Poulan PD20PH42STA User Manual

Poulan PD20PH42STA Manual

Get Poulan PD20PH42STA PDF manuals and user guides View all Poulan PD20PH42STA manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PD20PH42STA manual content summary:

  • Poulan PD20PH42STA | User Manual - Page 1
    Do Not Throw Away 02478 OWNER'S MANUAL MODEL: PD20PH42STA LAWN TRACTOR WARNING: Read this Owner's Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION 186996 Rev. 1 08.13.03 RD/TR Printed in U.S.A.
  • Poulan PD20PH42STA | User Manual - Page 2
    -re- IV. SERVICE lated injuries. These operators should evaluate their ability to operate the riding mower safely enough to protect themselves and others from serious injury. • Keep machine free of grass , leaves or other debris build-up which can touch hot exhaust / engine parts and burn. Do not
  • Poulan PD20PH42STA | User Manual - Page 3
    SAFETY RULES SAFE OPERATION PRACTICES FOR RIDE-ON MOWERS • Be sure the area is clear of is dangerous. Tires can lose traction with the ground and cause you to lose control of your tractor. WARNING Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals
  • Poulan PD20PH42STA | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan PD20PH42STA | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Seat Steering Sleeve Steering Wheel Insert Steering Extension Shaft Steering Adapter (1) Locknut 1/2-20 (1) Large Flat Washer (1) Locknut 1/4-28 (1) Washer 17/32 x 1-3/16 x 12
  • Poulan PD20PH42STA | User Manual - Page 6
    knife When right or left hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel). TO REMOVE TRACTOR FROM CARTON UNPACK CARTON • Remove all accessible loose parts and parts cartons from carton . • Cut along dotted lines on all four
  • Poulan PD20PH42STA | User Manual - Page 7
    into service after month and year indicated on label (label located between terminals) charge battery for minimum of one hour at 6-10 amps. (See "BATTERY" in Maintenance section of this manual for charging instructions). SEAT PAN LABEL 02602 FIG. 3 NOTE: You may now roll or drive your tractor off
  • Poulan PD20PH42STA | User Manual - Page 8
    of this manual. ✓CHECKLIST BEFOREYOU OPERATE AND ENJOYYOUR NEW TRACTOR, WE WISH TO ASSURE THAT YOU RECEIVE THE BEST PERFORMANCE AND SATISFACTION FROM THIS QUALITY PRODUCT. PLEASE REVIEW THE FOLLOWING CHECKLIST: ✓ All assembly instructions have been completed. ✓ No remaining loose parts in carton
  • Poulan PD20PH42STA | User Manual - Page 9
    MOWER LIFT 15 ATTACHMENT ATTACHMENT CLUTCH ENGAGED CLUTCH DISENGAGED DANGER, KEEP HANDS AND FEET AWAY KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) FREE WHEEL (Automatic Models only) Failure to follow instructions could result in damage to the tractor and/or engine. HOT SURFACES
  • Poulan PD20PH42STA | User Manual - Page 10
    TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual engage the mower blades, or other attachments mounted to your tractor. LIGHT
  • Poulan PD20PH42STA | User Manual - Page 11
    position and remove key. Always remove key when leaving tractor to prevent unauthorized use. • Never use choke to rate. • Full throttle offers the best bagging and mower perfor- mance. TO USE CHOKE CONTROL (See Fig. of grass being mowed. • The average lawn should be cut to approximately 2-1/2 inches
  • Poulan PD20PH42STA | User Manual - Page 12
    prevent scalping in most terrain conditions. NOTE:Adjust gauge wheels with tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO AD- JUST MOWER CUTTING HEIGHT" in the Operation section of this manual). • Remove retainer spring and clevis pin which secure each gauge wheel
  • Poulan PD20PH42STA | User Manual - Page 13
    in storage. To avoid engine problems, the fuel system should be fuel next season. See Storage Instructions for additional information. Never use fications of the manufacturer of your tractor. Use common sense when towing. this manual). • To change engine oil, see the Maintenance section in this manual.
  • Poulan PD20PH42STA | User Manual - Page 14
    transmission should be warmed up as follows: • Be sure the tractor is on level ground. • Release the parking brake and let Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower
  • Poulan PD20PH42STA | User Manual - Page 15
    the mulching action. The best time to mow your lawn is the early afternoon. At this time the grass has dried, the newly cut area will not be exposed to direct sunlight. • For best results, adjust the mower cutting height so that the mower cuts off only the top one-third of the
  • Poulan PD20PH42STA | User Manual - Page 16
    as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual. • At least once a year you should
  • Poulan PD20PH42STA | User Manual - Page 17
    may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. OPERATOR PRESENCE SYSTEM Be sure operator presence and interlock systems are working properly. If your tractor does not function as described, repair the problem immediately. • The engine should not
  • Poulan PD20PH42STA | User Manual - Page 18
    range expected before oil change. All oil must meet API service classification SF-SJ. • Be sure tractor is on level surface. • Oil will drain more freely not overfill. For approximate capacity see "PRODUCT SPECIFICATIONS" section of this manual. • Use gauge on oil fill cap/dipstick for checking level.
  • Poulan PD20PH42STA | User Manual - Page 19
    . TO SERVICE CARTRIDGE • section of this manual. IN-LINE tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower
  • Poulan PD20PH42STA | User Manual - Page 20
    parts have completely stopped. • Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. TRACTOR TO REMOVE MOWER (See Fig. 19) Mower spring. • Push clutch cable housing guide into bracket, slide collar onto guide and secure with large retainer spring.
  • Poulan PD20PH42STA | User Manual - Page 21
    SERVICE AND ADJUSTMENTS TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underinflated, you will not properly adjust your mower. SIDE-TO-SIDE
  • Poulan PD20PH42STA | User Manual - Page 22
    SERVICE AND ADJUSTMENTS TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 24) The mower blade drive belt may be replaced without tools. Park the tractor on level surface. Engage parking brake. BELT REMOVAL • Remove mower from tractor (See "TO REMOVE MOWER" in this section of manual). • Work belt off both
  • Poulan PD20PH42STA | User Manual - Page 23
    due to slow leaks, tire sealant may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. 01510 FIG. per instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER The front wheel toe-in and camber are not adjustable on your tractor.
  • Poulan PD20PH42STA | User Manual - Page 24
    SERVICE MAINTENANCE section of this manual). If "jumper cables" are used for emergency starting, follow this procedure: IMPORTANT: YOUR TRACTOR IS EQUIPPED WITH A your tractor to run poorly, stop running, or prevent it from starting. • Check wiring. See electrical wiring diagram in the Repair Parts
  • Poulan PD20PH42STA | User Manual - Page 25
    TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment. High speed stop is factory adjusted. Do not adjust - damage may result. IMPORTANT
  • Poulan PD20PH42STA | User Manual - Page 26
    enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan PD20PH42STA | User Manual - Page 27
    TROUBLESHOOTING POINTS PROBLEM 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/ Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan PD20PH42STA | User Manual - Page 28
    TROUBLESHOOTING POINTS PROBLEM CAUSE Engine continues to run when operator leaves seat with attachment clutch engaged 1. Faulty operator-safety presence control system. CORRECTION 1. Check wiring, switches and connections. If not corrected, contact an authorized service center/ department.
  • Poulan PD20PH42STA | User Manual - Page 29
    LIGHT B+A1 RUN B+A1 START B + S + A1 NONE A2+L NONE NONE NOTE YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. 29
  • Poulan PD20PH42STA | User Manual - Page 30
    TRACTOR - - MODEL NUMBER PD20PH42STA PRODUCT NO. 954 57 09-25 ELECTRICAL 22 21 42 24 41 43 27 27 26 40 27 27 25 33 30 16 16 8 2 1 D.C. AMPERES 45 52 28 29 27 90 30
  • Poulan PD20PH42STA | User Manual - Page 31
    TRACTOR - - MODEL NUMBER PD20PH42STA PRODUCT NO. 954 57 09-25 ELECTRICAL KEY PART NO. NO. 1 144927 2 74760412 8 176689 16 176138 21 183759 22 4152J 24 4799J 25 146147 26 175158 27 73510400 28 4207J 29 121305X 30 175566
  • Poulan PD20PH42STA | User Manual - Page 32
    TRACTOR - - MODEL NUMBER PD20PH42STA PRODUCT NO. 954 57 09-25 CHASSIS 259 264 28 258 263 17 261 10 39 18 10 30 31 209 208
  • Poulan PD20PH42STA | User Manual - Page 33
    TRACTOR - - MODEL NUMBER PD20PH42STA PRODUCT NO. 954 57 09-25 CHASSIS KEY PART NO. NO. 18 x 1/2 TYT 38 175710 Bracket Asm Pivot Mower Rear 39 174714 Bracket Pivot 58 185949 Duct Air x 3/4 258 183835X599 Lens Grille Pro RH 259 183834X599 Lens Grille Pro LH 261 183829X428 Insert Grille 263
  • Poulan PD20PH42STA | User Manual - Page 34
    TRACTOR - - MODEL NUMBER PD20PH42STA PRODUCT NO. 954 57 09-25 DRIVE 57 51 221 219 19 59 19 221 214 254 222 274 224 61 56
  • Poulan PD20PH42STA | User Manual - Page 35
    TRACTOR - - MODEL NUMBER PD20PH42STA PRODUCT NO. 954 57 09-25 DRIVE KEY PART NO. NO. 1 - - - - - - 6 17060512 9 251 17060516 253 179422 254 178062 272 17670508 273 179610 274 175646 DESCRIPTION Keeper Belt Engine Guide Belt Mower RH Spacer, Axle Washer 25/32 x 1-1/4 x 16 Ga. E-Ring Key, Square
  • Poulan PD20PH42STA | User Manual - Page 36
    TRACTOR - - MODEL NUMBER PD20PH42STA PRODUCT NO. 954 57 09-25 STEERING ASSEMBLY 38 12 39 1 37 44 51 91 43 41 42 37 36 54 88 71 29 17 68 29 15 15 15 steering_pl.lt_29 82 29 46 8 6 2 87 5 68 67 13 65 46 8 6 67 67 3 32 11 40 33 34 10 35 87 5 4 43 43 6 8 36
  • Poulan PD20PH42STA | User Manual - Page 37
    TRACTOR - - MODEL NUMBER PD20PH42STA PRODUCT NO. 954 57 09-25 STEERING ASSEMBLY KEY PART NO. NO. DESCRIPTION 1 180656 Wheel Steering 2 184706 Axle Asm 3 169840 Spindle Asm LH 4 169839 Spindle Asm RH 5 6266H Bearing Race Thrust Harden 6 121748X Washer 25/
  • Poulan PD20PH42STA | User Manual - Page 38
    TRACTOR - - MODEL NUMBER PD20PH42STA PRODUCT NO. 954 57 09-25 SEAT ASSEMBLY 1 14 24 8 9 7 10 5 8 9 7 5 6 22 2 21 16 25 15 11 4 13 17 12 3 KEY PART 32 X 1 X 14 Ga. Pan Seat Knob Seat Bracket Mounting Switch KEY PART NO. NO. 13 121248X 14 72050412 15 134300 16 121250X 17 123976X 21 171852
  • Poulan PD20PH42STA | User Manual - Page 39
    Decal Handle Lft Height Adjust - - 186996 Manual Owner's (English) - - 186997 Manual Owner's (French) KEY PART NO. NO. DESCRIPTION 1 59192 Cap Valve Tire 2 65139 Stem Valve 3 170455 Tire F T 15 X 6 0 - 6 Service 4 59904 Tube Front (Service Item Only) 5 106732X421 Rim Asm 6"front
  • Poulan PD20PH42STA | User Manual - Page 40
    TRACTOR - - MODEL NUMBER PD20PH42STA PRODUCT NO. 954 57 09-25 ENGINE 2 1 14 25 38 26 17 32 44 46 8 3 13 10 81 17 16 6 5 72 33 37 31 45 33 23 29 4 OPTIONAL EQUIPMENT Spark Arrester engine-bs intek-twin_40 40
  • Poulan PD20PH42STA | User Manual - Page 41
    TRACTOR - - MODEL NUMBER PD20PH42STA PRODUCT NO. 954 57 09-25 ENGINE KEY PART NO. NO. 1 170771 2 17720408 3 ------- 4 component dimensions given in U.S. inches 1 inch = 25.4 mm For engine service and replacement parts, call the toll free number for your engine manufacturer listed below: Briggs &
  • Poulan PD20PH42STA | User Manual - Page 42
    TRACTOR - - MODEL NUMBER PD20PH42STA PRODUCT NO. 954 57 09-25 MOWER DECK 158 151 152 67 157 156 153 155 153 154 159 46 44 56 53 52 55 134 135 136 116 117 119 113
  • Poulan PD20PH42STA | User Manual - Page 43
    TRACTOR - - MODEL NUMBER PD20PH42STA PRODUCT NO. 954 57 09-25 MOWER DECK KEY PART NO. NO. DESCRIPTION 1 182032X421 Mower Deck Assembly Hinge 42" 6 75 W/G 30 173984 Screw Thdrol 31 129963 asher, Spacer Mower Vented 32 173436 Pulley, Mandrel 33 178342 Nut, Toplock 34 72110614 Bolt 36
  • Poulan PD20PH42STA | User Manual - Page 44
    TRACTOR - - MODEL NUMBER PD20PH42STA PRODUCT NO. 954 57 09-25 MOWER LIFT 29 28 27 25 24 23 7 41 37 38 40 11 19 13 31 32 13 5 49 36 13 4 6 2 12 13 30 50 3 26 6 19 31 32 20 15 1 5 4 17 18 20 16 20 20 15 44
  • Poulan PD20PH42STA | User Manual - Page 45
    TRACTOR - - MODEL NUMBER PD20PH42STA PRODUCT NO. 954 57 09-25 MOWER LIFT KEY PART NO. NO. 1 184432 2 159476 3 178981 4 12000002 5 19211621 6 120183X 7 175830 11 139865 12 139866 13 4939M 15 173288 16 73350800 17 175689 18 73800800 19 139868
  • Poulan PD20PH42STA | User Manual - Page 46
    option, without charge for parts or labor incurred in replacing parts, any part which we find to Battery must be maintained in accordance with the instructions furnished. 4. The Warranty period for any products used return the product to an authorized service dealer. Should you have any unanswered
  • Poulan PD20PH42STA | User Manual - Page 47
    47 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan PD20PH42STA | User Manual - Page 48
    pages of your phone directory for the name of the nearest service dealer (under "saws" for Chain Saws or under "lawn mowers" for Trimmers, Brushcutters, and Blowers). 3. For replacement parts, have available the following information: a. Model Number/Manufacturer's I.D. Number. b. Description of
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
02478
OWNER'S MANUAL
MODEL:
PD20PH42STA
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
WARNING:
Read this Owner's Manual and follow all Warn-
ings and Safety Instructions.
Failure to do so
can result in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
186996
Rev. 1
08.13.03
RD/TR
Printed in U.S.A.