Poulan 954570680 User Manual

Poulan 954570680 Manual

Get Poulan 954570680 PDF manuals and user guides View all Poulan 954570680 manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan 954570680 manual content summary:

  • Poulan 954570680 | User Manual - Page 1
    Do Not Throw Away 00993-poulan_pro 02478 OWNER'S MANUAL MODEL: 279370 LAWN TRACTOR WARNING: Read this Owner's Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION 186895 Rev. 2 04.29.03 RD/TR Printed
  • Poulan 954570680 | User Manual - Page 2
    SAFETY RULES SAFE OPERATION PRACTICES FOR RIDE-ON MOWERS IMPORTANT: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. I. GENERAL OPERATION DO NOT: • Read, understand,
  • Poulan 954570680 | User Manual - Page 3
    SAFETY RULES SAFE OPERATION PRACTICES FOR RIDE-ON MOWERS • Be sure the area is clear of is dangerous. Tires can lose traction with the ground and cause you to lose control of your tractor. WARNING Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals
  • Poulan 954570680 | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan 954570680 | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Seat Steering Sleeve Steering Wheel Insert Steering Extension Shaft (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Knob Steering Adapter (1) Large Flat Washer Blade (1) Oil
  • Poulan 954570680 | User Manual - Page 6
    mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel). TO REMOVE TRACTOR FROM CARTON . • Check for any additional loose parts or cartons and remove. ADAPTER TABS EXTENSION SHAFT BEFORE REMOVING TRACTOR FROM SKID ATTACH STEERING WHEEL (See
  • Poulan 954570680 | User Manual - Page 7
    is put into service after month and year indicated on label (label located between terminals) charge battery for minimum of one hour at 6-10 amps. (See "BATTERY" in Maintenance section of this manual for charging instructions). SEAT PAN LABEL NOTE: You may now roll or drive your tractor off the
  • Poulan 954570680 | User Manual - Page 8
    See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is properly adjusted. See
  • Poulan 954570680 | User Manual - Page 9
    MOWER LIFT 15 15 15 ATTACHMENT ATTACHMENT CLUTCH ENGAGED CLUTCH DISENGAGED DANGER, KEEP HANDS AND FEET AWAY KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) FREE WHEEL (Automatic Models only) Failure to follow instructions result in damage to the tractor and/or engine. HOT SURFACES
  • Poulan 954570680 | User Manual - Page 10
    TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual engage the mower blades, or other attachments mounted to your tractor. LIGHT
  • Poulan 954570680 | User Manual - Page 11
    position and remove key. Always remove key when leaving tractor to prevent unauthorized use. • Never use choke to THE USEFUL LIFE OF YOUR TRANSAXLE. TO ADJUST MOWER CUTTING HEIGHT (See Fig. 6) The position of of grass being mowed. • The average lawn should be cut to approximately 2-1/2 inches
  • Poulan 954570680 | User Manual - Page 12
    prevent scalping in most terrain conditions. NOTE:Adjust gauge wheels with tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO ADJUST MOWER CUTTING HEIGHT" in the Operation section of this manual). • With mower in desired height of cut position, gauge wheels should be
  • Poulan 954570680 | User Manual - Page 13
    . • Check engine oil with tractor on level ground. • Remove engine while in storage. To avoid engine problems, the fuel system should be emptied before Use fresh fuel next season. See Storage Instructions for additional information. Never use engine Service and Adjustments section of this manual. 13
  • Poulan 954570680 | User Manual - Page 14
    best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower should be used for trimming. • them in size so that as they fall onto the lawn they will disperse into the grass and not be noticed. Also, the mulched
  • Poulan 954570680 | User Manual - Page 15
    receive full value from the warranty, operator must maintain tractor as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. All adjustments in the Service and Adjustments section of this manual should be checked at least once each season
  • Poulan 954570680 | User Manual - Page 16
    may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. OPERATOR PRESENCE SYSTEM Be sure operator presence and interlock systems are working properly. If your tractor does not function as described, repair the problem immediately. • The engine should not
  • Poulan 954570680 | User Manual - Page 17
    range expected before oil change. All oil must meet API service classification SF-SJ. • Be sure tractor is on level surface. • Oil will drain more freely not overfill. For approximate capacity see "PRODUCT SPECIFICATIONS" section of this manual. • Use gauge on oil fill cap/dipstick for checking level.
  • Poulan 954570680 | User Manual - Page 18
    operation or every season. Service paper cartridge every 100 hours of operation or every season, whichever occurs first. Service air cleaner more often under engine oil filter every season or every other oil change if the tractor is used more than 100 hours in one year. MUFFLER Inspect and manual. 18
  • Poulan 954570680 | User Manual - Page 19
    of all gasoline, oil, etc. • Protect painted surfaces with automotive type wax. We do not recommend using a garden hose or pressure washer to clean your tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your
  • Poulan 954570680 | User Manual - Page 20
    BEFORE PERFORMING ANY SERVICE OR ADJUST- parts have completely stopped. • Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. TRACTOR TO REMOVE MOWER (See Fig. 18) Mower clutch cable housing guide into bracket, slide collar onto guide and secure with
  • Poulan 954570680 | User Manual - Page 21
    SERVICE AND ADJUSTMENTS TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underinflated, you will not properly adjust your mower. SIDE-TO-SIDE
  • Poulan 954570680 | User Manual - Page 22
    pul- leys. • Make sure belt is in all pulley grooves and inside all belt guides. • Install mower (See "To Install Mower" in this section of manual). MANDREL PULLEY IDLER PULLEYS • Road test tractor for proper stopping distance as stated above. Readjust if necessary. If stopping distance is still
  • Poulan 954570680 | User Manual - Page 23
    to adjustment bolt, move mower deck height to the lowest instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER The front wheel toe-in and camber are not adjustable on your tractor sealant may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot
  • Poulan 954570680 | User Manual - Page 24
    SERVICE AND ADJUSTMENTS IMPORTANT: YOUR TRACTOR IS EQUIPPED WITH A 12 VOLT SYSTEM. THE OTHER VEHICLE MUST ALSO BE A 12 VOLT SYSTEM. DO NOT USE YOUR TRACTOR your tractor to run poorly, stop running, or prevent it from starting. • Check wiring. See electrical wiring diagram in the Repair Parts section
  • Poulan 954570680 | User Manual - Page 25
    , altitude or load. If the carburetor does need adjustment, see engine manual. High speed stop is factory adjusted. Do not adjust - damage may -GOVERNED HIGH SPEED NEEDS ADJUSTING, CONTACTYOUR NEAREST AUTHORIZED SERVICE CENTER/ DEPARTMENT, WHICH HAS PROPER EQUIPMENT AND EXPERIENCE TO MAKE
  • Poulan 954570680 | User Manual - Page 26
    enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan 954570680 | User Manual - Page 27
    TROUBLESHOOTING POINTS PROBLEM 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/ Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan 954570680 | User Manual - Page 28
    TROUBLESHOOTING POINTS PROBLEM CAUSE Engine continues to run when operator leaves seat with attachment clutch engaged 1. Faulty operator-safety presence control system. CORRECTION 1. Check wiring, switches and connections. If not corrected, contact an authorized service center/ department.
  • Poulan 954570680 | User Manual - Page 29
    TRACTOR - - MODEL NUMBER 279370, PRODUCT NUMBER 954 57 06-80 SCHEMATIC BLACK RED BATTERY BLACK A CONNECTIONS HEADLIGHTS REMOVABLE CONNECTIONS WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. 29
  • Poulan 954570680 | User Manual - Page 30
    REPAIR PARTS TRACTOR - - MODEL NUMBER 279370, PRODUCT NUMBER 954 57 06-80 ELECTRICAL 22 21 42 24 41 43 27 27 26 27 27 25 33 30 40 16 16 8 2 1 D.C. AMPERES 45 52 29 28 27 90 30
  • Poulan 954570680 | User Manual - Page 31
    REPAIR PARTS TRACTOR - - MODEL NUMBER 279370, PRODUCT NUMBER 954 57 06-80 ELECTRICAL KEY PART NO. NO. 1 163465 2 74760412 8 176689 16 176138 21 183759 22 4152J 24 4799J 25 146147 26 175158 27 73510400 28 4207J 29 121305X 30 175566
  • Poulan 954570680 | User Manual - Page 32
    REPAIR PARTS TRACTOR - - MODEL NUMBER 279370, PRODUCT NUMBER 954 57 06-80 CHASSIS AND ENCLOSURES 259 264 28 258 263 17 159 30 24 18 261 39 25
  • Poulan 954570680 | User Manual - Page 33
    REPAIR PARTS TRACTOR - - MODEL NUMBER 279370, PRODUCT NUMBER 954 57 06-80 CHASSIS AND ENCLOSURES KEY PART NO. NO. DESCRIPTION 1 3/8-16 x 3/4 Screw Thdrol 5/16-18 x 1/2 Tyt Bracket Asm. Pivot Mower Rear Bracket Pivot Air Duct Private Label Dash Lower Plate Reinforcement Rod Pivot Chassis/Hood
  • Poulan 954570680 | User Manual - Page 34
    REPAIR PARTS TRACTOR - - MODEL NUMBER 279370, PRODUCT NUMBER 954 57 06-80 DRIVE 57 89 51 69 197 81 59 84 85 13 14 112 80 21 10 8
  • Poulan 954570680 | User Manual - Page 35
    REPAIR PARTS TRACTOR - - MODEL NUMBER 279370, PRODUCT NUMBER 954 57 06-80 DRIVE KEY PART NO. NO. 1 ------ 2 146682 3 123666X Lock Hvy Hlcl Spr 7/16 Keeper Belt Engine Foolproof Screw Hex wsh HiLo 1/4 x 1/2 Unc Guide Belt Mower Drive RH Spacer Axle Washer 25/32 x 1 1/4 x 16 Ga E-ring #5133-75 Key
  • Poulan 954570680 | User Manual - Page 36
    REPAIR PARTS TRACTOR - - MODEL NUMBER 279370, PRODUCT NUMBER 954 57 06-80 STEERING ASSEMBLY 38 12 39 1 37 44 51 91 43 41 42 37 36 54 88 71 29 17 68 29 15 15 15 steering_pl.lt_29 82 29 46 8 6 2 87 5 68 67 13 65 46 8 6 67 67 3 32 11 40 33 34 10 35 87 5 4 43 43 6 8 36
  • Poulan 954570680 | User Manual - Page 37
    REPAIR PARTS TRACTOR - - MODEL NUMBER 279370, PRODUCT NUMBER 954 57 06-80 STEERING ASSEMBLY KEY PART NO. NO. DESCRIPTION 1 180656 Wheel Steering 2 184706 Axle Asm Front 3 169840 Spindle Asm Lh 4 169839 Spindle Asm Rh 5 6266H Bearing Race Thrust Harden 6 121748X Washer
  • Poulan 954570680 | User Manual - Page 38
    REPAIR PARTS TRACTOR - - MODEL NUMBER 279370, PRODUCT NUMBER 954 57 06-80 SEAT ASSEMBLY 1 14 24 8 9 7 10 5 8 9 7 2 5 6 22 21 16 25 15 11 4 13 17 12 3 seat_lt.knob_1 KEY PART NO. NO. 1 171683 2 140551 3 71110616 4 19131610 5 145006 6 73800600 7 124181X 8 17000616 9 19131614 10 182493 11
  • Poulan 954570680 | User Manual - Page 39
    REPAIR PARTS TRACTOR - - MODEL NUMBER 279370, PRODUCT NUMBER 954 57 06-80 DECALS 9 12 2 5 3 8 4 8 10 12 16 1 7 6 13 14 15 KEY PART NO. NO. 1 156369 2 172743 3 186163 4 186164 5 186785 6 170563 7 179128 8 182005 9 172740 10 157140 DESCRIPTION Decal Instruction Operat English/French
  • Poulan 954570680 | User Manual - Page 40
    REPAIR PARTS TRACTOR - - MODEL NUMBER 279370, PRODUCT NUMBER 954 57 06-80 ENGINE 2 3 72 1 81 38 13 4 78 32 44 16 14 46 78 33 37 31 33 45 23 29 OPTIONAL EQUIPMENT Spark Arrester engine-bs.1cyl_46 KEY PART NO. NO. DESCRIPTION KEY PART NO. NO. DESCRIPTION 1 170551 2 17720408 3
  • Poulan 954570680 | User Manual - Page 41
    PARTS TRACTOR - - MODEL NUMBER 279370, PRODUCT NUMBER 954 57 06-80 MOWER LIFT 7 41 8 37 38 40 11 19 13 5 36 13 4 6 12 13 31 32 19 13 31 32 KEY PART 4 20 15 1617 18 20 20 20 15 lift-rh.1pc.stlt_5 KEY PART NO. NO. DESCRIPTION 17 175689 18 73800800 19 139868 20 163552 31 169865 32
  • Poulan 954570680 | User Manual - Page 42
    REPAIR PARTS TRACTOR - - MODEL NUMBER 279370, PRODUCT NUMBER 954 57 06-80 MOWER DECK 68 158 151 152 67 157 156 153 155 159 46 153 154 40 37 36 40 143 144 45 150 40 37 145
  • Poulan 954570680 | User Manual - Page 43
    PARTS TRACTOR - - MODEL NUMBER 279370, PRODUCT NUMBER 954 57 06-80 MOWER DECK KEY PART NO. NO. DESCRIPTION KEY PART NO. NO. DESCRIPTION 1 165892 Mower W/G 30 173984 Screw Thdrol Washer Head 31 129963 Washer, Spacer Mower Vented 32 173436 Pulley, Mandrel 33 178342 Nut, Toplock Flange 34
  • Poulan 954570680 | User Manual - Page 44
    NOTES 44
  • Poulan 954570680 | User Manual - Page 45
    , without charge for parts or labor incurred in replacing parts, any part which we find to Battery must be maintained in accordance with the instructions furnished. 4. The Warranty period for any products return the product to an authorized service dealer. Should you have any unanswered
  • Poulan 954570680 | User Manual - Page 46
    instructions contained in an Instruction Manual for the operation of the Power Train Component and parts. The cost of normal maintenance and replacement of service legal rights which vary from state to state. E. No Dealer Warranty Tecumseh neither assumes nor authorizes any other person, natural or
  • Poulan 954570680 | User Manual - Page 47
    47 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan 954570680 | User Manual - Page 48
    pages of your phone directory for the name of the nearest service dealer (under "saws" for Chain Saws or under "lawn mowers" for Trimmers, Brushcutters, and Blowers). 3. For replacement parts, have available the following information: a. Model Number/Manufacturer's I.D. Number b. Description of
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
OWNER'S MANUAL
MODEL:
279370
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
WARNING:
Read this Owner's Manual and follow all
Warnings and Safety Instructions.
Failure
to do so can result in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
186895
Rev. 2
04.29.03
RD/TR
Printed in U.S.A.
02478
00993-poulan_pro