Poulan BB185H42LT User Manual

Poulan BB185H42LT Manual

Get Poulan BB185H42LT PDF manuals and user guides View all Poulan BB185H42LT manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan BB185H42LT manual content summary:

  • Poulan BB185H42LT | User Manual - Page 1
    Do Not Throw Away 02478 OPERATOR'S MANUAL MODEL: BB185H42LT LAWN TRACTOR WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 194992 10.26.04 RD
  • Poulan BB185H42LT | User Manual - Page 2
    for holes, ruts, bumps, rocks, or other hidden I. GENERAL OPERATION • Read, understand, and follow all instructions on the machine and in the manual before starting. • Do not put hands or feet near rotating parts or under the machine. Keep clear of the discharge opening at all times. • Only allow
  • Poulan BB185H42LT | User Manual - Page 3
    and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction labels, as necessary
  • Poulan BB185H42LT | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan BB185H42LT | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Seat Steering Boot Steering Wheel Adapter (1) Large Flat Washer Steering Wheel Insert Steering Extension Shaft (1) 5/16 Lock Washer (1) Hex Bolt 5/16-18 x 4 (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Knob Key (2) Keys (1) Oil Drain Tube Slope Sheet 5
  • Poulan BB185H42LT | User Manual - Page 6
    gauge Utility knife When right or left hand is mentioned in this manual, it means when you are in the operating position (seated behind WASHER TO REMOVE TRACTOR FROM CARTON UNPACK CARTON • Remove all accessible loose parts and parts cartons from carton. • Cut along dotted lines on all four panels
  • Poulan BB185H42LT | User Manual - Page 7
    position. • If this battery is put into service after month and year indicated on label (label located between terminals) charge battery for minimum of one hour at 6-10 amps. (See "BATTERY" in MAINTENANCE section of this manual for charging instructions). SEAT PAN LABEL NOTE: You may now roll
  • Poulan BB185H42LT | User Manual - Page 8
    section of this manual. ✓CHECKLIST BEFORE YOU OPERATE YOUR NEW TRACTOR, WE WISH TO ASSURE THAT YOU RECEIVE THE BEST PERFORMANCE AND SATISFACTION FROM THIS QUALITY PRODUCT. PLEASE REVIEW THE FOLLOWING CHECKLIST: ✓ All assembly instructions have been completed. ✓ No remaining loose parts in carton
  • Poulan BB185H42LT | User Manual - Page 9
    ENGAGED DANGER, KEEP HANDS AND FEET AWAY KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) FREE WHEEL (Automatic Models only) LIGHTS ON Failure to follow instructions could result in serious injury or death. The safety alert symbol is used to identify safety information about hazards
  • Poulan BB185H42LT | User Manual - Page 10
    YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual for future reference. LIGHT SWITCH THROTTLE/CHOKE CONTROL CLUTCH/BRAKE PEDAL ATTACHMENT CLUTCH LEVER IGNITION SWITCH ROS "ON" POSITION LIFT
  • Poulan BB185H42LT | User Manual - Page 11
    OPERATION The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your tractor or performing any adjustments or repairs. We recommend a wide vision safety mask over spectacles
  • Poulan BB185H42LT | User Manual - Page 12
    with tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO ADJUST MOWER CUTTING HEIGHT" in the Operation section of this manual). • With mower in desired height of cut position, gauge wheels should be assembled so they are slightly off the ground. Install gauge wheel in
  • Poulan BB185H42LT | User Manual - Page 13
    section of this manual). • To change engine oil, see the Maintenance section in this manual. ADD GASOLINE engine while in storage. To avoid engine problems, the fuel system should be emptied before Use fresh fuel next season. See Storage Instructions for additional information. Never use engine or
  • Poulan BB185H42LT | User Manual - Page 14
    for normal operation. MOWING TIPS • Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower should be used for trimming. • Drive so that clippings are discharged onto the area
  • Poulan BB185H42LT | User Manual - Page 15
    value from the warranty, operator must maintain tractor as instructed in this manual. Some adjustments will need to be made periodically to if you should make any of the adjustments described in the Service and Adjustments section of this manual. • At least once a year you should replace the spark
  • Poulan BB185H42LT | User Manual - Page 16
    Service and Adjustments section of this manual). TIRES • Maintain proper air pressure in all tires (See"PRODUCT SPECIFICATIONS" section of this manual the problem SHOWN IN THE REPAIR PARTS. TRAILING EDGE UP BLADE using a cone balancer, follow the instructions supplied with balancer). NOTE: Do
  • Poulan BB185H42LT | User Manual - Page 17
    with wire brush until bright. • Coat terminals with grease or petroleum jelly. • Reinstall battery (See "REPLACING BATTERY" in the SERVICE AND ADJUSTMENTS section of this manual). V-BELTS Check V-belts for deterioration and wear after 100 hours of operation and replace if necessary. The belts are
  • Poulan BB185H42LT | User Manual - Page 18
    to remove dirt and stubborn dried gum fibers. AIR FILTER Your engine will not run properly using a dirty air filter. Service air cleaner more often under dusty conditions. See Engine Manual. ENGINE OIL FILTER Replace the engine oil filter every season or every other oil change if the tractor is used
  • Poulan BB185H42LT | User Manual - Page 19
    BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS: • Make sure the blades and all moving parts have completely stopped. • Disconnect spark plug clutch cable housing guide into bracket, slide collar onto guide and secure with "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underin
  • Poulan BB185H42LT | User Manual - Page 20
    SERVICE mower from tractor (See "TO REMOVE MOWER" in this section of this manual). • Work belt off both mandrel pulleys and idler pulleys. • Pull belt . • Make sure belt is in all pulley grooves and inside all belt guides. • Install mower in reverse order of removal instruc- tions. MANDREL PULLEY
  • Poulan BB185H42LT | User Manual - Page 21
    , further maintenance is necessary. Replace brake pads or contact a qualified service center. OPERATING ARM 1-9/16" NUT "A" JAM NUT TO REPLACE MOTION DRIVE REMOVE MOWER" in this section of manual). NOTE: Observe entire motion drive belt and position of all belt guides and keepers. • Remove belt
  • Poulan BB185H42LT | User Manual - Page 22
    slow leaks, tire sealant may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. transmission require removal for service or replacement, it steering wheel and reassemble per instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER
  • Poulan BB185H42LT | User Manual - Page 23
    SERVICE If adjustment is necessary, see engine manual. TO ADJUST CHOKE CONTROL The choke not be necessary. If adjustment is necessary, see engne manual. POSITIVE (RED) CABLE NEGATIVE (BLACK) CABLE FIG. to suspected carburetor problems, take your tractor to an authorized service center for repair
  • Poulan BB185H42LT | User Manual - Page 24
    instructions in the Service and Adjustments section of this manual). • Lubricate as shown in the Maintenance section of this manual. • Be sure that all nuts, bolts and screws are securely fastened. Inspect moving parts /or dirt in your gasoline will cause problems. • If possible, store your tractor
  • Poulan BB185H42LT | User Manual - Page 25
    TROUBLESHOOTING POINTS PROBLEM Will not start CAUSE 1. Out of fuel. 2. Engine not "CHOKED" properly. 3. Engine in Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part(s).
  • Poulan BB185H42LT | User Manual - Page 26
    TROUBLESHOOTING POINTS PROBLEM wiring, switches and connections. If not corrected, contact an authorized service center/ department. Poor cut - uneven 1. Worn, bent blades sharp edge down. 10. Replace with blades listed in this manual. 11. Clean around mandrels to open vent holes. Headlight(s)
  • Poulan BB185H42LT | User Manual - Page 27
    charge for parts or labor incurred in replacing parts, any part which we be maintained in accordance with the instructions furnished. 4. The Warranty period for any product to an authorized service dealer. Should you Mississauga, Ontario L5T 1K6 giving the model number, serial number and date
  • Poulan BB185H42LT | User Manual - Page 28
    maintenance, improper use or abuse of the product, failure to follow the instructions contained in an Instruction Manual for the operation of the Power Train Component and parts. The cost of normal maintenance and replacement of service items which are not defective shall be paid for by the original
  • Poulan BB185H42LT | User Manual - Page 29
    29 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate
  • Poulan BB185H42LT | User Manual - Page 30
    the following information: a. Model Number/Manufacturer's I.D. Number b. Description of part. For Techical Assistance: call 1-800-829-5886 For a Parts Manual, go to our website: www.poulan-pro.com/support.asp NOTE: Electrolux Home Products provides parts and service through its authorized
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
OPERATOR'S MANUAL
MODEL:
BB185H42LT
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan-pro.com
WARNING:
Read this Manual and follow all Warnings and
Safety Instructions.
Failure to do so can result
in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
194992
10.26.04
RD
Printed in U.S.A.
02478