Kenmore 464722309 Use and Care Guide
Kenmore 464722309 - 2 Burner Gas Grill Manual
 |
View all Kenmore 464722309 manuals
Add to My Manuals
Save this manual to your list of manuals |
Kenmore 464722309 manual content summary:
- Kenmore 464722309 | Use and Care Guide - Page 1
Use and Care Guide ® LiquidPropaneGasGrill Kenmore Model No. 415.16110800 This Grill is For Outdoor Use Only • Read this manual before cooking on grill. Failure to follow all manufacturer's instructions could result in fire or e×plosion which could cause property damage, personal injury or death. • - Kenmore 464722309 | Use and Care Guide - Page 2
appliance. 2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance. Call Grill Service Center For Help And Parts the messages found throughout the manual. Model Number Serial Number See ratinglabel on grill for serialnumber. Date Purchased - Kenmore 464722309 | Use and Care Guide - Page 3
For Your Safety Grill Service Center Product Record Information Safety Symbols Installation Safety Precautions Kenmore Grill Warranty Use and Care Parts List Parts Diagram Assembly Troubleshooting 2 2 2 2 2 3 4-10 11 12 13-24 25-27 Repair Protection Agreements Congratulations on making - Kenmore 464722309 | Use and Care Guide - Page 4
due to possible gas release from the safety relief valve. • if you see, smell or hear escaping gas, immediately get away from the LP tank/grill and call your fire off of LP tank collar, then lift LP tank up and off of support bracket, install safety cap onto LP tank valve. Always use cap and strap - Kenmore 464722309 | Use and Care Guide - Page 5
during leak test. • Do not use an open flame to check for gas leaks. Grill must be leak tested outdoors in a well-ventilated area, away from ignition sources such as gas fired or electrical appliances. During leak test, keep grill away from open flames or sparks. , Use a clean paintbrush and a 50/50 - Kenmore 464722309 | Use and Care Guide - Page 6
leak test by turning hand wheel clockwise. • Outdoor gas appliance is not intended to be installed in or on a boat. • Outdoor gas appliance is not intended to be installed in or on an RV. • Never attempt to attach this grill to the self-contained LP gas system of a camper trailer or motor home - Kenmore 464722309 | Use and Care Guide - Page 7
not use on or under balconies. • NEVER attempt to light burner with lid closed. A buildup of non-ignited gas inside a closed grill is hazardous. • Never operate grill with LP tank out of correct position specified in assembly instructions, • Always close LP tank valve and remove coupling nut before - Kenmore 464722309 | Use and Care Guide - Page 8
gas to clear and repeat the lighting procedure. 5. To Light Other Burners turn control knob to HI. If ignitor does not work, follow match lighting instructions. After Lighting: Turn knobs to HI position for 15 minutes to preheat grill " in the Troubleshooting Section. If burner does not light, - Kenmore 464722309 | Use and Care Guide - Page 9
burner and electrodes. See "Troubleshooting" if no click or spark. Valve Check • important: Make sure gas grill cleaner on plastic parts. Damage to and failure of parts can problems.Thespidersspinwebs,build nestsand layeggsin thegrill'sventuritube(s)obstructingthe flow of gas to the burner - Kenmore 464722309 | Use and Care Guide - Page 10
Burner Assembly Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting grill. 1. Turn gas off at control knobs and LP cylinder, 2. Remove cooking grate and vaporiser bar. 3. Under grill temperatures. Chill: Refrigerate prepared foods and leftovers - Kenmore 464722309 | Use and Care Guide - Page 11
2 49 2 50 1 51 1 52 4 53 1 54 1 55 1 56 1 57 1 58 1 59 1 60 2 61 4 62 1 63 1 1 1 1 Description Grate,Side Burner Part # 80009728 SidebumerClip WingNut 80015912 80015912 #8X3/8"Self-TapScrew 80015912 LowerHinge UpperHinge Lid Handle 80012696 80012695 80012224 TopLid 80015577 - Kenmore 464722309 | Use and Care Guide - Page 12
G ® _b ® \ ,# (_/-o 12°464810408 - Kenmore 464722309 | Use and Care Guide - Page 13
LeftLeg Placeone upperleg as shown. NOTE:Left front and left back legsdo not haveleg extenders. In front,attachupperleg, side braceand left front leg (curve)with #10-24x1-1/4"screw and #10-24flange nut. In back,attach upperleg,sidebraceand left back leg (straight)with #10-24x1-1/4"screw and #10- - Kenmore 464722309 | Use and Care Guide - Page 14
TanHkoEoxkctalunskieoxncWluirseionwire intolegswith openingfor LPcylinderon side braceside. \ Side Brace Largeropeningside TankExclusionWire D ULapypefrraonndt LleogwserdPoawnnelson the floor. Fit upperpanelwith two tabs betweenlegs.Attachwith #10-24x2"screws and #10-24 flange nuts. Fit - Kenmore 464722309 | Use and Care Guide - Page 15
Back Braces to Cart Removepreviouslyattachedscrewsand nutsfrom upper legsasshown.Attachback braceswith #10-24x1-1/4"screws and #10-24flange nuts. BackBrace / 12 #10-24xl -1/4" Screw Qty. 6 13 #10-24FlangeNut Qty.6 Remove screws and nuts to attach back brace 12 BackBrace Wheels - Kenmore 464722309 | Use and Care Guide - Page 16
, In back,attachupperfireboxsupportwith #10-24x2" screws and#10-24flange nuts, ControlPanel \ 17 ,,,_ 17 #10-24x2"Screw Qty.8 UpperFirebox Support 13 #10-24FlangeNut Qty.8 Valve/Hose/Regulatorand Electronic ignitionModule Attachvalve/hose/regulatoarssemblyto controlpanelwith #10-24x1/2"screws - Kenmore 464722309 | Use and Care Guide - Page 17
Heat Shield Attach heatshieldwith #10-24x1/2"screws and#10-24flange nuts. HeatShield 27 27 #10-24Xl/2S" crew Qty.2 13 #10-24FlangeNut Qty.2 Tank Retainer Inserttank retainerintoside braceand securewith wingscrew. 30 WingScrew Qty.1 S Retainer 464810408 • 17 - Kenmore 464722309 | Use and Care Guide - Page 18
Firebox and Control Knobs Placeburnerassemblyintofirebox (A).Fastenthe burnerassemblyto thefirebox using5ramfiber washers and #10-24x 1/2" machine screws. Placefireboxontoupperfireboxsupportswith burnertubes belowheatshield.Makesure burner tubes are correctly engaged. If burneris notleveledfrom left - Kenmore 464722309 | Use and Care Guide - Page 19
Shelves Insertmountingbracketsintoside shelfsupportswith #10-24x1/2"screws (A). Attachbackof leg with 1/4"-20x1-1/4"screws and!/4"-20 flange nuts, Donotfully tighten.Attachmountingbracketstofront of leg with 1/4"-20x1/2"screws (B). Fullytightenall screws. Repeatabovestepsto attachsideburnershelf to - Kenmore 464722309 | Use and Care Guide - Page 20
Attachsideburnerwith wing nut and 5mm ID 9mm ODfiber washer. Insertone end of burnerclip intohole in sidebumertube with #10-24xl/2"screwsand #10-24nuts (E). SideburnerValve Sideburner Correctly assembled burner-to-valve engagement D SidebumerGrate-/J_@ SideburnerIgnitorWire 6O #8-32x3/8" Screws - Kenmore 464722309 | Use and Care Guide - Page 21
5mmID, 19ramODflat washersand #10-24x3/4"screws. Attachupperhingesto backof lid with #10-24x1/2"screws, 5ramfiber washers and #10-24flange nuts. Hingesshouldcurve downwardwhen properlyinstalled. Handte_ iii _ 5.5mmFiberWashers 27 #10-24xl/2" Screws Qty:4 34 13 5mm FiberWashers #10-24FlangeNut - Kenmore 464722309 | Use and Care Guide - Page 22
Lid Place lid assembly onto firebox, aligning hinges. Hinges on lid fit inside hinges on firebox. Secure using two hinge pins and hitch pins (See inset ). 10 HingePins Qty.2 11 HitchPins Qty.2 Heat Diffuser Place heat diffuser over screws in firebox. Heat Diffuser 22. 464810408 - Kenmore 464722309 | Use and Care Guide - Page 23
Cooking Grate Placegrateintofirebox. Cooking Grate Swing Away } Insertendsof SwingAway pivotwire intoholesin sidesof grill lid.Insertendsof SwingAway legwire into holesin sidesof firebox. NOTE:Pivotand legwires,runningside-to-side,shouldbe underwires runningfront-to-back.If pivotand leg wiresare on - Kenmore 464722309 | Use and Care Guide - Page 24
.See Use and Care section to correctly Leak Test and perform the Burner Flame Check. Tankcollaropeningmustface to front of grill.Loosenwing nutfrom tank retainerbracket.Set bottomof tank into notchesin the tank bracket.Fit tank retainerbracketontotank collarand tightenthe wingnut. m CAUTioZNL - Kenmore 464722309 | Use and Care Guide - Page 25
Troubleshooting EMERGENCIES: if a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Gasleakingfrom cracked/cut/burned hose. , Damagedhose. , Turnoff gas fire is out and grill is cold, removeburner pointingtowardport holein burner.The distanceshouldbe - Kenmore 464722309 | Use and Care Guide - Page 26
positionand letfire burn out.After grill cools,removeand cleanall parts. Flashback... , Burnerand/orburnertubesare blocked. (firein burnertube(s)). , Turnknobsto OFF.Cleanburnerand/orburnertubes.See burner cleaningsectionof Use andCare manual. Unabletofill LP tank. , Somedealershaveolder fill - Kenmore 464722309 | Use and Care Guide - Page 27
Troubleshooting - Electronic ignition SECTIONI Nosparksappearat anyelectrodeswhen ignitionbuttonis pushed;no noisecan be heardfrom spark /ornot atfull strength , Outputlead connectionsnot connected. . Arcingto grill away from burner(s). , Weak battery. . Electrodesare wet. . Electrodescrackedor - Kenmore 464722309 | Use and Care Guide - Page 28
appliances, iiiiiiiiiiiiiiiiiiiiiiiliaiiiwiiiniiiiaiind garden equipment, or heating and cooling systems, iiiiiiiiiiiiiiiiiiiiiiiiiiiiiiiiiiiinomatterwhomadeit, nomatterwhosoldit! iiiiiiiiiiiiiiiiiiiiiiiiiiiiiiiiiiii Forthe replacement parts 784-6427) Au Canada pour service en francais: 1-800-LE-
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
 |
 |
Use and Care Guide
LiquidPropaneGasGrill
Kenmore
Model
No. 415.16110800
This Grill
is
For
Outdoor Use Only
®
•
Read
this
manual
before
cooking
on
grill.
Failure
to follow
all
manufacturer's
instructions
could
result
in
fire
or
e×plosion
which
could
cause
property
damage,
personal
injury
or death.
•
Combustion
by=products
produced
when
using
this
product
contain
chemicals
known
to the
State
of
California
to cause
cancer,
birth
defects,
or other
reproductive
harm.
CAUTION
•
Read
and
follow
all Safety
Statements,
Assembly
Instructions
and
Use
& Care
Directions
before
attempting
to assemble
and
cook.
•
Some
parts
may
contain
sharp
edges,
especially
as noted
in
these
instructions.
Wear
protective
gloves
if
necessary.
•
Parts
• Assembly
• Safety
Rules
• Use and Care
•
Troubleshooting
Assembly
Questions?
Call
1 =800=241 =7548
Parts
Ordering:
Call
1 =800=4=MY=HOME ®
To
InstalledAssembler:
Leave
these
instructions
with
consumer.
To Consumer:
Keep
this
manual
for
future
reference.
Sears,
Roebuck
and
Co.,
Hoffman
Estates,
IL
60179
U.S.A.
©2007Sears,RoebuckandCo.,AllRightsReserved
Printed in China
464810408
•
80015569
•
11-15-07