Poulan PD18542STA User Manual

Poulan PD18542STA Manual

Get Poulan PD18542STA PDF manuals and user guides View all Poulan PD18542STA manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PD18542STA manual content summary:

  • Poulan PD18542STA | User Manual - Page 1
    IMPORTANT MANUAL Do Not Throw Away 02478 OWNER'S MANUAL MODEL: PD18542STA LAWN TRACTOR WARNING: Read this Owner's Manual and follow allWarnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION 188737 11.18.03 MH Printed in
  • Poulan PD18542STA | User Manual - Page 2
    FOR RIDE-ON MOWERS IMPORTANT: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. I. GENERAL OPERATION • Read, understand, and follow all instructions in the manual and
  • Poulan PD18542STA | User Manual - Page 3
    SAFETY RULES SAFE OPERATION PRACTICES FOR RIDE-ON MOWERS • Be sure the area is clear of is dangerous. Tires can lose traction with the ground and cause you to lose control of your tractor. WARNING Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals
  • Poulan PD18542STA | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan PD18542STA | User Manual - Page 5
    CONTENTS OF HARDWARE PACK Steering Wheel Seat Steering Boot Steering Wheel Adapter (1) Large Flat Washer Steering Steering Wheel Extension Insert Shaft (1) Locknut 1/2-20 (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Knob Key (2) Keys (1) Locknut 1/4-28 (1) Oil Drain Tube Slope Sheet (1) Hex Bolt
  • Poulan PD18542STA | User Manual - Page 6
    or left hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel). INSERT 1/2 HEX NUT LARGE FLAT WASHER TO REMOVE TRACTOR FROM CARTON UNPACK CARTON • Remove all accessible loose parts and parts cartons from carton. • Cut along dotted
  • Poulan PD18542STA | User Manual - Page 7
    gauge wheels before operating mower. See "TO ADJUST GAUGE WHEELS" in the Operation section of this manual. RETAINER SPRING FIG. 3 NOTE: You may now roll or drive your tractor off the skid. Follow the appropriate instruction below to remove the tractor from the skid. TO ROLL TRACTOR OFF SKID (See
  • Poulan PD18542STA | User Manual - Page 8
    See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is properly adjusted. See
  • Poulan PD18542STA | User Manual - Page 9
    MOWER LIFT 15 ATTACHMENT ATTACHMENT CLUTCH ENGAGED CLUTCH DISENGAGED DANGER, KEEP HANDS AND FEET AWAY KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) FREE WHEEL (Automatic Models only) Failure to follow instructions could result in damage to the tractor and/or engine. HOT SURFACES
  • Poulan PD18542STA | User Manual - Page 10
    TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual engage the mower blades, or other attachments mounted to your tractor. LIGHT
  • Poulan PD18542STA | User Manual - Page 11
    • Full throttle offers the best bagging and mower perfor- mance. THROTTLE/ CHOKE CONTROL LEVER and remove key. Always remove key when leaving tractor to prevent unauthorized use. The position of the during hot months. For healthier and better looking lawns, mow often and after moderate growth. •
  • Poulan PD18542STA | User Manual - Page 12
    prevent scalping in most terrain conditions. NOTE:Adjust gauge wheels with tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO AD- JUST MOWER CUTTING HEIGHT" in the Operation section of this manual). • Remove retainer spring and clevis pin which secure each gauge wheel
  • Poulan PD18542STA | User Manual - Page 13
    oil with tractor on Service and Adjustments section of this manual problems, the fuel system should be emptied before storage of 30 days or longer. Drain the gas tank, start the engine and let it run until the fuel lines and carburetor are empty. Use fresh fuel next season. See Storage Instructions
  • Poulan PD18542STA | User Manual - Page 14
    best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower should be used for trimming. • them in size so that as they fall onto the lawn they will disperse into the grass and not be noticed. Also, the mulched
  • Poulan PD18542STA | User Manual - Page 15
    as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual. • At least once a year you should
  • Poulan PD18542STA | User Manual - Page 16
    may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. OPERATOR PRESENCE SYSTEM Be sure operator presence and interlock systems are working properly. If your tractor does not function as described, repair the problem immediately. • The engine should not
  • Poulan PD18542STA | User Manual - Page 17
    FILTER Your engine will not run properly using a dirty air filter. Service air cleaner more often under dusty conditions. See Engine Manual. ENGINE OIL FILTER Replace the engine oil filter every season or every other oil change if the tractor is used more than 100 hours in one year. MUFFLER Inspect
  • Poulan PD18542STA | User Manual - Page 18
    a garden hose or pressure washer to clean your tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower. 18
  • Poulan PD18542STA | User Manual - Page 19
    PERFORMING ANY SERVICE OR ADJUSTMENTS: parts have completely stopped. • Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. TRACTOR TO REMOVE MOWER (See Fig. 17) Mower clutch cable housing guide into bracket, slide collar onto guide and secure with
  • Poulan PD18542STA | User Manual - Page 20
    SERVICE AND ADJUSTMENTS TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underinflated, you will not properly adjust your mower. SIDE-TO-SIDE
  • Poulan PD18542STA | User Manual - Page 21
    MOTION DRIVE BELT (See Fig. 24) Park the tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal on bottom side of left footrest. BELT REMOVAL • Remove mower (See "TO REMOVE MOWER" in this section of manual). NOTE: Observe entire motion drive belt and
  • Poulan PD18542STA | User Manual - Page 22
    instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER The front wheel toe-in and camber are not adjustable on your tractor due to slow leaks, tire sealant may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. RETAINING WASHERS
  • Poulan PD18542STA | User Manual - Page 23
    adjustment should not be necessary. If adjustment is necessary, see engne manual. TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment. 23
  • Poulan PD18542STA | User Manual - Page 24
    enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan PD18542STA | User Manual - Page 25
    TROUBLESHOOTING POINTS PROBLEM 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/ Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan PD18542STA | User Manual - Page 26
    TROUBLESHOOTING POINTS PROBLEM CAUSE Engine continues to run when operator leaves seat with attachment clutch engaged 1. Faulty operator-safety presence control system. CORRECTION 1. Check wiring, switches and connections. If not corrected, contact an authorized service center/ department.
  • Poulan PD18542STA | User Manual - Page 27
    REPAIR PARTS TRACTOR - - MODEL NUMBER PD1842ST (PD18542STA) SCHEMATIC RED BATTERY BLACK A AMMETER (OPTIONAL) RED WHITE RED S BM G A1 L A2 WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. 27
  • Poulan PD18542STA | User Manual - Page 28
    TRACTOR - - MODEL NUMBER PD1842ST (PD18542STA) ELECTRICAL 22 21 42 24 41 43 27 27 26 40 27 27 25 33 30 16 16 8 27 2 1 D.C. AMPERES 45 52 28 29 90 28
  • Poulan PD18542STA | User Manual - Page 29
    TRACTOR - - MODEL NUMBER PD1842ST (PD18542STA) ELECTRICAL KEY PART NO. NO. 1 163465 2 74760412 8 176689 16 176138 21 183759 22 4152J 24 4799J 25 146147 26 175158 27 73510400 28 4207J 29 121305X 30 175566
  • Poulan PD18542STA | User Manual - Page 30
    CHASSIS TRACTOR - - MODEL NUMBER PD1842ST (PD18542STA) 259 264 28 258 263 17 159 30 24 18 261 39 25 26 31 209 209 24 25 26 5 5 208 11 9 207 209 208
  • Poulan PD18542STA | User Manual - Page 31
    TRACTOR - - MODEL NUMBER PD1842ST (PD18542STA) CHASSIS AND ENCLOSURES KEY PART 6/16-18 x 1/2 TYT Bracket Asm Pivot Mower Rear Bracket Pivot Duct Air Dash Lower STLT Thdr 3/8-16 x 3/4 Nut Hex Flange Lock Lens Grille Pro RH Lens Grille Pro LH Insert Grille Bezel Grille LH Bezel Grille RH Plug BTN
  • Poulan PD18542STA | User Manual - Page 32
    DRIVE TRACTOR - - MODEL NUMBER PD1842ST (PD18542STA) 57 89 120 69 197 81 59 84 198 161 159 158 61 162 85 13 21 10 56 169 112 14 83 41 14
  • Poulan PD18542STA | User Manual - Page 33
    DRIVE TRACTOR - - MODEL NUMBER PD1842ST (PD18542STA) KEY PART NO. NO. 1 ------ 2 146682 3 123666X 4 12000028 5 Washer Lock Hvy Hlcl Spr 7/16 Keeper Belt Engine Foolproof Screw Hex wsh HiLo 1/4 x 1/2 unc Guide Belt Mower Drive RH Spacer Axle Washer 25/32 x 1-1/4 x 16 Ga E-ring #5133-75 Key Square 2
  • Poulan PD18542STA | User Manual - Page 34
    TRACTOR - - MODEL NUMBER PD1842ST (PD18542STA) STEERING ASSEMBLY 38 12 39 1 37 44 51 91 43 41 42 37 36 54 88 71 29 17 68 29 15 15 15 steering_pl.lt_47 82 29 46 8 6 2 87 5 68 67 13 65 46 8 6 67 67 3 40 32 11 26 87 5 4 43 28 10 30 43 95 8 34
  • Poulan PD18542STA | User Manual - Page 35
    TRACTOR - - MODEL NUMBER PD1842ST (PD18542STA) STEERING ASSEMBLY KEY PART NO. NO. DESCRIPTION 1 184704X428 Wheel Steering 2 184706 Axle Asm Cast Iron LT 3 169840 Spindle Asm LH 4 169839 Spindle Asm RH 5 6266H Bearing Race Thrust Harden 6
  • Poulan PD18542STA | User Manual - Page 36
    TRACTOR - - MODEL NUMBER PD1842ST (PD18542STA) SEAT ASSEMBLY 1 14 24 8 9 7 10 5 8 9 7 5 6 22 2 21 16 25 15 11 4 13 17 12 3 seat_lt.knob_1 KEY PART 32 x 1 x 14 Ga. Pan Seat Knob Seat Bracket Mounting Switch KEY PART NO. NO. 13 121248X 14 72050412 15 134300 16 121250X 17 123976X 21
  • Poulan PD18542STA | User Manual - Page 37
    TRACTOR - - MODEL NUMBER PD1842ST (PD18542STA) 7 11 16 4 9 43 8 6 10 20 1 12 5 14 KEY PART Manual Owner's (English) Manual Owner's (French) KEY PART NO. NO. DESCRIPTION 1 59192 Cap Valve Tire 2 65139 Stem Valve 3 106222X Tire F T 15 x 6 0 - 6 Service 4 59904 Tube Front (Service
  • Poulan PD18542STA | User Manual - Page 38
    TRACTOR - - MODEL NUMBER PD1842ST (PD18542STA) 2 3 72 1 81 13 4 78 38 32 14 44 78 46 33 31 37 33 45 29 23 OPTIONAL EQUIPMENT Spark Arrester engine-bs.1cyl_48 KEY PART inches 1 inch = 25.4 mm For engine service and replacement parts, call the toll free number for your engine
  • Poulan PD18542STA | User Manual - Page 39
    TRACTOR - - MODEL NUMBER PD1842ST (PD18542STA) MOWER LIFT 7 8 5 11 19 13 31 32 13 13 4 6 12 13 3 1 2 6 5 4 20 15 1617 18 20 20 19 31 32 20 15 lift-rh.1piece_3 KEY NO. 1 2 3 4 5 6 7 8 11 12 13 15 16 17 18 19 20 31 32 PART NO. 159461 159476 178981 12000002 19211621 120183X 125631X 124526X
  • Poulan PD18542STA | User Manual - Page 40
    TRACTOR - - MODEL NUMBER PD1842ST (PD18542STA) MOWER DECK 67 158 185 42_clutch_mod_7 152 159 46 44 56 53 52 55 134 135 136 116 117 119 113 48 142 147 21 5 140 1
  • Poulan PD18542STA | User Manual - Page 41
    TRACTOR - - MODEL NUMBER PD1842ST (PD18542STA) MOWER DECK KEY PART NO. NO. DESCRIPTION 1 182032X421 Mower Deck Assembly, 42" 2 72140506 Asm. Whl Ga. F RH Bracket Asm Whl Ga. F LH Arm Spring Brake Mower Bracket Arm Idler 42" Keeper Belt 42" Clutch Cable Pulley Idler Flat Bolt Carriage Idler
  • Poulan PD18542STA | User Manual - Page 42
    SERVICE NOTES 42
  • Poulan PD18542STA | User Manual - Page 43
    SERVICE NOTES 43
  • Poulan PD18542STA | User Manual - Page 44
    SERVICE NOTES 44
  • Poulan PD18542STA | User Manual - Page 45
    option, without charge for parts or labor incurred in replacing parts, any part which we find to Battery must be maintained in accordance with the instructions furnished. 4. The Warranty period for any products used return the product to an authorized service dealer. Should you have any unanswered
  • Poulan PD18542STA | User Manual - Page 46
    instructions contained in an Instruction Manual for the operation of the Power Train Component and parts. The cost of normal maintenance and replacement of service legal rights which vary from state to state. E. No Dealer Warranty Tecumseh neither assumes nor authorizes any other person, natural or
  • Poulan PD18542STA | User Manual - Page 47
    47 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan PD18542STA | User Manual - Page 48
    pages of your phone directory for the name of the nearest service dealer (under "saws" for Chain Saws or under "lawn mowers" for Trimmers, Brushcutters, and Blowers). 3. For replacement parts, have available the following information: a. Model Number/Manufacturer's I.D. Number b. Description of
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
OWNER'S MANUAL
MODEL:
PD18542STA
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
WARNING:
Read this Owner's Manual and follow all Warn-
ings and Safety Instructions.
Failure to do so
can result in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
188737
11.18.03
MH
Printed in U.S.A.
02478