Poulan HDR500K User Manual
Poulan HDR500K Manual
 |
View all Poulan HDR500K manuals
Add to My Manuals
Save this manual to your list of manuals |
Poulan HDR500K manual content summary:
- Poulan HDR500K | User Manual - Page 1
'S MANUAL MODEL NO. HDR5OOK 5 HP 17 Inch Tiller • Assembly • Operation • Customer Responsibilities • Service and Adjustments • Storage • Troubleshooting • Repair Parts For Parts and Service, contact our authorized distributor: call 1-800-849-1297 For Technical Assistance: call 1-800-829-5886 Poulan - Poulan HDR500K | User Manual - Page 2
• Always refer to the operator's guide instructions for • Never attempt to make any parts. CAUTIONS, IMPORTANTS, AND NOTES ARE A MEANS OF ATTRACTING ATTENTION TO IMPORTANT OR CRITICAL INFORMATION IN THIS MANUAL cause. Vibration is generally a warning of trouble. IMPORTANT: USED TO ALERT YOU THAT - Poulan HDR500K | User Manual - Page 3
. Should you experience any problems you cannot easily remedy, please contact your nearest authorized service center. We have competent, well-trained technicians and the proper tools to service or repair this unit. Please read and retain this manual. The instructions will enable you to assemble - Poulan HDR500K | User Manual - Page 4
exception of those parts left unassembled for shipping purposes. To ensure safe and proper operation of your tiller, all parts and hardware you OPERATOR'S POSITION (See Fig. 1) When right orleft hand is mentionedin this manual, it means when you are in the operating position (standing behind tiller - Poulan HDR500K | User Manual - Page 5
place on top of carton. • Cut down right hand front and right hand rear corners of carton, lay side carton wall down. • Remove packing material from handle and loosely assemble locknut (See Fig. 5). • Insert pivot bolt in front part of plate and tighten. • Cut down remaining corners of carton and lay - Poulan HDR500K | User Manual - Page 6
tire pressure to 20 PSI (1.4 kg/cm2). HANDLE HEIGHT • Handle height may be adjusted to better suit operator. (See "TO ADJUST HANDLE HEIGHT" in the Service and Adjustments section of this manual). 6 - Poulan HDR500K | User Manual - Page 7
OPERATING YOUR TILLER. Compare the illustrations with your tiller to familiarize yourself with the location of various controls and adjustments. Save this manual for future reference. These symbols may appear on your Tiller or in literature supplied with the product. Learn and understand their - Poulan HDR500K | User Manual - Page 8
OPERATION WEAR YOUR FORESIGHT IS BETTER THAN NO SIGHT The operation of any tiller can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields before starting your tiller and while tilling. We recommend a wide vision safety - Poulan HDR500K | User Manual - Page 9
system of an engine while in storage. To avoid engine problems, the fuelsystem shouldbeemptiedbeforestorageof30days or longer. Drain the gas tank capacity see "PRODUCT SPECIFICATIONS" on page 3 of this manual. All oil must meet A.P.I. Service Classification SF-SJ. When starting engine for the first - Poulan HDR500K | User Manual - Page 10
TO ADJUST CARBURETOR" in the Service and Adjustments section of this manual. NOTE: If engine does not start, see troubleshooting points. • You will find break, replace only with those shown in the Repair Parts section of this manual. CULTIVATING TILLING HINTS FIG. 13 CAUTION: Until youare - Poulan HDR500K | User Manual - Page 11
OPERATION ADJUST WHEELS FOR CULTIVATING (See Figs. 16 and 17) • Place blocks under right hand side of tiller and remove hairpin clip and clevis pin from right hand wheel. • Move wheel outward approximately 1 inch (2.5 cm) until hole in inner wheel hub lines up with inner hole in axle. • Replace - Poulan HDR500K | User Manual - Page 12
full value from the warranty, the operator must maintain tiller as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tiller. All adjustments in the Service and Adjustments section of this manual should be checked at least once each season. • Once - Poulan HDR500K | User Manual - Page 13
temperature range expected before oil change. All oil must meet API service classification SF-SJ. • Be sure tiller is on level surface CHECK ENGINE OIL LEVEL" in the Operation section of this manual. AIR FILTER (See Fig. 20) Your engine will not blower housing and clean as necessary. • Keep cylinder fins free - Poulan HDR500K | User Manual - Page 14
BLOWER HOUSING gap setting is shown in "PRODUCT SPECIFICATIONS" on page 3 of this manual. TRANSMISSION Once a season, lubricate the right hand side gear case , etc. • Protect painted surfaces with automotive type wax. SERVICE AND ADJUSTMENTS a CAUTION: Disconnect spark plug wire from spark - Poulan HDR500K | User Manual - Page 15
SERVICE AND ADJUSTMENTS TINE REPLACEMENT (See Figs. 24, 25 and 26) A CAUTION: Tines are sharp. Wear gloves or otherprotection whenhandlingtines. A badly worn tine causes your tiller - Poulan HDR500K | User Manual - Page 16
SERVICE AND ADJUSTMENTS TO REMOVE BELT GUARD (See Fig. 27) NOTE: For ease of pulley and into engine pulley. BELT MUST BE IN GROOVE ON TOP OF IDLER PULLEY. NOTE POSITION OF BELT TO GUIDES. • Check belt adjustment as described below. • Replace belt guard. • Reposition wheel and replace clevis pin and - Poulan HDR500K | User Manual - Page 17
THE FACTORY HIGH SPEED SETTING CAN BE DANGEROUS. IF YOU THINK THE ENGINE-GOVERNED HIGH SPEED NEEDS ADJUSTING, CONTACT YOUR NEAREST AUTHORIZED SERVICE CENTER/ DEPARTMENT, WHICH HAS THE PROPER EQUIPMENT AND EXPERIENCE TO MAKE ANY NECESSARY ADJUSTMENTS. FUEL TANK CLAMP SCREW CASING AND WIRE FIG - Poulan HDR500K | User Manual - Page 18
instructions in the Service and Adjustments section of this manual). • Lubricate as shown in the Customer Responsibilities section of this manual. • Be sure that all nuts, bolts and screws are securely fastened. Inspect moving parts dirt in your gasoline will cause problems. • If possible, store your - Poulan HDR500K | User Manual - Page 19
TROUBLESHOOTING POINTS PROBLEM CAUSE Will not start 1. Out of fuel. 2. Engine not "CHOKED" properly. 3. air screen. 11. Clean/replace muffler. 12. Make necessary adjustments. 13. Contact an authorized service center/department. 1. Check oil level/change oil. 2. Clean engine air screen. 3. Clean - Poulan HDR500K | User Manual - Page 20
TILLER - - MODEL NUMBER HDR500K HANDLE ASSEMBLY 10 42 8 36 41 1 29 2 35 15 35 **/*/* 1 38 2 37 39 34 26 21 4 KEY NO. 1 2 4 5 8 10 11 15 16 17 18 19 20 PART NO. 175250 150744 159227 72110514 71191008 8389J 4497H 108281X 72110608 109229X 73680600 19131611 109228X DESCRIPTION Control - Poulan HDR500K | User Manual - Page 21
TILLER - - MODEL NUMBER HDR500K MAINFRAME, LEFT SIDE 3 3 2 65 „ • 6 39 7 8 43 9 10 %/ 11 12 37 36 35 34 4 3 32 16 0 38 31 O 19 N •\ --22 30 N z( N 28 3 27 KEY NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 19 21 22 23 24 25 26 PART NO. 73510500 10040600 73220600 170127 154734 110111X - Poulan HDR500K | User Manual - Page 22
REPAIR PARTS TILLER - - MODEL NUMBER HDR500K MAINFRAME, RIGHT SIDE 16 0 z 0 .., .....4.7 15 O ---. ". ...."' 2 ',.. 1 411\ ss.•, k. k 7 \ \ \ k . .. . ..... 0 I ,I,ifi 4 /0' , , \,-\N 0."...,.,,.,4 4 7r.e , . kt .„ . " „., Ni,s..,.-i.."-.4.. .14 ,-,----- .75 / ".A., - Poulan HDR500K | User Manual - Page 23
PARTS TILLER - MODEL NUMBER HDR500K TRANSMISSION 12\6 13 15 14 1117 16 24 25 24 kr160 14' 3 ! 2 9 5 18 7 6 23 5 \ 21 22 19 29 30 18 28 27 20 --A,S32 3 .7 18 24%-- 18 34 4 42 41 40 44 48 53 37 39 49; 7 3 36 24 50 2k 24 53 25 24 52 25 KEY PART - Poulan HDR500K | User Manual - Page 24
REPAIR PARTS TILLER - - MODEL NUMBER HDR500K TINE SHIELD 23 24 24 23 1 4 5 3 2 29 6 30/ 8 5 9 12 11 28 32 Tine 15 161414X428 Shield. Side, Outer R.H. 16 73900400 Nut, Hex Flange 1/4-20 UNC KEY PART NO. NO. DESCRIPTION 18 72040410 Bolt, Carriage 1/4-20 x 1-1/4 Gr. 5 19 102701X Grip - Poulan HDR500K | User Manual - Page 25
REPAIR PARTS TILLER - MODEL NUMBER HDR500K TINE ASSEMBLY 2 5 4 3 3 , ..,. 1 1 O ,'...-. s-,-„6 I ;". , , / '--\ .." • or „, / . / __, , .. 1-. . • A I '' •/.. ,' , , 4p.'' // j : e, „,' o," 4/, x / / :..---- ,, 0 1 .-. 7 fie, I ( /' ,`,,.M.. ( t -%4:: - Poulan HDR500K | User Manual - Page 26
NUMBER HDR500K DECALS d 2 4 10 O O 5 12 9 7 8 6 I -o.N 0 KEY PART NO. NO. 1 157384 2 157387 3 167386 4 143678 5 141907 6 102180X 7 175643 8 171077 9 141906 10 156199 11 171078 12 162215 - - 175668 - - 175669 DESCRIPTION Decal, Logo Decal, Description Decal, Logo Decal, Instruction, Tilling - Poulan HDR500K | User Manual - Page 27
option, without charge for parts or labor incurred in replacing parts, any part which we find to and maintained in accordance with the instructions furnished. This Warranty does not apply service dealer. Should you have any unanswered questions concerning this Warranty, please contact: Electrolux - Poulan HDR500K | User Manual - Page 28
Poulan
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
 |
 |
•
OWNER'S
MANUAL
MODEL
NO.
HDR5OOK
5
HP
17
Inch
Tiller
•
Assembly
•
Operation
•
Customer
Responsibilities
•
Service
and
Adjustments
•
Storage
•
Troubleshooting
•
Repair
Parts
For
Parts
and
Service,
contact
our
authorized
distributor:
call
1-800-849-1297
For
Technical
Assistance:
call
1-800-829-5886
Poulan
175668
Rev.
1
2.13.01
TR
PRINTED
IN
U.S.A.