Maytag CWG3100AAS Installation Instructions
Maytag CWG3100AAS - 24"Gas Single Oven Manual
 |
UPC - 719881149066
View all Maytag CWG3100AAS manuals
Add to My Manuals
Save this manual to your list of manuals |
Maytag CWG3100AAS manual content summary:
- Maytag CWG3100AAS | Installation Instructions - Page 1
INSTALLATION INSTRUCTIONS 24" (61.0 CM) GAS SINGLE AND DOUBLE BUILT-IN OVEN Table of Contents BUILT-IN OVEN SAFETY 1 INSTALLATION REQUIREMENTS 3 Tools and Parts 3 Location Requirements 3 Electrical Requirements 4 Gas Supply Requirements 5 INSTALLATION INSTRUCTIONS 6 Prepare Built-In Oven 6 - Maytag CWG3100AAS | Installation Instructions - Page 2
from a neighbor's phone. Follow the gas supplier's instructions. • If you cannot reach your gas supplier, call the fire department. - Installation and service must be performed by a qualified installer, service agency or the gas supplier. WARNING: Gas leaks cannot always be detected by smell - Maytag CWG3100AAS | Installation Instructions - Page 3
openings in the wall or floor where oven is to be installed must be sealed. ■ Cabinet opening dimensions that are shown must be used. Given dimensions provide minimum clearance with oven. ■ Grounded electrical supply is required. See "Electrical Requirements" section. ■ Proper gas supply connection - Maytag CWG3100AAS | Installation Instructions - Page 4
(61 cm) min. cutout depth B. 22⁵⁄₈" (57.5 cm) recessed oven depth C. Oven front D. Recessed oven E. Cabinet Electrical Requirements WARNING Cabinet Dimensions - Double Oven Double Oven Installed in Cabinet A B F D E C A. 24" (61 cm) min. cabinet width B. 1¹⁄₂" (3.8 cm) top of cutout to bottom - Maytag CWG3100AAS | Installation Instructions - Page 5
of local codes, installation must conform with American National Standard, National Fuel Gas Code ANSI Z223.1 - latest edition or CAN/CGA B149 - latest edition. IMPORTANT: Leak testing of the oven must be conducted according to the manufacturer's instructions. Type of Gas Natural gas: This oven is - Maytag CWG3100AAS | Installation Instructions - Page 6
must be isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system at test pressures equal to or less than ½ psi (3.5 kPa). INSTALLATION INSTRUCTIONS Prepare Built-In Oven 1. Disconnect power. 2. Decide on - Maytag CWG3100AAS | Installation Instructions - Page 7
seal area of oven front frame when pushing oven into cabinet. Do not push against outside edges. F E D A. Gas pressure regulator B. Gas supply line C. Electrical disconnect D. Serial plate E. Manual oven valve F. Burner rating plate G. Manifold pressure tap 2. Push oven completely into cabinet - Maytag CWG3100AAS | Installation Instructions - Page 8
the oven control is turned on a glow bar igniter heats and ignites the gas. Check Operation of Oven(s) 1. Turn power on. The time should flash in the display. 2. Check that the oven door(s) is closed 3. Turn on the oven(s) Broil function. See the Use and Care Guide for instructions. If oven(s) does - Maytag CWG3100AAS | Installation Instructions - Page 9
to the closed position. 2. Unplug oven or disconnect power. B A C A. To oven B. Shutoff valve (closed position) C. Gas supply line G F E D A. Gas pressure regulator B. Gas supply line C. Electrical disconnect D. Serial plate E. Manual oven valve F. Burner rating plate G. Manifold pressure tap - Maytag CWG3100AAS | Installation Instructions - Page 10
to the widest opening that will not cause the flame to lift or blow off the burner when cold. F E D A. Gas pressure regulator B. Gas supply line C. Electrical disconnect D. Serial plate E. Manual oven valve F. Burner rating plate G. Manifold pressure tap IMPORTANT: Do not remove the - Maytag CWG3100AAS | Installation Instructions - Page 11
A. Regulator pin B. Regulator cap 3. Flip the regulator pin over and snap pin firmly into place. B A A. LP gas position B. Natural gas position A. Burner orifice hood NOTE: On units using Eaton Oven Safety Valve, screw the burner orifice hood away from the pin. There will be approximately 1¹⁄₂ to - Maytag CWG3100AAS | Installation Instructions - Page 12
W10203509A © 2008. Whirlpool Corporation. All rights reserved. 7/08 Printed in U.S.A.
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
 |
 |
INSTALLATION INSTRUCTIONS
24" (61.0 CM) GAS SINGLE
AND DOUBLE BUILT-IN OVEN
BUILT-IN OVEN SAFETY
IMPORTANT:
Installer:
Leave installation instructions with the homeowner.
Homeowner:
Keep installation instructions for future reference.
W10203509A
Table of Contents
BUILT-IN OVEN SAFETY
................................
1
INSTALLATION REQUIREMENTS
.................
3
Tools and Parts
.............................................
3
Location Requirements
.................................
3
Electrical Requirements
................................
4
Gas Supply Requirements
............................
5
INSTALLATION INSTRUCTIONS
...................
6
Prepare Built-In Oven
....................................
6
Make Gas Connection
..................................
6
Install Oven
....................................................
7
Complete Installation
....................................
8
GAS CONVERSIONS
.......................................
9
LP Gas Conversion
.......................................
9
Natural Gas Conversion
..............................
10
You can be killed or seriously injured if you don't immediately
You
can be killed or seriously injured if you don't follow
All safety messages will tell you what the potential hazard is, tell you how to reduce the chance of injury, and tell you what can
happen if the instructions are not followed.
Your safety and the safety of others are very important.
We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety
messages.
This is the safety alert symbol.
This symbol alerts you to potential hazards that can kill or hurt you and others.
All safety messages will follow the safety alert symbol and either the word “DANGER” or “WARNING.”
These words mean:
follow instructions.
instructions.
DANGER
WARNING