Poulan PK19H42LT User Manual

Poulan PK19H42LT Manual

Get Poulan PK19H42LT PDF manuals and user guides View all Poulan PK19H42LT manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PK19H42LT manual content summary:

  • Poulan PK19H42LT | User Manual - Page 1
    Do Not Throw Away 02478 OPERATOR'S MANUAL MODEL: PK19H42LT LAWN TRACTOR WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 401208 09.13.05 TR
  • Poulan PK19H42LT | User Manual - Page 2
    and cause you to lose control of your tractor. WARNING Engine exhaust, some of its riding mower-related injuries. These operators should evaluate their ability to operate the riding mower instructions on the machine and in the manual before starting. • Do not put hands or feet near rotating parts
  • Poulan PK19H42LT | User Manual - Page 3
    and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction labels, as necessary
  • Poulan PK19H42LT | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan PK19H42LT | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Seat Steering Boot (1) Large Flat Washer Steering Wheel Adapter Steering Wheel Insert Steering Extension Shaft (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Knob Key (2) Keys (1) 5/16 Lock Washer (1) Oil Drain Tube Slope Sheet (1) Hex Bolt 5/16-18 x 4 5
  • Poulan PK19H42LT | User Manual - Page 6
    hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel). INSERT 5/16 HEX BOLT 5/16 LOCK WASHER LARGE FLAT WASHER TO REMOVE TRACTOR FROM CARTON UNPACK CARTON • Remove all accessible loose parts and parts cartons from carton. • Cut along
  • Poulan PK19H42LT | User Manual - Page 7
    is put into service after month and year indicated on label (label located between terminals) charge battery for minimum of one hour at 6-10 amps. (See "BATTERY" in MAINTENANCE section of this manual for charging instructions). SEAT PAN LABEL NOTE: You may now roll or drive your tractor off the
  • Poulan PK19H42LT | User Manual - Page 8
    See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is properly adjusted. See
  • Poulan PK19H42LT | User Manual - Page 9
    MOWER LIFT 15 ATTACHMENT ATTACHMENT CLUTCH DISENGAGED CLUTCH ENGAGED BRAKE/CLUTCH PEDAL KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) LIGHTS ON FREE WHEEL (Automatic Models only) DANGER, KEEP HANDS AND FEET AWAY Failure to follow instructions in damage to the tractor and/or engine.
  • Poulan PK19H42LT | User Manual - Page 10
    Standards Institute. ATTACHMENT CLUTCH LEVER - Used to engage the mower blades, or other attachments mounted to your tractor. ATTACHMENT LIFT LEVER - Used to raise and lower the mower deck or other attachments mounted to your tractor. CLUTCH/BRAKE PEDAL - Used for declutching and braking the
  • Poulan PK19H42LT | User Manual - Page 11
    tractor with motion control lever in neutral (N) position. • Release parking brake. • Slowly move motion control lever to desired position. TO ADJUST MOWER to over 3 inches during hot months. For healthier and better looking lawns, mow often and after moderate growth. • For best cutting performance,
  • Poulan PK19H42LT | User Manual - Page 12
    prevent scalping in most terrain conditions. NOTE:Adjust gauge wheels with tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO ADJUST MOWER CUTTING HEIGHT" in the Operation section of this manual). • With mower in desired height of cut position, gauge wheels should be
  • Poulan PK19H42LT | User Manual - Page 13
    this manual). • To change engine oil, see the Maintenance section in this manual. ADD in storage. To avoid engine problems, the fuel system should be emptied fuel next season. See Storage Instructions for additional information. Never use LEVEL The engine in your tractor has been shipped, from the
  • Poulan PK19H42LT | User Manual - Page 14
    transmission should be warmed up as follows: • Be sure the tractor is on level ground. • Place the motion control lever in Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower
  • Poulan PK19H42LT | User Manual - Page 15
    as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual. • At least once a year you should
  • Poulan PK19H42LT | User Manual - Page 16
    . BRAKE OPERATION If tractor requires more than five (5) feet to stop at highest speed in highest gear on a level, dry concrete or paved surface, then brake must be checked and adjusted. (See "TO ADJUST BRAKE" in the Service and Adjustments section of this manual). TIRES • Maintain proper
  • Poulan PK19H42LT | User Manual - Page 17
    tractor. • Rinse the battery with plain water and dry. • Clean terminals and battery cable ends with wire brush until bright. • Coat terminals with grease or petroleum jelly. • Reinstall battery (See "REPLACING BATTERY" in the SERVICE AND ADJUSTMENTS section of this manual). V-BELTS Check V-belts
  • Poulan PK19H42LT | User Manual - Page 18
    a garden hose or pressure washer to clean your tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower. 18
  • Poulan PK19H42LT | User Manual - Page 19
    and secure with small retainer spring. • Install belt onto engine pulley. TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underinflated, you
  • Poulan PK19H42LT | User Manual - Page 20
    TO ADJUST BOTH FRONT LINKS EQUALLY SO MOWER WILL STAY LEVEL SIDE-TO-SIDE. BELT REMOVAL • Remove mower from tractor (See "TO REMOVE MOWER" in this section of this manual). • Work belt off both mandrel pulleys and idler pulleys. • Pull belt away from mower. BELT INSTALLATION - To obtain the best
  • Poulan PK19H42LT | User Manual - Page 21
    Park the tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal on bottom side of left footrest. BELT REMOVAL • Remove mower (See "TO REMOVE MOWER" in this section of manual). NOTE: Observe entire motion drive belt and position of all belt guides and
  • Poulan PK19H42LT | User Manual - Page 22
    mower deck height to the lowest position. After above adjustment is made, if the tractor be purchased from your local parts dealer. Tire sealant also instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER The front wheel toe-in and camber are not adjustable on your tractor
  • Poulan PK19H42LT | User Manual - Page 23
    SERVICE carefully remove battery from tractor. • Install new tractor. Grasp hood at sides, tilt toward engine and lift off of tractor , see engine manual. TO ADJUST If adjustment is necessary, see engne manual. POSITIVE (RED) CABLE NEGATIVE ( problems, take your tractor to an authorized service
  • Poulan PK19H42LT | User Manual - Page 24
    enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan PK19H42LT | User Manual - Page 25
    TROUBLESHOOTING POINTS PROBLEM 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/ Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan PK19H42LT | User Manual - Page 26
    TROUBLESHOOTING POINTS PROBLEM CAUSE Engine dies when tractor is shifted into reverse 1. Reverse operation system (ROS) is not "ON" while mower Clean underside of mower housing. 8. Replace mower drive belt. 9. Reinstall blades sharp edge down. 10. Replace with blades listed in this manual. 11.
  • Poulan PK19H42LT | User Manual - Page 27
    parts or labor incurred in replacing parts, any part accordance with the instructions furnished. 4. The Warranty are belts, blades, service dealer. Should you have any unanswered questions concerning this Warranty, please contact: Electrolux Home Products, Inc. Outdoor Products Customer Service
  • Poulan PK19H42LT | User Manual - Page 28
    SERVICE NOTES 28
  • Poulan PK19H42LT | User Manual - Page 29
    29 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan PK19H42LT | User Manual - Page 30
    Assistance: call 1-800-829-5886 For a Parts Manual, go to our website: www.poulan-pro.com/support.asp NOTE: Electrolux Home Products provides parts and service through its authorized distributors and dealers; therefore, all requests for parts and service should be directed to your local dealer
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
OPERATOR'S MANUAL
MODEL:
PK19H42LT
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan-pro.com
WARNING:
Read this Manual and follow all Warnings and
Safety Instructions.
Failure to do so can result
in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
401208
09.13.05
TR
Printed in U.S.A.
02478