LG WM2277HB Service Manual

LG WM2277HB Manual

Get LG WM2277HB PDF manuals and user guides View all LG WM2277HB manuals
Add to My Manuals
Save this manual to your list of manuals

LG WM2277HB manual content summary:

  • LG WM2277HB | Service Manual - Page 1
    Website: http: //www.LGEservice.com E-mail: http: //www.LGEservice.com/techsup.html WASHING MACHINE SERVICE MANUAL ! CAUTION READ THIS MANUAL CAREFULLY TO DIAGNOSE PROBLEMS CORRECTLY BEFORE SERVICING THE UNIT. MODEL: WM2277H*/WM2077CW WM2177H*/WM2677H*M WD-11270BD 100
  • LG WM2277HB | Service Manual - Page 2
    APR. 2004 PRINTED IN KOREA P/No.:3828ER3018Y 101
  • LG WM2277HB | Service Manual - Page 3
    3. PARTS IDENTIFICATION ...7 4. INSTALLATION & TEST ...8 5. OPERATION ...11 6. WIRING DIAGRAM/PROGRAM CHART 14 7. TROUBLESHOOTING...17 7-1. BEFORE PERFORMING SERVICE 17 7-2. QC TEST MODE...17 7-3. HOW TO CHECK THE WATER LEVEL FREQUENCY 17 7-4. ERROR DISPLAY ...18 8. ERROR DIAGNOSIS AND CHECK LIST
  • LG WM2277HB | Service Manual - Page 4
    (3.72 IEC) 27" (W) X 29 3/4" (D) X 3811/16" (H), 5013/16" (D, door open) up to 19 hours up to 12 hours up to 9 hours DOOR SWITCH TYPE PTC + Solenoid WATER LEVEL 10 steps (by sensor) LAUNDRY LOAD SENSING Incorporated ERROR DIAGNOSIS Incorporated AUTO POWER OFF Incorporated CHILD LOCK
  • LG WM2277HB | Service Manual - Page 5
    motor directly drives the drum without belt and pulley. Tilted Drum and Extra Large Door Opening Tilted drum and extra large door opening make it possible to load and unload easily. Water Circulation Laundry Monitor) The RLM monitors status of your washer and/or dryer. You can plug the display unit
  • LG WM2277HB | Service Manual - Page 6
    when the water level reaches the preset level, the washing program then proceeds. Spinning does not proceed until the water in the tub drains to a certain level. 2-4. DOOR CONTROL The door can be opened by pulling the door handle whenever washer is not in operation. When the cycle is completed, the
  • LG WM2277HB | Service Manual - Page 7
    seconds to lock/unlock control. When Child lock is set, CHILD LOCK lights and all buttons are disabled except the Power button. You can lock the washer while it is operating. 2-8. WATER CIRCULATION When Washing and Rinsing function of shower at the upper part of Gasket. When Washing, it continuously
  • LG WM2277HB | Service Manual - Page 8
    3. PARTS IDENTIFICATION ACCESSORIES Water Circulation Nozzle A Safety Cover (PLC Moderm) 7
  • LG WM2277HB | Service Manual - Page 9
    , ask the customer what the trouble is. Check the setup (power supply is 120 V AC, remove the transit bolts....). Check with the troubleshooting guide. Plan your service method by referring to the disassembly instructions. Service the unit. After servicing, operate the appliance to see whether
  • LG WM2277HB | Service Manual - Page 10
    CONNECT THE INLET HOSE Verify that the rubber washer is inside of the valve connector. Tighten the inlet hose securely to prevent leaks. CONNECT THE DRAIN HOSE Make sure that the hose is not twisted. Avoid submerging the end of the hose. The end of the drain hose should be placed less than 96
  • LG WM2277HB | Service Manual - Page 11
    button. Check if water is supplied through the detergent dispenser. Water removal Power off and the power on. Press the SPIN SPEED button. Press the START/PAUSE button. Check the spin and drain functions. Listen for a click to determine if the door is unlocking. If SVC is needed during check
  • LG WM2277HB | Service Manual - Page 12
    5. OPERATION WM2277H*/WM2177H* WM2077CW WM2677H*M 11
  • LG WM2277HB | Service Manual - Page 13
    time remaining in the cycle when operating. b) an error code when an error has been detected. • Use this option to preven Press and hold PRE WA lock/unlock control. • When Child lock is set, C buttons are disabled exc can lock the washer whil • Rotate the Cycle selector knob to select the
  • LG WM2277HB | Service Manual - Page 14
    washer is operating. • Lights whenever the door of the washer is locked. • The door can be unlocked by pressing the Start/Pause button to stop the washer. option for loads that need pretreatment. It adds 16 minutes prewash and drain. • Rinse+Spin: Use this option to rinse and then spin. • Extra
  • LG WM2277HB | Service Manual - Page 15
    6. WIRING DIAGRAM/PROGRAM CHART WM2277H* WM2077CW BL GN BN / YL GN / YL RD 1 2 3 123 NOISE FILTER 123 WH 1 2 3 BK GN WH POWER CORD 14 BL GN BN / YL GN / YL RD 1 2 3 123 NOISE FILTER 123 WH 1 2 3 BK GN WH POWER CORD
  • LG WM2277HB | Service Manual - Page 16
    5 WH 1 1 2 2 THERMISTOR MOTOR (NOTES) #250TERMINAL #250TERMINAL+HOUSING NOISE RD FILTER 123 YL BL RD BK WH 1 2 3 4 2 3 3 2 4 1 5 WH BK BK 8 7 6 5 YL 1 2 WH 4 3 2 1 PLC MODEM PRESSURE SWITCH BN BK BK SB P T C SOLE NOID P T C BK GN WH DRAIN PUMP CIRCULATION PUMP DOOR
  • LG WM2277HB | Service Manual - Page 17
    Cool-down * * **Approx. (Minutes) * Wash time is in minutes. ** The total working time will vary with the load size, water temperature and ambient temperature. 16
  • LG WM2277HB | Service Manual - Page 18
    BEFORE PERFORMING SERVICE Be careful of electric shock when disconnecting parts while troubleshooting. The voltage of each terminal is 110/120 V AC and DC when the unit is plugged in. 7-2. QC TEST MODE. The washer must be empty and the controls must be in the off state. 1. Press the SPIN SPEED and
  • LG WM2277HB | Service Manual - Page 19
    • Not fully drained within 10 minutes. 4 OVER FLOW ERROR PRESSURE 5 SENSOR ERROR 6 DOOR OPEN ERROR 7 HEATING ERROR • Water is overflowing (water level frequency is over 213). If is displayed, the drain pump will operate to drain the water automatically. • The SENSOR SWITCH ASSEMBLY is
  • LG WM2277HB | Service Manual - Page 20
    connector in the MAIN PWB ASSEMBLY is bad or unstable. • The MOTOR HARNESS between the STATOR ASSEMBLY and MAIN PWB ASSEMBLY is cut (open circuited). • The hall sensor is out of order/defective. • Loose Ball Sensor Connector. • Ball Sensor is out of order. Displayed only when the START/PAUSE button
  • LG WM2277HB | Service Manual - Page 21
    8. ERROR DIAGNOSIS AND CHECK LIST 8-1. DIAGNOSIS AND SOLUTION FOR ABNORMAL OPERATION SYMPTOM No power Water inlet trouble GUIDE FOR SERVICE CALL Is the power plug connected firmly to 120 V AC outlet? YES Power failure? or Breaker opened? Is the outlet controlled by a switch? NO Visit to service.
  • LG WM2277HB | Service Manual - Page 22
    SYMPTOM Door error GUIDE FOR SERVICE CALL Was the load too large? Drain trouble Visit to service. Visit to service. 21
  • LG WM2277HB | Service Manual - Page 23
    from the appliance. (In this condition, wash and spin do not operate normally) GUIDE FOR SERVICE CALL Is a low-sudsing detergent used? ;-5 Is prevents overflow. When excessive suds are sensed, the suds removing implementations such as drain, water input, pause will operate, without rotating the
  • LG WM2277HB | Service Manual - Page 24
    parts while troubleshooting. 2. First of all, check the connection of each electrical terminal with the wiring diagram. 3. If you replace FILTER ASSEMBLY NO connectors 120 V AC? Replace the FILTER ASSEMBLY (CIRC). YES Is the LED (1) on? YES NO Replace MAIN PWB ASSEMBLY. Are the connectors (2)
  • LG WM2277HB | Service Manual - Page 25
    & NOISE IN SPIN Base Packing Level Unbalance Part Higher LNouctk Adjustable feet Lower Adjustable feet Have all the transit bolts and base packing been removed? YES Remove the transit bolts NO and Base packing. Is the washer installed on a solidly constructed floor? NO YES Move the washer or
  • LG WM2277HB | Service Manual - Page 26
    If it still has severe vibration and noise, regulate a specific spin speed that generates excessive vibration and noise as follows: 1) Put an unbalance part (rubber) inside of the drum. 2) Start the QC test mode (Refer to section 7-2). 3) Press Delay Wash button, then ' ' is displayed. 4) Press
  • LG WM2277HB | Service Manual - Page 27
    ? NO Is the tap opened? NO YES When you press both SPIN SPEED button and SOIL LEVEL button simultaneously, is the water YES level is 120 V AC. (Refer to 7-2 QC TEST MODE) Check electrical connection. NO Replace the MAIN PWB ASSEMBLY. DETERGENT DOES NOT FLOW IN Is water supplied? YES NO Refer
  • LG WM2277HB | Service Manual - Page 28
    Bleach cap SOFTENER Softener cap Is the liquid detergent/softener/bleach cap clogged? Liquid detergent cap ABNORMAL SOUND Clean the Cap and Container. Is the motor bolt loosened? Is there friction noise coming from the motor? Secure the bolt. Replace the STATOR ASSEMBLY or ROTOR ASSEMBLY. 27
  • LG WM2277HB | Service Manual - Page 29
    too high or low? (resistance of the coil is 10-20 Ω) NO YES Repair the DRAIN HOSE ASSEMBLY. YES Remove foreign material. YES Reconnect or repair the connector YES Replace the DRAIN PUMP ASSEMBLY. When checking voltage between connectors during NO spin, is the voltage 120 V AC as in the figure
  • LG WM2277HB | Service Manual - Page 30
    WASH HEATER TROUBLE HEATING CONTINUOUSLY ABOVE THE SETTING WATER TEMPERATURE Extra Hot: 70 °C 25 (1) When checking the THERMISTOR on the tub, is the THERMISTOR loose? 29 Push the THERMISTOR tightly to the rubber.
  • LG WM2277HB | Service Manual - Page 31
    disconnected, disassembled? YES Reconnect or repair the connector. Connector NO Is the coil of the right side of drain pump open or short circuited? (Coil R is 18-30 Ω) YES Replace PUMP MOTOR ASSEMBLY. NO When checking voltage between the connectors during spin, is the voltage 120 V AC
  • LG WM2277HB | Service Manual - Page 32
    (2) SPIN TROUBLE Check during spin if the frequency of the water level is 248 or more. Press the START/PAUSE button 2 times in QC Test mode, is the drum spinning at low speed? Check the SENSOR SWITCH ASSEMBLY or HOSE (Pressure). If the problem is on the SENSOR SWITCH ASSEMBLY or the HOSE, replace
  • LG WM2277HB | Service Manual - Page 33
    to unplug the machine out of the outlet before disassembling and repairing the parts. TOP PLATE ASSEMBLY Unscrew 2 screws on the back of the top plate. Pull the top plate backward and upward as shown. DRAWER CONTROL PANEL ASSEMBLY Disconnect the Display PWB Assembly connector from Trans cable
  • LG WM2277HB | Service Manual - Page 34
    Disconnect the POWER connector and SENSOR SWITCH ASSEMBLY. Remove the Protect Cover. CONNECTOR PROTECT COVER Disconnect the connectors. Unscrew 1 screw on the back. Disassemble the Main PWB. 33
  • LG WM2277HB | Service Manual - Page 35
    drawer. Push out the DISPENSER ASSEMBLY after unscrew 2 screws. Unscrew the nut at the lower part of the dispenser. Disassemble the 4 connectors from the valves. Wire Color Blue Housing (OR-BK . Disassemble two (or three) connectors from the NOISE FILTER. Unscrew a screw from the TOP BRACKET. 34
  • LG WM2277HB | Service Manual - Page 36
    Unscrew the 4 screws from upper of the canbinet cover. Unscrew the screw from filter cover. Put a flat ( - ) screwdriver or putty knife into the both sides of the filter cover, and pull it out. Unscrew the screw from the lower side of the cabinet cover. 35
  • LG WM2277HB | Service Manual - Page 37
    Open the door. Disassemble the clamp assembly. Tilt the cabinet cover. Disconnect the door switch connector. NOTE: When assembling the CABINET COVER, connect the connector. Lift and separate the cabinet cover. Disassemble the clamp assembly. Disassemble the Gasket. 36
  • LG WM2277HB | Service Manual - Page 38
    of the hinge, and pull out the hinge cover. Unscrew a screw from the lower side of door. Disassemble the door upward. Be careful! The door is heavy. Open the door and disassemble the CLAMP ASSEMBLY. Unscrew the 2 screws. NOTE • Reconnect the connector after replacing the DOOR SWITCH ASSEMBLY. 37
  • LG WM2277HB | Service Manual - Page 39
    Disassemble the cabinet cover. Separate the pump hose, the bellows and the circulation hose assembly from the pump assembly. Disassemble the pump assembly in arrow direction. Disassemble the cabinet cover. Unplug the white connector from the thermistor. Pull it out by holding the bracket of the
  • LG WM2277HB | Service Manual - Page 40
    Disassemble the cabinet cover. Separate the heater from the tub. Remove any foreign objects (wire, coin, etc.) by inserting a long bar in the opening. Unscrew the 4 screws from the back cover. Unscrew the single screw from
  • LG WM2277HB | Service Manual - Page 41
    the back cover. Remove the bolt. Pull out the Rotor. Unscrew the 2 screws from the tub bracket. Remove the 6 bolts on the stator. Unplug the 2 connectors from the stator. Disassemble the damper hinges from the tub and base. Separate the dampers. NOTE • Once removed, replace the damper pin with
  • LG WM2277HB | Service Manual - Page 42
    10. EXPLODED VIEW 10-1. CABINET & CONTROL PANEL ASSEMBLY A485 A455 A410 A152 A450 F210 A150 A154 A110 A111 F215 F110 A495 A102 A103 A490 A104 A105 A151 A153 A130 A140 A390 A131 A141 A101 A100 A430 A133 A440 A310 A300 A303 A200 41 A155 A201 A220
  • LG WM2277HB | Service Manual - Page 43
    10-2.DRUM & TUB ASSEMBLY K351 K350 K360 K143 K123 F140 K411 K410 K110 K111 K140 K571 K572 K115 K141 F310 K610 K611 F466 F315 F465 K570 K320 K310 K311 K560 K510 K512 K131 K340 K130 K530 F463 F464 K135 K122 K125 K121 K105 F467 K342 K346 K344 K345 F145 F468 K520 F461 K540
  • LG WM2277HB | Service Manual - Page 44
    10-3. DISPENSER ASSEMBLY F300 F462 F323 F322 F321 F227 F226 F220 F225 F440 F436 F431 F170 F160 F430 F441 F435 F120 HOT (RED) A275 F130 COLD (BLUE) A276 F432 43
  • LG WM2277HB | Service Manual - Page 45
    LG MODEL: WD-11270BD.ABWEEUS Run_Date : 2004-04-09 YOUR MODEL: WM2277HW SPECIFICATION: 120V 60Hz S AL LOC DESCRIPTION PARTS No. Q'TY REMARKS *001 MANUAL ASSEMBLY,OWNERS 3829ER3021Q 1 *002 BOX,CARTON 3890EZ3524A 1 *003 SPANNER 3W20018B 1 *004 MANUAL,SERVICE 3828ER3018Y 0 *005 MANUAL
  • LG WM2277HB | Service Manual - Page 46
    SEAL K143 SCREW,DRAWING K310 THERMISTOR ASSEMBLY K320 HEATER ASSEMBLY K340 MOTOR ASSEMBLY,PUMP K343 CLAMP K344 CASING,PUMP K345 MOTOR ASSEMBLY,PUMP K346 FILTER(MECH) K350 STATOR ASSEMBLY K360 ROTOR ASSEMBLY K410 SPRING,HINGE K411 HOLDER K510 GASKET K520 BELLOWS K530 CLAMP ASSEMBLY
  • LG WM2277HB | Service Manual - Page 47
    LG MODEL: WD-11275BD.ABPEEUS Run_Date : 2004-04-09 YOUR MODEL: WM2277HB SPECIFICATION: 120V 60Hz S AL LOC DESCRIPTION PARTS No. Q'TY REMARKS *001 MANUAL ASSEMBLY,OWNERS 3829ER3021Q 1 *002 BOX,CARTON 3890EZ3524A 1 *003 SPANNER 3W20018B 1 *004 MANUAL,SERVICE 3828ER3018Y 0 *005 MANUAL
  • LG WM2277HB | Service Manual - Page 48
    SEAL K143 SCREW,DRAWING K310 THERMISTOR ASSEMBLY K320 HEATER ASSEMBLY K340 MOTOR ASSEMBLY,PUMP K343 CLAMP K344 CASING,PUMP K345 MOTOR ASSEMBLY,PUMP K346 FILTER(MECH) K350 STATOR ASSEMBLY K360 ROTOR ASSEMBLY K410 SPRING,HINGE K411 HOLDER K510 GASKET K520 BELLOWS K530 CLAMP ASSEMBLY
  • LG WM2277HB | Service Manual - Page 49
    LG MODEL: WD-10270BD.ABWEEUS Run_Date : 2004-04-09 YOUR MODEL: WM2077CW SPECIFICATION: 120V 60Hz S AL LOC DESCRIPTION PARTS No. Q'TY REMARKS *001 MANUAL ASSEMBLY,OWNERS 3829ER3024Q 1 *002 BOX,CARTON 3890EZ3524A 1 *003 SPANNER 3W20018B 1 *004 MANUAL,SERVICE 3828ER3018Y 0 *005 MANUAL
  • LG WM2277HB | Service Manual - Page 50
    K122 BEARING,BALL K123 BOLT ASSEMBLY K125 SEAL K140 COVER ASSEMBLY,TUB K141 SEAL K143 SCREW,DRAWING K310 THERMISTOR ASSEMBLY K340 MOTOR ASSEMBLY,PUMP K343 CLAMP K344 CASING,PUMP K346 FILTER(MECH) K350 STATOR ASSEMBLY K360 ROTOR ASSEMBLY K410 SPRING,HINGE K411 HOLDER K510 GASKET K520
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
100
WASHING MACHINE
SERVICE MANUAL
READ THIS MANUAL CAREFULLY TO DIAGNOSE
PROBLEMS CORRECTLY BEFORE SERVICING THE UNIT.
MODEL: WM2277H*/WM2077CW
WM2177H*/WM2677H*M
WD-11270BD
CAUTION
Website: http: //www.LGEservice.com
E-mail: http: //www.LGEservice.com/techsup.html
!