Poulan PK23H48YT User Manual

Poulan PK23H48YT Manual

Get Poulan PK23H48YT PDF manuals and user guides View all Poulan PK23H48YT manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PK23H48YT manual content summary:

  • Poulan PK23H48YT | User Manual - Page 1
    Do Not Throw Away 02139 OPERATOR'S MANUAL MODEL: PK23H48YT LAWN TRACTOR WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 194818 10.25.04 TR
  • Poulan PK23H48YT | User Manual - Page 2
    control of your tractor. WARNING Engine riding mower-related injuries. These operators should evaluate their ability to operate the riding mower parts and burn. Do not allow the mower deck instructions on the machine and in the manual before starting. • Do not put hands or feet near rotating parts
  • Poulan PK23H48YT | User Manual - Page 3
    and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction labels, as necessary
  • Poulan PK23H48YT | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan PK23H48YT | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Seat Steering Wheel Adapter (1) Large Flat Washer Steering Wheel Insert Clevis Pins Nose Roller Brackets (2) Hex Bolts 5/16-18 x 1 (2) Locknuts 5/16-18 Mower (2) Retainer Springs (single loop) (5) Retainer Springs (double loop) (4) Shoulder Bolt Key (1)
  • Poulan PK23H48YT | User Manual - Page 6
    Utility knife When right or left hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel). TO REMOVE TRACTOR FROM CARTON UNPACK CARTON • Remove all accessible loose parts and parts cartons from carton. • Cut along dotted lines on all four
  • Poulan PK23H48YT | User Manual - Page 7
    If this battery is put into service after month and year indicated on label (label located between terminals) charge battery for minimum of one hour at 6-10 amps. (See "BATTERY" in Maintenance section of this manual for charging instructions). LABEL TO ROLL TRACTOR OFF SKID (See Operation section
  • Poulan PK23H48YT | User Manual - Page 8
    • Cut and remove ties securing anti-sway bar and belts. Swing anti-sway bar to left side of mower deck. • Slide mower under tractor with deflector shield to right side of tractor. IMPORTANT: Check belt for proper routing in all mower pulley grooves. • If equipped, turn height adjustment knob counter
  • Poulan PK23H48YT | User Manual - Page 9
    See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. ✓ Before driving tractor, be sure freewheel control is in "transmission engaged" position (see "TO TRANSPORT" in the
  • Poulan PK23H48YT | User Manual - Page 10
    MOWER LIFT 15 ATTACHMENT ATTACHMENT CLUTCH DISENGAGED CLUTCH ENGAGED DANGER, KEEP HANDS AND FEET AWAY KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) FREE WHEEL (Automatic Models only) LIGHTS ON Failure to follow instructions result in damage to the tractor and/or engine. HOT
  • Poulan PK23H48YT | User Manual - Page 11
    (-) of battery. ATTACHMENT CLUTCH SWITCH - Used to engage the mower blades or other attachments mounted to your tractor. ATTACHMENT LIFT LEVER - Used to raise and lower the mower deck or other attachments mounted to your tractor. CHOKE CONTROL - Used when starting a cold engine. CLUTCH/BRAKE
  • Poulan PK23H48YT | User Manual - Page 12
    and remove key. Always remove key when leaving tractor to prevent unauthorized use. • Never use choke rate. • Full throttle offers the best bagging and mower perfor- mance. TO USE CHOKE CONTROL (See Fig during hot months. For healthier and better looking lawns, mow often and after moderate growth. •
  • Poulan PK23H48YT | User Manual - Page 13
    then keep the deck in proper position to help prevent scalping in most terrain conditions. NOTE:Adjust gauge wheels with tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO AD- JUST MOWER CUTTING HEIGHT" in the Operation section of this manual). • Remove retainer spring
  • Poulan PK23H48YT | User Manual - Page 14
    manual). • To change engine oil, see the Maintenance section in this manual. in storage. To avoid engine problems, the fuel system should be fuel next season. See Storage Instructions for additional information. Never specifications of the manufacturer of your tractor. Use common sense when towing.
  • Poulan PK23H48YT | User Manual - Page 15
    transmission should be warmed up as follows: • Be sure the tractor is on level ground. • Place the motion control lever in Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower
  • Poulan PK23H48YT | User Manual - Page 16
    as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual. • At least once a year you should
  • Poulan PK23H48YT | User Manual - Page 17
    Service and Adjustments section of this manual). CAUTION: Use only a replacement blade approved by the manufacturer of your tractor. Using a blade not approved by the manufacturer of your tractor is hazardous, could damage your tractor purchased from your local parts dealer. Tire sealant also
  • Poulan PK23H48YT | User Manual - Page 18
    tractor. • Rinse the battery with plain water and dry. • Clean terminals and battery cable ends with wire brush until bright. • Coat terminals with grease or petroleum jelly. • Reinstall battery (See "REPLACING BATTERY" in the SERVICE AND ADJUSTMENTS section of this manual). V-BELTS Check V-belts
  • Poulan PK23H48YT | User Manual - Page 19
    a garden hose or pressure washer to clean your tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower. 19
  • Poulan PK23H48YT | User Manual - Page 20
    parts have completely stopped. • Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. TRACTOR TO REMOVE MOWER mower deck. • Slide mower under tractor with deflector shield to right side of tractor. IMPORTANT: CHECK BELT FOR PROPER ROUTING IN ALL MOWER
  • Poulan PK23H48YT | User Manual - Page 21
    • Raise deck to highest position. TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underinflated, you will not properly adjust your mower. SIDE
  • Poulan PK23H48YT | User Manual - Page 22
    SERVICE AND ADJUSTMENTS BOTH FRONT PLATE LINKS MUST BE EQUAL IN LENGTH 02516 NUT "D" 02517 FRONT PLATE ASSEMBLY NUT "C" TRUNNION FIG. 22 TO REPLACE MOWER DRIVE BELT MOWER DRIVE BELT REMOVAL (See Fig. 23) • Park tractor on a level surface. Engage parking brake. • Lower mower to its lowest
  • Poulan PK23H48YT | User Manual - Page 23
    SERVICE AND ADJUSTMENTS TO REPLACE MOWER BLADE (SECONDARY) DRIVE BELT (See Fig. 24) Park the tractor on level surface. Engage parking brake. • Remove mower (See "TO REMOVE MOWER" in this section of manual). • Remove screws from R.H. and L.H. mandrel covers and remove covers. REMOVE MOWER DRIVE BELT
  • Poulan PK23H48YT | User Manual - Page 24
    Park the tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal on bottom side of left footrest. BELT REMOVAL • Remove mower (See "TO REMOVE MOWER" in this section of manual). NOTE: Observe entire motion drive belt and position of all belt guides and
  • Poulan PK23H48YT | User Manual - Page 25
    instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER The front wheel toe-in and camber are not adjustable on your tractor due to slow leaks, tire sealant may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. TO START ENGINE
  • Poulan PK23H48YT | User Manual - Page 26
    adjustment should not be necessary. If adjustment is necessary, see engne manual. TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment. 26
  • Poulan PK23H48YT | User Manual - Page 27
    enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan PK23H48YT | User Manual - Page 28
    TROUBLESHOOTING POINTS PROBLEM 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/ Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan PK23H48YT | User Manual - Page 29
    TROUBLESHOOTING POINTS PROBLEM CAUSE Engine dies when tractor is shifted into reverse 1. Reverse operation system (ROS) is not "ON" while mower or other attachment is engaged. Engine continues to run when operator leaves seat with attachment clutch engaged 1. Faulty operator-safety presence
  • Poulan PK23H48YT | User Manual - Page 30
    parts or labor incurred in replacing parts, any part the instructions furnished. belts, blades, blade adapters, normal wear, normal adjustments, standard hardware and normal maintenance. 7. In the event you have a claim under this Warranty, you must return the product to an authorized service dealer
  • Poulan PK23H48YT | User Manual - Page 31
    31 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan PK23H48YT | User Manual - Page 32
    Techical Assistance: call 1-800-829-5886 For a Parts Manual, go to our website: www.poulan-pro.com/support.asp NOTE: Electrolux Home Products provides parts and service through its authorized distributors and dealers; therefore, all requests for parts and service should be directed to your local
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
OPERATOR'S MANUAL
MODEL:
PK23H48YT
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan-pro.com
WARNING:
Read this Manual and follow all Warnings and
Safety Instructions.
Failure to do so can result
in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
194818
10.25.04
TR
Printed in U.S.A.
02139