Lenovo ThinkPad Edge E10 Hardware Maintenance Manual
Lenovo ThinkPad Edge E10 Manual
View all Lenovo ThinkPad Edge E10 manuals
Add to My Manuals
Save this manual to your list of manuals |
Lenovo ThinkPad Edge E10 manual content summary:
- Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 1
Hardware Maintenance Manual ThinkPad Edge 11" and E10 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 2
and the product it supports, be sure to read the general information under Appendix A "Notices" on page 103. Fourth Edition (April 2012) © Copyright Lenovo 2012. LIMITED AND RESTRICTED RIGHTS NOTICE: If data or software is delivered pursuant a General Services Administration "GSA" contract, use - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 3
23 Checkout guide 24 Diagnostics using PC-Doctor for DOS. . . . 24 Lenovo Solution Center -related symptoms 42 Intermittent problems 43 Undetermined problems 43 Chapter 5. Status and replacing a FRU 53 Before servicing ThinkPad Edge 11" and E10 . . 53 1010 Battery pack 54 1020 Bottom door 56 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 4
Premium (32 bit) DVDs . . 98 Windows 7 Home Premium (64 bit) DVDs . . 98 Windows 7 Professional (64 bit) DVDs. . . . 99 Windows 7 Starter (32 bit) DVDs 100 Common service tools 101 Appendix A. Notices 103 Trademarks 104 ii Hardware Maintenance - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 5
the following ThinkPad® products: ThinkPad Edge 11" and E10 MT 0328 and 2545 Use this manual along with the advanced diagnostic tests to troubleshoot problems. Important: This manual is intended only for trained service technicians who are familiar with ThinkPad products. Use this manual along with - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 6
iv Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 7
you need to be familiar with before you service a ThinkPad Notebook. • "General safety" on page 1 • "Electrical safety" on page 2 • "Safety inspection guide" on page 3 • "Handling devices that are Do not obstruct fan louvers or cover them with labels or stickers. © Copyright Lenovo 2010, 2012 1 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 8
safety precautions when you work with very high voltages; Instructions for these precautions are in the safety sections of such touching can cause personal injury and machine damage. • Do not service the following parts with the power on when they are removed from : 2 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 9
ThinkPad features or options not covered by this inspection guide service or sharp edges). 2. batteries. 5. Remove the cover. 6. Check for any obvious non-ThinkPad alterations. Use good judgment as to the safety of any non-ThinkPad specific ESD procedures when they exceed the requirements noted here. - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 10
meets the specific service requirement. Note : The use of a grounding system to guard against ESD damage is desirable but not necessary. - Attach the ESD ground clip to any frame ground, ground braid, or green-wire ground. - When working on a double-insulated or battery Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 11
DANGER DANGER DANGER DANGER DANGER Chapter 1. Safety information 5 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 12
DANGER 6 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 13
PERIGO PERIGO PERIGO Chapter 1. Safety information 7 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 14
PERIGO PERIGO PERIGO PERIGO PERIGO DANGER 8 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 15
DANGER DANGER DANGER DANGER DANGER Chapter 1. Safety information 9 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 16
DANGER DANGER VORSICHT VORSICHT VORSICHT 10 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 17
VORSICHT VORSICHT VORSICHT VORSICHT VORSICHT Chapter 1. Safety information 11 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 18
12 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 19
Chapter 1. Safety information 13 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 20
14 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 21
Chapter 1. Safety information 15 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 22
16 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 23
Chapter 1. Safety information 17 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 24
18 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 25
replacing any FRUs listed in this manual. After a system board is replaced, ensure that the latest BIOS is loaded to the system board before completing the service action. To download software fixes, drivers, and BIOS, do as follows: 1. Go to http://support.lenovo.com. 2. Enter the product number of - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 26
listed in the Symptom-to-FRU Index for the computer you are servicing. Strategy for replacing FRUs for CTO, CMV, and GAV Product Model Variant (CMV) This is a unique configuration that has been negotiated between Lenovo and the customer. A unique 4-digit MT and 3-digit model is provided to Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 27
the following Web site: http://support.lenovo.com • To view the key commodities, do the following: 1. Click Products & Service Warranty. 2. Click Check follow the instructions on the screen to reach the Product and Parts Details page. 2. Click the Parts Detail tab to view the list of service parts. - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 28
22 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 29
battery" on page 32 The descriptions in this chapter apply to any ThinkPad model that supports the PC-Doctor® for DOS diagnostics program. Some descriptions might not apply to your particular computer. Before you go to the checkout guide when a problem recurs. If service technician • Date of service - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 30
be a symptom of unauthorized service or modification. • If the spindle of a hard disk drive becomes noisy, it may have been subjected to excessive force, or dropped. Checkout guide Use the following procedures as a guide in identifying and correcting problems with the ThinkPad Notebook. Note: The - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 31
available on the following Web site: http://support.lenovo.com Testing the computer In this product to-FRU index" on page 39. 6. When the ThinkPad logo comes up, immediately press F12 to enter the Boot 0, 1, ...) and then press Enter. 9. Follow the instructions on the screen. 10. The main panel of PC- - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 32
otherwise, it cannot be sensed. • Video Adapter test supports only the LCD display on the ThinkPad Notebook. If you have an external monitor attached to supports only the internal optical drive. 12. Run the applicable function test. 13. Follow the instructions on the screen. If there is a problem, - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 33
test programs that enable you to troubleshoot and resolve computer internal storage and memory problems. Notes: • If the computer you are servicing is not installed with the Lenovo Solution Center program, you can download the quick test programs from the Lenovo Support Web site. • The two programs - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 34
instructions on the screen to start the test. When a problem is detected, information messages will be displayed. Refer to the messages to troubleshoot the problem servicing is not installed with the UEFI diagnostic program, you can download a bootable diagnostic program from the Lenovo Support Web - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 35
39 for error code descriptions and troubleshooting hints. 3. When the ThinkPad logo is displayed, repeatedly press Lenovo ThinkVantage Toolbox is available at the following Web site: http://support.lenovo.com To install the latest Lenovo ThinkVantage Toolbox on the computer, follow the instructions - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 36
ThinkPad Devices ➙ AC Adapter ➙ Battery . 2. If the problem does not recur, return drift on the screen for a short time. This drift can occur when a slight, steady pressure is applied to the TrackPoint pointer. This symptom is not a hardware problem. If the pointer stops after a short time, no service - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 37
charged battery pack. 7. Check that the battery pack supplies power when you turn on the computer. If you suspect a power problem, Output voltage of pin no.2 of the ac adapter may different from the one you are servicing. 3. If the voltage is not correct, replace the ac adapter. 4. If the voltage - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 38
: 1. Power off the computer, and unplug the ac adapter from it. 2. Turn the computer upside down. 3. Remove the battery pack (see "1010 Battery pack" on page 54). 4. Remove the backup battery (see "1120 System board, fan assembly, and backup battery" on page 70). 32 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 39
. Wire Red Black Voltage (V dc) +2.5 to +3.2 Ground • If the voltage is correct, replace the system board. • If the voltage is not correct, replace the backup battery. • If the backup battery discharges quickly after replacement, replace the system board. Chapter 3. General checkout 33 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 40
34 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 41
Service Web site: When the latest maintenance diskette and the system program service diskette become available, they will be posted on http://support.lenovo disc set consists of the user instructions and the following set of DVDs the preinstalled applications and drivers on the computer. This - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 42
, the Set Up Windows screen is displayed. Follow the instructions on the screen to complete the Windows setup. 11. to reinstall some device drivers. Passwords As many as three passwords may be needed for any ThinkPad Notebook: the power- Lenovo nor Lenovo authorized 36 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 43
removed. 5. Reinstall the backup battery and the battery pack. (B) If an SVP has been set and is known by the service technician: 1. Turn on the computer. 2. When the ThinkPad logo comes up, immediately press F1 to enter BIOS Setup Utility. For models supporting the Passphrase function, press F1 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 44
the master HDP. Note: To check whether the ThinkPad Notebook you are servicing supports the Passphrase function, enter the BIOS Setup Utility and into screen blank mode, do as follows: 1. Right-click the Power Manager Battery Gauge in the task bar. 2. Select Power off display (keep current Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 45
code is displayed, check the narrative descriptions of symptoms. If the symptom is not described there, go to "Intermittent problems" on page 43. Note: For a device not supported by diagnostic codes in the ThinkPad Notebooks, see the manual for that device. Chapter 4. Related service information 39 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 46
low-battery error (two short beeps) 1. Charge the battery pack. 2. Battery pack. the backup battery for more than 8 hours by connecting the ac adapter. 2. Replace the backup battery and run the backup battery for more than 8 hours by connecting the ac adapter. 2. Replace the backup battery and run - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 47
time clock error. (two short beeps) 1. Charge the backup battery for more than 8 hours by connecting the ac adapter. 2. Replace the backup battery and run BIOS Setup Utility to reset the time and date. . Memory card is not installed. Install memory card. Chapter 4. Related service information 41 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 48
of TFT LCD technology, but excessive pixel problems can cause viewing concerns. If the LCD you are servicing has two or less visible defective pixels to all ThinkPad Notebooks purchased on 1 January, 2008 or later. • Lenovo will not provide replacement if the LCD is within specification as we cannot - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 49
check each FRU for damage. Replace any damaged FRU. 3. Remove or disconnect all of the following devices: a. Non-ThinkPad devices b. Printer, mouse, and other external devices c. Battery pack d. Hard disk drive e. External diskette drive or optical drive f. DIMM g. PC Cards 4. Turn on the computer - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 50
44 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 51
1 2 3 Table 6. Status indicators Indicator 1 Sleep (standby) status Meaning The illumination dot in the ThinkPad logo on the outer lid of the computer and on the palm rest works as a system-status indicator ) mode. Off: The computer is off or in hibernation mode. © Copyright Lenovo 2010, 2012 45 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 52
indicators (continued) Indicator Meaning 3 Power status Green: Off: The AC adapter is connected. If a battery is installed on the computer, it is charged when this indicator is on. The AC adapter is not quickly change the power state of each feature in the list. 46 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 53
level temporarily. To change the default brightness level, change the settings of the Power Option in the Control Panel or use the Power Manager. © Copyright Lenovo 2010, 2012 47 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 54
of each feature in the list. Notes: If you want to use this button to enable or disable the wireless features, the following device drivers must be installed on your computer beforehand: • Power Management driver • OnScreen Display Utility • Wireless device drivers 48 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 55
is your responsibility; you may request that Lenovo installs an Optional-service CRU according to the warranty service for your product. Where you are installing the CRU, Lenovo will ship the CRU to you. CRU information and replacement instructions are shipped with your product and are available - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 56
drivers are calibrated correctly by following country specifications the LENOVO ThinkPad Hardware instructions on the screen. If the MTM and Product ID numbers differ from each other on the rear label, use what is shown for the Product ID field. See example below: 50 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 57
date, select 5. Read box build date from EEPROM, and follow the instruction on the screen. After an ECA has been applied to the machine, the EEPROM must be updated to reflect the ECA's application. Use the LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later to update the EEPROM. Note - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 58
52 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 59
2. Before replacing any FRU, review Chapter 7 "FRU replacement notices electrical outlets, remove the battery pack, and then servicing ThinkPad Edge 11" and E10 Some models of the ThinkPad Edge 11" and E10 you are servicing might have the SIM card that the customer has installed. © Copyright Lenovo - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 60
After you finish the servicing, make sure that you insert the card back into the slot firmly. 1 3 2 1010 Battery pack Important notice for replacing a battery pack: ThinkVantage Toolbox have an automatic battery diagnostic that determines if the battery pack is defective. A battery pack FRU should - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 61
in the parts list for your computer. Any other battery could ignite or explode. Unlock the battery latches 1 . Holding the battery latches in the unlocked position, remove the battery pack in the direction shown by arrow 2 . When installing: Install the battery pack in the slot, and then make sure - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 62
1020 Bottom door For access, remove this FRU: • "1010 Battery pack" on page 54 Table 9. Removal steps of bottom door Note: Loosen the screws 1 , but do not remove them. 56 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 63
and what the label part number, serial number, and product key were. 1 Serial number blank label 79x16 2 FCC label 3 Homologation label 4 Information label under battery Following labels need to be peeled off from the old bottom door, and need to be put on the new bottom door. 6 Wireless WAN label - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 64
1030 Hard disk drive or solid state drive For access, remove these FRUs in order: • "1010 Battery pack" on page 54 • "1020 Bottom door" on page 56 Attention: • Do not drop the drive kgfcm) 3 When installing: Make sure that the HDD or SSD connector is attached firmly. 58 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 65
1040 DIMM For access, remove these FRUs in order: • "1010 Battery pack" on page 54 • "1020 Bottom door" on page 56 Table 11. Removal steps of DIMM b a 1 1 2 Note: If the computer you are servicing has two DIMM slots and only one DIMM is used, the card must be installed in SLOT-0 ( a ), but not - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 66
into the jack marked AUX or A on the card. 1060 PCI Express Mini Card for wireless WAN For access, remove these FRUs in order: • "1010 Battery pack" on page 54 • "1020 Bottom door" on page 56 60 Hardware Maintenance - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 67
jack marked MAIN, and the blue cable into the jack marked AUX on the card. 1070 Keyboard For access, remove these FRUs in order: • "1010 Battery pack" on page 54 • "1020 Bottom door" on page 56 • "1030 Hard disk drive or solid state drive" on page 58 Chapter 8. Removing and replacing - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 68
Table 14. Removal steps of keyboard 1 1 Step 1 Screw (quantity) M2 × 2.5 mm, big-head, nylon-coated (2) Color Black Torque 0.181 Nm (1.85 kgfcm) 2 62 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 69
keyboard (continued) 3 5 6 7 8 7 4 Installation steps of keyboard When installing the keyboard, do as follows: 1. Attach the keyboard connectors. 2. Attach the keyboard so that the front edge of the keyboard are under the frame as shown in this figure. Chapter 8. Removing and replacing a FRU 63 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 70
power-on board assembly (with cable), and microphone For access, remove these FRUs in order: • "1010 Battery pack" on page 54 • "1020 Bottom door" on page 56 • "1030 Hard disk drive or M2 × 7mm, wafer-head, nylon-coated (3) 64 Hardware Maintenance Manual Color Silver Torque 0.181 Nm (1.85 kgfcm) - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 71
Table 15. Removal steps of palm rest assembly, power-on board assembly (with cable), and microphone (continued) 1 6 6 2 3 4 5 Step 6 Screw (quantity) M2 × 7 mm, wafer-head, nylon-coated (3) When installing: Make sure that the connectors are attached firmly. 6 Color Silver Torque 0.181 Nm - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 72
Table 15. Removal steps of palm rest assembly, power-on board assembly (with cable), and microphone (continued) 7 8 7 7 12 1 Step 1 Screw (quantity) M2 × 2 mm, big-head, nylon-coated (2) Color Black Torque 0.181 Nm (1.85 kgfcm) 66 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 73
: Make sure that all the projections of the palm rest assembly are attached firmly to the guide holes of the base cover. 1090 Bluetooth daughter card (BDC-2) For access, remove these FRUs in order: • "1010 Battery pack" on page 54 • "1020 Bottom door" on page 56 • "1030 Hard disk drive or solid - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 74
: Make sure that the connector is attached firmly. Color Silver Torque 0.181 Nm (1.85 kgfcm) 1100 I/O board For access, remove these FRUs in order: • "1010 Battery pack" on page 54 • "1020 Bottom door" on page 56 • "1030 Hard disk drive or solid state drive" on page 58 • "1070 Keyboard" on page - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 75
sure that the connector is attached firmly. Color Silver Torque 0.181 Nm (1.85 kgfcm) 1110 Speaker assembly For access, remove these FRUs in order: • "1010 Battery pack" on page 54 • "1020 Bottom door" on page 56 • "1030 Hard disk drive or solid state drive" on page 58 • "1070 Keyboard" on page - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 76
Silver Torque 0.181 Nm (1.85 kgfcm) 1120 System board, fan assembly, and backup battery Important notices for handling the system board: When handling the system board, bear the following . Note: The fan assembly and the backup battery are attached to the system board. 70 Hardware Maintenance - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 77
For access, remove these FRUs in order: • "1010 Battery pack" on page 54 • "1020 Bottom door" on page 56 components soldered on the top side of the system board are extremely sensitive. When you service the system board, avoid any kind of rough handling. For Intel models: a Accelerometer chip - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 78
Table 19. Location of major sensitive components on the system board (continued) a b c d 72 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 79
Table 20. Removal steps of system board, fan assembly, and backup battery 5 4 1 2 3 6 6 4 Step 6 Screw (quantity) M2 × 4 mm, wafer-head, nylon-coated (2) When installing: Make sure that the connectors are attached firmly. 5 Color Silver Torque 0.181 Nm (1.85 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 80
(continued) 8 7 When installing: Make sure that the connector is attached firmly. DANGER Use only the battery specified in the parts list for your computer. Any other battery could ignite or explode. 9 9 10 11 13 12 When installing: Make sure that the connectors are attached firmly. 74 Hardware - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 81
Table 20. Removal steps of system board, fan assembly, and backup battery (continued) When installing: Before you attach the fan assembly to the system board, you need to peel the thin film off from the thermal rubbers - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 82
unit For access, remove these FRUs in order: • "1010 Battery pack" on page 54 • "1020 Bottom door" on board assembly (with cable), and microphone" on page 64 • "1120 System board, fan assembly, and backup battery" on page 70 Table 21. Removal steps of LCD unit 1 Step 1 Screw (quantity) M2 × 4 mm - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 83
sure that they are not subjected to any tension. Tension could cause the cables to be damaged by the cable guides, or a wire to be broken. 3 3 33 Step 3 Screw (quantity) M2.5 × 4 mm, For access, remove these FRUs in order: • "1010 Battery pack" on page 54 Chapter 8. Removing and replacing a FRU 77 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 84
board assembly (with cable), and microphone" on page 64 • "1120 System board, fan assembly, and backup battery" on page 70 • "1130 LCD unit" on page 76 Table 23. Removal steps of CRT board assembly 64 • "1120 System board, fan assembly, and backup battery" on page 70 78 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 85
. When you replace the base cover, you need to apply the following labels: 2 SIM information label under door 3 Information label under door 5 Certified label under battery Following labels need to be peeled off from the old base cover, and need to be put on the new base cover. 4 Ethernet label For - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 86
1 5 4 2 2010 LCD bezel assembly For access, remove the following FRU: • "1010 Battery pack" on page 54 Table 25. Removal steps of LCD bezel assembly 1 3 1 Step Screw cap Screw (quantity) 80 Hardware Maintenance Manual Color Torque - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 87
(continued) 1 M2 × 4 mm, wafer-head, nylon-coated (2) 2 2 2 2 Silver 2 2 2 2 0.211 Nm (2.15 kgfcm) 1 3 2020 Integrated camera For access, remove these FRUs, in order: • "1010 Battery pack" on page 54 • "2010 LCD bezel assembly" on page 80 Chapter 8. Removing and replacing a FRU 81 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 88
attached firmly. 2030 LCD panel, hinges, and LCD cable For access, remove these FRUs in order: • "1010 Battery pack" on page 54 • "1020 Bottom door" on page 56 • "1030 Hard disk drive or solid state 64 • "1120 System board, fan assembly, and backup battery" on page 70 82 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 89
Table 27. Removal steps of LCD panel, hinges, and LCD cable In step 1 , release the cables from the cable guide of the left and right hinges. 2 1 1 3 3 3 3 Step 3 Screw (quantity) M2 × 4 mm, wafer-head, nylon-coated (4) Color Silver Torque 0.211 Nm (2.15 kgfcm) Chapter 8. Removing and - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 90
(continued) When installing: When attaching the LCD panel to the cover, press the left and right edges covered with metal gently with your fingers. DO NOT press the surface of the panel or apply any 64 • "1120 System board, fan assembly, and backup battery" on page 70 84 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 91
you route the cables, make sure that they are not subjected to any tension. Tension could cause the cables to be damaged by the cable guides, or a wire to be broken. a : Wireless LAN AUX antenna (black) and wireless WAN AUX antenna (blue) b : Wireless LAN MAIN antenna (gray) and wireless WAN MAIN - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 92
86 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 93
Chapter 9. Locations This chapter presents the location of ThinkPad Edge 11" features and hardware. Front view 1 Integrated camera (for some models) 2 Power switch 3 TrackPoint buttons 10 TrackPoint pointing stick 11 UltraNav 12 Built-in digital microphone © Copyright Lenovo 2010, 2012 87 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 94
Rear view 1 Combo audio jack 2 RJ-45 (Ethernet) connector 3 Universal serial bus (USB) connectors 4 Security keyhole 5 External monitor connector 6 AC power connector 7 Bottom view 1 Battery pack 2 Battery pack latch 3 Built-in stereo speaker 4 Bottom door 1 2 3 4 6 5 88 Hardware Maintenance - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 95
or models, unless specific types or models are specified. • FRU with specific models listed and described Lenovo Limited Warranty documentation for full details. ThinkPad Notebooks contain the following types of CRUs: - Self-service cord, battery, and hard disk drive. Other Self-service CRUs depending - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 96
Overall 90 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 97
93.) 2 Power-on board assembly (with cable) 3 Palm rest assembly 4 System board assembly, Intel ULV i3-380UM • 0328-CTO, 4Wx, 4Vx, 4Ux, 4Rx, 4Qx, 4Px, 4Nx, 4Lx, 4Fx, 4Ex, 4Dx 0328-CTO • 2545-CTO 7 I/O board with cable 8 DC-in cable 9 Battery pack, Li-ion (3 cell) • 0328-CTO, 62x, 3Jx, 3Dx, 3Cx, 3Bx, - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 98
12 Speaker assembly 13 CRT board assembly (with cable) 14 Backup battery 15 Thermal module for 0328 15 Thermal module for 2545 16 2Px, 2Kx, 24x, 5Dx • 2545-CTO, 44x, 45x, 3Rx, 48x 17 ThinkPad 2x2 11a/b/g/n Wireless LAN PCI Express Half Mini Card Adapter • 0328-CTO, 4Px, Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 99
LCD FRUs 8 7 6 1 2 3 4 5 Chapter 10. Parts list 93 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 100
• 2545-CTO, 43x, 44x, 45x, 48x 8 LCD module, 11.6-inch HD, anti-glare • 2545-CTO, 3Px, 3Rx 04W1379 No 04W0450 04W0451 0A66647 94 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 101
Keyboard Table 31. Parts list-Keyboard Language Arabic Belgian Brazilian Portuguese Bulgarian Canadian French (058) Canadian French (Acnor) Czech Danish Dutch Finnish, Swedish French German Greek (U.S. English and Greek layout) Hebrew Hungarian Icelandic Italian Japanese Kazakhstan Korean Latin - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 102
), flat head (10) • Screw caps (6) FRU no. CRU ID 04W0290 No Power cords A ThinkPad power cord for a specific country or region is usually available only in that country or region: Table 35. Parts list-2-pin ID * 42T5180 42T5183 42T5008 42T5093 42T5014 42T5099 96 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 103
Table 36. Parts list-3-pin power cords Country or region Australia, New Zealand • models -CTO, xxM Bangladesh, Sri Lanka, South Africa • models -CTO, xxG Canada, U.S. • models -CTO, xxF, xxL, xxS, xxU China (P.R.C.) (other than Hong Kong S.A.R.) • models -CTO, xxC Denmark • models -CTO, xxG European - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 104
/Norway/English) Czech French Greek German Hebrew Hungarian 04T2317 04T2318 04T2343 04T2341 04T2342 04T2340 04T2321 04T2322 04T2323 04T2324 04T2325 04T2326 CRU ID * 98 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 105
Table 39. Parts list-Windows 7 Home Premium (64 bit) recovery DVDs (continued) Language P/N Japanese Korean Polish Portuguese Russian English Romanian Russian Simplified Chinese Slovak Spanish Serbian-Latin Traditional Chinese Turkish US English US English disable 04T2327 04T2328 04T2329 04T2330 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 106
Spanish Turkish US English US English disable 04T2290 04T2291 04T2292 04T2293 04T2294 04T2295 04T2296 04T2297 04T2298 04T2300 04T2299 CRU ID CRU ID * 100 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 107
tools Table 42. Parts list-Common service tools Tool Screwdriver kit 1/4" drive spinner handle 1/4" Sq. to 1/4" hex integrated Smart Card LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later Note: Download the file from the following Web site: http://support.lenovo.com P/N 95F3598 - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 108
102 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 109
the operation of any other product, program, or service. Lenovo may have patents or pending patent applications covering support applications where malfunction may result in injury or death to persons. The information contained in this document does not affect or change Lenovo product specifications - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 110
United States, other countries or both: Active Protection System Lenovo ThinkPad ThinkVantage TrackPoint UltraNav Microsoft and Windows are trademarks or Centrino Intel Pentium Other company, product, or service names may be the trademarks or service marks of others. 104 Hardware Maintenance Manual - Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 111
- Lenovo ThinkPad Edge E10 | Hardware Maintenance Manual - Page 112
Part Number: 75Y6925_03 (1P) P/N: 75Y6925_03 *1P75Y6925_03*
Hardware Maintenance Manual
ThinkPad Edge 11” and E10