Poulan HD17542 User Manual

Poulan HD17542 Manual

Get Poulan HD17542 PDF manuals and user guides View all Poulan HD17542 manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan HD17542 manual content summary:

  • Poulan HD17542 | User Manual - Page 1
    Do Not Throw Away 02478 OPERATOR'S MANUAL MODEL: HD17542 LAWN TRACTOR WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 403315 12.12.05 TR
  • Poulan HD17542 | User Manual - Page 2
    cause you to lose control of your tractor. WARNING • Do not operate machine without riding mower-related injuries. These operators should evaluate their ability to operate the riding mower instructions on the machine and in the manual before starting. • Do not put hands or feet near rotating parts
  • Poulan HD17542 | User Manual - Page 3
    and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction labels, as necessary
  • Poulan HD17542 | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan HD17542 | User Manual - Page 5
    CONTENTS OF HARDWARE PACK Steering Wheel Seat Steering Boot (1) Large Flat Washer Steering Wheel Adapter Steering Wheel Insert Steering Extension Shaft (1) 5/16 Lock Washer (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Bolt Key (2) Keys (1) Oil Drain Tube Slope Sheet (1) Hex Bolt 5/16-18 x 4 5
  • Poulan HD17542 | User Manual - Page 6
    pressure gauge When right or left hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel). TO REMOVE TRACTOR FROM CARTON UNPACK CARTON • Remove all accessible loose parts and parts cartons from carton. • Cut along dashed lines on all four
  • Poulan HD17542 | User Manual - Page 7
    service after month and year indicated on label (label located between terminals) charge battery for minimum of one hour at 6-10 amps. (See "BATTERY" in MAINTENANCE section of this manual for charging instructions). SEAT PAN LABEL TERMINAL TERMINAL NOTE: You may now roll or drive your tractor
  • Poulan HD17542 | User Manual - Page 8
    See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is operating properly. See
  • Poulan HD17542 | User Manual - Page 9
    tractor or in literature supplied with the product. Learn and understand their meaning. REVERSE NEUTRAL HIGH LOW CHOKE FAST SLOW IGNITION SWITCH ENGINE OFF REVERSE OPERATION SYSTEM (ROS) ENGINE ON ENGINE START PARKING BRAKE MOWER HEIGHT MOWER Failure to follow instructions could result
  • Poulan HD17542 | User Manual - Page 10
    Standards Institute. ATTACHMENT CLUTCH LEVER - Used to engage the mower blades, or other attachments mounted to your tractor. ATTACHMENT LIFT LEVER - Used to raise, lower, and adjust the mower deck or other attachments mounted to your tractor. CLUTCH/BRAKE PEDAL - Used for declutching and braking
  • Poulan HD17542 | User Manual - Page 11
    ficiency. • Full speed (fast) offers the best mower performance. TO MOVE FORWARD AND BACKWARD (See Fig. and remove key. Always remove key when leaving tractor to prevent unauthorized use. • Never use choke during hot months. For healthier and better looking lawns, mow often and after moderate growth. •
  • Poulan HD17542 | User Manual - Page 12
    either the entire grass catcher, on mowers so equipped,or the deflector shield in place. ATTACHMENT CLUTCH LEVER "DISENGAGED" POSITION "ENGAGED" POSITION ATTACHMENT LIFT LEVER HIGH POSITION LOW POSITION DEFLECTOR SHIELD FIG. 6 REVERSE OPERATION SYSTEM (ROS) Your tractor is equipped with a Reverse
  • Poulan HD17542 | User Manual - Page 13
    . • Check engine oil with tractor on level ground. • Remove engine while in storage. To avoid engine problems, the fuel system should be emptied before Use fresh fuel next season. See Storage Instructions for additional information. Never use engine Service and Adjustments section of this manual. 13
  • Poulan HD17542 | User Manual - Page 14
    should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower should be used for trimming. • Drive so that clippings are discharged onto the area that has been cut. Have the cut area to the
  • Poulan HD17542 | User Manual - Page 15
    Mower Blades T Lubrication Chart 0 Check Battery Level R Clean Battery and Terminals Check Transaxle Cooling Check Mower temperatures. 2 - Service more often when operating tractor as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor
  • Poulan HD17542 | User Manual - Page 16
    tractor requires more than five (5) feet to stop at highest speed in highest gear on a level, dry concrete or paved surface, then brake must be checked and adjusted. (See "TO ADJUST BRAKE" in the Service and Adjustments section of this manual purchased from your local parts dealer. Tire sealant also
  • Poulan HD17542 | User Manual - Page 17
    terminals with grease or petroleum jelly. • Reinstall battery (See "REPLACING BATTERY" in the Service and Adjustment section of this manual). Change the oil after every 25 hours of operation or at least once a year if the tractor is not used for 25 hours in one year. Check the crankcase oil level
  • Poulan HD17542 | User Manual - Page 18
    a garden hose or pressure washer to clean your tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower. 18
  • Poulan HD17542 | User Manual - Page 19
    PERFORMING ANY SERVICE OR ADJUSTMENTS: parts have completely stopped. • Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. TRACTOR TO REMOVE MOWER (See Fig. 13) Mower clutch cable housing guide into bracket, slide collar onto guide and secure with
  • Poulan HD17542 | User Manual - Page 20
    SERVICE AND ADJUSTMENTS TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underinflated, you will not properly adjust your mower. SIDE-TO-SIDE
  • Poulan HD17542 | User Manual - Page 21
    MOTION DRIVE BELT (See Fig. 20) Park the tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal on bottom side of left footrest. BELT REMOVAL • Remove mower (See "TO REMOVE MOWER" in this section of manual). NOTE: Observe entire motion drive belt and
  • Poulan HD17542 | User Manual - Page 22
    bolt, move mower deck height to instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER TO ATTACH JUMPER CABLES • Connect one end of the RED cable to the POSITIVE (+) terminal of each battery(A-B), taking care not to short against tractor parts dealer. Tire sealant also
  • Poulan HD17542 | User Manual - Page 23
    and carefully remove battery from tractor. • Install new battery with front of tractor. Grasp hood at sides, tilt toward engine and lift off of tractor. • If adjustment is necessary, see engne manual. POSITIVE (RED) CABLE NEGATIVE (BLACK) problems, take your tractor to an authorized service
  • Poulan HD17542 | User Manual - Page 24
    enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan HD17542 | User Manual - Page 25
    TROUBLESHOOTING POINTS PROBLEM 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/ Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan HD17542 | User Manual - Page 26
    TROUBLESHOOTING POINTS PROBLEM CAUSE Engine dies when tractor is shifted into reverse 1. Reverse operation system (ROS) is not "ON" while mower Clean underside of mower housing. 8. Replace mower drive belt. 9. Reinstall blades sharp edge down. 10. Replace with blades listed in this manual. 11.
  • Poulan HD17542 | User Manual - Page 27
    option, without charge for parts or labor incurred in replacing parts, any part which we find to Battery must be maintained in accordance with the instructions furnished. 4. The Warranty period for any products used return the product to an authorized service dealer. Should you have any unanswered
  • Poulan HD17542 | User Manual - Page 28
    SERVICE NOTES 28
  • Poulan HD17542 | User Manual - Page 29
    29 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan HD17542 | User Manual - Page 30
    Techical Assistance: call 1-800-829-5886 For a Parts Manual, go to our website: www.poulan-pro.com/support.asp NOTE: Electrolux Home Products provides parts and service through its authorized distributors and dealers; therefore, all requests for parts and service should be directed to your local
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
OPERATOR'S MANUAL
MODEL:
HD17542
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan-pro.com
WARNING:
Read this Manual and follow all Warnings and
Safety Instructions.
Failure to do so can result
in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
403315
12.12.05
TR
Printed in U.S.A.
02478