Pentair Clean and Clear Pool Cartridge Filters Clean and Clear FIlter Manual--
Pentair Clean and Clear Pool Cartridge Filters Manual
 |
View all Pentair Clean and Clear Pool Cartridge Filters manuals
Add to My Manuals
Save this manual to your list of manuals |
Pentair Clean and Clear Pool Cartridge Filters manual content summary:
- Pentair Clean and Clear Pool Cartridge Filters | Clean and Clear FIlter Manual-- - Page 1
Clean & Clear® Cartridge Filter Owners Manual IMPORTANT SAFETY INSTRUCTIONS READ AND FOLLOW ALL INSTRUCTIONS SAVE THESE INSTRUCTIONS SECTION I. SECTION II. SECTION III. SECTION IV. Table of Contents FILTER INSTALLATION 1 FILTER OPERATION ...2 TROUBLESHOOTING 6 TECHNICAL DATA ...7 A. Filter - Pentair Clean and Clear Pool Cartridge Filters | Clean and Clear FIlter Manual-- - Page 2
WHENEVER INSTALLING THE FILTER LOCK RING, FOLLOW THE FILTER LOCK RING INSTALLATION INSTRUCTIONS EXACTLY. 3. ONCE SERVICE ON THE CIRCULATING SYSTEM IS COMPLETE, FOLLOW SYSTEM RESTART INSTRUCTIONS EXACTLY. 4. MAINTAIN CIRCULATION SYSTEM PROPERLY. REPLACE WORN OR DAMAGED PARTS IMMEDIATELY (e.g., lock - Pentair Clean and Clear Pool Cartridge Filters | Clean and Clear FIlter Manual-- - Page 3
steps before working on any part of the circulating system (e.g., lock ring, pump, filter, valves, etc.). a. Turn the pump off and shut off any automatic controls to ensure that the system is not inadvertently started during servicing. b. Open the High Flow™ manual air relief valve. c. Wait until - Pentair Clean and Clear Pool Cartridge Filters | Clean and Clear FIlter Manual-- - Page 4
ON THE BODY. 4. Follow the System Restart Instructions in Section C. C. SYSTEM RESTART INSTRUCTIONS WARNING THIS FILTER OPERATES UNDER HIGH PRESSURE. WHEN ANY PART OF THE CIRCULATING SYSTEM (e.g., LOCK RING, PUMP, FILTER, VALVES, ETC.) IS SERVICED, AIR CAN ENTER THE SYSTEM AND BECOME PRESSURIZED - Pentair Clean and Clear Pool Cartridge Filters | Clean and Clear FIlter Manual-- - Page 5
clean cartridge element on support tube and install assembly into the filter tank body, aligning the arrow on the support tube with the inlet port of the filter and reinstall High Flow™ manual air relief valve drain hose if used. E. REPLACING CARTRIDGE ELEMENT Cartridge element life will vary with - Pentair Clean and Clear Pool Cartridge Filters | Clean and Clear FIlter Manual-- - Page 6
servicing. 2. OPEN THE HIGH FLOW™ MANUAL AIR RELIEF VALVE UNTIL IT SNAPS INTO THE FULL OPEN POSITION, THEN WAIT UNTIL ALL PRESSURE IS RELIEVED. 3. With the relief valve attached to the filter TROUBLESHOOTING Figure 3. A. Air entering your filter is an important part of the filter system. It is - Pentair Clean and Clear Pool Cartridge Filters | Clean and Clear FIlter Manual-- - Page 7
on plumbing size and other system components. 2 C. Replacement Parts Item Part Number Description 1 98209800 High Flow™ manual air relief valve 2 190058 Pressure Gauge 3 178553 Lid, 50, 100 sq. ft. filter 4 178561 Lid, 75,150, 200 sq. ft. filter 5 59052900 Locking Ring assy. 6 87300400 Body O-ring - Pentair Clean and Clear Pool Cartridge Filters | Clean and Clear FIlter Manual-- - Page 8
SAVE THESE INSTRUCTIONS © 2009 Pentair Water Pool and Spa, Inc. All rights reserved. 1620 Hawkins Ave., . Trademarks and Disclaimers: Pentair Pool Products®, Because reliability matters most®, Clean & Clear®, and High Flow™, are trademarks and/or registered trademarks of Pentair Water Pool and Spa,
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
 |
 |
Rev. D
6-26-09
1
P/N
178556
Figure 1.
Pentair Water Pool and Spa, Inc.
1620 Hawkins Ave., Sanford, NC 27330 • (800) 831-7133 • (919) 566-8000
10951 West Los Angeles Ave., Moorpark, CA 93021 • (800) 831-7133 • (805) 553-5000
Visit
www.pentairpool.com
or
www.staritepool.com
Before installing this product, read and follow all warning notices and instructions accompanying this
filter. Failure to follow safety warnings and instructions can result in severe injury, death, or property
damage. Call (800) 831-7133 for additional free copies of these instructions.
WARNING
Important Notice
Attention Installer.
This manual contains important information about the installation, operation and safe
use of this product. This information should be given to the owner/operator of this
equipment.
SECTION I.
FILTER INSTALLATION
A.
GENERAL INFORMATION
1.
The filter should be mounted on a level concrete slab. Position the filter so that the instructions,
warnings and pressure gauge are visible to the operator. Also, position the filter so that the piping
connections, control valve and drain port are convenient and accessible
for servicing and winterizing.
2.
Install electrical controls (e.g., on/off switches, timers control systems,
etc.) at least five (5) feet from the filter. This will allow you enough
room to stand clear of the filter during system start up.
3.
Provide sufficient clearance around the filter to permit visual verification
that the clamp is properly installed, see Figure 1.
4.
Provide sufficient space above the filter to remove the filter lid for
cleaning and servicing. This distance will vary with the model of filter
you are using. See Table 1, for the required vertical clearance.
Clean & Clear
®
Cartridge Filter Owners Manual
IMPORTANT SAFETY INSTRUCTIONS
READ AND FOLLOW ALL INSTRUCTIONS
SAVE THESE INSTRUCTIONS
Table of Contents
SECTION I.
FILTER INSTALLATION
...............................................................................................
1
SECTION II.
FILTER OPERATION
.....................................................................................................
2
SECTION III.
TROUBLESHOOTING
...................................................................................................
6
SECTION IV.
TECHNICAL DATA
.......................................................................................................
7
A.
Filter Pressure Loss Chart
..........................................................................................
7
C.
Replacement Parts
.....................................................................................................
7
B.
Flow Rate Table
.........................................................................................................
7