Poulan 532438896R1 User Manual

Poulan 532438896R1 Manual

Get Poulan 532438896R1 PDF manuals and user guides View all Poulan 532438896R1 manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan 532438896R1 manual content summary:

  • Poulan 532438896R1 | User Manual - Page 1
    Do Not Throw Away OPERATOR'S MANUAL MODEL: PO15538LT LAWN TRACTOR WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan.com Gasoline containing up to 10
  • Poulan 532438896R1 | User Manual - Page 2
    tractor. I. GENERAL OPERATION • Read, understand, and follow all instructions on the machine and in the manual before starting. • Do not put hands or feet near rotating parts percentage of riding mower-related injuries. These operators should evaluate their ability to operate the riding mower safely
  • Poulan 532438896R1 | User Manual - Page 3
    and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction labels, as necessary
  • Poulan 532438896R1 | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan 532438896R1 | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Steering Wheel Insert (1) Large Flat Washer (1) Hex Bolt 5/16-18 x 4 (1) 5/16 Lock Washer Steering Wheel Adapter Steering Boot Seat (1) Seat Steering Extension Shaft (1) Washer (1) Knob Keys (1) Oil Drain Tube For Future Use Slope Sheet (2) Keys 5
  • Poulan 532438896R1 | User Manual - Page 6
    hour at 6-10 amps. (See "BATTERY" in Maintenance section of this manual for charging instructions). • For battery and battery cable installation see "REPLACING BATTERY" in the "Service and Adjustments" section in this manual. TO INSTALL STEERING WHEEL (See Fig. 2) ASSEMBLE EXTENSION SHAFT AND BOOT
  • Poulan 532438896R1 | User Manual - Page 7
    See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is operating properly. See
  • Poulan 532438896R1 | User Manual - Page 8
    MOWER LIFT 15 ATTACHMENT ATTACHMENT CLUTCH DISENGAGED CLUTCH ENGAGED BRAKE/CLUTCH PEDAL KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) LIGHTS ON FREE WHEEL (Automatic Models only) DANGER, KEEP HANDS AND FEET AWAY Failure to follow instructions in damage to the tractor and/or engine.
  • Poulan 532438896R1 | User Manual - Page 9
    Standards Institute. ATTACHMENT CLUTCH LEVER - Used to engage the mower blades, or other attachments mounted to your tractor. ATTACHMENT LIFT LEVER - Used to raise, lower, and adjust the mower deck or other attachments mounted to your tractor. CLUTCH/BRAKE PEDAL - Used for declutching and braking
  • Poulan 532438896R1 | User Manual - Page 10
    position and remove key. Always remove key when leaving tractor to prevent unauthorized use. TO ADJUST MOWER CUTTING HEIGHT (See Fig. 5) The position of the and to over 3" during hot months. For healthier and better looking lawns, mow often and after moderate growth. • For best cutting performance,
  • Poulan 532438896R1 | User Manual - Page 11
    needed, turn the ignition key clockwise to engine "ON" position. ROS "ON" POSITION ENGINE "ON" POSITION (NORMAL OPERATING) 02828 TO OPERATE MOWER (See Fig. 6) Your tractor is equipped with an operator presence sensing switch. Any attempt by the operator to leave the seat with the engine running
  • Poulan 532438896R1 | User Manual - Page 12
    • Check engine oil with tractor on level ground. • Remove engine while in storage. To avoid engine problems, the fuel system should be emptied before Use fresh fuel next season. See Storage Instructions for additional information. Never use engine or Service and Adjustments section of this manual. 12
  • Poulan 532438896R1 | User Manual - Page 13
    TIPS • Tire chains cannot be used when the mower housing is attached to tractor. • Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower should be used for trimming. • Drive so
  • Poulan 532438896R1 | User Manual - Page 14
    as instructed in this manual. SPINDLE ZERK SPINDLE ZERK Some adjustments will need to be made periodically to properly maintain your tractor. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual. FRONT
  • Poulan 532438896R1 | User Manual - Page 15
    tractor requires more than five (5) feet to stop at highest speed in highest gear on a level, dry concrete or paved surface, then brake must be checked and adjusted. (See "TO CHECK BRAKE" in the Service and Adjustments section of this manual local parts dealer. Tire best results mower blades must
  • Poulan 532438896R1 | User Manual - Page 16
    range expected before oil change. All oil must meet API service classification SG-SL. • Be sure tractor is on level surface. • Oil will drain more freely overfill. For approximate capacity see "PRODUCT SPECIFICATIONS" section of this manual. • Use gauge on oil fill cap/dipstick for checking level.
  • Poulan 532438896R1 | User Manual - Page 17
    a garden hose or pressure washer to clean your tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower. 17
  • Poulan 532438896R1 | User Manual - Page 18
    ANY SERVICE OR parts have completely stopped. • Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. TO REMOVE MOWER (See Fig. 14) Mower will be easier to remove from the right side of tractor housing guide into bracket, slide collar onto guide and
  • Poulan 532438896R1 | User Manual - Page 19
    SERVICE AND ADJUSTMENTS TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See the sides of the tires for proper PSI). If tires are over or underinflated, you will not properly adjust your mower. SIDE-TO-SIDE
  • Poulan 532438896R1 | User Manual - Page 20
    qualified service center. TO REPLACE MOTION DRIVE BELT (See Fig. 20) Park the tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal on bottom side of left footrest. BELT REMOVAL • Remove mower (See "TO REMOVE MOWER" in this section of manual). NOTE
  • Poulan 532438896R1 | User Manual - Page 21
    bolt, move mower deck height to instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER TO ATTACH JUMPER CABLES • Connect one end of the RED cable to the POSITIVE (+) terminal of each battery(A-B), taking care not to short against tractor parts dealer. Tire sealant also
  • Poulan 532438896R1 | User Manual - Page 22
    AND RELAYS Loose or damaged wiring may cause your tractor to run poorly, stop running, or prevent it from manual. TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service
  • Poulan 532438896R1 | User Manual - Page 23
    enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan 532438896R1 | User Manual - Page 24
    TROUBLESHOOTING POINTS PROBLEM Will not start CAUSE in "CHOKE" position. 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/dirty oil. 6. Faulty To Adjust Carburetor" in Service Adjustments section. 10. Contact an authorized service center/department. 1. Clean
  • Poulan 532438896R1 | User Manual - Page 25
    TROUBLESHOOTING POINTS PROBLEM Excessive vibration CAUSE 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part(s). CORRECTION 1. Replace blade. Tighten blade bolt. 2. Replace blade mandrel. 3. Tighten loose part(s). Replace damaged parts parts manual. 11. Clogged mower Service
  • Poulan 532438896R1 | User Manual - Page 26
    charge for parts or labor incurred in replacing parts, any part which be maintained in accordance with the instructions furnished. 4. The Warranty period for service dealer. Should you have any unanswered questions concerning this Warranty, please contact: HOP Outdoor Products Customer Service
  • Poulan 532438896R1 | User Manual - Page 27
    27 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan 532438896R1 | User Manual - Page 28
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
OPERATOR'S MANUAL
MODEL:
PO15538LT
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan.com
WARNING:
Read this Manual and follow all Warnings
and Safety Instructions.
Failure to do so
can result in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
08.18.11 BD
532 43 88-96 Rev 1
Printed in the U.S.A.
Gasoline containing up to 10% ethanol (E10) is acceptable for use in this machine.
The use of any gasoline exceeding 10% ethanol (E10) will void the product warranty.