Poulan PD18H42STA User Manual

Poulan PD18H42STA Manual

Get Poulan PD18H42STA PDF manuals and user guides View all Poulan PD18H42STA manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PD18H42STA manual content summary:

  • Poulan PD18H42STA | User Manual - Page 1
    IMPORTANT MANUAL Do Not Throw Away 02478 OWNER'S MANUAL MODEL: PD18H42STA LAWN TRACTOR WARNING: Read this Owner's Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION 184581 Rev. 1 02.12.03 RH Printed
  • Poulan PD18H42STA | User Manual - Page 2
    SAFETY RULES SAFE OPERATION PRACTICES FOR RIDE-ON MOWERS IMPORTANT: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. I. GENERAL OPERATION DO NOT: • Read, understand,
  • Poulan PD18H42STA | User Manual - Page 3
    RIDE-ON MOWERS IMPORTANT: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS with the ground and cause you to lose control of your tractor. WARNING Engine exhaust, some of its constituents, and certain vehicle
  • Poulan PD18H42STA | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan PD18H42STA | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Seat Steering Sleeve (1) Large Flat Washer Steering Wheel Insert Steering Extension Shaft (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Knob Gauge Wheel (4) Adjusting Bar (4)
  • Poulan PD18H42STA | User Manual - Page 6
    or left hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel). INSERT 1/2 HEX NUT LARGE FLAT WASHER TO REMOVE TRACTOR FROM CARTON UNPACK CARTON • Remove all accessible loose parts and parts cartons from carton . • Cut along dotted
  • Poulan PD18H42STA | User Manual - Page 7
    . • Adjust gauge wheels before operating mower. See "TO ADJUST GAUGE WHEELS" in the Operation section of this manual. NOTE: You may now roll or drive your tractor off the skid. Follow the appropriate instruction below to remove the tractor from the skid. TO ROLL TRACTOR OFF SKID (See Op- eration
  • Poulan PD18H42STA | User Manual - Page 8
    of this manual. ✓CHECKLIST BEFOREYOU OPERATE AND ENJOYYOUR NEW TRACTOR, WE WISH TO ASSURE THAT YOU RECEIVE THE BEST PERFORMANCE AND SATISFACTION FROM THIS QUALITY PRODUCT. PLEASE REVIEW THE FOLLOWING CHECKLIST: ✓ All assembly instructions have been completed. ✓ No remaining loose parts in carton
  • Poulan PD18H42STA | User Manual - Page 9
    MOWER LIFT 15 15 15 ATTACHMENT ATTACHMENT CLUTCH ENGAGED CLUTCH DISENGAGED DANGER, KEEP HANDS AND FEET AWAY KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) FREE WHEEL (Automatic Models only) Failure to follow instructions result in damage to the tractor and/or engine. HOT SURFACES
  • Poulan PD18H42STA | User Manual - Page 10
    TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual engage the mower blades, or other attachments mounted to your tractor. LIGHT
  • Poulan PD18H42STA | User Manual - Page 11
    tractor with motion control lever in neutral (N) position. • Release parking brake. • Slowly move motion control lever to desired position. TO ADJUST MOWER CUTTING HEIGHT (See Fig. 6) STOPPING (See Fig. 6) MOWER BLADES - • To stop mower being mowed. • The average lawn should be cut to approximately
  • Poulan PD18H42STA | User Manual - Page 12
    prevent scalping in most terrain conditions. NOTE:Adjust gauge wheels with tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO AD- JUST MOWER CUTTING HEIGHT" in the Operation section of this manual). • Remove retainer spring and clevis pin which secure each gauge wheel
  • Poulan PD18H42STA | User Manual - Page 13
    storage. To avoid engine problems, the fuel system should be fuel next season. See Storage Instructions for additional information. Never use fications of the manufacturer of your tractor. Use common sense when towing. manual). • To change engine oil, see the Maintenance section in this manual.
  • Poulan PD18H42STA | User Manual - Page 14
    (See "TO TRANSPORT" in this section of manual). • Sitting in the tractor seat, start engine. After the engine is running Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower
  • Poulan PD18H42STA | User Manual - Page 15
    MOWING TIPS IMPORTANT: FOR BEST PERFORMANCE, KEEP MOWER HOUSING FREE OF BUILT-UP GRASS AND TRASH. CLEAN AFTER EACH USE. • The special mulching blade will recut the grass clippings many times and reduce them in size so that as they fall onto the lawn they will disperse into the grass and not
  • Poulan PD18H42STA | User Manual - Page 16
    receive full value from the warranty, operator must maintain tractor as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. All adjustments in the Service and Adjustments section of this manual should be checked at least once each season
  • Poulan PD18H42STA | User Manual - Page 17
    rules when performing any maintenance. BRAKE OPERATION If tractor requires more than six (6) feet stopping distance at high speed in highest gear, then brake must be adjusted. (See "TO ADJUST BRAKE" in the Service and Adjustments section of this manual). TRAILING EDGE UP BLADE CENTER HOLE FLAT
  • Poulan PD18H42STA | User Manual - Page 18
    . All oil must meet API service classification SF-SJ. • Be sure tractor is on level surface. • Oil For approximate capacity see "PRODUCT SPECIFICATIONS" section of this manual. • Use gauge on oil fill cap/dipstick for dusty, dirty conditions), remove the blower housing and Check the crankcase oil
  • Poulan PD18H42STA | User Manual - Page 19
    cloth and squeeze to remove excess oil. TO SERVICE CARTRIDGE • Replace a dirty, bent, or damaged cartridge shown in "PRODUCT SPECIFICATIONS" section of this manual. IN-LINE FUEL FILTER (See Fig. 17 tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower
  • Poulan PD18H42STA | User Manual - Page 20
    BEFORE PERFORMING ANY SERVICE OR ADJUST- parts have completely stopped. • Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. TRACTOR TO REMOVE MOWER (See Fig. 18) Mower clutch cable housing guide into bracket, slide collar onto guide and secure with
  • Poulan PD18H42STA | User Manual - Page 21
    SERVICE AND ADJUSTMENTS TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underinflated, you will not properly adjust your mower. SIDE-TO-SIDE
  • Poulan PD18H42STA | User Manual - Page 22
    SERVICE AND ADJUSTMENTS TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 23) The mower blade drive belt may be replaced without tools. Park the tractor on level surface. Engage parking brake. BELT REMOVAL • Remove mower from tractor (See "TO REMOVE MOWER" in this section of manual). • Work belt off both
  • Poulan PD18H42STA | User Manual - Page 23
    instructions in the Assembly section of this manual. FIG. 25 TRANSMISSION REMOVAL/REPLACEMENT Should your transmission require removal for service or replacement, it should be purged after reinstallation and before operating the tractor be purchased from your local parts dealer. Tire sealant also
  • Poulan PD18H42STA | User Manual - Page 24
    SERVICE AND ADJUSTMENTS If your battery is too weak to start the engine, it should be recharged. (See "BATTERY" in the MAINTENANCE section of this manual). If "jumper cables" are used for emergency starting, follow this procedure: IMPORTANT: YOUR TRACTOR IS EQUIPPED WITH A 12 VOLT SYSTEM. THE OTHER
  • Poulan PD18H42STA | User Manual - Page 25
    expense, may be performed by any non-road engine repair establishment or individual. Warranty repairs must be performed by an authorized engine manufacturer's service outlet. TO ADJUST THROTTLE CONTROL CABLE (See Fig. 32) The throttle control has been preset at the factory and adjustment should not
  • Poulan PD18H42STA | User Manual - Page 26
    enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan PD18H42STA | User Manual - Page 27
    TROUBLESHOOTING POINTS PROBLEM 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/ Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan PD18H42STA | User Manual - Page 28
    TROUBLESHOOTING POINTS PROBLEM CAUSE Engine continues to run when operator leaves seat with attachment clutch engaged 1. Faulty operator-safety presence control system. CORRECTION 1. Check wiring, switches and connections. If not corrected, contact an authorized service center/ department.
  • Poulan PD18H42STA | User Manual - Page 29
    REPAIR PARTS TRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93 SCHEMATIC RED BLACK BATTERY SOLENOID A AMMETER (OPTIONAL) RED WHITE WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. 29
  • Poulan PD18H42STA | User Manual - Page 30
    REPAIR PARTS TRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93 ELECTRICAL 42 24 41 43 27 27 26 81 81 27 81 27 25 40 16 16 33 30 D.C. AMPERES 45 52 8 29 28 27 2 90 1 30
  • Poulan PD18H42STA | User Manual - Page 31
    REPAIR PARTS TRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93 ELECTRICAL KEY PART NO. NO. DESCRIPTION 1 163465 Battery 12 Volt 25 Amp 2 74760412 Bolt Hex Hd 1/4-20unc X 3/4 8 176689 Box Battery 16 176137 Switch Interlock 21 183759 Harness Asm
  • Poulan PD18H42STA | User Manual - Page 32
    REPAIR PARTS TRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93 CHASSIS AND ENCLOSURES 259 264 28 258 263 17 159 30 24 18 261 39 25 26 31 209
  • Poulan PD18H42STA | User Manual - Page 33
    REPAIR PARTS TRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93 CHASSIS AND ENCLOSURES KEY PART NO. NO. DESCRIPTION 1 174619 Chassis 2 176554 Thdrol 5/16-18 x 1/2 Tyt 38 175710 Bracket Asm. Pivot Mower Rear 39 174714 Bracket Pivot 58 185949 Air Duct 64 154798 Dash Lower
  • Poulan PD18H42STA | User Manual - Page 34
    REPAIR PARTS TRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93 DRIVE 51 57 89 69 197 81 32 30 52 16 95 77 15 96 1 26 63 169 198
  • Poulan PD18H42STA | User Manual - Page 35
    REPAIR PARTS TRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93 DRIVE KEY PART NO. NO. 1 ------ 8 Gr. 5 Washer Keeper, Belt Engine Hydro KEY PART NO. NO. DESCRIPTION 69 142432 Screw Hex Wsh Hi-Lo 1/4-1/2 Unc 70 134683 Guide, Belt, Mower Drive RH 71 169183 Strap, Torque, Lh 73
  • Poulan PD18H42STA | User Manual - Page 36
    REPAIR PARTS TRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93 STEERING ASSEMBLY 38 12 39 1 37 44 51 91 43 41 42 37 36 54 88 71 29 17 68 29 15 15 15 82 29 46 8 6 2 87 5 68 67 13 65 46 8 6 67 67 3 32 11 40 33 34 10 35 87 5 4 43 36 43 6 8
  • Poulan PD18H42STA | User Manual - Page 37
    REPAIR PARTS TRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93 STEERING ASSEMBLY KEY PART NO. NO. DESCRIPTION 1 180656 Wheel Steering 2 184706 Axle Asm Front 3 169840 Spindle Asm Lh 4 169839 Spindle Asm Rh 5 6266H Bearing Race Thrust Harden 6 121748X Washer
  • Poulan PD18H42STA | User Manual - Page 38
    REPAIR PARTS TRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93 ENGINE 2 1 105 32 44 46 3 38 101 16 14 105 80 13 77 101 4 33 37 31 33 29 45 23 OPTIONAL EQUIPMENT Spark Arrester 38
  • Poulan PD18H42STA | User Manual - Page 39
    REPAIR PARTS TRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93 ENGINE KEY PART NO. NO. DESCRIPTION 1 170805 Control Throt /Ch Flag 2 17720408 Screw Hex Thd Cut 1/4-20x1/2 3 ------ Engine Kohl Model CV492 (Order Parts From Engine Manufacturer) 4 174667 Muffler Exhaust 13 12-041-
  • Poulan PD18H42STA | User Manual - Page 40
    PARTS TRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93 SEAT ASSEMBLY 1 14 24 8 9 7 10 5 8 9 7 2 5 6 22 21 16 25 15 11 4 13 17 12 3 KEY PART 14 Ga Pan Pnt Seat (blk ) Knob Bracket Pnt Mounting Switch KEY PART NO. NO. DESCRIPTION 13 121248X Bushing Snap Blk Nyl 50 Id 14
  • Poulan PD18H42STA | User Manual - Page 41
    REPAIR PARTS TRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93 DECALS 9 12 2 5 3 8 4 8 10 12 16 1 7 13 14 15 KEY PART NO. NO. 1 157032 2 172743 3 186163 4 186164 5 187051 7 179128 8 182005 9 172740 10 157140 12 176303 DESCRIPTION Decal Instruction Operat English/French Decal
  • Poulan PD18H42STA | User Manual - Page 42
    REPAIR PARTS TRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93 MOWER LIFT 29 28 27 25 24 23 7 41 37 38 40 11 19 13 31 32 13 5 49 36 13 4 6 2 12 13 30 50 3 26 6 19 31 32 20 15 1 5 4 1617 18 20 20 20 15 42
  • Poulan PD18H42STA | User Manual - Page 43
    REPAIR PARTS TRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93 MOWER LIFT KEY PART NO. NO. DESCRIPTION 1 184432 Plunger Asm. 2 159476 Shaft Asm Lift 3 178981 Pin Groove 4 12000002 E Ring #5133-62 5 19211621 Washer 21/32 x 1 x 21 Ga. 6 120183X Bearing
  • Poulan PD18H42STA | User Manual - Page 44
    REPAIR PARTS TRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93 MOWER DECK 68 40 67 157 158 37 36 40 151 152 156 153 155 159 46 153 154 143 144 45 150 40 37 145
  • Poulan PD18H42STA | User Manual - Page 45
    REPAIR PARTS TRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93 MOWER DECK KEY PART NO. NO. DESCRIPTION 1 182032X421 Mower Deck Assembly, 42" 2 72140506 Bolt 3 138017 Bracket Asm Fr. Sway Bar 3/42 4 165460 Bracket Asm Deck 42" Sway Bar 5 4939M Retainer Spring 6 178024 Bar Sway
  • Poulan PD18H42STA | User Manual - Page 46
    option, without charge for parts or labor incurred in replacing parts, any part which we find to Battery must be maintained in accordance with the instructions furnished. 4. The Warranty period for any products used return the product to an authorized service dealer. Should you have any
  • Poulan PD18H42STA | User Manual - Page 47
    47 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan PD18H42STA | User Manual - Page 48
    pages of your phone directory for the name of the nearest service dealer (under "saws" for Chain Saws or under "lawn mowers" for Trimmers, Brushcutters, and Blowers). 3. For replacement parts, have available the following information: a. Model Number/Manufacturer's I.D. Number. b. Description of
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
OWNER'S MANUAL
MODEL:
PD18H42STA
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
WARNING:
Read this Owner's Manual and follow all Warn-
ings and Safety Instructions.
Failure to do so
can result in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
184581
Rev. 1
02.12.03
RH
Printed in U.S.A.
02478