Intel W2600CR Technical Product Specification

Intel W2600CR Manual

Get Intel W2600CR PDF manuals and user guides View all Intel W2600CR manuals
Add to My Manuals
Save this manual to your list of manuals

Intel W2600CR manual content summary:

  • Intel W2600CR | Technical Product Specification - Page 1
    Intel® Server System R2000IP Product Family Technical Product Specification Intel order number G38158-002 Revision 1.0 May 2012 Enterprise Platforms and Services Division
  • Intel W2600CR | Technical Product Specification - Page 2
    information. Updated and instructions marked "reserved" or "undefined." Intel® reserves these for future definition and shall have no responsibility whatsoever for conflicts or incompatibilities arising from future changes to them. The Intel® Server System R2000IP may contain design defects or errors
  • Intel W2600CR | Technical Product Specification - Page 3
    Intel® Server System R2000IP Product Family TPS Table of Contents Table of Contents 1. Introduction ...1 1.1 Chapter Outline ...1 1.2 Server Board Front Control Panel Options 8 2.4 Server Board Features Overview 8 2.5 Front Bezel Support 12 2.6 Available Rack and Cabinet Mounting
  • Intel W2600CR | Technical Product Specification - Page 4
    Table of Contents Intel® Server System R2000IP Product Family TPS 3.5.16 Electrostatic Discharge Susceptibility 22 3.5.17 Fast Transient/Burst 22 3.5.18 Radiated Immunity 22 3.5.19 Surge Immunity ...22 3.5.20 AC Line Leakage Current 23 3.6 DC
  • Intel W2600CR | Technical Product Specification - Page 5
    Intel® Server System R2000IP Product Family TPS Table of Contents 4.1 Thermal Operation and Configuration Requirements 36-Port Internal Intel RAID Expander Cards 50 5.5.2.1 Cable Routing using a x8 wide-port capable 6 Gb SAS/SAS RAID Controller ......52 5.5.3 Protocol Support 53 5.5.4
  • Intel W2600CR | Technical Product Specification - Page 6
    Options 8 Figure 10. Intel® Server Board S2600IP 9 Figure 11. driver installation 45 Figure 34. 3.5" Drive Hot-Swap Backplane Overview 46 Figure 35. 3.5" Hard Drive Backplane backside 47 Figure 36. Opitcal driver support 48 Figure 37. eUSB SSD Suport...48 Figure 38. 24 Port PCIe Intel® RAID
  • Intel W2600CR | Technical Product Specification - Page 7
    Intel® Server System R2000IP Product Family TPS Table of Contents Figure 39. Internal SAS Expander Installation 51 Figure 40. Internal 24-Port SAS Expander Card 51 Figure 41. 24-Port Expander SAS Connector/Drive Identification Block Diagram 51 Figure 42. Internal 36-Port SAS Expander Card 52
  • Intel W2600CR | Technical Product Specification - Page 8
    List of Tables Intel® Server System R2000IP Product Family TPS List of Tables Table 1. System Feature Set...3 Table 2. Dimensional Data ...4 Table 3. System Environmental Limits Summary 4 Table 4. P1 Baseboard Power Connector (P1 17 Table 5. Processor Power
  • Intel W2600CR | Technical Product Specification - Page 9
    Intel® Server System R2000IP Product Family TPS List of Tables Table 39. Drive Status LED States 46 Table 40. Drive Activity LED States 46 Table 41. SAS Expander Support Options 48 Table 42. Intel® RAID Expander Card RES2SV240 Series Basic Feature 49 Table 43. Power/Sleep LED Functional States
  • Intel W2600CR | Technical Product Specification - Page 10
    List of Tables Intel® Server System R2000IP Product Family TPS x Revision 1.0
  • Intel W2600CR | Technical Product Specification - Page 11
    integrated into them is different. The Intel® Server System R2000IP product family is integrated with an Intel® Server Board S2600IP. This document will describe the functions and features of the integrated server system which includes the chassis layout, system boards, power sub-system, cooling sub
  • Intel W2600CR | Technical Product Specification - Page 12
    Introduction Intel® Server System R2000IP Product Family TPS 1.2 Server Board Use Disclaimer Intel Corporation server boards support add-in peripherals and contain a number of high-density VLSI and power delivery components that need adequate airflow to cool. Intel® ensures through its own chassis
  • Intel W2600CR | Technical Product Specification - Page 13
    name or the integrated server board name. Table 1. System Feature Set Feature Processor Support Memory Chipset External I/O connections Internal I/O connectors/headers Optional I/O Module Support Description  Support for one or two Intel® Xeon® processors E5-2600 product family with a Thermal
  • Intel W2600CR | Technical Product Specification - Page 14
    SAS/SATA  Intel SAS ROC module support (Optional)  Intel® RAID C600 Upgrade Key support providing optional expanded SATA/SAS RAID capabilities Trusted Platform Module (Optional)  Integrated Baseboard Management Controller, IPMI 2.0 compliant  Support for Intel® Server Management Software  Intel
  • Intel W2600CR | Technical Product Specification - Page 15
    Intel® Server System R2000IP Product Family TPS Product Family Overview Parameter Limits Temperature up to 45C for up to 90 hrs per year. -40º C to 70º C (-40º F to 158º F) Support operation up to 3050m with ASHRAE class deratings. 50% to 90%, non-condensing with a maximum wet bulb of 28° C
  • Intel W2600CR | Technical Product Specification - Page 16
    Overview Intel® Server System R2000IP Product Family TPS Note: 1. Intel Corporation server boards contain a number of high-density VLSI and power delivery components that need adequate airflow to cool. Intel ensures through its own chassis development and testing that when Intel® server building
  • Intel W2600CR | Technical Product Specification - Page 17
    Intel® Server System R2000IP Product Family TPS Product Family Overview Figure 4. 3.5" Hard Drive Bay - 12 Drive Configuration Figure 5. 2.5" Hard Drive Bay - 8 Drive Configuration Figure 6. 2.5" Hard Drive Bay - 16 Drive Configuration Figure 7. 2.5" Hard
  • Intel W2600CR | Technical Product Specification - Page 18
    Product Family Overview 2.3.2 Back Panel Features Intel® Server System R2000IP Product Family TPS Figure 8. Back Panel Feature Identification 2.3.3 Front Control Options 2.4 Server Board Features Overview The following illustration provides a general overview of the server board, identifying
  • Intel W2600CR | Technical Product Specification - Page 19
    Intel® Server System R2000IP Product Family TPS Product Family Overview Figure 10. Intel® Server Board S2600IP Revision 1.0 9
  • Intel W2600CR | Technical Product Specification - Page 20
    Product Family Overview Intel® Server System R2000IP Product Family TPS Figure 11. Stand by LED, Fan Fault LED and CPU Fault LED Location 10 Revision 1.0
  • Intel W2600CR | Technical Product Specification - Page 21
    Intel® Server System R2000IP Product Family TPS Product Family Overview Figure 12. DIMM Fault LED's Location Revision 1.0 11
  • Intel W2600CR | Technical Product Specification - Page 22
    Product Family Overview Intel® Server System R2000IP Product Family TPS Figure 13. Location of System Status, System ID and POST Code Diagnostic LEDs LED Name A B LSB 1 2 3 4 5 6 MSB Description System Status LED System ID LED Post Code Diagnostic LEDs 2.5 Front Bezel Support The optional front
  • Intel W2600CR | Technical Product Specification - Page 23
    Intel® Server System R2000IP Product Family TPS Product Family Overview 2.6 Available Rack and Cabinet Mounting Kit Options  Tool-less rack mount rail kit - Intel Product Code - AXXPRAIL o 1U and 2U compatible o 65 lbs max support weight o Tool-less installation o Full extension from rack o Drop
  • Intel W2600CR | Technical Product Specification - Page 24
    Power Subsystem Intel® Server System R2000IP Product Family TPS 3. Power Subsystem There is 750 Watt AC power supply module available. This chapter will provide the power supply specification details. The power supply will accept a
  • Intel W2600CR | Technical Product Specification - Page 25
    Intel® Server System R2000IP Product Family TPS Power Subsystem 3.2 Power Distribution Board and Power Interface board 3.2.1 Input Connectors to Power Interface board (PSU mating connectors) Pin Signal Pin S1 +12V Remote Sense S13 S2 +12V Remote Sense Return S14 S3 12V Load Share
  • Intel W2600CR | Technical Product Specification - Page 26
    Power Subsystem Intel® Server System R2000IP Product Family TPS 3.2.2 Connector from Interface Board to power distribution board Pin Signal Pin S1 +12V Remote Sense S9 S2 +12V Remote Sense Return S10 S3 SMBAlert# S11 S4 SDA S12 S5 SCL S13 S6 PSON
  • Intel W2600CR | Technical Product Specification - Page 27
    Intel® Server System R2000IP Product Family TPS Power Subsystem Connector P1 P2 P3 P4 P5 P6 P7 No. of pins 24 8 8 5 4 6 4 Description Motherboard Main Power Connector CPU1 Power Connector CPU2 Power Connector PMBus* Connector Motherboard 2x2 12V power connector HSBP power connector Peripherals
  • Intel W2600CR | Technical Product Specification - Page 28
    Power Subsystem Intel® Server System R2000IP Product Family TPS Table 7. 2x2 pin 12V Power Connectors (P5) Pin Signal Pin 1 COM 3 2 COM 4 Signal +12V1 +12V1 Table 8. HSBP Power Connectors (P6) Pin Signal Pin Signal 1 COM 4 +
  • Intel W2600CR | Technical Product Specification - Page 29
    Intel® Server System R2000IP Product Family TPS Power Subsystem Figure 20. AC Power Cord 3.5 AC Input Requirement The power supply shall incorporate universal power input with active power factor correction which shall
  • Intel W2600CR | Technical Product Specification - Page 30
    Power Subsystem Intel® Server System R2000IP Product Family TPS 3.5.4 Power Recovery The power supply will recover automatically after an AC power failure. AC power failure is defined to be any loss of AC power that exceeds
  • Intel W2600CR | Technical Product Specification - Page 31
    Intel® Server System R2000IP Product Family TPS Power Subsystem during a single cycle AC dropout condition as well as upon recovery after AC under any condition; all power supply output voltage levels to stay within proper spec levels; No change in operating state or loss of data during and after
  • Intel W2600CR | Technical Product Specification - Page 32
    Power Subsystem Intel® Server System R2000IP Product Family TPS The supply must meet surge-withstand test is allowed under any condition; All power supply output voltage levels to stay within proper spec levels; No change in operating state or loss of data during and after the test profile
  • Intel W2600CR | Technical Product Specification - Page 33
    Intel® Server System R2000IP Product Family TPS Power Subsystem The power supply shall comply with the Connector The power supply module shall use the card edge for output power to the power distribution board with the mating connector of (Molex 459840005) and AC input power to the module. 3.6.2
  • Intel W2600CR | Technical Product Specification - Page 34
    Power Subsystem Intel® Server System R2000IP Product Family TPS Output Tolerance MIN NOM MAX Units + 12V + 5Vsb ± 5% ± 5% 11.40 4.75 12.00 5.00 12.60 VDC 5.25 VDC 3.6.6 5Vsb Outputs The 5Vsb output shall
  • Intel W2600CR | Technical Product Specification - Page 35
    Intel® Server System R2000IP Product Family TPS Power Subsystem 3.6.11 Common Mode Noise The Common Mode noise on any output shall not exceed 350mV pk-pk over the frequency band of 10Hz
  • Intel W2600CR | Technical Product Specification - Page 36
    Power Subsystem Intel® Server System R2000IP Product Family TPS 3.6.16 Timing Requirements These are the timing requirements for the power supply operation. The 12V must rise from 10% to within regulation limits (Tvout_rise) within 5
  • Intel W2600CR | Technical Product Specification - Page 37
    Intel® Server System R2000IP Product Family TPS Power Subsystem Figure 21. Turn On/Off Timing . 3.7 Protection Circuits Protection circuits inside the power supply shall cause only the power supply's main outputs to shutdown. If the power supply latches off due to a protection circuit tripping,
  • Intel W2600CR | Technical Product Specification - Page 38
    Power Subsystem Intel® Server System R2000IP Product Family TPS +12V + 5Vsb 70A min; 78A max 4.5Amin; temperature hysteresis, so that the power supply will not oscillate on and off due to temperature recovery condition. The power supply shall alert the system of the OTP condition from the power
  • Intel W2600CR | Technical Product Specification - Page 39
    Intel® Server System R2000IP Product Family TPS Power Subsystem PSON# = High or Open Logic level low (power supply ON) Logic level high (power supply OFF) Source current, Vpson = low Power up delay:
  • Intel W2600CR | Technical Product Specification - Page 40
    Power Subsystem Intel® Server System R2000IP Product Family TPS Signal Type PWOK = High PWOK = Low Logic level low voltage Logic level high voltage 3.8.6 SMBALERT Output Signal SMBALERT signal is open drain output signal to give an alert when any problem happens on PMBUS*. 30 Revision 1.0
  • Intel W2600CR | Technical Product Specification - Page 41
    Intel® Server System R2000IP Product Family TPS Power Subsystem Table 29. SMBALERT Signal Characteristics Signal Type Open Drain Output Signal, Low active Logic level low voltage MIN MAX 0V 0.4V Logic level
  • Intel W2600CR | Technical Product Specification - Page 42
    Power Subsystem Intel® Server System R2000IP Product Family TPS Total Load 50% 0% Ishare Minimum 3.90V 0.00V Ishare Maximum Number of supplies following table puts boundaries on the expected data. When writing, command errors will be reported for data outside these parameter ranges. Table 32.
  • Intel W2600CR | Technical Product Specification - Page 43
    Intel® Server System R2000IP Product Family TPS Power Subsystem Address A1/A0 PMBus* Address 0/0 58h (B0h) 0/1 59h (B2h) 1/0 5Ah (B4h) 1/1 5Bh (B6h) 3.9.3 IPMI FRU Device Addressing The addressing method uses the 7 MSB
  • Intel W2600CR | Technical Product Specification - Page 44
    the system operating within supported maximum thermal limits, Intel® Server System R2000IP product family Power Budget and Thermal Configuration Guidelines Tool, available as a download online at Intel Intel® Server Board S2600IP (16 DIMM server board)  Memory slot 2 populated on all memory channels
  • Intel W2600CR | Technical Product Specification - Page 45
    Intel® Server System R2000IP Product Family TPS Thermal and Acoustic Management o Add-in cards with a available add-in card slot. o Add-in cards with a >200 LFM air flow requirement cannot be supported. o Note: Most PCI add-in cards have minimum air flow requirements of 100 LFM (0.5m/s). Some
  • Intel W2600CR | Technical Product Specification - Page 46
    Intel® Server System R2000IP Product Family TPS management technology (mechanism) is developed. Options reserved for end users to adjust parameter settings based on the actual system configuration and usage in BIOS interface with path: BIOS feature is reserved for manual adjustment to the minimum
  • Intel W2600CR | Technical Product Specification - Page 47
    Intel® Server System R2000IR consists six 60x38mm system fans providing cooling for all ingredients inside the enclosure. All the fans are Pulse Width Modulated (PWM) 4 wire/pin fans. The fan headers are connected to motherboard FAN reserved The Intel® Server System R2000IR supports up to 12x3.5''
  • Intel W2600CR | Technical Product Specification - Page 48
    Thermal and Acoustic Management Intel® Server System R2000IP Product Family TPS Disk/Optical SATA 3.5" (6x) Gfx/add-in card PCI-e card (3x) Others Roc - Typical operating mode 1: processor and HDD stressed. 4. TO2 - Typical operating mode 2: processor, memory, HDD stressed. 38 Revision 1.0
  • Intel W2600CR | Technical Product Specification - Page 49
    of use and supports several features.  Each fan is hot-swappable.  Each fan is designed for tool-less insertion and extraction from the fan assembly.  Fan speed for each fan is controlled by integrated platform management as controlled by the integrated BMC on the server board. As system thermals
  • Intel W2600CR | Technical Product Specification - Page 50
    Intel® Server System R2000IP Product Family TPS integrated BMC firmware 6-pin wire harness that connects to a matching connector on the server board. Table 36. System Fan Connector Pin-out Pin Signal Name will shut down. 4.6 Air Duct Module The chassis requires the use of an air duct module to
  • Intel W2600CR | Technical Product Specification - Page 51
    System R2000IP Product Family TPS System Storage and Peripheral Drive Bays 5. System Storage and Peripheral Drive Bays The Intel® Server System R2000IP4 product family has support for many storage device options, including:  Hot Swap 2.5'' Hard Disk Drives  Hot Swap 3.5'' Hard Disk Drives  SATA
  • Intel W2600CR | Technical Product Specification - Page 52
    System Storage and Peripheral Drive Bays Intel® Server System R2000IP Product Family TPS Figure 27. 2.5" Hard Drive Bay - 24 Drive Configuration The drive bay can support either SATA or SAS hard disk drives. Mixing of drive types within the hard drive bay is not supported. Hard disk drive type is
  • Intel W2600CR | Technical Product Specification - Page 53
    Intel® Server System R2000IP Product Family TPS System Storage and Peripheral Drive Bays Green Table 38. Drive Activity LED States Condition Power on with no drive activity Power on with drive activity Power on and drive spun down Power on and drive spinning up Drive Type SAS SATA SAS SATA SAS
  • Intel W2600CR | Technical Product Specification - Page 54
    Intel® Server System R2000IP Product Family TPS Label A B C D Description SMBus*-out cable connector - From Server board or other backplane 4-port Mini-SAS cable connectors SMBus*-in cable connector for multi-backplane support server board, add-in SAS/SATA RAID cards, or optionally installed SAS
  • Intel W2600CR | Technical Product Specification - Page 55
    , SATA only or SAS. Each 3.5" hard disk drive is mounted to a drive tray, allowing for hot swap extraction and insertion. Drive trays have a latching mechanism that is used to extract and insert drives from the chassis, and lock the tray in place. Figure 33. 3.5" Hard driver installation Revision
  • Intel W2600CR | Technical Product Specification - Page 56
    Intel® Server System R2000IP Product Family TPS Blink No access and no fault Hard Drive Fault has occured RAID rebuild in progress (1 Hz), Identify (2 Hz) Green Table down Power on and drive spinning up Drive Type SAS SATA SAS SATA SAS SATA SAS SATA Behavior LED stays on LED stays off LED
  • Intel W2600CR | Technical Product Specification - Page 57
    can be routed from matching connectors on the server board, add-in SAS/SATA RAID cards, or optionally installed SAS expander cards. Each mini-SAS connector will include a silkscreen identifying which drives the connector supports; Drives 0-3, Drives 4-7, and Drives 8-11. C - SMBus* Cable Connectors
  • Intel W2600CR | Technical Product Specification - Page 58
    Storage and Peripheral Drive Bays Intel® Server System R2000IP Product Family TPS Figure 36. Opitcal driver support 5.4 eUSB SSD Suport The system provides support for a eUSB SSD storage device. A 2x5-pin connector labeled "eUSB SSD" near the rear I/O section of the server board is used to plug
  • Intel W2600CR | Technical Product Specification - Page 59
    Intel® Server System R2000IP Product Family TPS System Storage and Peripheral Drive Bays Table 42. Intel® RAID Expander Card RES2SV240 Series Basic Feature Intel Order Code Embedded Processor Compatibility SAS/SATA Ports Firmware Enclosure Management Operating Temperature Operating Voltage Cables
  • Intel W2600CR | Technical Product Specification - Page 60
    connectors are attached to the SAS expander card. Please reference the Intel® Server System R2000IP Product Family Service Guide for cable routing diagrams illustrating a variety of different storage configurations. 5.5.2 24-Port and 36-Port Internal Intel RAID Expander Cards For large storage
  • Intel W2600CR | Technical Product Specification - Page 61
    Intel® Server System R2000IP Product Family TPS System Storage and Peripheral Drive Bays Figure 39. Internal SAS Expander Installation The following diagrams are used to help identify the mini-SAS connectors found on the SAS expander cards. Care should be taken when connecting connectors from the
  • Intel W2600CR | Technical Product Specification - Page 62
    Drive Bays Intel® Server System R2000IP Product Family TPS Figure 42. Internal 36-Port SAS Expander Card 0-3 4-7 A B 8-11 C 24-27 G 12-15 D 7 36-port SAS 6Gb 8 6 0 Expander 5 1 4 2 3 28-31 H 16-19 E 32-35 I 20-23 F Figure 43. 36-Port Expander SAS Connector/Drive Identification
  • Intel W2600CR | Technical Product Specification - Page 63
    are attached to the SAS expander card. Please reference the Intel® Server System R2000IP Product Family Service Guide for cable routing diagrams illustrating a variety of different storage configurations. 5.5.3 Protocol Support Each port on the expander cards support SAS devices, SATA II devices
  • Intel W2600CR | Technical Product Specification - Page 64
    Front Control Panel and I/O Panel Overview Intel® Server System R2000IP Product Family TPS 6. Front Control Panel and I/O Panel of the system. When BIOS detects that a monitor is attached to the front video connector, it disables the video signals routed to the on-board video connector on the back
  • Intel W2600CR | Technical Product Specification - Page 65
    the NMI button is pressed, it puts the server in a halt state and issues a non-maskable interrupt (NMI). This can be useful when performing diagnostics for a given issue where a memory download is necessary to help determine the cause of the problem. To prevent an inadvertent system halt, the actual
  • Intel W2600CR | Technical Product Specification - Page 66
    Intel® Server System R2000IP Product Family TPS single color (Green) and is capable of supporting different indicator states as defined in the the BIOS has not initialized the chipset. System power is on but Bios has not the on-board hard disk controllers. The server board also provides a header
  • Intel W2600CR | Technical Product Specification - Page 67
    load the proper Sensor Data Records for the server chassis onto the server board.  Make sure the latest system software is loaded on the server. This includes System BIOS, BMC Firmware, ME Firmware and FRUSDR. The latest system software can be downloaded from the Intel web site. Revision 1.0 57
  • Intel W2600CR | Technical Product Specification - Page 68
    Glossary Intel® Server System R2000IP Product Family TPS Glossary Word/Acronym ACA ANSI BMC BIOS CMOS D2D Peripheral Component Interconnect Printed Circuit Board Peripheral Component Interconnect Express* Test Power Supply Unit Random Access Memory Ring Indicate Single Connector Attachment Sensor
  • Intel W2600CR | Technical Product Specification - Page 69
    additional information:  Intel® Server Board S2600IP Technical Product Specification  Intel® Server System R2000IP Product Family Spares/Parts List and Configuration Guide  Intel® Server System R2000IP Service Guide  Intel® Server System R2000IP Quick Installation Guide  BIOS for EPSD Platforms
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
  • 53
  • 54
  • 55
  • 56
  • 57
  • 58
  • 59
  • 60
  • 61
  • 62
  • 63
  • 64
  • 65
  • 66
  • 67
  • 68
  • 69
Intel
®
Server System R2000IP
Product Family
Technical Product Specification
Intel order number G38158-002
Revision 1.0
May 2012
Enterprise Platforms and Services Division