Poulan PKGTH2554 User Manual

Poulan PKGTH2554 Manual

Get Poulan PKGTH2554 PDF manuals and user guides View all Poulan PKGTH2554 manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PKGTH2554 manual content summary:

  • Poulan PKGTH2554 | User Manual - Page 1
    Do Not Throw Away 02139 OPERATOR'S MANUAL MODEL: PKGTH2554 LAWN TRACTOR WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 193921 10.20.04 TR
  • Poulan PKGTH2554 | User Manual - Page 2
    cause you to lose control of your tractor. WARNING • Do not operate machine without riding mower-related injuries. These operators should evaluate their ability to operate the riding mower instructions on the machine and in the manual before starting. • Do not put hands or feet near rotating parts
  • Poulan PKGTH2554 | User Manual - Page 3
    and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction labels, as necessary
  • Poulan PKGTH2554 | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan PKGTH2554 | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Gauge Wheels Steering Sleeve Premium Steering Adapter Seat (4) Adjusting Bars (4) Spring (2) Hex Bolts 5/16-18 x 1 Rod (2) Locknuts 5/16-18 (4) Shoulder Bolt Mower (2) Flanged Pins (2) Retainer Springs (double loop) Keys (2) Keys Slope Sheet (1) Oil Drain
  • Poulan PKGTH2554 | User Manual - Page 6
    lines on all four panels of carton. Remove end panels and lay side panels flat. • Remove mower and packing materials. • Check for any additional loose parts or cartons and remove. BEFORE REMOVING TRACTOR FROM SKID ATTACH STEERING WHEEL (See Fig. 1) • Remove locknut and large flat washer from steering
  • Poulan PKGTH2554 | User Manual - Page 7
    washers and 3/8-16 center locknuts and tighten securely. • For ease of mower to tractor assembly, set all the gauge wheels in the fourth hole from top. all instructions in the Operation section of this manual. Be sure tractor is in a well-ventilated area. Be sure the area in front of tractor is
  • Poulan PKGTH2554 | User Manual - Page 8
    as it will go and position mower on right side of tractor with deflector shield to the right. • Remove plastic tie strap from mower belt and check belt for proper routing in all mower pulley grooves. • Slide mower under tractor until it is centered under tractor.DO NOT connect any pins.When properly
  • Poulan PKGTH2554 | User Manual - Page 9
    See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is properly adjusted. See
  • Poulan PKGTH2554 | User Manual - Page 10
    MOWER LIFT 15 ATTACHMENT ATTACHMENT CLUTCH DISENGAGED CLUTCH ENGAGED DANGER, KEEP HANDS AND FEET AWAY KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) FREE WHEEL (Automatic Models only) LIGHTS ON Failure to follow instructions result in damage to the tractor and/or engine. HOT
  • Poulan PKGTH2554 | User Manual - Page 11
    TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR. Compare the illustrations with your tractor to familiarize yourself with the location of various controls and adjustments. Save this manual and lower mower deck or other attachments mounted to your tractor. LIFT LEVER
  • Poulan PKGTH2554 | User Manual - Page 12
    . FIG. 9 • Start tractor with motion control lever in neutral (N) position. MOWER BLADES - • To stop mower blades,move attachment clutch switch to over 3 inches during hot months. For healthier and better looking lawns, mow often and after moderate growth. IMPORTANT: LEAVING THE IGNITION SWITCH
  • Poulan PKGTH2554 | User Manual - Page 13
    prevent scalping in most terrain conditions. NOTE:Adjust gauge wheels with tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO AD- JUST MOWER CUTTING HEIGHT" in the Operation section of this manual). • Remove retainer spring and clevis pin which secure each gauge wheel
  • Poulan PKGTH2554 | User Manual - Page 14
    in storage. To avoid engine problems, the fuel system should be emptied fresh fuel next season. See Storage Instructions for additional information. Never use you to lose control of your tractor. NOTE: Before starting, read the Maintenance section of this manual). the engine does not accept the
  • Poulan PKGTH2554 | User Manual - Page 15
    TIPS • Tire chains cannot be used when the mower housing is attached to tractor. • Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower should be used for trimming. • Drive so
  • Poulan PKGTH2554 | User Manual - Page 16
    as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual. • At least once a year you should
  • Poulan PKGTH2554 | User Manual - Page 17
    . (See "TO ADJUST BRAKE" in the Service and Adjustments section of this manual). CAUTION: Use only a replacement blade approved by the manufacturer of your tractor. Using a blade not approved by the manufacturer of your tractor is hazardous, could damage your tractor and void your warranty. TIRES
  • Poulan PKGTH2554 | User Manual - Page 18
    battery (See "REPLACING BATTERY" in the SERVICE AND ADJUSTMENTS section of this manual). V-BELTS Check V-belts for deterioration and wear range expected before oil change. All oil must meet API service classification SG-SL. • Be sure tractor is on level surface. • Oil will drain more freely when
  • Poulan PKGTH2554 | User Manual - Page 19
    a garden hose or pressure washer to clean your tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower. 19
  • Poulan PKGTH2554 | User Manual - Page 20
    DRIVE BELT" in the Assembly section of this manual. NOTE: You will need to reattach front plate assembly to tractor after sliding mower under the tractor. TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT
  • Poulan PKGTH2554 | User Manual - Page 21
    tip is approximately 1/8" to 1/2" lower than the rear tip when the mower is in its highest position. CAUTION: Blades are sharp. Protect your hands with gloves and/or wrap blade with heavy cloth. Check adjustment on right side of tractor. Position any blade so the tip is pointing straight forward
  • Poulan PKGTH2554 | User Manual - Page 22
    SERVICE AND ADJUSTMENTS TO REPLACE MOWER DRIVE BELT (See Fig. 24) MOWER DRIVE BELT REMOVAL • Park tractor on a level surface. Engage onto electric clutch pulley. IMPORTANT: CHECK BELT FOR PROPER ROUTING IN ALL MOWER PULLEY GROOVES. • Reassemble R.H. and L.H. mandrel covers. Securely tighten all
  • Poulan PKGTH2554 | User Manual - Page 23
    Fig. 26) ADJUSTMENT BOLT Park the tractor on level surface. Engage parking brake. For ease of service there is a belt installation guide decal on bottom of left footrest. 02508 FIG. 27 • Remove mower (See "TO REMOVE MOWER" in this section of this manual.) BELT REMOVAL - • Create slack in belt
  • Poulan PKGTH2554 | User Manual - Page 24
    instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER The front wheel toe-in and camber are not adjustable on your tractor tires due to slow leaks, tire sealant may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. TO START
  • Poulan PKGTH2554 | User Manual - Page 25
    be necessary. If adjustment is necessary, see engine manual. TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment. INTERLOCKS AND RELAYS
  • Poulan PKGTH2554 | User Manual - Page 26
    enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan PKGTH2554 | User Manual - Page 27
    TROUBLESHOOTING POINTS PROBLEM 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/ Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan PKGTH2554 | User Manual - Page 28
    TROUBLESHOOTING POINTS PROBLEM CAUSE Engine dies when tractor is shifted into reverse 1. Reverse operation system (ROS) is not "ON" while mower mower housing. 8. Replace mower drive belt. 9. Reinstall blades sharp edge down. 10. Replace with blades listed in this manual shipment or servicing. 1.
  • Poulan PKGTH2554 | User Manual - Page 29
    option, without charge for parts or labor incurred in replacing parts, any part which we find to Battery must be maintained in accordance with the instructions furnished. 4. The Warranty period for any products used return the product to an authorized service dealer. Should you have any unanswered
  • Poulan PKGTH2554 | User Manual - Page 30
    maintenance, improper use or abuse of the product, failure to follow the instructions contained in an Instruction Manual for the operation of the Power Train Component and parts. The cost of normal maintenance and replacement of service items which are not defective shall be paid for by the original
  • Poulan PKGTH2554 | User Manual - Page 31
    31 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan PKGTH2554 | User Manual - Page 32
    Assistance: call 1-800-829-5886 For a Parts Manual, go to our website: www.poulan-pro.com/support.asp NOTE: Electrolux Home Products provides parts and service through its authorized distributors and dealers; therefore, all requests for parts and service should be directed to your local dealer
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
OPERATOR'S MANUAL
MODEL:
PKGTH2554
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan-pro.com
WARNING:
Read this Manual and follow all Warnings and
Safety Instructions.
Failure to do so can result
in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
193921
10.20.04
TR
Printed in U.S.A.
02139