Manual - Page 7
    grooves. NOTE: Be sure mower side suspension arms (A) are pointing forward before sliding mower under tractor. • Slide mower under tractor until it is centered under tractor. Q A A. MOWER SIDE SUSPENSION ARMS Q. DEFLECTOR 02965 SHIELD Fig. 8 5. INSTALL ANTI-SWAY BAR (S) (IF EQUIPPED) (See
  • Husqvarna YTH24V54XLS | Owners Manual - Page 8
    13) • Insert rod end of rear lift link (C) into hole (U) in tractor lift shaft suspension arm and pivot link down to mower. • Lift rear corner of secure with large washer and large retainer spring. • Repeat on opposite side of tractor. U C S T S. ANTI-SWAY BAR T. TRANSAXLE BRACKET Fig. 10 NOTE
  • Husqvarna YTH24V54XLS | Owners Manual - Page 9
    BRAKE" in the Service and Adjustments section of this manual. ✓CHECKLIST BEFORE YOU OPERATE YOUR NEW TRACTOR, WE WISH TO ENSURE THAT YOU RECEIVE THE BEST PERFORMANCE AND SATISFACTION FROM THIS QUALITY PRODUCT. PLEASE REVIEW THE FOLLOWING CHECKLIST: ✓ All assembly instructions have been completed
  • Husqvarna YTH24V54XLS | Owners Manual - Page 10
    RULES SECTION) FREE WHEEL (Automatic Models only) Failure to follow instructions could result in serious injury or death. The safety alert symbol the alert symbol, indicates a situation that could result in damage to the tractor and/or engine. HOT SURFACES indicates a hazard which, if not avoided,
  • Husqvarna YTH24V54XLS | Owners Manual - Page 11
    OPERATION KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual for future reference. D P Z H G E F N B A M Q C K
  • Husqvarna YTH24V54XLS | Owners Manual - Page 12
    in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your tractor or performing any adjustments or repairs. We recommend standard safety glasses or a wide vision safety mask worn over spectacles. HOW TO USE YOUR
  • Husqvarna YTH24V54XLS | Owners Manual - Page 13
    during hot months. For healthier and better looking lawns, mow often and after moderate growth. • For JUST MOWER CUTTING HEIGHT" in this section of manual). • With mower in desired height of cut position hole. Fig. 22 TO OPERATE MOWER Your tractor is equipped with an operator presence sensing switch
  • Husqvarna YTH24V54XLS | Owners Manual - Page 14
    Fig. 25 TOWING CARTS AND OTHER ATTACHMENTS Tow only the attachments that are recommended by and comply with specifications of the manufacturer of your tractor. Use common sense when towing. Too heavy of a load, while on a slope, is dangerous. Tires can lose traction with the ground and cause you
  • Husqvarna YTH24V54XLS | Owners Manual - Page 15
    manual. NOTE: Service reminder runs when the ignition key is in any position but "STOP". For accurate reading, be sure key remains in the "STOP" position when engine is not running. BEFORE STARTING THE ENGINE CHECK ENGINE OIL LEVEL The engine in your tractor engine problems, the Instructions for
  • Husqvarna YTH24V54XLS | Owners Manual - Page 16
    TIPS • Tire chains cannot be used when the mower housing is attached to tractor. • Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower should be used for trimming. • Drive so
  • Husqvarna YTH24V54XLS | Owners Manual - Page 17
    as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual. • At least once a year you should
  • Husqvarna YTH24V54XLS | Owners Manual - Page 18
    tractor requires more than five (5) feet to stop at highest speed in highest gear on a level, dry concrete or paved surface, then brake must be checked and adjusted. (See "TO CHECK BRAKE" in the Service and Adjustments section of this manual tractor does not function as described, repair the problem
  • Husqvarna YTH24V54XLS | Owners Manual - Page 19
    after every 50 hours of operation or at least once a year if the tractor is not used for 50 hours in one year. AIR FILTER Your engine will (8) hours of operation. Tighten oil fill Service air cleaner more often under dusty conditions. See Engine Manual. cap/dipstick securely each time you check
  • Husqvarna YTH24V54XLS | Owners Manual - Page 20
    in "PRODUCT SPECIFICATIONS" section of this manual. IN-LINE FUEL FILTER (See part of its deck wash system. It should be utilized after each use. 1. Drive the tractor to a level, clear spot on your lawn, near enough to a water spigot for your garden hose to reach. IMPORTANT: Make certain the tractor
  • Husqvarna YTH24V54XLS | Owners Manual - Page 21
    the left as far as it will go. • Slide mower out from under right side of tractor. TO INSTALL MOWER Follow procedure described in "INSTALL MOWER AND DRIVE BELT" in the Assembly section of this manual. L K B M A F E H TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 37) MOWER DRIVE BELT REMOVAL • Park
  • Husqvarna YTH24V54XLS | Owners Manual - Page 22
    SERVICE AND ADJUSTMENTS TO LEVEL MOWER Make sure tires are properly inflated to the PSI shown on tires. If tires are over or under inflated, it may affect the appearance of your lawn in Visual Adjustment instructions above. • Recheck tires properly inflated, park tractor on level ground or driveway
  • Husqvarna YTH24V54XLS | Owners Manual - Page 23
    SERVICE AND ADJUSTMENTS TO REPLACE MOTION DRIVE BELT (See Fig. 42) Park the tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal on bottom side of left footrest. BELT REMOVAL - 1. Remove mower (See "TO REMOVE MOWER" section in this manual parts
  • Husqvarna YTH24V54XLS | Owners Manual - Page 24
    SERVICE AND ADJUSTMENTS TO START ENGINE WITH A WEAK BATTERY (See Fig. be recharged. (See "BATTERY" in the MAINTENANCE section of this manual). If "jumper cables" are used for emergency starting, follow this procedure: IMPORTANT: YOUR TRACTOR IS EQUIPPED WITH A 12 VOLT SYSTEM. THE OTHER VEHICLE MUST
  • Husqvarna YTH24V54XLS | Owners Manual - Page 25
    not be necessary. If adjustment is necessary, see engne manual. TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment. TRANSMISSION REMOVAL
  • Husqvarna YTH24V54XLS | Owners Manual - Page 26
    tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual DEPOSITS FROM FORMING IN ESSENTIAL FUEL SYSTEM PARTS SUCH AS CARBURETOR, FUEL FILTER, FUEL HOSE
  • Husqvarna YTH24V54XLS | Owners Manual - Page 27
    TROUBLESHOOTING PROBLEM Will not start CAUSE 1. Out of service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part(s). 1. Replace blade. Tighten blade bolt. 2. Replace blade mandrel. 3. Tighten loose part(s). Replace damaged parts
  • Husqvarna YTH24V54XLS | Owners Manual - Page 28
    TROUBLESHOOTING PROBLEM CAUSE Engine continues to run when operator leaves seat with attachment clutch engaged 1. Faulty operator-safety presence control system. CORRECTION 1. Check wiring, switches and connections. If not corrected, contact an authorized service listed in parts manual. 11.
  • Husqvarna YTH24V54XLS | Owners Manual - Page 29
    TRACTOR - MODEL NO. YTH24V54XLS (96043011401), PRODUCT NO. 960 43 01-14 SCHEMATIC SCH12 A AMMETER (OPTIONAL) BATTERY RED RED FUSE WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE RE-INSTALLED TO PROPERLY SECURE YOUR WIRING. NON
  • Husqvarna YTH24V54XLS | Owners Manual - Page 30
    TRACTOR - MODEL NO. YTH24V54XLS (96043011401), PRODUCT NO. 960 43 01-14 ELECTRICAL T15S 90 33 22 30 27 2 1 91 99 100 8 79 21 34 24 27 42 43 41 26 40 25 28 55 16 0 60 AMPS 60 45 46 With 12V Outlet Option 103 59 71 29 30 102 105
  • Husqvarna YTH24V54XLS | Owners Manual - Page 31
    TRACTOR - MODEL NO. YTH24V54XLS (96043011401), PRODUCT NO. 960 43 01-14 ELECTRICAL KEY PART NO. NO. DESCRIPTION 1 532 16 34-65 Battery 2 874 76 04-12 Bolt Hex Head 1/4-20 x 3/4 8 532 18 64-91 Box Battery 16 532 17
  • Husqvarna YTH24V54XLS | Owners Manual - Page 32
    TRACTOR - MODEL NO. YTH24V54XLS (96043011401), PRODUCT NO. 960 43 01-14 CHASSIS 297 208 15 204 18 3 203 214 14 234 206 137 336 5 176 130 130 130 130
  • Husqvarna YTH24V54XLS | Owners Manual - Page 33
    TRACTOR - MODEL NO. YTH24V54XLS (96043011401), PRODUCT NO. 960 43 01-14 CHASSIS KEY PART NO. NO. DESCRIPTION 3 532 43 97-52 Logo 5 27 Window, Fuel 162 532 14 24-32 Screw Hex Wsh 1/4 x 1/2 unc 165 532 19 68-26 Support Tank Rear 175 532 19 63-04 Crossmember 176 532 40 07-76 Screw 10-24 x 5/8 177 532
  • Husqvarna YTH24V54XLS | Owners Manual - Page 34
    TRACTOR - MODEL NO. YTH24V54XLS (96043011401), PRODUCT NO. 960 43 01-14 DRIVE 221 213 207 206 92 125 116 160 56 209 26 216 185 221 184 42 143
  • Husqvarna YTH24V54XLS | Owners Manual - Page 35
    TRACTOR - MODEL NO. YTH24V54XLS (96043011401), PRODUCT NO. 960 43 01-14 DRIVE KEY PART NO. NO. DESCRIPTION 1 Transaxle, TUFFTORQ K46 CR Centerspan 183 532 13 70-57 Spacer Split 184 532 40 31-18 Handle Parking Brake KEY PART NO. NO. DESCRIPTION 185 872 11 06-22 Bolt Rdhd Sqnk 3/8-16 x 2-3/4 Gr
  • Husqvarna YTH24V54XLS | Owners Manual - Page 36
    TRACTOR - MODEL NO. YTH24V54XLS (96043011401), PRODUCT NO. 960 43 01-14 ENGINE 116 21 1 14 20 22 92 18 91 15 37 28 37 29 90 45 69 92 12 86 11 41 42 85 9 87 62 71 70 2 SPARK ARRESTER KIT engine-tex_Kawa-2cyl_6 KEY PART service and replacement parts, call the toll free number for
  • Husqvarna YTH24V54XLS | Owners Manual - Page 37
    ) - - 532 44 17-62 Manual, Owner's (Spanish) WHEELS AND TIRES 1 2 11 3 4 7 10 6 wheel_art_1-tex 5 9 8 KEY PART NO. NO. DESCRIPTION 1 532 05 91-92 Cap Valve Tire 2 532 06 51-39 Stem Valve 3 532 13 83-36 Rim Front Service 4 532 05 99-04 Tube Front (Service Item Only) 5 532 10 62
  • Husqvarna YTH24V54XLS | Owners Manual - Page 38
    TRACTOR - MODEL NO. YTH24V54XLS (96043011401), PRODUCT NO. 960 43 01-14 MOWER DECK                                                           
  • Husqvarna YTH24V54XLS | Owners Manual - Page 39
    TRACTOR - MODEL NO. YTH24V54XLS (96043011401), PRODUCT NO. 960 43 01-14 MOWER DECK KEY PART NO. NO. DESCRIPTION 1 532 42 41-29 Deck Weldment unc x 2 52 532 19 73-79 Pulley Idler 58 532 18 73-42 Baffle Right KEY PART NO. NO. DESCRIPTION 59 532 18 73-44 Baffle Left 60 532 18 76-07 Baffle Center
  • Husqvarna YTH24V54XLS | Owners Manual - Page 40
    TRACTOR - MODEL NO. YTH24V54XLS (96043011401), PRODUCT NO. 960 43 01-14 STEERING ASSEMBLY 26 51 45 1 21 16 64 63 28 13 28 22 60 19 59 35 58 63 57 4 9 8 66 7 2 67 6 67 9 8 7 6 15 61 14 69 70 68 steering-tex_HUSQSR_14 KEY PART 22 532 42 05-37 Steering Support Lower 26 532 41 59-
  • Husqvarna YTH24V54XLS | Owners Manual - Page 41
    TRACTOR - MODEL NO. YTH24V54XLS (96043011401), PRODUCT NO. 960 43 01-14 SEAT ASSEMBLY 1 8 8 7 7 8 41 40 8 10 seat-tex_6.5SL_2 21 44 43 6 37 2 37 21 3 KEY PART NO. NO. 77 Pan, Seat 21 532 17 18-52 Bolt, Shoulder 5/16-18 KEY PART NO. NO. DESCRIPTION 37 873 80 05-00 Nut, Lock 5/16-18
  • Husqvarna YTH24V54XLS | Owners Manual - Page 42
    TRACTOR - MODEL NO. YTH24V54XLS (96043011401), PRODUCT NO. 960 43 01-14 MOWER LIFT 87 7 87 3 10 97 90 98 89 88 2 91 87 89 97 91 lift-tex_23 89 87 KEY PART NO. 07-10 Spring Lift Assist 89 819 19 19-12 Washer Clear Zinc KEY PART NO. NO. DESCRIPTION 90 532 19 42-08 Pin Cotter 5/16 Bow
  • Husqvarna YTH24V54XLS | Owners Manual - Page 43
    43 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Husqvarna YTH24V54XLS | Owners Manual - Page 44
    12.27.10 TH Printed in the U.S.A.
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
YTH24V54XLS
Owner's Manual
532 44 17-61
07002
Gasoline containing up to 10% ethanol (E10) is acceptable for use in this machine.
The use of any gasoline exceeding 10% ethanol (E10) will void the product warranty.