Poulan HD1842 User Manual

Poulan HD1842 Manual

Get Poulan HD1842 PDF manuals and user guides View all Poulan HD1842 manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan HD1842 manual content summary:

  • Poulan HD1842 | User Manual - Page 1
    Not Throw Away 02478 OPERATOR'S MANUAL MODEL: HD1842 LAWN TRACTOR WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 195506 11.4.04 RD Printed
  • Poulan HD1842 | User Manual - Page 2
    INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. WARNING: In order to prevent accidental starting when setting up, transporting, adjusting understand, and follow all instructions on the machine and in the manual before starting. • Do not put hands or feet near rotating parts or under • the
  • Poulan HD1842 | User Manual - Page 3
    and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction labels, as necessary
  • Poulan HD1842 | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan HD1842 | User Manual - Page 5
    CONTENTS OF HARDWARE PACK Steering Wheel Seat Steering Boot Steering Extension Shaft Steering Wheel Insert (1) Large Flat Washer (1) 5/16 Lock Washer (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Lock Washer 1/2 (1) Bolt Key (2) Keys (1) Oil Drain Tube Slope Sheet Steering Wheel Adapter (1) Hex
  • Poulan HD1842 | User Manual - Page 6
    or left hand is mentioned in this manual, it means when you are in the FROM CARTON UNPACK CARTON • Remove all accessible loose parts and parts cartons from carton. • Cut along dotted lines SEAT (See Fig. 2) Adjust seat before tightening adjustment bolt. • Remove adjustment bolt, lock washer and
  • Poulan HD1842 | User Manual - Page 7
    position. • If this battery is put into service after month and year indicated on label (label located between terminals) charge battery for minimum of one hour at 6-10 amps. (See "BATTERY" in MAINTENANCE section of this manual for charging instructions). SEAT PAN LABEL TO ROLL TRACTOR OFF SKID
  • Poulan HD1842 | User Manual - Page 8
    BRAKE" in the Service and Adjustments section of this manual. ✓CHECKLIST BEFORE YOU OPERATE YOUR NEW TRACTOR, WE WISH TO ASSURE THAT YOU RECEIVE THE BEST PERFORMANCE AND SATISFACTION FROM THIS QUALITY PRODUCT. PLEASE REVIEW THE FOLLOWING CHECKLIST: ✓ All assembly instructions have been completed
  • Poulan HD1842 | User Manual - Page 9
    HANDS AND FEET AWAY KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) FREE WHEEL (Automatic Models only) LIGHTS ON Failure to follow instructions could result in serious injury or death. The safety alert symbol is used to identify safety information about hazards which can result in
  • Poulan HD1842 | User Manual - Page 10
    OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual for future reference. ATTACHMENT CLUTCH LEVER IGNITION SWITCH ROS "ON" POSITION THROTTLE/ CHOKE CONTROL LIGHT SWITCH LIFT LEVER
  • Poulan HD1842 | User Manual - Page 11
    into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your tractor or performing any adjustments or repairs. We recommend a wide vision safety mask over spectacles or standard safety glasses. HOW TO USE YOUR TRACTOR TO SET PARKING BRAKE (See
  • Poulan HD1842 | User Manual - Page 12
    OPERATION TO OPERATE MOWER (See Fig. 6) Your tractor is equipped with an operator presence sensing switch. Any attempt by the operator to leave the seat with the engine running and the attachment clutch engaged will shut off the engine. You must remain fully and centrally positioned in the seat to
  • Poulan HD1842 | User Manual - Page 13
    ) or in cold temperatures (below 32 F) the carburetor fuel mixture may need to be adjusted for best engine performance. See "TO ADJUST CARBURETOR" in the Service and Adjustments section of this manual. CAUTION: Alcohol blended fuels (called gasohol or using ethanol or methanol) can attract moisture
  • Poulan HD1842 | User Manual - Page 14
    OPERATION MOWING TIPS • Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower should be used for trimming. • Drive so that clippings are discharged onto the area that has been
  • Poulan HD1842 | User Manual - Page 15
    from the warranty, operator must maintain tractor as instructed in this manual. Some adjustments will need to be made periodically to properly maintain to see if you should make any of the adjustments described in the Service and Adjustments section of this manual. • At least once a year you should
  • Poulan HD1842 | User Manual - Page 16
    adjusted. (See "TO ADJUST BRAKE" in the Service and Adjustments section of this manual , repair the problem immediately. • APPROVE BOLT SHOWN IN THE REPAIR PARTS. TRAILING EDGE UP FLAT WASHER LOCK (When using a cone balancer, follow the instructions supplied with balancer.) NOTE: Do not use
  • Poulan HD1842 | User Manual - Page 17
    • Reinstall battery (See "REPLACING BATTERY" in the Service and Adjustment section of this manual). V-BELTS CheckV-belts for deterioration and wear after drain tube and replace the cap onto to the bottom fitting of the drain valve. • Refill engine with oil through oil fill dipstick tube. Pour slowly.
  • Poulan HD1842 | User Manual - Page 18
    remove dirt and stubborn dried gum fibers. AIR FILTER Your engine will not run properly using a dirty air filter. Service air cleaner more often under dusty conditions. See Engine Manual. MUFFLER Inspect and replace corroded muffler and spark arrester (if equipped) as it could create a fire hazard and
  • Poulan HD1842 | User Manual - Page 19
    ANY SERVICE OR ADJUSTMENTS: • Depress clutch/brake pedal fully and set parking brake. • Place gearshift lever in neutral (N) position. • Place attachment clutch in "DISENGAGED" position. • Turn ignition key to "STOP" and remove key. • Make sure the blades and all moving parts have completely
  • Poulan HD1842 | User Manual - Page 20
    SERVICE AND ADJUSTMENTS TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underinflated, you will not properly adjust of this manual). • Work
  • Poulan HD1842 | User Manual - Page 21
    manually push the tractor forward. If the rear wheels rotate, the brake needs to be adjusted or the pads need to be replaced. TO ADJUST Replace brake pads or contact a qualified service center. WITH PARKING BRAKE "ENGAGED" TO there is a belt installation guide decal on bottom side of left footrest. BELT
  • Poulan HD1842 | User Manual - Page 22
    instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER The front wheel toe-in and camber are not adjustable at tires due to slow leaks, tire sealant may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. RETAINING WASHERS RING
  • Poulan HD1842 | User Manual - Page 23
    in the Repair Parts section. TO REPLACE adjustment should not be necessary. If adjustment is necessary, see engne manual. TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service
  • Poulan HD1842 | User Manual - Page 24
    instructions in the Service and Adjustments section of this manual). • Lubricate as shown in the Maintenance section of this manual. • Be sure that all nuts, bolts and screws are securely fastened. Inspect moving parts /or dirt in your gasoline will cause problems. • If possible, store your tractor
  • Poulan HD1842 | User Manual - Page 25
    TROUBLESHOOTING POINTS PROBLEM CAUSE CORRECTION Will not start 1. Out of fuel. 2. Engine not "CHOKED" properly. 3. Engine flooded. 4. Bad spark plug. 5. Dirty air filter. 6. Dirty fuel filter. 7. Water in fuel. 8. Loose or damaged wiring. 9. Carburetor out of adjustment. 10. Engine valves out of
  • Poulan HD1842 | User Manual - Page 26
    TROUBLESHOOTING POINTS PROBLEM wiring, switches and connections. If not corrected, contact an authorized service center/ department. Poor cut - uneven 1. Worn, bent blades sharp edge down. 10. Replace with blades listed in this manual. 11. Clean around mandrels to open vent holes. Headlight(s)
  • Poulan HD1842 | User Manual - Page 27
    our option, without charge for parts or labor incurred in replacing parts, any part which we find to be properly assembled, adjusted, operated, and maintained in accordance with the instructions furnished. This must return the product to an authorized service dealer. Should you have any unanswered
  • Poulan HD1842 | User Manual - Page 28
    maintenance, improper use or abuse of the product, failure to follow the instructions contained in an Instruction Manual for the operation of the Power Train Component and parts. The cost of normal maintenance and replacement of service items which are not defective shall be paid for by the original
  • Poulan HD1842 | User Manual - Page 29
    29 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate
  • Poulan HD1842 | User Manual - Page 30
    Assistance: call 1-800-829-5886 For a Parts Manual, go to our website: www.poulan-pro.com/support.asp NOTE: Electrolux Home Products provides parts and service through its authorized distributors and dealers; therefore, all requests for parts and service should be directed to your local dealer
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
OPERATOR'S MANUAL
MODEL:
HD1842
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan-pro.com
WARNING:
Read this Manual and follow all Warnings and
Safety Instructions.
Failure to do so can result
in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
195506
11.4.04
RD
Printed in U.S.A.
02478