Poulan PD20H42STA User Manual

Poulan PD20H42STA Manual

Get Poulan PD20H42STA PDF manuals and user guides View all Poulan PD20H42STA manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PD20H42STA manual content summary:

  • Poulan PD20H42STA | User Manual - Page 1
    IMPORTANT MANUAL Do Not Throw Away 02478 OWNER'S MANUAL MODEL: PD20H42STA LAWN TRACTOR WARNING: Read this Owner's Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION 184617 Rev. 2 02.06.03 TR Printed
  • Poulan PD20H42STA | User Manual - Page 2
    instructions in the • Do not turn on slopes unless necessary, and then, manual riding mower safely enough to protect themselves and others from serious injury. • Keep machine free of grass , leaves or other debris build-up which can touch hot exhaust / engine parts and burn. Do not allow the mower
  • Poulan PD20H42STA | User Manual - Page 3
    RIDE-ON MOWERS IMPORTANT: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS with the ground and cause you to lose control of your tractor. WARNING Engine exhaust, some of its constituents, and certain vehicle
  • Poulan PD20H42STA | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan PD20H42STA | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Seat Steering Sleeve Steering Wheel Insert Steering Extension Shaft Steering Adapter (1) Large Flat Washer (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Knob Slope Sheet (1)
  • Poulan PD20H42STA | User Manual - Page 6
    or left hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel). INSERT 1/2 HEX NUT LARGE FLAT WASHER TO REMOVE TRACTOR FROM CARTON UNPACK CARTON • Remove all accessible loose parts and parts cartons from carton . • Cut along dotted
  • Poulan PD20H42STA | User Manual - Page 7
    of controls) FLAT WASHER WARNING: Before starting, read, understand and follow all instructions in the Operation section of this manual. Be sure tractor is in a well-ventilated area. Be sure the area in front of tractor is clear of other people and objects. • Be sure all the above assembly
  • Poulan PD20H42STA | User Manual - Page 8
    CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is properly adjusted. See "TO ADJUST BRAKE" in the Service and Adjustments section of this manual. • Place front of mulcher plate over front of mower deck opening and slide into place, as shown. • Hook front
  • Poulan PD20H42STA | User Manual - Page 9
    MOWER LIFT 15 15 15 ATTACHMENT ATTACHMENT CLUTCH ENGAGED CLUTCH DISENGAGED DANGER, KEEP HANDS AND FEET AWAY KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) FREE WHEEL (Automatic Models only) Failure to follow instructions result in damage to the tractor and/or engine. HOT SURFACES
  • Poulan PD20H42STA | User Manual - Page 10
    TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual engage the mower blades, or other attachments mounted to your tractor. LIGHT
  • Poulan PD20H42STA | User Manual - Page 11
    rate. • Full throttle offers the best bagging and mower perfor- mance. TO USE CHOKE CONTROL (See Fig. position and remove key. Always remove key when leaving tractor to prevent unauthorized use. TO MOVE FORWARD AND of grass being mowed. • The average lawn should be cut to approximately 2-1/2 inches
  • Poulan PD20H42STA | User Manual - Page 12
    prevent scalping in most terrain conditions. NOTE:Adjust gauge wheels with tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO AD- JUST MOWER CUTTING HEIGHT" in the Operation section of this manual). • Remove retainer spring and clevis pin which secure each gauge wheel
  • Poulan PD20H42STA | User Manual - Page 13
    storage. To avoid engine problems, the fuel system should be fuel next season. See Storage Instructions for additional information. Never use specifications of the manufacturer of your tractor. Use common sense when towing. manual). • To change engine oil, see the Maintenance section in this manual
  • Poulan PD20H42STA | User Manual - Page 14
    transmission should be warmed up as follows: • Be sure the tractor is on level ground. • Place the motion control lever in Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower
  • Poulan PD20H42STA | User Manual - Page 15
    MOWING TIPS IMPORTANT: FOR BEST PERFORMANCE, KEEP MOWER HOUSING FREE OF BUILT-UP GRASS AND TRASH. CLEAN AFTER EACH USE. • The special mulching blade will recut the grass clippings many times and reduce them in size so that as they fall onto the lawn they will disperse into the grass and not
  • Poulan PD20H42STA | User Manual - Page 16
    receive full value from the warranty, operator must maintain tractor as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. All adjustments in the Service and Adjustments section of this manual should be checked at least once each season
  • Poulan PD20H42STA | User Manual - Page 17
    rules when performing any maintenance. BRAKE OPERATION If tractor requires more than six (6) feet stopping distance at high speed in highest gear, then brake must be adjusted. (See "TO ADJUST BRAKE" in the Service and Adjustments section of this manual). TIRES • Maintain proper air pressure in all
  • Poulan PD20H42STA | User Manual - Page 18
    range expected before oil change. All oil must meet API service classification SF-SJ. • Be sure tractor is on level surface. • Oil will drain more freely not overfill. For approximate capacity see "PRODUCT SPECIFICATIONS" section of this manual. • Use gauge on oil fill cap/dipstick for checking level.
  • Poulan PD20H42STA | User Manual - Page 19
    . TO SERVICE CARTRIDGE • section of this manual. IN-LINE tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower
  • Poulan PD20H42STA | User Manual - Page 20
    BEFORE PERFORMING ANY SERVICE OR ADJUST- parts have completely stopped. • Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. TRACTOR TO REMOVE MOWER (See Fig. 18) Mower clutch cable housing guide into bracket, slide collar onto guide and secure with
  • Poulan PD20H42STA | User Manual - Page 21
    SERVICE AND ADJUSTMENTS TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underinflated, you will not properly adjust your mower. SIDE-TO-SIDE
  • Poulan PD20H42STA | User Manual - Page 22
    SERVICE AND ADJUSTMENTS TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 23) The mower blade drive belt may be replaced without tools. Park the tractor on level surface. Engage parking brake. BELT REMOVAL • Remove mower from tractor (See "TO REMOVE MOWER" in this section of manual). • Work belt off both
  • Poulan PD20H42STA | User Manual - Page 23
    mower deck height to the lowest position. After above adjustment is made, if the tractor instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER The front wheel toe-in and camber are not adjustable on your tractor purchased from your local parts dealer. Tire sealant also prevents tire
  • Poulan PD20H42STA | User Manual - Page 24
    SERVICE MAINTENANCE section of this manual). If "jumper cables" are used for emergency starting, follow this procedure: IMPORTANT: YOUR TRACTOR IS EQUIPPED WITH A your tractor to run poorly, stop running, or prevent it from starting. • Check wiring. See electrical wiring diagram in the Repair Parts
  • Poulan PD20H42STA | User Manual - Page 25
    TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment. High speed stop is factory adjusted. Do not adjust - damage may result. IMPORTANT
  • Poulan PD20H42STA | User Manual - Page 26
    enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan PD20H42STA | User Manual - Page 27
    TROUBLESHOOTING POINTS PROBLEM 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/ Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan PD20H42STA | User Manual - Page 28
    TROUBLESHOOTING POINTS PROBLEM CAUSE Engine continues to run when operator leaves seat with attachment clutch engaged 1. Faulty operator-safety presence control system. CORRECTION 1. Check wiring, switches and connections. If not corrected, contact an authorized service center/ department.
  • Poulan PD20H42STA | User Manual - Page 29
    TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09 SCHEMATIC RED BATTERY BLACK A AMMETER (OPTIONAL) RED WHITE RED CONNECTIONS WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. 29
  • Poulan PD20H42STA | User Manual - Page 30
    TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09 ELECTRICAL 22 21 42 24 41 43 27 27 26 40 27 27 25 33 30 16 16 8 2 1 D.C. AMPERES 45 52 28 29 27 90 30
  • Poulan PD20H42STA | User Manual - Page 31
    TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09 ELECTRICAL KEY PART NO. NO. 1 144927 2 74760412 8 176689 16 176138 21 183759 22 4152J 24 4799J 25 146147 26 175158 27 73510400 28 4207J 29 121305X 30 175566
  • Poulan PD20H42STA | User Manual - Page 32
    TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09 CHASSIS 259 264 28 258 263 17 159 30 24 18 261 39 25 26 31 209 208 11
  • Poulan PD20H42STA | User Manual - Page 33
    TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09 CHASSIS KEY PART NO. NO. 18 x 1/2 TYT 38 175710 Bracket Asm Pivot Mower Rear 39 174714 Bracket Pivot 58 185949 Duct Air x 3/4 258 183835X599 Lens Grille Pro RH 259 183834X599 Lens Grille Pro LH 261 183829Z428 Insert Grille 263
  • Poulan PD20H42STA | User Manual - Page 34
    TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09 DRIVE 51 57 89 69 197 81 32 30 52 16 95 77 15 96 1 26 63 169 198
  • Poulan PD20H42STA | User Manual - Page 35
    TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09 DRIVE KEY PART NO. NO. 1 ------ 8 165619 10 , Pedal Pulley, Engine Bolt, Hex Washer KEY PART NO. NO. DESCRIPTION 66 154778 Keeper Belt Engine 69 142432 Screw 70 134683 Guide Belt 71 169183 Strap Torque Lh Hydro 73 169182
  • Poulan PD20H42STA | User Manual - Page 36
    TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09 STEERING ASSEMBLY 38 12 39 1 37 44 51 91 43 41 42 37 36 54 88 71 29 17 68 29 15 15 15 82 29 46 8 6 2 87 5 68 67 13 65 46 8 6 67 67 3 32 11 40 33 34 10 35 87 5 4 43 43 6 8 36
  • Poulan PD20H42STA | User Manual - Page 37
    TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09 STEERING ASSEMBLY KEY PART NO. NO. DESCRIPTION 1 180656 Wheel Steering 2 172393 Axle Asm Cast Iron LT 3 169840 Spindle Asm LH 4 169839 Spindle Asm RH 5 6266H Bearing Race Thrust Harden 6
  • Poulan PD20H42STA | User Manual - Page 38
    TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09 SEAT ASSEMBLY 1 14 24 8 9 7 10 5 8 9 7 5 6 22 2 21 16 25 15 11 4 13 17 12 3 KEY PART /32 X 1 X 14 Ga. Pan Seat Knob Seat Bracket Mounting Switch KEY PART NO. NO. 13 121248X 14 72050412 15 134300 16 121250X 17 123976X 21 171852
  • Poulan PD20H42STA | User Manual - Page 39
    Decal Handle Lft Height Adjust - - 184617 Manual Owner's (English) - - 184618 Manual Owner's (French) KEY PART NO. NO. DESCRIPTION 1 59192 Cap Valve Tire 2 65139 Stem Valve 3 170455 Tire F T 15 X 6 0 - 6 Service 4 59904 Tube Front (Service Item Only) 5 106732X421 Rim Asm 6"front
  • Poulan PD20H42STA | User Manual - Page 40
    TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09 ENGINE 2 1 14 25 38 26 17 32 44 46 31 112 33 37 33 23 41 29 OPTIONAL EQUIPMENT Spark Arrester 8 3 13 81 5 17 16 72 10 6 45 4 40
  • Poulan PD20H42STA | User Manual - Page 41
    TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09 ENGINE KEY PART NO. NO. 1 170771 2 17720408 3 ------- 4 DESCRIPTION Control, Throttle Screw Hex Thd Cut 1/4-20 x 1/2 Engine Briggs Model 407777 (Order Parts from Engine Mfg.) Muffler, Asm. Twin Lo-Tone Pipe Exhaust Intek 20 RH Pipe
  • Poulan PD20H42STA | User Manual - Page 42
    TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09 MOWER DECK 158 151 152 67 157 156 153 155 153 154 159 46 44 56 53 52 55 134 135 136 116 117 119 113
  • Poulan PD20H42STA | User Manual - Page 43
    TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09 MOWER DECK KEY PART NO. NO. DESCRIPTION 1 182032X421 Mower Deck Assembly, 42" 2 72140506 Bolt 3 138017 Bracket Asm Fr. Sway Bar 3/42 4 165460 Bracket Asm Deck 42" Sway Bar 5 4939M Retainer Spring 6 178024 Bar Sway
  • Poulan PD20H42STA | User Manual - Page 44
    TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09 MOWER LIFT 29 28 27 25 24 23 7 41 37 38 40 11 19 13 31 32 13 5 49 36 13 4 6 2 12 13 30 50 3 26 6 19 31 32 20 15 1 5 4 17 18 20 16 20 20 15 44
  • Poulan PD20H42STA | User Manual - Page 45
    TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09 MOWER LIFT KEY PART NO. NO. 1 184432 2 159476 3 178981 4 12000002 5 19211621 6 120183X 7 175830 11 139865 12 139866 13 4939M 15 173288 16 73350800 17 175689 18 73800800 19 139868
  • Poulan PD20H42STA | User Manual - Page 46
    option, without charge for parts or labor incurred in replacing parts, any part which we find to Battery must be maintained in accordance with the instructions furnished. 4. The Warranty period for any products used return the product to an authorized service dealer. Should you have any unanswered
  • Poulan PD20H42STA | User Manual - Page 47
    47 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan PD20H42STA | User Manual - Page 48
    pages of your phone directory for the name of the nearest service dealer (under "saws" for Chain Saws or under "lawn mowers" for Trimmers, Brushcutters, and Blowers). 3. For replacement parts, have available the following information: a. Model Number/Manufacturer's I.D. Number. b. Description of
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
OWNER'S MANUAL
MODEL:
PD20H42STA
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
WARNING:
Read this Owner's Manual and follow all Warn-
ings and Safety Instructions.
Failure to do so
can result in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
184617
Rev. 2
02.06.03
TR
Printed in U.S.A.
02478