Poulan PD22H42STA User Manual

Poulan PD22H42STA Manual

Get Poulan PD22H42STA PDF manuals and user guides View all Poulan PD22H42STA manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PD22H42STA manual content summary:

  • Poulan PD22H42STA | User Manual - Page 1
    Do Not Throw Away 02478 OWNER'S MANUAL MODEL: PD22H42STA LAWN TRACTOR WARNING: Read this Owner's Manual and follow allWarnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION 188781 Rev. 1 11.3.03 RD/MH Printed in U.S.A.
  • Poulan PD22H42STA | User Manual - Page 2
    instructions in the • Do not turn on slopes unless necessary, and then, manual riding mower safely enough to protect themselves and others from serious injury. • Keep machine free of grass , leaves or other debris build-up which can touch hot exhaust / engine parts and burn. Do not allow the mower
  • Poulan PD22H42STA | User Manual - Page 3
    RIDE-ON MOWERS IMPORTANT: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS with the ground and cause you to lose control of your tractor. WARNING Engine exhaust, some of its constituents, and certain vehicle
  • Poulan PD22H42STA | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan PD22H42STA | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Seat Steering Sleeve Steering Wheel Insert Steering Extension Shaft Steering Adapter (1) Large Flat Washer (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Knob Slope Sheet (1)
  • Poulan PD22H42STA | User Manual - Page 6
    or left hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel). INSERT 1/2 HEX NUT LARGE FLAT WASHER TO REMOVE TRACTOR FROM CARTON UNPACK CARTON • Remove all accessible loose parts and parts cartons from carton . • Cut along dotted
  • Poulan PD22H42STA | User Manual - Page 7
    location and function of controls) WARNING: Before starting, read, understand and follow all instructions in the Operation section of this manual. Be sure tractor is in a well-ventilated area. Be sure the area in front of tractor is clear of other people and objects. • Be sure all the above assembly
  • Poulan PD22H42STA | User Manual - Page 8
    See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is properly adjusted. See
  • Poulan PD22H42STA | User Manual - Page 9
    MOWER HEIGHT 15 MOWER LIFT 15 ATTACHMENT ATTACHMENT CLUTCH ENGAGED CLUTCH DISENGAGED DANGER, KEEP HANDS AND FEET AWAY KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) FREE WHEEL (Automatic Models only) Failure to follow instructions result in damage to the tractor and/or engine. HOT
  • Poulan PD22H42STA | User Manual - Page 10
    TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual engage the mower blades, or other attachments mounted to your tractor. LIGHT
  • Poulan PD22H42STA | User Manual - Page 11
    reduces the battery charging rate. • Full throttle offers the best bagging and mower perfor- mance. TO USE CHOKE CONTROL (See Fig. 6) Use choke Always remove key when leaving tractor to prevent • unauthorized use. • Never use choke to stop engine. 11 The average lawn should be cut to
  • Poulan PD22H42STA | User Manual - Page 12
    prevent scalping in most terrain conditions. NOTE:Adjust gauge wheels with tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO AD- JUST MOWER CUTTING HEIGHT" in the Operation section of this manual). • Remove retainer spring and clevis pin which secure each gauge wheel
  • Poulan PD22H42STA | User Manual - Page 13
    storage. To avoid engine problems, the fuel system should be fuel next season. See Storage Instructions for additional information. Never use specifications of the manufacturer of your tractor. Use common sense when towing. manual). • To change engine oil, see the Maintenance section in this manual
  • Poulan PD22H42STA | User Manual - Page 14
    transmission should be warmed up as follows: • Be sure the tractor is on level ground. • Place the motion control lever in Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower
  • Poulan PD22H42STA | User Manual - Page 15
    the mulching action. The best time to mow your lawn is the early afternoon. At this time the grass has dried, the newly cut area will not be exposed to direct sunlight. • For best results, adjust the mower cutting height so that the mower cuts off only the top one-third of the
  • Poulan PD22H42STA | User Manual - Page 16
    as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual. • At least once a year you should
  • Poulan PD22H42STA | User Manual - Page 17
    may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. OPERATOR PRESENCE SYSTEM Be sure operator presence and interlock systems are working properly. If your tractor does not function as described, repair the problem immediately. • The engine should not
  • Poulan PD22H42STA | User Manual - Page 18
    range expected before oil change. All oil must meet API service classification SF-SJ. • Be sure tractor is on level surface. • Oil will drain more freely not overfill. For approximate capacity see "PRODUCT SPECIFICATIONS" section of this manual. • Use gauge on oil fill cap/dipstick for checking level.
  • Poulan PD22H42STA | User Manual - Page 19
    . TO SERVICE CARTRIDGE • section of this manual. IN-LINE tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower
  • Poulan PD22H42STA | User Manual - Page 20
    BEFORE PERFORMING ANY SERVICE OR ADJUST- parts have completely stopped. • Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. TRACTOR TO REMOVE MOWER (See Fig. 17) Mower clutch cable housing guide into bracket, slide collar onto guide and secure with
  • Poulan PD22H42STA | User Manual - Page 21
    SERVICE AND ADJUSTMENTS TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underinflated, you will not properly adjust your mower. SIDE-TO-SIDE
  • Poulan PD22H42STA | User Manual - Page 22
    SERVICE AND ADJUSTMENTS TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 22) The mower blade drive belt may be replaced without tools. Park the tractor on level surface. Engage parking brake. BELT REMOVAL • Remove mower from tractor (See "TO REMOVE MOWER" in this section of manual). • Work belt off both
  • Poulan PD22H42STA | User Manual - Page 23
    mower deck height to the lowest position. After above adjustment is made, if the tractor instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER The front wheel toe-in and camber are not adjustable on your tractor purchased from your local parts dealer. Tire sealant also prevents tire
  • Poulan PD22H42STA | User Manual - Page 24
    SERVICE MAINTENANCE section of this manual). If "jumper cables" are used for emergency starting, follow this procedure: IMPORTANT: YOUR TRACTOR IS EQUIPPED WITH A 12 tractor to run poorly, stop running, or prevent it from starting. • Check wiring. See electrical wiring diagram in the Repair Parts
  • Poulan PD22H42STA | User Manual - Page 25
    TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment. High speed stop is factory adjusted. Do not adjust - damage may result. IMPORTANT
  • Poulan PD22H42STA | User Manual - Page 26
    enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan PD22H42STA | User Manual - Page 27
    PROBLEM Will not start TROUBLESHOOTING Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan PD22H42STA | User Manual - Page 28
    TROUBLESHOOTING POINTS PROBLEM CAUSE Engine continues to run when operator leaves seat with attachment clutch engaged 1. Faulty operator-safety presence control system. CORRECTION 1. Check wiring, switches and connections. If not corrected, contact an authorized service center/ department.
  • Poulan PD22H42STA | User Manual - Page 29
    SCHEMATIC TRACTOR - - MODEL NUMBER PD22H42STA RED BATTERY BLACK A AMMETER (OPTIONAL) RED WHITE RED S BM G A1 L A2 IGNITION CONNECTIONS WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. 29
  • Poulan PD22H42STA | User Manual - Page 30
    ELECTRICAL 24 TRACTOR - - MODEL NUMBER PD22H42STA 42 41 22 21 43 27 27 26 40 27 27 25 33 30 10 11 12 2 1 8 27 12 D.C. AMPERES 45 52 28 29 16 16 30
  • Poulan PD22H42STA | User Manual - Page 31
    ELECTRICAL TRACTOR - - MODEL NUMBER PD22H42STA KEY PART NO. NO. DESCRIPTION 1 144927 Battery 2 74760412 Bolt Hex Hd 1/4-20 unc x 3/4 8 7603J Tray Battery 10 145211 Bolt Btr frt 1/4-20 x 7.5 zinc 11 150109 Holddown battery
  • Poulan PD22H42STA | User Manual - Page 32
    CHASSIS TRACTOR - - MODEL NUMBER PD22H42STA 259 264 28 258 263 17 10 217 18 10 30 261 39 58 166 31 209 208 11 209 2 206 159 209 9 207 5 5 219
  • Poulan PD22H42STA | User Manual - Page 33
    CHASSIS TRACTOR - - MODEL NUMBER PD22H42STA KEY PART NO. NO. Thdrol 6/16-18 x 1/2 TYT 38 175710 Bracket Asm Pivot Mower Rear 39 174714 Bracket Pivot 58 185949 Duct Air 60 72140606 x 3/4 258 183835X599 Lens Grille Pro RH 259 183834X599 Lens Grille Pro LH 261 183829Z428 Insert Grille 263
  • Poulan PD22H42STA | User Manual - Page 34
    DRIVE TRACTOR - - MODEL NUMBER PD22H42STA 57 89 269 263 120 90 197 81 59 84 85 13 14 112 21 10 80 8 85 11 16 52 30 32 170 77
  • Poulan PD22H42STA | User Manual - Page 35
    DRIVE TRACTOR - - MODEL NUMBER PD22H42STA KEY PART NO. NO. 1 ------ 8 165866 10 76020416 14 Engine Bolt Hex 7/16-20 x 4 x Gr. 5-1.5 Thr Washer KEY PART NO. NO. DESCRIPTION 66 154778 Keeper Belt Engine 70 134683 Guide Belt 71 169183 Strap Torque Lh Hydro 73 169182 Strap Torque Rh Hydro
  • Poulan PD22H42STA | User Manual - Page 36
    TRACTOR - - MODEL NUMBER PD22H42STA STEERING ASSEMBLY 38 12 39 1 37 44 51 91 43 41 42 37 36 54 88 71 29 17 68 29 15 15 15 steering_pl.lt_47 82 29 46 8 6 2 87 5 68 67 13 65 46 8 6 67 67 3 40 32 11 26 87 5 4 43 28 10 30 43 95 8 36
  • Poulan PD22H42STA | User Manual - Page 37
    TRACTOR - - MODEL NUMBER PD22H42STA STEERING ASSEMBLY KEY PART NO. NO. DESCRIPTION 1 184704X428 Wheel Steering 2 184706 Axle Asm Cast Iron LT 3 169840 Spindle Asm LH 4 169839 Spindle Asm RH 5 6266H Bearing Race Thrust Harden 6
  • Poulan PD22H42STA | User Manual - Page 38
    TRACTOR - - MODEL NUMBER PD22H42STA SEAT ASSEMBLY 1 14 24 8 9 7 10 5 8 9 7 5 6 22 2 21 16 25 15 11 4 13 17 12 3 KEY PART NO. NO. 1 188720 2 140551 3 71110616 4 19131610 5 145006 6 73800600 7 124181X 8 17000616 9 19131614 10 182493 11 166369 12 121246X DESCRIPTION Seat Bracket Pivot
  • Poulan PD22H42STA | User Manual - Page 39
    TRACTOR - - MODEL NUMBER PD22H42STA 7 11 16 4 9 43 8 6 10 20 1 12 5 14 KEY PART Manual Owner's (English) - - 188782 Manual Owner's (French) KEY PART NO. NO. DESCRIPTION 1 59192 Cap Valve Tire 2 65139 Stem Valve 3 106222X Tire F T 15 x 6 0 - 6 Service 4 59904 Tube Front (Service
  • Poulan PD22H42STA | User Manual - Page 40
    ENGINE TRACTOR - - MODEL NUMBER PD22H42STA 2 1 14 25 38 26 17 32 31 33 37 112 41 33 23 29 OPTIONAL EQUIPMENT Spark Arrester engine-bs intek-twin_39 8 3 13 81 5 17 72 10 6 45 4 40
  • Poulan PD22H42STA | User Manual - Page 41
    TRACTOR - - MODEL NUMBER PD22H42STA KEY PART NO. NO. DESCRIPTION 1 170771 Control, Throttle 2 17720408 Screw Hex Thd Cut 1/4-20 x 1/2 3 Engine Briggs Model 407577 (Order Parts inches 1 inch = 25.4 mm For engine service and replacement parts, call the toll free number for your engine
  • Poulan PD22H42STA | User Manual - Page 42
    MOWER DECK TRACTOR - - MODEL NUMBER PD22H42STA 42_clutch_mod_7 67 158 185 152 44 159 46 56 53 52 55 68 40 37 36 40 143 144 45 150 40 37 145 184
  • Poulan PD22H42STA | User Manual - Page 43
    MOWER DECK TRACTOR - - MODEL NUMBER PD22H42STA KEY PART NO. NO. DESCRIPTION 1 182032X421 Mower Deck Assembly, 42" 2 72140506 Bolt 3 138017 Bracket Asm Fr. Sway Bar 3/42 4 165460 Bracket Asm Deck 42" Sway Bar 5 4939M Retainer Spring 6 178024 Bar Sway
  • Poulan PD22H42STA | User Manual - Page 44
    MOWER LIFT TRACTOR - - MODEL NUMBER PD22H42STA 29 28 27 25 24 23 7 41 8 37 38 40 11 19 13 31 32 13 5 49 36 13 4 6 2 12 13 30 50 3 26 6 19 31 32 20 15 1 5 4 17 18 20 16 20 20 15 lift-rh.1pc.stlt_10 44
  • Poulan PD22H42STA | User Manual - Page 45
    MOWER LIFT TRACTOR - - MODEL NUMBER PD22H42STA KEY PART NO. NO. DESCRIPTION 1 159461 Wire Asm Inner/Sprg W/plunger 2 159476 Shaft Asm Lift RH w/Inf 3 178981 Pin Groove 2" 4 12000002 E Ring #5133-62 5 19211621 Washer 21/
  • Poulan PD22H42STA | User Manual - Page 46
    instructions furnished Service Dept. 250 Bobby Jones Expressway Augusta, GA 30909 USA In Canada contact: Electrolux Canada Corp. 7075 Ordan Drive Mississauga, Ontario L5T 1K6 giving the model number, serial number and date of purchase of your product and the name and address of the authorized dealer
  • Poulan PD22H42STA | User Manual - Page 47
    47 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan PD22H42STA | User Manual - Page 48
    name of the nearest service dealer (under "saws" for Chain Saws or under "lawn mowers" for Trimmers, Brushcutters, and Blowers). 3. For replacement parts, have available the following information: a. Model Number/Manufacturer's I.D. Number. b. Description of part. NOTE: Electrolux Home Products
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
OWNER'S MANUAL
MODEL:
PD22H42STA
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
WARNING:
Read this Owner's Manual and follow all Warnings
and Safety Instructions.
Failure to do so can result
in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
188781
Rev. 1
11.3.03
RD/MH
Printed in U.S.A.
02478