Poulan PGB22H48 User Manual

Poulan PGB22H48 Manual

Get Poulan PGB22H48 PDF manuals and user guides View all Poulan PGB22H48 manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PGB22H48 manual content summary:

  • Poulan PGB22H48 | User Manual - Page 1
    Do Not Throw Away 03090 OPERATOR'S MANUAL MODEL: PBGT22H48 LAWN TRACTOR WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 402483 Rev.1 01.04
  • Poulan PGB22H48 | User Manual - Page 2
    Ride-On Mowers DANGER: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS your tractor. manual before starting. • Choose a low ground speed so that you will not have • Do not put hands or feet near rotating parts
  • Poulan PGB22H48 | User Manual - Page 3
    and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction labels, as necessary
  • Poulan PGB22H48 | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized servicecenter/ department We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan PGB22H48 | User Manual - Page 5
    UNASSEMBLED PARTS Mower Mower Front Wheel (5) Large Retainer Springs - 7/16 (2) Smaller Retainer Springs - 5/16 (1) 3/4 O.D. Washers (1) Wheel (1) 1-1/4 O.D. Washer (1) Anti-Sway Bar (5) 1-3/16 O.D. Washers (1) Front Link Assembly (2) Rear Lift Link Assemblies (1)
  • Poulan PGB22H48 | User Manual - Page 6
    is put into service after month and year indicated on label (L) (label is located between terminals) charge battery for minimum of one hour at 6-10 amps. (See "BATTERY" in Maintenance section of this manual for charging instructions). FIG. 2 NOTE: You may now roll or drive your tractor off the skid
  • Poulan PGB22H48 | User Manual - Page 7
    bolt, washer and locknut from parts bag, assemble front wheel to mower as shown.Tighten securely. 02051 FIG. 3 INSTALL MOWER AND DRIVE BELT (See Figs. 4-12) See MOWER AND DRIVE BELT ASSEMBLY Supplement Sheet for additional guidance on this assembly. Be sure tractor is on level surface and engage
  • Poulan PGB22H48 | User Manual - Page 8
    LIFT LINKS (C) - Insert rod end of lift link assembly into hole in tractor lift shaft suspension arm (L) and pivot link down to mower. Lift rear corner of mower and position slot in link assembly over pin on rear mower bracket (D) and secure with washer and retainer spring. • Repeat on opposite side
  • Poulan PGB22H48 | User Manual - Page 9
    See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is operating properly. See
  • Poulan PGB22H48 | User Manual - Page 10
    tractor or in literature supplied with the product. Learn and understand their meaning. REVERSE NEUTRAL HIGH LOW CHOKE FAST SLOW IGNITION SWITCH ENGINE OFF REVERSE OPERATION SYSTEM (ROS) ENGINE ON ENGINE START PARKING BRAKE MOWER HEIGHT MOWER Failure to follow instructions could result
  • Poulan PGB22H48 | User Manual - Page 11
    . Save this manual for future reference. D N B C Q A M P E K H J L F G FIG. 13 Our tractors conform to the tractor with the engine off. (N) CHOKE CONTROL - Used when starting a cold engine. (P) SERVICE REMINDER / HOUR METER - Indicates when service is required for the engine and mower
  • Poulan PGB22H48 | User Manual - Page 12
    eliminate this possibility, always stop engine when stopping tractor on grass areas. CAUTION: Always stop tractor completely, as described above, before leaving the operator's position. D B C N F FIG. 14 STOPPING MOWER BLADES • To stop mower blades, push attachment clutch switch in to disengaged
  • Poulan PGB22H48 | User Manual - Page 13
    and to over 3 inches during hot months. For healthier and better looking lawns, mow often and after moderate growth. • For best cutting performance, tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO ADJUST MOWER CUTTING HEIGHT" in this section of manual). • With mower
  • Poulan PGB22H48 | User Manual - Page 14
    mower needs servicing. When service is required, the service reminder will flash for two hours. To service engine and mower, see the Maintenance section of this manual. NOTE: Service by and comply with specifications of the manufacturer of your tractor. Use common sense when towing. Too heavy of a load
  • Poulan PGB22H48 | User Manual - Page 15
    in storage. To avoid engine problems, the fuel system should be emptied next season. See Storage Instructions for additional information. Never as follows: • Be sure the tractor is on level ground. • Release ADJUST CARBURETOR" in the Service and Adjustments section of this manual. TO START ENGINE (
  • Poulan PGB22H48 | User Manual - Page 16
    (See "TO TRANSPORT" in this section of manual). • Sitting in the tractor seat, start engine. After the engine is running Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower
  • Poulan PGB22H48 | User Manual - Page 17
    as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual. • At least once a year you should
  • Poulan PGB22H48 | User Manual - Page 18
    tractor requires more than five (5) feet to stop at highest speed in highest gear on a level, dry concrete or paved surface, then brake must be serviced. (See "TO CHECK BRAKE" in the Service and Adjustments section of this manual from your local parts dealer. Tire sealant results mower blades must be
  • Poulan PGB22H48 | User Manual - Page 19
    range expected before oil change. All oil must meet API service classification SG-SL. • Be sure tractor is on level surface. • Oil will drain more freely not overfill. For approximate capacity see "PRODUCT SPECIFICATIONS" section of this manual. • Use gauge on oil fill cap/dipstick for checking level.
  • Poulan PGB22H48 | User Manual - Page 20
    " section of this manual. IN-LINE FUEL FILTER tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower
  • Poulan PGB22H48 | User Manual - Page 21
    remove key. • Make sure the blades and all moving parts have completely stopped. • Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. TRACTOR (See Fig. 27) TO REMOVE MOWER • Place attachment clutch in "DISENGAGED" position. • Lower attachment lift
  • Poulan PGB22H48 | User Manual - Page 22
    1/8" to 1/2" lower than the rear tip, go to the front of tractor. • With an 11/16" or adjustable wrench, loosen jam nut A instructions above. • Recheck measurements, adjust if necessary until both sides are equal. B A 02966 Tighten adjust nut Loosen adjust nut B to raise mower B to lower mower
  • Poulan PGB22H48 | User Manual - Page 23
    manually push the tractor forward. If the rear wheels rotate, then the brake needs to be serviced. Contact a qualified service center. TO REPLACE MOTION DRIVE BELT MOWER mower (See "TO REMOVE MOWER" in this section of manual). NOTE: Observe entire motion drive belt and position of all belt guides
  • Poulan PGB22H48 | User Manual - Page 24
    position. The rear wheels must lock and skid when you try to manually push the tractor forward. If the rear wheels rotate, then the brake needs to be serviced. Contact a qualified service center. FRONT WHEEL TOE-IN/CAMBER Your new tractor front wheel toe-in and camber is set at the factory and is
  • Poulan PGB22H48 | User Manual - Page 25
    adjustment should not be necessary. If adjustment is necessary, see engne manual. TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment. 25
  • Poulan PGB22H48 | User Manual - Page 26
    enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan PGB22H48 | User Manual - Page 27
    TROUBLESHOOTING POINTS PROBLEM and trash under mower. 3. Clean underside of mower housing. 4. Dirty Service Adjust ments section. 15. Engine valves out of adjustment. 15. Contact an authorized service center/ department. 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan PGB22H48 | User Manual - Page 28
    TROUBLESHOOTING POINTS PROBLEM Engine dies when tractor is shifted into reverse CAUSE 1. Reverse operation system (ROS) is not "ON" while mower blades listed in this manual. 11. Clogged mower deck vent holes from trapped in transmission during shipment or servicing. 1. Place freewheel control in
  • Poulan PGB22H48 | User Manual - Page 29
    29
  • Poulan PGB22H48 | User Manual - Page 30
    option, without charge for parts or labor incurred in replacing parts, any part which we find to Battery must be maintained in accordance with the instructions furnished. 4. The Warranty period for any products used return the product to an authorized service dealer. Should you have any unanswered
  • Poulan PGB22H48 | User Manual - Page 31
    SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than 15
  • Poulan PGB22H48 | User Manual - Page 32
    Techical Assistance: call 1-800-829-5886 For a Parts Manual, go to our website: www.poulan-pro.com/support.asp NOTE: Electrolux Home Products provides parts and service through its authorized distributors and dealers; therefore, all requests for parts and service should be directed to your local
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
OPERATOR'S MANUAL
MODEL:
PBGT22H48
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan-pro.com
WARNING:
Read this Manual and follow all Warnings and
Safety Instructions.
Failure to do so can result
in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
402483
Rev.1
01.04.06
VB
Printed in U.S.A.
03090