Poulan PO12538LT User Manual

Poulan PO12538LT Manual

Get Poulan PO12538LT PDF manuals and user guides View all Poulan PO12538LT manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PO12538LT manual content summary:

  • Poulan PO12538LT | User Manual - Page 1
    Do Not Throw Away OPERATOR'S MANUAL MODEL: PO12538LT LAWN TRACTOR WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan.com Gasoline containing up to 10
  • Poulan PO12538LT | User Manual - Page 2
    tractor. I. GENERAL OPERATION • Read, understand, and follow all instructions on the machine and in the manual before starting. • Do not put hands or feet near rotating parts over. • Use extra care while operating machine with grass catchers or other attachments; they can affect the stability of
  • Poulan PO12538LT | User Manual - Page 3
    lawn mower and a minimum of 16 years of age before operating a riding lawn grass catcher components and the discharge chute frequently and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing
  • Poulan PO12538LT | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan PO12538LT | User Manual - Page 5
    UNASSEMBLED PARTS Steering Steering Wheel Steering Wheel Adapter Steering Wheel Insert (1) Bolt (1) Large Flat Washer Steering Extension Shaft Steering Boot (1) Lock Washer Seat (1) Seat (1) Washer (1) Knob Battery (2)
  • Poulan PO12538LT | User Manual - Page 6
    hour at 6-10 amps. (See "BATTERY" in Maintenance section of this manual for charging instructions). • For battery and battery cable installation see "REPLACING BATTERY" in the "Service and Adjustments" section in this manual. TO INSTALL STEERING WHEEL (See Fig. 2) ASSEMBLE EXTENSION SHAFT AND BOOT
  • Poulan PO12538LT | User Manual - Page 7
    the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is operating properly. See "TO
  • Poulan PO12538LT | User Manual - Page 8
    ) LIGHTS ON FREE WHEEL (Automatic Models only) DANGER, KEEP HANDS AND FEET AWAY Failure to follow instructions could result in serious injury or the alert symbol, indicates a situation that could result in damage to the tractor and/or engine. HOT SURFACES indicates a hazard which, if not avoided,
  • Poulan PO12538LT | User Manual - Page 9
    OPERATION KNOW YOUR TRACTOR READ THIS MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual for future reference. LIGHT SWITCH THROTTLE/CHOKE CONTROL CLUTCH/
  • Poulan PO12538LT | User Manual - Page 10
    grass. To eliminate this possibility, always stop engine when stopping tractor on grass areas. CAUTION: Always stop tractor completely, as described above, before leaving the operator's position; to empty grass catcher , height of grass and types of grass being mowed. • The average lawn should be cut
  • Poulan PO12538LT | User Manual - Page 11
    ON" POSITION (NORMAL OPERATING) 02828 TO OPERATE MOWER (See Fig. 6) Your tractor is equipped with an operator presence sensing switch. Any attempt by the operator to . CAUTION: Do not operate the mower without either the entire grass catcher, on mowers so equipped, or the deflector shield in place.
  • Poulan PO12538LT | User Manual - Page 12
    • Check engine oil with tractor on level ground. • Remove engine while in storage. To avoid engine problems, the fuel system should be emptied before Use fresh fuel next season. See Storage Instructions for additional information. Never use engine or Service and Adjustments section of this manual. 12
  • Poulan PO12538LT | User Manual - Page 13
    to tractor. • Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. left hand turns until finished (See Fig. 7). Fig. 7 • If grass is extremely tall, it should be mowed twice to reduce load and possible fire
  • Poulan PO12538LT | User Manual - Page 14
    V-Belts Check instructed in this manual. SPINDLE ZERK SPINDLE ZERK Some adjustments will need to be made periodically to properly maintain your tractor. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual
  • Poulan PO12538LT | User Manual - Page 15
    tractor requires more than five (5) feet to stop at highest speed in highest gear on a level, dry concrete or paved surface, then brake must be checked and adjusted. (See "TO CHECK BRAKE" in the Service and Adjustments section of this manual purchased from your local parts dealer. Tire sealant also
  • Poulan PO12538LT | User Manual - Page 16
    necessary. The belts are not adjustable. Replace belts if they begin before oil change. All oil must meet API service classification SG-SL. • Be sure tractor is on level surface. • Oil will approximate capacity see "PRODUCT SPECIFICATIONS" section of this manual. • Use gauge on oil fill cap/dipstick
  • Poulan PO12538LT | User Manual - Page 17
    of all gasoline, oil, etc. • Protect painted surfaces with automotive type wax. We do not recommend using a garden hose or pressure washer to clean your tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your
  • Poulan PO12538LT | User Manual - Page 18
    PERFORMING ANY SERVICE OR ADJUSTMENTS: • Make sure the blades and all moving parts have completely stopped. • Disconnect spark plug • Slide mower under tractor with deflector shield to right side of tractor. • Lower lift lever BELT KEEPER RETAINER SPRING ANTI-SWAY BAR COLLAR HOUSING GUIDE WIRE BELT
  • Poulan PO12538LT | User Manual - Page 19
    SERVICE AND ADJUSTMENTS TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. the rear when the mower is in its highest position. Check adjustment on right side of tractor. Measure distance "D" directly in front and behind the mandrel at bottom edge of mower
  • Poulan PO12538LT | User Manual - Page 20
    try to manually push the tractor forward. If the rear wheels rotate, then the brake needs to be serviced. Contact a qualified service center. TO REPLACE MOTION DRIVE BELT (See Fig. 20) Park the tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal
  • Poulan PO12538LT | User Manual - Page 21
    instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER TO ATTACH JUMPER CABLES • Connect one end of the RED cable to the POSITIVE (+) terminal of each battery(A-B), taking care not to short against tractor from your local parts dealer. Tire sealant also prevents tire dry
  • Poulan PO12538LT | User Manual - Page 22
    AND RELAYS Loose or damaged wiring may cause your tractor to run poorly, stop running, or prevent it from manual. TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service
  • Poulan PO12538LT | User Manual - Page 23
    tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual DEPOSITS FROM FORMING IN ESSENTIAL FUEL SYSTEM PARTS SUCH AS CARBURETOR, FUEL FILTER, FUEL HOSE
  • Poulan PO12538LT | User Manual - Page 24
    TROUBLESHOOTING POINTS PROBLEM Will not start CAUSE starter. 1. Cutting too much grass/too fast. 2. Throttle in "CHOKE" position. 3. Build-up of grass, leaves and trash under mower "To Adjust Carburetor" in Service Adjustments section. 10. Contact an authorized service center/department. 1. Clean/
  • Poulan PO12538LT | User Manual - Page 25
    . 8. Replace mower drive belt. 9. Blades improperly installed. 9. Reinstall blades sharp edge down. 10. Improper blades used. 10. Replace with blades listed in parts manual. 11. Clogged mower deck vent holes from buildup 11. Clean around mandrels to open vent holes. of grass, leaves, and trash
  • Poulan PO12538LT | User Manual - Page 26
    parts or labor incurred in replacing parts, any part accordance with the instructions furnished. 4. The Warranty Warranty are belts, blades, blade Service Dept. 9335 Harris Corners Parkway Charlotte, NC 28269 USA In Canada contact: HOP 5855 Terry Fox Way Mississauga, Ontario L5V 3E4 giving the model
  • Poulan PO12538LT | User Manual - Page 27
    27 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan PO12538LT | User Manual - Page 28
    28
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
OPERATOR'S MANUAL
MODEL:
PO12538LT
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan.com
WARNING:
Read this Manual and follow all Warnings
and Safety Instructions.
Failure to do so
can result in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
11.23.11 BD
532 44 66-59
Printed in the U.S.A.
Gasoline containing up to 10% ethanol (E10) is acceptable for use in this machine.
The use of any gasoline exceeding 10% ethanol (E10) will void the product warranty.