Poulan PK1942YT User Manual

Poulan PK1942YT Manual

Get Poulan PK1942YT PDF manuals and user guides View all Poulan PK1942YT manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PK1942YT manual content summary:

  • Poulan PK1942YT | User Manual - Page 1
    Do Not Throw Away 02478 OPERATOR'S MANUAL MODEL: PK1942YT LAWN TRACTOR WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 194698 10.13.04 RD
  • Poulan PK1942YT | User Manual - Page 2
    cause you to lose control of your tractor. WARNING • Do not operate machine without riding mower-related injuries. These operators should evaluate their ability to operate the riding mower instructions on the machine and in the manual before starting. • Do not put hands or feet near rotating parts
  • Poulan PK1942YT | User Manual - Page 3
    and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction labels, as necessary
  • Poulan PK1942YT | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan PK1942YT | User Manual - Page 5
    CONTENTS OF HARDWARE PACK Steering Wheel Seat Steering Boot Steering Wheel Adapter Steering Wheel Insert (1) Large Flat Washer (1) Hex nut 1/2-20 (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Knob Key (2) Keys (1) Oil Drain Tube Slope Sheet (1) Hex Bolt 1/4-28 x 1-1/4 (4) Retainer Springs Gauge
  • Poulan PK1942YT | User Manual - Page 6
    pressure gauge When right or left hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel). TO REMOVE TRACTOR FROM CARTON UNPACK CARTON • Remove all accessible loose parts and parts cartons from carton. • Cut along dotted lines on all four
  • Poulan PK1942YT | User Manual - Page 7
    • Adjust gauge wheels before operating mower. See "TO ADJUST GAUGE WHEELS" in the Operation section of this manual. FIG. 3 NOTE: You may now roll or drive your tractor off the skid. Follow the appropriate instruction below to remove the tractor from the skid. TO ROLL TRACTOR OFF SKID (See Operation
  • Poulan PK1942YT | User Manual - Page 8
    See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is properly adjusted. See
  • Poulan PK1942YT | User Manual - Page 9
    MOWER LIFT 15 ATTACHMENT ATTACHMENT CLUTCH DISENGAGED CLUTCH ENGAGED DANGER, KEEP HANDS AND FEET AWAY KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) FREE WHEEL (Automatic Models only) LIGHTS ON Failure to follow instructions result in damage to the tractor and/or engine. HOT
  • Poulan PK1942YT | User Manual - Page 10
    Standards Institute. ATTACHMENT CLUTCH LEVER - Used to engage the mower blades, or other attachments mounted to your tractor. ATTACHMENT LIFT LEVER - Used to raise, lower, and adjust the mower deck or other attachments mounted to your tractor. CLUTCH/BRAKE PEDAL - Used for declutching and braking
  • Poulan PK1942YT | User Manual - Page 11
    key. Always remove key when leaving tractor to prevent unauthorized use. • Never use choke to stop engine. TO ADJUST MOWER CUTTING HEIGHT (See Fig. 6) The to over 3 inches during hot months. For healthier and better looking lawns, mow often and after moderate growth. • For best cutting performance,
  • Poulan PK1942YT | User Manual - Page 12
    prevent scalping in most terrain conditions. NOTE:Adjust gauge wheels with tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO AD- JUST MOWER CUTTING HEIGHT" in the Operation section of this manual). • Remove retainer spring and clevis pin which secure each gauge wheel
  • Poulan PK1942YT | User Manual - Page 13
    fications of the manufacturer of your tractor. Use common sense when towing. this manual). • To change engine oil, see the Maintenance section in this manual. in storage. To avoid engine problems, the fuel system should be next season. See Storage Instructions for additional information. Never use
  • Poulan PK1942YT | User Manual - Page 14
    See "TO ADJUST CARBURETOR" in the Service and Adjustments section of this manual. MOWING TIPS • Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower should be used for trimming
  • Poulan PK1942YT | User Manual - Page 15
    SERVICE Check Brake Operation Check Tire Pressure Check Operator Presence and T ROS Systems R Check for Loose Fasteners A Sharpen/Replace Mower must maintain tractor as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. LUBRICATION
  • Poulan PK1942YT | User Manual - Page 16
    tractor requires more than five (5) feet to stop at highest speed in highest gear on a level, dry concrete or paved surface, then brake must be checked and adjusted. (See "TO ADJUST BRAKE" in the Service and Adjustments section of this manual purchased from your local parts dealer. Tire sealant also
  • Poulan PK1942YT | User Manual - Page 17
    range expected before oil change. All oil must meet API service classification SG-SL. • Be sure tractor is on level surface. • Oil will drain more freely not overfill. For approximate capacity see "PRODUCT SPECIFICATIONS" section of this manual. • Use gauge on oil fill cap/dipstick for checking level.
  • Poulan PK1942YT | User Manual - Page 18
    a garden hose or pressure washer to clean your tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower. 18
  • Poulan PK1942YT | User Manual - Page 19
    PERFORMING ANY SERVICE OR ADJUSTMENTS: parts have completely stopped. • Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. TRACTOR TO REMOVE MOWER (See Fig. 15) Mower clutch cable housing guide into bracket, slide collar onto guide and secure with
  • Poulan PK1942YT | User Manual - Page 20
    SERVICE AND ADJUSTMENTS TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underinflated, you will not properly adjust your mower. SIDE-TO-SIDE
  • Poulan PK1942YT | User Manual - Page 21
    MOTION DRIVE BELT (See Fig. 22) Park the tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal on bottom side of left footrest. BELT REMOVAL • Remove mower (See "TO REMOVE MOWER" in this section of manual). NOTE: Observe entire motion drive belt and
  • Poulan PK1942YT | User Manual - Page 22
    to get to adjustment bolt, move mower deck height to the lowest position. instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER The front wheel toe-in and camber are not adjustable on your tractor from your local parts dealer. Tire sealant also prevents tire dry rot
  • Poulan PK1942YT | User Manual - Page 23
    and carefully remove battery from tractor. • Install new battery with front of tractor. Grasp hood at sides, tilt toward engine and lift off of tractor. • If adjustment is necessary, see engne manual. POSITIVE (RED) CABLE NEGATIVE (BLACK) problems, take your tractor to an authorized service
  • Poulan PK1942YT | User Manual - Page 24
    enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan PK1942YT | User Manual - Page 25
    TROUBLESHOOTING POINTS PROBLEM 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/ Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan PK1942YT | User Manual - Page 26
    TROUBLESHOOTING POINTS PROBLEM CAUSE Engine dies when tractor is shifted into reverse 1. Reverse operation system (ROS) is not "ON" while mower Clean underside of mower housing. 8. Replace mower drive belt. 9. Reinstall blades sharp edge down. 10. Replace with blades listed in this manual. 11.
  • Poulan PK1942YT | User Manual - Page 27
    option, without charge for parts or labor incurred in replacing parts, any part which we find to Battery must be maintained in accordance with the instructions furnished. 4. The Warranty period for any products used return the product to an authorized service dealer. Should you have any unanswered
  • Poulan PK1942YT | User Manual - Page 28
    instructions contained in an Instruction Manual for the operation of the Power Train Component and parts. The cost of normal maintenance and replacement of service legal rights which vary from state to state. E. No Dealer Warranty Tecumseh neither assumes nor authorizes any other person, natural or
  • Poulan PK1942YT | User Manual - Page 29
    29 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan PK1942YT | User Manual - Page 30
    Techical Assistance: call 1-800-829-5886 For a Parts Manual, go to our website: www.poulan-pro.com/support.asp NOTE: Electrolux Home Products provides parts and service through its authorized distributors and dealers; therefore, all requests for parts and service should be directed to your local
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
OPERATOR'S MANUAL
MODEL:
PK1942YT
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan-pro.com
WARNING:
Read this Manual and follow all Warnings and
Safety Instructions.
Failure to do so can result
in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
194698
10.13.04
RD
Printed in U.S.A.
02478