Poulan PD185H42STB User Manual

Poulan PD185H42STB Manual

Get Poulan PD185H42STB PDF manuals and user guides View all Poulan PD185H42STB manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PD185H42STB manual content summary:

  • Poulan PD185H42STB | User Manual - Page 1
    IMPORTANT MANUAL Do Not Throw Away 02777 OWNER'S MANUAL MODEL: PD185H42STB LAWN TRACTOR WARNING: Read this Owner's Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION 190944 1.23.04 RD Printed in
  • Poulan PD185H42STB | User Manual - Page 2
    instructions in the • Do not turn on slopes unless necessary, and then, manual SERVICE • Data indicates that operators, age 60 years and above, • Use extra care in handling gasoline and other fuels. are involved in a large percentage of riding mower so that you will parts or allow objects to be
  • Poulan PD185H42STB | User Manual - Page 3
    SAFETY RULES Safe Operation Practices for Ride-On Mowers • Be sure the area is clear of is dangerous. Tires can lose traction with the ground and cause you to lose control of your tractor. WARNING Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals
  • Poulan PD185H42STB | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan PD185H42STB | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Seat Steering Boot Steering Wheel Adapter (1) Large Flat Washer Steering Steering Wheel Extension Insert Shaft (1) Locknut 1/2-20 (1) Washer 17/32 x 1-3/16 x 12 Gauge (1)
  • Poulan PD185H42STB | User Manual - Page 6
    is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel). TO REMOVE TRACTOR FROM CARTON STEERING WHEEL INSERT 1/2 LOCK WASHER LARGE FLAT WASHER STEERING BOOT UNPACK CARTON • Remove all accessible loose parts and parts cartons from carton
  • Poulan PD185H42STB | User Manual - Page 7
    • If this battery is put into service after month and year indicated on label (label located between terminals) charge battery for minimum of one hour at 6-10 amps. (See "BATTERY" in MAINTENANCE section of this manual for charging instructions). TO DRIVE TRACTOR OFF SKID (See Operation section for
  • Poulan PD185H42STB | User Manual - Page 8
    See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is properly adjusted. See
  • Poulan PD185H42STB | User Manual - Page 9
    MOWER LIFT 15 ATTACHMENT ATTACHMENT CLUTCH ENGAGED CLUTCH DISENGAGED DANGER, KEEP HANDS AND FEET AWAY KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) FREE WHEEL (Automatic Models only) Failure to follow instructions could result in damage to the tractor and/or engine. HOT SURFACES
  • Poulan PD185H42STB | User Manual - Page 10
    TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual engage the mower blades, or other attachments mounted to your tractor. LIGHT
  • Poulan PD185H42STB | User Manual - Page 11
    and to over 3 inches during hot months. For healthier and better looking lawns, mow often and after moderate growth. • For best cutting performance, key when leaving tractor to prevent unauthorized use. Gauge wheels are properly adjusted when they are slightly off the ground when mower is at the
  • Poulan PD185H42STB | User Manual - Page 12
    desired cutting height (See "TO ADJUST MOWER CUTTING HEIGHT" in the Operation section of this manual). • Remove retainer spring and clevis CHANGE THE CUTTING HEIGHT OF THE MOWER DECK. RETAINER SPRING CLEVIS PIN FIG. 8 TO OPERATE MOWER (See Fig. 9) Your tractor is equipped with an operator presence
  • Poulan PD185H42STB | User Manual - Page 13
    . To avoid engine problems, the fuel system next season. See Storage Instructions for additional information. Never Service and Adjustments section of this manual. PURGE TRANSMISSION To ensure proper operation and performance, it is recommended that the transmission be purged before operating tractor
  • Poulan PD185H42STB | User Manual - Page 14
    approximately 20 feet. After the tractor moves approximately 20 feet in Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower fall onto the lawn they will disperse into the grass
  • Poulan PD185H42STB | User Manual - Page 15
    as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual. • At least once a year you should
  • Poulan PD185H42STB | User Manual - Page 16
    may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. OPERATOR PRESENCE SYSTEM Be sure operator presence and interlock systems are working properly. If your tractor does not function as described, repair the problem immediately. • The engine should not
  • Poulan PD185H42STB | User Manual - Page 17
    battery (See "REPLACING BATTERY" in the SERVICE AND ADJUSTMENTS section of this manual). V-BELTS TO CHANGE ENGINE OIL (See Figs. 15 and 16) Determine temperature range expected before oil change. All oil must meet API service classification SF-SJ. • Be sure tractor is on level surface. • Oil will
  • Poulan PD185H42STB | User Manual - Page 18
    " section of this manual. IN-LINE FUEL FILTER tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower
  • Poulan PD185H42STB | User Manual - Page 19
    small retainer spring. • Install belt onto engine pulley. TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underinflated, you will not properly
  • Poulan PD185H42STB | User Manual - Page 20
    tractor (See "TO REMOVE MOWER" in this section of this manual). • Work belt off both mandrel pulleys and idler pulleys. • Pull belt away from mower. BELT INSTALLATION • Install new belt in reverse order of removal. • Make sure belt is in all pulley grooves and inside all belt guides. • Install mower
  • Poulan PD185H42STB | User Manual - Page 21
    brake pads or contact a qualified service center. BELT INSTALLATION • Carefully work tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal on bottom side of left footrest. BELT REMOVAL • Remove mower (See "TO REMOVE MOWER" in this section of manual
  • Poulan PD185H42STB | User Manual - Page 22
    instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER The front wheel toe-in and camber are not adjustable on your tractor due to slow leaks, tire sealant may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. WASHERS RETAINING
  • Poulan PD185H42STB | User Manual - Page 23
    factory and adjustment should not be necessary. If adjustment is necessary, see engne manual. POSITIVE (RED) CABLE FIG. 30 NEGATIVE (BLACK) CABLE TO REPLACE not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment.
  • Poulan PD185H42STB | User Manual - Page 24
    enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan PD185H42STB | User Manual - Page 25
    TROUBLESHOOTING POINTS PROBLEM 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/ Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan PD185H42STB | User Manual - Page 26
    for proper air pressure. 6. Replace/sharpen blade. Tighten blade bolt. 7. Clean underside of mower housing. 8. Replace mower drive belt. 9. Reinstall blades sharp edge down. 10. Replace with blades listed in this manual. 11. Clean around mandrels to open vent holes. Headlight(s) not working (if so
  • Poulan PD185H42STB | User Manual - Page 27
    TRACTOR - - MODEL NUMBER PD185H42ST (PD185H42STB) SCHEMATIC RED BATTERY BLACK A AMMETER (OPTIONAL) RED WHITE RED S BM G A1 L A2 CONNECTIONS WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. 27
  • Poulan PD185H42STB | User Manual - Page 28
    TRACTOR - - MODEL NUMBER PD185H42ST (PD185H42STB) ELECTRICAL 22 21 42 24 41 43 27 27 26 40 27 27 25 33 30 16 16 8 27 2 1 D.C. AMPERES 45 52 28 29 90 28
  • Poulan PD185H42STB | User Manual - Page 29
    TRACTOR - - MODEL NUMBER PD185H42ST (PD185H42STB) ELECTRICAL KEY PART NO. NO. 1 163465 2 74760412 8 176689 16 176138 21 183759 22 4152J 24 4799J 25 146147 26 175158 27 73510400 28 4207J 29 121305X 30 175566
  • Poulan PD185H42STB | User Manual - Page 30
    TRACTOR - - MODEL NUMBER PD185H42ST (PD185H42STB) CHASSIS 259 264 28 258 263 17 159 30 24 18 261 39 25 26 31 209 208 11 209 9 207 26 24 25 26 5 5
  • Poulan PD185H42STB | User Manual - Page 31
    TRACTOR - - MODEL NUMBER PD185H42ST (PD185H42STB) CHASSIS KEY PART NO. -18 x 1/2 TYT 38 175710 Bracket Asm Pivot Mower Rear 39 174714 Bracket Pivot 58 184322 Duct Air 64 16 x 3/4 258 183835X599 Lens Grille Pro RH 259 183834X599 Lens Grille Pro LH 261 183829Z428 Insert Grille 263 183832
  • Poulan PD185H42STB | User Manual - Page 32
    TRACTOR - - MODEL NUMBER PD185H42ST (PD185H42STB) DRIVE 120 57 89 263 90 197 85 245 247 85 81 32 30 52 16 95 63 246 263 251 169 159 161 198
  • Poulan PD185H42STB | User Manual - Page 33
    TRACTOR - - MODEL NUMBER PD185H42ST (PD185H42STB) DRIVE KEY PART NO. NO. 1 ------ 8 165619 10 76020416 Engine Bolt Hex 7/16-20 x 4 x Gr. 5-1.5 Thr Washer Keeper Belt Engine KEY PART NO. NO. DESCRIPTION 70 134683 Guide Belt 74 137057 Spacer, Axle 75 121749X Washer 25/32 x 1-1/4 x 16 Ga. 76
  • Poulan PD185H42STB | User Manual - Page 34
    TRACTOR - - MODEL NUMBER PD185H42ST (PD185H42STB) STEERING ASSEMBLY 38 12 39 1 37 44 51 91 43 41 42 37 36 54 88 71 29 17 68 29 15 15 15 steering_pl.lt_47 82 29 46 8 6 2 87 5 68 67 13 65 46 8 6 67 67 3 40 32 11 26 87 5 4 43 28 10 30 43 95 8 34
  • Poulan PD185H42STB | User Manual - Page 35
    TRACTOR - - MODEL NUMBER PD185H42ST (PD185H42STB) STEERING ASSEMBLY KEY PART NO. NO. DESCRIPTION 1 184704X428 Wheel Steering 2 184706 Axle Asm Cast Iron LT 3 169840 Spindle Asm LH 4 169839 Spindle Asm RH 5 6266H Bearing Race Thrust Harden 6
  • Poulan PD185H42STB | User Manual - Page 36
    TRACTOR - - MODEL NUMBER PD185H42ST (PD185H42STB) SEAT ASSEMBLY 1 14 24 8 9 7 10 5 8 9 7 5 6 22 2 21 16 25 15 11 4 13 17 12 3 seat_lt.knob_1 KEY PART 32 x 1 x 14 Ga. Pan Seat Knob Seat Bracket Mounting Switch KEY PART NO. NO. 13 121248X 14 72050412 15 134300 16 121250X 17 123976X 21
  • Poulan PD185H42STB | User Manual - Page 37
    TRACTOR - - MODEL NUMBER PD185H42ST (PD185H42STB) DECALS 7 11 16 4 9 43 8 6 10 20 1 12 5 14 KEY PART NO. NO. 1 157032 3 186164 4 189289 5 189288 6 170563 7 190928 8 179128 9 172740 10 157140 11 172743 12 173587 13 173589 DESCRIPTION Decal Oper Decal Hood LH Decal
  • Poulan PD185H42STB | User Manual - Page 38
    TRACTOR - - MODEL NUMBER PD185H42ST (PD185H42STB) ENGINE 2 3 72 1 81 13 4 78 38 32 14 44 78 46 33 31 37 33 45 29 23 OPTIONAL EQUIPMENT Spark Arrester engine-bs.1cyl_48 KEY PART engine service and replacement parts, call the toll free number for your engine manufacturer listed
  • Poulan PD185H42STB | User Manual - Page 39
    TRACTOR - - MODEL NUMBER PD185H42ST (PD185H42STB) MOWER LIFT 7 8 5 11 19 13 31 32 13 13 4 6 12 13 3 1 2 6 5 4 20 15 1617 18 20 20 19 31 32 20 15 lift-rh.1piece_3 KEY PART NO. NO. DESCRIPTION 1 159461 Wire Asm Inner/Sprg W/plunger 2 159476 Shaft Asm Lift RH w/Inf 3 188822 Pin
  • Poulan PD185H42STB | User Manual - Page 40
    TRACTOR - - MODEL NUMBER PD185H42ST (PD185H42STB) MOWER DECK 67 158 185 42_clutch_mod_7 152 159 46 44 56 53 52 55 134 135 136 116 117 119 113 48 142 147 21 5 140 1
  • Poulan PD185H42STB | User Manual - Page 41
    TRACTOR - - MODEL NUMBER PD185H42ST (PD185H42STB) MOWER DECK KEY PART NO. NO. DESCRIPTION 1 182032X421 Mower Deck Assembly, 42" 2 72140506 Bolt 3 138017 Bracket Asm Fr. Sway Bar 3/42 4 165460 Bracket Asm Deck 42" Sway Bar 5 4939M Retainer Spring 6 178024 Bar Sway
  • Poulan PD185H42STB | User Manual - Page 42
    SERVICE NOTES 42
  • Poulan PD185H42STB | User Manual - Page 43
    SERVICE NOTES 43
  • Poulan PD185H42STB | User Manual - Page 44
    SERVICE NOTES 44
  • Poulan PD185H42STB | User Manual - Page 45
    option, without charge for parts or labor incurred in replacing parts, any part which we find to Battery must be maintained in accordance with the instructions furnished. 4. The Warranty period for any products used return the product to an authorized service dealer. Should you have any unanswered
  • Poulan PD185H42STB | User Manual - Page 46
    instructions contained in an Instruction Manual for the operation of the Power Train Component and parts. The cost of normal maintenance and replacement of service legal rights which vary from state to state. E. No Dealer Warranty Tecumseh neither assumes nor authorizes any other person, natural or
  • Poulan PD185H42STB | User Manual - Page 47
    47 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan PD185H42STB | User Manual - Page 48
    pages of your phone directory for the name of the nearest service dealer (under "saws" for Chain Saws or under "lawn mowers" for Trimmers, Brushcutters, and Blowers). 3. For replacement parts, have available the following information: a. Model Number/Manufacturer's I.D. Number b. Description of
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
OWNER'S MANUAL
MODEL:
PD185H42STB
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
WARNING:
Read this Owner's Manual and follow all
Warnings and Safety Instructions.
Failure
to do so can result in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
190944
1.23.04
RD
Printed in U.S.A.
02777