LG R580-U.ARC3BA9 Service Manual

LG R580-U.ARC3BA9 Manual

Get LG R580-U.ARC3BA9 PDF manuals and user guides View all LG R580-U.ARC3BA9 manuals
Add to My Manuals
Save this manual to your list of manuals

LG R580-U.ARC3BA9 manual content summary:

  • LG R580-U.ARC3BA9 | Service Manual - Page 1
    P/N :MFL62539202 REV.18 Service Manual Model : R580, RB580, R560, RB560 Series 2011. 05. 12 Copy Rightⓒ2011 LG Electronic inc, DigitalMate Co,.Ltd. (LGE Internal use only) 1
  • LG R580-U.ARC3BA9 | Service Manual - Page 2
    Contents Ch 1. Service information Ch 2. Locations Ch 3. System information · Specification · Model configuration · Power system checkout · Numeric error codes · Error messages · LCD-related symptoms · Indeterminate problems Ch 5. Removing and replacing a part (FRU) Ch 6. Part list · Part list ·
  • LG R580-U.ARC3BA9 | Service Manual - Page 3
    listed in this Use the following strategy to prevent unnecessary expense for replacing and servicing parts 1. If you are instructed to replacing a part but the replacement does not correct the problem, reinstall the original part before you continue. 2. Some computers have both a processor board and
  • LG R580-U.ARC3BA9 | Service Manual - Page 4
    Ch1. Service information 1-2. Safety notices Warning Before the computer is powered-on after part (FRU) replacement, make sure all screws, springs, and other small parts are in
  • LG R580-U.ARC3BA9 | Service Manual - Page 5
    and the customer's personnel are not in a hazardous position. · Place removed covers and other parts in a safe place, away from all personnel, while you are servicing the machine. · Keep your tool box away from walk areas so that other people will not trip over it. · Do not wear loose clothing that
  • LG R580-U.ARC3BA9 | Service Manual - Page 6
    Ch1. Service information „ Electrical safety Observe the following rules when working on electrical equipment. Important Use only approved tools and test equipment. Some hand tools have handles
  • LG R580-U.ARC3BA9 | Service Manual - Page 7
    Ch1. Service information · Stand on suitable rubber mats (obtained locally, if necessary) to insulate you from grounds such as metal floor strips and machine frames. · Observe the special safety precautions when you work with very high voltages. These instructions are in the safety sections of
  • LG R580-U.ARC3BA9 | Service Manual - Page 8
    required safety items were installed to protect users and service personnel from injury. This guide addresses only those items. You should use good hazard could be and whether you can continue without first correcting the problem. · Consider these conditions and the safety hazards they present 1.
  • LG R580-U.ARC3BA9 | Service Manual - Page 9
    useful when handling ESD-sensitive devices. 5. Select a grounding system, such as those listed below, to provide protection that meets the specific service requirement. Note The use of a grounding system is desirable but not required to protect against ESD damage. a. Attach the ESD ground clip
  • LG R580-U.ARC3BA9 | Service Manual - Page 10
    . Opening the CD-ROM drive, DVD-ROM drive or the other optical storage device could result in exposure to hazardous laser radiation. There are no serviceable parts inside those drives. Do not open Danger Emits visible and invisible laser radiation when open. Do not stare into the beam , do not view
  • LG R580-U.ARC3BA9 | Service Manual - Page 11
    you go to the checkout guide, be sure to read this section. Important Notes · Only trained personnel certified by LG should service the computer. · Read under warranty and some symptoms that might indicate that the system was subjected to stress beyond normal use. Before checking problems with
  • LG R580-U.ARC3BA9 | Service Manual - Page 12
    Ch1. Service information The followings are not covered under warranty : · CD panel cracked from the application of excessive Damaged or bent diskette eject button · Fusses blown by attachment of a non-supported device · Forgotten computer password (making the computer unusable) · Sticky keys caused
  • LG R580-U.ARC3BA9 | Service Manual - Page 13
    Chapter 2. Locations Ch2. Locations ■ Left View 1. Fan louvers 2. VGA Port 3. LAN Port 4. Modem Port 5. HDMI Port 6. e-SATA Port(USB-combo) 7. Multi Card Slot(xD/SD/MS/MS Pro) 8. Express Card Slot ■ Right View 9. Microphone Port 10. Headphone Port 11. USB Port 12. Optical Disk Drive 13. Power
  • LG R580-U.ARC3BA9 | Service Manual - Page 14
    ■ Front Back ① 15. Fan louvers ■ Front View Ch2. Locations ② ④ ③ 16. Built-in Microphone(May vary depending on model.) 17. Smart Cam(May vary depending on model.) 18. Power Button 19. Mute Button 20. Volume Down Button 21. Volume Up Button 22. SRS Button 23. Keyboard 24. Touchpad 25. Stereo
  • LG R580-U.ARC3BA9 | Service Manual - Page 15
    · Intel® Core™2 Duo / Pentium® Dual‐Core / Celeron® Dual‐Core / Celeron® Processors (L2 Cache Size: 1MB/2MB/3MB/6MB, FSB:667/800/1066MHZ ) are supported. The user must not replace or expand the CPU capacity arbitrarily. The CPU capacity differs depends on model type. - Main Memory · Maximum Capacity
  • LG R580-U.ARC3BA9 | Service Manual - Page 16
    ※ The specifications may differ depending on the model type and the video driver. - Sound · Realtek High Definition Audio Codec (ALC262) HDMI is supported · Built-in Stereo Speakers - LAN · Realtek RTL8103/8111 10/100/1000 PCI Express Fast Ethernet Controller · RJ 45 Jack ※ Specifications may differ
  • LG R580-U.ARC3BA9 | Service Manual - Page 17
    Chapter 3. System information ■ System Block Diagram 17
  • LG R580-U.ARC3BA9 | Service Manual - Page 18
    Chapter 3. System information „ Fn key combinations The following table shows the function of each combination of Fn with a function key. Function of Fn keys has nothing to do with Operating System. Fn + F1 Fn + F2 Customizable hot keys. (Configurable through OSD settings) Customizable hot keys.
  • LG R580-U.ARC3BA9 | Service Manual - Page 19
    Ch3. System information „ Status indicators The system status indicators show the status of the computer 1 . Power Lamp: • Blinking: System Standby • On: The system is running on the AC power or battery. • Off: The system is turned off or in Hibernates. 2. AC Power and Battery Status Lamp • Orange:
  • LG R580-U.ARC3BA9 | Service Manual - Page 20
    /Bluetooth lamp may operate differently depending on model type. ※ The Wireless LAN card and the Bluetooth device are optional, and so it may not be supported in some models. . 20
  • LG R580-U.ARC3BA9 | Service Manual - Page 21
    Ch3. System information ■ BIOS Flash You Can update BIOS using USB Device (FDD/USB Memory) Because this system is not equipped with any USB Device, you have to use an external USB Device for a BIOS update. In order to boot up with an USB Device, please set Removable Device as the first boot up drive
  • LG R580-U.ARC3BA9 | Service Manual - Page 22
    Ch3. System information 10. Press [F2] Key, then you can see the BIOS SETUP UTILITY screen as below. 11. It selects the :" Load Optimal Dafault" and it summons a BIOS settings at initial value. 22
  • LG R580-U.ARC3BA9 | Service Manual - Page 23
    Ch3. System information 12. It selects the "Exit & Saving Change" and it stores system a settings and the reboot 23
  • LG R580-U.ARC3BA9 | Service Manual - Page 24
    when BIOS should be updated. 2. BIOS will include both System BIOS and EC(Embedded Controller) BIOS. 3. Service center can download BIOS file from GCSC and update BIOS according to below procedure. 4. Service center will make Bootable Image CD with Image file(*.iso) as below a. Insert empty disc to
  • LG R580-U.ARC3BA9 | Service Manual - Page 25
    Ch3. System information c. Select "Disc Image or Saved Project" d. Select File Format as "Image Files(*.iso)". 25
  • LG R580-U.ARC3BA9 | Service Manual - Page 26
    Ch3. System information e. Open Image File(*.iso) which is sent from LGE f. Tab Burn then burning will be started 26
  • LG R580-U.ARC3BA9 | Service Manual - Page 27
    Ch3. System information g. Burn process completed as below, and tab "OK 27
  • LG R580-U.ARC3BA9 | Service Manual - Page 28
    Ch3. System information „ BIOS/EC Flash Process 1. Insert Bootable CD in PC, and Turn it on, then PC will boot by DOS mode as below (If the EC is not correct or old version, then automatically update EC first and reboot again) 2. Select Boot mode, then press "Enter" Key. 3. Type in LOGO SETTING at
  • LG R580-U.ARC3BA9 | Service Manual - Page 29
    Ch3. System information 4. Type in Mode Name at the "WIP ID :" then press Enter key (You must use Capital Letter) (You can see the Model Name in ID Label at the bottom Case of PC: "M/N: LMXX-XXXX") 5. Type in Serial No at the "WIP ID :" then press Enter key (You must use Capital Letter) (You can see
  • LG R580-U.ARC3BA9 | Service Manual - Page 30
    Ch3. System information 5. After flashing is completed, you can see the "PASS" on your screen, and reboot your PC 30
  • LG R580-U.ARC3BA9 | Service Manual - Page 31
    Ch3. System information „ BIOS Setup BIOS (Basic Input and Output System) Setup saves the system configuration in CMOS RAM, and check the configurations during startup. Use the BIOS Setup Utility to change and save the system environment, hardware configurations, power saving mode, etc. · Open the
  • LG R580-U.ARC3BA9 | Service Manual - Page 32
    Ch3. System information „ Using the keys The keys used in the BIOS Setup Utility and their functions are described at the bottom. ·, + : General Help Display the descriptions of the keys used in the setup utility. ·, : Select Item Navigate and select items in the setup utility. The selected
  • LG R580-U.ARC3BA9 | Service Manual - Page 33
    „ Main menu Ch3. System information · System Time Current time. To change the value, press or key. · System Date Current date. To change the value, press or key. · SATA Hard Drive This shows the description of the drive connected to the SATA port. To change the settings of the
  • LG R580-U.ARC3BA9 | Service Manual - Page 34
    any of Normal, Silent, and Cool for the operating speed of CPU cooling fan (for DC power). · Mute button option Set whether or not to support the Mute function (Fn + F9) during the system startup. · Internal Devices Configurations Set whether or not to use the devices such as Auiod, LAN, Wireless
  • LG R580-U.ARC3BA9 | Service Manual - Page 35
    „ Security menu Ch3. System information · Supervisor Password The password setting prevents not allowed users from using the notebook computer. The password is not set when starting the system for the first time. When the system is turned on, any other user cannot change the BIOS settings without
  • LG R580-U.ARC3BA9 | Service Manual - Page 36
    „ Boot menu Ch3. System information · Quick Boot Set whether or not to use Quiet Boot. · PXE Boot to LAN Set whether or not to use the HDD password. · Boot Device Priority Select the desired device drive by using the arrow buttons and change its booting sequence by using the [+] or [-] key. 36
  • LG R580-U.ARC3BA9 | Service Manual - Page 37
    „ Info menu Ch3. System information · BIOS Version This shows the Version of BIOS. · KBC Version This shows the Version of KBD firm ware. · Serial Number This shows the serial number of the product. · SLP 2.0 The Vista OS protection device will be able to use from LG. · CPU Type This shows the
  • LG R580-U.ARC3BA9 | Service Manual - Page 38
    „ Exit menu Ch3. System information · Exit & Save Change Save the changes you have made and exit the utility. · Exit & Discard Changes Exit the utility without saving the changes you have made. · Load Optimal Defaults This changes the parameters in the Setup menu to the factory default settings.
  • LG R580-U.ARC3BA9 | Service Manual - Page 39
    Also contains computer identification and user identification, which are used to match computers and users during the restoration process. • Manually written Backup Archive (e.g. SPBackupArchive.xml): Created by Security Platform User. Contains credentials and settings of one Security Platform
  • LG R580-U.ARC3BA9 | Service Manual - Page 40
    Backup Archives. • PSD backup file (e.g. SpPSDBackup.fsb): A backup copy of the PSD image file may be created during a Security Platform User's manual backup. ■ Restoration Cases Depending on the type of emergency there are different restoration cases Restoration Case Broken hard disk or lost
  • LG R580-U.ARC3BA9 | Service Manual - Page 41
    for all users (including Security Platform Credentials and Settings, Emergency Recovery and PSD configuration settings). How to backup ("Manual Backup") User Task: Run backup manually for the current user. How to restore Administrative Task: Prepare restoration for certain users. User Task: Run
  • LG R580-U.ARC3BA9 | Service Manual - Page 42
    current user account has administrative rights. Click here to start a manual backup of your Security Platform Settings and credentials. If you have set up or the user is not set up. Click here to start a manual restore of archived Security Platform Settings and credentials. If you have a backup of
  • LG R580-U.ARC3BA9 | Service Manual - Page 43
    lists symptoms and errors and their possible causes. The most likely cause is listed first. Note If replacing a part (FRU) does not solve the problem, put the original part back in the computer. Do not replace a non-defective FRU. „ Power system checkout · To verify a symptom, do the following
  • LG R580-U.ARC3BA9 | Service Manual - Page 44
    Ch4. Symptom-to-part index To check the AC adapter, do the following : 1. Unplug the AC adapter cable from the computer. Pin 2. Measure the output voltage at the plug of the 1 AC adapter cable. See the following figure : 2 3. If the voltage is not correct, remove the power code 1 2 form AC
  • LG R580-U.ARC3BA9 | Service Manual - Page 45
    · If the voltage is not correct, replace the AC adapter. · If the voltage is acceptable, do the following : 1. Replace the system board. 2. If the problem persists, check the AC adapter whether it is correct product or not. Note Noise from the AC adapter does not always indicate a defect. · Checking
  • LG R580-U.ARC3BA9 | Service Manual - Page 46
    Ch4. Symptom-to-part index · The Characteristics of the battery pack 1. Self-discharge The battery gradually loses its power over time without ever being used. 2. Periodic full discharge / charge Frequent recharge of the battery pack can reduce the capacity of the battery pack. When this happens,
  • LG R580-U.ARC3BA9 | Service Manual - Page 47
    Ch4. Symptom-to-part index · To check the battery pack, do the following : 1. Power off the computer. 2. Remove the battery pack and measure the voltage between battery terminals 1(-) and 5(+). See the following figure : Terminal Voltage (V dc) 1 Ground(-) 5(+) 4 3 2 1(-) 5 +0V ~ +12.6V (6
  • LG R580-U.ARC3BA9 | Service Manual - Page 48
    Ch4. Symptom-to-part index „ Numeric error codes Symptom / Error 0200 Fixed disk failure (The hard disk is not working) FRU or action, in sequence 1.Reset the hard-disk drive. 2.Load Setup Defaults in BIOS Setup Utility. 3.Hard-disk drive. 4.System board. 0210 Stuck Key error 0211 Keyboard error
  • LG R580-U.ARC3BA9 | Service Manual - Page 49
    Ch4. Symptom-to-part index Symptom / Error 0251 System CMOS checksum bad - System CMOS checksum is not correct. - Default configuration used. 0252 Password checksum bad - The password is cleared. 0260 System timer error 0271 Check date and time settings - Date and time error. 0280 Previous boot
  • LG R580-U.ARC3BA9 | Service Manual - Page 50
    Ch4. Symptom-to-part index Symptom / Error 02F7 Fail - Safe timer NMI failed 0611 IDE configuration changed 0612 IDE configuration error 0613 Com A configuration changed 0614 Com A configuration error 0615 Com B configuration changed 0616 Com B configuration error 0617 Floppy configuration changed
  • LG R580-U.ARC3BA9 | Service Manual - Page 51
    „ Error message Ch4. Symptom-to-part index Symptom / Error Device address conflict. FRU or action, in sequence 1. Load Setup Defaults in BIOS Setup Utility. 2. Backup battery. 3. System board. Allocation error for device. 1. Load Setup Defaults in BIOS Setup Utility. 2. Backup battery. 3.
  • LG R580-U.ARC3BA9 | Service Manual - Page 52
    Ch4. Symptom-to-part index „ LCD-related symptoms Note Before removing or disassembling LCD, power off the computer, unplug all power cords from electrical outlets, remove the battery pack also. Symptom / Error LCD screen becomes dark suddenly. Nothing displayed on LCD screen. FRU or action, in
  • LG R580-U.ARC3BA9 | Service Manual - Page 53
    FRUs that have no defects). · Verify that all attached devices are supported by the computer. · Verify that the power supply being used at computer. 4. Power on the computer. 5. Determine whether the problem has changed. 6. If the problem does not recur, reconnect the removed devices one at a time
  • LG R580-U.ARC3BA9 | Service Manual - Page 54
    Ch5. Removing and replacing a part Chapter 5. Removing and replacing a part (FRU) Danger Before removing any FRU, power off the computer, unplug all power cords from electrical outlets, remove the battery pack, and then disconnect any interconnecting cables. Caution Before the computer is powered on
  • LG R580-U.ARC3BA9 | Service Manual - Page 55
    Ch5. Removing and replacing a part ■ 1010 Battery Pack 1. Push the battery latch in the direction shown below; then slide the battery pack out of the slot. 2. Remove the Battery Pack. 55
  • LG R580-U.ARC3BA9 | Service Manual - Page 56
    Ch5. Removing and replacing a part ■ 1020 Memory ※ Remove the following parts in order before replacing this part a. Battery Pack(1010) 1. Remove the 3 screw. 2. Remove the Memory Cover. 56
  • LG R580-U.ARC3BA9 | Service Manual - Page 57
    Ch5. Removing and replacing a part 3. Remove the Hook. Hook Hook Hook Hook 4. Remove the Memory. 57
  • LG R580-U.ARC3BA9 | Service Manual - Page 58
    Ch5. Removing and replacing a part ■ 1030 HDD ※ Remove the following parts in order before replacing this part a. Battery Pack(1010) 1. Remove the 2 Screw. 2. Remove the HDD Cover. 58
  • LG R580-U.ARC3BA9 | Service Manual - Page 59
    Ch5. Removing and replacing a part 3. Remove the HDD 4. Remove the 4 Screw. No. FRU No. Specification Qty 1 FAB30479801 (M3.0*3.0MM) White 4EA 59
  • LG R580-U.ARC3BA9 | Service Manual - Page 60
    Ch5. Removing and replacing a part 5. Remove the HDD Shield. 60
  • LG R580-U.ARC3BA9 | Service Manual - Page 61
    Ch5. Removing and replacing a part ■ 1040 Wi-Fi Cover ※ Remove the following parts in order before replacing this part a. Battery Pack(1010) 1. Remove the 1 Screw. 2. Remove the Wi-Fi Cover. 61
  • LG R580-U.ARC3BA9 | Service Manual - Page 62
    Ch5. Removing and replacing a part ■ 1050 WLAN Module ※ Remove the following parts in order before replacing this part Battery Pack(1010), b. Wi-Fi Cover(1040) 1. Remove the Antenna Cable 2 Screw. 2. Remove the 1 Screw. No. FRU No. Specification Qty 1 FAB30208501 (M2.0*3.0MM) White 1EA 62
  • LG R580-U.ARC3BA9 | Service Manual - Page 63
    Ch5. Removing and replacing a part 3. Remove the WLAN Module. 63
  • LG R580-U.ARC3BA9 | Service Manual - Page 64
    Ch5. Removing and replacing a part ■ 1060 Turbo Memory ※ Remove the following parts in order before replacing this part Battery Pack(1010), b. Wi-Fi Cover(1040) 1. Remove the 1 Screw. No. FRU No. 1 MM20030ICI3 2. Remove the Turbo Memory. Specification Qty (M2.0*3.0MM) White 1EA 64
  • LG R580-U.ARC3BA9 | Service Manual - Page 65
    Ch5. Removing and replacing a part ■ 1070 ODD ※ Remove the following parts in order before replacing this part a. Battery Pack(1010) 1. Remove the 1 Screw. No. FRU No. Specification Qty 1 FAB30479701 (M2.5*6.5MM) black 1EA 2. It uses JIG and pushes separates with arrow ticket direction. 65
  • LG R580-U.ARC3BA9 | Service Manual - Page 66
    Ch5. Removing and replacing a part 3. Remove the ODD. 4. Remove the ODD Bezel. Bezel 66
  • LG R580-U.ARC3BA9 | Service Manual - Page 67
    Ch5. Removing and replacing a part ■ 1080 Retainer/Keyboard ※ Remove the following parts in order before replacing this part a. Battery Pack(1010) 1. Remove the 6 Screw.. No. FRU No. 1 FAB30479701 2 FAB30255101 2. It uses JIG and it removes the Hooks. Specification Qty (M2.5*6.5MM) black
  • LG R580-U.ARC3BA9 | Service Manual - Page 68
    Ch5. Removing and replacing a part 3. Remove the 2 Screw. No. FRU No. 1 FAB30255101 4. Remove the Retainer/Keyboard Cable. Specification Qty (M2.5*3.0MM) black 2EA Cable Cable 68
  • LG R580-U.ARC3BA9 | Service Manual - Page 69
    Ch5. Removing and replacing a part 5. Remove the Keyboard. 6. Remove the Retainer. 69
  • LG R580-U.ARC3BA9 | Service Manual - Page 70
    Ch5. Removing and replacing a part ■ 1090 Display Module ※ Remove the following parts in order before replacing this part a. Battery Pack(1010), b. Retainer/Keyboard (1080) 1. Remove the 4 Screw. No. 1 2 2. Remove the Cable. FRU No. FAB30479701 FAB30255101 Specification Qty (M2.5*6.5MM) black
  • LG R580-U.ARC3BA9 | Service Manual - Page 71
    Ch5. Removing and replacing a part 3. Remove the Display Module. 71
  • LG R580-U.ARC3BA9 | Service Manual - Page 72
    Ch5. Removing and replacing a part ■ 1100 Button Sub Board ※ Remove the following parts in order before replacing this part a. Battery Pack(1010), b. Retainer/Keyboard (1080), c. Display Module(1090) 1. Remove the 1 Screw. Cable 2. Remove the Button Sub Board. 72
  • LG R580-U.ARC3BA9 | Service Manual - Page 73
    Ch5. Removing and replacing a part ■ 1120 Keydeck ※ Remove the following parts in order before replacing this part a. Battery Pack(1010), b. Retainer/Keyboard (1080), c. Display Module(1090), d. Button Sub Board(1100) 1. Remove the 10 Screw. No. FRU No. Specification Qty 1 FAB30479701 (M2
  • LG R580-U.ARC3BA9 | Service Manual - Page 74
    Ch5. Removing and replacing a part 3. Remove the Keyboard deck. 74
  • LG R580-U.ARC3BA9 | Service Manual - Page 75
    Ch5. Removing and replacing a part ■ 1130 USB(R) Sub Board ※ Remove the following parts in order before replacing this part a. Battery Pack(1010), b. Retainer/Keyboard (1080), c. Display Module(1090), d. Button Sub Board(1100) e. Keydeck(1120) 1. Remove the Cable and 2 Screw. Cable Cable No. FRU
  • LG R580-U.ARC3BA9 | Service Manual - Page 76
    Ch5. Removing and replacing a part ■ 1140 Bluetooth Module ※ Remove the following parts in order before replacing this part a. Battery Pack(1010), b. Retainer/Keyboard (1080), c. Display Module(1090), d. Button Sub Board(1100) e. Keydeck(1120) 1. Remove the Bluetooth. 2. Remove the Bluetooth Module.
  • LG R580-U.ARC3BA9 | Service Manual - Page 77
    Ch5. Removing and replacing a part ■ 1150 Touch Pad ※ Remove the following parts in order before replacing this part a. Battery Pack(1010), b. Retainer/Keyboard (1080), c. Display Module(1090), d. Button Sub Board(1100) e. Keydeck(1120) 1. Remove the 1 Connector. 2. Remove the Touch Pad. Connector
  • LG R580-U.ARC3BA9 | Service Manual - Page 78
    Ch5. Removing and replacing a part ■ 1160 Mainboard ※ Remove the following parts in order before replacing this part a. Battery Pack(1010), b. Retainer/Keyboard (1080), c. Display Module(1090), d. Button Sub Board(1100) e. Keydeck(1120) , f. USB(R) Sub Board(1130) 1. Remove the Connector/Cable.
  • LG R580-U.ARC3BA9 | Service Manual - Page 79
    Ch5. Removing and replacing a part 3. Remove the Mainboard Case. 79
  • LG R580-U.ARC3BA9 | Service Manual - Page 80
    Ch5. Removing and replacing a part ■ 1170 CPU/GPU Fan Assembly ※ Remove the following parts in order before replacing this part a. Battery Pack(1010), b. Memory(1020) 1. Remove the 7 Screw. Cable Fix Fix 2. Remove the CPU/GPU Fan Assembly. 80
  • LG R580-U.ARC3BA9 | Service Manual - Page 81
    Ch5. Removing and replacing a part ■ 1180 CPU ※ Remove the following parts in order before replacing this part a. Battery Pack(1010), b. Retainer/Keyboard (1080), c. Display Module(1090), d. Button Sub Board(1100) e. Keydeck(1120) , f. Mainboard(1160) , g. CPU/GPU Fan Assembly(1170) 1. Remove the
  • LG R580-U.ARC3BA9 | Service Manual - Page 82
    Ch5. Removing and replacing a part ■ 1190 Modem Module ※ Remove the following parts in order before replacing this part a. Battery Pack(1010), b. Retainer/Keyboard (1080), c. Display Module(1090), d. Button Sub Board(1100) e. Keydeck(1120) , f. Mainboard(1160) 1. Remove the 2 Screw and Cable. Cable
  • LG R580-U.ARC3BA9 | Service Manual - Page 83
    Ch5. Removing and replacing a part ■ 1200 AC Connector ※ Remove the following parts in order before replacing this part a. Battery Pack(1010), b. Retainer/Keyboard (1080), c. Display Module(1090), d. Button Sub Board(1100) e. Keydeck(1120) 1. Remove the 2 Screw and Cable. Cable 2. Remove the AC
  • LG R580-U.ARC3BA9 | Service Manual - Page 84
    Ch5. Removing and replacing a part ■ 1210 Speaker ※ Remove the following parts in order before replacing this part a. Battery Pack(1010), b. Retainer/Keyboard (1080), c. Display Module(1090), d. Button Sub Board(1100) e. Keydeck(1120) , f. Mainboard(1160) 1. Remove the 2 Screw. 2. Remove the Speaker
  • LG R580-U.ARC3BA9 | Service Manual - Page 85
    Ch5. Removing and replacing a part ■ 1220 LCD Front Case ※ Remove the following parts in order before replacing this part a. Battery Pack(1010), b. Retainer/Keyboard(1080), c..Keydeck(1120) 1. Remove the 4 Rubber and 4 Screw . No. FRU No. Specification Qty 1 FAB30479701 (M2.5*6.5MM) black
  • LG R580-U.ARC3BA9 | Service Manual - Page 86
    Ch5. Removing and replacing a part 3. Remove the Hinge Cap. 86
  • LG R580-U.ARC3BA9 | Service Manual - Page 87
    Ch5. Removing and replacing a part ■ 1230 LCD Assembly ※ Remove the following parts in order before replacing this part a. Battery Pack(1010), b. Retainer/Keyboard (1080), c. Display Module(1090 ) d. LCD Front Case(1220) 1. Remove the 4 Screw. No. FRU No. 1 FAB30479701 2. Remove the LCD
  • LG R580-U.ARC3BA9 | Service Manual - Page 88
    Ch5. Removing and replacing a part ■ 1240 LCD Panel Bracket ※ Remove the following parts in order before replacing this part a. Battery Pack(1010), b. Retainer/Keyboard (1080), c. Display Module(1090 ) d. LCD Front Case(1220) e. LCD Assembly(1230) 1. Remove the 4 Screw. No. FRU No. 1 FAB30208501
  • LG R580-U.ARC3BA9 | Service Manual - Page 89
    Ch5. Removing and replacing a part ■ 1250 LCD Cable ※ Remove the following parts in order before replacing this part a. Battery Pack(1010), b. Retainer/Keyboard (1080), c. Display Module(1090 ) d. LCD Front Case(1220) e. LCD Assembly(1230), f. LCD Panel Bracket(1240) 1. Remove the LCD Cable. Cable
  • LG R580-U.ARC3BA9 | Service Manual - Page 90
    Ch5. Removing and replacing a part ■ 1260 Web Cam Module ※ Remove the following parts in order before replacing this part a. Battery Pack(1010), b. Retainer/Keyboard (1080), c. Display Module(1090 ) d. LCD Front Case(1220) 1. Remove the Web Cam Module. 90
  • LG R580-U.ARC3BA9 | Service Manual - Page 91
    Ch5. Removing and replacing a part ■ 1270 Wireless ANT ※ Remove the following parts in order before replacing this part a. Battery Pack(1010), b. Retainer/Keyboard (1080), c. Display Module(1090 ) d. LCD Front Case(1220) e. LCD Assembly(1230), f. LCD Panel Bracket(1240) 1. Remove the Wireless Module
  • LG R580-U.ARC3BA9 | Service Manual - Page 92
    Ch6. Part lists Chapter 6. Part lists Category Loc. No. NMLB01 NMLB01 NMLB01 NMLB01 LG P/N EBR63154402 EBR63154502 EBR63154401 EBR63154501 NMLB01 EBR63154403 NMLB01 EBR63154404 NMLB01 EBR63154503 NMLB01 EBR63154504 NMLB01 EBR63154406 Mainboard NMLB01 NMLB01 EBR63154405 EBR63154506
  • LG R580-U.ARC3BA9 | Service Manual - Page 93
    )CNY KB (KOREA) QL5(AEQL5Y00,REV3A)CNY K/B(TURKEY)QL5(AEQL5A00,REV3A)CNY K/B(BRAZILIAN)QL5(AEQL5600,REV3A)CNY K/B(GERMAN)QL5(AEQL5G00,REV3A)CNY K/B(FR CANADA)QL5(AEQL5K00,REV3A)CNY K/B(NORDIC)QL5(AEQL5N00,REV3A)CNY K/B(SPANISH)QL5(AEQL5P00,REV3A)CNY KB (ARABIC) QL5(AEQL5Q00,REV3A)CNY K/B(HEBREW)QL5
  • LG R580-U.ARC3BA9 | Service Manual - Page 94
    Ch6. Part lists Category Memory Battery Webcam Dummy Socket Thermal Module Retainer Keyboard Deck Bottom Loc. No. NMRY01 NMRY01 NBATT01 NBATT01 NBATT01 NBATT01 NBATT01 NBATT01 NBATT01 NWEBC01 NDSO01 NDSO01 NDSO02 NDSO02 NTHMO01 NTHMO01 NTHMO01 NTHMO01 NTHMO01 NRTN01 NRTN01 NRTN02 NRTN03 NKDECK01
  • LG R580-U.ARC3BA9 | Service Manual - Page 95
    rear case(Red_LG) Front Case assy (with web cam lens, without Name plate) Front Case assy (without web cam lens, without Name plate) Name Label R580 Consummer Name Label R560 Consummer Name Label RB560 KOREA Commecial Name Label RD580 FREE DOS Name Label RD560 FREE DOS HINGE CAP LEFT QL5 HINGE
  • LG R580-U.ARC3BA9 | Service Manual - Page 96
    Ch6. Part lists Category Power code Adapter Screw CPU Loc. No. NPWCD01 NPWCD01 NPWCD01 NPWCD01 NPWCD01 NPWCD01 NPWCD01 NPWCD01 NPWCD01 NPWCD01 NPWCD01 NPWCD01 NPWCD01 NADT01 NADT01 NADT01 NADT01 NSCR01 NSCR02 NSCR03 NSCR04 NSCR07 NCPU01 NCPU01 NCPU01 NCPU01 NCPU01 NCPU01 NCPU01 NCPU01 NCPU01
  • LG R580-U.ARC3BA9 | Service Manual - Page 97
    (2009) 320817-001 CPU Label All model Intel Core2 Duo Processor (2009) 320781001 POP LABEL KOREA POP LABEL GLOBAL POP LABEL Brazil POP LABEL R480,R580 free DOS Global ulna label all NT (over 13,14,15) 25.0mm X 11.27mm energy star label for (16 x 16.37mm) NVIDIA GRAPHIC CHIP
  • LG R580-U.ARC3BA9 | Service Manual - Page 98
    NLCD05 NLCD09 NWEBC01 NLCD03 NLCD01 NLCD02 NLCD04 NLCD07 NLCD08
  • LG R580-U.ARC3BA9 | Service Manual - Page 99
    rear case(Red_LG) Front Case assy (with web cam lens, without Name plate) Front Case assy (without web cam lens, without Name plate) Name Label R580 Consummer Name Label R560 Consummer Name Label RB560 KOREA Commecial Name Label RD580 FREE DOS Name Label RD560 FREE DOS HINGE CAP LEFT QL5 HINGE
  • LG R580-U.ARC3BA9 | Service Manual - Page 100
    NMINI02 NMINI01 NKDECK01 NKDECK02 NKEYBD01 NRTN01
  • LG R580-U.ARC3BA9 | Service Manual - Page 101
    )CNY KB (KOREA) QL5(AEQL5Y00,REV3A)CNY K/B(TURKEY)QL5(AEQL5A00,REV3A)CNY K/B(BRAZILIAN)QL5(AEQL5600,REV3A)CNY K/B(GERMAN)QL5(AEQL5G00,REV3A)CNY K/B(FR CANADA)QL5(AEQL5K00,REV3A)CNY K/B(NORDIC)QL5(AEQL5N00,REV3A)CNY K/B(SPANISH)QL5(AEQL5P00,REV3A)CNY KB (ARABIC) QL5(AEQL5Q00,REV3A)CNY K/B(HEBREW)QL5
  • LG R580-U.ARC3BA9 | Service Manual - Page 102
    NMRY01 NMRY01 NMINI04 NRBS01 NMINI03 NTHMO01 NCPU01 NMLB01
  • LG R580-U.ARC3BA9 | Service Manual - Page 103
    Main Category Mainboard MiniCard Memory Loc. No. NMLB01 NMLB01 NMLB01 NMLB01 NMLB01 NMLB01 NMLB01 NMLB01 NMLB01 NMLB01 NMLB01 NMLB01 NMLB01 NMLB01 NMLB01 NMLB01 NMLB01 NMLB01 NMLB01 NMLB01 NMINI01 NMINI02 NMINI03 NMINI03 NMINI03 NMINI03 NMINI04 NMRY01 NMRY01 NMRY01 NMRY01 NMRY01 LG P/N
  • LG R580-U.ARC3BA9 | Service Manual - Page 104
    Main Category Memory Thermal Module Screw CPU Robson Loc. No. NMRY01 NTHMO01 NTHMO01 NTHMO01 NTHMO01 NTHMO01 NSCR01 NSCR02 NSCR03 NSCR04 NSCR07 NCPU01 NCPU01 NCPU01 NCPU01 NCPU01 NCPU01 NCPU01 NCPU01 NCPU01 NCPU01 NCPU01 NCPU01 NCPU01 NCPU01 NCPU01 NCPU01 NCPU01 NCPU01 NCPU01 NRBS01 NRBS01 LG P/N
  • LG R580-U.ARC3BA9 | Service Manual - Page 105
    NCVR02 NHDD02 NHDD01 NCVR03 NCVR01 NODD02 NODD01 NHDD03 NBATT01 NBOTM01 NBOTM02 NBOTM03
  • LG R580-U.ARC3BA9 | Service Manual - Page 106
    Etc. Category ODD Cover HDD Battery Bottom Loc. No. NODD01 NODD01 NODD01 NODD02 NODD02 NODD02 NODD02 NODD03 NCVR01 NCVR01 NCVR02 NCVR02 NCVR03 NCVR03 NHDD01 NHDD01 NHDD01 NHDD01 NHDD01 NHDD01 NHDD01 NHDD01 NHDD01 NHDD02 NHDD03 NBATT01 NBATT01 NBATT01 NBATT01 NBATT01 NBATT01 NBATT01 NBOTM01 NBOTM01
  • LG R580-U.ARC3BA9 | Service Manual - Page 107
    Etc. Category Bottom Screw Loc. No. NBOTM01 NBOTM01 NBOTM01 NBOTM01 NBOTM01 NBOTM02 NBOTM03 NBOTM04 NSCR01 NSCR02 NSCR03 NSCR04 NSCR07 LG P/N AFP72919104 AFP72919105 AFP72919106 AFP72919107 AFP72919108 EBR63115501 EAD60840101 EAD60684401 FAB30248901 FAB30479701 FAB30255101 FAB30208501 FAB30249001
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
  • 53
  • 54
  • 55
  • 56
  • 57
  • 58
  • 59
  • 60
  • 61
  • 62
  • 63
  • 64
  • 65
  • 66
  • 67
  • 68
  • 69
  • 70
  • 71
  • 72
  • 73
  • 74
  • 75
  • 76
  • 77
  • 78
  • 79
  • 80
  • 81
  • 82
  • 83
  • 84
  • 85
  • 86
  • 87
  • 88
  • 89
  • 90
  • 91
  • 92
  • 93
  • 94
  • 95
  • 96
  • 97
  • 98
  • 99
  • 100
  • 101
  • 102
  • 103
  • 104
  • 105
  • 106
  • 107
1
Service Manual
Model : R580, RB580, R560, RB560 Series
P/N :MFL62539202
REV.18
2011. 05. 12
Copy Right
ⓒ
2011 LG Electronic inc, DigitalMate Co,.Ltd.
(LGE Internal use only)